ACR4 REFRIGERANT MACHINE MAINTENANCE
|
|
- Barnard Brown
- 6 years ago
- Views:
Transcription
1 Classification: Reference: Date: HA NTB March 13, 2000 ACR4 REFRIGERANT MACHINE MAINTENANCE APPLIED VEHICLES: All Nissan Vehicles with R-134a Air Conditioning SERVICE INFORMATION To ensure accurate air conditioning system diagnosis and repair, it is critical that periodic maintenance be performed on your refrigerant charging equipment (ACR4 machine) and that proper operating techniques be used. Additionally, as refrigerant charge amounts continue to become smaller, it is vital that your refrigerant charging equipment be as accurate as possible. SERVICE PROCEDURE Use the information listed under the Maintenance section of this bulletin to tune-up your ACR4 machine to keep it operating at top performance. Refer to information listed under Operational Tips to ensure the highest level of charging accuracy when using the ACR4 machine. IMPORTANT: ACR4 maintenance should be conducted following the manufacture s instructions and recommended schedule. For details about performing ACR4 maintenance, refer to the ACR4 Operating Instruction Manual (Tech-Mate P/N J ). Additional information related to ACR4 maintenance and operation is available in the May 1998 edition of Tech Talk and SIR video #57. The ACR4 Operating Instruction Manual can be ordered from Tech-Mate by calling NOTE: A maintenance kit is available for the ACR4 machine through Tech-Mate (P/N J MAINT). The kit includes: vacuum pump oil, a desiccant/filter and two o-rings (for the desiccant/filter). The ACR4 Maintenance Kit can be ordered from Tech-Mate by calling /5
2 Maintenance Vacuum Pump Oil Change the vacuum pump oil every 10 hours of operation (when display reads OIL ) or sooner if contamination is seen through the sight glass (see Figure 1). Filter/Dryer Figure 1 Change the filter/dryer (see Figure 2) when 300lbs of refrigerant (approximately 150 cars) has been recovered (display reads CH-F ) or sooner if the moisture indicator does not turn green during recycling. Figure 2 ACR4 Leak Check Check the ACR4 for leaks every 3 months or as specified by state or local laws. Weight Scale Platform Securing Screw Make sure the weight scale platform securing screw is properly tightened. 2/5
3 Weight Scale Accuracy Check the weight scale accuracy at a minimum of every 3 months (or sooner if the scale is suspected to be inaccurate). Use the following procedure to check the scale accuracy. 1. Simultaneously press the SHIFT/RESET and ENTER buttons to get into the diagnostic mode (see Figure 3). Figure 3 2. Press 6 on the key pad to display the approximate scale platform weight 3. Remove the tank from the weight scale platform (see Figure 4). Figure 4 4. With the weight scale platform empty, the display should read close to zero lbs. If the reading is too low or too high, perform the scale calibration procedure listed below. 3/5
4 Weight Scale Calibration Check the weight scale calibration at a minimum of every 3 months (or sooner if the scale is suspected to be inaccurate). Use the following procedure to calibrate the weight scale. 1. Simultaneously press the SHIFT/RESET and ENTER buttons to get into the diagnostic mode. 2. Press The display will read A1. 3. Remove all weight from the scale. 4. Press 0, then press ENTER. The display will show 0.00 and then changes to A2. 5. Place a certified known weight (between 10 to 80 lbs) in the center of the scale platform. NOTE: A certified 10 lb weight is available from Tech-Mate (P/N J-42363). This item can be ordered from Tech-Mate by calling Enter the weight using four digits (i.e., for lbs). 7. Press ENTER. The display will return to vacuum mode. 8. Simultaneously press the SHIFT/RESET and ENTER buttons. 9. Press 6. The display will show the weight on the scale platform. 10. Remove the weight from the scale platform. The display will return to Press the SHIFT/RESET button only (not ENTER ) to return to the program mode. NOTE: If the scale cannot be calibrated or another malfunction exists, call the SPX Robinair ACR4 Help Line at or contact another qualified facility for repair. Tank Certification The tank must be certified on the First Retest Date (stamped into the top of the tank handle) and every 5 years after the First Retest Date. This is according to DOT-4BA-400. NOTE: A qualified welding supply, fire extinguisher maintenance or refrigerant company can perform the certification. Operational Tips Tank Position Make sure the tank is properly positioned/seated (especially after moving the ACR4 machine) on the scale platform and that it does not touch surrounding components (such as the back bar, hoses, etc.). Also, make sure the weight scale platform securing screw is properly tightened. Residual Refrigerant Recover all residual refrigerant from the hoses before connection to the vehicle. Residual Refrigerant Oil Drain all refrigerant oil from the oil separator (see Figure 4) before recovering refrigerant. This prepares the oil separator to measure the amount of oil removed during the recovery process. 4/5
