Home Stacked Washer/Dryer

Transcription

1 Home Stacked Washer/Dryer Refer to Page 3 for Model Numbers Parts SWD443C_ Part No R6 August 2014

2

3 Table of Contents Title Page Parts Ordering Information... 2 Serial Plate Location... 2 Model Identification... 3 Control Cabinet and Controls... 4 Washer Front Panel, Door Assembly and Door Seal... 6 Dispenser Assembly... 8 Mixing Valve, Valve-to-Dispenser Inlet Hose and Fill Hose Outer Tub, Front and Clamp Ring Inner Basket, Trunnion, Bearing Housing and Pulley Washer Motor and Belt Drain Hose and Pump Washer Base, Panels and Rear Panel Washer Lead-In Cord, Wire Ties and Clips Dryer Loading Door Dryer Access Panel, Front Panel and Seal Dryer Motor, Blower Fan and Belt Front Bulkhead, Air Duct, Felt Seal and Cylinder Rear Bulkhead, Felt Seal, Cylinder Roller and Terminal Block Heater Duct and Element Assembly Heater Duct Assembly Gas Valve, Igniter and Gas Conversion Kits Dryer Cabinet, Exhaust Duct and Base Dryer Lead-In Cord Dryer Motor Connection Block, Terminal Extractor Tools Shipping Materials Special Tools Labels Wire Harnesses and Wires Parts Index Copyright 2014, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher

4 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. Parts Ordering Information For technical assistance, call either of the numbers listed below: (920) Ripon, Wisconsin Wevelgem, Belgium When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate(s) as shown. Serial Plate Location Serial Plate SWD1134P_

5 Model Identification Information in this manual is applicable to these stacked washer/dryer models: CTS97AWN CTS97AWN1500 CTS99AWN

6 Control Cabinet and Controls SWD1226P_

7 Control Cabinet and Controls REF PART NO. DESCRIPTION COMMENTS Control Shield Uses service door Control Shield No service door Screw Control Access Door P Transformer P Pressure Switch 6 M Snap Bushing P Control Assembly Screw Screw Rear Control Cabinet W Right Control Cabinet Side Expansion Clip Screw Temperature Switch Washer Fabric Selector Switch Dryer Resistor Assembly Use with Timer; Models CTS97AWN and CTS97AWN P Timer and Harness Kit Models CTS97AWN and CTS97AWN P Timer Model CTS99AWN Control Cabinet Bottom Screw W Timer Knob Assembly W Knob Assembly W Rocker Switch Extra rinse W Push-to-Start Switch Graphic Overlay W Control Panel Assembly Light Cycle Switch Washer Nut WP Left Control Cabinet Side Hose Clip

8 Washer Front Panel, Door Assembly and Door Seal S WD1154P_

9 Washer Front Panel, Door Assembly and Door Seal REF PART NO. DESCRIPTION COMMENTS W Outer Door Bezel P Door Glass Nut Inner Door Bezel Locking Catch Screw Screw Screw Door Hinge Nut Hold-Down Clip Panel Locator Screw Door Latch/Switch Assembly Hinge Plate Wire Clamp Ring P Door Seal Clamp Seal to outer tub front P Door Seal and Hose Assembly Kit Black P Door Seal and Hose Assembly Kit Gray Harness Strap Hose Clamp Extension Spring Nut Screw Access Panel Damper Screw WP Access Panel Assembly WP Front Panel Door Switch WP Door Assembly Includes items

10 Dispenser Assembly FLW820P_

11 Dispenser Assembly REF PART NO. DESCRIPTION COMMENTS P Door Seal and Hose Assembly Kit Black Door Seal and Hose Assembly Gray Wire Clip Harness Strap Hose Clamp Valve-to-Dispenser Inlet Hose Backflow Preventer P Valve Kit Dispenser-to-Tub Hose Hose Clamp 10 F Hose Clamp Cap P Dispenser P Dispenser Assembly P Dispenser Drawer Screw WP Dispenser Drawer Front Insert Detergent Cover Dispenser Plate Screw

