DEPARTMENT OF THE ARMY TECHNICAL MANUAL
|
|
- Jemima Ball
- 5 years ago
- Views:
Transcription
1 This copy is a reprint which includes current pages from Changes 1 through 10. TM DEPARTMENT OF THE ARMY TECHNICAL MANUAL TECHNICAL MANUAL OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL AIR CONDITIONER, HORIZONTAL COMPACT 18,000 BTU TRANE MODELS 208V, 3 PHASE, 50/60 HERTZ, MODEL MAC6H (FSN ) 208V, 3 PHASE, 400 HERTZ, MODEL MAC4H (FSN ) 230V, 1 PHASE, 50/60 HERTZ, MODEL MAC6H (FSN ) HEADQUARTERS, DEPARTMENT OF THE ARMY 28 OCTOBER 1971
2 TM T ECHNICAL M ANUAL HEADQUARTERS DEPARTMENT OF THE ARMY No W ASHINGTON, D.C. 28 0ctober 1971 OPERATOR, ORGANIZATlONAL, DIRECT AND GENERAL SUPPORT MAINTENANCE MANUAL AIR CONDITIONER, HORIZONTAL COMPACT, 18,000 BTU (TRANE MODELS) 208V, 3 PHASE, 50/60 HERTZ, MODEL MAC6H (FSN ) 208V, 3 PHASE, 400 HERTZ, MODEL MAC4H (FSN ) 230V, 1 PHASE, 50/60 HERTZ, MODEL MAC6H (FSN ) CHAPTER 1. C HAPTER 2. I IV. V. CHAPTER 3. I IV. V. CHAPTER 4. I IV. V. VI. V VI IX. X. XI. X XI XIV. XV. XVI. Paragraph INTRODUCTION General Description and data INSTALLATION AND OPERATION INSTRUCTIONS Service upon receipt of equipment Movement to a new worksite Control sand instruments operation under usual conditions Operation under unusual conditions OPERATOR/CREW MAINTENANCE INSTRUCTIONS Basic issue items Lubrication Preventive maintenance checks and services Troubleshooting operator s maintenance of air conditioner ORGANIZATIONAL MAINTENANCE INSTRUCTIONS Service upon receipt of material Movement to a new worksite Repair parts, special tools and equipment Preventive maintenance checks and service Troubleshooting Radio interference suppression Covers, louvers, and filters Condenser coil, evaporator coil, and drains Fresh air vent damper and control Electrical system Heaters and thermostatics witch Fan motors Fan motor switches and capacitors Control module Junction box Transformer, rectifier, and pressure switches Page i
3 Paragraph Section XV Compressor XVI Refrigeration system CHAPTER 5. DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE INSTRUCTIONS Repair parts, special tools and equipment Troubleshooting I General maintenance instructions IV. Removal and installation of major components CHAPTER 6. REPAIR INSTRUCTIONS Refrigeration system Electrical components APPENDIX A. REFERENCES B. MAINTENANCE ALLOCATION CHART B-1 C. BASIC ISSUE ITEM LIST C-1 ]NDEX I-1 Page A-1
4 Number LIST OF ILLUSTRATIONS Title Page Air conditioner, left front 3/4 view with shipping dimensions Air conditioner, right rear 3/4view Air conditioner, top view, top covers removed Control system schematic diagram, 1 phase, 50/60 hertz, 230 volts Control system schematic diagram, 3 phase, 50/60 hertz, and 400 hertz, 208 volts Wiring diagram, 1 phase,50/60 hertz, 230 volts Wiring diagram, 3 phase, 50/60 hertz, 208 volts Wiring diagram, 3 phase, 400 hertz, 208 volts Base mounting holes Typical installation of air conditioner to enclosure Control and instruments (sheet 1 of 2) Controls and instruments (sheet 2 of 2) Starting instructions for cooling Operating instructions for cooling Starting instructions for heating Operating instructions for heating Operating instructions for ventilation Stripping instructions R. F. I. capacitors Evaporator air louvers and air filter Fresh air vent screen Louver blades push-on nuts Housing covers Evaporator drain tubing Vent damper control Vent damper Heater thermostatic switch Heater elements and support Evaporator fanand motor assembly Condenser fan and motor Condenser fan motor and mounting plate, exploded view Motor thermal protector housing Condenser fan motor thermostatic switch Fan motor capacitors Control module connector knob and bulb mounting Control module less cover Junction box, partially removed Junction box components, exploded view Transformer, rectifier, and pressure switches Compressor electrical connector and terminal box cover Compressor start capacitor and relay Compressor run capacitor Refrigerant flow diagram Compressor,removal and installation Evaporator coil, remova l and installation Condenser louver control, and actuator cylinder Condenser. air discharge louver assembly Condenser coil, removal and installation Charging valves and pressure switch connections Dehydrator, receiver and solenoid valves Thermal expansion valve Quench valve and pressure regulator valve Pressure regulator valves Accumulator Accumulator Discharge and evacuating refrigerant system Charging refrigerant system Solenoid valve, exploded view Fan motor, exploded view Control module, exploded view iii
5 CHAPTER 1 INTRODUCTION GENERAL. Scope a. These instructions are published for the use of the personnel to whom the Trane Company Models, MAC6H , MAC6H and MAC4H Air Conditioners are issued. Chapters 1 through 4 provide information on the operation, preventive maintenance services, and organizational maintenance of the equipment, accessories, components, and attachments. Chapters 5 and 6 provide information for direct and general support maintenance. Also included are descriptions of main units and their functions in relationship to other components. b. Appendix A contains a list of publications applicable to this manual. Appendix B contains the Maintenance Allocation Charts. Appendix C contains a list of Basic Issue Items authorized to operator of this equipment. The Organizational, Direct, and General Support Maintenance Repair Parts are listed and illustrated in TM P (when printed). c. Numbers in parentheses on illustrations indicate quantity Record and Report Forms a. DA Form 2258, Depreservation guide of Engineer Equipment. b. Maintenance forms, records, and reports which are to be used by maintenance personnel at all maintenance levels are listed in and prescribed by TM Note. Applicable forms, excluding Standard Form 46 (United States Government Motor Vehicle Operator s Identification Card) which is carried by the operator, will be kept in a canvas bag mounted on the equipment Reporting of Errors a. Report of errors, omissions, and recommendations for improving this publication by the individual user is encouraged. Reports should be submitted on DA Form 2028 (Recommended Changes to Publications) and forwarded direct to Commanding General, U. S. Army Mobility Equipment Command, ATTN: AMSME-MPP, 4300 Goodfellow Boulevard, St. Louis, Mo b. Report all equipment improvement recommendations as prescribed by TM Section DESCRIPTION AND DATA 1-4. Description cooling and heating air to a desired predetermined a. General. Air conditioners, Model MAC6HA18- range and circulating the conditioned air to provide , MAC6H , and heating or cooling of equipment or personnel within MAC4H , (fig. thru 1-3) are the air conditioned area. lightweight, compact, horizontal units designed for
6
DEPARTMENT OF THE ARMY TECHNICAL MANUAL (FSN ) This copy is a reprint which includes current pages from Changes 1 through 3.
