Jacuzzi. J- Installation and Operating Instructions

Size: px

Start display at page:

Download "Jacuzzi. J- Installation and Operating Instructions"

Morgan Parks
5 years ago
Views:

1 Jacuzzi J- Installation and Operating Instructions

4 WARMED WATER OUT HEAT LADEN AIR ENTERS COOL WATER IN

6 Failure to heed the following may result in permanent injury or death.

10 7

15 12

16 13

MINIMUM CLEARANCE, OVERHEAD 12- INCHES (SIDE) 12- INCHES (SIDE) SQ MODELS, 12-INCHES 30

17 OVERHANG WITH GUTTER SQ MODELS, 12-INCHES; 6-INCHES ALL OTHER, 6-INCHES (REAR) RAIN RUN-OFF MUST BE DIRECTED AWAY FROM HEATER. 5 FT. MINIMUM CLEARANCE, OVERHEAD 12- INCHES (SIDE) 12- INCHES (SIDE) SQ MODELS, 12-INCHES 30 MINIMUM CLEARANCE, FRONT ALL OTHER, 6-INCHES 6 MINIMUM CLEARANCE, (REAR) 30-INCHES (FRONT) 14 SIDE VIEW (NO SCALE) TOP VIEW (NO SCALE)

21 18

22 > > > > > > > > > > > > > > > > > > > >

24 Yes Display is illuminated. If "FLO" Display displayed, illuminated. If check "FLO" to be is display sure thed, circulating check to be pump sure isthe operating circulating and the pump f ilter is is operating clean. There and may the f ilter also is clean. be a vthere alv emay positioned also incorrectly be a v alv e. Be positioned certain water incorrectly is. f lowing Be certain through water the is f lowing heater. through the heater. START START Is the Display Illuminated? IstheDisplayIlluminated?, No If not, ensure the main breaker If not, (located ensure the at the main power breaker supply (located panel) at the and power the disconnect supply panel) switch and (located the disconnect near the switch heat pump) (located arenear both the heat turned pump) ON. are both turned ON. Yes Is the heater operating Is the correctly? heater operating c orrectly? No Is the Pool or Spa thermostat Is selected Pool or Spa for thermostat correct body selected of f or water the to correct be heated, body of and water have to ybe ou heated, tried selecting and have a higher you tried temperature selecting setting? a higher temperature setting? Yes Is the heater operating Is the correctly heater? operating correctly? No The heater is equipped The with heater a f iv e mis inute equipped delay with. Wait a f iv at e minute least five delay. minutes Wait to at allow least the five timer minutes to reset. to allow the timer to reset. Problem Solved. Problem Solved. (Verif y water temperature (Verif y water settings temperature are as settings desired.) are as desired.) Yes Is the unit operating Is correctly the unit operating? correctly? No Contact for Assistance AquaCal at for Assistance at

25 No START START Is the air being discharged out of Is the top air of being the discharged heater 9-12 out degrees of the cooler top of the than heater the 9-12 degrees outside cooler air? than the outside air? Yes Does the display read : "FS"? Does the display read : "FS"? Yes HEAT ONLY MODELS: "FS" HEAT display ONLY ed indicates MODELS: air "FS" temperature displaymay ed indicates be too low airto temperature support the may heater's be too low to operation. support Heater the will heater's remain in def operation. rost until Heater air temperature will remain in def rost until rises. air temperature HEAT-COOL MODELS:"FS" rises. indicates HEAT-COOL heater is MODELS:"FS" defrosting. indicates heater is def rosting. Is the pool pump timer set Is to the allow pool extended pump timer operation set to of allow the extended heater? operation of the heater? HEAT ONLY MODELS: Has the air HEAT temperature ONLY remained MODELS: abov Has ethe air 38ºF temperature f or sev eral hours remained and above "FS" has 38ºF been f or display sev eral ed hours throughout and "FS" has been the display period? ed throughout HEAT-COOL the MODELS: period? Has "FS" remained HEAT-COOL display MODELS: ed longer Has than "FS" 5-minutes remained (If display yes, shut ed longer heater than 5-minutes of (If f.)? yes, shut heater of f.)? No Yes No Extend the pool pump's hours Extend of the operation pool pump's to hours accommodate of operation to additional accommodate heater run time additional required heater in cooler run time conditions. required in cooler conditions. No HEAT ONLY MODELS: Ambient conditions HEAT ONLY too MODELS: cold to operate Ambient conditions heater. too cold to operate HEAT-COOL heater. MODELS: "FS" display HEAT-COOL ed f or 5-minutes MODELS: or less "FS" display indicates ed normal f 5-minutes defrostor less indicates operation. normal def rost operation. Problem Solved. Problem Solved. Yes No Is the heater performing Is the heater adequately? perf orming adequately? Yes Call Assistance: Problem Solved. Problem Solved. 22