5 Disturbing the ACR4 Machine Do not disturb or touch the ACR4 machine when it is recovering or recharging as this will upset the weight scale and cause the machine to record an inaccurate recovery amount and/or dispence an incorrect charge. Transfer All Refrigerant to Vehicle Use the following steps to ensure all of the refrigerant charge is transferred to the vehicle s A/C system. 1. When the display shows CPL (charge is complete), close the control panel high side valve (both control panel high and low side valves should now be closed). 2. Start the vehicle and let the A/C run until the gauge readings stabilize. Check for cold air at the vents. 3. With the compressor running, close the high side (red) coupler valve (on the end of the high side hose) and disconnect it from the vehicle. 4. Open the control panel high and low side valves. This will allow the residual refrigerant to be drawn into the vehicle s A/C system through the low (blue) hose. 5. Close the low side (blue) coupler valve (on the end of the low side hose) and disconnect it from the vehicle. NOTE: If your dealership purchases R134a in small, disposable (12 oz) cans, do not charge the vehicle s A/C system with the can directly. Transfer the refrigerant from the small can to the ACR4 refrigerant tank (see page 17 of the ACR4 Operating Instruction Manual). Charging the A/C system directly from the 12 oz refrigerant can (using a can tap gauge set) will not properly control the weight of refrigerant being transferred. This will result in an overcharge or undercharge condition and improper A/C performance. 5/5
WORKSHEET 4-4 (ON-CAR) HFC-134a Recovery
WORKSHEET 4-4 (ON-CAR) HFC-134a Recovery TOYOTA AIR CONDITIONING AND CLIMATE CONTROL Vehicle: Year/Prod. Date: Engine: Transmission: Worksheet Objectives: Given this worksheet, a Toyota vehicle, a Vehicle
More informationSERVICE PROCEDURE FOR RETROFITTED A/C SYSTEMS
Classification: Reference: Date: HA94-005 NTB94-091 September 26, 1994 SERVICE PROCEDURE FOR RETROFITTED A/C SYSTEMS APPLIED VEHICLE(S): All models except Quest equipped with a retrofitted A/C system SERVICE
More informationOperating Manual Manual de Operación Manuel d utilisation
Operating Manual Manual de Operación Manuel d utilisation Model 17800B/17801B Recovery/Recycling/Recharging Unit for Multiple Refrigerants... 1 Modelo 17800B/17801B Unidad de recuperación/reciclado/recarga
More informationOperating Manual. Series 12134B Recovery/Recycling/Recharging Unit for R-12 and R-134a
Operating Manual Series 12134B Recovery/Recycling/Recharging Unit for R-12 and R-134a LISTED 80S2 Design Certified by Underwriters Laboratories Inc., to meet SAE J1770 for recycling R-12 and R-134a using
More informationService Manual. Models 17700/17701/17703 Recovery/Recycling/Recharging Unit For R-12 Only
Service Manual Models 17700/17701/17703 Recovery/Recycling/Recharging Unit For R-12 Only Theory of Operation and Safety Precautions... 2 Component Descriptions... 3 Plumbing Diagram... 8 Pictorial Views...
More informationRefrigerant Recovery Machine. Model No Operating Manual
Refrigerant Recovery Machine Model No. 25700 Operating Manual Safety Precautions WARNING : TO PREVENT PERSONAL INJURY AND / OR EQUIPMENT DAMAGE, CAUTION - Risk of injury. This equipment should only be
More informationA/C Refrigerant. Air Conditioning systems use refrigerant to move heat from air inside the car to air outside the car
A/C Refrigerant Air Conditioning systems use refrigerant to move heat from air inside the car to air outside the car Refrigerants are HAZARDOUS to you and the environment Motor Vehicle Air Conditioning
More informationOPERATION & MAINTENANCE MANUAL AC860
OPERATION & MAINTENANCE MANUAL AC860 Refrigerant Handling System Manual P/N 035-80913-00 TABLE OF CONTENTS Startup & Safe Operation... 1 Introduction to the AC860... 2 Control Panel... 3 Keypad Functions...
More informationOPERATION & MAINTENANCE MANUAL RHS680
OPERATION & MAINTENANCE MANUAL RHS680 Refrigerant Handling System 4075 East Market Street York, PA 17402 800-468-2321 tech@rtitech.com Manual P/N 035-80740-00 (Rev 1- May 22, 2001) TABLE OF CONTENTS Startup
More informationHarold Ag & Mobile Products
TM Harold Ag & Mobile Products Your Ag A/C Parts Specialist 1-800-541-8910 www.heco.net R E F R I G E R A N T S 6-18-13 FR-12 COMPARED TO OTHER BLENDS UL Classified A1/A1 (non-flammable!) ASHRAE Listed
More informationSome of these procedures need to be performed to conform to requirements of the Clean Air Act.
Leak Detection, Recovery, Evacuation and Charging Four basic service procedures used to repair and maintain a mechanical refrigeration system are leak detection, evacuation, recovery, and refrigerant charging.
