TORRENT ECO ONE NAME. EVERY SOLUTION. OPEN VENTED THERMAL STORE PROVIDING HEATING AND MAINS PRESSURE HOT WATER

Transcription

1 TORRENT ECO OPEN VENTED THERMAL STORE PROVIDING HEATING AND ONE NAME. EVERY SOLUTION.

2 WHAT IS A THERMAL STORE? A THERMAL STORE IS THE PERFECT SOLUTION FOR A HOME S HEATING AND REQUIREMENTS. TORRENT OFFERS MORE OPTIONS THAN ANY OTHER STORE OR CYLINDER, AND IS DESIGNED TO REDUCE HEATING COSTS BY OFFERING COMPLETE FLEXIBILITY FOR HOUSEHOLDERS TO USE MULTIPLE ENERGY SOURCES. The hot water within the store circulates around the heating system to heat the property, while mains cold water is instantaneously heated through a plate heat exchanger, to provide hot water. All our Torrent models are open vented, enabling uncontrolled heat sources such as woodburning stoves to be used. BENEFITS OF THERMAL STORES PROVIDE USE FOR BOTH HEATING AND NO ANNUAL MAINTENANCE OR SAFETY CHECK REQUIREMENT NO DISCHARGE PIPEWORK NO RISK OF LEGIONELLA NO G QUALIFICATION REQUIREMENT CONTENTS 0. WHAT IS A THERMAL STORE? 0. TORRENT ECO 0. WHICH PRODUCT DO I NEED? 0. TORRENT ECO OV 08. TORRENT ECO SP. TORRENT ECO SOL.. 0 0

3 TORRENT ECO THE TORRENT ECO IS MANUFACTURED FROM COPPER, BY OUR TRAINED COPPERSMITHS, WITHIN GLEDHILL S EIGHT NATIONWIDE MANUFACTURING DEPOTS. This provides the flexibility for homeowners to select the thermal store which best suits their requirements, allowing them to maximise the available heat sources, whether they are traditional boilers, electric immersions, or increasingly popular alternative energy fuel sources. The cylinder is open vented, enabling uncontrolled heat sources such as woodburning stoves to be used. WHICH PRODUCT DO I NEED? OUR SELECTION CHART BELOW WILL HELP YOU IDENTIFY THE MOST SUITABLE TORRENT ECO MODEL FOR YOUR INSTALLATION. To use the chart, identify the available heat sources for your cylinder in each section, and follow the lines to identify the model required. The option to add solid fuel tappings to utilise wood burning stoves or biomass boilers is available on the full range of Torrent ECO products. DOES THE SITE HAVE: ELECTRIC HEAT SOURCE? GAS/OIL BOILER? SOLAR THERMAL? HEAT PUMP? TORRENT ECO OV SOL FLOW SENSOR PROVIDES A FAST RESPONSE TIME FOR SUPPLY INTEGRATED PCB AND SOFTWARE HIGH STORE TEMPERATURES CAN BE UTILISED, PROVIDING GREATER BENEFIT FROM SOLID FUEL INPUTS ENERGY SAVING WITH A HIGH EFFICIENCY PUMP START HERE TORRENT ECO SP (SEALED PRIMARY BOILER) TORRENT ECO OV (OPEN VENTED BOILER) TORRENT ECO OV SOL (OPTIONAL SP COIL) TORRENT ECO OV TORRENT ECO OV SOL TORRENT ECO SP (SEALED PRIMARY BOILER) TORRENT ECO OV (OPEN VENTED BOILER) TORRENT ECO OV SOL (OPTIONAL SP COIL) Underfloor tappings optional through the full range. All models come complete with back up immersion. Where a Torrent ECO SP is used, heating should be provided directly by the boiler as the store will only provide auxiliary heating. 0 0

