DDYZ SERIES - 13 SEER SINGLE PACKAGED GAS/ELECTRIC AIR CONDITIONER (R-410A, STYLE A,B)

Transcription

1 HVAC SERVICE PARTS DDYZ SERIES - 13 SEER SINGLE PACKAGED GAS/ELECTRIC AIR CONDITIONER (R-410A, STYLE A,B) Supersedes: Rev. A (1211) Rev. B (0112) 1 of , SINGLE AND THREE PHASE CONTROL BOX (208/230V) Figure 1 24 THREE PHASE CONTROL BOX (460/575V) Johnson Controls Unitary Products

2 Rev. B (0112) 2 of Figure 2 2 of 14 Johnson Controls Unitary Products

3 3 of Rev. B (0112) ITEM FIG DESCRIPTION DDYZ-F048D110 DDYZ-F048D135 DDYZ-F048N080 DDYZ-T048N080 Compressors 1 3 Compressor S S S S Cushion Mount S S S S Bolt, Compressor S S S S Condensor Fan Motor & Air Moving Components 5 1 Motor, Fan S S S S Blade, Fan S S S S Guard, Fan S S S S * Wireway(26 ) S S S S Roof, Condenser S S S S * Kit, Acorn Nut S S S S Indoor Blower Motor & Air Moving Components 12 1 Motor, Blower, Programmed S S S S Motor, Blower, Unprogrammed S S S S Wheel, Blower Included in item #16 Included in item #16 Included in item #16 Included in item # Grommet, Motor Mount (3 Req d) S S S S Ferrule, Motor Mount (3 Req d) S S S S Housing, Blower S S S S Assembly, Motor Mount S S S S * Cutoff, Blower Plate, Blower S S S S Switch,Aux Limit, Manual Reset S S S S Electric Box 22 * Relay, Control S S S S Board, Control S S S S Capacitor, Dual Run S S S Capacitor, Single Run S Transformer S S S S Contactor S S S S Lug, Electrical S S S S Assist, Motor Start S * Harness, Wire, Control S S S S * Diagram, Wiring Breaker, Circuit S Evaporator Coil, Condensor Coil, and Piping Components 36 3 Coil, Evaporator S S S S TXV S S S S Coil, Condenser S S S S Switch, High Pressure S S S S Switch, Low Pressure S S S S Filter Drier S S S S Connector Tee, Pres Sw. (2 Req d) S S S S * Valve, Schraeder (4 Req d) S S S S * Cap, Seal (2 Req d) S S S S Heating Section, Vent, Blower, and Gas Control Components 48 2 Heat Exchanger Assy S S S S Plate, Restrictor S S S S Baffle, Restrictor S S S Flue, Exhaust S S S S Blower, Vent S S S S Gasket, Vent Blower S S S S Valve, Gas S S S1-VR8204M1026 S1-VR8204M Maniflold, Gas S S S S Orifice, Gas (#40) S S S S Ignitor, Spark, Pilot S S S S Switch, Control Rollout S S S S * Switch, Limit, Auto Reset S S S S Burner, Gas S S S S Switch, Air Pressure S S S S * Gasket, High Temp S S S S Johnson Controls Unitary Products 3 of 14

4 Rev. B (0112) 4 of 14 ITEM FIG DESCRIPTION DDYZ-F048D110 DDYZ-F048D135 DDYZ-F048N080 DDYZ-T048N080 Sheet Metal Components 66 1 Base Rail, Front S S S S Base Rail, Back S S S S Base Rail, Side (2 Req d) S S S S Post, Corner Assy S S S S Panel, Access, Blower S S S S Panel, Access, Heater S S S S Panel, Duct S S S S Post, Corner Assy, Front S S S S Post, Corner Assy, Left Front S S S S Duct Cover (2 Req d) S S S S * Screen, Flue S S S S Coil Guard, (narrow) S S S S Coil Guard, (wide) S S S S * Hood, Flue, Exhaust Outlet S S S S * Kit, Filter Rack S * Filter, Air, Alum S Drain Pan & Accessories 87 * Pan, Drain S S S S * Plug, Drain Pan S S S S * Drain Fitting S S S S * Tubing, Drain S S S S Figure of 14 Johnson Controls Unitary Products

