MR Series Heatless Mini Regenerative Desiccant Dryer. Operator s Manual

Size: px
Start display at page:

Download "MR Series Heatless Mini Regenerative Desiccant Dryer. Operator s Manual"

Transcription

1 MR Series Heatless Mini Regenerative Desiccant Dryer Operator s Manual

2 Introduction Many years of trouble-free service can be expected from your Numatics regenerative dryer. Superior dew point depression will be obtained and operating problems will be avoided with careful installation and proper preventative maintenance procedures. Location The ambient temperature of the dryer should fall in the35ºf-120ºf range. The dryer will function in warmer surroundings, but the degree of dew point depression obtained will decrease. All Ultra Air dryers are designed for indoor use only. Dryers located outdoors require a Low-Ambient Package. A protective roof is absolutely needed so that the dryer will not be directly exposed to rain and snow. Before using the dryer, make sure that no pipe or tubing connections have become loosened in transit. Make the necessary control power electrical connections and make sure the dryer is grounded. Recommended Installation Making the following connections: Inlet piping (including a shut-off valve) Outlet piping (including a shut-off valve) Prefilter(s) and afterfilter(s) Bypass piping (if desired. Use a bubble-tight valve for bypass) Electrical connection to control box An access connection should be made upstream and downstream of the dryer for dew point and temperature checks Required Pre-Filtration All regenerative desiccant dryers are designed to remove only water vapor. The possibility of liquid water carryover to the desiccant dryer must be avoided. A coalescing prefilter will eliminate the carryover of droplets and aerosol-sized mists of both liquid water and compressor lubricant. Required After-Filtration All regenerative desiccant dryers gradually produce hard and abrasive desiccant fines. These contaminant should be removed with and Ultra Air particulate afterfilter to keep downstream air from clogging the air lines. Optional Block and Bypass Suitable manual block and bypass valves should be installed to facilitate servicing of the dryer and filter without interruption of compressed air flow. Valves must be bubble-tight to prevent water vapor migration around the system from the region of high relative humidity to low relative humidity. For a typical installation, block and bypass valves should be installed around the entire dehydration system prefilter, dryer, and afterfilter. 1 MINIATURE REGENERATIVE DRYER INSTRUCTION MANUAL

3 Desiccant Fill and Drain Ports The MR-10 and MR-15 model towers are filled with desiccant by Numatics at the factory. The desiccant can be replaced by unbolting the top plate. The average life of the desiccant is two to three years depending on the working condition of the dryer and the maintenance of the filters. If the color of the desiccant has changed from the original white to pink or yellow, it is fully saturated and cannot be regenerated. Operation The operation of the MR dryer can be readily traced by referring to the enclosed flow schematic drawing. The operating sequence is fully automatic and is controlled by an electronic solid state timer. Wet and dirty compressed air leaving the compressor aftercooler and mechanical separator is freed of all entrained liquids and aerosols, as well as solid contamination, by the prefilter. Separated liquid contaminant is discharged from the prefilter sump through the automatic drain valve. Wet air enters the inlet 4-way valve (1) passing through the strainer, the strainer (2), the desiccant chamber (3), and through the outer check valve (4). Then the dry air exits through the dryer outlet. A small portion of the dry compressed air is expanded to near-atmospheric pressure by passing through the purge orifice (5). Expansion of this already-dry gas to near-atmospheric pressure increases the ability of the purge air to strip the previously absorbed water vapor from the partially saturated desiccant bed in the right chamber. The water vapor removed from the right chamber desiccant is passed to ambient through the 4-way valve (1) and exhaust muffler (6). Before tower switch-over, the 4-way valve (1) stop the air from purging. At that point, both towers (online and offline) are up to line pressure and ready to switch, assuming that both towers will be at equal pressure and no desiccant bed bumping will occur during switch over. The dryer 4-way inlet valve (1) switch then diverts the inlet compressed air to the right tower and the purge air escapes through the left tower. This process repeats as long as power is on. Should power to the dryer be lost or turned off, the sequence of operation will not be disturbed and will remain as is, also, air will still flow through the 4-way inlet valve (1) and out through the dryer outlet. The cycle is as follows: 1) the online tower dries for 30 seconds 2) the offline tower regenerates for 25 seconds 3) the offline tower repressurizes for 5 seconds. The entire cycle takes 60 seconds to complete for a -40º dewpoint system. MR-10/MR-15 Flow Diagram MINIATURE REGENERATIVE DRYER INSTRUCTION MANUAL 2

4 Start Up A) Verify that the air inlet and air outlet are connected properly. B) Verify that there is a high quality oil-removing prefilter installed upstream of the dryer C) Verify that there is a high quality drain system installed on the prefilter to assure the filter is properly drained. D) Verify that the proper electrical connections are made to the dryer. Check the voltage on the data label of the dryer. Check the line voltage and amperage of the electrical line connected to the dryer. Make sure the line voltage and the data label voltage are the same. E) The dryer upstream and downstream isolation valves should be closed and the bypass valve should be open. Before turning on power to the MR Series dryer, slowly pressurize the dryer by gradually opening the isolation valve upstream of the dryer. When both tower pressure gauges indicate line pressure, the dryer system outlet isolation valve can be opened and the dryer system bypass valve closed. Compressed air then flows through the prefilter, MR Series dryer, and afterfilter. Dryer operation should never be initiated by sudden pressurization of the dryer towers from the dryer inlet. The sudden rush of incoming high velocity air into the desiccant bed could cause damage to the prefilter and afterfilter elements. Power to the MR Series dryer should, at that point, be turned on. Immediately after activating the dryer control circuit, one tower will depressurize to atmospheric pressure through the purge exhaust valve. Regenerating purge air will then flow to the offline tower. Maintenance A) Prefilter The prefilter element must be replaced whenever the pressure drop over the filter exceeds 5 PSID or the indicator in the gauge points to the change zone. It is important to check the operation of the automatic drain trap or valve at frequent intervals to ensure that no liquid carryover into the dryer occurs. Ultra Air recommends prefilter elements be changed every 3 months to ensure proper filtration. This will prolong desiccant bed life and ensure clean, dry air downstream. B) Afterfilter The filter element must be replaced whenever the pressure drop exceeds 5 PSID or the indicator in the gauge points to the change zone. Whenever changing the prefilter, the afterfilter should be changed as well. C) Desiccant replacement For best results, change desiccant periodically. Be sure to use only Numatics Activated Alumina which can be obtained through your Numatics or Ultra Air representative. Numatics Activated Alumina excels in dew point depression capability and attrition resistance. WARNING! Failure to maintain and change prefilter on a regular basis could damage desiccant bed, cause dryer failure, and void any and all warranties! 3 MINIATURE REGENERATIVE DRYER INSTRUCTION MANUAL