4 TORRENT ECO OV LITRES TORRENT ECO OV SHOWING HOW THE CENTRAL HEATING SUPPLIED FROM STORE 1 Utilises open vented boiler to heat the store directly kw immersion heater for emergency back-up Electric only versions available Optional solid fuel connections UNDERFLOOR HEATING SUPPLIED FROM STORE TORRENT ECO OV Description TEC0-OV TEC-OV TEC-OV TEC0-OV TEC0-OV ErP rating C C C C C Immersion heater Solid fuel flow (optional) Boiler flow OV Central heating flow Control thermostat 8 Immersion heater 9 Central heating Open vented boiler Domestic hot water Plate heat exchanger flow Hot supply Cold mains Cold feed 1 Solid fuel (optional) 1 Plate heat exchanger 18 Drain Heat loss watts Capacity litres Unit height mm Unit diameter mm 8 8 Max. hot water flow rate litres/minute bath 1 1 shower room bed Vent pipes shown through the side of the feed and expansion tank may not be suitable for all systems. Installers must check suitability. The standard open vented store relies on a feed and expansion tank suitably sited above the highest radiator point to provide sufficient head for the system. 0

5 TORRENT ECO SP LITRES TORRENT ECO SP SHOWING HOW THE AUXILIARY CENTRAL HEATING SUPPLIED FROM STORE LIMITED TO HEAT INPUT PROVIDED BY AUXILIARY HEAT SOURCE 1 Utilises a sealed primary boiler to heat the store indirectly via an internal coil Auxiliary or underfloor heating available directly from the store (subject to heat input) kw immersion heater for emergency back-up UNDERFLOOR HEATING SUPPLIED FROM STORE CENTRAL HEATING SUPPLIED BY BOILER Optional solid fuel connections SEALED SYSTEM KIT TORRENT ECO SP Description TEC0-SP TEC-SP TEC-SP TEC0-SP TEC0-SP Solid fuel flow (optional) Central heating flow (optional) Immersion heater Control thermostat Sealed primary boiler flow 8 Sealed primary boiler 9 Central heating (optional) Domestic hot water Plate heat exchanger flow Hot supply Cold mains Cold feed Solid fuel (optional) 1 Plate heat exchanger 1 Drain ErP rating C C C C C Heat loss watts Capacity litres Unit height mm Unit diameter mm 8 8 Max. hot water flow rate litres/minute bath 1 1 shower room bed Vent pipes shown through the side of the feed and expansion tank may not be suitable for all systems. Installers must check suitability. 09

6 TORRENT ECO SOL 0 0 LITRES 1 Specifically designed for use with solar thermal panels TORRENT ECO SOLAR SHOWING HOW THE IF USING AN SP BOILER, THE AUXILIARY CENTRAL HEATING SUPPLIED FROM THE STORE IS LIMITED TO THE HEAT INPUT PROVIDED BY THE AUXILIARY HEAT SOURCE Utilises open vented boiler to heat the store directly Optional sealed primary boiler connections UNDERFLOOR HEATING SUPPLIED FROM STORE 1 kw immersion heater for emergency back-up Optional solid fuel connections EITHER AN OPEN VENTED, SEALED PRIMARY OR A COMBINATION OF THE TWO BOILERS CAN BE USED SEALED BOILER SEALED SYSTEM KIT CENTRAL HEATING SUPPLIED BY BOILER TORRENT ECO SOL Open vented boiler flow Central heating flow Sealed primary boiler flow (optional) Sealed primary boiler (optional) Central heating 8 Open vented boiler 9 Solid fuel (optional) Solar coil flow Solar sensor Solar coil Domestic hot water Plate heat exchanger flow Solar sensor 1 Solid fuel flow (optional) 1 Control thermostat 18 Hot supply 19 Cold mains 0 Immersion heater 1 Cold feed Solid fuel (optional) Plate heat exchanger Drain Description TEC -SOL TEC0-SOL TEC0-SOL ErP rating C C C Heat loss watts 81 9 Capacity litres 01 9 Unit height mm 1 18 Unit diameter mm 8 8 Dedicated solar volume litres 1 Max. solar collector area 1 m Solar heat exch. surface area 1 m Max. hot water flow rate litres/minute bath 1 1 shower room 1 bed To comply with the Building Regulations ADL1 Domestic Heating Compliance Guide. This can be adjusted at the time of specification. Vent pipes shown through the side of the feed and expansion tank may not be suitable for all systems. Installers must check suitability. The standard open vented store relies on a feed and expansion tank suitably sited above the highest radiator point to provide sufficient head for the system. As the domestic hot water is at mains pressure, the Torrent ECO Solar itself can be sited anywhere in the property. Provision is also made within the design for a sealed heating/boiler circuit with the heat exchanger provided which would then operate as a conventional cylinder. Although this would reduce the potential for utilising the solar energy in the HEATING CIRCUIT, it would mean that both the Torrent and the feed and expansion tank can then be sited anywhere in the property, as the feed and expansion is only being used to fill the store with water.