TM 5-4120-239-14 DEPARTMENT OF THE ARMY TECHNICAL MANUAL TECHNICAL MANUAL OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL AIR CONDITIONER, HORIZONTAL COMPACT, 9,000 BTU
More informationDEPARTMENT OF THE ARMY TECHNICAL MANUAL TECHNICAL MANUAL OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
TM 10-4520-201-14 DEPARTMENT OF THE ARMY TECHNICAL MANUAL TECHNICAL MANUAL OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL HEATER, DUCT - TYPE; PORTABLE; GASOLINE; 250,000
More informationTM TO 34W
TM 5-3431-228-14 TO 34W4-102-1 TECHNICAL MANUAL OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL WELDING MACHINE, ARC: AC/DC, 300 AMP, TRANSFORMER RECTIFIER; CONSTANT CURRENT,
More informationAIR CONDITIONER, HORIZONTAL, COMPACT, BTUH
TECHNICAL MANUAL OPERATOR S ORGANIZATIONAL, DIRECT SUPPORT & GENERAL SUPPORT MAINTENANCE MANUAL FOR AIR CONDITIONER, HORIZONTAL, COMPACT, 36000 BTUH 208 VOLT, 3 PHASE 400 HERTZ NSN 4120-00-063-8182 AMERICAN
More informationOPERATING INSTRUCTIONS 2-1 OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) 2-5 OPERATOR TROUBLESHOOTING 3-1
TECHNICAL MANUAL TM 9-4120-402-14 OPERATOR'S, UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL OPERATING INSTRUCTIONS 2-1 OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) 2-5 OPERATOR
More informationDEPARTMENT OF THE ARMY TECHNICAL MANUAL TECHNICAL MANUAL
DEPARTMENT OF THE ARMY TECHNICAL MANUAL TM 5-4520-235-13 TECHNICAL MANUAL OPERATOR, ORGANIZATIONAL AND DIRECT SUPPORT MAINTENANCE MANUAL INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST HEATER, SPACE, OIL
More informationTECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL, DIRECT AND GENERAL SUPPORT MAINTENANCE MANUAL
TECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL, DIRECT AND GENERAL SUPPORT MAINTENANCE MANUAL HEATER, SPACE, MULTI-FUEL, WITH BLOWER, 6,000 BTU/HR (HUNTER MODEL UH-68F) NSN 4520-01-050-5628 This copy is a
More informationAIR CONDITIONER, HORIZONTAL, 9,000 BTU/HR
TECHNICAL MANUAL OPERATOR, ORGANIZATIONAL, AND DIRECT SUPPORT MAINTENANCE MANUAL AIR CONDITIONER, HORIZONTAL, 9,000 BTU/HR A.R.E. MANUFACTURING CO., INC. MODEL FM9000 NSN 4120-01-125-3947 HEADQUARTERS,
More informationOperator's, Unit, Direct Support and General Support Maintenance Manual
Operator's, Unit, Direct Support and General Support Maintenance Manual * INTRODUCTION PAGE 1-1 OPERATING INSTRUCTIONS PAGE 2-1 OPERATOR MAINTENANCEPAGE PAGE 3-1 UNIT MAINTENANCE P PAGE 4-1 DIRECT SUPPORT
More informationTM NOVEMBER 1986 HEATER, SPACE, MULTIFUEL WITH BLOWER, 60,000 BTU/HR, 120 V UH-68G ( )
OPERATOR S, UNIT, AND INTERMEDIATE MAINTENANCE MANUAL TABLE OF CONTENTS i OPERATING INSTRUCTIONS 2-1 UNIT MAINTENANCE INSTRUCTIONS 3-1 INTERMEDIATE MAINTENANCE INSTRUCTIONS 4-1 MAINTENANCE ALLOCATION CHART
More informationHEADQUARTERS, DEPARTMENT OF THE ARMY AND THE AIR FORCE 5 AUGUST 1988
ARMY TM 5-4520-256-14 AIR FORCE T.O. 35E7-6-26-1 OPERATOR S, UNIT, INTERMEDIATE DIRECT SUPPORT AND INTERMEDIATE GENERAL SUPPORT MAINTENANCE HEATER, DUCT TYPE, PORTABLE, HDU-36/E, 120,000 BTU, MODEL H82
More informationHEATER, DUCT TYPE, PORTABLE, TRAILER MOUNTED, 400,000 BTU/HR FlESTA MODEL FC OPERATOR S, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT
T M 5-4 5 2 0-2 4 4-1 4 OPERATOR S, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL TABLE OF CONTENTS EQUIPMENT DESCRIPTION OPERATING INSTRUCTIONS OPERATOR S MAINTENANCE ORGANIZATIONAL
More informationTECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
TECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL LANDING CRAFT UTILITY LCU 1667-1670 NSN 1905-01-168-5764 OPERATOR MAINTENANCE INSTRUCTIONS FOR AUXILIARY
More informationDEPARTMENT OF THE ARMY TECHNICAL MANUAL. Operator, Organizational, Direct Support General Support and Depot Maintenance Manual
DEPARTMENT OF THE ARMY TECHNICAL MANUAL Operator, Organizational, Direct Support General Support and Depot Maintenance Manual AIR CONDITIONING UNITS, ELECTRIC MOTOR DRIVEN 6,000 BTU/HR VERTICAL COMPACT,
More informationAIR CONDITIONER, VERTICAL, COMPACT
*TM 9-4120-385-14 TECHNICAL MANUAL Operator s, Unit, Direct Support and General Support Maintenance Manual AIR CONDITIONER, VERTICAL, COMPACT 9,000 BTU/HR 115 VOLT, 1-PHASE, 50/60 HERTZ (NSN 4120-01-193-4999)
More informationOPERATING INSTRUCTIONS 2-1 OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) 2-5 OPERATOR TROUBLESHOOTING 3-1
TECHNICAL MANUAL TM 9-4120-402-14 OPERATOR'S, UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL OPERATING INSTRUCTIONS 2-1 OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) 2-5 OPERATOR
More informationTM DEPARTMENT OF THE ARMY TECHNICAL MANUAL OPERATOR S, ORGANIZATIONAL, DIRECT SUPPORT, GENERAL SUPPORT, AND DEPOT MAINTENANCE MANUAL
TM 5-4120-285-15 DEPARTMENT OF THE ARMY TECHNICAL MANUAL OPERATOR S, ORGANIZATIONAL, DIRECT SUPPORT, GENERAL SUPPORT, AND DEPOT MAINTENANCE MANUAL AIR CONDITIONER, COMPACT VERTICAL: 208V, 3 PHASE, 18,000
More information*TM Operator s, Unit, Direct Support, and General Support Maintenance Manual TECHNICAL MANUAL
*TM 9-4520-251-14 TECHNICAL MANUAL Operator s, Unit, Direct Support, and General Support Maintenance Manual HEATER, DUCT TYPE, PORTABLE, TRAILER MOUNTED, 400,000 BTU/HR MODEL PH-400-G NSN 4520-01-136-2139
More informationHEADQUARTERS, DEPARTMENT OF THE ARMY 25 FEBRUARY 1982
TECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL CHAPTER/ APPENDIX INTRODUCTION 1 OPERATING INSTRUCTIONS 2 ORGANIZATIONAL MAINTENANCE INSTRUCTIONS 3 DIRECT
More informationDEPARTMENT OF THE ARMY TECHNICAL MANUAL
This copy is a reprint which includes current pages from Changes 1 through 10. TM 5-4120-243-14 DEPARTMENT OF THE ARMY TECHNICAL MANUAL TECHNICAL MANUAL OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL
More informationTECHNICAL MANUAL OPERATOR S, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL IINCLUDING REPAIR PARTS AND SPECIAL TOOLS LISTI FOR
TM 5-4210-222-14&P-3 TECHNICAL MANUAL OPERATOR S, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL IINCLUDING REPAIR PARTS AND SPECIAL TOOLS LISTI FOR TRUCK, FIREFIGHTIN6G DRY CHEMICAL
More informationTECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL, DIRECT AND GENERAL SUPPORT MAINTENANCE MANUAL
TECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL, DIRECT AND GENERAL SUPPORT MAINTENANCE MANUAL HEATER, SPACE, MULTI-FUEL, WITH BLOWER, 6,000 BTU/HR (HUNTER MODEL UH-68F) NSN 4520-01-050-5628 This copy is a
More informationICEU 36 SPARE PARTS LIST REV. 07/2016
ICEU 36 ~ SPARE PARTS LIST REV. 07/2016 ICEU 36 1 UNIT PANELS UP TO S.N. 02594 2 UNIT PANELS FROM S.N. 02595 3 REFRIGERANT SYSTEM AIR COOLED UP TO S.N. 02413 4 REFRIGERANT SYSTEM AIR COOLED - FROM S.N.