5 Troubleshooting Problem Possible cause Solution Poor dew point Excessive inlet flow Reduce flow to rated capacity Check upstream separator, prefilter, Excessive inlet temp (above 120ºF) Excessive water Desiccant fouled by lubricant Prefilter drain failure Low inlet pressure Contaminated Check upstream aftercooler and drain traps Replace desiccant and prefilter element Check for clogging. Clean, repair, and/or replace Check for pressure loss over prefilter. Check dryer sizing based on flow and temperature Change desiccant Excessive pressure Excessive inlet flow Reduce flow to rated capacity or drop install larger dryer Low inlet pressure Excessive pressure drop over prefilter and/or afterfilter Saturated desiccant Check for pressure loss over prefilter Change filter elements Change filter elements MINIATURE REGENERATIVE DRYER INSTRUCTION MANUAL 4

6 Standard MR10/MR-15 Parts Diagram Standard MR10 Dimensions & Components Legend: A Air outlet B Air inlet C Electrical access box D 4-way valve E Desiccant tower F Pressure gauge G Muffler Standard MR15 Dimensions & Components Legend: A Air outlet B Air inlet C Electrical access box D 4-way valve E Desiccant tower F Pressure gauge G Muffler 5 MINIATURE REGENERATIVE DRYER INSTRUCTION MANUAL

7 MR10/MR-15 with Optional Mini-Pak Legend: A Air outlet B Air inlet C Electrical access box D 4-way valve E Desiccant tower F Pressure gauge G Muffler H Diff. pressure gauge I Coalescing filter J Adsorbing filter K Particulate filter L Drain Solenoid Drain Valve Replacement and Repair Kits Model Description LFT25 VAL-SO W ELE-TB-59-CR MUF-PU-5-SH Purge muffler (2) GAG Pressure gauge (2) VAL-CK-4-PK Check valve (2) Inlet valve (4-way double solenoid) Timer board FIL-TF-4 Tank strainer (2) DES-AA-2-00 Desiccant (10 lbs/.31 kg) MINIATURE REGENERATIVE DRYER INSTRUCTION MANUAL 6

8 Air Preparation Group 3309 John Conley Drive Lapeer, MI, phone (810) fax (810) Numatics, Inc. All rights reserved. LTMRDRYMAN-1 EAM05/01 xxx-ap-xx/xx

HEATLESS REGENERATIVE DRYERS

HEATLESS REGENERATIVE DRYERS HEATLESS REGENERATIVE DRYERS PHL SERIES Pioneer Air Systems Inc. 210, Flatfork Road, Wartburg, TN - 37887 Tel. : (423) 346-6693 Fax : (423) 346-3865, (423) 346-7522 Email : sales@pioneerair.com Internet

More information

WILKERSON MODELS DE3, DE4 AND DE5 COMPACT HEATLESS AIR DRYERS

WILKERSON MODELS DE3, DE4 AND DE5 COMPACT HEATLESS AIR DRYERS INSTRUCTION MANUAL FOR WILKERSON MODELS DE3, DE4 AND DE5 COMPACT HEATLESS AIR DRYERS DE3 - DE5 OPERATIONS GENERAL This instruction manual covers the installation, operation, maintenance and troubleshooting

More information

HEATLESS DESICCANT AIR DRYER INSTRUCTION & MAINTENANCE MANUAL

HEATLESS DESICCANT AIR DRYER INSTRUCTION & MAINTENANCE MANUAL HEATLESS DESICCANT AIR DRYER INSTRUCTION & MAINTENANCE MANUAL H-Series & 203 THRU 223 SERIES ARROW PNEUMATICS, INC. REGENERATIVE DRYER DIVISION 2111 WEST 21ST STREET BROADVIEW, IL 60155 708-343-9595 708-343-1907

More information

Heated Desiccant Air Dryer

Heated Desiccant Air Dryer OWNERS MANUAL F-0073 HEATED DESICCANT AIR DRYER Heated Desiccant Air Dryer MODELS RE231-RE250 ARROW PNEUMATICS Table of Contents Unpacking/Application/Analysis 3 Specifications 4 Dimensional Drawings 5-6

More information

Heatless Regenerative Compressed Air Dryers. Compressed Air System Products. Made in America

Heatless Regenerative Compressed Air Dryers. Compressed Air System Products. Made in America Heatless Regenerative Compressed Air Dryers Compressed Air System Products Made in America 22 AIR/TAK Heatless Regenerative Air Dryers Compressed Air System Products That Save Energy & Improve Operations.

More information

EXHAUST PURGE DESICCANT AIR DRYER INSTRUCTION & MAINTENANCE MANUAL MODEL RE-231 THROUGH RE-252

EXHAUST PURGE DESICCANT AIR DRYER INSTRUCTION & MAINTENANCE MANUAL MODEL RE-231 THROUGH RE-252 EXHAUST PURGE DESICCANT AIR DRYER INSTRUCTION & MAINTENANCE MANUAL MODEL RE-231 THROUGH RE-252 ARROW PNEUMATICS, INC. REGENERATIVE DRYER DIVISION 500 NORTH OAKWOOD RD LAKE ZURICH, IL,60047 PHONE # (847)

More information

INGERSOLLrAND AIR COMPRESSORS CAUTION: HMD SERIES AIR DRYERS MODELS 18 THROUGH 385 OPERATORS/ INSTRUCTION MANUAL REPLACEMENT PARTS