12 Mixing Valve, Valve-to-Dispenser Inlet Hose and Fill Hose FLW881P_

13 Mixing Valve, Valve-to-Dispenser Inlet Hose and Fill Hose REF PART NO. DESCRIPTION COMMENTS Hose Clamp Valve-to-Dispenser Inlet Hose Backflow Preventer Mixing Valve Plate Screw Washer Washer Filter screen Washer Flow restrictor; Water pressure reducer; Available for water pressure up to but not exceeding 120 psi 8 F Water Hose 4 feet; Includes 2 of item Fill Hose 8 feet Fill Hose 10 feet Screw Mixing Valve Screen P Mixing Valve

14 Outer Tub, Front and Clamp Ring SWD1151P_

15 Outer Tub, Front and Clamp Ring REF PART NO. DESCRIPTION COMMENTS 1 F Nut Washer Screw Screw Out-of-Balance Switch Assembly Wire Clamp 7 M Washer Screw Switch Mounting Bracket Nut Warning Label Grommet Pressure Bulb P Tubing Hose Clamp P Outer Tub Assembly P Tub Shock Absorber Kit Upper P Base Shock Absorber Kit Lower Grounding Clip Ballast Weight Tub Front Assembly P Tub Front Seal Clamp Ring

16 Inner Basket, Trunnion, Bearing Housing and Pulley FLW865P_

17 Inner Basket, Trunnion, Bearing Housing and Pulley REF PART NO. DESCRIPTION COMMENTS NA 27604P Anti-Seize Compound Pulley to inner basket shaft NA 838P3 Hardware Kit Includes (8) of item 6, (7) each of items 7 and 13, (6) of item 10, (1) each of items 12, 14, 17, 18 and 27604P Anti-Seize Compound Tension Rod Assembly P Inner Basket Assembly Includes (3) each of items 1, 5, 6, and 838P3 Hardware Kit P Trunnion Shaft and Hardware Kit Includes (3) each of items 1, 5, 6, and 838P3 Hardware Kit P Inner Basket Assembly Includes items 2, 3, (3) each of items 1, 5, 6, and 838P3 Hardware Kit Nut Washer Nut Hose Mounting Plate Hose Clip Pop Rivet Driven Pulley Screw Left hand thread 13 M Washer Washer 15 M Screw P Bearing Housing Kit Includes 838P3 Hardware Kit P Tub Front Seal Screw

18 Washer Motor and Belt FLW967P_

19 Washer Motor and Belt REF PART NO. DESCRIPTION COMMENTS Screw P Inverter Control Assembly Control Shield Screw P Inverter Assembly Kit Includes items 2-4, Motor Harness Assembly and wire ties Fuse Use for inverter control 7 M Screw Washer 9 M Washer P Drive Belt P Motor and Rod Assembly Kit Includes 2 each of items and Motor Harness Assembly and wire ties Retaining Ring Washer Motor Mount Rod

20 Drain Hose and Pump FLW916P_

21 Drain Hose and Pump REF PART NO. DESCRIPTION COMMENTS Drain Hose Sleeve Standpipe Strap Retainer Clip Drain Hose Strain Relief Backflow Preventer Hose Clamp Screw Metric; Use with Drain Pump Screw Use with Drain Pump Washer Use with and Drain Pump Grommet Use with and Drain Pump Pump Bracket Use with and Drain Pump Pump Mount Bracket Use with Drain Pump Screw Screw Use with and Drain Pump Pump Mount Use with Drain Pump 15 F Hose Clamp Use with Drain Pump Nozzle Cap Use with Drain Pump Pump Shield Use with Drain Pump Screw Use with and Drain Pump O-Ring Use with Drain Pump P O-Ring Use with and Drain Pump Pump Housing Use with Drain Pump Pump Housing Use with and Drain Pump O-Ring Use with Drain Pump Gasket Use with and Drain Pump P Drain Pump Includes pump mount bracket Pump Housing Assembly Includes items 20, 21 and 24; Use with Drain Pump P Pump Housing Assembly Includes items 20, 21 and 24; Use with and Drain Pump P Lid Assembly Includes filter; Use with Drain Pump P Lid Assembly Includes filter; Use with and Drain Pump Tub-to-Pump Hose P Sealant Tub-to-pump hose to outer tub

