SERVICE MANUAL MUZ-GB50VA - MUZ-GB50VA - E2 OUTDOOR UNIT. No. OB455 REVISED EDITION-D. Wireless type Models HFC

Size: px
Start display at page:

Download "SERVICE MANUAL MUZ-GB50VA - MUZ-GB50VA - E2 OUTDOOR UNIT. No. OB455 REVISED EDITION-D. Wireless type Models HFC"

Transcription

1 SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS Revision D: RoHS PARTS LIST has been changed. Please void OB455 REVISED EDITION-C. OUTDOOR UNIT SERVICE MANUAL HFC utilized R40A. OB455 REVISED EDITION-D Wireless type Models E MUZ-B50VA - MUZ-B50VA - E2 Indoor unit service manual MSZ-B VA Series (OB454) Refrigerant service manual R40A REFRIERANT (OBR0) CONTENTS. TECHNICAL CHANES 2 2. PART NAMES AND FUNCTIONS 3 3. SPECIFICATION 3 4. NOISE CRITERIA CURVES 4 5. OUTLINES AND DIMENSIONS 5 6. WIRIN DIARAM 6 7. REFRIERANT SYSTEM DIARAM 7 8. PERFORMANCE CURVES 9 9. ACTUATOR CONTROL 4 0. TROUBLESHOOTIN 5. DISASSEMBLY INSTRUCTIONS RoHS PARTS LIST 38 NOTE: This service manual describes technical data of the outdoor units.

2 Revision A: Compressor has been changed. Previous New Model SNB30FLDH SNB30FLDH RoHS PARTS LIST number E E Revision B: REFRIERANT SYSTEM DIARAM has been changed. Oil separator has been added. Capillary tube has been added. ([.8 [ ) MUZ-B50VA- E2 has been added. Check of outdoor thermistors(0-6.b) has been corrected. Revision C: RoHS PARTS LIST has been changed. Revision D: RoHS PARTS LIST has been changed. TECHNICAL CHANES MUZ-A50VA - E MUZ- B50VA - E. Refrigerant filling capacity has been changed. 2. Outdoor electronic control P.C. board has been changed. MUZ-B50VA - E MUZ- B50VA - E2. Compressor has been changed. (SNB30FLDH SNB30FLEH) 2. Outdoor electronic control P.C. board has been changed. 2

3 2 PART NAMES AND FUNCTIONS MUZ-B50VA Air inlet (back and side) ACCESSORIES Piping Drain hose 2 Drain socket Drain cap [33 MUZ-B50VA 2 Air outlet Drain outlet 3 SPECIFICATION Outdoor model MUZ-B50VA Capacity Electrical data Function Power supply Capacity Rated frequency(min.-max.) Dehumidification Air flow (High/Low) Power outlet Running current Power input Power factor Starting current Compressor motor current Fan motor current A Coefficient of performance(c.o.p) Model E E2 Compressor Fan motor Special remarks Output Winding resistance(at 20:) Model Winding resistance(at 20:) Dimensions WOHOD Weight Sound level (High/Low) Fan speed (High/Low) Fan speed regulator Refrigerant filling capacity(r40a) Refrigeration oil (Model) kw r/h K /h A A W % A A W " " mm kg db(a) rpm kg Cooling 5.0( ) 2.5 2,940/, , /5 800/480 Single phase 230V,50Hz SNB30FLDH or SNB30FLDH SNB30FLEH 850 U-V 0.45 W-U 0.45 V-W 0.45 RC0J60-AA BLK-WHT 5.2 WHT-RED 5.2 RED-BLK o850o NEO22 Heating 5.8( ) 2,940/2, , /53 800/620 NOTE : Test conditions are based on ISO 55. Cooling : Indoor Dry-bulb temperature 27:Wet-bulb temperature 9: Outdoor Dry-bulb temperature 35:Wet-bulb temperature 24: Heating : Indoor Dry-bulb temperature 20:Wet-bulb temperature 5: Outdoor Dry-bulb temperature 7: Wet-bulb temperature 6: Refrigerant piping length (one way): 5m Measured under rated operating frequency 3

4 Specifications and rating conditions of main electric parts Item Current transformer Current transformer Smoothing capacitor Fuse Fuse Fuse Expansion valve coil Intelligent power module Intelligent power module Reactor Power factor controller Resistor Resistor Resistor Solenoid coil relay Terminal block Terminal block Relay R.V. coil Model (CT,2) (CT6) (CB,2,3) (F64) (F80) (F9) (LEV) (IPM) (HC930) (L) (PFC) (R64A,B) (R937A,B) (RS~4) (SSR6) (TB) (TB2) (X64) (2S4) MUZ-B50VA ETQ9Z68AY ETQ9Z53AY V 250V 2A 250V 3.5A 250V A CAM-MD2ME PS2244-A PS266-RZ 340µH 20A PS5259-A 0" 0W." 2W 2% 0.04" 7W TLP3506 3P 3P 4A LD NOISE CRITERIA CURVES MUZ-B50VA FAN SPEED High FUNCTION SPL(dB(A)) LINE COOLIN 52 HEATIN OCTAVE BAND SOUND PRESSURE LEVEL, 0dB=20µPa APPROXIMATE THRESHOLD OF HEARIN FOR CONTINUOUS NOISE NC-70 NC-60 NC-50 NC-40 NC-30 NC-20 Test conditions Cooling : Dry-bulb temperature 35: Wet-bulb temperature (24:) Heating : Dry-bulb temperature 7: Wet-bulb temperature 6: MICROPHONE OUTDOOR UNIT m BAND CENTER FREQUENCIES, Hz 4

5 OUTLINES AND DIMENSIONS MUZ-B50VA Unit: mm REQUIRED SPACE 00 mm or more Open as a rule 500 mm or more if the front and both sides are open 00 mm or more 200 mm or more if there are obstacles to both sides Open as a rule 500 mm or more if the back, both sides and top are open 350 mm or more Service panel 850 Liquid refrigerant pipe joint Refrigerant pipe (flared) [ as refrigerant pipe joint Refrigerant pipe (flared) [2.7 5

6 6 WIRIN DIARAM MUZ-B50VA R64B WHT BLU LDE2 CN92 YLW BRN RN/YLW NOISE FILTER P.C.BOARD TO INDOOR UNIT CONNECTIN 230V~ TB2 S 2-24V S3 3 CN6 RED CN CN3 2 PFC POWER SUPPLY ~/N 230V 50Hz CIRCUIT BREAKER RT65 R64A NR64 CN RS RS2 RS3 RS4 LD9 POWER BOARD RN RT64 F80 RED WHT CB CB2 CB3 BLU WHT BLU NF ELECTRONIC CONTROL P.C.BOARD L BLK BLK BLK IPM CT2 CT U RY PNK ORN BLU YLW RED WHT BLK RED BLK HC930 BLK BLK BLK BLK BLK BLK BLK BLK BLK BLK RN RN BLU BLU SSR6 CN CN795 6 CN4 2 W 3 CN60 S2 TAB CT6 2 X CN CN702 2 CN70 LD2 3 LD CN80 CN LDE F9 F64 TB L N PE TAB2 2S4 TAB4 2 RED RED S 3 4 YLW R 7 2 CN CN2 2 CN903 2 CN5 RT6 RT62 RT68 LEV T80 R937A R937B CN932 V V WHT W MC U MF SYMBOL NAME CB~3 SMOOTHIN CAPACITOR CT, 2 CURRENT TRANSFORMER CT6 CURRENT TRANSFORMER F64 FUSE (T2AL 250V) F80 FUSE (T3.5AL 250V) FUSE (TAL 250V) F9 HC930 INTELLIENT POWER MODULE IPM INTELLIENT POWER MODULE L REACTOR LEV EXPANSION VALVE COIL SYMBOL NAME MC COMPRESSOR MF RT6 RT62 OUTDOOR FAN MOTOR NOISE FILTER NF NR64 VARISTOR PFC R64A,B RESISTOR POWER FACTOR CONTROLLER R937A, B RESISTOR RS~4 RESISTOR DEFROST THERMISTOR DISCHARE TEMPERATURE THERMISTOR SYMBOL NAME RT64 FIN TEMPERATURE THERMISTOR RT65 AMBIENT TEMPERATURE THERMISTOR RT68 OUTDOOR HEAT EXCHANER TEMPERATURE THERMISTOR T80 TRANSFORMER SSR6 SOLENOID COIL RELAY TB TERMINAL BLOCK TB2 TERMINAL BLOCK X64 RELAY 2S4 R.V. COIL NOTES:.About the indoor side electric wiring refer to the indoor unit electric wiring diagram for servicing. 2.Use copper conductors only (for field wiring). 3.Symbols below indicate. :Terminal block :Connector 6

7 7 REFRIERANT SYSTEM DIARAM MUZ-B50VA- E Unit:mm 4-way valve Muffler #00 Refrigerant pipe [2.7 (with heat insulator) Flared connection Stop valve (with service port) Discharge temperature thermistor RT62 Defrost thermistor RT6 Outdoor heat exchanger Ambient temperature thermistor RT65 Flared connection Refrigerant pipe [6.35 (with heat insulator) Stop valve Strainer Receiver #00 Capillary tube [3.6 [ Compressor LEV Strainer #00 Outdoor heat exchanger temperature thermistor RT68 R.V. coil OFF ON Refrigerant flow in cooling Refrigerant flow in heating MUZ-B50VA- E MUZ-B50VA- E2 Unit:mm Refrigerant pipe [2.7 (with heat insulator) Capillary tube [.8 [ Oil separator 4-way valve Flared connection Stop valve (with service port) Strainer Defrost #00 thermistor RT6 Discharge temperature thermistor RT62 Outdoor heat exchanger Ambient temperature thermistor RT65 Flared connection Refrigerant pipe [6.35 (with heat insulator) Strainer Receiver #00 Stop valve Capillary tube [3.6 [ Compressor LEV Strainer #00 Outdoor heat exchanger temperature thermistor RT68 R.V. coil heating ON cooling OFF Refrigerant flow in cooling Refrigerant flow in heating 7

8 MAX. REFRIERANT PIPIN LENTH and MAX. HEIHT DIFFERENCE Model MUZ-B50VA Refrigerant piping : m Max. length Max. Height difference A B 30 5 Piping size O.D : mm as Liquid Indoor unit Max. Height difference B Max. length A Outdoor unit ADDITIONAL REFRIERANT CHARE (R40A:g) Model Outdoor unit precharged 7m 0m Refrigerant piping length (one way) 5m 20m 25m 30m MUZ-B50VA, Calculation : Xg=20g/m (Refrigerant piping length (m) 7) NOTE : Refrigerant piping exceeding 7m requires additional refrigerant charge according to the calculation. 8

9 8 PERFORMANCE CURVES MUZ-B50VA The standard specifications apply only to the operation of the air conditioner under normal conditions. Since operating conditions vary according to the areas where these units are installed, the following information has been provided to clarify the operating characteristics of the air conditioner under the conditions indicated by the performance curve. () UARANTEED VOLTAE 98 ~ 264V, 50Hz (2) AIR FLOW Air flow should be set at MAX. (3) MAIN READINS () Indoor intake air wet-bulb temperature : C [WB] (2) Indoor outlet air wet-bulb temperature : C [WB] (3) Outdoor intake air dry-bulb temperature : C [DB] (4) Total input: W (5) Indoor intake air dry-bulb temperature : C [DB] (6) Outdoor intake air wet-bulb temperature : C [WB] (7) Total input : W Indoor air wet/dry-bulb temperature difference on the left side of the following chart shows the difference between the indoor intake air wet/dry-bulb temperature and the indoor outlet air wet/dry-bulb temperature for your reference at service. } } Cooling Heating How to measure the indoor air wet-bulb / dry-bulb temperature difference. Attach at least 2 sets of wet and dry-bulb thermometers to the indoor air intake as shown in the figure, and at least 2 sets of wet and dry-bulb thermometers to the indoor air outlet. The thermometers must be attached to the position where air speed is high. 2. Attach at least 2 sets of wet and dry-bulb thermometers to the outdoor air intake. Cover the thermometers to prevent direct rays of the sun. 3. Check that the air filter is cleaned. 4. Open windows and doors of room. 5. Press the EMERENCY OPERATION switch once (twice) to start the EMERENCY COOL (HEAT) MODE. 6. When system stabilizes after more than 5 minutes, measure temperature and take an average temperature minutes later, measure temperature again and check that the temperature does not change. INDOOR UNIT OUTDOOR UNIT Wet and dry-bulb thermometers Wet and dry-bulb thermometers 8-. Capacity and input curves Indoor air Wet-bulb temperature difference (:) Indoor intake air Wet-bulb temperature (:) Indoor intake air Wet-bulb temperature (:) MSZ-B50VA MUZ-B50VA at Rated frequency Outdoor intake air Dry-bulb temperature (:) Outdoor intake air Dry-bulb temperature (:) 9

10 Indoor air Dry-bulb temperature difference (:) Indoor intake air Dry-bulb temperature (:) Indoor intake air Dry-bulb temperature (:) MSZ-B50VA MUZ-B50VA at Rated frequency Outdoor intake air Wet-bulb temperature (:) Outdoor intake air Wet-bulb temperature (:) NOTE:The above broken lines are for the heating operation without any frost and defrost operation Capacity and input correction by operational frequency of compressor MUZ-B50VA Correction of Cooling capacity.5 Correction of Cooling total input Correction of Heating capacity.5.5 Correction of Heating total input 2.0 Capacity correction factors Input correction factors Capacity correction factors Input correction factors (Hz) (Hz) (Hz) (Hz) The operational frequency of compressor The operational frequency of compressor The operational frequency of compressor The operational frequency of compressor 8-3. Test run operation (How to operate fixed-frequency operation). Press EMERENCY OPERATION switch to COOL or HEAT mode (COOL : Press once, HEAT : Press twice). 2. Test run operation starts and continues to operate for 30 minutes. 3. Compressor operates at rated frequency in COOL mode or 58Hz in HEAT mode. 4. Indoor fan operates at High speed. 5. After 30 minutes, test run operation finishes and EMERENCY OPERATION starts (Operation frequency of compressor varies). 6. To cancel test run operation (EMERENCY OPERATION), press EMERENCY OPERATION switch or any button on remote controller. 0

11 8-4. OUTDOOR LOW PRESSURE AND OUTDOOR UNIT CURRENT NOTE: The unit of pressure has been changed to MPa based on the international system of units (SI unit system). The conversion factor is: (MPa [auge] = 0.2 (Kgf/f [auge]) COOL operation Both indoor and outdoor unit are under the same temperature/humidity condition. 2 Operation : TEST RUN OPERATION (refer to 8-3.) Dry-bulb temperature(:) Relative humidity(%) MUZ-B50VA (kgf/f [auge])(mpa [auge]) Outdoor low pressure Outdoor unit current(a) ( C) (%) Ambient temperature( C) Ambient humidity(%) ( C) (%) Ambient temperature( C) Ambient humidity(%) HEAT operation Condition : Dry bulb temperature ( C) Wet bulb temperature ( C) Indoor Outdoor Operation : TEST RUN OPERATION (refer to 8-3.) 8 MUZ-B50VA Outdoor unit current (A) ( C) Ambient temperature( C)

