ORIGINAL INSTRUCTIONS

Transcription

1 ORIGINAL INSTRUCTIONS CAUTION READ THESE INSTRUCTIONS BEFORE USING THE MACHINE User instructions TruBroom Rechargeable Battery Sweeper Issue 2 03/10

2

3 Contents Page 1. General Information Important safety advice Guidelines for the operator Transporting the machine Electrical connection Preparation for use Operation Charging the battery Using the machine Storage Maintenance After sales service Guarantee Waste electrical & electronic equipment (WEEE) Technical specification Accessories Fault diagnosis Declaration of conformity...7

4 IMPORTANT BEFORE USE READ THESE INSTRUCTIONS AND RETAIN FOR FUTURE REFERENCE 1. General information The TruBroom is designed for the efficient cleaning of carpets and floors. These instructions only cover the operation of the machines and do not include information on the basics of floor cleaning. Any user not familiar with basic floor cleaning should contact their supervisor or Truvox International before proceeding. The TruBroom must only be used for the manufacturer s approved application. It is designed for the cleaning and removal of light carpet soil or hard floors. Do not use where it is suspected that the carpet floor contains health endangering dust or debris such as asbestos or chemical waste. If this is suspected do not proceed, contact your supervisor or Truvox International for advice. The following instructions contain important information about the TruBroom and safety advice for the operator. Equipment must be operated, serviced and maintained in accordance with the manufacturer s instructions. If in doubt contact the supplier of your machine. These instructions are valid for the following model: TruBroom 1.1 Important Safety Advice When using electrical equipment basic safety precautions should be followed including the following. Make sure TruBroom is assembled correctly before use. TruBroom is not intended for use by children. Do not use TruBroom if it has been damaged, left outdoors or dropped into water. Keep fingers, hair, all other body parts and clothing away from rotating cleaning brushes. Do not use on coarse concrete surfaces. Do not use outdoors: patios, decks or rough surfaces. Do not use where hazardous dust is present. Do not use in an explosive atmosphere. Do not use to clean up any burning or lighted materials such as cigarettes, matches and ashes Only use the supplied charger when charging TruBroom. Store your TruBroom indoors in a dry, safe place. Do not use a damaged charger. When not in use the charger should be removed from the mains supply socket. 1.2 Guidelines for the operator Operators must be fully trained in the use of the machine in accordance with these instructions, able to perform user maintenance and the correct selection of accessories. Operators should be physically capable to manoeuvre, transport and operate the machine. Operators should be able to recognise unusual operation of the machine and report any problems. Wear suitable footwear to avoid slipping. Wear suitable clothing to keep dry and warm. Where possible implement job rotation and adequate rest periods to avoid continuous use of same muscles. Do not leave the machine running unattended Do not smoke when using the machine. CAUTION - This machine is for indoor use only and should not be used or stored outdoors or in wet conditions. 1.3 Transporting the machine When transporting a machine ensure that all components and removable parts are securely fastened. Take extreme care when using the machine on or around steps or stairs. CAUTION Incorrect lifting techniques may result in personal injury. We advise that the manual handling regulations are followed. 1.4 Electrical connection Before connecting the charger to the power supply, check that your supply voltage corresponds with that marked on the rating label on the charger. 4

5 2 Preparation for use Remove the appliance and components from the box. Take out the handle components, simultaneously depress the two buttons on either side of the tube and connect each part together. Ensure machine is turned off. Depress the dust tray button to take out the tray. Empty the tray. Insert into plastic handle on machine base. 4 Storage Always empty and clean the machine after use. Always recharge after use. Store the machine in a dry indoor area only. 3 Operation 3.1 Charging the battery Ensure TruBroom is turned off when charging. Before using the first time initially charge for 12 hours. A green light will show when charging. Recharge after use, never wait until battery is fully discharged. Do not leave on continuous charge. 3.2 Using the machine Ensure dust tray is empty before use. Switch on by pressing the on/off button. Push and pull the sweeper on the floor/carpet at a normal speed. When finished, turn the machine off by pressing the on/off button. 5 Maintenance WARNING - Before undertaking maintenance operations or adjustments switch off machine and unplug from the electricity supply. The machine requires minimum maintenance apart from the following checks by the operator. Recharge cord - Regularly inspect sheath, plug and cord anchorage for damage or loose connection. Dust tray Check the dust tray is cleaned and replaced as appropriate. Brush Check that the brush is free of debris and clean as required. There are no user serviceable parts on this appliance. IMPORTANT All other servicing and repairs should only be performed by a Truvox engineer or Authorised Service Agent. IMPORTANT Should the machine fail to operate please refer to the fault diagnosis section in the back of the instruction manual. If the problem / remedy is not listed please contact Truvox Customer Service Department for rapid attention. 5