5 5 of Rev. B (0112) ITEM FIG DESCRIPTION DDYZ-W048N080 DDYZ-F048N110 DDYZ-T048N110 DDYZ-W048N110 Compressors 1 3 Compressor S S S S Cushion Mount S S S S Bolt, Compressor S S S S Condensor Fan Motor & Air Moving Components 5 1 Motor, Fan S S S S Blade, Fan S S S S Guard, Fan S S S S * Wireway(26 ) S S S S Roof, Condenser S S S S * Kit, Acorn Nut S S S S Indoor Blower Motor & Air Moving Components 12 1 Motor, Blower, Programmed S S S S Motor, Blower, Unprogrammed S S S S Wheel, Blower Included in item #16 Included in item #16 Included in item #16 Included in item # Grommet, Motor Mount (3 Req d) S S S S Ferrule, Motor Mount (3 Req d) S S S S Housing, Blower S S S S Assembly, Motor Mount S S S S * Cutoff, Blower Plate, Blower S S S S Switch,Aux Limit, Manual Reset S S S S Electric Box 22 * Relay, Control S S S S Board, Control S S S S Capacitor, Dual Run --- S Capacitor, Single Run S S S Transformer S S S S Contactor S S S S Lug, Electrical S S S S Assist, Motor Start * Harness, Wire, Control S S S S * Diagram, Wiring Transformer S S Breaker, Circuit S S S Block, Terminal S S Evaporator Coil, Condensor Coil, and Piping Components 36 3 Coil, Evaporator S S S S TXV S S S S Coil, Condenser S S S S Switch, High Pressure S S S S Switch, Low Pressure S S S S Filter Drier S S S S Connector Tee, Pres Sw. (2 Req d) S S S S * Valve, Schraeder (4 Req d) S S S S * Cap, Seal (2 Req d) S S S S Heating Section, Vent, Blower, and Gas Control Components 48 2 Heat Exchanger Assy S S S S Plate, Restrictor S S S S Baffle, Restrictor S S S S Flue, Exhaust S S S S Blower, Vent S S S S Gasket, Vent Blower S S S S Valve, Gas S1-VR8204M1026 S1-VR8204M1026 S1-VR8204M1026 S1-VR8204M Maniflold, Gas S S S S Orifice, Gas (#40) S S S S Ignitor, Spark, Pilot S S S S Switch, Control Rollout S S S S * Switch, Limit, Auto Reset S S S S Burner, Gas S S S S Switch, Air Pressure S S S S * Gasket, High Temp S S S S Johnson Controls Unitary Products 5 of 14

6 Rev. B (0112) 6 of 14 ITEM FIG DESCRIPTION DDYZ-W048N080 DDYZ-F048N110 DDYZ-T048N110 DDYZ-W048N110 Sheet Metal Components 66 1 Base Rail, Front S S S S Base Rail, Back S S S S Base Rail, Side (2 Req d) S S S S Post, Corner Assy S S S S Panel, Access, Blower S S S S Panel, Access, Heater S S S S Panel, Duct S S S S Post, Corner Assy, Front S S S S Post, Corner Assy, Left Front S S S S Duct Cover (2 Req d) S S S S * Screen, Flue S S S S Coil Guard, (narrow) S S S S Coil Guard, (wide) S S S S * Hood, Flue, Exhaust Outlet S S S S * Kit, Filter Rack S S S * Filter, Air, Alum. S S S Drain Pan & Accessories 87 * Pan, Drain S S S S * Plug, Drain Pan S S S S * Drain Fitting S S S S * Tubing, Drain S S S S of 14 Johnson Controls Unitary Products

