SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL-ICE0806, ICE1006 Includes 50Hz. and 3 Phase Units

Transcription

1 SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL-ICE0806, ICE1006 Includes 50Hz. and 3 Phase Units ICE-O-Matic East 45th Ave Denver, Colorado Part Number Rev 3/06

2 *

3 This parts list contains the service parts available for the ICE Series icemakers. Check the model number on the data plate and refer to the correct listing for the specific component. Check carefully that the correct part is identified and ordered. Table of Contents Page 1 Exterior Components Page 2-3 Interior Components-Front View Page 4-5 Air Cooled Page 6-7 Water Cooled Page 8-9 Remote Page Control Box Page Specific Compressor Components Page 13 Old Style Harvest Assist Assembly Page New Style Harvest Assist Assembly Page Remote Condenser Page Ice-O-Matic East 45th Ave. Denver Co PUREICE The ICE Series Service manual is avialable seperately, Part number Page 1 Rev. 3/06

4 Exterior Components Page 2 Rev. 3/06

5 Exterior Components Item No. Description ICE0805 ICE0806 ICE1005 ICE1006 ICE Top Panel-Air Cooled S S S S S 1 Top Panel-Water and Remote Top Panel-Wall Hugger Remote Top Panel Screw Front Panel Front Panel Screw Left Hand Side Panel Side Panel Screws Plastic Nut Insert Right Hand Side Panel-Louvered Junction Box Cover Junction Box Cover Screw Right Hand Side Panel-Solid Rear Panel Rear Panel Screw Control Box Top Cover Control Box Side Cover Control Box Screws Water Trough Support Page 3 Rev. 3/06

6 Front Interior Page 4 Rev. 3/06

7 Front Interior Item No. Description ICE0805 ICE0806 ICE1005 ICE1006 ICE Left Hand Frame Panel Right Hand Frame Panel Evaporator-Full Cube Evaporator-Half Cube Evaporator Splash Curtain Water Distribution Tube Thumb Screw Rubber Washer High Pressure Control Clamp Water Pump Tube Water Pump Thumbscrew / Pump (2 Req) Float Water Float Tube (26") Snap Bushing Water Return Trough Water Return Trough Screw Valve Core Valve Cap Caplug Purge Valve Plastic Nut Insert Evaporator Mounting Screw Evaporator Spillway Evaporator Side Panel - RH Evaporator Side Panel - LH Evaporator Water Return Please note: Water Pumps are shipped with the Thumbscrews when ordered as a service replacement part. Page 5 Rev. 3/06

8 Air Cooled Page 6 Rev. 3/06

9 Air Cooled Item No. Description ICE0805 ICE0806 ICE1005 ICE1006 ICE Compressor Hot Gas Valve Coil Hot Gas Valve Body Low Pressure Control Filter Drier Purge Valve Drop Adapter Water Inlet Fitting Purge Drain Fitting Clamp-TXV Bulb TXV - SPORLAN TXV - ALCO (Beg. Mid Ser. H2) Purge Drain Hose (1.5 Ft.) Tube ( 2.17 Ft.) Clamp High Temp Safety Air Condenser Air Condenser (Beg. Mid Ser. H2) Fan Motor Fan Motor (Beg. Mid Ser. H2) Fan Blade Fan Blade (Beg. Mid Ser. H2) Fan Mtr Bracket Fan Mtr Brkt (Beg. Mid Ser. H2) Fan Shroud TXV - SPORLAN Assy* TXV - ALCO Assy* S S S S S * Includes Distributor and Tubing - Same Efectivity Date as TXV's Page 7 Rev. 3/06

10 Water Cooled Page 8 Rev. 3/06

11 Water Cooled Item No. Description ICE0805 ICE0806 ICE1005 ICE1006 ICE Compressor Hot Gas Valve Coil Hot Gas Valve Body Low Pressure Control Filter Drier Purge Valve Drop Adapter Water Inlet Fitting Purge Drain Fitting Clamp-TXV Bulb TXV - SPORLAN TXV - ALCO (Beg. Mid Ser. H2) Purge Drain Hose Tube ( 2.17 Ft.) Clamp High Temp Safety Water Condenser Water Condenser (Beg. Ser. G2) Water Valve Drop Adapter 1/2" TXV - SPORLAN Assy* TXV - ALCO Assy* S S S S S * Includes Distributor and Tubing - Same Efectivity Date as TXV's Page 9 Rev. 3/06