22 Washer Base, Panels and Rear Panel SWD1207P_

23 Washer Base, Panels and Rear Panel REF PART NO. DESCRIPTION COMMENTS NA 122P4P Porcelain Touch-Up Paint Bumper Pad Panel Locator Screw WP Cabinet Panel Kit Left panel; Includes corner gusset with hardware Screw P Rear Panel Screw Label Left hand thread 8 M Hole Plug Rear Access Panel Motor Access Hole Edging WP Side Panel Kit Right panel; Includes Dispenser Plate with hardware Screw Cabinet Brace Right Rubber Foot P3 Anchor Includes 4 rubber discs with adhesive backing Leveling Leg Nut Base Assembly Cabinet Brace Left P3 Brace Kit Includes items 12, 13 and

24 Washer Lead-In Cord, Wire Ties and Clips FLW823P_

25 Washer Lead-In Cord, Wire Ties and Clips REF PART NO. DESCRIPTION COMMENTS Wire Tie Push mount Harness Strap Hose Clip Wire Clip Small Wire Clip Large Nut Washer Screw Strain Relief Lead-In Cord

26 Dryer Loading Door D427P_

27 Dryer Loading Door REF PART NO. DESCRIPTION COMMENTS WP Dryer Door Door Handle Wedge P Dryer Door Window Door Strike Mount Door Strike Screw P Liner Door Seal W Door Liner Grill W Liner and Seal Assembly Includes item Screw Screw Hinge W Window Trim WP Door Pull and Wedge Kit Includes item WP Door and Liner Assembly Includes items 1-10, 13 and

28 Dryer Access Panel, Front Panel and Seal S WD648P_

29 Dryer Access Panel, Front Panel and Seal REF PART NO. DESCRIPTION COMMENTS Speed Clip Switch Front Panel Seal WP Front Panel Screw Screw WP Access Panel Assembly Panel Locator Screw Door Catch Assembly Warning/Caution Label Hinge Hole Plug

30 Dryer Motor, Blower Fan and Belt SWD1227P_

31 Dryer Motor, Blower Fan and Belt REF PART NO. DESCRIPTION COMMENTS P Blower Housing Seal Screw WP Blower Housing P Motor and Pulley Assembly 120 Volt/60 Hertz; Includes items 6, 8 and Motor Mount Clamp 6 N/A Motor Switch Kit Does not include thermal protector P Cylinder Belt Motor Pulley 9 590P3 Motor Hub Ring Kit Screw P Blower Fan Assembly Idler Spring Nut Idler Lever P Shaft Washer P Idler Wheel and Bearing Assembly Retaining Ring Screw Idler Lever and Wheel Assembly Includes items Nut Motor Mount Thermostat Models CTS97AWN and CTS97AWN P Thermostat Model CTS99AWN Screw P Blower and Fan Kit Includes items 1-6 and 8-22 N/A = Part no longer available

32 Front Bulkhead, Air Duct, Felt Seal and Cylinder SWD1228P_

33 Front Bulkhead, Air Duct, Felt Seal and Cylinder REF PART NO. DESCRIPTION COMMENTS P Front Bulkhead Assembly Includes item P Cylinder Seal Assembly P Adhesive Use for cylinder seal W Cylinder Baffle WP Cylinder Assembly Includes item Screw Cylinder Glide Cylinder Glide Bracket Screw Screw W Lint Filter Cover Screw Air Duct Assembly Fuse Notice Label W Lint Filter Screw Felt Pad

34 Rear Bulkhead, Felt Seal, Cylinder Roller and Terminal Block D403P_

35 Rear Bulkhead, Felt Seal, Cylinder Roller and Terminal Block REF PART NO. DESCRIPTION COMMENTS P Cylinder Seal Assembly P Adhesive Use for cylinder seal Screw P Rear Bulkhead Assembly Includes item Screw Use with item 5; Models CTS97AWN and CTS97AWN Terminal Block Shield Models CTS97AWN and CTS97AWN P Terminal Block Assembly Includes 3 of item 7; Models CTS97AWN and CTS97AWN Screw Cylinder Roller Bracket P Cylinder Roller Nut P Shaft Washer Washer Retaining Ring