7 7 of Rev. B (0112) ITEM FIG DESCRIPTION DDYZ-F048N135 DDYZ-T048N135 DDYZ-W048N135 DDYZ-F060D110 Compressors 1 3 Compressor S S S S Cushion Mount S S S S Bolt, Compressor S S S S Condensor Fan Motor & Air Moving Components 5 1 Motor, Fan S S S S Blade, Fan S S S S Guard, Fan S S S S * Wireway(26 ) S S S S Roof, Condenser S S S S * Kit, Acorn Nut S S S S Indoor Blower Motor & Air Moving Components 12 1 Motor, Blower, Programmed S S S S Motor, Blower, Unprogrammed S S S S Wheel, Blower Included in item #16 Included in item #16 Included in item #16 Included in item # Grommet, Motor Mount (3 Req d) S S S S Ferrule, Motor Mount (3 Req d) S S S S Housing, Blower S S S S Assembly, Motor Mount S S S S * Cutoff, Blower Plate, Blower S S S S Switch,Aux Limit, Manual Reset S S S S Electric Box 22 * Relay, Control S S S S Board, Control S S S S Capacitor, Dual Run S S Capacitor, Single Run --- S S Transformer S S S S Contactor S S S S Lug, Electrical S S S S Assist, Motor Start * Harness, Wire, Control S S S S * Diagram, Wiring Transformer S Breaker, Circuit --- S S Block, Terminal S Evaporator Coil, Condensor Coil, and Piping Components 36 3 Coil, Evaporator S S S S TXV S S S S Coil, Condenser S S S S Switch, High Pressure S S S S Switch, Low Pressure S S S S Filter Drier S S S S Connector Tee, Pres Sw. (2 Req d) S S S S * Valve, Schraeder (4 Req d) S S S S * Cap, Seal (2 Req d) S S S S Heating Section, Vent, Blower, and Gas Control Components 48 2 Heat Exchanger Assy S S S S Plate, Restrictor S S S S Baffle, Restrictor --- S S Flue, Exhaust S S S S Blower, Vent S S S S Gasket, Vent Blower S S S S Valve, Gas S1-VR8204M1026 S1-VR8204M1026 S1-VR8204M1026 S Maniflold, Gas S S S S Orifice, Gas (#40) S S S S Ignitor, Spark, Pilot S S S S Switch, Control Rollout S S S S * Switch, Limit, Auto Reset S S S S Burner, Gas S S S S Switch, Air Pressure S S S S * Gasket, High Temp S S S S Johnson Controls Unitary Products 7 of 14

8 Rev. B (0112) 8 of 14 ITEM FIG DESCRIPTION DDYZ-F048N135 DDYZ-T048N135 DDYZ-W048N135 DDYZ-F060D110 Sheet Metal Components 66 1 Base Rail, Front S S S S Base Rail, Back S S S S Base Rail, Side (2 Req d) S S S S Post, Corner Assy S S S S Panel, Access, Blower S S S S Panel, Access, Heater S S S S Panel, Duct S S S S Post, Corner Assy, Front S S S S Post, Corner Assy, Left Front S S S S Duct Cover (2 Req d) S S S S * Screen, Flue S S S S Coil Guard, (narrow) S S S S Coil Guard, (wide) S S S S * Hood, Flue, Exhaust Outlet S S S S * Kit, Filter Rack --- S S * Filter, Air, Alum. --- S S Drain Pan & Accessories 87 * Pan, Drain S S S S * Plug, Drain Pan S S S S * Drain Fitting S S S S * Tubing, Drain S S S S of 14 Johnson Controls Unitary Products

9 9 of Rev. B (0112) ITEM FIG DESCRIPTION DDYZ-F060D135 DDYZ-F060N080 DDYZ-T060N080 DDYZ-W060N080 < Compressors 1 3 Compressor S S S S Cushion Mount S S S S Bolt, Compressor S S S S * Harness, Compressor S S Condensor Fan Motor & Air Moving Components 5 1 Motor, Fan S S S S Blade, Fan S S S S Guard, Fan S S S S * Wireway(26 ) S S S S Roof, Condenser S S S S * Kit, Acorn Nut S S S S Indoor Blower Motor & Air Moving Components 12 1 Motor, Blower, Programmed S S S S Motor, Blower, Unprogrammed S S S S Wheel, Blower Included in item #16 Included in item #16 Included in item #16 Included in item # Grommet, Motor Mount (3 Req d) S S S S Ferrule, Motor Mount (3 Req d) S S S S Housing, Blower S S S S Assembly, Motor Mount S S S S * Cutoff, Blower Plate, Blower S S S S Switch,Aux Limit, Manual Reset S S S S Electric Box 22 * Relay, Control S S S S Board, Control S S S S Capacitor, Dual Run S S Capacitor, Single Run S S Transformer S S S S Contactor S S S S Lug, Electrical S S S S Assist, Motor Start * Harness, Wire, Control S S S S * Diagram, Wiring Transformer S Breaker, Circuit S S Block, Terminal S Evaporator Coil, Condensor Coil, and Piping Components 36 3 Coil, Evaporator S S S S TXV S S S S Coil, Condenser S S S S Switch, High Pressure S S S S Switch, Low Pressure S S S S Filter Drier S S S S Connector Tee, Pres Sw. (2 Req d) S S S S * Valve, Schraeder (4 Req d) S S S S * Cap, Seal (2 Req d) S S S S Heating Section, Vent, Blower, and Gas Control Components 48 2 Heat Exchanger Assy S S S S Plate, Restrictor S S S S Baffle, Restrictor --- S S S Flue, Exhaust S S S S Blower, Vent S S S S Gasket, Vent Blower S S S S Valve, Gas S S1-VR8204M1026 S1-VR8204M1026 S1-VR8204M Maniflold, Gas S S S S Orifice, Gas (#40) S S S S Ignitor, Spark, Pilot S S S S Switch, Control Rollout S S S S * Switch, Limit, Auto Reset S S S S Burner, Gas S S S S Switch, Air Pressure S S S S * Gasket, High Temp S S S S Johnson Controls Unitary Products 9 of 14