More informationTECHNICAL MANUAL OPERATOR S, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
* TECHNICAL MANUAL OPERATOR S, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL AIR CONDITIONER, HORIZONTAL, COMPACT 9,000 BTU/HR, 115 VOLT, SINGLE PHASE 50/60 HZ OPERATOR S MAINTENANCE INSTRUCTIONS
More informationTM LANDING CRAFT, UTILITY (LCU) BASIC CRAFT UNIT, INTERMEDIATE DIRECT SUPPORT AND INTERMEDIATE GENERAL MAINTENANCE INSTRUCTIONS
TECHNICAL MANUAL UNIT, INTERMEDIATE DIRECT SUPPORT AND INTERMEDIATE GENERAL SUPPORT MAINTENANCE INSTRUCTIONS LANDING CRAFT, UTILITY (LCU) NSN 1905-01-154-1191 BASIC CRAFT (PART I) This, copy is a reprint
More informationTECHNICAL MANUAL OPERATOR, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) FOR
*TM 55-1930-209-14&P-17 TECHNICAL MANUAL OPERATOR, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) FOR WATER PURIFICATION BARGES (NSN 1930-01-234-2165)
More informationTECHNICAL MANUAL OPERATOR S, UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL FOR
TM 9-4120-430-14 TECHNICAL MANUAL OPERATOR S, UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL FOR AIR CONDITIONER, HORIZONTAL COMPACT, 18,000 BTU/HR 230 VOLT, 1 PHASE, 50/60 HERTZ, ENVIRONMENTAL
More informationTECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL AND DIRECT SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST)
TM 5-4210-228-14&P-2 TECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL AND DIRECT SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) TRUCK, FIRE FIGHTING, 4x4, MODEL 1350 PKP/200 AFFF
More informationTECHNICAL MANUAL OPERATOR S MANUAL FOR MULTIPLE INTEGRATED LASER ENGAGEMENT SYSTEM (MILES) SIMULATOR SYSTEM, FIRING, LASER: M78 NSN
TECHNICAL MANUAL OPERATOR S MANUAL FOR MULTIPLE INTEGRATED LASER ENGAGEMENT SYSTEM (MILES) SIMULATOR SYSTEM, FIRING, LASER: M78 NSN 1270-01-159-0482 FOR OH-58 OBSERVATION HELICOPTER HEADQUARTERS, DEPARTMENT
More informationTECHNICAL MANUAL OPERATOR'S, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
TECHNICAL MANUAL OPERATOR'S, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL AIR CONDITIONER, 24,000 BTU ELECTRIC MOTOR DRIVEN 208 V, 3-PHASE, 50/60 HZ, 5 WIRE INTRODUCTION PAGE 1-1 OPERATING
More informationTECHNICAL MANUAL OPERATOR'S, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
TECHNICAL MANUAL OPERATOR'S, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL AIR CONDITIONER, COMPACT, VERTICAL 208-VOLT, 3 PHASE, 60,000 BTU/HR 50/60 HERTZ KECO MODEL F60T-2 NSN 4120-00-935-5416
More informationTM REFRIGERATION UNIT, MECHANICAL, 9K BTU, ELECTRIC MODEL F9000RE ( ) MODEL F9000REA ( ) TECHNICAL MANUAL
TECHNICAL MANUAL TM 9-4110-258-13 OPERATOR S, UNIT, AND DIRECT SUPPORT MAINTENANCE MANUAL OPERATING INSTRUCTIONS 2-1 OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) 2-6 UNIT MAINTENANCE INSTRUCTIONS
More informationParts List. Modular Crescent Cuber. Models KM-340MAJ, MWJ. hoshizakiamerica.com
Parts List Modular Crescent Cuber Models KM-340MAJ, MWJ hoshizakiamerica.com Number: 71389 Issued: 10-23-2017 Revised: 6-12-2018 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts... 3 A. Main Assembly
More informationRED DOT UNITS. Heating & Air Conditioning. Parts
Heating & Air Conditioning Parts 71 R-134a COMPONENTS THE DETAILS R-134a is the new refrigerant that will be used in future heavy duty air conditioning systems. This new refrigerant is used in conjunction
More informationUNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST
UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST LAUNDRY UNIT, TRAILER MOUNTED MODEL M85-100 NSN 3510-01-291-8169 Approved for public release; distribution is unlimited
More informationRoom Air Conditioner Service and Parts Manual
Cool Dry Temp Mode Room Air Conditioner Service and Parts Manual F Fan Speed hr Timer 0n 0ff Money Saver Fan Only Auto Swing Power CP06 CP08 93011401_01 CONTENTS 1. PREFACE 1.1 SAFETY PRECAUTIONS...2 1.2
More informationParts List. Modular Crescent Cuber. Models KM-515MAJ, MWJ, MRJ. hoshizakiamerica.com
Parts List Modular Crescent Cuber Models KM-515MAJ, MWJ, MRJ hoshizakiamerica.com Number: 71390 Issued: 10-23-2017 Revised: 11-17-2017 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts... 3 A. Main
More informationOPERATION AND MAINTENANCE INSTRUCTIONS FOR ROOF TOP HEAT PUMPS AND CEILING PLENUMS
OPERATION AND MAINTENANCE INSTRUCTIONS FOR ROOF TOP HEAT PUMPS AND CEILING PLENUMS TABLE OF CONTENTS I. General Information.................................................. 2 II. Standard Ceiling Plenum
More informationPreventative Maintenance Tables
Preventative Maintenance Tables Table of Contents I. Table : Gas Fired Domestic Hot Water Heater II. III. IV. Table : Circulating Pump Table : Convectors Table 4: Grille and Diffusors V. Table 5: Unit
More informationSERVICE MANUAL PORTABLE AIR CONDITIONER WAP-237EB NEW WIDETECH V 50Hz
IDETECH R NE IDETECH SERVICE MANUAL PORTABLE AIR CONDITIONER AP-237EB Important points on service, and flow chart for inspecting and repairing the unit... 1 Appearance(out ward)... 2 Troubleshooting...
More informationTECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL AND DIRECT SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST)
TECHNICAL MANUAL OPERATOR'S, ORGANIZATIONAL AND DIRECT SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) TRUCK, FIRE FIGHTING, 4x4, MODEL 1350 PKP/200 AFFF NSN 4210-00-484-5729
More informationCOMMERCIAL TECHNICAL MANUAL WITH PERFORMANCE DATA OPERATOR S, UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL FOR
TM 24-4120-14&P COMMERCIAL TECHNICAL MANUAL WITH PERFORMANCE DATA OPERATOR S, UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL FOR AIR CONDITIONER, HORIZONTAL COMPACT, 24,000 BTU/HR 208 VOLT,
More informationRoom Air Conditioner EP08 & EP12. Chill 115 Volts-EP Volts-EP12. Service & Parts Manual THE EXPERTS IN ROOM AIR CONDITIONING
Room Air Conditioner Service & Parts Manual 2014-2015 EP08 & EP12 Chill 115 Volts-EP08 230 Volts-EP12 THE EXPERTS IN ROOM AIR CONDITIONING 93011407_00 CONTENTS 1. PREFACE 1.1 SAFETY PRECAUTIONS...2 1.2
More informationParts List. Low-Profile Modular Crescent Cuber. Models KML-325MAJ KML-325MWJ. hoshizakiamerica.com
Parts List Low-Profile Modular Crescent Cuber Models KML-325MAJ KML-325MWJ hoshizakiamerica.com Number: 71377 Issued: 4-7-2017 Revised: 9-8-2017 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts...
More informationRoom Air Conditioner CP06 & CP08. Chill 115 Volts. Service & Parts Manual THE EXPERTS IN ROOM AIR CONDITIONING _02
Room Air Conditioner Service & Parts Manual 2014-2015 CP06 & CP08 Chill 115 Volts THE EXPERTS IN ROOM AIR CONDITIONING 93011401_02 CONTENTS 1. PREFACE 1.1 SAFETY PRECAUTIONS...2 1.2 INSULATION RESISTANCE
More informationOPERATION AND MAINTENANCE INSTRUCTIONS FOR ROOF TOP HEAT PUMPS AND CEILING PLENUMS
OPERATION AND MAINTENANCE INSTRUCTIONS FOR ROOF TOP HEAT PUMPS AND CEILING PLENUMS RV Products A Division of Airxcel, Inc. P.O. Box 4020 Wichita, KS 67204 1976H207 (10-06) PP TABLE OF CONTENTS I. General
More informationParts List. Modular Crescent Cuber. Models KM-901MAJ KM-901MWJ KM-901MRJ/3. hoshizakiamerica.com
Parts List Modular Crescent Cuber Models KM-901MAJ KM-901MWJ KM-901MRJ/3 hoshizakiamerica.com Number: 71391 Issued: 10-23-2017 Revised: 6-8-2018 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts...
More informationTitle 24, Part 6 Certification of Economizer Fault Detection and Diagnostics (FDD)
Title 24, Part 6 Certification of Economizer Fault Detection and Diagnostics (FDD) Title 24, Part 6 Section 120.2(i) requires that economizer FDD functions be installed on air cooled unitary air conditioning
More informationOPERATION AND MAINTENANCE INSTRUCTIONS FOR 6535 AND 6536 SERIES TWO TON PACKAGED HEAT PUMP
RV Products Division OPERATION AND MAINTENANCE INSTRUCTIONS FOR 6535 AND 6536 SERIES TWO TON PACKAGED HEAT PUMP TABLE OF CONTENTS I. Specifications....................................... 2 II. General
More informationRSES Technical Institute Training Manual 2 72 hours, 72 NATE CEHs, 7.2 CEUs
Lesson 1 - Trade Tools Explain the importance of using proper tools and test instruments. List the various types of wrenches and describe their use. Describe the proper procedures for bending, flaring,
More informationParts List. Stackable Crescent Cuber. Models KM-1601SAJ/3 KM-1601SWJ/3 KM-1601SRJ/3. hoshizakiamerica.com
Parts List Stackable Crescent Cuber Models KM-1601SAJ/3 KM-1601SWJ/3 KM-1601SRJ/3 hoshizakiamerica.com Number: 71375 Issued: 5-15-017 Revised: 10-3-018 CONTENTS Auxiliary Codes... 3 Note About Ordering
More informationRefrigeration and. Modern. Air Conditioning. Bracciano, BS, M.Ed., Ed. Sp. Alfred F. Andrew D. Althouse, BS, (ME), MA. Carl H. Tumquist, BS, (ME), MA
Modern Refrigeration and Air Conditioning by Andrew D. Althouse, BS, (ME), MA Technical-Vocational Education Consultant Life Member, American Society of Heating, Refrigeration, and Air-Conditioning Engineers
More informationDISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
TECHNICAL MANUAL OPERATOR'S UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL FOR CONTAINER, REFRIGERATED 20 FEET MODEL KR020A180G NSN: 8145-01-388-4966 Operating Instructions 2-1 Operator Maintenance
More informationPROAIR Air Conditioner. CR29 Model INSTRUCTION MANUAL nvent Rev. I P/N
PROAIR Air Conditioner CR29 Model INSTRUCTION MANUAL Rev. I P/N 89104461 TABLE OF CONTENTS Warranty and Return Policy...2 RECEIVING THE AIR CONDITIONER...3 HANDLING AND TESTING THE AIR CONDITIONER...3
More informationAIR CONDITIONER OPERATOR'S MANUAL. Keep This Manual With Air Conditioner ADVANTAGE RP55 SERIES
ADVANTAGE RP55 SERIES Keep This Manual With Air Conditioner AIR CONDITIONER OPERATOR'S MANUAL BEFORE INSTALLING AND USING THIS AIR CONDITIONER, IT IS IMPORTANT THAT THIS MANUAL BE READ AND UNDERSTOOD THOROUGHLY
More informationRefrigeration System with a Capillary Tube and a Thermostat
Exercise 2-1 Refrigeration System with a Capillary Tube Part A: REFRIGERATION CIRCUIT OBJECTIVE When you have completed this part, a refrigeration circuit using a capillary tube as a metering device will
More informationOPERATION AND MAINTENANCE INSTRUCTIONS FOR SERIES TWO TON PACKAGED HEAT PUMP
OPERATION AND MAINTENANCE INSTRUCTIONS FOR 46516 SERIES TWO TON PACKAGED HEAT PUMP Airxcel, Inc. P.O. Box 4020 Wichita, KS 67204 1976-554 (2-10) PP TABLE OF CONTENTS I. Specifications.........................................