INGERSOLLrAND AIR COMPRESSORS CAUTION: HMD SERIES AIR DRYERS MODELS 18 THROUGH 385 OPERATORS/ INSTRUCTION MANUAL REPLACEMENT PARTS INGERSOLLrAND AIR COMPRESSORS HMD SERIES AIR DRYERS MODELS 18 THROUGH 385 OPERATORS/ INSTRUCTION MANUAL REPLACEMENT PARTS CAUTION: For HMD Models 84 Through 385 ONLY 1. Remove Dryer Chambers And Protective

More information

Fred C. Gilbert Co. 106 Norris Road Bakersfield, Ca fax

Fred C. Gilbert Co. 106 Norris Road Bakersfield, Ca fax A R R O W P N E U M A T I C S Fred C. Gilbert Co. 106 Norris Road Bakersfield, Ca. 93308 661-399-9569 fax 661-393-9654 F I L T E R S R E G U L A T O R S L U B R I C A T O R S A C C E S S O R I E S H E

More information

Regenerative Desiccant Dryers. KAD, KED, KBD and Hybritec Series

Regenerative Desiccant Dryers. KAD, KED, KBD and Hybritec Series Regenerative Desiccant Dryers KAD, KED, KBD and Hybritec Series The Right Dryer For You Most compressed air applications require only refrigerated dryers; however, if your compressed air is exposed to

More information

Heatless Regenerative Air Dryers

Heatless Regenerative Air Dryers Heatless Regenerative Air Dryers CPAD Series / CPADM Series Owner s Manual Jan. 2009 DATE OF PURCHASE MODEL SERIAL NO. Record above information from nameplate. Retain this information for future reference.

More information

Overview of HL series heatless regenerative dryers.

Overview of HL series heatless regenerative dryers. Overview of HL series heatless regenerative dryers. WWW.VANAIRSYSTEMS.COM Billbert www.vanairsystems.com Regenerative Desiccant Dryers MHL/HLS Series Heatless HL Series Heatless HI Series-Heated Internally

More information

AirCel. Heated Regenerative Desiccant Dryers. AEHD Externally Heated, HRE Blower Purge, and HRS-L Zero Purge Series

AirCel. Heated Regenerative Desiccant Dryers. AEHD Externally Heated, HRE Blower Purge, and HRS-L Zero Purge Series AirCel Heated Regenerative Desiccant Dryers AEHD Externally Heated, HRE Blower Purge, and HRS-L Zero Purge Series ié~çáåö=íüé=t~ó=áå=^áê=mìêáñáå~íáçå As one of the world s leading manufacturers of compressed

More information

Moisture can be very disruptive to a dust. Preventing moisture problems in your dust collector

Moisture can be very disruptive to a dust. Preventing moisture problems in your dust collector As appeared in March 2017 PBE Copyright CSC Publishing www.powderbulk.com Preventing moisture problems in your dust collector Brian Mathews Scientific Dust Collectors This article discusses how moisture

More information

DHW Series INSTRUCTION MANUAL. Pressure Swing Desiccant Compressed Air Dryer Models 7 through 50 scfm

DHW Series INSTRUCTION MANUAL. Pressure Swing Desiccant Compressed Air Dryer Models 7 through 50 scfm INSTRUCTION MANUAL DHW Series Pressure Swing Desiccant Compressed Air Dryer Models 7 through 50 scfm FORM NO.: 3215738 REVISION: 07/2014 READ AND UNDERSTAND THIS MANUAL PRIOR TO OPERATING OR SERVICING

More information

MODEL MW200 MODEL MW600 AIR DRYER

MODEL MW200 MODEL MW600 AIR DRYER OPERATING MANUAL MODEL MW200 MODEL MW600 AIR DRYER Mail Address: 226A Commerce St. Tel: 303-465-3063 Broomfield, CO 80020 Fax: 303-465-9294 TABLE OF CONTENTS 1.0 GENERAL...3 2.0 SPECIFICATIONS...3 3.0

More information

Desiccant Air Drying Technologies HCS Series HCL Series HCT Series

Desiccant Air Drying Technologies HCS Series HCL Series HCT Series Desiccant Air Drying Technologies HCS Series HCL Series HCT Series HCS, HCL and HCT Series Heatless Dryers Models 40-450 Models 590-5400 HCS, HCL and HCT Series Heatless Desiccant Dryers Since 1961, compressed

More information

Hybrid Refrigerated/Desiccant Compressed Air Dryers

Hybrid Refrigerated/Desiccant Compressed Air Dryers Hybrid Refrigerated/Desiccant Compressed Air Dryers This paper first appeared at the 2013 World Energy Engineering Congress Wayne Perry, Senior Technical Director David Phillips, Air Treatment Product

More information

CLEAN, DRY COMPRESSED AIR

CLEAN, DRY COMPRESSED AIR CLEAN, DRY COMPRESSED AIR Adsorption Air Dryers Air and gas purification have been at the core of Xebec adsorption technology since 1967. We have built, installed and continue to service over 9000 dryers.

More information

Instruction Manual Dry spell HFH INSTALLATION, OPERATION, MAINTENANCE. Regenerative Type Heatless Desiccant Dryer

Instruction Manual Dry spell HFH INSTALLATION, OPERATION, MAINTENANCE. Regenerative Type Heatless Desiccant Dryer Adsorption dryer Instruction Manual Dry spell HFH INSTALLATION, OPERATION, MAINTENANCE Regenerative Type Heatless Desiccant Dryer WE REDEFINE COMPRESSED AIR TREATMENT SYSTEMS 5/232 KNG Pudur road, Somayampalayam

More information

Desiccant Dryers. Desiccant Dryers. Heatless Heated Purge Blower Purge Modular

Desiccant Dryers. Desiccant Dryers. Heatless Heated Purge Blower Purge Modular Desiccant Dryers Desiccant Dryers Heatless Heated Purge Blower Purge Modular Desiccant Air Dryers Quincy desiccant air dryers purify compressed air by adsorbing water vapor. Pressure dewpoints of -40 F

More information

A Division of Numatics. 201 Series Refrigerated Air Dryer. Models UA through UA Installation, Operating, & Maintenance Manual