10 Rev. B (0112) 10 of 14 ITEM FIG DESCRIPTION DDYZ-F060D135 DDYZ-F060N080 DDYZ-T060N080 DDYZ-W060N080 < Sheet Metal Components 66 1 Base Rail, Front S S S S Base Rail, Back S S S S Base Rail, Side (2 Req d) S S S S Post, Corner Assy S S S S Panel, Access, Blower S S S S Panel, Access, Heater S S S S Panel, Duct S S S S Post, Corner Assy, Front S S S S Post, Corner Assy, Left Front S S S S Duct Cover (2 Req d) S S S S * Screen, Flue S S S S Coil Guard, (narrow) S S S S Coil Guard, (wide) S S S S * Hood, Flue, Exhaust Outlet S S S S * Kit, Filter Rack S S * Filter, Air, Alum S S Drain Pan & Accessories 87 * Pan, Drain S S S S * Plug, Drain Pan S S S S * Drain Fitting S S S S * Tubing, Drain S S S S of 14 Johnson Controls Unitary Products

11 11 of Rev. B (0112) ITEM FIG DESCRIPTION DDYZ-F060N110 DDYZ-T060N110 DDYZ-W060N110 Compressors 1 3 Compressor S S S Cushion Mount S S S Bolt, Compressor S S S * Harness, Compressor --- S S Condensor Fan Motor & Air Moving Components 5 1 Motor, Fan S S S Blade, Fan S S S Guard, Fan S S S * Wireway(26 ) S S S Roof, Condenser S S S * Kit, Acorn Nut S S S Indoor Blower Motor & Air Moving Components 12 1 Motor, Blower, Programmed S S S Motor, Blower, Unprogrammed S S S Wheel, Blower Included in item #16 Included in item #16 Included in item # Grommet, Motor Mount (3 Req d) S S S Ferrule, Motor Mount (3 Req d) S S S Housing, Blower S S S Assembly, Motor Mount S S S * Cutoff, Blower Plate, Blower S S S Switch,Aux Limit, Manual Reset S S S Electric Box 22 * Relay, Control S S S Board, Control S S S Capacitor, Dual Run S Capacitor, Single Run --- S S Transformer S S S Contactor S S S Lug, Electrical S S S Assist, Motor Start * Harness, Wire, Control S S S * Diagram, Wiring Transformer S Breaker, Circuit --- S S Block, Terminal S Evaporator Coil, Condensor Coil, and Piping Components 36 3 Coil, Evaporator S S S TXV S S S Coil, Condenser S S S Switch, High Pressure S S S Switch, Low Pressure S S S Filter Drier S S S Connector Tee, Pres Sw. (2 Req d) S S S * Valve, Schraeder (4 Req d) S S S * Cap, Seal (2 Req d) S S S Heating Section, Vent, Blower, and Gas Control Components 48 2 Heat Exchanger Assy S S S Plate, Restrictor S S S Baffle, Restrictor S S S Flue, Exhaust S S S Blower, Vent S S S Gasket, Vent Blower S S S Valve, Gas S1-VR8204M1026 S1-VR8204M1026 S1-VR8204M Maniflold, Gas S S S Orifice, Gas (#40) S S S Ignitor, Spark, Pilot S S S Switch, Control Rollout S S S * Switch, Limit, Auto Reset S S S Burner, Gas S S S Switch, Air Pressure S S S * Gasket, High Temp S S S Johnson Controls Unitary Products 11 of 14