More informationOperation Manual... 1 Manuel d utilisation Manual de Operación.. 60
Operation Manual... 1 Manuel d utilisation... 30 Manual de Operación.. 60 SERIES: ACR2000 KENT-MOORE: J-43600 Air Conditioning and Refrigerant Service Solution WARNING Refrigerant: R134a PRESSURIZED TANK
More informationFluid Exchange. Refrigerant Handling Systems Recovery/Recycling Systems Fluid Exchangers Flushers Fluid Exchange Accessories BUYER'S GUIDE
Fluid Exchange Refrigerant Handling Systems Recovery/Recycling Systems Fluid Exchangers Flushers Fluid Exchange Accessories 423 ASCOT 424 Refrigerant Recovery/Recycling Systems Recovery and Recycling Systems
More information347002K/177002K/34900
Service Manual Models: 347002K/177002K 34900/347012K Manifold Block Style Recovery/Recycling/Recharging Unit For R-12 or R-134a Only TABLE OF CONTENTS: Theory of Operation and Safety Precautions... 2 Depressurizing
More informationModel K / K. Modelo K / K. Modèle K / K. Operating Manual
Operating Manual Model 34800-2K / 34801-2K Recovery/Recycling/Recharging Unit for R-12 and R-134a Refrigerants... English Modelo 34800-2K / 34801-2K Unidad de recuperación/reciclaje/recarga para refrigerantes
More informationENSPECO Recovery/ Recycle/ Evacuate/ Recharge
ENSPECO Recovery/ Recycle/ Evacuate/ Recharge RMS 3012 RMS 3034 Approved by UL/SAE to J-1991 R12 Purity Standards Approved by UL/SAE to J-2210 R134 Purity Standards This semi-automatic machine will recover
More information5. MVAC-like appliance include appliances using R22 refrigerant a. True b. False
1. Reductions in stratospheric ozone levels lead to higher levels of reaching the Earths surface. a. Infrared radiation b. Microwave radiation c. Ultraviolet radiation d. Visible light 2. UVB can have
More information2004 HVAC. Heating, Ventilation and Air Conditioning - Hummer H2. Fastener Tightening Specifications Specification Application
SPECIFICATIONS 2004 HVAC Heating, Ventilation and Air Conditioning - Hummer H2 FASTENER TIGHTENING SPECIFICATIONS Fastener Tightening Specifications Specification Application Metric English A/C Accumulator
More informationOperating Manual for. Model Recovery, Recycling, Recharging Unit
Operating Manual for Model 34988 Recovery, Recycling, Recharging Unit Model 34988 Recovery, Recycling, & Recharging Unit SAFETY DEFINITIONS: Follow all WARNING, CAUTION, IMPORTANT, and NOTE messages in
More informationOperating Manual. Model Refrigerant Service Solution
Operating Manual Model 342000 Refrigerant Service Solution Series: 342000 Refrigerant: R-134a Air Conditioning and Refrigerant Service Solution SAFETY DEFINITIONS: Follow all WARNING, CAUTION, IMPORTANT,
More informationAutomotive Air-Conditioning Service Equipment Ariazone 5001HD OPERATOR MANUAL Ariazone 5001HD
Automotive Air-Conditioning Service Equipment Ariazone 5001HD OPERATOR MANUAL Ariazone 5001HD - Automotive A/C Service Station 1 Contents Page 1. Introduction... 3 2. Safety firts... 4 3. Technical Features...
More informationEnspeco RMS. The Enspeco Refrigerant Management. The following instructions will INSTRUCTIONS
Enspeco AUTOMOTIVE REFRIGERANT MANAGEMENT SYSTEMS RMS 5000 INSTRUCTIONS The Enspeco Refrigerant Management System 5000 provides fast and efficient recovery, recycling and charging of automotive air conditioning
More informationOwner s Manual. Model AC375C Refrigerant Recovery, Recycle, and Recharge Unit
Owner s Manual Model AC375C Refrigerant Recovery, Recycle, and Recharge Unit Model AC375C Recover, Recycle, and Recharge Unit for R-12 or R-134a Refrigerant Voltage: 220 230; 50 60 Hz SAFETY DEFINITIONS:
More informationGENERAL 2004 HVAC SYSTEMS. Manual HVAC System - Sorento SPECIFICATIONS. Fig. 1: Air Conditioner Specifications Courtesy of KIA MOTORS AMERICA, INC.