A Division of Numatics. 201 Series Refrigerated Air Dryer. Models UA through UA Installation, Operating, & Maintenance Manual A Division of Numatics 201 Series Refrigerated Air Dryer Models UA201-10 through UA201-2000 Installation, Operating, & Maintenance Manual Introduction This manual contains information and recommendations

More information

Dual Tower Heat Reactivated Desiccant Air Dryer

Dual Tower Heat Reactivated Desiccant Air Dryer Dual Tower Heat Reactivated Desiccant Air Dryer idhpe Dryer idbpe Dryer Eliminate Water from Your Compressed Air System Moisture in compressed air is damaging. Without proper treatment, this vital energy

More information

GPS-SERIES HEATLESS REGENERATIVE DESICCANT DRYERS

GPS-SERIES HEATLESS REGENERATIVE DESICCANT DRYERS Great Lakes Air Products 1515 S. Newburgh Road Westland, MI 48186 PH: 734-326-7080 www.glair.com GPS-SERIES HEATLESS REGENERATIVE DESICCANT DRYERS COMPRESSED AIR DRYER INSTRUCTION MANUAL Contents Introduction

More information

DGH Series Global Air Treatment

DGH Series Global Air Treatment DGH Series Global Air Treatment 2 DGH Desiccant Dryers Customizable Performance Gardner Denver DGH Series Heatless Desiccant Dryers were designed to help you meet your goals. Customizable performance technology

More information

Meeting Your Compressed Air Treatment Needs

Meeting Your Compressed Air Treatment Needs Compressed Air Treatment Guide Meeting Your Compressed Air Treatment Needs How to Select the Right Equipment for Your Application Provided as a Service by Kaeser Compressors, Inc. Six Levels of Compressed

More information

HEATLESS DESICCANT AIR DRYERS

HEATLESS DESICCANT AIR DRYERS HEATLESS DESICCANT AIR DRYERS HHS, HHL AND HHE SERIES HANKISON HEATLESS DESICCANT DRYERS HHS, HHL AND HHE SERIES Since 1948, sensitive applications requiring clean, dry, compressed air have turned to Hankison

More information

PET Drying Technology

PET Drying Technology PET Drying Technology Introduction Industry s increasing demand for clean, reliable sources of high pressure compressed air require that system designers become more educated in dehydration and filtration

More information

Externally Heated Exhaust Purge Regenerative Compressed Air Dryer

Externally Heated Exhaust Purge Regenerative Compressed Air Dryer Externally Heated Exhaust Purge Regenerative Compressed Air Dryer Provides safety and reliability Designed for medium flow rates Conservative design for optimal energy efficiency and savings World Leader

More information

COMPRESSED AIR DRYER INSTRUCTION MANUAL BLOWER PURGE DESICCANT DRYERS. Contents

COMPRESSED AIR DRYER INSTRUCTION MANUAL BLOWER PURGE DESICCANT DRYERS. Contents Great Lakes Air Products 1515 S. Newburgh Road Westland, MI 48186 PH: 734-326-7080 www.glair.com GBS-SERIES COMPRESSED AIR DRYER INSTRUCTION MANUAL BLOWER PURGE DESICCANT DRYERS Contents Introduction 2

More information

TECHNICAL BULLETIN SELECTING A COMPRESSED AIR DRYER INTRODUCTION

TECHNICAL BULLETIN SELECTING A COMPRESSED AIR DRYER INTRODUCTION TECHNICAL BULLETIN SELECTING A COMPRESSED AIR DRYER INTRODUCTION Having an understanding of why water forms in your compressed air piping system will help you in evaluating the type of air drying system

More information

EXTERNALLY HEATED DESICCANT AIR DRYERS. DHP Series

EXTERNALLY HEATED DESICCANT AIR DRYERS. DHP Series EXTERNALLY HEATED DESICCANT AIR DRYERS DHP Series Critical Performance Gardner Denver DHP Gardner Denver DHP externally heated series is designed for applications that were previously forced to accept

More information

MDH Series Air Dryer. User s Guide

MDH Series Air Dryer. User s Guide MDH Series Air Dryer User s Guide Models covered: MDH1 MDH2 MDH3 MDH4 MDH5 MDH6 1. Welcome & Congratulations Congratulations on your purchase of a new PUREGAS MDH SERIES AIR DRYER! We here at PUREGAS

More information

Industrial Oxygen Generation Plant

Industrial Oxygen Generation Plant Industrial Oxygen Generation Plant Operation Process Description : (Ref: P-I Diagram) Oxygen is generated from Compressed air by a separation process which uses the principle of selective adsorption. The

More information

Blower Purge Desiccant Compressed Air Dryers IBP SERIES 500-4,300 SCFM

Blower Purge Desiccant Compressed Air Dryers IBP SERIES 500-4,300 SCFM Blower Purge Desiccant Compressed Air Dryers IBP SERIES 500-4,300 SCFM Since 1946, the world has turned to SPX FLOW s Pneumatic Products brand for the quality and service demanded by the most critical

More information

Dry Air Pac ENGINEERED COMPRESSED AIR DRYING SYSTEMS FOR COLD STORAGE/ FREEZER ROOM DRY PIPE SPRINKLER SYSTEMS

Dry Air Pac ENGINEERED COMPRESSED AIR DRYING SYSTEMS FOR COLD STORAGE/ FREEZER ROOM DRY PIPE SPRINKLER SYSTEMS Dry Air Pac ENGINEERED COMPRESSED AIR DRYING SYSTEMS FOR COLD STORAGE/ FREEZER ROOM DRY PIPE SPRINKLER SYSTEMS Installation, Operation and Maintenance Manual MODELS DAP500, DAP1000 & DAP2000 Model Number

More information

VSA Series Air Dryer. User s Guide

VSA Series Air Dryer. User s Guide VSA Series Air Dryer User s Guide Models covered: VSA1 VSA2 VSA3 VSA4 1. Welcome & Congratulations Congratulations on your purchase of a new PUREGAS VSA SERIES AIR DRYER! We here at PUREGAS are very proud

More information

ZPA Heatless Regeneration ZHA Heated Regeneration ZBA Heated Blower Regeneration

ZPA Heatless Regeneration ZHA Heated Regeneration ZBA Heated Blower Regeneration INNOVATIVE COMPRESSED AIR SOLUTIONS TM DESICCANT AIR DRYERS 90-8000 scfm ZPA Heatless Regeneration ZHA Heated Regeneration ZBA Heated Blower Regeneration www.zeks.com RELIABLE PERFORMANCE. DESIGN INNOVATION.