12 Remote Page 10 Rev. 3/06

13 Remote Item No. Description ICE0805 ICE0806 ICE1005 ICE1006 ICE Compressor Hot Gas Valve Coil Hot Gas Valve Body Low Pressure Control Filter Drier Purge Valve Drop Adapter Water Inlet Fitting Purge Drain Fitting Clamp-TXV Bulb TXV - SPORLAN TXV - ALCO (Beg. Mid Ser. H2) Purge Drain Hose Tube ( 2.17 Ft.) Clamp High Temp Safety High Temp Safety (Beg. Rev. 3) Liquid Line Solenoid Body Liquid Line Solenoid Coil Receiver TXV - SPORLAN Assy* TXV - ALCO Assy* S S S S S 20 Mixing Valve (240) Remote Fitting 3/8" Remote Fitting 1/2" Rear Brace Rear Brace (Wall Hugger) High Press Control High Press Control (Beg. Rev. 3) Pump Down Control Pump Down Control (Beg. Rev. 3) Check Valve Roto-Loc Valve * Includes Distributor and Tubing - Same Efectivity Date as TXV's PLEASE NOTE: Mixing Valves are not used on Remote Cubers beginning Revision 3. PLEASE NOTE: When using an ICE Revision 3 Remote Cuber on an existing or new ERC Remote Condenser, please use kit at installation. Page 11 Rev. 3/06

14 Control Box Page 12 Rev. 3/06

15 Control Box Item No. Description ICE0805 ICE0806 ICE1005 ICE1006 ICE Purge Switch ON-OFF-WASH Switch Relay Socket Relay Water Pump Cord Contactor Compressor Start Relay See Below See Below See Below See Below See Below 8 Start Capacitor See Below See Below See Below See Below See Below 9 Run Capacitor See Below See Below See Below See Below See Below 10 Timer Low Pressure Timer Initiate Pump Down Control Bin Switch Compressor Components ICE806 A & W Compressor Start Capacitor Run Capacitor Relay ICE806 R AND ICE 1006 A & W ICE805 A W & R ICE1007 A W & R ICE1006 R ICE1005 A W & R Compressor Start Capacitor Run Capacitor Relay Compressor Start Capacitor Run Capacitor Relay Compressor N/A Start Capacitor N/A Run Capacitor N/A Relay Compressor Start Capacitor Run Capacitor Relay Compressor Start Capacitor Run Capacitor Relay A = Air Cooled W= Water Cooled R= Remote Page 13 Rev. 3/06

16 Old Style Harvest Assist Assembly OLD STYLE HARVEST ASSIST ASSEMBLY WITH PROBE SHAFT, SWIVEL AND LOCKING NUT Page 14 Rev. 3/06

17 Old Style Harvest Assist Assembly Item No. Description ICE0805 ICE0806 ICE1005 ICE1006 ICE Probe Motor Bracket Snap Bushing Gear Motor Clutch Assembly 180 Degree One Piece Shaft & Swivel Probe Shaft Connecting Rod Cam Switch Speed Nut Plate Insulation, Switch Nut Shoulder Screw Pan Head Machine Screw Self Tapping Screw Flat Washer Swivel Complete Assembly S S S S S Please Note: The XX is a direct replacement for the XX Harvest Assist Assembly, however the Swivel/Shaft and Nut is NOT directly replaced by the new One Piece Probe Shaft. Page 15 Rev. 3/06

18 New Style Harvest Assist Assembly NEW STYLE HARVEST ASSIST ASSEMBLY WITH SINGLE LENGTH PROBE SHAFT Page 16 Rev. 3/06

19 New Style Harvest Assist Assembly Item No. Description ICE0805 ICE0806 ICE1005 ICE1006 ICE Bracket, Probe Motor Gear Motor Clutch Assembly, 180 Deg Snap Bushing Snap Bushing #6-32 x 1/2 Screw Connecting Rod Probe, Single Length Flat Washer Shoulder Screw Spacer, Cam Switch Cam Switch Insulator Pan Head Screw Speed Nut Plate Complete Assembly S S S S S Please Note: The XX is a direct replacement for the XX Harvest Assist Assembly, however the Swivel/Shaft and Nut is NOT directly replaced by the new One Piece Probe Shaft. Page 17 Rev. 3/06

20 Remote Condenser Page 18 Rev. 3/06

21 Remote Condenser Item ICE0805 ICE0806 ICE1005 ICE1006 ICE1007 No. Description ERC2061 ERC2061 ERC2061 ERC2061 ERC Condenser Fan Blade Fan Motor Capacitor Fan Motor Brace Fan Guard Top Panel Side Panel Front Panel Rear Panel Coupling Half-Bulkhead-1/2" Coupling Half-Bulkhead-3/8" Mounting Leg Lineset Fitting with Port 1/2" Lineset Fitting with Port 3/8" Lineset Fitting without Port 1/2" Lineset Fitting without Port 3/8" Item ICE0805 ICE0806 ICE1005 ICE1006 ICE1007 No. Description ERC2062 ERC2062 ERC2062 ERC2062 ERC Condenser Fan Blade Fan Motor Capacitor Fan Motor Brace Fan Guard Top Panel Side Panel Front Panel Rear Panel Coupling Half-Bulkhead-1/2" Coupling Half-Bulkhead-3/8" Mounting Leg Lineset Fitting with Port 1/2" Lineset Fitting with Port 3/8" Lineset Fitting without Port 1/2" Lineset Fitting without Port 3/8" Page 19 Rev. 3/06