12 PERFORMANCE DATA COOL operation at Rated frequency MSZ-B50VA : MUZ-B50VA CAPACITY:5.0(kW) SHF:0.69 INPUT:650(W) OUTDOOR DB(:) INDOOR INDOOR DB(:) WB(:) Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT NOTE Q : Total capacity (kw) SHF : Sensible heat factor DB : Dry-bulb temperature SHC : Sensible heat capacity (kw) INPUT : Total power input (W) WB : Wet-bulb temperature 2

13 PERFORMANCE DATA COOL operation at Rated frequency MSZ-B50VA : MUZ-B50VA CAPACITY:5.0(kW) SHF:0.69 INPUT:650(W) OUTDOOR DB(:) INDOOR INDOOR DB(:) WB(:) Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT NOTE Q : Total capacity (kw) SHF : Sensible heat factor DB : Dry-bulb temperature SHC : Sensible heat capacity (kw) INPUT : Total power input (W) WB : Wet-bulb temperature 3

14 PERFORMANCE DATA HEAT operation at Rated frequency MSZ-B50VA : MUZ-B50VA CAPACITY:5.8(kW) INPUT:700(W) OUTDOOR WB(:) INDOOR DB(:) Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT NOTE Q : Total capacity (kw) INPUT : Total power input (W) DB : Dry-bulb temperature WB : Wet-bulb temperature 9 ACTUATOR CONTROL MUZ-B50VA 9-. Outdoor fan motor control The fan motor turns ON/OFF, interlocking with the compressor. [ON] The fan motor turns ON 5 seconds before the compressor starts up. [OFF] The fan motor turns OFF 5 seconds after the compressor has stopped running. Compressor Outdoor fan motor ON OFF ON 5 seconds 5 seconds OFF 9-2. R.V. coil control Heating ON Cooling OFF Dry OFF NOTE: The 4-way valve reverses for 5 seconds right before start-up of the compressor. <COOL> <HEAT> 5 seconds 5 seconds ON Compressor OFF ON R.V.coil OFF Outdoor fan ON motor OFF ON or OFF ON or OFF 4

15 9-3. Relation between main sensor and actuator Sensor Discharge temperature thermistor Indoor pipe temperature thermistor Defrost thermistor Fin temperature thermistor Outdoor heat exchanger temperature Ambient temperature thermistor Purpose Protection Defrosting Protection Defrosting Protection Protection Protection Compressor Actuator Outdoor LEV fan motor R.V. coil 0 TROUBLESHOOTIN MUZ-B50VA 0-. Cautions on troubleshooting. Before troubleshooting, check the following ) Check the power supply voltage. 2) Check the indoor/outdoor connecting wire for miswiring. 2. Take care of the following during servicing ) Before servicing the air conditioner, be sure to turn OFF the main unit first with the remote controller, then after confirming the horizontal vane is closed, turn off the breaker and / or disconnect the power plug. 2) Be sure to turn OFF the power supply before removing the front panel, the cabinet, the top panel, and the electronic control P.C. board. 3) When removing the electrical parts, be careful to the residual voltage of smoothing capacitor. 4) When removing the electronic control P.C. board, hold the edge of the board with care NOT to apply stress on the components. 5) When connecting or disconnecting the connectors, hold the housing of the connector. DO NOT pull the lead wires. Lead wiring Housing point 3. Troubleshooting procedure ) First, check if the OPERATION INDICATOR lamp on the indoor unit is flashing on and off to indicate an abnormality. To make sure, check how many times the abnormality indication is flashing on and off before starting service work. 2) Before servicing check that the connector and terminal are connected properly. 3) When the electronic control P.C. board seems to be defective, check the copper foil pattern for disconnection and the components for bursting and discoloration. 4) When troubleshooting, refer to 0-2., 0-3. and

16 0-2. Failure mode recall function Outline of the function This air conditioner can memorize the abnormal condition which has occurred once. Even though LED indication listed on the troubleshooting check table (0-4.) disappears, the memorized failure details can be recalled. This mode is very useful when the unit needs to be repaired for the abnormality which doesn't recur.. Flow chart of failure mode recall function for the indoor/outdoor unit Operational procedure The cause of abnormality cannot be found because the abnormality doesn't recur. Setting up the failure mode recall function Turn ON the power supply. <Preparation of the remote controller> While pressing both OPERATION SELECT button and TOO COOL button on the remote controller at the same time, press RESET button. 2 First, release RESET button. And release the other two buttons after all LCD except the set temperature in operation display section of the remote controller is displayed after 3 seconds. Press OPERATE/STOP(ON/OFF) button of the remote controller (the set temperature is displayed) with the remote controller headed towards the indoor unit. w Does the left lamp of OPERATION INDICATOR lamp on the indoor unit blink at the interval of 0.5 seconds? Blinks: Either indoor or outdoor unit is abnormal. Beep is emitted at the same timing as the blinking of the left lamp of OPERATION INDICATOR lamp. W2 Judgment of indoor/outdoor abnormality (Blinks) Before blinking, does the left lamp of OPERATION INDICATOR lamp stay ON for 3 seconds? Stays ON for 3 seconds (without beep): The outdoor unit is abnormal. (OFF) W. Regardless of normal or abnormal condition, a short beep is emitted once the signal is received. Indoor unit is normal. But the outdoor unit might be abnormal because there are some abnormalities that can't be recalled with this way. Confirm if outdoor unit is abnormal according to the detailed outdoor unit failure mode recall function.(refer to 0-2.2) The indoor unit is abnormal. Check the blinking pattern, and confirm the abnormal point with the indoor unit failure mode table (Refer to indoor unit service manual.) Make sure to check at least two consecutive blinking cycles. W2 The outdoor unit is abnormal. Check the blinking pattern, and confirm the abnormal point with the outdoor unit failure mode table (Refer to 0-2.3). Make sure to check at least two consecutive blinking cycles. W3 Releasing the failure mode recall function Release the failure mode recall function by the following procedures. Turn OFF the power supply and turn it ON again. Press RESET button of the remote controller. Repair the defective parts. Deleting the memorized abnormal condition After repairing the unit, recall the failure mode again according to "Setting up the failure mode recall function" mentioned above. 2Press OPERATE/STOP(ON/OFF) button of the remote controller (the set temperature is displayed) with the remote controller headed towards the indoor unit. 3Press EMERENCY OPERATION switch so that the memorized abnormal condition is deleted. 4Release the failure mode recall function according to "Releasing the failure mode recall function" mentioned above. te.make sure to release the failure mode recall function once it's set up, otherwise the unit cannot operate properly. 2.If the abnormal condition is not deleted from the memory, the last abnormal condition is kept memorized. W2. Blinking pattern when the indoor unit is abnormal: 2.5-second OFF Blinking at 0.5- second interval 2.5-second OFF Blinking at 0.5- second interval ON OFF Beeps Repeated cycle Beeps Repeated cycle Beeps Repeated cycle W3.Blinking pattern when the outdoor unit is abnormal: Blinking at second OFF 3-second ON second interval 2.5-second OFF 3-second ON Blinking at 0.5- second interval ON OFF beep Repeated cycle Beeps beep Repeated cycle Beeps Repeated cycle 6

17 2. Flow chart of the detailed outdoor unit failure mode recall function Operational procedure The outdoor unit might be abnormal. Confirm if outdoor unit is abnormal according to the following procedures. Confirm that the remote controller is in the failure mode recall function. With the remote controller headed towards the indoor unit, press TOO COOL or TOO WARM button to adjust the set temperature to 25:. W W. Regardless of normal or abnormal condition, 2 short beeps are emitted as the signal is received. Does left lamp of OPERATION INDICATOR lamp on the indoor unit blink at the interval of 0.5 seconds? Blinks: The outdoor unit is abnormal. Beep is emitted at the same timing as the blinking of the left lamp of OPERATION INDICATOR lamp. W2 (Blinks) (OFF) The outdoor unit is abnormal. Check the blinking pattern, and confirm the abnormal point with the outdoor unit failure mode table (Refer to ). Make sure to check at least two consecutive blinking cycles. W2 The outdoor unit is normal. Releasing the failure mode recall function Release the failure mode recall function by the following procedures. Turn OFF the power supply and turn it ON again. Press RESET button of the remote controller. Release the failure mode recall function according to the left mentioned procedure. Repair the defective parts. Deleting the memorized abnormal condition After repairing the unit, recall the failure mode again according to "Setting up the failure mode recall function" mentioned above. 2Press OPERATE/STOP(ON/OFF) button of the remote controller (the set temperature is displayed) with the remote controller headed towards the indoor unit. 3Press EMERENCY OPERATION switch so that the memorized abnormal condition is deleted. 4Release the failure mode recall function according to "Releasing the failure mode recall function" mentioned above. te. Make sure to release the failure mode recall function once it's set up, otherwise the unit cannot operate properly. 2. If the abnormal condition is not deleted from the memory, the last abnormal condition is kept memorized. W2.Blinking pattern when outdoor unit is abnormal: 2.5-second OFF 3-second ON Blinking at 0.5- second interval 2.5-second OFF 3-second ON Blinking at 0.5- second interval ON OFF beep Repeated cycle Beeps beep Repeated cycle Beeps Repeated cycle 7

18 3. Outdoor unit failure mode table MUZ-B50VA The left lamp of OPERATION INDICATOR lamp (Indoor unit) OFF 2-time flash Abnormal point (Failure mode / protection) ne (rmal) Outdoor power system LED indication (Outdoor P.C. board) LED LED Lighting Lighting Condition Overcurrent protection stop is continuously performed 3 times within minute after the compressor gets started, or converter protection stop or bus-bar voltage protection stop is continuously performed 3 times within 3 minutes after start-up. Correspondence Check the connection of the compressor connecting wire. Refer to 0-6.A "How to check inverter / compressor". Check the stop valve. Indoor/outdoor unit failure mode recall function 3-time flash Discharge temperature thermistor Defrost thermistor Ambient temperature thermistor Fin temperature thermistor P.C. board temperature thermistor Outdoor heat exchanger temperature thermistor Lighting Lighting Lighting Once Once Twice Lighting 3 times Lighting 4 times Lighting 9 times Thermistor shorts or opens during compressor running. Refer to 0-6.B "Check of outdoor thermistors". Replace the outdoor electronic control P.C. board. Refer to 0-6.B "Check of outdoor thermistors". 4-time flash 5-time flash Overcurrent Discharge temperature Once oes out Lighting Lighting 28A current flows into intelligent power module. Discharge temperature exceeds 6 C during operation. Compressor can restart if discharge temperature thermistor reads 00: or less 3 minutes later. Reconnect compressor connector. Refer to 0-6.A "How to check inverter/ compressor." Check the stop valve. Check refrigerant circuit and refrigerant amount. Refer to 0-6. "Check of LEV". 6-time flash High pressure Lighting Lighting Tthe outdoor heat exchanger temperature exceeds 70: during cooling or the indoor gas pipe temperature exceeds 70: during heating. Check refrigerant circuit and refrigerant amount. Check the stop valve. 7-time flash Fin temperature P.C. board temperature 3 times oes out 4 times oes out The fin temperature exceeds 87: during operation. The P.C. board temperature exceeds 70: during operation. Check around outdoor unit. Check outdoor unit air passage. Refer to 0-6.D "Check of outdoor fan motor". 8-time flash Outdoor fan motor Lighting Lighting Failure occurs continuously 3 times within 30 seconds after the fan gets started. Refer to 0-6.D "Check of outdoor fan motor". 9-time flash 0-time flash nvolatile memory data Discharge temperature Lighting 5 times Lighting Lighting nvolatile memory data cannot be read properly. The frequency of the compressor is kept 80Hz or more and the discharge temperature is kept under 39: for more than 20 minutes. Replace the outdoor electronic control P.C. board. Check refrigerant circuit and refrigerant amount. Refer to 0-6. "Check of LEV". NOTE : Blinking patterns of this mode differ from the ones of Troubleshooting check table (0-4.). 8

19 The left lamp of OPERATION INDICATOR lamp (Indoor unit) -time flash Abnormal point (Failure mode / protection) Communication error between P.C. boards LED indication (Outdoor P.C. board) LED LED 2 Lighting 6 times Condition Communication error occurs between the electronic control P.C. board and power board for more than 0 seconds. The communication between boards protection stop is continuously performed twice. Correspondence Check the connecting wire between outdoor electronic control P.C. board and power board. Indoor/outdoor unit failure mode recall function Current sensor Zero cross detecting circuit Converter Lighting 7 times 5 times oes out 5 times oes out A short or open circuit is detected in the current sensor during compressor operating. Current sensor protection stop is continuously performed twice. Zero cross signal cannot be detected while the compressor is operating. The protection stop of the zero cross detecting circuit is continuously performed 0 times. A failure is detected in the operation of the converter during operation. Replace the power board. Check the connecting wire among electronic control P.C. board, noise filter P.C. board and power board. Replace the power board. Bus-bar voltage () Bus-bar voltage (2) weven if this protection stop is performed continuously 3 times, it does not mean the abnormality in outdoor power system. 5 times 6 times oes out oes out The bus-bar voltage exceeds 400V or falls to 200V or below during compressor operating. The bus-bar voltage exceeds 400V or falls to 50V or below during compressor operating. NOTE : Blinking patterns of this mode differ from the ones of Troubleshooting check table (0-4.). 9

20 0-3. Instruction of troubleshooting Start Indoor unit operates. Outdoor unit doesn't operate. Indoor unit operates. Outdoor unit doesn't operate normally. Indoor unit doesn't receive the signal from remote controller. OPERATION INDICATOR lamp on the indoor unit is flashing on and off. Outdoor unit operates only in Test Run operation. (Refer to 8-3.) w Outdoor unit doesn't operate even in Test Run operation. (Refer to 8-3.) w Unit doesn't operate normal operation in COOL or HEAT mode. Indoor unit operates, when EMERENCY OPERATION switch is pressed. Indoor unit doesn't operate, when EMERENCY OPERATION switch is pressed. If blinking of OPERATION INDICATOR lamp cannot be checked, it can be checked with failure mode recall function. w "Test Run operation" means the operation within 30 minutes after EMERENCY OPERATION switch is pressed. Check room temperature thermistor. Refer to "Test point diagram and voltage". Refer to 0-6.A "How to check inverter/ compressor". Refer to 0-6.C "Check of R.V. coil". Refer to "Check of remote controller and receiver P.C. board".. Check indoor / outdoor connecting wire. (Check if the power is supplied to the indoor unit.) 2. Refer to "Check of indoor electronic control P.C. board and indoor fan motor". Refer to indoor unit service manual. All lamps Flash on and off at 0.5-second intervals Cause: Indoor unit The horizontal vane is not installed correctly. Left lamp Flash on and off at 0.5-second intervals Cause: Indoor/ Outdoor unit Miswiring or trouble of serial signal. Left lamp 2-time flash Cause: Indoor unit Trouble of room temperature/ indoor coil thermistor Left lamp 3-time flash Cause: Indoor unit Trouble of indoor fan motor Left lamp 4-time flash Cause: Indoor unit Trouble of indoor unit control system Left lamp 5-time flash Cause: Outdoor unit Outdoor power system abnormality Left lamp 6-time flash Cause: Outdoor unit Trouble of thermistor in outdoor unit Left lamp 7-time flash Cause: Outdoor unit Trouble of outdoor control system Left lamp 4-time flash Cause: Outdoor unit Other abnormality Refer to "Check of installation of the horizontal vane". Refer to 0-6.H "How to check miswiring and serial signal error". Check room temperature thermistor and indoor coil thermistor. Refer to "Test point diagram and voltage". Refer to "Check of indoor fan motor". Replace the indoor electronic control P.C. board. Refer to 0-6.A "How to check inverter/ compressor". Refer to 0-6.B "Check of outdoor thermistors". Replace inverter P.C. board or outdoor control electronic control P.C. board. Check "Flow chart of the detailed outdoor unit failure mode recall function." 20