7 1 0 0 LITRES Specifically designed for use with either air source or ground source heat pumps Heating provided directly from the store Optional solid fuel connections kw immersion heaters for boost and emergency back-up for both heating and hot water SHOWING HOW THE CENTRAL HEATING SUPPLIED FROM STORE Description TEC-HP TEC-HP TEC0-HP TEC0-HP ErP rating C C C C 1 1 Solid fuel flow (optional) Heat pump cylinder sensor Control thermostat Heat pump flow Central heating flow 8 Central heating immersion 9 Central heating Heat pump sensor Heat pump Domestic hot water Plate heat exchanger flow Hot supply Cold mains 1 Domestic hot water immersion heater 1 Heat pump flow sensor 18 Cold feed 19 Solid fuel (optional) 0 Plate heat exchanger 1 Drain Heat loss watts Capacity litres Unit height mm Unit diameter mm 8 8 Max. hot water flow rate litres/minute bath 1 1 shower room 1 1 bed The suggested model sizes in the selection chart are based on a store temperature of C. If the intention is that the heat pump will be used to provide the majority of the hot water with minimum boost from another heat source then consideration should be given to choosing a larger model of Torrent ECO HP appliance. See the design installation and servicing instructions for equivalent volumes at different charge temperatures. If the immersion heater is to be used as the hot water boost a suitable control system should be installed to ensure that the heat pump has fully charged the appliance before the boost immersion heater is allowed to operate. This will ensure the most efficient and cost effective use of the system.

8 1 0 0 LITRES Specifically designed to combine solar thermal and heat pump technology SHOWING HOW THE Heating provided directly from the store Optional solid fuel connections to provide the ultimate alternative energy cylinder CENTRAL HEATING SUPPLIED FROM STORE kw immersion heaters for boost and emergency back-up for both heating and hot water Solid fuel flow (optional) Heat pump cylinder sensor Control thermostat Heat pump flow Central heating flow 8 Central heating 9 Heat pump sensor Heat pump Solar coil flow Solar coil Domestic hot water Plate heat exchanger flow Solar sensor 1 Hot supply 1 Domestic hot water immersion heater 18 Heat pump flow sensor 19 Cold mains 0 Central heating immersion heater 1 Solid fuel (optional) Solar sensor Cold feed Solid fuel (optional) Plate heat exchanger Drain Description TEC-HPSOL TEC0-HPSOL TEC0-HPSOL ErP rating C C C Heat loss watts 81 9 Capacity litres 01 9 Unit height mm 1 18 Unit diameter mm 8 8 Dedicated solar volume litres 1 Max. solar collector area 1 m Solar heat exch. surface area 1 m Max. hot water flow rate litres/minute bath 1 1 shower room 1 1 bed To comply with the Building Regulations ADL1 Domestic Heating Compliance Guide This can be adjusted at the time of specification. The suggested model sizes in the selection chart are based on a store temperature of C. If the intention is that the heat pump will be used to provide the majority of the hot water with minimum boost from another heat source then consideration should be given to choosing a larger model of Torrent ECO HP SOL appliance. See table 1b in the design installation and servicing instructions for equivalent volumes at different charge temperatures. If the immersion heater is to be used as the hot water boost a suitable control system should be installed to ensure that the heat pump has fully charged the appliance before the boost immersion heater is allowed to operate. This will ensure the most efficient and cost effective use of the system.

9 SPARES Gledhill cylinders are manufactured to the highest quality standards. In the unlikely event that you require a spare part, you can contact Gledhill Spare Parts, on: 0 or visit HERE TO HELP If you re looking for technical assistance while you re on the job, give our technical team a call. With many years experience, they re an invaluable resource to have at the end of the phone. FOR ADVICE PLEASE CALL 0 8 Gledhill Building Products Limited Sycamore Estate, Squires Gate, Blackpool FY RL T: 0 0 E: enquiries@gledhill.net GBP.1 Due to a programme of continuous improvement Gledhill Building Products reserves the right to modify products without prior notice. It is advisable to check the product technical detail by using the latest design and installation manuals available from our technical support team or on our website. It is an offence to copy or adapt this document without consent of the owner.