More informationTECHNICAL MANUAL UNIT, INTERMEDIATE DIRECT SUPPORT AND INTERMEDIATE GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST)
TM 55-1925-227-24&P TECHNICAL MANUAL UNIT, INTERMEDIATE DIRECT SUPPORT AND INTERMEDIATE GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) FIRE FIGHTING SYSTEM FOR LARGE
More informationParts List. Low-Profile Modular Crescent Cuber. Models KML-500MAJ KML-500MWJ. hoshizakiamerica.com
Parts List Low-Profile Modular Crescent Cuber Models KML-500MAJ KML-500MWJ hoshizakiamerica.com Number: 71378 Issued: -8-017 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts... 3 A. Main Assembly
More informationParts List. Modular Crescent Cuber. Models KM-1100MAJ, MWJ, MRJ. hoshizakiamerica.com
Parts List Modular Crescent Cuber Models KM-1100MAJ, MWJ, MRJ hoshizakiamerica.com Number: 71392 Issued: 12-12-2017 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts... 3 A. Main Assembly & Refrigeration
More informationAE October 1965 Reformatted October Hot Gas Bypass Control Systems
Hot Gas Bypass Control Systems AE21-1160 AE21-1160 October 1965 Reformatted October 2010 On many refrigeration and air conditioning systems, the refrigeration load will vary over a wide range. This may
More informationParts List. Stackable Crescent Cuber. Models KM-1900SAJ/3 KM-1900SWJ/3 KM-1900SRJ/3. hoshizakiamerica.com
Parts List Stackable Crescent Cuber Models KM-1900SAJ/3 KM-1900SWJ/3 KM-1900SRJ/3 hoshizakiamerica.com Number: 71384 Issued: 8-31-2017 Revised: 3-26-2018 CONTENTS Auxiliary Codes... 3 Note About Ordering
More informationSubmittal Data PERFORMANCE DATA CERTIFIED DIMENSION PRINTS CERTIFIED ROOF CURB DIMENSION PRINTS SERVICE OPTION DIMENSION PRINTS
AutoZone R Model Single Package Rooftop Gas Heating/Electric Cooling Unit Size 07 with Puronr (R---410A) Refrigerant Submittal Data PERFORMANCE DATA CERTIFIED DIMENSION PRINTS CERTIFIED ROOF CURB DIMENSION
More informationpower Describe the purpose of lockout/tag-out devices Demonstrate use of lockout/tagout
c. All contestants are required to remain in the contest area until the contest has been torn down and excused by the Chairperson. Note: Your contest may also require a hard copy of your résumé as part
More informationParts List. Modular Crescent Cuber. Models KMD-460MAH, MWH KMD-530MAH, MWH, MRH. hoshizakiamerica.com
Parts List Modular Crescent Cuber Models KMD-460MAH, MWH KMD-530MAH, MWH, MRH hoshizakiamerica.com Number: 71357 Issued: 11-19-2014 Revised: 11-28-2017 CONTENTS Auxiliary Codes... 3 Note About Ordering
More informationRoom Air Conditioner Service and Parts Manual
Cool Dry Mode Temp Room Air Conditioner Service and Parts Manual 0F Fan Speed hr Timer 0n/0ff Money Saver Fan Only Auto Swing Power CP10 CP12 CP10 - CP12 (06/14) 93011402_04 CONTENTS 1. PREFACE 1.1 SAFETY
More informationTROUBLESHOOTING VANGUARD
TROUBLESHOOTING VANGUARD IMPORTANT: Only a qualified Service Person should service internal components or electrical wiring. WARNING: Disconnect electrical power to the Unit to prevent personal injury
More informationThru-the-Wall Series
Uni- Fit R Thru-the-Wall Series Service and Parts Manual Thru-the-Wall Series 115 Volts US08C10 US10C10 US12C10 230 Volts US10C30 US12C30 US14C30 Unifit Cool Svc Parts 2010 (05/10) Unifit. Cool (03/07)
More informationParts List. Modular Flaker F-1501MAH(-C) F-1501MWH(-C) F-1501MRH(-C) hoshizakiamerica.com
Parts List Modular Flaker F-1501MAH(-C) F-1501MWH(-C) F-1501MRH(-C) hoshizakiamerica.com Number: 71353 Issued: 7-9-2014 Revised: 12-14-2017 CONTENTS Note About Ordering Parts... 3 A. Main Assembly & Refrigeration
More informationUSER'S MANUAL PGE Single Package Rooftop
USER'S MANUAL PGE Single Package Rooftop Gas Heating/Electric Cooling Units Sizes 036-150 3 to 12-1/2 Tons NOTE TO INSTALLER: This manual should be left with the equipment owner. WARNING: If the information
More informationSpare Parts Catalogue AC176
Spare Parts Catalogue AC176 1 - UNIT PANELS 2 - REFRIGERANT SYSTEM AIR COOLED 3 - REFRIGERANT SYSTEM WATER COOLED 4 - WATER SYSTEM - SMALL CUBE 5 - WATER SYSTEM - MEDIUM CUBE 6 - WATER SYSTEM - LARGE CUBE