Fig. 2: Blower & Evaporator Unit Specifications 2004 HVAC SYSTEMS Manual HVAC System - Sorento GENERAL SPECIFICATIONS AIR CONDITIONER Fig. 1: Air Conditioner Specifications BLOWER AND EVAPORATOR UNIT HEATER
More informationBest Practices for Mobile A/C Refrigerant System Service
Best Practices for Mobile A/C Refrigerant System Service Note: Refer to the vehicle manufacturer or aftermarket issued service information, the applicable SAE standards, and tool and equipment instruction
More informationOPERATING INSTRUCTIONS
OPERATING INSTRUCTIONS MODEL LV8 COMMERCIAL REFRIGERANT RECOVERY UNIT NATIONAL REFRIGERATION PRODUCTS 985 WHEELER WAY LANGHORNE, PA 19047 (215) 638-8909 FAX (215) 638-9270 A01001 7/11/96 NRP-OM-LV8 7/96
More informationOPERATING INSTRUCTIONS
OPERATING INSTRUCTIONS MODEL LV20 LARGE CAPACITY REFRIGERANT RECOVERY UNIT NATIONAL REFRIGERATION PRODUCTS 985 WHEELER WAY LANGHORNE, PA 19047 (215) 638-8909 FAX (215) 638-9270 R01101 LV20.DOC NRP-OM-LV20
More informationAIR CONDITIONNING 95 CODE 002
CODE 002 AIR CONDITIONNING 95 Cool-Tech Refrigerant Recovery/Recycling Unit Model 34788 It recovers, recycles, evacuates, leak tests, and recharges R-134a quickly and accurately. Fully automatic function
More informationChapter 6. Do s & Don ts in Refrigeration & Air-Conditioning Servicing
Do s & Don ts in Refrigeration & Air-Conditioning Servicing Who is Better? OR Common Practices that are damaging to the Refrigeration & Air-conditioning Systems Brazing with Cu electrode for brazing Cu
More informationOperating Manual, Model K/348012K Recovery/Recycling/Recharging Unit For R-12 and R-134a Refrigerants...1
Operating Manual, Model 348002K/348012K Recovery/Recycling/Recharging Unit For R-12 and R-134a Refrigerants...1 Refrigerant Recovery, Recycling and Recharging Station Series: 348002K/348012K Refrigerants:
More informationOPERATING INSTRUCTIONS
OPERATING INSTRUCTIONS MODEL RLV-700 REFRIGERANT RECOVERY / RECYCLING UNIT (PATENTED) NATIONAL REFRIGERATION PRODUCTS 985 Wheeler Way Langhorne, PA 19047 (215) 638-8909 FAX (215) 638-9270 REVISED 03-21-2018
More informationOperating Manual. Model K/ K Recovery/Recycling/Recharging Unit
Operating Manual Model -K/-K Recovery/Recycling/Recharging Unit Model -K (for R- refrigerant) Model -K (for R-a refrigerant) Recover, Recycle, and Recharge Unit SAFETY DEFINITIONS: Follow all WARNING,
More informationFULLY AUTOMATIC A/C SERVICE UNIT USE AND INSTRUCTION MANUAL
INDEX FULLY AUTOMATIC A/C SERVICE UNIT USE AND INSTRUCTION MANUAL INDEX PARAGRAPH TITLE DESCRIPTION VERSION PAGE N. GENERAL INFO PRELIMINARY INSTRUCTIONS, PROPER USE SW 1.3.X VER.1.0 3 INSTALLATION PREPARING
More informationOften fellow technicians, co-workers and field personnel CHARGE REFRIGERANT DETERMINING PROPER SYSTEM
Image courtesy of Mastercool. DETERMINING PROPER SYSTEM REFRIGERANT CHARGE Troubleshooting refrigerant system issues is one of the toughest jobs HVACR technicians will ever face. BY RICH PERROTTA A wireless
More informationOPERATION & MAINTENANCE MANUAL TC670
OPERATION & MAINTENANCE MANUAL TC670 Refrigerant Management Center (Convertible For Use With R12 or R134a) RTI TECHNOLOGIES, INC. 4075 East Market Street York, PA 17402 Manual P/N 035-80342-02 TC670 CONVERTIBLE
More informationKOOLKARE CAR & COMMERCIAL AIR CONDITIONING SERVICE SOLUTIONS
KOOLKARE CAR & COMMERCIAL AIR CONDITIONING SERVICE SOLUTIONS THE STANDARD IN INFORMATION, EQUIPMENT AND DIAGNOSTICS SYSTEMS KOOLKARE DUAL GAS UNIT The air conditioning maintenance unit KoolKare Dual Gas
More informationOPER LV Wheeler Way
OPER RATING INSTRUCTIONS LV5 REFRIGERANT RECOVERY UNIT NATIONAL REFRIGERATION PRODUCTS 985 Wheeler Way Langhorne, PA 19047 Ph:(215) 638-8909 9 info@ @nrproducts.com LV5.DOC 9.17.2018 MODEL LV5 REFRIGERANT
More informationModel AC Original Instructions. Recover, Recycle, Recharge Machine for R1234yf A/C Systems
Original Instructions 99 Washington Street Melrose, MA 02176 Phone 781-665-1400 Toll Free 1-800-517-8431 Visit us at www.testequipmentdepot.com Model AC1234-6 Recover, Recycle, Recharge Machine for R1234yf
More informationOperating Manual. Model 34700Z / 17700Z Recovery, Recycling, Recharging Unit
Operating Manual Model 34700Z / 17700Z Recovery, Recycling, Recharging Unit Model 34700Z / 17700Z Recovery, Recycling, & Recharging Unit SAFETY DEFINITIONS: Follow all WARNING, CAUTION, IMPORTANT, and
More informationTOYOTA FJ-40 DIRECTIONS
PAGE 1 TOYOTA FJ-40 DIRECTIONS Please read the following directions prior to installing this a/c system. Contact us by email or phone if you need any assistance or information regarding this a/c system.