21 0-4. Troubleshooting check table MUZ-B50VA. Symptom Outdoor unit does not operate. Indication LED(Red) LED2(Yellow) Abnormal point / Condition Lightning Twice Outdoor power system Condition Overcurrent protection stop is continuously performed 3 times within minute after the compressor gets started, or when converter protection stop or bus-bar voltage protection stop is continuously performed 3 times within 3 minutes after start-up. Correspondence Check the connection of the compressor connecting wire. Refer to 0-6.A "How to check inverter/compressor". Check the stop valve. 2 Lightning 3 times Discharge temperature thermistor A short circuit is detected in the thermistor during operation, or an open circuit is detected in the thermistor after 0 minutes of compressor start-up. Refer to 0-6.B "Check of outdoor thirmistors". 3 Lightning 4 times Fin temperature thermistor P.C board temperature thermistor Ambient temperature thermistor A short or open circuit is detected in the thermistor during operation. A short or open circuit is detected in the thermistor during operation. Refer to 0-6.B "Check of outdoor thirmistors". Replace the outdoor electronic control P.C. board. 4 Lightning 5 times Outdoor heat exchanger temperature thermistor A short circuit is detected in the thermistor during operation, or an open circuit is detected in the thermistor after 5 minutes (in cooling) and 0 minutes (in heating) of compressor start-up. Refer to 0-6.B "Check of outdoor thirmistors". Defrost thermistor A short circuit is detected in the thermistor during operation, or an open circuit is detected in the thermistor after 5 minutes of compressor start-up. 5 Lightning 6 times Serial signal The communication fails between the indoor and outdoor unit for 3 minutes. Refer to 0-6.H "How to check miswiring and serial signal error" 'Outdoor unit stops and restarts 3 minutes later' is repeated. Lightning 7 times nvolatile memory data The nonvolatile memory data cannot be read properly. Replace the outdoor electronic control P.C. board. Lightning 8 times Current sensor Current sensor protection stop is continuously performed twice. Replace the power board. Lightning times Communication error between P.C. boards Lightning 2 times Zero cross detecting circuit Twice oes out IPM protection Lock protection The communication protection stop between boards is continuously performed twice. The protection stop of the zero cross detecting circuit is continuously performed 0 times. Overcurrent is detected after 30 minutes of compressor start-up. Overcurrent is detected within 30 minutes of compressor start-up. Check the connecting wire between outdoor electronic control P.C. board and power board. Check the connecting wire among outdoor electronic control P.C. board, noise filter P.C. board and power board. Reconnect compressor connector. Refer to 0-6.A "How to check inverter/compressor". Check the stop valve. Check the power module (PAM module). 3 times oes out Discharge temperature protection Discharge temperature exceeds 6:during operation and compressor stops. Compressor can restart if discharge temperature thermistor reads 00: or less 3 minutes later. Check the amount of gas and refrigerant circuit. Refer to 0-6. "Check of LEV" times oes out 5 times oes out Fin temperature protection P.C. board temperature protection High-pressure protection The fin temperature exceeds 87: during operation. The P.C. board temperature exceeds 70: during operation. The outdoor heat exchanger temperature exceeds 70: during cooling or indoor gas pipe temperature exceeds 70:during heating. Check refrigerant circuit and refrigerant amount. Refer to 0-6.D "Check of outdoor fan motor". Check the amount of gas and the refrigerant circuit. Check stop valve times oes out Converter protection A failure is detected in the operation of the converter during operation. Replace the power board. 9 times oes out Bus-bar voltage protection () The bus-bar voltage exceeds 400V or falls to 200V or below during compressor operating. Bus-bar voltage protection (2) The bus-bar voltage exceeds 400V or falls to 50V or below during compressor operating. Replace the power board. 3 times oes out Outdoor fan motor Failure occurs continuously 3 times within 30 seconds after the fan gets started. Refer to 0-6.D "Check of outdoor fan motor". Lighting 8 times Current sensor protection A short or open circuit is detected in the current sensor during compressor operating. Replace the power board. Lighting times Communication error occurs between the outdoor electronic control P.C. board and power board for more than 0 seconds. Zero cross signal cannot be detected while the compressor is operating. Lighting 2 times Communication between P.C. boards protection Zero cross detecting circuit protection Check the connecting wire between outdoor electronic control P.C. board and power board. Check the connecting wire among outdoor electronic control P.C. board, noise filter P.C. board and power board. NOTE. The location of LED is illustrated at the right figure. Refer to LED is lighted during normal operation. The flashing frequency shows the number of times the LED blinks after every 2.5-second OFF. (Example) When the flashing frequency is second ON Outdoor electronic control P.C. board(parts side) LED2 LED Lighting 0.5-second ON ON OFF 2.5-second OFF 2.5-second OFF 2

22 Symptom Outdoor unit operates. Indication LED(Red) LED2(Yellow) Once Lighting Twice Lighting Abnormal point / Condition Primary current protection Secondary current protection High-pressure protection Defrosting in cooling Condition The input current exceeds 5A. The current of the compressor exceeds 5A. The indoor gas pipe temperature exceeds 45: during heating. The indoor gas pipe temperature falls 3: or below during cooling. Correspondence These symptoms do not mean any abnormality of the product, but check the following points. Check if indoor filters are clogged. Check if refrigerant is short. Check if indoor/outdoor unit air circulation is short cycled times Lighting Discharge temperature protection The discharge temperature exceeds 00: during operation. Check refrigerant circuit and refrigerant amount. Refer to 0-6. "Check of LEV". Refer to 0-6.B "Check of outdoor thermistors" times Lighting Low discharge temperature protection The frequency of the compressor is kept 80Hz or more and the discharge temperature is kept under 39: for more than 20 minutes. Refer to 0-6. "Check of LEV". Check refrigerant circuit and refrigerant amount times Lighting Cooling high-pressure protection The outdoor heat exchanger temperature exceeds 58: during operation. This symptom does not mean any abnormality of the product, but check the following points. Check if indoor filters are clogged. Check if refrigerant is short. Check if indoor/outdoor unit air circulation is short cycled. 25 Outdoor unit operates 9 times Lighting Inverter check mode The unit is operated with emergency operation switch Lighting Lighting rmal

23 0-5. Trouble criterion of main parts MUZ-B50VA Part name Check method and criterion Figure Defrost thermistor (RT6) Measure the resistance with a tester. Ambient temperature thermistor (RT65) Outdoor heat exchanger temperature thermistor (RT68) Refer to 0-7. Test point diagram and voltage,. Outdoor electronic control P.C. board, the chart of thermistor. Discharge temperature thermistor (RT62) Measure the resistance with a tester. Before measurement, hold the thermistor with your hands to warm it up. Fin temperature thermistor (RT64) Refer to 0-7. Test point diagram and voltage,. Outdoor electronic control P.C. board, the chart of thermistor. Compressor Measure the resistance between terminals using a tester. (Winding temperature : -0 C ~ 40 C) rmal 0.40 " ~ 0.49 " V WHT W RED U BLK Measure the resistance between lead wires using a tester. (Part temperature : -0 C ~ 40 C) Outdoor fan motor Color of lead wire RED - BLK BLK - WHT WHT - RED rmal 3.4 " ~ 6.4 " RED U (W) WHT V (V) BLK W (U) Measure the resistance using a tester. (Part temperature : -0 C ~ 40 C) R. V. coil rmal 2.6 k" ~ 3.3 k" Linear expansion valve Measure the resistance using a tester.(part temperature : -0 C ~ 40 C) Color of lead wire WHT - RED RED - ORN YLW - BRN BRN - BLU rmal 37.4 " ~ 53.9 " WHT RED ORN LEV YLW BRN BLU 23

24 0-6. Troubleshooting flow MUZ-B50VA A How to check inverter/ compressor Disconnect the terminal of the compressor. 3 minutes after turning on the power supply, start EMERENCY OPERATION. Measure the voltage between each lead wire leading to the compressor. U (BLK) - V (WHT) V (WHT) - W (RED) W (RED) - U (BLK) Is voltage output on right table? Is output balanced? W After the outdoor fan starts running, wait for minute or more before measuring the voltage. The output voltage values have the tolerance of i20%. COOL 22V~54V (56Hz~7Hz) HEAT 74V~26V (30Hz~58Hz) Is the input voltage to the outdoor electronic control P.C. board 370V or more? Replace the power board. Turn off power supply of indoor and outdoor unit, and measure the compressor winding resistance between the compressor terminals. Is the resistance between each terminal normal? Reconnect the lead wire of compressor, and turn on power supply to indoor and outdoor unit. 3 minutes later, start EMERENCY OPERATION. Replace the compressor. Clarify the causes by counting time until the inverter stops. 0 to 0 seconds: compressor rare short 0 to 60 seconds: compressor lock 60 seconds to 5minutes: refrigerant circuit defective 5 minutes or more: normal 24

25 When OPERATION INDICATOR lamp flashes 6-time. When thermistor is abnormal. B Check of outdoor thermistors Disconnect the connector in the outdoor electronic control P.C. board or the outdoor power board (see below table), and measure the resistance of thermistor. Is the thermistor normal? Reconnect the connector CN66, CN663 and CN3. 3 minutes after turning on the power supply, start EMERENCY OPERATION. Replace the thermistor.w W When RT64 is abnormal, replace the outdoor power board. Does the unit operate 0 minutes or more without showing thermistor abnormality? rmal Replace the outdoor electronic control P.C. board. Thermistor Defrost Discharge temperature Outdoor heat exchanger temperature Ambient temperature Fin temperature Symbol RT6 RT62 RT68 RT65 RT64 Connector, Pin. Between CN66 pin and pin2 Between CN66 pin3 and pin4 Between CN66 pin7 and pin8 Between CN663 pin and pin2 Between CN3 pin and pin2 Board Outdoor electronic control P.C. board Outdoor power board 25

26 The cooling operation or heating operation does not operate. (LED display: Both LED and LED2 lighting) C Check of R.V. coil When heating operation does not work.. Disconnect the lead wire leading to the compressor minutes after turning on the power supply, start EMERENCY OPERATION in HEAT mode. Is there voltage of 230V AC between pin and pin 2 at connector CN92? W Turn off power supply of indoor and outdoor unit.. Turn off power supply of indoor and outdoor unit, and disconnect the connector CN78 in the outdoor electronic control P.C. board minutes after turning on the power supply, start EMERENCY OPERATION in HEAT mode. Disconnect the connector CN92 in noise filter P. C. board. Is there normal resistance to R.V. coil? Replace the 4-way valve. Replace the R.V. coil. Is there voltage 2V DC between the connector CN78 pin 5 (+) and pin 3 (-)? Replace the noise filter P.C. board. Replace the electronic control P.C. board. When cooling operation does not work.. Disconnect the lead wire leading to the compressor minutes after turning on the power supply, start EMERENCY OPERATION in COOL mode. Is there voltage of 230V AC between pin and pin 2 at connector CN92? W Replace the 4-way valve. W If the connector CN92 is not connected or R.V. coil is open, voltage occurs between terminals even when the control is OFF.. Turn off power supply of indoor and outdoor unit, and disconnect the connector CN78 in the outdoor electronic control P.C. board minutes after turning on the power supply, start EMERENCY OPERATION in COOL mode. Is there voltage 2V DC between the connector CN78 pin 5 (+) and pin 3 (-)? Replace the noise filter P.C. board. Replace the outdoor electronic control P.C. board. 26

27 Fan motor does not operate or stops operating shortly after starting the operation. D Check of outdoor fan motor Check the connection between the connector CN93 and CN932. Is the resistance between each terminal of outdoor fan motor normal? Disconnect CN932 from outdoor electronic control P.C. board, and turn on the power supply. Rotate the outdoor fan motor manually and measure the voltage of CN93. Between (+) and 5(-) Between 2(+) and 5(-) Between 3(+) and 5(-) (Fixed to either 5V or 0V DC) Replace the outdoor DC fan motor. Does the voltage between each terminal become 5V DC and 0V DC repeatedly? Does the outdoor fan motor rotate smoothly? Replace the outdoor electronic control P.C. board. Outdoor unit does not operate. (LED display: display OFF) E Check of power supply Check the connecting of parts of main power supply circuit. Turn on power supply. Is there voltage of 230V AC in the power supply terminal block? Check the power supply cable. Is the output voltage from the noise filter P.C. board 230V AC? Is fuse (F64) blown? Replace the noise filter P.C. board. Replace the fuse. Is the input voltage to the power board 230V AC? Replace the reactor. Is the input voltage to the outdoor electronic control P.C. board 325V DC? Replace the power board. Replace the outdoor electronic control P.C. board. 27

28 Outdoor unit does not operate at all, or stops immediately due to overcurrent. F Check of current-limiting resistor When the current-limiting resistor is open, the rush current limiting relay (X64) may not work properly. Is the resistance of current-limiting resistor (R64A or R64B) on the noise filter P.C. board normal? (rmal resistance : 0' i5%) Open t open Turn ON the power supply and press EMERENCY OPERATION switch. Does LED on the outdoor electronic control P.C. board light up? Replace the noise filter P.C. board or the outdoor electronic control P.C. board. Replace the power P.C. board. Does the rush current limiting relay (X64) work properly? Replace the outdoor electronic control P.C. board or power P.C. board or the compressor. Replace the noise filter P.C. board. Check other electric parts in the main circuit together in the case that the current-limiting resistor is defective. When cooling, heat exchanger of non-operating indoor unit frosts. When heating, non-operating indoor unit gets warm. Check of LEV Turn on power supply to the outdoor unit after checking LEV coil is mounted to the LEV body securely. Is "click - click" sound heard? Or, do you feel vibration of the LEV coil with hands? rmal Disconnect the connector CN795. Is there normal resistance to LEV coil? Replace the LEV coil. Replace the outdoor electronic control P.C. board. 28