More information

Single Tower Heat Reactivated Desiccant Air Dryer

Single Tower Heat Reactivated Desiccant Air Dryer Single Tower Heat Reactivated Desiccant Air Dryer iste Dryer Understanding Compressed Air Moisture in compressed air is damaging. Using untreated air results in water and contaminants in your air lines,

More information

MANUAL. Dryspell INSTALLATION OPERATION MAINTENANCE. Regenerative Type Heatless Desiccant Dryer

MANUAL. Dryspell INSTALLATION OPERATION MAINTENANCE. Regenerative Type Heatless Desiccant Dryer MANUAL INSTALLATION OPERATION MAINTENANCE Regenerative Type Heatless Desiccant Dryer Dryspell Contents 1. Introduction 2 1.1 Design 1.2 Relevant Units 1.3 Statement of Conformity 1.4 Description 1.5 Adsorbant

More information

Installation, Operation, and Maintenance Instructions. Heatless Regenerative Air Dryers and HLD-PAK Dryer/Filter Packages HLD-25 through HLD-6250

Installation, Operation, and Maintenance Instructions. Heatless Regenerative Air Dryers and HLD-PAK Dryer/Filter Packages HLD-25 through HLD-6250 107 W. Main Street, Worthington, PA 16262 Phone: 724-297-3416 Fax: 724-297-5189 URL: http://www.airtak.com e-mail: airtak@airtak.com Installation, Operation, and Maintenance Instructions Heatless Regenerative

More information

Corrosion Dry Air Pak

Corrosion Dry Air Pak Corrosion Dry Air Pak ENGINEERED COMPRESSED AIR DRYING SYSTEMS FOR MIC REDUCTION IN DRY PIPE SPRINKLER SYSTEMS Installation, Operation, & Maintenance Manual MODELS CDP500, CDP1000, & CDP2000 MFG#: 5403584

More information

150-3,000 scfm AEHD Series. Desiccant Air Dryers AEHD Series. Externally Heated Desiccant Air Dryer 150-3,000 scfm. Front Page

150-3,000 scfm AEHD Series. Desiccant Air Dryers AEHD Series. Externally Heated Desiccant Air Dryer 150-3,000 scfm. Front Page 150-3,000 scfm AEHD Series Desiccant Air Dryers AEHD Series Externally Heated Desiccant Air Dryer 150-3,000 scfm Front Page 1 AEHD Series Heated Dryer Externally Heated Desiccant Dryer 150-3,000 scfm Since

More information

Pressure Swing Desiccant Dryers

Pressure Swing Desiccant Dryers Pressure Swing Desiccant Dryers Featuring Legendary Heat-Les TM Technology The Original Heat Les Drying Technology The DHA / CDA series dryer has been designed specifically to bring you reliable performance

More information

clean, dry compressed air

clean, dry compressed air clean, dry compressed air Adsorption Air Dryers Air and gas purification have been at the core of Xebec adsorption technology since 1967. We have built, installed and continue to service over 9000 dryers.

More information

Owners Manual Refrigerated Air Dryer MHT SERIES

Owners Manual Refrigerated Air Dryer MHT SERIES Owners Manual Refrigerated Air Dryer MHT SERIES IMPORTANT: READ THIS MANUAL CAREFULLY. IT CONTAINS IN- FORMATION ABOUT SAFETY AND THE SAFETY OF OTHERS. ALSO BECOME FAMILAR WITH THE PROPER INSTALLATION

More information

Compressed Air Specialists

Compressed Air Specialists Compressed Air Specialists Breathing Air Systems The Breathing Air Device (BRAD) ensures clean, contaminant free, Grade D breathable air to the painter, eliminating health hazards. RTi has several innovative

More information

HS Dryer. Smart Solutions for Drying Compressed Air. Single Tower Heat Reactivated Desiccant Air Dryer. Engineered Air Products

HS Dryer. Smart Solutions for Drying Compressed Air. Single Tower Heat Reactivated Desiccant Air Dryer. Engineered Air Products Smart Solutions for Drying Compressed Air Single Tower Heat Reactivated Desiccant Air Dryer TM HS Dryer 800.943.794 www.engineeredairproducts.com Engineered Air Products Moisture in compressed air is damaging.

More information

HEATLESS REGENERATIVE COMPRESSED AIR DRYER models THL-200 through THL- 5000

HEATLESS REGENERATIVE COMPRESSED AIR DRYER models THL-200 through THL- 5000 P.O Box 879 50 W. 6th Ave. - unit P Broomfield, CO 8008 Phone:0-65-06 Order Entry Fax: 0-65-99 www.airdryers.com INSTALLATION, OPERATION & MAINTENANCE MANUAL FOR HEATLESS REGENERATIVE COMPRESSED AIR DRYER

More information

20 21,250 SCFM GLOBAL AIR TREATMENT. FIL Series

20 21,250 SCFM GLOBAL AIR TREATMENT. FIL Series 20 21,250 SCFM GLOBAL AIR TREATMENT FIL Series World Class Filtration FIL Series Filters provide your compressed air system with premium quality filtration for the three typical contaminant types Solid

More information

DESICCANT DRYER USER MANUAL

DESICCANT DRYER USER MANUAL DESICCANT DRYER USER MANUAL AHLD Series Heatless Regenerative 70-4,000 scfm WARRANTY NOTICE Failure to follow the instructions and procedures in this manual, or misuse of this equipment, will void its

More information

HS Dryer. Smart Solutions for Drying Compressed Air. Single Tower Heat Reactivated Desiccant Air Dryer. Engineered Air Products

HS Dryer. Smart Solutions for Drying Compressed Air. Single Tower Heat Reactivated Desiccant Air Dryer. Engineered Air Products Smart Solutions for Drying Compressed Air Single Tower Heat Reactivated Desiccant Air Dryer TM HS Dryer 800.943.794 www.engineeredairproducts.com Engineered Air Products Understanding Compressed Air Moisture