12 Rev. B (0112) 12 of 14 ITEM FIG DESCRIPTION DDYZ-F060N110 DDYZ-T060N110 DDYZ-W060N110 Sheet Metal Components 66 1 Base Rail, Front S S S Base Rail, Back S S S Base Rail, Side (2 Req d) S S S Post, Corner Assy S S S Panel, Access, Blower S S S Panel, Access, Heater S S S Panel, Duct S S S Post, Corner Assy, Front S S S Post, Corner Assy, Left Front S S S Duct Cover (2 Req d) S S S * Screen, Flue S S S Coil Guard, (narrow) S S S Coil Guard, (wide) S S S * Hood, Flue, Exhaust Outlet S S S * Kit, Filter Rack --- S S * Filter, Air, Alum. --- S S Drain Pan & Accessories 87 * Pan, Drain S S S * Plug, Drain Pan S S S * Drain Fitting S S S * Tubing, Drain S S S of 14 Johnson Controls Unitary Products

13 13 of Rev. B (0112) ITEM FIG DESCRIPTION DDYZ-F060N135 DDYZ-T060N135 DDYZ-W060N135 Compressors 1 3 Compressor S S S Cushion Mount S S S Bolt, Compressor S S S * Harness, Compressor --- S S Condensor Fan Motor & Air Moving Components 5 1 Motor, Fan S S S Blade, Fan S S S Guard, Fan S S S * Wireway(26 ) S S S Roof, Condenser S S S * Kit, Acorn Nut S S S Indoor Blower Motor & Air Moving Components 12 1 Motor, Blower, Programmed S S S Motor, Blower, Unprogrammed S S S Wheel, Blower Included in item #16 Included in item #16 Included in item # Grommet, Motor Mount (3 Req d) S S S Ferrule, Motor Mount (3 Req d) S S S Housing, Blower S S S Assembly, Motor Mount S S S * Cutoff, Blower Plate, Blower S S S Switch,Aux Limit, Manual Reset S S S Electric Box 22 * Relay, Control S S S Board, Control S S S Capacitor, Dual Run S Capacitor, Single Run --- S S Transformer S S S Contactor S S S Lug, Electrical S S S Assist, Motor Start * Harness, Wire, Control S S S * Diagram, Wiring Transformer S Breaker, Circuit --- S S Block, Terminal S Evaporator Coil, Condensor Coil, and Piping Components 36 3 Coil, Evaporator S S S TXV S S S Coil, Condenser S S S Switch, High Pressure S S S Switch, Low Pressure S S S Filter Drier S S S Connector Tee, Pres Sw. (2 Req d) S S S * Valve, Schraeder (4 Req d) S S S * Cap, Seal (2 Req d) S S S Heating Section, Vent, Blower, and Gas Control Components 48 2 Heat Exchanger Assy S S S Plate, Restrictor S S S Baffle, Restrictor Flue, Exhaust S S S Blower, Vent S S S Gasket, Vent Blower S S S Valve, Gas S1-VR8204M1026 S1-VR8204M1026 S1-VR8204M Maniflold, Gas S S S Orifice, Gas (#40) S S S Ignitor, Spark, Pilot S S S Switch, Control Rollout S S S * Switch, Limit, Auto Reset S S S Burner, Gas S S S Switch, Air Pressure S S S * Gasket, High Temp S S S Johnson Controls Unitary Products 13 of 14

14 14 of 14 ITEM FIG DESCRIPTION DDYZ-F060N135 DDYZ-T060N135 DDYZ-W060N135 Sheet Metal Components 66 1 Base Rail, Front S S S Base Rail, Back S S S Base Rail, Side (2 Req d) S S S Post, Corner Assy S S S Panel, Access, Blower S S S Panel, Access, Heater S S S Panel, Duct S S S Post, Corner Assy, Front S S S Post, Corner Assy, Left Front S S S Duct Cover (2 Req d) S S S * Screen, Flue S S S Coil Guard, (narrow) S S S Coil Guard, (wide) S S S * Hood, Flue, Exhaust Outlet S S S * Kit, Filter Rack --- S S * Filter, Air, Alum. --- S S Drain Pan & Accessories 87 * Pan, Drain S S S * Plug, Drain Pan S S S * Drain Fitting S S S * Tubing, Drain S S S For Lo-Nox Models listed below, all componets are identical with the models above except for the addition of lo-nox screens part number S (1 per burner). LO-NOX MODELS DDYZ-F048N080X DDYZ-F048N110X DDYZ-F060N080X DDYZ-F060N110X TO ORDER AUTHORIZED FACTORY REPLACEMENT PARTS - Contact your Source1 HVAC Parts Distributor or visit our website at for a Distributor and Dealer listing. Subject to change without notice. Published in U.S.A Rev. B (0112) Copyright 2012 by Johnson Controls, Inc. All rights reserved. Supersedes: Rev. A (1211) Johnson Controls Unitary Products 5005 York Drive Norman, OK 73069