36 Heater Duct and Element Assembly Models CTS97AWN and CTS97AWN1500 DRY1789P_

37 Heater Duct and Element Assembly REF PART NO. DESCRIPTION COMMENTS Screw Outlet Cover P Heater Duct and Screw Assembly Includes items 1 and Wire Assembly Orange; Thermostat jumper; Attaches to heater assembly Wire Assembly Black; Fuse jumper; Attaches to heater assembly Thermal Fuse Assembly Screw Limit Thermostat P Heater Assembly Model CTS97AWN; 5350 Watt; 240 Volt/60 Hertz Heater Kit Assembly Model CTS97AWN; 4750 Watt; 208 Volt/60 Hertz P Heater Model CTS97AWN1500; 4750 Watt; 208 Volt/60 Hertz

38 Heater Duct Assembly Model CTS99AWN D315P_

39 Heater Duct Assembly REF PART NO. DESCRIPTION COMMENTS Screw Heat Duct Shroud Outlet Cover P Heater Duct and Screw Assembly Includes items 1 and Combustion Duct Screw Limit Thermostat Color code black

40 Gas Valve, Igniter and Gas Conversion Kits Model CTS99AWN L.P. N.G. SWD1225P_

41 Gas Valve, Igniter and Gas Conversion Kits REF PART NO. DESCRIPTION COMMENTS Lead-In Pipe Assembly Screw P Igniter and Bracket Assembly Screw Sensor Screw P Burner Assembly 8 649P3 L.P. Conversion Kit Used to convert dryers from Natural Gas (N.G.) or Mixed Gas to Liquid Petroleum Gas (L.P.); 22,500 Btu 9 650P3 N.G. Conversion Kit Used to convert dryers from L.P. to N.G. or Mixed Gas; 22,500 Btu B Secondary Coil P Gas Valve Assembly 60 Hertz; 22,500 Btu; Includes items 8 and Screw Gas Valve Mounting Bracket A Booster and Holding Coil Elbow Shut-Off Valve

42 Dryer Cabinet, Exhaust Duct and Base SWD1229P_

43 Dryer Cabinet, Exhaust Duct and Base REF PART NO. DESCRIPTION COMMENTS NA 122P4P Porcelain Touch-Up Paint Screw Bracket WP Top Kit Screw Top Hinge P Cabinet Rear Panel Access Panel Plate 8 521P3 Flexible Venting Kit Exhaust Duct Each dryer requires 2 pieces WP Cabinet Side Panel Right P3 Directional Exhaust Kit Used to vent dryer out the sides Leveling Leg Dryer Base Washer Screw WP Cabinet Side Panel Left P3W Panel Kit Replaces the 1 piece wrap-around cabinet; Includes items 6, 10, 16 and the necessary attaching hardware Panel Locator Screw Bumper Pad

44 Dryer Lead-In Cord Model CTS99AWN SWD1237P_

45 Dryer Lead-In Cord REF PART NO. DESCRIPTION COMMENTS Screw Strain Relief Lead-In Cord

46 Dryer Motor Connection Block, Terminal Extractor Tools DRY1767P_

47 Dryer Motor Connection Block, Terminal Extractor Tools REF PART NO. DESCRIPTION COMMENTS Position Housing Molex; 10 circuit Female Terminal 1/4 inch; For (1) 12 gauge wire; Models CTS97AWN and CTS97AWN Female Terminal 1/4 inch; For (1) or (2) 18 gauge wires; Model CTS99AWN Female Terminal For 1 or 2 wire applications 4 283P4 Terminal Extractor Tool For use on Molex connectors 5 190P4 Extractor Tool For use on electric dryer terminals; Models CTS97AWN and CTS97AWN P4 Extractor Tool For use on gas dryer terminals; Model CTS99AWN

48 Shipping Materials FLW845P_

49 Shipping Materials REF PART NO. DESCRIPTION COMMENTS 1 M Screw 2 M Washer Shipping Bracket P Shipping Cord and Brace Assembly Warning Label Non-grounded Warning Label 7 728P3 Shipping Materials Kit Includes items 1-4 and Shipping Bracket Label

