For more Parts Information:

Transcription

1 For more Parts Information:

2 TABLE OF CONTENTS Manitowoc Foodservice [Updated: Sep. 30, 2013] Manitowoc - Ice & Related Parts Catalog Ice Machine Q Series Q Model - QuietQube Q1400C, CVD1375, CVD1475, CVD1476 Q1400C - Control Box Components 1 Q1400C - Evaporator Compartment - Common Components 3 Q1400C - Refrigeration Compartment - Common Components 5 Q1400C - Head Section - Panels 7 CVD1475/ Condensing Unit - Control Box Components 9 CVD1475/ Condensing Unit - Refrigeration Components 11 CVD1475/ Condensing Unit - Panels 13 CVD Condensing Unit - Control Box Components 15 CVD Condensing Unit - Refrigeration Components 17 CVD Condensing Unit - Panels 19 PAGE i

3 Q1400C - CONTROL BOX COMPONENTS Q1400C_2.PDF 1

4 Q1400C - CONTROL BOX COMPONENTS # PART # DESCRIPTION QTY Note Control Board Amp Fuse Mounted on Control Board Toggle Switch Only 3a Toggle Switch with Wiring Harness Attached 4 Wiring Harness 4a Wiring Harness - 115V/60 Hz/1 Ph 4b Wiring Harness - 230V/50 Hz/1 Ph Terminal Block - 50 Hz - 3 Pole [1] Wire Lead with Shunt Resistor Control Box Control Box Cover Control Board Mounting Supports Screw - #10-24 x 0.50" Ground Screw - #10-24 x 0.50" HEX PART NOTES: [1] - 50 Hz Only Q1400C_2.PDF 2

5 Q1400C - EVAPORATOR COMPARTMENT - COMMON COMPONENTS Q1400C_3.PDF 3

6 Q1400C - EVAPORATOR COMPARTMENT - COMMON COMPONENTS # PART # DESCRIPTION QTY Note 1 Evaporator Assembly 1a Evaporator - Regular Cube 2b Evaporator - Dice Cube 2c Evaporator - Half Dice Cube 2 Water Pump 2a Water Pump - 115V/60 Hz 2b Water Pump V/50-60 Hz 3 Float Valve 3a Float Valve Assembly 3b Float Valve Screen 3c Float Valve Plunger 3d Compression Nut Ice Thickness Control Probe Magnetic Bin Switch Water Curtain Water Trough Water Distribution Tube - B/J/Q Water Pump Discharge Tube 9a Degree Barbed Fitting 9b Tube [1] 10a Male Wing Nut 10b Female Receptacle Float Valve Bracket Water Curtain Pin Assembly Thumbscrew - #8-32 x 0.375" Water Flow Clamp Use on Regular Cube Evap. Only Evaporator Top Molding and Gasket Assembly Trough Protectors PART NOTES: [1] - elbow to dump valve Q1400C_3.PDF 4

7 Q1400C - REFRIGERATION COMPARTMENT - COMMON COMPONENTS Q1400C_4.PDF 5

8 Q1400C - REFRIGERATION COMPARTMENT - COMMON COMPONENTS # PART # DESCRIPTION QTY Note Receiver Service Valve 1a Caps for Refrigeration Service Valve Drier Magni-Check Valve - 0.5" 4 Liquid Line Solenoid Valve 4a Danfoss Solenoid Valve with Coil - 115V/60 Hz 4b Danfoss Solenoid Valve Coil Only - 115V/60 Hz [1] 4c Alco Solenoid Valve Coil Only - 115V/60 Hz 4d Danfoss Solenoid Valve with Coil - 230V/50-60 Hz 4e Danfoss Solenoid Valve Coil Only - 230V/50-60 Hz [2] 4f Alco Solenoid Valve Coil Only - 230V/50 Hz Expansion Valve Valve Insulation Boot - Body 7 Dump Valve 7a Water Dump Valve - 115V/60 Hz 7b Water Dump Valve V/50-60 Hz 8 Harvest Valves [3] 8a Solenoid Valve Assembly 115V/60 Hz Alco 8b Alco Solenoid Valve Coil Only - 115V/60 Hz 8c Solenoid Valve Assembly Alco 230V/50 Hz 8d Alco Solenoid Valve Coil Only - 230V/50 Hz Manual Shut-off Valve Liquid Line Manual Shut-off Valve Suction Line 10a Valve Insulation Boot - Body [4] Female Wing Adapter " Expansion Valve Bulb, Boot Receiver Dump Valve Bracket Receiver Mounting Strap [5] Female Wing Adapter " Dump Valve Drain Tubing Bracket - 1/2" Valve Bracket - 3/4" Valve Screw - #10-24 x 0.50" PHIL Wiring Harness - Control Box to Valves PART NOTES: [1] - \pages from _02.jpg" width=280 height=256> [2] - \pages from _02.jpg" width=266 height=183> [3] - Some Q1400C machines contain Danfoss harvest valves; replace both left & right with Alco. [4] - \pages from _02.jpg" width=362 height=281> [5] - Interchangeable Top or Bottom Q1400C_4.PDF 6

9 Q1400C - HEAD SECTION - PANELS Q1400C_5.PDF 7

10 Q1400C - HEAD SECTION - PANELS # PART # DESCRIPTION QTY Note Front Panel Assembly 2 Left Side Panel 2a Left Side Panel - Up to Serial Number b Left Side Panel - After Serial Number Top Cover 4 Back Panel 4a Back Panel - Up to Serial Number b Back Panel - After Serial Number Back Coupling Panel Right Side Panel Water Splash Shield Screw - #8 x 1.75" Washer - Nylon 0.171" x 0.38" Screw Retainer - Nylon # Speed Nut Assembly to Mount Front Cover Screw - #10-24 x 0.50" PHIL Extruded Tape Nylatch Fastener Grommet Nylatch Fastener Plunger Q1400C_5.PDF 8