More informationREFRIGERANT SYSTEM SERVICE WARNINGS
2005 HVAC Refrigerant System - MX-5 Miata REFRIGERANT SYSTEM SERVICE WARNINGS USING/HANDLING UNAPPROVED REFRIGERANT Using a flammable refrigerant, such as OZ-12, in this vehicle is dangerous. In an accident,
More informationTruck Edition V-220 / V-320 Series Single Temperature Systems TK IM (Rev. 0, 06/17)
Installation Manual Truck Edition V-220 / V-320 Series Single Temperature Systems TK 56321-18-IM (Rev. 0, 06/17) Installation Manual Truck Edition V-220 / V-320 Series Single Temperature Systems TK 56321-18-IM
More informationASSIGNMENT OBJECTIVES
LESSON 2 HVAC DIAGNOSIS covers the diagnosis, or troubleshooting, of the HVAC system and the tools used to perform that diagnosis. The lesson contains one reading assignment. ASSIGNMENT 1 HEATING AND AIR-CONDITIONING
More informationModel Operating Manual for. Recovery, Recycling, Recharging Unit P E R A T I N G A N U A L
O P E R A T I N G 99 Washington Street Melrose, MA 02176 Phone 781-665-1400 Toll Free 1-800-571-8431 Visit us at www.testequipmentdepot.com M A N U A L Operating Manual for Model 34788 Recovery, Recycling,
More information5/12/2018 Climate Control System General Information and Diagnostics - Air Conditioning (A/C) System Recovery, Evacuation and Charging - G
2008 Fusion Subarticles Report a problem with this article Refrigerant System Recovery Refrigerant System Evacuation Using a R-134a Refrigerant Management Machine Refrigerant System Evacuation Using a
More information2012 ALTIMA, SENTRA; COMPRESSOR LEAK AT DRAIN PLUG
Classificatio n: Reference: Date: HA12-004a NTB12-044a June 5, 2012 2012 ALTIMA, SENTRA; COMPRESSOR LEAK AT DRAIN PLUG This bulletin has been amended to include additional models and their procedures.
More informationAUTOMOTIVE SPECIALIZATION (Air Conditioning and Heating) STUDENT GRADE RECORD Career & Technical Education
STUDENT GRADE RECORD Career & Technical Education Course Outline Modules Windham Module Test Module Competenc y Rating WINDHAM SCHOOL DISTRICT 1. CTE Orientation 2. Introduction to Automotive Heating,
More information99 Washington Street Melrose, MA Phone Toll Free Visit us at
99 Washington Street Melrose, MA 02176 Phone 781-665-1400 Toll Free 1-800-517-8431 Visit us at www.testequipmentdepot.com User s Manual 1 WARNING! CAUTION! Before operating this unit, please read this
More informationUser manual Flushing device VAS 6337/1a
User manual Flushing device VAS 6337/1a 2 Content Safety warnings 3 Flushing with R134a refrigerant 4 1.0 Preparing the Vehicle AC System 4 1.1 Connecting the recovery recharge Unit 6 1.2 Flush procedure
More informationMANUAL CONTROL HEATING, VENTILATION, AND AIR CONDITIONING SYSTEM
SECTION 7B MANUAL CONTROL HEATING, VENTILATION, AND AIR CONDITIONING SYSTEM CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a tool or equipment
More informationP E R A T I N G A N U A L. Operating Manual for. Model Recovery, Recycling, Recharging Unit
O P E R A T I N G M A N U A L Operating Manual for Model 34788 Recovery, Recycling, Recharging Unit Model 34788 Recovery, Recycling, & Recharging Unit SAFETY DEFINITIONS: Follow all WARNING, CAUTION, IMPORTANT,
More informationSection 2. Air Conditioning & Cooling System Service Equipment. Section 2: Suppliers: CALL:
Air Conditioning & Cooling System Service Equipment A/C Refrigerant Recovery/Recycle/ Recharging Units A/C Refrigerant Charging Scales A/C Vacuum Gauge A/C Vacuum Pumps A/C Refrigerant Leak Detectors A/C
More informationOPERATIONS MAINTENANCE MANUAL
OPERATIONS and MAINTENANCE MANUAL White 1090ST Refrigerant Recovery/Recycle/Recharge Unit Table of Contents Safety... 1 Introduction... 8 Refrigerant Gases... 8 Refrigerant Handling... 9 Refrigerant Safety...