29 When unit cannot operate neither by the remote controller nor by EMERENCY OPERATION switch. Indoor unit does not operate. When OPERATION INDICATOR lamp flashes ON and OFF every 0.5-second. Outdoor unit doesn t operate. H How to check miswiring and serial signal error (when outdoor unit does not work) Turn OFF the power supply. Is there rated voltage in the power supply? Turn ON the power supply. Check the power supply. Is there rated voltage between outdoor terminal block S and S2? Check the wiring. Press EMERENCY OPERATION switch once. Does the left lamp of OPERATION INDICATOR lamp light up? <Confirmation of the power to the indoor unit> Is serial signal error indicated 6 minutes later? Is there any miswiring, poor contact, or wire disconnection of the indoor/outdoor connecting wire? Correct them. A B Turn OFF the power supply. Check once more if the indoor/outdoor connecting wire is not miswiring. Short-circuit outdoor terminal block S2 and S3. W Turn ON the power supply. W. Miswiring may damage indoor electronic control P.C. board during the operation. Be sure to confirm the wiring is correct before the operation starts. W3.Be sure to check this within 3 minutes after turning ON. After 3 minutes, LED blinks 6 times. Even when the outdoor electronic control P.C. board is normal, LED blinks 6 times after 3 minutes. Outdoor electronic control P.C. board (Parts side) Lighted Blinking A Turn OFF inverter-controlled lighting equipment. Turn OFF the power supply and then turn ON again. Press EMERENCY OPERATION switch. Is serial signal error indicated 6 minutes later? B LED2 LED Reinstall either the unit or the light each other away. Attach a filter on remote control receiving section of the indoor unit. Does the LED on the outdoor electronic control P.C. board repeat "3.6-second-OFF and 0.8-second-ON quick blinking"? W3 Turn OFF the power supply. Remove the short-circuit between outdoor terminal block S2 and S3. Turn ON the power supply. Is there amplitude of 0 to 20V DC between outdoor terminal block S2 and S3? <Confirmation of serial signal> Is there rated voltage between indoor terminal block S and S2? <Confirmation of power voltage> Be sure to release the failure-mode recall function after checking. Refer to indoor unit service manual. Replace the indoor electronic control P.C. board. (Lighted or not lighted) Replace the outdoor electronic control P.C. board. W2 W2 Be careful to the residual voltage of smoothing capacitor. Is there any error of the indoor/outdoor connecting wire, such as the damage of the wire, intermediate connection, poor contact to the terminal block? Is there any error of the indoor/outdoor connecting wire, such as the damage of the wire, intermediate connection, poor contact to the terminal block? Replace the indoor/outdoor connecting wire. Replace the indoor/outdoor connecting wire. 29

30 I Electromagnetic noise enters into TV sets or radios Is the unit earthed? Earth the unit. Is the distance between the antennas and the indoor unit within 3m, or is the distance between the antennas and the outdoor unit within 3m? Extend the distance between the antennas and the indoor unit, and/or the antennas and the outdoor unit. Is the distance between the TV sets or radios and the indoor unit within m, or is the distance between the TV sets or radios and the outdoor unit within 3m? Extend the distance between the TV sets and/or radios and the indoor unit, or the TV sets or radios and the outdoor unit. Are the antennas damaged? Is the coaxial cable damaged? Is there any poor contact in the antenna wiring? Replace or repair the antenna. Replace or repair the coaxial cable. Is the indoor/outdoor connecting wire of the air conditioner and the wiring of the antennas close? Extend the distance between the indoor/outdoor connecting wire of the air conditioner and the wiring of the antennas. Even if all of the above conditions are fulfilled, the electromagnetic noise may enter, depending on the electric field strength or the installation condition (combination of specific conditions such as antennas or wiring). Check the followings before asking for service..devices affected by the electromagnetic noise TV sets, radios (FM/AM broadcast, shortwave) 2.Channel, frequency, broadcast station affected by the electromagnetic noise 3.Channel, frequency, broadcast station unaffected by the electromagnetic noise 4.Layout of ; indoor/outdoor unit of the air conditioner, indoor/outdoor wiring, grounding wire, antennas, wiring from antennas, receiver 5.Electric field intensity of the broadcast station affected by the electromagnetic noise 6.Presence or absence of amplifier such as booster 7.Operation condition of air conditioner when the electromagnetic noise enters in )Turn OFF the power supply once, and then turn ON the power supply. In this situation, check for the electromagnetic noise. 2)Within 3 minutes after turning ON the power supply, press OPERATE/STOP (ON/OFF) button on the remote controller for power ON, and check for the electromagnetic noise. 3)After a short time (3 minutes later after turning ON), the outdoor unit starts running. During operation, check for the electromagnetic noise. 4)Press OPERATE/STOP (ON/OFF) button on the remote controller for power OFF, when the outdoor unit stops but the indoor/outdoor communication still runs on. In this situation, check for the electromagnetic noise. 30

31 OB455D--2qxp :23 PM Page Test point diagram and voltage. Outdoor electronic control P.C. board MUZ-B50VA Defrost thermistor (RT6) Ambient temperature thermistor (RT65) Fin temperature thermistor (RT64) Outdoor heat exchanger temperature thermistor (RT68) Temperature ( C) ( ( ( ) ( (+) ( ) (+) (+) ( ) (+) ( ( ( ( ( 5V DC pulse wave 5V ND CN93 ( CN V AC 50 0 ( To fan motor Temperature (;) Temperature ( C) CN78 90 LEV V DC ND (power board) ( )Rush current relay ( )R.V. coil V 5V CN702 Signal reception (From power board) 5V DC pulse wave 40 Outdoor heat exchanger temperature thermistor (RT68) 30 Defrost thermistor (RT6) Discharge temperature thermistor (RT62) 20 ( ( ( ( 0 20 ND Ambient temperature CN663 thermistor (RT65) CN70 Signal transmission (To power board) 5V DC pulse wave Resistance (k") CN795 2V DC pulse wave 600 Resistance (k") 80 CN66 Resistance (k') Discharge temperature thermistor (RT62) 700 LED LED 2 CN80 325V DC ~ 370V DC Input F80 FUSE 250V 3.5A ( 3 230V AC Input ( CN60 Serial signal Room A 5~0V DC

32 2. ise filter P.C. board MUZ-B50VA CN90 To electronic control P.C. board CN902 To power board CN903 To power board { { 230V AC Input CN92 R.V. coil 230V AC { 230V AC Output { 230V AC Output NR64 VARISTOR F64 FUSE 250V 2A F9 FUSE 250V A 32

33 OB455D--2qxp :23 PM Page Outdoor power board MUZ-B50VA Connect to the compressor Voltage among phases: 5V to 80V V DC Output (Red) (+) Connect to the earth CN2 Connect to the controller board (+)-5( ): Signal transmission (To electronic control P.C. board) 5V DC pulse wave (+)2-5( ): Zero cross signal 3-4 : t used (+)6-5( ): 5V (+)7-5( ): 5V ( ) 3 (White) CN3 Fin temperature thermistor RT64 reception (From ) Signal electronic control P.C. board) 5V DC pulse wave CN5 Primary current detection (Connect to the noise filter) Connect to the compressor Voltage among phases: 5V to 80V Connect to the earth V DC Output (Red) (+) CN2 Connect to the controller board (+)-5( ): Signal transmission (To electronic control P.C. board) 5V DC pulse wave (+)2-5( ): Zero cross signal 3-4 : t used (+)6-5( ): 5V (+)7-5( ): 5V ( ) 3 (White) CN3 Fin temperature thermistor RT64 reception (From ) Signal electronic control P.C. board) 5V DC pulse wave CN5 Primary current detection (Connect to the noise filter) 33

34 DISASSEMBLY INSTRUCTIONS <"Terminal with locking mechanism" Detaching points> The terminal which has the locking mechanism can be detached as shown below. There are two types ( Refer to () and (2)) of the terminal with locking mechanism. The terminal without locking mechanism can be detached by pulling it out. Check the shape of the terminal before detaching. () Slide the sleeve and check if there is a locking lever or not. (2) The terminal with this connector has the locking mechanism. Sleeve Locking lever Slide the sleeve. 2Pull the terminal while pushing the locking lever. Connector Hold the sleeve, and pull out the terminal slowly. MUZ-B50VA OPERATIN PROCEDURE. Removing the cabinet () Remove the screws of the service panel. (2) Remove the screws of the top panel. (3) Remove the screw of the valve cover. (4) Remove the service panel. (5) Remove the top panel. (6) Remove the valve cover. (7) Disconnect the power supply and indoor/ outdoor connecting wire. (8) Remove the screws of the cabinet. (9) Remove the cabinet. (0) Remove the screws of the back panel. () Remove the back panel. Photo Screws of the cabinet PHOTOS Screw of the top panel Photo 3 Screw of the motor support Photo 2 Screws of the cabinet Screw of the service panel Screws of the back panel Screws of the cabinet Screws of the top panel Set screws of the back panel Screw of the valve cover 34

35 OPERATIN PROCEDURE 2. Removing the inverter assembly, inverter P.C. board and power board () Remove the top panel, cabinet and service panel. (Refer to.) (2) Remove the back panel.(refer to.) (3) Disconnect the following connectors; <Electronic control P.C. board> CN93 and CN932 (Fan motor) CN795 (LEV) CN66 (Discharge temperature thermistor, defrost thermistor and outdoor heat exchanger temperature thermistor) CN663 (Ambient temperature thermistor) <ise filter P.C. board> CN92 (R.V. coil) (4) Remove the compressor connector. (5) Remove the screws fixing the relay panel. (6) Remove the inverter assembly. (7) Disconnect all connectors and lead wires on the electronic control P.C. board. (8) Remove the electronic control P.C. board from the inverter assembly. (9) Remove the screws fixing the power board assembly. (0) Disconnect all connectors and lead wires on the power board. () Remove the power board from the inverter assembly. (2) Disconnect all connectors and lead wires on the noise filter P.C. board. (3) Remove the noise filter P.C. board from the inverter assembly. PHOTOS Photo 4 Screws of the power board assembly Screws of the relay panel 3. Removing R.V. coil () Remove the top panel, cabinet and service panel. (Refer to.) (2) Remove the back panel. (Refer to.) (3) Disconnect the following connectors; <ise filter P.C. board> CN92 (R.V. coil) (4) Remove the R.V. coil. (Photo 9) 35

36 OPERATIN PROCEDURE 4. Removing the defrost thermistor, discharge temperature thermistor, outdoor heat exchanger temperature thermistor and ambient temperature thermistor () Remove the top panel, cabinet and service panel. (Refer to.) (2) Remove the back panel. (Refer to.) (3) Disconnect the following connectors; <Electronic control P.C. board> CN66 (Discharge temperature thermistor, defrost thermistor and outdoor heat exchanger temperature thermistor) CN663 (Ambient temperature thermistor) (4) Pull out the defrost thermistor from its holder. (Photo 6) (5) Pull out the discharge temperature thermistor from its holder. (Photo 5) (6) Pull out the outdoor heat exchanger temperature thermistor from its holder. (Photo 6) (7) Pull out the ambient temperature thermistor from its holder. (Photo 6) Photo 5 PHOTOS Discharge temperature thermistor Photo 6 Outdoor heat exchanger temperature thermistor Ambient temperature thermistor Defrost thermistor 5. Removing outdoor fan motor () Remove the top panel, cabinet and service panel. (Refer to.) (2) Remove the back panel. (Refer to.) (3) Disconnect the following connectors; <Electronic control P.C. board> CN93 and CN932 (Fan motor) (4) Remove the propeller. (5) Remove the screws fixing the fan motor. (6) Remove the fan motor. Photo 7 Screws of the outdoor fan motor Propeller 36

37 OPERATIN PROCEDURE 6. Removing the compressor and 4-way valve () Remove the top panel, cabinet and service panel. (Refer to.) (2) Remove the back panel. (Refer to.) (3) Remove the inverter assembly. (Refer to 2.) (4) Recover gas from the refrigerant circuit. NOTE: Recover gas from the pipes until the pressure gauge shows 0 kg/cm 2 (0 MPa). (5) Detach the welded part of the suction and the discharge pipe connected with compressor. (Photo 9) (6) Remove the compressor nuts. (7) Remove the compressor. (8) Detach the welded part of 4-way valve and pipe. (Photo 8) Photo 8 PHOTOS Welded parts of 4-way valve Photo 9 R.V. coil Welded part of the discharge pipe Welded part of the suction pipe 7. Removing the reactor () Remove the top panel. (Refer to.) (2) Disconnect the reactor lead wire. (3) Remove the screws of the reactor, and remove the reactor. Photo 0 Screws of the reactor 37

SERVICE MANUAL MUZ-GB50VA - E1 MUZ-GB50VA - E2 MUZ-GB50VA - E3 OUTDOOR UNIT. No. OB455. Models HFC

SERVICE MANUAL MUZ-GB50VA - E1 MUZ-GB50VA - E2 MUZ-GB50VA - E3 OUTDOOR UNIT. No. OB455. Models HFC Revision G: Errors in TROUBLESHOOTING have been corrected. Please void OB455 REVISED EDITION-F. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OB455 REVISED EDITION-G Models MUZ-GB50VA - E1 MUZ-GB50VA

More information

SERVICE MANUAL MUZ-GB50VA - E1 MUZ-GB50VA - E2 MUZ-GB50VA - E3 OUTDOOR UNIT. No. OB455. Wireless type Models HFC. Revision E: REVISED EDITION-E R410A

SERVICE MANUAL MUZ-GB50VA - E1 MUZ-GB50VA - E2 MUZ-GB50VA - E3 OUTDOOR UNIT. No. OB455. Wireless type Models HFC. Revision E: REVISED EDITION-E R410A Revision E: MUZ-GB50VA- E3 has been added. Please void OB455 REVISED EDITION-D. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OB455 REVISED EDITION-E Wireless type Models MUZ-GB50VA - E1 MUZ-GB50VA -

More information

SERVICE MANUAL MUZ-HC25VA - E1 MUZ-HC35VA - E1 MUZ-HC35VA - E2 MUZ-HC35VAB - E1 MUZ-HC35VAB - E2 OUTDOOR UNIT. No. OBH467.

SERVICE MANUAL MUZ-HC25VA - E1 MUZ-HC35VA - E1 MUZ-HC35VA - E2 MUZ-HC35VAB - E1 MUZ-HC35VAB - E2 OUTDOOR UNIT. No. OBH467. SPLIT-TYPE AIR CONDITIONERS Revision B: MUZ-HC35VA- E2 and MUZ-HC35VAB- E2 have been added. Please void OBH467 REVISED EDITION-A. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH467 REVISED EDITION-B

More information

SERVICE MANUAL MUZ-DM25VA - E1, ER1, ET1 MUZ-DM35VA - E1, ER1, ET1 OUTDOOR UNIT. No. OBH751. Models HFC R410A

SERVICE MANUAL MUZ-DM25VA - E1, ER1, ET1 MUZ-DM35VA - E1, ER1, ET1 OUTDOOR UNIT. No. OBH751. Models HFC R410A OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. Models MUZ-DM25VA - E1, ER1, ET1 MUZ-DM35VA - E1, ER1, ET1 Indoor unit service manual MSZ-DM VA Series (OBH750) CONTENTS 1. TECHNICAL CHANGES 2 2. PART NAMES

More information

SERVICE MANUAL MUZ-FH25VE MUZ-FH35VE MUZ-FH50VE OUTDOOR UNIT. No. OBH624. Models HFC. Revision A: MUZ-FH50VE- E1 has been added. Please void OBH624.