More information

SECTION AIR COMPRESSORS AND ACCESSORIES

SECTION AIR COMPRESSORS AND ACCESSORIES PART 1 GENERAL 1.01 WORK INCLUDED SECTION 11370 AIR COMPRESSORS AND ACCESSORIES A. This specification includes air compressors with air dryers. B. Furnish, install, start-up, and test air compressors and

More information

HR Heated HB Blower. Smart Solutions for Drying Compressed Air. Dual Tower Heat Reactivated Desiccant Air Dryer

HR Heated HB Blower. Smart Solutions for Drying Compressed Air. Dual Tower Heat Reactivated Desiccant Air Dryer Smart Solutions for Drying Compressed Air Dual Tower Heat Reactivated Desiccant Air Dryer HR Heated HB Blower 800.943.794 www.engineeredairproducts.com Engineered Air Products Moisture in compressed air

More information

Equipment Designed for Industrial Applications

Equipment Designed for Industrial Applications Equipment Designed for Industrial Applications Industrial equipment with moving components requires maintenance. As a manufacturer of industrial equipment we strive to produce a product that operates as

More information

Quality Components as a basis for Quality Equipment

Quality Components as a basis for Quality Equipment Above & Beyond Regenerative Type Compressed Air Dryers SPS - Heatless Regenerative Dryers SPEH - External Heated Regenerative Dryers SPBS - Heated Blower Purge Regenerative Dryers Quality Components as

More information

OPERATING MANUAL MODEL AIR 1500TM AIR DRYER

OPERATING MANUAL MODEL AIR 1500TM AIR DRYER OPERATING MANUAL MODEL AIR 500TM AIR DRYER Puregas, LLC 226-A Commerce St. Tel: 800-52-535 Broomfield, Colorado Fax: 303-657-2205 P/N P0255 REV A, 02/9/4 TABLE OF CONTENTS.0 GENERAL... 3 2.0 SPECIFICATIONS...

More information

Laboratory Open Scroll Air Compressor System with Premium NFPA Controls

Laboratory Open Scroll Air Compressor System with Premium NFPA Controls Laboratory Open Scroll Air Compressor System with Premium NFPA Controls Specification General The Powerex Laboratory Open Scroll Air Compressor System is designed to provide clean, dry air for applications

More information

SSB Blower Purge Desiccant Dryers SSE Heat Reactivated Desiccant Dryers 220 to 10,500 scfm

SSB Blower Purge Desiccant Dryers SSE Heat Reactivated Desiccant Dryers 220 to 10,500 scfm SSB Blower Purge Desiccant Dryers SSE Heat Reactivated Desiccant Dryers 220 to 10,500 scfm Dry air as low as -100 F pressure dew point Clean, dry compressed air solves the problems of moisture contamination

More information

Modular Adsorption Dryers

Modular Adsorption Dryers 01 GB Modular Adsorption Dryers Highly efficient air treatment Innovative compressed air treatment A-Series Totally dry and clean air The A-Series modular compressed air dryers - a dedicated solution for

More information

H & HC Heat-Of-Compression Air Dryers

H & HC Heat-Of-Compression Air Dryers H & HC Heat-Of-Compression Air Dryers Air Quality Solutions by Ingersoll-Rand Introduction Heat-of-compression dryers are dual tower, desiccant designs. The HOC dryer is the most energy efficient dryer

More information

EN Installation and Operation Manual

EN Installation and Operation Manual EN Installation and Operation Manual Heatless Regenerated Dryer DRYPOINT XC Premium Series XCp models 80 to 800 with BEKOTOUCH Controller READ MANUAL FIRST BEFORE INSTALLATION AND OPERATION Contents 1.

More information

Regenerative Desiccant Dryers. KAD, KED, KBD, and Hybritec Series. kaeser.com

Regenerative Desiccant Dryers. KAD, KED, KBD, and Hybritec Series. kaeser.com Regenerative Desiccant Dryers KAD, KED, KBD, and Hybritec Series kaeser.com Desiccant Air Dryers The right dryer for you Most compressed air applications can achieve the required air quality by using a

More information

DRY-PAK INDUSTRIAL AIR DRYER Installation and Instruction Manual

DRY-PAK INDUSTRIAL AIR DRYER Installation and Instruction Manual DRRRRDRY-PAK Instruction and Installation Manual IB-160 Rev. B P/N 36595 Registered by UL to ISO 9001 DRY-PAK INDUSTRIAL AIR DRYER Installation and Instruction Manual INSTALLATION: Models DS0-00-000 through

More information

Titus Air Systems. TDD Series. The need for clean and dry compressed air. Energy efficiency

Titus Air Systems. TDD Series. The need for clean and dry compressed air. Energy efficiency Titus Air Systems TDD Series The Company Since 1986, our company has been known for delivering high quality compressed air and gas system solutions. In moving from being a local sales and service provider

More information

Trident Breathing Air System

Trident Breathing Air System Trident Breathing Air System INSTALLATION, OPERATION, MAINTENANCE PSA Type Breathing Air Dryer Dealer: This manual MUST be given to the end user. User: BEFORE using this product, read this manual and preserve

More information

Refrigerated & Desiccant Compressed Air Dryer Product Selector

Refrigerated & Desiccant Compressed Air Dryer Product Selector Refrigerated & Desiccant Compressed Air Dryer Product Selector ASD and HTD Series Refrigerated Dryer Units DD Series Desiccant Dryer Units Service Parts For faster service and to avoid errors, please use

More information

ultra-high purity compressed air dryers flow capacity: scfm ( Nm 3 /hr)

ultra-high purity compressed air dryers flow capacity: scfm ( Nm 3 /hr) snowstorm filled ultra-high purity compressed air dryers flow capacity: 3-1110 scfm (5-1900 Nm 3 /hr) D 1 2 3 ultra-high purity compressed air dryers flow capacity: 3-1110 scfm (5-1900 Nm 3 /hr) D 1 2