50 Special Tools FLW1660P_

51 Special Tools REF PART NO. DESCRIPTION COMMENTS 1 318P4 Dispenser Drawer Tool Use to remove dispenser drawer Pulley Bolt Tightening Fixture Use to install inner basket 3 392P4 Wrench Use to adjust leveling legs

52 Labels SWD1156P_

53 Labels REF PART NO. DESCRIPTION COMMENTS Door Locked Label Oversudsing Label Disconnect Power Warning Label Venting Instruction Label Exhaust Warning Label Warning Label

54 Wire Harnesses and Wires SWD1161P_

55 Wire Harnesses and Wires REF PART NO. DESCRIPTION COMMENTS NA Gauge Wire Black; Order wire by foot and terminals as required NA Gauge Wire Orange; Order wire by foot and terminals as required P Control Panel Harness Assembly P Upper Harness Assembly Models CTS97AWN and CTS97AWN P Upper Harness Assembly Model CTS99AWN P Control Harness Assembly P Motor Harness Assembly P Base Harness Assembly P Security Cabinet Harness Models CTS97AWN and CTS97AWN Security Cabinet Harness Assembly Model CTS99AWN NOTE: Individual wires are not available separately. Order complete harness, or order wire by the foot. When applying terminals to wires, it is recommended that the terminals be soldered to the wires

56 Notes

57 Parts Index A Access Panel Assembly WP... 7, 27 Access Panel Damper Access Panel Plate Adhesive P... 31, 33 Air Duct Assembly Anchor 155P Anti-Seize Compound 27604P B Backflow Preventer , Ballast Weight Base Assembly Base Harness Assembly P Base Shock Absorber Kit P Bearing Housing Kit P Blower and Fan Kit P Blower Fan Assembly P Blower Housing WP Blower Housing Seal P Booster and Holding Coil 58804A Brace Kit 918P Bracket Bumper Pad , 41 Burner Assembly P C Cabinet Brace Cabinet Panel Kit WP...21 Cabinet Rear Panel P...41 Cabinet Side Panel WP WP...41 Cap Clamp Ring Combustion Duct Control Access Door Control Assembly P...5 Control Cabinet Bottom Control Harness Assembly P...53 Control Panel Assembly W...5 Control Panel Harness Assembly P...53 Control Shield Cycle Switch Cylinder Assembly WP...31 Cylinder Baffle W...31 Cylinder Belt P...29 Cylinder Glide Cylinder Glide Bracket Cylinder Roller P...33 Cylinder Roller Bracket Cylinder Seal Assembly P...31, 33 D Detergent Cover Directional Exhaust Kit 528P Disconnect Power Warning Label Dispenser P...9 N/A items do not appear in index

58 Dispenser Assembly P... 9 Dispenser Drawer P... 9 Dispenser Drawer Front WP... 9 Dispenser Drawer Tool 318P Dispenser Plate Dispenser-to-Tub Hose Door and Liner Assembly WP Door Assembly WP... 7 Door Catch Assembly Door Glass P... 7 Door Handle Wedge Door Hinge Door Latch/Switch Assembly Door Liner Grill W Door Locked Label Door Pull and Wedge Kit WP Door Seal and Hose Assembly Door Seal and Hose Assembly Kit P... 7, P... 7 Door Seal Clamp P... 7 Door Strike Door Strike Mount Door Switch Drain Hose Drain Hose Sleeve Drain Pump P Drive Belt P Driven Pulley Dryer Base Dryer Door WP Dryer Door Window P E Elbow Shut-Off Valve Exhaust Duct Exhaust Warning Label Expansion Clip Extension Spring Extractor Tool 128P P F Fabric Selector Switch Felt Pad Female Terminal Fill Hose Flexible Venting Kit 521P Front Bulkhead Assembly P...31 Front Panel WP WP...7 Front Panel Seal Fuse Fuse Notice Label G Gas Valve Assembly P...39 Gas Valve Mounting Bracket Gasket Graphic Overlay Grommet Grounding Clip N/A items do not appear in index