SERVICE MANUAL MUZ-FH25VE MUZ-FH35VE MUZ-FH50VE OUTDOOR UNIT. No. OBH624. Models HFC. Revision A: MUZ-FH50VE- E1 has been added. Please void OBH624. SPLIT-TYPE AIR CONDITIONERS Revision A: MUZ-FH50VE- E1 has been added. Please void OBH624. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH624 REVISED EDITION-A Models MUZ-FH25VE MUZ-FH35VE MUZ-FH50VE

More information

SERVICE MANUAL MUFZ-KJ50VE - E1, E2, ER1, ER2, ET1, ET2 MUFZ-KJ35VE OUTDOOR UNIT. No. OBH667. Models HFC

SERVICE MANUAL MUFZ-KJ50VE - E1, E2, ER1, ER2, ET1, ET2 MUFZ-KJ35VE OUTDOOR UNIT. No. OBH667. Models HFC Revision D: MUFZ-KJ25VE - E2, ER2, ET2, MUFZ- KJ35VE - E2, ER2, ET2 and MUFZ- KJ50VE - E2, ER2, ET2 have been added. Please void OBH667 REVISED EDITION-C. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A.

More information

SERVICE MANUAL MUZ-D30NA / - MUZ-D36NA / - MUY-D30NA / - MUY-D36NA / - OUTDOOR UNIT. No. OBH502. Models HFC. Revision E: REVISED EDITION-E R410A

SERVICE MANUAL MUZ-D30NA / - MUZ-D36NA / - MUY-D30NA / - MUY-D36NA / - OUTDOOR UNIT. No. OBH502. Models HFC. Revision E: REVISED EDITION-E R410A Revision E: Capacity corrections have been corrected [7-1. 2), 3)]. OBH502 REVISED EDITION-D is void. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH502 REVISED EDITION-E Models MUZ-D30NA / - 1 / -

More information

SERVICE MANUAL MUZ-D30NA MUZ-D30NA- U1 MUZ-D36NA MUZ-D36NA- U1 MUY-D30NA MUY-D36NA OUTDOOR UNIT. No. OBH502. Wireless type Models HFC R410A

SERVICE MANUAL MUZ-D30NA MUZ-D30NA- U1 MUZ-D36NA MUZ-D36NA- U1 MUY-D30NA MUY-D36NA OUTDOOR UNIT. No. OBH502. Wireless type Models HFC R410A OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH502 Wireless type Models MUZ-D30NA MUZ-D30NA- U1 MUZ-D36NA MUZ-D36NA- U1 MUY-D30NA MUY-D36NA Indoor unit service manual MSZ-D NA Series (OBH501) MSY-D

More information

SERVICE MANUAL. No. OBH747 REVISED EDITION-A. Models HFC

SERVICE MANUAL. No. OBH747 REVISED EDITION-A. Models HFC Revision A: MUZ-HM09/12NA- U8, MUZ-HM09/12NA2- U8, MUZ-HM15/18NA- U1, MUZ-HM15/18NA2- U1 and MUZ-HM24NA2- U1 have been added. Please void OBH747. OUTDOOR INDOOR UNIT UNIT SERVICE MANUAL HFC utilized R410A.

More information

SERVICE MANUAL OUTDOOR UNIT MUZ-GA25VA - MUZ-GA25VA - MUZ-GA25VA - MUZ-GA25VA - MUZ-GA35VA - MUZ-GA35VA - MUZ-GA25VA(H)- MUZ-GA25VAH E4 MUZ-GA25VAH -

SERVICE MANUAL OUTDOOR UNIT MUZ-GA25VA - MUZ-GA25VA - MUZ-GA25VA - MUZ-GA25VA - MUZ-GA35VA - MUZ-GA35VA - MUZ-GA25VA(H)- MUZ-GA25VAH E4 MUZ-GA25VAH - SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS Revision:C MUZ-A5VA(H)- Please void OB79 REVISED EDITION-B. E4 has been added. OUTDOOR UNIT SERVICE MANUAL HFC utilized R40A. OB79 REVISED EDITION-C Wireless type

More information

SERVICE MANUAL OUTDOOR UNIT MUZ-FH06NAH MUZ-FH09NAH MUZ-FH06NA MUZ-FH09NA MUZ-FH09NA - 1 MUZ-FH09NAH - 1 MUZ-FH12NA MUZ-FH12NAH

SERVICE MANUAL OUTDOOR UNIT MUZ-FH06NAH MUZ-FH09NAH MUZ-FH06NA MUZ-FH09NA MUZ-FH09NA - 1 MUZ-FH09NAH - 1 MUZ-FH12NA MUZ-FH12NAH Revision D: Capacity corrections have been corrected [7-1. 2), 3)]. OBH684 REVISED EDITION-C is void. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH684 REVISED EDITION-D Models MUZ-FH06NA MUZ-FH09NA

More information

TECHNICAL & SERVICE MANUAL

TECHNICAL & SERVICE MANUAL SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS TECHNICAL & SERVICE MANUAL R40A Outdoor unit [model names] SUZ-KA5VA SUZ-KA35VA SUZ-KA5VAH SUZ-KA35VAH SUZ-KA50VA SUZ-KA60VA SUZ-KA7VA [Service Ref.] SUZ-KA5VA.TH

More information

SERVICE MANUAL MUZ-GE25VA - E1 MUZ-GE25VAH - E1 MUZ-GE35VA - E1 MUZ-GE35VAH - E1 MUZ-GE42VA - E1 MUZ-GE42VAH - E1 MUZ-GE50VA - E1 MUZ-GE50VAH - E1

SERVICE MANUAL MUZ-GE25VA - E1 MUZ-GE25VAH - E1 MUZ-GE35VA - E1 MUZ-GE35VAH - E1 MUZ-GE42VA - E1 MUZ-GE42VAH - E1 MUZ-GE50VA - E1 MUZ-GE50VAH - E1 SPLIT-TYPE AIR CONDITIONERS Revision A: MUZ-GE42/50VA(H) - E1 has been added. Please void OBH516. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH516 REVISED EDITION-A Models MUZ-GE25VA - E1 MUZ-GE25VAH

More information

SERVICE MANUAL MUZ-GE50VA - E1 MUZ-GE50VAH - E1 MUZ-GE60VA - E1 MUZ-GE71VA - E1

SERVICE MANUAL MUZ-GE50VA - E1 MUZ-GE50VAH - E1 MUZ-GE60VA - E1 MUZ-GE71VA - E1 SPLIT-TYPE AIR CONDITIONERS Revision D: Changing defrost finish temperature has been corrected (10-1.). Please void OBH516 REVISED EDITION-C. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH516 REVISED

More information

SERVICE MANUAL MUY-GL24NA - U1. No. OBH733. Models HFC. Revision B: REVISED EDITION-B R410A

SERVICE MANUAL MUY-GL24NA - U1. No. OBH733. Models HFC. Revision B: REVISED EDITION-B R410A Revision B: MUZ-GL09NA- U8 and MUZ-GL09NAH- U8 have been added. Please void OBH733 REVISED EDITION-A. OUTDOOR INDOOR UNIT UNIT SERVICE MANUAL HFC utilized R410A. OBH733 REVISED EDITION-B Models MUZ-GL09NA

More information

SERVICE MANUAL MFZ-KA25VA - MFZ-KA35VA - MFZ-KA35VA - E1. Wireless type Models FLOOR-TYPE, HEAT PUMP AIR CONDITIONERS. No.

SERVICE MANUAL MFZ-KA25VA - MFZ-KA35VA - MFZ-KA35VA - E1. Wireless type Models FLOOR-TYPE, HEAT PUMP AIR CONDITIONERS. No. FLOOR-TYPE, HEAT PUMP AIR CONDITIONERS SERVICE MANUAL Wireless type Models MFZ-KAVA - MFZ-KA3VA - E E. OB409 MFZ-KA0VA - E Indication of model name MFZ-KAVA - E MFZ-KA3VA - E MFZ-KA0VA - E NOTE: This service

More information

TECHNICAL & SERVICE MANUAL R410A

TECHNICAL & SERVICE MANUAL R410A SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS TECHNICAL & SERVICE MANUAL R40A Outdoor unit [Model Name] SUZ-KA25VA SUZ-KA35VA SUZ-KA25VAH SUZ-KA35VAH SUZ-KA50VA SUZ-KA60VA SUZ-KA7VA SUZ-KA25VA(H).TH SUZ-KA35VA(H).TH

More information

SERVICE MANUAL MUZ-FH25VE MUZ-FH35VE MUZ-FH50VE OUTDOOR UNIT. No. OBH624 REVISED EDITION-E. Models HFC

SERVICE MANUAL MUZ-FH25VE MUZ-FH35VE MUZ-FH50VE OUTDOOR UNIT. No. OBH624 REVISED EDITION-E. Models HFC Revision E: MUZ-FH25VE- E4, ER4, ET3, MUZ- FH35VE- E3, ER3, ET3 and MUZ- FH50VE- E2, ER2, ET2 have been added. Please void OBH624 REVISED EDITION-D. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH624

More information

TECHNICAL & SERVICE MANUAL

TECHNICAL & SERVICE MANUAL SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS TECHNICAL & SERVICE MANUAL R40A Outdoor unit [model names] [Service Ref.] SUZ-KA25VA SUZ-KA25VA.TH SUZ-KA25VAR.TH SUZ-KA35VA SUZ-KA35VA.TH SUZ-KA35VAR.TH SUZ-KA25VAH

More information

SERVICE MANUAL MUZ-FE09NA MUZ-FE09NAH MUZ-FE12NA MUZ-FE12NA1 MUZ-FE12NAH MUZ-FE18NA OUTDOOR UNIT. No. OBH543 REVISED EDITION-F.

SERVICE MANUAL MUZ-FE09NA MUZ-FE09NAH MUZ-FE12NA MUZ-FE12NA1 MUZ-FE12NAH MUZ-FE18NA OUTDOOR UNIT. No. OBH543 REVISED EDITION-F. Revision F: The descriptions of the expansion valve coil have been corrected. (10-4.) Some descriptions have been modified. Please void OBH543 REVISED EDITION-E. OUTDOOR UNIT SERVICE MANUAL HFC utilized

More information

SUZ-A09VR.TH SUZ-A12VR.TH SUZ-A18VR.TH SUZ-A24VR.TH

SUZ-A09VR.TH SUZ-A12VR.TH SUZ-A18VR.TH SUZ-A24VR.TH SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS.OC4 REVISED EDITION-A TECHNICAL & SERVICE MANUAL R40A [model names] SUZ-A09VR SUZ-A2VR SUZ-AVR SUZ-AVR [Service Ref.] SUZ-A09VR.TH SUZ-A2VR.TH SUZ-AVR.TH SUZ-AVR.TH

More information

SERVICE MANUAL MUH-GA50VB- MUH-GA50VB - MUH-GA60VB - MUH-GA80VB - E1 OUTDOOR UNIT. No. OB368 REVISED EDITION-B. Wireless type Models HFC.

SERVICE MANUAL MUH-GA50VB- MUH-GA50VB - MUH-GA60VB - MUH-GA80VB - E1 OUTDOOR UNIT. No. OB368 REVISED EDITION-B. Wireless type Models HFC. Revision:B - E has been added. SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS Please void OB68 REVISED EDITION-A. OUTDOOR UNIT SERVICE MANUAL HFC utilized R40A. OB68 REVISED EDITION-B Wireless type Models E -

More information

Mitsubishi ilmalämpöpumput huoltaa ja korjaa: Jäähdytinpalvelu RefGroup Oy MUZ-GA35VAH - E1

Mitsubishi ilmalämpöpumput huoltaa ja korjaa: Jäähdytinpalvelu RefGroup Oy MUZ-GA35VAH - E1 SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SERVICE MANUAL Wireless type Models E MUZ-GA5VA - E MUZ-GA35VA - E MUZ-GA5VAH - MUZ-GA35VAH - E HFC utilized R40A. OB379 Indication of model name MUZ-GA5VA - E MUZ-GA35VA

More information

SERVICE MANUAL MUZ-HJ50VA - E1, E2, ER1, ER2, ET1, ET2 MUZ-HJ35VA - E1, E3, ER1, ER3, ET1, ET2

SERVICE MANUAL MUZ-HJ50VA - E1, E2, ER1, ER2, ET1, ET2 MUZ-HJ35VA - E1, E3, ER1, ER3, ET1, ET2 Revision F: "How to check miswiring and serial signal error" has been corrected (11-5. M ). OBH648 REVISED EDITION-E is void. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH648 REVISED EDITION-F Models

More information

SERVICE MANUAL MUZ-EF25VE MUZ-EF25VEH MUZ-EF35VE MUZ-EF35VEH MUZ-EF42VE MUZ-EF50VE. No. OBH590 REVISED EDITION-F. Models HFC

SERVICE MANUAL MUZ-EF25VE MUZ-EF25VEH MUZ-EF35VE MUZ-EF35VEH MUZ-EF42VE MUZ-EF50VE. No. OBH590 REVISED EDITION-F. Models HFC Revision F: The descriptions of the expansion valve coil have been corrected. (11-4.) Please void OBH590 REVISED EDITION-E. OUTDOOR INDOOR UNIT UNIT SERVICE MANUAL HFC utilized R410A. OBH590 REVISED EDITION-F

More information

SERVICE MANUAL MUZ-SF25VE MUZ-SF25VEH MUZ-SF35VE MUZ-SF35VEH MUZ-SF42VE MUZ-SF42VEH MUZ-SF50VE MUZ-SF50VEH OUTDOOR UNIT. No. OBH629 REVISED EDITION-E

SERVICE MANUAL MUZ-SF25VE MUZ-SF25VEH MUZ-SF35VE MUZ-SF35VEH MUZ-SF42VE MUZ-SF42VEH MUZ-SF50VE MUZ-SF50VEH OUTDOOR UNIT. No. OBH629 REVISED EDITION-E Revision E: The descriptions of the expansion valve coil have been corrected. (11-4.) Please void OBH629 REVISED EDITION-D. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH629 REVISED EDITION-E Models

More information

SERVICE MANUAL MUCFH-GA35VB - MUCFH-GA50VB - MUCFH-GA60VB - E1 OUTDOOR UNIT. No. OB381. Models HFC

SERVICE MANUAL MUCFH-GA35VB - MUCFH-GA50VB - MUCFH-GA60VB - E1 OUTDOOR UNIT. No. OB381. Models HFC FLOOR AND CEILIN TYPE AIR CONDITIONERS Revision B: The fan guard for MUCFH-A 60VBhas been changed. Please void OB8 REVSED EDITION-A. E OUTDOOR UNIT SERVICE MANUAL HFC utilized R40A. OB8 REVISED EDITION-B

More information

SERVICE MANUAL OUTDOOR UNIT. No. OBH530. Models MU-GE50VB- E1 MUH-GE50VB- E1 HFC SPLIT-TYPE AIR CONDITIONERS R410A

SERVICE MANUAL OUTDOOR UNIT. No. OBH530. Models MU-GE50VB- E1 MUH-GE50VB- E1 HFC SPLIT-TYPE AIR CONDITIONERS R410A SPLIT-TYPE AIR CONDITIONERS OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH530 Models MU-GE50VB- E1 - E1 Indoor unit service manual MS/MSH-GE VB Series (OBH529) CONTENTS 1. TECHNICAL CHANGES 2 2. PART

More information

SERVICE MANUAL OUTDOOR UNIT. No. OBH629 REVISED EDITION-A. Models HFC. Revision A: MUZ-SF25/35/42VE - E2 have been added. Please void OBH629.