6 6 After Sales Service Should you require after sales service please contact the supplier from whom you purchased the machine, who will arrange service. Repairs and servicing of Truvox products should only be performed by trained staff. Improper repairs can cause considerable dangers to the user. 7 Guarantee Your product is guaranteed for 90 days from the date of original purchase, or hire purchase, against defects in materials or workmanship during manufacture. Within the guarantee period we undertake at our discretion, to repair or replace free of charge to the purchaser, any part found to be defective, subject to the following conditions. CONDITIONS 1. Claims made under the terms of the guarantee must be supported by the original invoice/bill of sale issued at the time of sale, or the machine Serial Number. 2. For claims under this guarantee contact the supplier from whom you purchased the product who will arrange the appropriate action. Do not initially return the product as this could result in transit damage. 3. Neither Truvox nor its distributors shall be liable for any incidental or consequential loss. 4. This guarantee is governed by the laws of England. 5. This guarantee does not cover any of the following: Periodic maintenance, and repair or replacement of parts due to normal wear and tear. Damage caused by accident, misuse or neglect, or the fitting of other than genuine Truvox parts. Defects in other than genuine Truvox parts, or repairs, modifications or adjustments performed by other than a Truvox service engineer or authorised service agent. Costs and risks of transport relating directly or indirectly to the guarantee of this product. Consumable items and wear parts such as drive belts. 8 Waste Electrical & Electronic Equipment Do no dispose of this device with unsorted waste. Improper disposal may be harmful to the environment and human health. Please refer to your local waste authority for Information on return and collection systems in your area. This guarantee does not affect your statutory rights, nor your rights against the supplier arising from their sales or purchase contract. 6

7 9 Technical specification Model TruBroom Code TRUB Voltage V 4.8 Power consumption W 18 Charge time H 12 Working time Min Working current A 2.6 Brush Speed r/min 2850 Dust capacity l 0.35 Size ( L x W x H) cm 28 x 19 x 8 Weight empty kg 2 Warranty 90 days Charger Input 240v AC 50Hz Charger Output 9v DC 200mA Truvox International is a BSI Registered Company and our policy is one of continuous development. We reserve the right to change specifications without prior notification. 10 Accessories Part Part No Description Charger TruBroom charger unit Unit TruBroom base unit Handle TruBroom telescopic handle 11 Fault diagnosis WARNING - Before undertaking maintenance operations or adjustments switch off machine and unplug from the electricity supply. The following simple checks may be performed by the operator. Problem Reason Remedy Machine fails to start Batteries discharged Obstruction to brush Charge machine Check and remove debris Poor pick up Dust tray is full Batteries discharged Empty the tray Charge machine The brush stops working Obstruction to brush Check and remove debris Dust/debris is not collected Dust container is full Check and empty dust container 7

8 We, Truvox International Ltd. EC Declaration of Conformity of Third Avenue, Millbrook, Southampton, Hampshire England SO15 0LE declare that the machinery Make Type Model : Sweeper : TruBroom : TRUB Serial Number : from Year of Construction : 2010 has been manufactured using the following transposed harmonised European Standards and technical specifications. Ref No 2006/42/EC 2006/95/EC BS EN BS EN /108/EC EN EN EN EN Title Machinery Directive and subsequent amendments The Low Voltage Directive and subsequent amendments The EMC Directive and subsequent amendments Signed in : SOUTHAMPTON, England on the 29 th day of December 2009 Signature : Name : David Overell Technical file: TruBroom Iss. 1 Position : Managing Director Mark Campbell Product Support Manager 8

9 9

10 Authorised dealer: Truvox International Limited Third Avenue, Millbrook, Southampton, Hampshire SO15 0LE, England Tel: +44 (0) Fax: +44 (0) Web: 10