59 H Hardware Kit 838P Harness Strap , 9, 23 Heat Duct Shroud Heater P Heater Assembly P Heater Duct and Screw Assembly P... 35, 37 Heater Kit Assembly Hinge Hinge Hole Plug Hinge Plate Hold-Down Clip Hole Plug M Hose Clamp F , , 11 Hose Clip , Hose Mounting Plate Housing, 10 Position Inverter Control Assembly P...17 K Knob Assembly 36701W...5 L Lead-In Cord Lead-In Pipe Assembly Left Control Cabinet Side WP...5 Leveling Leg Lid Assembly P P...19 Light Limit Thermostat Liner and Seal Assembly W...25 Liner Door Seal P...25 Lint Filter W...31 Lint Filter Cover W...31 Locking Catch L.P. Conversion Kit 649P I Idler Lever Idler Lever and Wheel Assembly Idler Spring Idler Wheel and Bearing Assembly P Igniter and Bracket Assembly P Inner Basket Assembly P P Inner Door Bezel Insert Inverter Assembly Kit P N/A items do not appear in index M Mixing Valve P...11 Mixing Valve Plate Mixing Valve Screen Motor Access Hole Edging Motor and Pulley Assembly P...29 Motor and Rod Assembly Kit P...17 Motor Harness Assembly P...53 Motor Hub Ring Kit 590P3...29

60 Motor Mount Motor Mount Clamp Motor Mount Rod Motor Pulley N Nozzle Cap Nut F , , N.G. Conversion Kit 650P O O-Ring P Outer Door Bezel W... 7 Outer Tub Assembly P Outlet Cover , 37 Out-of-Balance Switch Assembly Oversudsing Label P Panel Kit 727P3W Panel Locator , 21, 27, 41 Pop Rivet Porcelain Touch-Up Paint 122P4P... 21, 41 Pressure Bulb Pressure Switch P... 5 Pulley Bolt Tightening Fixture Pump Bracket Pump Housing Pump Housing Assembly P...19 Pump Mount Pump Mount Bracket Pump Shield Push-to-Start Switch W...5 N/A items do not appear in index R Rear Access Panel Rear Bulkhead Assembly P...33 Rear Control Cabinet Rear Panel P...21 Resistor Assembly Retainer Clip Retaining Ring , 29, 33 Right Control Cabinet Side W...5 Rocker Switch 38424W...5 Rubber Foot S Screw M , 47 M , 35, , 21, 27, , , 31, , , 7, 11, 13, 17, 19, 21, , 29, 31, 33, 35, 37, 39, ,

61 , , , Screw Label Sealant 27615P Secondary Coil 58804B Security Cabinet Harness P Security Cabinet Harness Assembly Sensor Shaft 56461P... 29, 33 Shipping Bracket Shipping Bracket Label Shipping Cord and Brace Assembly P Shipping Materials Kit 728P Side Panel Kit WP Snap Bushing M Speed Clip Standpipe Strap Strain Relief , 43 Switch Switch Mounting Bracket T Temperature Switch Tension Rod Assembly Terminal Block Assembly P Terminal Block Shield Terminal Extractor Tool 283P Thermal Fuse Assembly Thermostat P...29 Timer P...5 Timer and Harness Kit P...5 Timer Knob Assembly W...5 Top Hinge Top Kit WP...41 Transformer P...5 Trunnion Shaft and Hardware Kit P...15 Tub Front Assembly Tub Front Seal P...13, 15 Tub Shock Absorber Kit P...13 Tubing P...13 Tub-to-Pump Hose U Upper Harness Assembly P P...53 V Valve Kit P...9 Valve-to-Dispenser Inlet Hose , 11 Venting Instruction Label W Warning Label , 47, Warning/Caution Label Washer M M M N/A items do not appear in index

62 M , 29, , Water Hose F Window Trim W Wire Assembly Wire Clamp Wire Clamp Ring Wire Clip , 23 Wire Tie Wire, 12 Gauge Wire, 18 Gauge Wrench 392P N/A items do not appear in index