More informationAriazone 5001 HFO-1234yf
Automotive Air-Conditioning Service Equipment Ariazone 5001 HFO-1234yf OPERATOR MANUAL 1 Contents Page 1. Introduction... 3 2. Safety... 4 3. Technical Features... 5 4. Main Parts & Features... 6 5. Preparing
More informationBAC 4000a BAC 5000yf
AC Service Units BAC 4000a BAC 5000yf AC Service Units Recommended by Volvo Cars Fully-automatic, high capacity and comfortable Maximum safety Easy to use BAC 4000a Maximum precision easy operation. The
More informationAPPENDIX C USER S MANUAL
APPENDIX C USER S MANUAL GENERAL This appendix is for reference only. The Snap-on (ZEEAC318A) version User s Manuals is supplied for your information or can be copied for the customer. This version and
More informationUSING R-134A REFRIGERANT
USING R-134A REFRIGERANT HANDLING/SAFETY PRECAUTIONS 1998 GENERAL SERVICING General Servicing Procedures 1. Always work in a well-ventilated, clean area. Refrigerant is colorless and invisible as a gas.
More informationControl of refrigerant gases during manufacture, installation, servicing
The Australian automotive code of practice 2008 Control of refrigerant gases during manufacture, installation, servicing or de-commissioning of motor vehicle air conditioners Motor Trades Association of
More informationSEA FROST SHORE ASSIST SA-1 R-12 THIS MANUAL IS SUPPLEMENTAL TO THE SEA FROST R-12 ENGINE DRIVE MANUAL INSTALLATION INSTRUCTIONS
148 OLD CONCORD TURNPIKE BARRINGTON, NH 03825 USA TEL (603) 868-5720 FAX (603) 868-1040 1-800-435-6708 E-Mail:sales@seafrost.com www.seafrost.com SEA FROST SHORE ASSIST SA-1 R-12 THIS MANUAL IS SUPPLEMENTAL
More informationOPERATION & MAINTENANCE MANUAL AC880
OPERATION & MAINTENANCE MANUAL AC880 Refrigerant Handling System Manual P/N 035-80749-00 TABLE OF CONTENTS AC880 Before Using the AC880... 2 Safety Precautions... 2 Using the AC880... 3 Setup... 4 Fill
More informationGETZ EQUIPMENT INNOVATORS PART NO.: 9G58619 MODEL: SV1 150 PR VACUFILL SYSTEM (Revised 2/25/14)
GETZ EQUIPMENT INNOVATORS PART NO.: 9G58619 MODEL: SV1 150 PR VACUFILL SYSTEM (Revised 2/25/14) !!WARNING!! SEVERE DAMAGE AND/OR INJURY MAY RESULT DO NOT DISCHARGE ANY EXTINGUISHER CYLINDER EXCEEDING 195
More informationAC1234 PRODUCT RANGE.
AC1234 PRODUCT RANGE THE REFERENCE POINT FOR THE MAINTENANCE OF THE R-1234YF A/C SYSTEMS www.ac1234yf.com AC1234-8, AC1234-7 AND AC1X34-7 AC1234-8 and AC1234-7 are service stations which perform maintenance
More information1 of 3 5/4/ :44 AM
Expansion Block/Orifice Tube Service and Repair, Removal and Repla... http://repair.alldata.com/alldata/article/display.action?componentid=35&... 1 of 3 5/4/2016 11:44 AM Air Conditioning Evaporator Thermal
More informationOriginal Instructions Instucciones originales Consignes originales. Model: AC R-1234yf A/C Recover, Recycle, Recharge Machine
Original Instructions Instucciones originales Consignes originales Model: AC1234-6 R-1234yf A/C Recover, Recycle, Recharge Machine Description: Recover, recycle, and recharge machine for use with R-1234yf
More informationOPERATING MANUAL. Model 34134Z. Refrigerant Unit Recover, Recycle, and Recharge
OPERATING MANUAL Model 34134Z Refrigerant Unit Recover, Recycle, and Recharge Recover, Recycle, and Recharge Unit Model: 34134Z Refrigerant: R-134a Voltage: 115, 60 Hz LISTED 80S2 Recycling Equipment Design
More informationNZQA Expiring unit standard 3397 version 4 Page 1 of 5. Convert an automotive air conditioning system from R-12 to R-134a
Page 1 of 5 Title Convert an automotive air conditioning system from R-12 to R-134a Level 3 Credits 2 Purpose This unit standard is for people in the automotive repair industry. People credited with this
More informationINSTRUCTIONS RHS 700. Recovery, Recycling, Evacuation and Charging Station RHS 700
A GRAMKOW A/S Augustenborg Landevej 19 DK-6400 Sønderborg Denmark A/S Reg. No. 17 12 31 Telephone: 45 74 12 36 36 Telefax: 45 74 43 36 46 Telex: 5 23 18 Bank: Den Danske Bank, No. 32 27 INSTRUCTIONS Recovery,
More informationInstruction Manual DIGITAL MANIFOLD FOR HVAC/R SYSTEMS
English Instruction Manual DIGITAL MANIFOLD FOR HVAC/R SYSTEMS 99 Washington Street Melrose, MA 02176 Phone 781-665-1400 Toll Free 1-800-517-8431 Visit us at www.testequipmentdepot.com Instruction Manual
More informationSYLLABUS. DIVISION: Business & Engineering Technologies REVISED: Spring CURRICULA IN WHICH COURSE IS TAUGHT: Automotive Analysis and Repair
SYLLABUS DIVISION: Business & Engineering Technologies REVISED: Spring 2012 CURRICULA IN WHICH COURSE IS TAUGHT: Automotive Analysis and Repair COURSE NUMBER/TITLE: AUT 236-01 Automotive Climate Control
More informationVacuum Gauge. Measures lower-than-atmospheric pressure Digital scales. microns psi in. Hg millibars pascals torr millitorr
Vacuum Gauge Measures lower-than-atmospheric pressure Digital scales microns psi in. Hg millibars pascals torr millitorr (Sealed Unit Parts Co., Inc.) Compound Gauge Measures pressure and vacuum Low-side
More informationRLD-H10P Refrigerant Leak Detector
FANs 125, 121 Product/Technical Bulletin RLD-H10P Issue Date 0396 RLD-H10P Refrigerant Leak Detector The RLD-H10P is a professional grade leak detector for use by refrigeration and air conditioning technicians.
