Owner s Manual. Operation and Care CL36D CR36D WOODBURNING FIREPLACE WARNING WARNING. NOTICE: DO NOT discard this manual! HOT SURFACES! materials.

Transcription

1 Owner s Manual Operation and Care NOTICE: DO NOT discard this manual! CL36D CR36D DO NOT- DO NOT - WARNING HOT SURFACES! WOODBURNING FIREPLACE DO NOT materials. - WARNING Fire Risk. For use with solid wood fuel only. 1

2 DANGER! WARNING! CAUTION! NOTICE:

3 1 Local Dealer Information DEALER: Fill in your name, address, phone and information here and below. Fireplace Information: Brand: Serial Grate Model FIREPLACE NO. WARNING: RISK OF FIRE DAMAGE. REPLACE MODEL NO. MODEL NO. MFG. DATE GRATE WITH HEARTH & HOME TECHNOLOGIES FIRECHAMBER INTENDED FOR USE WITH HEARTH & HOME TECHNOLOGIES LISTED FIREPLACE PARTS. SEE INSTALLATION AND OPERATING INSTRUCTIONS FOR THIS MODEL. ONLY HEARTH & HOME TECHNOLOGIES GLASS DOOR KITS CAN BE INSTALLED ON THIS UNIT. FIREPLACE ALSO FOR USE IN MANUFACTURED HOMES YES NO CLEARANCE TO COMBUSTIBLES: CHIMNEY 2 IN. MIN. FIREBOX IN. MIN. FAN KIT MODEL NO. & RATED AT 115 VOLTS, 50/60 Hz., AMP. DO NOT OVERFIRE. USE ONLY: SOLID WOOD FUEL OR LISTED DECORATIVE GAS APPLIANCE. DO NOT USE A FIREPLACE INSERT OR OTHER PRODUCTS NOT SPECIFIED FOR USE WITH THIS PRODUCT. IF DOORS ARE USED OPERATE FIREPLACE WITH DOORS FULLY OPEN OR CLOSED ONLY. WHEN BURNING A DECORATIVE GAS APPLIANCE IN THE FIREPLACE, ADJUST DAMPER TO THE FULLY OPEN POSITION. WARNING! THIS FIREPLACE HAS NOT BEEN TESTED WITH AN UNVENTED GAS LOG SET. TO REDUCE THE RISK OF FIRE OR INJURY, DO NOT INSTALL AN UNVENTED GAS LOG SET INTO FIREPLACE. WARNING! THIS APPLIANCE IS NOT FOR USE AS COOKING EQUIPMENT. IF INSTALLATION OR OPERATING INSTRUCTIONS ARE MISSING CONTACT: HEARTH & HOME TECHNOLOGIES, th Street West, Lakeville, MN 55044

4 B. LIMITED LIFETIME WARRANTY X X X X X X X listed X X X and glass X X X X X X X

5 5

6 WARNING! Risk of Fire or Asphyxiation! DO NOT Warning! Risk of Fire! For use with solid wood fuel only. (i.e. carbon monoxide).

7 3 A. - : WARNING! Risk of Fire! disclaims any responsibility for, and the warranty and DO NOT: components Improper installation, adjustment, alteration, service or - WARNING! Risk of Fire! Keep combustible materials, DO NOT: 48 in. (121.9 cm) Clear Space Front of Fireplace 18 in. (45.7 cm) Clear Space from Opening of Fireplace

8 2. Grate WARNING! Risk of Fire! Use only the factory-sup- WARNING! Risk of Fire! DO NOT out refractory. Use only refractory supplied by Hearth & WARNING! Risk of Fire or Burns! out. 5. Flue Damper WARNING! Risk of Fire and Asphyxiation! Open into the room. 6. Glass Doors WARNING! Risk of Fire! WARNING! Risk of Fire and Smoke! Fireplace doors fully open or doors fully closed. If doors are left WARNING! Risk of Fire! 8. Chimney Fire NFPA 211 Level 2 WARNING! Risk of Fire! - -

9 WARNING HOT SURFACES! DO NOT CAUTION! WARNING! DO NOT - Damper Control Up - Open Down - Closed Outside Air Control Handle Out - Open Handle In - Closed

10 1. Flue Damper - 3. Glass Doors CAUTION! Risk of Burns! The outside air control CORRECT CORRECT INCORRECT

11 C. Fuel WARNING! For use with solid wood fuel only. carbon monoxide). 1. Hardwood vs. Softwood WARNING! Risk of Fire! DO NOT creosote

12 NOTICE: conditions. 6. Creosote Formation D. First Fire that: 12

13 NOTICE: - WARNING! Risk of Fire! Keep combustible materials, DO NOT:

14 4 WARNING! Hot Surfaces! down. DO NOT WARNING! Risk of Asphyxiation and Fire! Annual -

15 - Tools WARNING! Risk of Fire! HOT. Prevent creosote buildup. Remove screws, lift top cover. Top Cover Remove 4 screws and lift top pan off. 1. Remove the 4 screws. 2. Remove the screen. 3. Remove the baffle. Remove 2 screws from the front and back and lift the top off. Remove 8 screws and lift top. Top Top Chimney Cap Cap Cap Screw Screw Slip Section Chase TR344/TR342 Round Termination Cap ST375 Square Termination Cap TS345/TS345P Square Termination Caps TCT375 Terra Cotta Termination Cap DTO/DTS Series Termination Cap 15

16 C. Grate : Tools Needed E. Ash Removal Tools Needed WARNING! Risk of Fire! DO NOT remove ashes until

17 5 Solution

18 A. FAQs dealer.

19 Overhanging tree? Strong winds around chimney termination? Another appliance in home also exhausting air (furnace, fan, dryer, etc.)? Unsealed can lights? Bird's nest or leaves in termination cap? Structural changes in chimney area? Overhead fan operating? Air register from furnace near fireplace? Creosote buildup in flue? Doors opening and closing? Window closed for start-up? Combustion air control Outside air closed?

20 Doors Gas Inserts 22

21

22 Heatilator, a brand of Hearth & Home Technologies th Street West, Lakeville, MN NOTES Important operating and maintenance instructions included. CAUTION DO NOT DISCARD THIS MANUAL Read, understand and follow these instructions for safe installation and operation. Leave this manual with party responsible for use and operation. This product may be covered by one or more of the following patents: (United States) , , , , , , , , , , , , , , , , , , , , , , , , , , , , , , , , , , , , B2, B2, , , , , , , , , , , , , , , , , , , D320652, D445174, D462436; (Canada) , , , ; (Australia) , , or other U.S. and foreign patents pending. Printed in U.S.A. - Copyright 2012