More information

CAMAIR THE LEADER IN DRY AIR TECHNOLOGY

CAMAIR THE LEADER IN DRY AIR TECHNOLOGY CAMAIR THE LEADER IN DRY AIR TECHNOLOGY INSTALLATION AND OPERATING INSTRUCTIONS XL100 Z Semi Automatic Dryer 1984 2007 Page 2 Page 3 Page 4 Page 5 Page 6 Page 7 Receiving and Inspection Locating the dryer

More information

industry revolves around VDWM Wall Mount Desiccant Dryer 7 50 SCFM

industry revolves around VDWM Wall Mount Desiccant Dryer 7 50 SCFM industry revolves around VWM Wall Mount esiccant ryer 7 50 SCFM VWM Series Benefits Consistent outlet pressure dew points desiccant beds and cycle time optimized to produce -40 F (-40 C) pressure dew point

More information

ARV -3 & ARV -10 Active Reservoir Vent Installation and Operation Manual

ARV -3 & ARV -10 Active Reservoir Vent Installation and Operation Manual ARV -3 & ARV -10 Active Reservoir Vent Installation and Operation Manual Manual P568800 Rev 1, Mar 30, 2010 1 As the installer or operator, you should make yourself familiar with this Installation and

More information

UltraDry s Features and Benefits

UltraDry s Features and Benefits pneuaire UltraDry s...........................................3-5 Features and Benefits..............................................................................3 How to Order....................................................................................4

More information

Heat Les Desiccant Compressed Air Dryers. DSE Series DSS Series DHD Series

Heat Les Desiccant Compressed Air Dryers. DSE Series DSS Series DHD Series Heat Les Desiccant Compressed Air Dryers DSE Series DSS Series DHD Series DSE, DSS and DHD Series Heat Les Desiccant Dryers For decades, compressed air users have relied on Pneumatic Products to deliver

More information

CDH Series Heatless Desiccant Dryers CFM

CDH Series Heatless Desiccant Dryers CFM CDH Series Heatless Desiccant Dryers 0 500 CFM NEW Engineered to Save CDH Desiccant Dryers Customizable Performance CompAir CDH Series Heatless Desiccant Dryers were designed to help you meet your goals.

More information

Installation, Operation, and Maintenance Manual Balston Model 76-01, 76-02, 76-10, and Membrane Air Dryers

Installation, Operation, and Maintenance Manual Balston Model 76-01, 76-02, 76-10, and Membrane Air Dryers Installation, Operation and Maintenance Manual Installation, Operation, and Maintenance Manual Balston Model 76-01, 76-02, 76-10, 76-20 and Membrane Air Dryers Model 76-20 Models 76-01, 76-02, 76-10 Figure

More information

CDWM Series Wall Mount Desiccant Dryer 7 50 SCFM

CDWM Series Wall Mount Desiccant Dryer 7 50 SCFM CWM Series Wall Mount esiccant ryer 7 50 SCFM NEW Engineered to Save CWM Series Benefits Consistent outlet pressure dew points desiccant beds and cycle time optimized to produce -40 F (-40 C) pressure

More information

Externally Heated Desiccant Air Dryer RP Series

Externally Heated Desiccant Air Dryer RP Series Externally Heated Desiccant Air Dryer RP Series Externally Heated Desiccant Compressed Air Dryers Reduce Purge Air Energy Costs For decades, compressed air users have relied on Deltechto deliver technology

More information

CDT Series MCGUIRE AIR COMPRESSORS INC MCGUIRE AIR COMPRESSORS INC Heatless Desiccant Air Dryers 40 5,400 SCfm

CDT Series MCGUIRE AIR COMPRESSORS INC MCGUIRE AIR COMPRESSORS INC Heatless Desiccant Air Dryers 40 5,400 SCfm CDT Series Heatless Desiccant Air Dryers 40 5,400 SCfm ISO Quality Dew Points Three Controller Selection NEMA4 Electrical Construction Standard on Two Controllers Purge Optimal Savings 2 Personalized Performance

More information

Desiccant Air Dryers. Heatless, Heated and Heated Blower

Desiccant Air Dryers. Heatless, Heated and Heated Blower Desiccant Air Dryers Heatless, Heated and Heated Blower Desiccant Dryers... When we designed the Ingersoll Rand heatless, heated and heated blower desiccant dryers we set our sights on creating the most

More information

Waveguide Dehydrators

Waveguide Dehydrators Waveguide Dehydrators Clean & Dry Air For Clear Communications Rugged & Reliable Compressed Air Systems for: TV and Radio Broadcast Applications Satellite Radar Aerospace Telecommunications Military Custom

More information

Compressed Air. Filtration. Balston Membrane Nitrogen Generators. 157 Parker Hannifin Corporation

Compressed Air. Filtration. Balston Membrane Nitrogen Generators. 157 Parker Hannifin Corporation Filtration Balston Membrane Nitrogen Generators Compressed Air Dryers 157 Parker Hannifin Corporation Membrane Air Dryers Provide Clean, Dry Compressed Air Offer a reliable, efficient, and economical alternative

More information

Heated purge desiccant compressed air dryers. hpd Series

Heated purge desiccant compressed air dryers. hpd Series Heated purge desiccant compressed air dryers hpd Series dedicated to excellence Since 1948, compressed air users around the world have relied on Hankison to provide innovative compressed air treatment

More information

FACT SHEET 3. Efficient Compressed Air Treatment. How to save energy, reduce costs and help the environment

FACT SHEET 3. Efficient Compressed Air Treatment. How to save energy, reduce costs and help the environment FACT SHEET 3 How to save energy, reduce costs and help the environment COMPRESSED AIR TREATMENT All compressed air needs some form of treatment to achieve the desired air quality. This guide investigates

More information

Adsorption Air Dryers

Adsorption Air Dryers Adsorption Air Dryers ADS 1 to 215 Clean and dry air. Prevent the risks, enjoy the benefits. AVAILABILITY PARTNERSHIP SERVICEABILITY TECHNOLOGY YOU CAN TRUST RELIABILITY SIMPLICITY AVAILABILITY PARTNERSHIP

More information

Global Leader in Efficiently Treating Compressed Air EXCELLENCE IN DESIGN, MANUFACTURING AND SERVICE