More informationHybrid Conversion Kit Procedure Guide
Automotive Air Conditioning Hybrid Conversion Kit Procedure Guide TM autoclimate COPYRIGHT INFRINGEMENT NOTICE Autoclimate Limited. All rights reserved. No part of this manual, publication or text may
More informationWMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS
WMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS **WARNING TO INSTALLER, SERVICE PERSONNEL AND OWNER** Altering the product or replacing parts with non authorized factory parts voids all warranty
More informationPORTABLE DEW POINT MONITOR
PORTABLE DEW POINT MONITOR MODEL 8072, 8072-230VAC (units made after 2002) Table of Contents INTRODUCTION... 2 SPECIFICATIONS:... 2 OPERATION... 3 Dryer Output Sampling... 3 Hopper Output Sampling... 3
More informationRLD-H10G Refrigerant Leak Detectors
FANs 125, 121 Product/Technical Bulletin RLD-H10G Issue Date 0396 RLD-H10G Refrigerant Leak Detectors The RLD-H10G is a professional grade leak detector for use by refrigeration and air conditioning technicians.
More informationOtherwise, you can continue reading the file on the following pages.
If you d like to be able to print this file out to study off-line or use on the job, a printable version is available for an administrative fee of $3.97 USD. To download the unlocked file, click here.
More informationPage 2 Draft Revision to the Australian Automotive Air Conditioning Code of Practice 2014
Draft Revision to the Australian Automotive Air Conditioning Code of Practice 2014 Preface This draft revision of the Australian Automotive Air Conditioning Code of Practice 2014 has been written and produced
More informationUse of R1234yf, R744 (CO 2 ) and R134a in automotive air conditioning
Use of R1234yf, R744 (CO 2 ) and R134a in automotive air conditioning This initiative was developed by: Content and guidance kindly provided by the following organisations: Cool Drive CPS Asia Pacific
More informationAC690PRO PART NO OPERATOR GUIDE
AC690PRO PART NO. 02404-0116 OPERATOR GUIDE Document Ref: OGAC690PRO v.1.0 Aug. 2011 Rel. 2 02/09 8 tuv 7 pqrs 0 1 4 ghi V abc j kl 5 2 9 wxy z def mno 6 3 M2 HIGH LOW P1 T1 T2 1 2 P EV1 EV5 EV3 EV6 3
More informationGETZ MANUFACTURING PART NO.: MODEL: SV1 100 PR VACUFILL SYSTEM (Revised 6/7/05)
GETZ MANUFACTURING PART NO.: 58616 MODEL: SV1 100 PR VACUFILL SYSTEM (Revised 6/7/05) GETZ SV1-100-PR VACU-FILL SYSTEM TABLE OF CONTENTS PAGE # 1... GETZ SV1-100-PR VACU-FILL SYSTEM 2... PARTS LIST 3...
More informationMotor Vehicle Air Conditioning (MVAC) System operation and the refrigerant cycle
Motor Vehicle Air Conditioning (MVAC) System operation and the refrigerant cycle At Sea level water boils at 212⁰ F R 134a boils at 15⁰ F At Sea level R 134a boils at 15⁰ F At 30 psig R 134a boils at 35⁰
More informationWATER PUMP REQUESTED INFORMATION STANDARD PROCEDURE RAM Pickup 6.7L Eng 2500 STANDARD PROCEDURE - COOLANT AIR EVACUATION
WATER PUMP 2012 RAM Pickup 6.7L Eng 2500 REQUESTED INFORMATION STANDARD PROCEDURE STANDARD PROCEDURE - COOLANT AIR EVACUATION Fig 1: Pressurized Air Operated Vacuum Generator Evacuating or purging air
More informationHEATING AND AIR CONDITIONING
WJ HEATING AND AIR CONDITIONING 24-1 HEATING AND AIR CONDITIONING TABLE OF CONTENTS page SERVICE PROCEDURES REFRIGERANT OIL LEVEL...1 REFRIGERANT RECOVERY....1 REFRIGERANT SYSTEM CHARGE...1 REFRIGERANT
More informationREFRIGERANT ON-VEHICLE INSPECTION AC 14
14 REFRIGERANT ON-VEHICLE INSPECTION 1. INSPECT REFRIGERANT PRESSURE WITH MANIFOLD GAUGE SET (a) This is a method to specify trouble areas by using a manifold gauge set. Read the manifold gauge pressure
More informationRECOVERY/RECYCLE/RECHARGE
RECOVERY/RECYCLE/RECHARGE Operating Instructions WARNING!! Do not stop the recovery process. Permanent damage will occur that could void the warranty. INTRODUCTION This machine is ETL Laboratories approved,
More informationSection 12-00: Climate Control System Service 1997 Town Car Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/29/2000 Climate Control System Inspection and Verification 1. Verify the customer's
More informationTechnical Service Bulletin
87 Faint noise heard in cabin from air conditioning circuit 87 16 75 2044717/1 July 8, 2016 Model(s) Year VIN Range Vehicle-Specific Equipment A6, A7 2012-2015 All 2.0L or 3.0L gas engine Condition A faint,
More information14. The center port of the manifold is used for evacuation, charging and refrigerant recovery.