SERVICE MANUAL OUTDOOR UNIT. No. OBH629 REVISED EDITION-A. Models HFC. Revision A: MUZ-SF25/35/42VE - E2 have been added. Please void OBH629. SPLIT-TYPE AIR CONDITIONERS Revision A: MUZ-SF25/35/42VE - E2 have been added. Please void OBH629. OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH629 REVISED EDITION-A Models MUZ-SF25VE - E1 MUZ-SF42VE

More information

SERVICE MANUAL MXZ-2A40VA - MXZ-2A52VA - MXZ-3A54VA - MXZ-3A54VA - MXZ-4A71VA - MXZ-4A71VA - MXZ-4A80VA - E1 OUTDOOR UNIT. No. OB377 REVISED EDITION-A

SERVICE MANUAL MXZ-2A40VA - MXZ-2A52VA - MXZ-3A54VA - MXZ-3A54VA - MXZ-4A71VA - MXZ-4A71VA - MXZ-4A80VA - E1 OUTDOOR UNIT. No. OB377 REVISED EDITION-A SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS Revision : A MXZ-A5/A7VA- MXZ-A0/A5VA- Please void OB77 E E has been added. has been added. OUTDOOR UNIT SERVICE MANUAL HFC utilized R0A No. OB77 REVISED EDITION-A

More information

MUZ-EF25VE - E1 MUZ-EF25VEH - E1 MUZ-EF35VE - E1 MUZ-EF35VEH - E1 MUZ-EF42VE - E1 MUZ-EF50VE - E1 Indoor unit service manual MSZ-EF VE Series (OBH589)

MUZ-EF25VE - E1 MUZ-EF25VEH - E1 MUZ-EF35VE - E1 MUZ-EF35VEH - E1 MUZ-EF42VE - E1 MUZ-EF50VE - E1 Indoor unit service manual MSZ-EF VE Series (OBH589) SPLIT-TYPE AIR CONDITIONERS OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH590 Models MUZ-EF25VE - E1 MUZ-EF25VEH - E1 MUZ-EF35VE - E1 MUZ-EF35VEH - E1 MUZ-EF42VE - E1 MUZ-EF50VE - E1 Indoor unit service

More information

SERVICE MANUAL INDOOR UNIT MFZ-KA25VA - MFZ-KA50VA - MFZ-KA35VA - No. OB409. Models. Revision E: SPLIT-TYPE AIR CONDITIONERS REVISED EDITION-E

SERVICE MANUAL INDOOR UNIT MFZ-KA25VA - MFZ-KA50VA - MFZ-KA35VA - No. OB409. Models. Revision E: SPLIT-TYPE AIR CONDITIONERS REVISED EDITION-E SPLIT-TYPE AIR CONDITIONERS Revision E: MFZ-KA5VA- E5, MFZ-KA35VA- E5 and MFZ-KA50VA- E5 have been added. Please void OB409 REVISED EDITION-D. INDOOR UNIT SERVICE MANUAL. OB409 REVISED EDITION-E Models

More information

SERVICE MANUAL MUH-GA50VB - MUH-GA60VB - MUH-GA80VB - E1. Wireless type Models HFC SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS. No. OB368 R410A CONTENTS

SERVICE MANUAL MUH-GA50VB - MUH-GA60VB - MUH-GA80VB - E1. Wireless type Models HFC SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS. No. OB368 R410A CONTENTS SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SERVICE MANUAL Wireless type Models E MUH-GA50VB - E MUH-GA60VB - MUH-GA80VB - E HFC utilized R40A. OB368 CONTENTS Indication of model name MUH-GA50VB - E. TECHNICAL

More information

SERVICE MANUAL MUCFH-GA35VB - MUCFH-GA50VB - MUCFH-GA60VB - E1. Wireless type Models HFC FLOOR AND CEILING TYPE AIR CONDITIONERS. No.

SERVICE MANUAL MUCFH-GA35VB - MUCFH-GA50VB - MUCFH-GA60VB - E1. Wireless type Models HFC FLOOR AND CEILING TYPE AIR CONDITIONERS. No. FLOOR AND CEILING TYPE AIR CONDITIONERS SERVICE MANUAL Wireless type Models E MUCFH-GA35VB - E MUCFH-GA50VB - MUCFH-GA60VB - E HFC utilized R40A. OB38 CONTENTS Indication of model name MUCFH-GA50VB - E.

More information

SERVICE MANUAL MUZ-FE09NA MUZ-FE12NA OUTDOOR UNIT. No. OBH543. Models HFC SPLIT-TYPE AIR CONDITIONERS R410A

SERVICE MANUAL MUZ-FE09NA MUZ-FE12NA OUTDOOR UNIT. No. OBH543. Models HFC SPLIT-TYPE AIR CONDITIONERS R410A SPLIT-TYPE AIR CONDITIONERS OUTDOOR UNIT SERVICE MANUAL HFC utilized R410A. OBH543 Models MUZ-FE09NA MUZ-FE12NA Indoor unit service manual MSZ-FE NA Series (OBH542) CONTENTS 1. TECHNICAL CHANGES 2 2. PART

More information

SERVICE MANUAL MUH-A18WV - MUH-A24WV - MUH-A30WV - E1. Wireless type Models HFC

SERVICE MANUAL MUH-A18WV - MUH-A24WV - MUH-A30WV - E1. Wireless type Models HFC SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS Revision A: Resistance of LEV (Expansion valve) has been modified. Power input and others have been added to SPECIFICATION. Method of check of R.V. coil has been

More information

MUH-24RV - MSH-30RV -

MUH-24RV - MSH-30RV - SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SERVICE MANUAL Wireless type Models Refer to the Service Manual OB85 REVISED EDITION C when MSH-8RV- E is connected with MXZ-NV- E or MXZ-NV- E as multi system units.

More information

SERVICE MANUAL MXZ-A18WV - MXZ-A26WV - MXZ-A32WV - E1 HFC. Inverter-controlled multi system Models SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS. No.

SERVICE MANUAL MXZ-A18WV - MXZ-A26WV - MXZ-A32WV - E1 HFC. Inverter-controlled multi system Models SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS. No. SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SERVICE MANUAL Inverter-controlled multi system Models E MXZ-A8WV - E MXZ-A6WV - MXZ-AWV - E HFC utilized R40A No. OB9 Indication of model name MXZ-A8WV - E CONTENTS.

More information

SUZ-KA25VA2.TH SUZ-KA35VA2.TH SUZ-KA50VA2.TH SUZ-KA60VA2.TH SUZ-KA71VA2.TH

SUZ-KA25VA2.TH SUZ-KA35VA2.TH SUZ-KA50VA2.TH SUZ-KA60VA2.TH SUZ-KA71VA2.TH SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS September 2011.OCH472 REVISED EDITION-A TECHNICAL & SERVICE MANUAL R410A Outdoor unit [Model names] SUZ-KA25VA2 SUZ-KA35VA2 SUZ-KA50VA2 SUZ-KA60VA2 SUZ-KA71VA2 [Service

More information

SERVICE MANUAL MSZ-GE22VA - E1 MSZ-GE25VA - E1 MSZ-GE35VA - E1 MSZ-GE42VA - E1 MSZ-GE50VA - E1 MSZ-GE60VA - E1 MSZ-GE71VA - E1 INDOOR UNIT. No.

SERVICE MANUAL MSZ-GE22VA - E1 MSZ-GE25VA - E1 MSZ-GE35VA - E1 MSZ-GE42VA - E1 MSZ-GE50VA - E1 MSZ-GE60VA - E1 MSZ-GE71VA - E1 INDOOR UNIT. No. SPLIT-TYPE AIR CONDITIONERS Revision E: Detail of the indoor fan speed control in COOL or DRY operation has been added (9-1.3, 9-2.3). Please void OBH515 REVISED EDITION-D. INDOOR UNIT SERVICE MANUAL.

More information

SERVICE MANUAL MLZ-KA25VA - MLZ-KA35VA - MLZ-KA50VA - E1 INDOOR UNIT. No. OBH483. Ceiling cassette type Models

SERVICE MANUAL MLZ-KA25VA - MLZ-KA35VA - MLZ-KA50VA - E1 INDOOR UNIT. No. OBH483. Ceiling cassette type Models CEILING CASSETTE TYPE, HEAT PUMP AIR CONDITIONERS INDOOR UNIT SERVICE MANUAL. OBH483 Ceiling cassette type Models E1 MLZ-KA25VA - E1 MLZ-KA35VA - MLZ-KA50VA - E1 Outdoor unit service manual MXZ-A VA Series

More information

SERVICE MANUAL INDOOR UNIT

SERVICE MANUAL INDOOR UNIT SPLIT-TYPE AIR CONDITIONERS Revision A: MSZ-SF25/35/42/50VE- E2 and MSZ-SF25/35/ 42/50VE- EN2 have been added. Please void OBH600. INDOOR UNIT SERVICE MANUAL. OBH600 REVISED EDITION-A Models MSZ-SF25VE

More information

Mitsubishi ilmalämpöpumput huoltaa ja korjaa: Jäähdytinpalvelu RefGroup Oy

Mitsubishi ilmalämpöpumput huoltaa ja korjaa: Jäähdytinpalvelu RefGroup Oy SPLIT-TYPE AIR CONDITIONERS INDOOR UNIT SERVICE MANUAL. OBH589 Models MSZ-EF22VEW - MSZ-EF22VEW - E1 MSZ-EF25VEW - E1 MSZ-EF22VEB - E1 MSZ-EF35VEW - E1 MSZ-EF22VES E1 - MSZ-EF42VEW - E1 MSZ-EF25VEW - E1

More information

SERVICE MANUAL. Wireless type Models MSZ-A09RV - (WH) MUZ-A09RV - MSZ-A12RV - (WH) MUZ-A12RV - E1 SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS

SERVICE MANUAL. Wireless type Models MSZ-A09RV - (WH) MUZ-A09RV - MSZ-A12RV - (WH) MUZ-A12RV - E1 SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SERVICE MANUAL. OB0 REVISED EDITION-A Wireless type Models E E MSZ-A09RV - (WH) MUZ-A09RV - MSZ-ARV - (WH) MUZ-ARV - E E CONTENTS. TECHNICAL CHANGES. PART NAMES AND

More information

SERVICE MANUAL MSZ-GL06NA - U1 MSZ-GL09NA - U1 MSZ-GL12NA - U1 MSZ-GL15NA - U1 MSZ-GL18NA - U1 MSZ-GL24NA - U1

SERVICE MANUAL MSZ-GL06NA - U1 MSZ-GL09NA - U1 MSZ-GL12NA - U1 MSZ-GL15NA - U1 MSZ-GL18NA - U1 MSZ-GL24NA - U1 Revision B: 3. SPECIFICATION has been corrected. Please void OBH732 REVISED EDITION-A. INDOOR UNIT SERVICE MANUAL. OBH732 REVISED EDITION-B Models MSZ-GL06NA - U1 MSZ-GL09NA - U1 MSZ-GL12NA - U1 MSZ-GL15NA

More information

SERVICE MANUAL MSZ-DM25VA - E1, ER1 MSZ-DM35VA - E1, ER1 INDOOR UNIT. No. OBH750. Models

SERVICE MANUAL MSZ-DM25VA - E1, ER1 MSZ-DM35VA - E1, ER1 INDOOR UNIT. No. OBH750. Models INDOOR UNIT SERVICE MANUAL. Models MSZ-DM25VA - E1, ER1 MSZ-DM35VA - E1, ER1 Outdoor unit service manual MUZ-DM VA Series (OBH751) MXZ-DM VA Series (OBH739) MSZ-DM25VA MSZ-DM35VA CONTENTS 1. TECHNICAL

More information

TECHNICAL & SERVICE MANUAL. Ceiling Concealed

TECHNICAL & SERVICE MANUAL. Ceiling Concealed STAND BY DEFROST CHECK CLOCK ON OFF NOT AVAILABLE FILTER CHECK MODE TEST RUN FUNCTION SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS TECHNICAL & SERVICE MANUAL Series SEZ Ceiling Concealed R40A.OC0 REVISED EDITION-A

More information

SERVICE MANUAL MSZ-HC25VA - E1 MSZ-HC35VA - E1 MSZ-HC35VA - E2 MSZ-HC35VAB - E1 MSZ-HC35VAB - E2 INDOOR UNIT. No. OBH466. Models

SERVICE MANUAL MSZ-HC25VA - E1 MSZ-HC35VA - E1 MSZ-HC35VA - E2 MSZ-HC35VAB - E1 MSZ-HC35VAB - E2 INDOOR UNIT. No. OBH466. Models SPLIT-TYPE AIR CONDITIONERS Revision B: MSZ-HC35VA- E2 and MSZ-HC35VAB- E2 have been added. Please void OBH466 REVISED EDITION-A. INDOOR UNIT SERVICE MANUAL. OBH466 REVISED EDITION-B Models MSZ-HC25VA

More information

SERVICE MANUAL MSC-A07YV - (WH) MSC-A09YV - (WH) MSC-A12YV - (WH) HFC. Wireless type Models

SERVICE MANUAL MSC-A07YV - (WH) MSC-A09YV - (WH) MSC-A12YV - (WH) HFC. Wireless type Models SPLIT-TYPE, AIR CONDITIONERS SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SERVICE MANUAL Wireless type Models E MSC-A07YV - (WH) E MSC-A09YV - (WH) E MSC-AYV - (WH) HFC utilized R40A. OB39 CONTENTS Indication