More informationPROAIR Air Conditioner. CR23 Model INSTRUCTION MANUAL nvent Rev. D P/N
PROAIR Air Conditioner CR23 Model INSTRUCTION MANUAL Rev. D P/N 89112522 TABLE OF CONTENTS Warranty and Return Policy...2 RECEIVING THE AIR CONDITIONER...3 HANDLING AND TESTING THE AIR CONDITIONER...3
More informationTECHNICAL MANUAL OPERATOR S, AND MANINTENANCE MANUAL AIR CONDITIONER, HORIZONTAL COMPACT, 33,000 BTU/HR 208 VOLT, THREE PHASE, 400HERTZ,
TM 21614-LCAC TECHNICAL MANUAL OPERATOR S, AND MANINTENANCE MANUAL FOR AIR CONDITIONER, HORIZONTAL COMPACT, 33,000 BTU/HR 208 VOLT, THREE PHASE, 400HERTZ, PART NO. LCAC-33KH-1 NSN 4120-01-512-2399 UNITED
More informationUNOFFICIAL COPY OF HOUSE BILL 1406 A BILL ENTITLED
UNOFFICIAL COPY OF HOUSE BILL 1406 M3 5lr2924 By: Delegates McMillan, Boschert, Gilleland, and McDonough Introduced and read first time: February 18, 2005 Assigned to: Rules and Executive Nominations 1
More informationTable of Contents. Models/Tech Data Sheet Location. Grille/Filter Removal. Power Supply. Fan Operation Adjustment. Temperature Limiting Switches
Copyright 2004 Table of Contents Models/Tech Data Sheet Location Grille/Filter Removal Power Supply Fan Operation Adjustment Temperature Limiting Switches Vent Control - PC Board Service Blower and Fan
More informationHEATER, DUCT TYPE, PORTABLE, TRAILER MOUNTED, 400,000 BTU/HR FlESTA MODEL FC OPERATOR S, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT
T M 5-4 5 2 0-2 4 4-1 4 OPERATOR S, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL TABLE OF CONTENTS EQUIPMENT DESCRIPTION OPERATING INSTRUCTIONS OPERATOR S MAINTENANCE ORGANIZATIONAL
More informationSECTION REFRIGERATION EQUIPMENT. A. Section Includes: Refrigeration equipment for insulated cold storage rooms including necessary accessories.
SECTION 15650 REFRIGERATION EQUIPMENT PART 1 GENERAL 1.01 SUMMARY A. Section Includes: Refrigeration equipment for insulated cold storage rooms including necessary accessories. B. Related Section: 1. 11400
More informationUNOFFICIAL COPY OF HOUSE BILL 1202 EMERGENCY BILL 5lr2923
P3 UNOFFICIAL COPY OF HOUSE BILL 1202 EMERGENCY BILL 5lr2923 By: Delegates McMillan, Boschert, Gilleland, and McDonough Introduced and read first time: February 11, 2005 Assigned to: Environmental Matters
More informationHEADQUARTERS, DEPARTMENT OF ARMY
OPERATING INSTRUCTIONS 2-1 TM 9-4520-260-13 TECHNICAL MANUAL OPERATOR S, UNIT, AND DIRECT SUPPORT MAINTENANCE MANUAL OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES 2-4 OPERTOR MAINTENANCE INSTRUCTIONS
More informationTABLE OF CONTENTS. NOTE: Read the entire instruction manual before starting the installation. TROUBLESHOOTING... 13
R 410A Duct Free Split System Air Conditioner and Heat Pump Product Family: DFS4(A/H) System, DFC4(A/H)3 Outdoor, DFF4(A/H)H Indoor NOTE: Read the entire instruction manual before starting the installation.
More informationUser Manual. Commercial School Milk Cooler User s Manual. Commercial School Milk Coolers: MC34, MC49, MC58
Commercial School Milk Cooler User s Manual Commercial School Milk Coolers: MC34, MC49, MC58 12/2015 Please read the manual thoroughly prior to equipment set-up, operation and maintenance. - 1 - Exploded
More informationRSES SERVICE APPLICATION MANUAL TABLE OF CONTENTS AUGUST 2016
This Table of Contents lists the complete contents of the RSES s (SAM) issued to date. Section 1 Refrigeration 620-05 Principles of Refrigeration Part 1 620-06 Principles of Refrigeration Part 2 620-67
More informationRefrigeration Training System
3401-20 Refrigeration Training System LabVolt Series Datasheet Festo Didactic en 120 V - 60 Hz 04/2018 Table of Contents General Description 2 Topic Coverage 2 Features & Benefits 2 List of Manuals 3 Table
More informationHVAC Basics RESIDENTIAL AIR CONDITIONING
HVAC Basics RESIDENTIAL AIR CONDITIONING Introduction This Instructor s Guide provides information to help you get the most out of Residential Air Conditioning, part of the two-part series HVAC Basics.
More informationWMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS
WMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS **WARNING TO INSTALLER, SERVICE PERSONNEL AND OWNER** Altering the product or replacing parts with non authorized factory parts voids all warranty
More informationICE AIR LLC. Draw1 REV. - PERFORMANCE DATA 117/133 COOLING CAPACITY CORRECTION FACTORS HEATING CAPACITY CORRECTION FACTORS
0 ICE AIR LLC HARTFORD AVENUE, MOUNT VERNON, NY 10553 WEBSITE: http://www.ice-air.com TEL: (914) 668-4700; FAX: (914)668-5643 Draw1 REV. - 117/133 SENS HEAT RATIO, % TOTAL COOL CAP; % 120 110 COOLING CAPACITY
More informationREPLACEMENT PARTS MANUAL
REPLACEMENT PARTS MANUAL WALL-MOUNTED SASO CERTIFIED AIR CONDITIONER Models: KA-N KA-N K0A-N General Notes Revised and/or additional pages may be issued from time to time. A complete and current manual
More informationPROAIR Air Conditioner. CR43 Model INSTRUCTION MANUAL nvent Rev. H P/N
PROAIR Air Conditioner CR43 Model INSTRUCTION MANUAL Rev. H P/N 10-1008-130 TABLE OF CONTENTS Warranty and Return Policy...2 RECEIVING THE AIR CONDITIONER...3 HANDLING AND TESTING THE AIR CONDITIONER...3
More informationField Start-Up Sheet Direct Fired Gas Equipment
Customer: Sales Representative: Model Number: Serial Number: Field Start-Up Sheet Direct Fired Gas Equipment ***Please Print*** INITIAL INSPECTION I. Installer Responsibilities 1. Remote Panel: All interconnecting
More informationThis parts list is current as of the above revision date. See for the current revision.
Parts List Form No. 92-42800- This parts list is current as of the above revision date. See http://www.rheempartslists.net/92-42800-.pdf for the current revision. Package ir Conditioners Table of Contents
More informationinstallation and start-up instructions HUMIDIFIERS AND HUMIDISTAT
installation and start-up instructions HUMIDIFIERS AND HUMIDISTAT HUM Cancels: II 912D-56-3 II HUM-56-1 7-98 MODEL HUMBBLFP1025-A-- FAN-POWERED HUMIDIFIER MODEL HUMBBLBP2018-A-- BYPASS HUMIDIFIER MODEL
More informationUNIT PANELS 6/25/2014 9:02:04 AM Page 2 of 23
AC126 1 UNIT PANELS 2 REFRIGERANT SYSTEM AIR COOLED 3 REFRIGERANT SYSTEM WATER COOLED 4 WATER SYSTEM - SMALL CUBE 5 WATER SYSTEM - MEDIUM CUBE 6 WATER SYSTEM - LARGE CUBE 7 CONTROL BOX AND P.C. BOARD -
More informationHeater and Air Conditioner, R 134a Systems 83.03
Heater and Air Conditioner, R 4a Systems 8.0 WARNING R 4a is the only refrigerant that is approved for use on Freightliner LLC vehicles. Several companies offer less expensive, hydrocarbonbased refrigerants,
More informationSERVICE MANUAL PORTABLE AIR CONDITIONER PAC-10000DB NEW WIDETECH V 50Hz
IDETECH R NE IDETECH SERVICE MANUAL PORTABLE AIR CONDITIONER PAC-0000DB Important points on service, and flow chart for inspecting and repairing the unit... Appearance(out ward)... Troubleshooting... 3
More informationRED DOT UNITS HEATER-A/C. Heater/Air Conditioner/Defroster Unit OFF-ROAD CONSTRUCTION INDUSTRIAL OPTIONS. Shown with optional louvers
RED DOT UNITS R-1630 Heater/Air Conditioner/Defroster Unit OFF-ROAD CONSTRUCTION INDUSTRIAL The R-1630 combines powerful heating and cooling with the compact profile you need for tight spaces. It easily
More informationCONTAINERIZED SELF SERVICE LAUNDRY (CSSL) MODEL B NSN
OPERATOR S, UNIT AND DIRECT SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) CONTAINERIZED SELF SERVICE LAUNDRY (CSSL) MODEL B NSN 3510-01-485-0457 DISTRIBUTION STATEMENT A: Approved
More informationTECHNICAL SPECIFICATIONS
TECHNICAL SPECIFICATIONS Model PSA4BI Series M1200 Product Line R-410A Ultra High Efficiency Air Conditioner 24.5 SEER 2-3-4 Ton 2 M1200 12 YEAR ALL PARTS LIMITED WARRANTY M1200 WITH UPGRADED WARRANTY
More informationFigure 17-1 Residential air conditioner (Image courtesy of Bryant Heating & Cooling Systems)
Figure 17-1 Residential air conditioner (Image courtesy of Bryant Heating & Cooling Systems) Figure 17-2 Commercial refrigeration Unit Figure 17-3 Industrial process chiller Figure 17-4 Basic refrigeration
More information1.03 RELATED SECTIONS: The following sections contain requirements that relate to this section.
SECTION 15855 GAS FURNACE/DX COOLING UNIT PART 1 - GENERAL 1.01 RELATED DOCUMENTS A. Drawings and general provisions of contract including General and Supplementary Conditions of Division 1 of Specification
More informationTABLE OF CONTENTS CHAPTER TITLE PAGE DECLARATION DEDICATION ACKNOWLEDGEMENTS ABSTRACT ABSTRAK
vii TABLE OF CONTENTS CHAPTER TITLE PAGE DECLARATION DEDICATION ACKNOWLEDGEMENTS ABSTRACT ABSTRAK TABLE OF CONTENTS LIST OF FIGURES LIST OF TABLES LIST OF ACROYMS LIST OF APPENDIXES ii iii iv v vi vii
More information