HET- 190 ESL Support page 1 CORE Basic Refrigeration Circuit 1. Liquid refrigerant boils in the evaporator. Heat is absorbed. The heat energy absorbed converts refrigerant liquid into vapor. 2. Refrigerant
More informationINSTALLATION MANUAL. Refrigerant stop valves kit EKRSVHTA
INSTALLATION MANUAL Refrigerant stop valves kit EKRSVHTA EKRSVHTA Refrigerant stop valves kit Installation manual CONTENTS Page 1. Introduction... 1 2. Accessories... 1 3. Installing the stop valves...
More information1. General Description
1. General Description A: SPECIFICATIONS 1. HEATER SYSTEM Heating capacity 2. A/C SYSTEM AUTO A/C MODEL Item Specifications Condition 5.0 kw (4,300 kcal/h, 17,062 BTU/h) or more AC-2 Mode selector switch:
More informationFully responsive touch screen command center...
Mastercool introduces its new ARCTIC COMMANDER line of RRR machines. Equipped with the latest technology, all models come standard with an 8 command center. The graphic user interface (GUI) will enable
More informationAUTOMOTIVE AIR CONDITIONER REFRIGERANT HANDLING SYSTEM
Guangzhou Junliye Import&Export Co., Ltd. AUTOMOTIVE AIR CONDITIONER REFRIGERANT HANDLING SYSTEM OPERATION MANUAL 1. Cautions: Wear the glove and eye protection glass to protect the skin and eyes from
More informationModel Operating Manual for. Recovery, Recycling, Recharging Unit P E R A T I N G A N U A L
O P E R A T I N G 99 Washington Street Melrose, MA 02176 Phone 781-665-1400 Toll Free 1-800-571-8431 Visit us at www.testequipmentdepot.com M A N U A L Operating Manual for Model 34288 Recovery, Recycling,
More informationNISSAN INTEGRATED HOMELINK TRANSMITTER
Classification: Reference: Date: EL99-012a NTB99-067a November 7, 2003 NISSAN INTEGRATED HOMELINK TRANSMITTER APPLIED VEHICLES: 1996-2004 Pathfinder - with HomeLink Option 1997-2004 Maxima - with HomeLink
More informationCONVERT-ABLE FA1234 REFRIGERANT RECOVER / RECYCLE / EVACUATION AND RECHARGE UNIT
CONVERT-ABLE FA1234 REFRIGERANT RECOVER / RECYCLE / EVACUATION AND RECHARGE UNIT Convertible between four refrigerants: R-134a, R-1234yf, R-22 and R-407C Unit covered under US Patent 8,082,750 and other
More informationInstallation Instructions
24AHA4 Performance Series Air Conditioner with Puron Refrigerant 1-1/2 to 5 Nominal Tons Installation Instructions Fig. 1-24AHA4 A07532 SAFETY CONSIDERATIONS Improper installation, adjustment, alteration,
More informationariazone 601HD Refrigerant Recovery & Recycling Unit User's manual
ariazone 601HD Refrigerant Recovery & Recycling Unit User's manual Model: Ariazone 601 HD Serial No: 1 1. SAFETY FIRST! Important safety information's - Read this user manual carefully before operating
More informationInstallation Instructions
PAGE 1 Installation Instructions Important information about your new a/c system. Please read the following directions prior to installing this a/c system. PN: CK6772-1CHPU 1967-1972 Chevy PU A/C Kit Contact
More informationHEATER & AIR CONDITIONING SYSTEM
VENTILATION, HEATER & AIR CONDITIONER SECTION HA A HEATER & AIR CONDITIONING SYSTEM B C D CONTENTS E PRECAUTION... 3 PRECAUTIONS... 3 Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT
More informationCalhoon MEBA Engineering School. Study Guide for Proficiency Testing Refrigeration
Calhoon MEBA Engineering School Study Guide for Proficiency Testing Refrigeration 1. To prevent an injury when working with refrigerants, what safety precautions are necessary? 2. When halogens are in
More information