More information

SERVICE MANUAL MSZ-FH25VE MSZ-FH35VE INDOOR UNIT. No. OBH623. Models SPLIT-TYPE AIR CONDITIONERS

SERVICE MANUAL MSZ-FH25VE MSZ-FH35VE INDOOR UNIT. No. OBH623. Models SPLIT-TYPE AIR CONDITIONERS SPLIT-TYPE AIR CONDITIONERS INDOOR UNIT SERVICE MANUAL. Models MSZ-FH25VE MSZ-FH35VE - E1 - E1 Outdoor unit service manual MUZ-FH VEHZ Series (OBH625) MUZ-FH VE Series MXZ-D VA Series CONTENTS 1. TECHNICAL

More information

SERVICE MANUAL MSC-GA20VB - (WH) MSC-GA25VB - (WH) MSC-GA35VB - (WH) Wireless type Models

SERVICE MANUAL MSC-GA20VB - (WH) MSC-GA25VB - (WH) MSC-GA35VB - (WH) Wireless type Models SPLIT-TYPE, AIR CONDITIONERS SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SERVICE MANUAL Wireless type Models E MSC-GA0VB - (WH) E MSC-GAVB - (WH) E MSC-GAVB - (WH). OB8 Indication of model name MSC-GA0VB -

More information

SERVICE MANUAL MSZ-FH25VE MSZ-FH35VE MSZ-FH50VE MSZ-FH25VE2 MSZ-FH35VE2 MSZ-FH50VE2 INDOOR UNIT. No. OBH623. Models

SERVICE MANUAL MSZ-FH25VE MSZ-FH35VE MSZ-FH50VE MSZ-FH25VE2 MSZ-FH35VE2 MSZ-FH50VE2 INDOOR UNIT. No. OBH623. Models Revision D: MSZ-FH25VE2- E1, ER1, MSZ- FH35VE2- E1, ER1 and MSZ- FH50VE2- E1, ER1 have been added. Please void OBH623 REVISED EDITION-C. INDOOR UNIT SERVICE MANUAL. OBH623 REVISED EDITION-D Models MSZ-FH25VE

More information

SERVICE MANUAL MSZ-HM09NA MSZ-HM12NA MSZ-HM15NA MSZ-HM18NA MSZ-HM24NA INDOOR UNIT. No. OBH746 REVISED EDITION-B. Models

SERVICE MANUAL MSZ-HM09NA MSZ-HM12NA MSZ-HM15NA MSZ-HM18NA MSZ-HM24NA INDOOR UNIT. No. OBH746 REVISED EDITION-B. Models Revision B: 3-1. OPERATING RANGE has been modified. Please void OBH746 REVISED EDITION-A. INDOOR UNIT SERVICE MANUAL. OBH746 REVISED EDITION-B Models MSZ-HM09NA MSZ-HM12NA MSZ-HM15NA MSZ-HM18NA MSZ-HM24NA

More information

SERVICE MANUAL INDOOR UNIT. No. OBH788

SERVICE MANUAL INDOOR UNIT. No. OBH788 INDOOR UNIT SERVICE MANUAL. Models MSZ-AP25VG - E1, EN1 MSZ-AP35VG - E1, EN1 MSZ-AP42VG - E1, EN1 MSZ-AP50VG - E1, EN1 MSZ-AP25VGK - E1, EN1 MSZ-AP35VGK - E1, EN1 MSZ-AP42VGK - E1, EN1 MSZ-AP50VGK - E1,

More information

SERVICE MANUAL MUX-A22WV - E1 HFC. Multi system type Model SPLIT-TYPE, AIR CONDITIONER. No. OB318 R410A CONTENTS. Revision A: MUX-A22WV -

SERVICE MANUAL MUX-A22WV - E1 HFC. Multi system type Model SPLIT-TYPE, AIR CONDITIONER. No. OB318 R410A CONTENTS. Revision A: MUX-A22WV - SPLIT-TYPE, AIR CDITIER Revision A: MUX-AWV - E can be connected to MSC-A07/AYV - E. PARTS LIST has partially modified. Please void OB8. SERVICE MANUAL Multi system type Model HFC utilized R40A. OB8 REVISED

More information

MSZ-GE06NA- 8, 9 MSZ-GE09NA- 8, 9 MSZ-GE12NA- 8, 9 MSZ-GE15NA- 8, 9 MSZ-GE18NA- 8, 9

MSZ-GE06NA- 8, 9 MSZ-GE09NA- 8, 9 MSZ-GE12NA- 8, 9 MSZ-GE15NA- 8, 9 MSZ-GE18NA- 8, 9 SPLIT-TYPE AIR CONDITIONERS Revision D: MSZ-GE06/09/12/15/18NA- 9 and MSY- GE09/12/15/18NA- 9 have been added. Please void OBH548 REVISED EDITION-C INDOOR UNIT SERVICE MANUAL. OBH548 REVISED EDITION-D

More information

SERVICE MANUAL MS-GF20VA MS-GF25VA MS-GF35VA MS-GF50VA MS-GF60VA MS-GF80VA INDOOR UNIT. No. OBH621 REVISED EDITION-A. Models

SERVICE MANUAL MS-GF20VA MS-GF25VA MS-GF35VA MS-GF50VA MS-GF60VA MS-GF80VA INDOOR UNIT. No. OBH621 REVISED EDITION-A. Models SPLIT-TYPE AIR CONDITIONERS Revision A: MS-GF50VA- E1, MS-GF60VA- E1 and MS-GF80VA- E1 have been added. Please void OBH621. INDOOR UNIT SERVICE MANUAL. OBH621 REVISED EDITION-A Models MS-GF20VA MS-GF25VA

More information

SERVICE MANUAL MUZ-LN25VG MUZ-LN35VG MUZ-LN50VG MUZ-LN60VG OUTDOOR UNIT. No. OBH767. Models HFC R32

SERVICE MANUAL MUZ-LN25VG MUZ-LN35VG MUZ-LN50VG MUZ-LN60VG OUTDOOR UNIT. No. OBH767. Models HFC R32 OUTDOOR UNIT SERVICE MANUAL HFC utilized R32. Models MUZ-LN25VG MUZ-LN35VG MUZ-LN50VG MUZ-LN60VG - E1, ER1, ET1 - E1, ER1, ET1 - E1, ER1, ET1 - E1, ER1, ET1 Indoor unit service manual MSZ-LN VGW/V/B/R

More information

SUZ-SA71VA3.TH SUZ-SA100VA2.TH

SUZ-SA71VA3.TH SUZ-SA100VA2.TH SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS TECHNICAL & SERVICE MANUAL R410A Outdoor unit [Model Name] SUZ-SA71VA3 SUZ-SA100VA2 [Service Ref.] SUZ-SA71VA3.TH SUZ-SA100VA2.TH January 2018. HFC utilized R410A

More information

SERVICE MANUAL. Wireless type Models MS-GA50VB - MS-GA60VB - MS-GA80VB - SPLIT-TYPE, AIR CONDITIONERS. No. OB369 CONTENTS

SERVICE MANUAL. Wireless type Models MS-GA50VB - MS-GA60VB - MS-GA80VB - SPLIT-TYPE, AIR CONDITIONERS. No. OB369 CONTENTS SPLIT-TYPE, AIR CONDITIONERS SERVICE MANUAL Wireless type Models MS-GA50VB - MS-GA60VB - MS-GA80VB - E E E (WH) (WH) (WH). OB69 CONTENTS Indication of model name MS-GA50VB - E MS-GA60VB - E MS-GA80VB -

More information

TECHNICAL & SERVICE MANUAL SUZ-SA71VA.TH. R410A Outdoor unit SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS. May 2014 HFC. No.OCH561 R410A CONTENTS

TECHNICAL & SERVICE MANUAL SUZ-SA71VA.TH. R410A Outdoor unit SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS. May 2014 HFC. No.OCH561 R410A CONTENTS SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS May 2014. TECHNICAL & SERVICE MANUAL R410A Outdoor unit [Model Name] SUZ-SA71VA [Service Ref.] HFC utilized R410A te: This service manual describes technical data

More information

SERVICE MANUAL MSC-GE20VB - E1 MSC-GE25VB - E1 MSC-GE35VB - E1 MS-GE50VB - E1 MSH-GE50VB - E1 INDOOR UNIT. No. OBH529. Models

SERVICE MANUAL MSC-GE20VB - E1 MSC-GE25VB - E1 MSC-GE35VB - E1 MS-GE50VB - E1 MSH-GE50VB - E1 INDOOR UNIT. No. OBH529. Models SPLIT-TYPE AIR CONDITIONERS INDOOR UNIT SERVICE MANUAL. OBH529 Models MSC-GE20VB - E1 MSC-GE25VB - E1 MSC-GE35VB - E1 MS-GE50VB - E1 MSH-GE50VB - E1 service manual MU-GA VB Series (OB386) MUH-GA VB Series

More information

SERVICE MANUAL MSZ-D30NA MSZ-D36NA MSY-D30NA MSY-D36NA INDOOR UNIT. No. OBH501. Wireless type Models

SERVICE MANUAL MSZ-D30NA MSZ-D36NA MSY-D30NA MSY-D36NA INDOOR UNIT. No. OBH501. Wireless type Models INDOOR UNIT SERVICE MANUAL. OBH501 Wireless type Models MSZ-D30NA MSZ-D36NA MSY-D30NA MSY-D36NA CONTENTS Outdoor unit service manual MUZ-D NA Series (OBH502) MUY-D NA Series (OBH502) 1. TECHNICAL CHANGES

More information

SERVICE MANUAL OUTDOOR UNIT. No. OBH789

SERVICE MANUAL OUTDOOR UNIT. No. OBH789 OUTDOOR UNIT SERVICE MANUAL HFC utilized R32. Models MUZ-AP25VG - E1, ET1 MUZ-AP25VGH - E1 MUZ-AP35VG - E1, ET1 MUZ-AP35VGH - E1 MUZ-AP42VG - E1, ET1 MUZ-AP42VGH - E1 MUZ-AP50VG - E1, ET1 MUZ-AP50VGH -

More information

SERVICE MANUAL MUX-2A28VB - MUX-2A59VB - E1 MUX-3A63VB - E1 MUX-3A63VB - MUX-2A70VB - MUX-4A73VB - E1 HFC. Multi system type Models

SERVICE MANUAL MUX-2A28VB - MUX-2A59VB - E1 MUX-3A63VB - E1 MUX-3A63VB - MUX-2A70VB - MUX-4A73VB - E1 HFC. Multi system type Models SPLIT-TYPE, IR CDITIER SERVICE MNUL Multi system type Models E MUX-8VB - E MUX-59VB - E MUX-360VB - E MUX-363VB - E MUX-70VB - MUX-473VB - E HFC utilized R40 No. OB384 MUX-59VB - E MUX-360VB - E MUX-363VB

More information

MUH-A07WV - MSC-A09WV - MUH-A09WV - MSC-A12WV - MUH-A12WV - Multi system type Models MUX-A10WV - MSC-A09WV - MUX-A19WV - MSC-A12WV -

MUH-A07WV - MSC-A09WV - MUH-A09WV - MSC-A12WV - MUH-A12WV - Multi system type Models MUX-A10WV - MSC-A09WV - MUX-A19WV - MSC-A12WV - SPLIT-TYPE, IR CONDITIONERS SPLIT-TYPE, HET PUMP IR CONDITIONERS Revision: MXZ-8WV - E have been added. MSC-07/09/WV - E Part No..have changed. VRISTOR (NR& NR) E0 6 85 E0 749 85 Please void OB07. SERVICE

More information

SERVICE MANUAL MSC-09RV - E1 MU-07RV - MSC-09RV - MU-09RV - MSC-12RV - MU-12RV - MSC-07RV - MUH-07RV - MSC-09RV - MUH-09RV - MSC-12RV - MUH-12RV -

SERVICE MANUAL MSC-09RV - E1 MU-07RV - MSC-09RV - MU-09RV - MSC-12RV - MU-12RV - MSC-07RV - MUH-07RV - MSC-09RV - MUH-09RV - MSC-12RV - MUH-12RV - SPLITTYPE,AIR CONDITIONERS SPLITTYPE,HEAT PUMP AIR CONDITIONERS SERVICE MANUAL Wireless type Models E MSC07RV (WH) MU07RV E MSC09RV (WH) MU09RV E MSCRV (WH) MURV Revision: MUX0/8/4RV E has been added.

More information

1. INDOOR UNITS... MSZ-FH-3 2. OUTDOOR UNITS... MSZ-FH-4 3. SYSTEM... MSZ-FH-5

1. INDOOR UNITS... MSZ-FH-3 2. OUTDOOR UNITS... MSZ-FH-4 3. SYSTEM... MSZ-FH-5 M-SERIES SINGLE ZONE SYSTEMS MSZ-FH High Performance Wall-Mount Heat Pump Systems 1. INDOOR UNITS... MSZ-FH-3 2. OUTDOOR UNITS... MSZ-FH-4 3. SYSTEM... MSZ-FH-5 3-1. SPECIFICATIONS... MSZ-FH-6 MSZ-FH09NA

More information

TECHNICAL & SERVICE MANUAL. Ceiling Cassettes

TECHNICAL & SERVICE MANUAL. Ceiling Cassettes RESET RESET SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SPLIT-TYPE, AIR CONDITIONERS TECHNICAL & SERVICE MANUAL Series SLH/SL Indoor unit [Model names] SLH-AR SLH-.6AR SLH-AR SL-AR SL-.6AR SL-AR Ceiling Cassettes

More information

Part 3 Troubleshooting

Part 3 Troubleshooting Part Troubleshooting What is in this part? This part contains the following chapters: Chapter See page Troubleshooting 2 Error Codes: Hydro-box 7 Error Codes: Outdoor Units Error Codes: System Malfunctions

More information

TECHNICAL & SERVICE MANUAL

TECHNICAL & SERVICE MANUAL RESET SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS. OC0 TECHNICAL & SERVICE MANUAL Series SLZ Ceiling Cassettes R0A Indoor unit [Model names] SLZ-A09AR SLZ-AAR SLZ-A8AR [Service Ref.] SLZ-A09AR.TH SLZ-AAR.TH

More information

TCL SERVICE MANUAL. Models WALL MOUNTED SPLIT-TYPE AIR CONDITIONERS. No.TE CONTENTS

TCL SERVICE MANUAL. Models WALL MOUNTED SPLIT-TYPE AIR CONDITIONERS. No.TE CONTENTS TCL WALL MOUNTED SPLIT-TYPE AIR CONDITIONERS SERVICE MANUAL No.TE031229 Models TAC-07CS/K TAC-09CS/K TAC-12CS/K TAC-18CS/K TAC-24CS/K TAC-07CSC/K TAC-09CSC/K TAC-12CSC/K TAC-18CSC/K TAC-24CSC/K TAC-07CHS/K

More information

SERVICE MANUAL MLZ-KP25VF MLZ-KP35VF MLZ-KP50VF INDOOR UNIT. No. OBH801. Models

SERVICE MANUAL MLZ-KP25VF MLZ-KP35VF MLZ-KP50VF INDOOR UNIT. No. OBH801. Models INDOOR UNIT SERVICE MANUAL. Models MLZ-KP25VF MLZ-KP35VF MLZ-KP50VF - E1, ER1 - E1, ER1 - E1, ER1 Outdoor unit service manual MXZ-D VA Series (OBH626) MXZ-E VA Series (OBH723) MXZ-F VF Series (OBH790)

More information

TABLE OF CONTENTS ERSQ-AAY1

TABLE OF CONTENTS ERSQ-AAY1 Daikin Altherma High Temperature Outdoor units ERSQ-AAY1 TABLE OF CONTENTS ERSQ-AAY1 1 Features............................................................ 6 2 Specifications......................................................