26 Yes START START Has the "Heating" lamp been Has the illuminated? "Heating" lamp been illuminated? No When the heater is operating, it is When normal the to heater produce is operating, up to 8 it gallons is normal of condensation to produce up to 8 (water) gallons per of hour. condensation If water drainage (water) seems per hour. excessiv If water e, drainage proceed seems to TESTING. excessiv e, proceed to TESTING. If heater has not run recently, If and heater water has is not coming run recently, f rom the and heater, water is heater coming may f rom havthe e a heater, water leak. heater may hav e a water leak. Sanitizer Test TESTING: If using chlorine or bromine TESTING: as a pool/spa sanitizer, use If a using test chlorine strip test or bromine kit to determine as a pool/spa whether sanitizer, the water use is a test f rom strip the or pool test or kit is normal to determine condensation. whether the water is f rom the pool ORor is normal condensation. An alternativ e method of determining OR a water leak in the An heater alternativ is to e turn method the heater of determining of f f or a a f ew water hours, leak in leav the e heater the water is to pump turn the running, heater and of f fsee or a if f ew water hours, leavcontinues e the water to pump come frunning, rom the heater. and see if water continues to come f rom the heater. Turn- Of f Test Did the test results indicate Did the test presence results indicate of sanitizer? the presence of sanitizer? No This would indicate This the would water present indicate is the f romwater present normalis f rom condensation. normal condensation. No Does water continue to drain Does f rom water the continue heater af ter to the drain heater f rom has the been heater off af ter f or the sevheater eral hours? has been of f f or sev eral hours? Problem Solved. Problem Solved. Yes Shut off Water Pump and Call AquaCal for for ssistance: Yes 23

27 } }

28 LIMITED WARRANTY Heating Solutions manufactures its products with the highest standards of workmanship, using the best materials available through state of the art processes. Heating Solutions warrants its products as follows: LIMITED WARRANTY: HEATING SOLUTIONS WARRANTS ITS PRODUCTS TO BE FREE FROM DEFECTS IN MATERIAL AND/OR WORKMANSHIP FOR A PERIOD OF TWO (2) YEARS (PARTS ONLY) FROM ORIGINAL DATE OF PURCHASE. SPECIFIC PRODUCTS WARRANTIES (FROM DATE OF PURCHASE): PRODUCT LIMITED EXCEPTIONS EXCEPTIONS WARRANTY J-H127C HEAT PUMP 2 YEARS O-RINGS HEAT EXCHANGER, REFER CLAUSE 6 BELOW Exceptions that could result in denial of a warranty claim: 1. Damage caused by careless handling, improper repackaging or shipping. 2. Damage due to misapplication, misuse, abuse or failure to operate equipment as specified in the owner s manual. 3. Damage caused by failure to install products as specified in the owner s manual. 4. Damage due to unauthorized product modifications or failure to use original replacement parts. 5. Damage caused by negligence or failure to properly maintain products as specified in the owner s manual. 6. Damage caused by failure to maintain water chemistry in conformity with the standards of the swimming pool industry for any length of time. 7. Damage caused by water freezing inside the product. 8. Accidental damage, fire, acts of God or other circumstances outside the control of Heating Solutions. WARRANTY OBLIGATIONS OF HEATING SOLUTIONS Should a defect in workmanship and/or material in any item covered by this warranty become evident during the term of the warranty, then upon the consumer following the procedures set forth below, Heating Solutions, or its authorized service representative, will, at its option, repair or replace such item or part at its own cost and expense. Heating Solutions is not however responsible under this warranty for any cost of shipping or transportation of the equipment or parts thereof to or from the service representative. Heating Solutions is not liable for any loss of time, inconvenience, incidental expenses such as telephone calls, travel costs, labor or material charges incurred in connection with the removal or replacement of the equipment or any other incidental or consequential damages. This warranty is void if the product is repaired or altered in any way by any persons, agents or representatives other than those authorized by Heating Solutions. Expendables, including but not limited to, refrigerant, recovery of refrigerant or transportation for components are not covered under this Limited Warranty. Heating Solutions, at its sole discretion, reserves the right to provide a replacement product or part of equal value in lieu of repair. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you. Except as stated in this section, Heating Solutions, its subsidiaries and affiliates make no warranties, express, implied or statutory as to any matter whatsoever. In particular, any and all warranties of merchantability or fitness for a particular purpose and non-infringement of a third party rights are expressly excluded. This warranty extends to the original residential owner only, beginning on the date of purchase and is not enforceable by any other party. This warranty does not cover commercial facilities which are defined as any facility other than a 1

29 single family dwelling. Proof of purchase receipt will be required to execute any warranty claim. Original owner agrees to prepay all shipping charges, if applicable or necessary. PROCEDURE FOR A WARRANTY CLAIM In order to obtain the benefits of this warranty, the consumer who made the original purchase must visit their local Leslie s Swimming Pool Supplies store or contact the Service Department help desk at as soon as possible after a discovery of the defect, but in no event later than the expiration date of the warranty period provided in this warranty. Leslie s Swimming Pool Supplies is the authorized service representative for Heating Solutions. WARRANTIES OR REPRESENTATIONS BY OTHERS No Dealer or other persons have any authority to make any warranties or representation concerning Heating Solutions or its products. Accordingly, Heating Solutions is not responsible for any such warranties or representations. To the extent an extended warranty period is provided by a third party and such warranty period exceeds the Limited Warranty period provided herein, the consumer will look to the third party for the additional warranty protection. SOLE WARRANTY Supersedes all previous publications. Manufacturer Heating Solutions 4438 Muhlhauser Road Suite 600 Hamilton, OH (877) For warranty information please visit 2

AQUAPRO!OWNER S!MANUAL!

!!!!!! AQUAPRO!OWNER S!MANUAL!! 4438!Muhlhauser!Road!! Suite!600! Hamilton,!OH!45011! 877F278F2797! 1-877-278-2797 TABLE OF CONTENTS HOW A HEAT PUMP WORKS ------------------------------------------1 SAFETY