11 CVD1475/ CONDENSING UNIT - CONTROL BOX COMPONENTS Q1400C_7.PDF 9

12 CVD1475/ CONDENSING UNIT - CONTROL BOX COMPONENTS # PART # DESCRIPTION QTY Note Fan Cycling Control psig [1] High Pressure Cut-out Control Low Pressure Cut-out Control 4 Contactor 4a Contactor V/50-60 Hz/1 Ph 4b Contactor - 230V/60 Hz/3 Ph Start Components Tecumseh Start Potential Relay - 60 Hz 5a Start Potential Relay - 50 Hz Start Capacitor Hz/1 Ph Run Capacitor V/50-60 Hz/1 Ph [2] 7a Run Capacitor V/50-60 Hz/1 Ph [3] Start Components Copeland CS20K6E Start Potential Relay Hz/1 Ph [2] 8a Start Potential Relay - 50 Hz/1 Ph [3] Start Capacitor 60 Hz/1 Ph 9a Start Capacitor 50 Hz/1 Ph Run Capacitor V/50-60 Hz/1 Ph Start Components Copeland CS24K6E Start Potential Relay V/60 Hz/1 Ph [2] 11a Start Potential Relay - 230V/50-60 Hz/1 Ph [3] Start Capacitor 60 Hz/1 Ph [2] 12a Start Capacitor - 230V/50-60 Hz/1 Ph [3] Run Capacitor V/50-60 Hz/1 Ph [2] 13a Run Capacitor V/50-60 Hz/1 Ph [3] Screw - #10-24 x 0.50" HEX Capacitor Mounting Strap Capacitor Mounting Bracket Screw - #10-24 x 0.50" Ground Bushing " OD x 0.44" ID Bushing " OD x 0.75" ID Terminal Block - 50 Hz - 3 Pole PART NOTES: [1] - \pages from _09.jpg" width=150 height=306> [2] - 60 Hz [3] - 50 Hz Q1400C_7.PDF 10

13 CVD1475/ CONDENSING UNIT - REFRIGERATION COMPONENTS Q1400C_6.PDF 11

14 CVD1475/ CONDENSING UNIT - REFRIGERATION COMPONENTS # PART # DESCRIPTION QTY Note 1 Compressor 1a Compressor - Copeland V/60 Hz/1 Ph 1b Compressor - Copeland V/60 Hz/3 Ph 1c Compressor - Copeland - 230V/50 Hz/1 Ph Suction Accumulator Access Valve 4 Fan Motor 4a Fan Motor V/60 Hz/1-3 Ph 4b Fan Motor V/50 Hz/1-3 Ph Fan Blade Air Condenser Head Pressure Control Valve Fan Shroud Fan Motor Mounting Bracket Mounting - Screw Mounting - Lockwasher Mounting - Hexnut Mounting - Screw Mounting - Lockwasher Mounting - Flatwasher Mounting - Rubber Wellnut Suction Line Filter Q1400C_6.PDF 12

15 CVD1475/ CONDENSING UNIT - PANELS Q1400C_8.PDF 13

16 CVD1475/ CONDENSING UNIT - PANELS # PART # DESCRIPTION QTY Note Condenser Fan Guard Control Box Cover Control Box Panel Left Side Panel Cover Top Right Side Panel Condensing Unit Tube Shield Screw - #10-24 x 0.50" HEX Q1400C_8.PDF 14

17 CVD CONDENSING UNIT - CONTROL BOX COMPONENTS Q1400C_10.PDF 15

18 CVD CONDENSING UNIT - CONTROL BOX COMPONENTS # PART # DESCRIPTION QTY Note 1 Contactor 1a Contactor V/50-60 Hz/1 Ph 1b Contactor - 230V/60 Hz/3 Ph Start Potential Relay Hz/1 Ph Start Capacitor 60 Hz/1 Ph Run Capacitor V/50-60 Hz/1 Ph Bushing " Screw - #10-24 x 0.50" Ground Screw - #10-24 x 0.50" HEX Capacitor Mounting Strap Control Box 10 Wiring Harness 10a Wiring Harness V/60Hz/1Ph 10b Wiring Harness V/60Hz/3Ph Q1400C_10.PDF 16

19 CVD CONDENSING UNIT - REFRIGERATION COMPONENTS Q1400C_9.PDF 17

20 CVD CONDENSING UNIT - REFRIGERATION COMPONENTS # PART # DESCRIPTION QTY Note 1 Compressor 1a Compressor - Copeland V/60 Hz/1 Ph 1b Compressor - Copeland V/60 Hz/3 Ph Suction Accumulator Suction Line Filter 4 Water Regulating Valve 4a Water Regulating Valve psig 4b Water Regulating Valve psig [1] Head Pressure Control Valve Water Cooled Condenser Low Pressure Cut-out Control High Pressure Cut-out Control Molded Plug Access Valve Receiver Mounting Bracket Upper/Lower 12 Drain Pan Assembly [2] Drain Pan White Vinyl Drain tube Female Wing Adapter " Water Regulating Valve Union 16 Compressor Mounting 16a Bolt 16b Mounting - Rubber Grommet 16c Mounting - Flatwasher 16d Metal Sleeve PART NOTES: [1] - High Pressure Option [2] - No Longer Available Q1400C_9.PDF 18

21 CVD CONDENSING UNIT - PANELS Q1400C_11.PDF 19

22 CVD CONDENSING UNIT - PANELS # PART # DESCRIPTION QTY Note Component Mounting Panel Left Side Panel Control Box Panel Cover Top Right Side Panel Screw - #10-24 x 0.50" HEX Q1400C_11.PDF 20