More information

1 TECHNICAL CHANGES. MUZ-A09NA MUZ-A09NA - 1 MUZ-A09NA - U1 MUZ-A09NA - U2 1. Refrigerant system diagram has been changed.

1 TECHNICAL CHANGES. MUZ-A09NA MUZ-A09NA - 1 MUZ-A09NA - U1 MUZ-A09NA - U2 1. Refrigerant system diagram has been changed. 1 TECHNICAL CHANGES MUZ09UN MUZ-A09NA MUZ12UN MUZ-A12NA MUH15TN MUZ-A15NA MUH17TN MUZ-A17NA MUH24WN MUZ-A24NA MU15TN MUY-A15NA MU17TN MUY-A17NA MU24WN MUY-A24NA 1. Outdoor unit model has been changed.

More information

DESIGN & TECHNICAL MANUAL

DESIGN & TECHNICAL MANUAL AIR CONDITIONER Wall mounted type DESIGN & TECHNICAL MANUAL INDOOR ASYG18KLCA ASYG24KLCA OUTDOOR AOYG18KLTA AOYG24KLTA DR_AS069EF_01 2018.03.16 Notices: Product specifications and design are subject to

More information

INVERTER WALL MOUNTED TYPE ROOM AIR-CONDITIONER (Split system, air to air heat pump type)

INVERTER WALL MOUNTED TYPE ROOM AIR-CONDITIONER (Split system, air to air heat pump type) TECHNICAL MANUAL & PARTS LIST DRAFT INVERTER WALL MOUNTED TYPE ROOM AIR-CONDITIONER (Split system, air to air heat pump type) SRK20ZD-S - 1 - INDOOR UNIT Model SRK20ZD-S OUTDOOR UNIT Model SRC20ZD-S REMOTE

More information

SPLIT TYPE ROOM AIR CONDITIONER. WALL MOUNTEDtype INVERTER. Models Indoor unit Outdoor unit AOU 9RLFW1 AOU12RLFW1 ASU 9RLF1 ASU12RLF1 R410A

SPLIT TYPE ROOM AIR CONDITIONER. WALL MOUNTEDtype INVERTER. Models Indoor unit Outdoor unit AOU 9RLFW1 AOU12RLFW1 ASU 9RLF1 ASU12RLF1 R410A SERVICE INSTRUCTION SPLIT TYPE ROOM AIR CONDITIONER WALL MOUNTEDtype INVERTER Models Indoor unit Outdoor unit ASU 9RLF ASURLF AOU 9RLFW AOURLFW R40A CONTENTS. DESCRIPTION OF EACH CONTROL OPERATION. COOLING

More information

SERVICE INSTRUCTION R410A. WALL MOUNTEDtype SPLIT TYPE ROOM AIR CONDITIONER INVERTER. Models Indoor unit Outdoor unit AO* R09LECN AO* R12LECN

SERVICE INSTRUCTION R410A. WALL MOUNTEDtype SPLIT TYPE ROOM AIR CONDITIONER INVERTER. Models Indoor unit Outdoor unit AO* R09LECN AO* R12LECN SERVICE INSTRUCTION SPLIT TYPE ROOM AIR CONDITIONER WALL MOUNTEDtype INVERTER Models Indoor unit Outdoor unit AS* A09LEC AS* A12LEC AO* R09LECN AO* R12LECN R410A CONTENTS 1. DESCRIPTION OF EACH CONTROL

More information

R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AO*G09LTCN AO*G12LTCN AO*G14LTCN

R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AO*G09LTCN AO*G12LTCN AO*G14LTCN SERVICE INSTRUCTION SPLIT TYPE ROOM AIR CONDITIONER WALL MOUNTEDtype INVERTER Models Indoor unit Outdoor unit AS*G09LTCB AS*GLTCB AS*G4LTCB AO*G09LTCN AO*GLTCN AO*G4LTCN R40A CONTENTS. DESCRIPTION OF EACH

More information

DC INVERTER SPLIT SYSTEM AIR CONDITIONER

DC INVERTER SPLIT SYSTEM AIR CONDITIONER AIR CONDITIONER TECHNICAL & SERVICE MANUAL KS1872 + C1872 + CL1872 KS2472 + C2472 + CL2472 FILE NO. Destination: North America DC INVERTER SPLIT SYSTEM AIR CONDITIONER Indoor Model No. KS1872 KS2472 Product

More information

R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AOYG07LEC AOYG09LEC AOYG12LEC AOYG14LEC

R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AOYG07LEC AOYG09LEC AOYG12LEC AOYG14LEC SERVICE INSTRUCTION SPLIT TYPE ROOM AIR CONDITIONER WALL MOUNTEDtype INVERTER Models Indoor unit Outdoor unit ASYG07LECA ASYG09LECA ASYG12LECA ASYG14LECA AOYG07LEC AOYG09LEC AOYG12LEC AOYG14LEC R410A CONTENTS

More information

DC INVERTER MULTI-SYSTEM AIR CONDITIONER

DC INVERTER MULTI-SYSTEM AIR CONDITIONER TECHNICAL & SERVICE MANUAL OUTDOOR UNIT : CU-3KE19NBU CU-4KE24NBU CU-4KE31NBU DC INVERTER MULTI-SYSTEM AIR CONDITIONER Capacity at 0V 19,100 BTU/h,200 BTU/h 30,600 BTU/h Outdoor Model No. CU-3KE19NBU CU-4KE24NBU

More information

DC INVERTER SPLIT SYSTEM AIR CONDITIONER

DC INVERTER SPLIT SYSTEM AIR CONDITIONER TECHNICAL & SERVICE MANUAL XHS1271 & PNR-XS1872 + CH1271 XHS1872 & PNR-XS1872 + CH1872 FILE NO. Destination: North America DC INVERTER SPLIT SYSTEM AIR CONDITIONER Indoor Model No. Body (Panel) XHS1271

More information

3.2 E1 Outdoor Unit PCB Abnormality E4 Actuation of Low Pressure Sensor E5 Compressor Motor Lock 3 52

3.2 E1 Outdoor Unit PCB Abnormality E4 Actuation of Low Pressure Sensor E5 Compressor Motor Lock 3 52 Error Codes: Outdoor Units Error Codes: Outdoor Units Part. What Is in This Chapter? Introduction Overview In the first stage of the troubleshooting sequence, it is important to correctly interpret the

More information

SERVICE INSTRUCTION R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AOU9RLS2H AOU12RLS2H AOU15RLS2H

SERVICE INSTRUCTION R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AOU9RLS2H AOU12RLS2H AOU15RLS2H SERVICE INSTRUCTION SPLIT TYPE ROOM AIR CONDITIONER WALL MOUNTEDtype INVERTER Models Indoor unit Outdoor unit ASU9RLS ASURLS ASU5RLS AOU9RLSH AOURLSH AOU5RLSH R40A CONTENTS. DESCRIPTION OF EACH CONTROL

More information

Digital Inverter 4 series 8 & 10HP

Digital Inverter 4 series 8 & 10HP E6-H Digital Inverter 4 series 8 & 0HP High static duct type Indoor unit RAV-SM2244DTP-E RAV-SM2804DTP-E Outdoor unit RAV-SM2244AT8-E RAV-SM2804AT8-E Contents. Line up... 2. Indoor unit (High static duct

More information

Floor Standing PFFY-P20VKM-E PFFY-P20VKM-ER1 PFFY-P25VKM-E PFFY-P25VKM-ER1 PFFY-P32VKM-E PFFY-P32VKM-ER1 PFFY-P40VKM-E PFFY-P40VKM-ER1

Floor Standing PFFY-P20VKM-E PFFY-P20VKM-ER1 PFFY-P25VKM-E PFFY-P25VKM-ER1 PFFY-P32VKM-E PFFY-P32VKM-ER1 PFFY-P40VKM-E PFFY-P40VKM-ER1 SPLIT-TYPE, HEAT PUMP AIR CDITIERS TECHNICAL & SERVICE MANUAL November 008 No. OC0 REVISED EDITI-A Series PFFY Indoor unit [Model names] PFFY-P0VKM-E PFFY-PVKM-E PFFY-PVKM-E PFFY-P0VKM-E Floor Standing

More information

SERVICE MANUAL KFR-7002GW

SERVICE MANUAL KFR-7002GW SPLIT TYPE AIR CONDITIONER SERVICE MANUAL KFR-7002GW CONTENTS 1.PART NAMES AND FUNCTIONS... 2.SPECIFICATION... 3.OUTLINES AND DIMENSIONS... 4.WIRING DIAGRAM... 5.REFRIGERANT SYSTEM DIAGRAM... 6.PERFORMANCE

More information

SERVICE INSTRUCTION R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AO*G24LFL AO*G24LFCC AO*G30LFT

SERVICE INSTRUCTION R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AO*G24LFL AO*G24LFCC AO*G30LFT SERVICE INSTRUCTION SPLIT TYPE ROOM AIR CONDITIONER WALL MOUNTEDtype INVERTER Models Indoor unit Outdoor unit AS*G4LFCA AS*G4LFCC AS*G0LFCA AO*G4LFL AO*G4LFCC AO*G0LFT R40A CONTENTS. DESCRIPTION OF EACH

More information

DC INVERTER MULTI-SYSTEM AIR CONDITIONER

DC INVERTER MULTI-SYSTEM AIR CONDITIONER TECHNICAL & SERVICE MANUAL INDOOR UNIT : CS-MKE9NB4U & CZ-18BT1U CS-MKE12NB4U & CZ-18BT1U CS-KE18NB4UW & CZ-18BT1U DC INVERTER MULTI-SYSTEM AIR CONDITIONER Capacity 9,000BTU / h 11,900BTU / h 17,500BTU

More information

TABLE OF CONTENTS RMXS-E8V1B

TABLE OF CONTENTS RMXS-E8V1B Outdoor Units R-410A RMXS-E8V1B TABLE OF CONTENTS RMXS-E8V1B! 1 Features........................................................... 814 2 Specifications.....................................................

More information

Ceiling Cassettes PLH-3AKH1.UK PLH-3AKH.UK PLH-4AKHS1.UK PLH-4AKHS.UK PLH-5AKHS1.UK PLH-5AKHS.UK PLH-6AKHS1.UK PLH-6AKHS.UK

Ceiling Cassettes PLH-3AKH1.UK PLH-3AKH.UK PLH-4AKHS1.UK PLH-4AKHS.UK PLH-5AKHS1.UK PLH-5AKHS.UK PLH-6AKHS1.UK PLH-6AKHS.UK T AVAILABLE C AMPM AMPM SPLIT-TYPE, HEAT PUM PAIR CDITIERS No. OC REVISED EDITI-A TECHNICAL & SERVICE MANUAL Series PLH Indoor unit [Model names] PLH-3AK PLH-3AKH PLH-AKS PLH-AKHS PLH-5AKS PLH-5AKHS PLH-6AKS

More information

Service manual. MIV V4+ Mini

Service manual. MIV V4+ Mini DM12-01.01.05en Service manual MIV V4+ Mini DC INVERTER R410A (~220V, 50Hz, 1Ph) MVUH80A-VA1 Contents Part 1 General Information... 1 Part 2 Outdoor Units... 6 Part 3 Installation... 44 DM12-01.01.05en

More information

R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AO*R07LGC AO*R09LGC AO*R12LGC AO*R14LGC

R410A. WALL MOUNTEDtype INVERTER SPLIT TYPE ROOM AIR CONDITIONER. Models Indoor unit Outdoor unit AO*R07LGC AO*R09LGC AO*R12LGC AO*R14LGC SERVICE INSTRUCTION SPLIT TYPE ROOM AIR CONDITIONER WALL MOUNTEDtype INVERTER Models Indoor unit Outdoor unit AS*A07LGC AS*A09LGC AS*A2LGC AS*A4LGC AO*R07LGC AO*R09LGC AO*R2LGC AO*R4LGC R40A CONTENTS.

More information

DC INVERTER SPLIT SYSTEM AIR CONDITIONER

DC INVERTER SPLIT SYSTEM AIR CONDITIONER TECHNICAL & SERVICE MANUAL KHS308 + CH308 KHS368 + CH368 FILE NO. Destination: North America DC INVERTER SPLIT SYSTEM AIR CONDITIONER Indoor Model No. KHS308 KHS368 Product Code No. 85 354 8 85 354 9 Outdoor

More information

TECHNICAL & SERVICE MANUAL

TECHNICAL & SERVICE MANUAL SPLIT-TYPE, HEAT PUMP AIR CONDITIONERS SPLIT-TYPE, AIR CONDITIONERS TECHNICAL & SERVICE MANUAL R07C Outdoor unit [model names] No.OC6 REVISED EDITION-B PUH-PVGAA PUH-P.6VGAA PUH-P.6YGAA PUH-PVGAA PUH-PYGAA

More information

DC INVERTER SPLIT SYSTEM AIR CONDITIONER

DC INVERTER SPLIT SYSTEM AIR CONDITIONER AIR CONDITIONER TECHNICAL & SERVICE MANUAL CS-KE30NKU + CU-KE30NKU CS-KE36NKU + CU-KE36NKU DC INVERTER SPLIT SYSTEM AIR CONDITIONER Indoor Model No. CS-KE30NKU CS-KE36NKU Product Code No. 1 852 360 88

More information

PMFY-P-VBM-E. Ceiling cassette (1-way flow type) R410A Data G8 1. SPECIFICATIONS EXTERNAL DIMENSIONS CENTER OF GRAVITY 1-100

PMFY-P-VBM-E. Ceiling cassette (1-way flow type) R410A Data G8 1. SPECIFICATIONS EXTERNAL DIMENSIONS CENTER OF GRAVITY 1-100 Ceiling cassette (-way flow type) RA Data G8 -P-VBM-E. SPECIFICATIONS - 98. EXTERNAL DIMENSIONS - 99 3. CENTER OF GRAVITY -. ELECTRICAL WIRING DIAGRAMS -. SOUND LEVELS -. Sound levels -. NC curve 6. TEMPERATURE/AIRFLOW

More information

DC INVERTER SPLIT SYSTEM AIR CONDITIONER

DC INVERTER SPLIT SYSTEM AIR CONDITIONER AIR CONDITIONER TECHNICAL & SERVICE MANUAL CS-KS30NKU + CU-KS30NKUA CS-KS36NKU + CU-KS36NKUA DC INVERTER SPLIT SYSTEM AIR CONDITIONER Indoor Model No. CS-KS30NKU CS-KS36NKU Product Code No. 852 360 86

More information