Global Leader in Efficiently Treating Compressed Air EXCELLENCE IN DESIGN, MANUFACTURING AND SERVICE Global Leader in Efficiently Treating Compressed Air EXCELLENCE IN DESIGN, MANUFACTURING AND SERVICE REFRIGERATED AIR DRYING TECHNOLOGIES HPR SERIES REFRIGERATED DRYERS Dry Compressed Air... Pure and Simple

More information

GRF-SERIES REFRIGERATION TYPE NON CYCLING STANDARD

GRF-SERIES REFRIGERATION TYPE NON CYCLING STANDARD Great Lakes Air Products 1515 S. Newburgh Road Westland, MI 48186 PH: 734-326-7080 www.glair.com COMPRESSED AIR DRYER INSTRUCTION MANUAL GRF-SERIES REFRIGERATION TYPE NON CYCLING STANDARD Contents Introduction

More information

DRYAIRE DESICCANT SYSTEM MODEL 6760

DRYAIRE DESICCANT SYSTEM MODEL 6760 MODEL 6760 THE SPRAY GUN PEOPLE FOR PRODUCT INFORMATION CALL: 1-800-742-7731 System Description Sharpe s DRYAIRE Desiccant Air Drying System is the painter s insurance for removing dirt, water, oil, and

More information

Owner s Manual Refrigerated Compressed Air Dryers Model F-100

Owner s Manual Refrigerated Compressed Air Dryers Model F-100 Owner s Manual Refrigerated Compressed Air Dryers Model F-100 Read carefully before attempting to assemble, install, operate or maintain the product described. Protect yourself and others by observing

More information

SERIES HC Heat-of-Compression Compressed Air Dryer

SERIES HC Heat-of-Compression Compressed Air Dryer SERIES HC Heat-of-Compression Compressed Air Dryer Models HC-3 HC-239 Information When making inquiries, please provide the following information: 1) Equipment Model Number 2) Equipment Serial Number 3)

More information

Compressed Air Filters

Compressed Air Filters Compressed Air Filters Superior Filtration for Increased Productivity What happens when you don t use an air filter? Kaeser Gives You the Air Quality You Require Ambient air contains contaminants that

More information

Heatless Air Dryers AIRTEK PREMIUM PRODUCTS FOR INDUSTRY. TW Series

Heatless Air Dryers AIRTEK PREMIUM PRODUCTS FOR INDUSTRY. TW Series Heatless Air Dryers AIRTEK PREMIUM PRODUCTS FOR INDUSTRY TW Series Heatless Air Dryer Operation Airtek Heatless Dryers remove water vapor from compressed air through a process known as Pressure Swing Adsorption.

More information

DESICCANT DRYER USER MANUAL

DESICCANT DRYER USER MANUAL DESICCANT DRYER USER MANUAL ABP Series Blower Purge 800-10,000 scfm WARRANTY NOTICE Failure to follow the instructions and procedures in this manual, or misuse of this equipment, will void its warranty.

More information

Vertical Dryer Owner s Manual

Vertical Dryer Owner s Manual DSV-250, DSV-450, DSV-750, DSV-1000, DSV-1200 & DSV-1600 Models Model DSV-250 DSV-450 DSV-750 DSV-1000 DSV-1200 DSV-1600 Regulator Setting For Air Motors 22 PSI TO GET 3450 RPM 20 PSI TO GET 1725 RPM 22

More information

A Primer for Air Dryer Selection

A Primer for Air Dryer Selection HYDRAULICS EXTRACTED FROM NOVEMBER 1980 & PNEUMATICS UPDATED JUNE 2015 A Primer for Air Dryer Selection Energy and maintenance costs are key factors in choosing these important components By Charles Henderson,

More information

High Efficiency Compressed Air Dryers. Adsorption Dryers Modular System INTELLIGENT AIR TECHNOLOGY

High Efficiency Compressed Air Dryers. Adsorption Dryers Modular System INTELLIGENT AIR TECHNOLOGY High Efficiency Compressed Air Dryers Adsorption Dryers Modular System INTELLIGENT AIR TECHNOLOGY Adsorption Dryers Modular System Compressed air purification equipment must deliver uncompromising performance

More information

Compressed Air Dryers

Compressed Air Dryers The world s highest efficiency and heavy duty Desiccant at affordable prices Up to 300 SCFM Point of use dryers Supplement to a central system Zero air loss Applications: Sand Blasting Paint Spraying Dust

More information

Owner s Manual Refrigerated Compressed Air Dryers Models F-3528, F-3529, F-3530, F-3531 & F-3532

Owner s Manual Refrigerated Compressed Air Dryers Models F-3528, F-3529, F-3530, F-3531 & F-3532 Owner s Manual Refrigerated Compressed Air Dryers Models F-3528, F-3529, F-3530, F-3531 & F-3532 Read carefully before attempting to assemble, install, operate or maintain the product described. Protect

More information

Unique, Energy-Saving Models HC & SP World Leader in Regenerative Dryer Technology

Unique, Energy-Saving Models HC & SP World Leader in Regenerative Dryer Technology Sahara-Pak Heat-of-Compression Regenerative Compressed Air Dryers Unique, Energy-Saving Models HC & SP World Leader in Regenerative Dryer Technology World Leader in Regenerative Dryer Technology The Competetive

More information

The leader in gas dehydration & filtration

The leader in gas dehydration & filtration The leader in gas dehydration & filtration wellhe ad production instrument and fuel gas l andfill & digester gas coal-bed methane off shore Van Gas Technologies specializes in natural gas and biogas dehydration

More information

Laboratory Open Scroll Air Compressor System with Premium NFPA Controls Rev. 06/27/14

Laboratory Open Scroll Air Compressor System with Premium NFPA Controls Rev. 06/27/14 Laboratory Open Scroll Air Compressor System with Premium NFPA Controls Rev. 06/27/14 GENERAL The Powerex Laboratory Open Scroll Air Compressor System is designed to provide clean, dry air for applications

More information

Helpful Hints on Preparing Compressed Air

Helpful Hints on Preparing Compressed Air Helpful Hints on Preparing Compressed Air Contents Compresses Air Distribution............................1 Compressed Air Drying................................3 Compressed Air Filtration..............................6

More information