SUBMITTAL DATA S100 & S100U POSITIVE PRESSURE SERIES GAS FIRED INFRA-RED TUBE HEATERS. Page 1 PROJECT: ENGINEER: CONTRACTOR:
|
|
- Leslie Daniel
- 5 years ago
- Views:
Transcription
1 SUBMITTAL DATA & U POSITIVE PRESSURE SERIES GAS FIRED INFRA-RED TUBE HEATERS PROJECT: ENGINEER: CONTRACTOR: DISTRIBUTOR: SCHWANK MODEL #: FUEL: APPROVED BY: DATE: APPROVAL #: Page 1 Submittal
2 NOTICE: Schwank reserves the right to make changes to equipment and specifications without obligation or notification. This publication, or parts therof, may not be reproduced in any form, without prior written consent from Schwank. Unauthorized use or distribution of this publication is strictly prohibited. Schwank Group 5285 Bradco Boulevard, Mississauga, Ontario, L4W 2A6 phone: (905) fax: Schwank Way Waynesboro,Georgia, USA Phone: (706) Fax: csr@schwankgroup.com Page 2 Submittal
3 TABLE 1: MODEL CONFIGURATIONS OVERALL HEATER LENGTH BTU/HOUR INPUT 0 TO 4500 FT ABOVE SEA LEVEL TURBULATOR REQUIRED LENGTH GAS PRESSURE & ELECTRICAL SHIPPING WEIGHT (LBS.) LINE 240 MINIMUM " W.C. N.G , " W.C. L.P. 180 U , ' U LINE Not Required MAXIMUM " W.C. N.G ' Not Required 14" W.C. L.P ' 4 155,000 10' 150 U Not Required 210 U ' 3 10' ' 0 Not Required ' MANIFOLD " W.C ,000 14' N.G. 10" W.C. 120 L.P. U ' 150 U ½" INLET Not Required ' ,000 14' 120 U ' ELECTRICAL 150 U V, 60 HZ , ' ,000 14' 90 U ' 120 U ' ,000 14' 90 U , NOTE: As required, the series /U heaters will be supplied with the turbulator snugly installed into the end tube(s) of the system configuration. Page 3 Submittal
4 STRAIGHT TUBE SYSTEM TABLE 2: COMPONENT QUANTI- TIES PER HEATER MODEL ' ALUMATHERM TUBE w/ FLANGE ' ALUMINIZED TUBE w/ FLANGE ' ALUMINIZED TUBE ' STEEL TUBE ' REFLECTOR REFLECTOR END CAP TORCTITE COUPLER ACCUSEAL TUBE CLAMP TUBE / REFLECTOR WIRE HANGER ' STAINLESS STEEL TURBULATOR ' STAINLESS STEEL TURBULATOR ' ALUMINIZED STEEL TURBULATOR ' ALUMINIZED STEEL TURBULATOR HEATERS ON THIS PROJECT U U TUBE SYSTEM TABLE 2: COMPONENT QUANTI- TIES PER HEATER MODEL U U U U U ' ALUMA-THERM TUBE w/ FLANGE ' ALUMINIZED TUBE w/ FLANGE ' ALUMINIZED TUBE ' STEEL TUBE STEEL TUBE ' REFLECTOR REFLECTOR REFLECTOR END CAP TORCTITE COUPLER ACCUSEAL TUBE CLAMP TUBE / REFLECTOR WIRE HANGER ' ALUMINIZED STEEL TURBULA- TOR 4' ALUMINIZED STEEL TURBULA- TOR DEGREE TURN-AROUND BOX HEATERS ON THIS PROJECT Page 4 Submittal
5 TABLE 3: APPROVED MINIMUM CLEARANCES TO COMBUSTIBLES STRAIGHT TUBE MODEL SUSPENDED HORIZONTALLY SUSPENDED AT AN ANGLE UP TO 45 DEGREES TOP SIDE BELOW TOP REAR FRONT BELOW A B C D E F G 200 7" 22" 68" 7" 1" 57" 68" " 20" 68" 6.5" 1" 47" 68" 155 6" 19" 64" 6" 1" 44" 64" 130 4" 11" 60" 5' 1" 35" 56" 110 3" 10" 60" 4.5" 1" 26" 54" 100 7" 22" 68" 7" 1" 57" 68" " 6" 42" 3.5" 1" 23" 38" " 5.5" 34" 3" 1" 17" 34" SECTION DETAILS STRAIGHT TUBE SIDE VIEW END VIEW 10-3/4 16" 10 10' TO 70' 68 13" Page 5 Submittal
6 TABLE 4: APPROVED MINIMUM CLEARANCES TO COMBUSTIBLES U U TUBE MODEL SUSPENDED HORIZONTALLY SUSPENDED AT AN ANGLE UP TO 45 DEGREES TOP SIDE BELOW TOP REAR FRONT BELOW A B C D E F G U 200 7" 22" 68" 7" 1" 57" 68" U " 20" 68" 6.5" 1" 47" 68" U 155 6" 19" 64" 6" 1" 44" 64" U 130 4" 11" 60" 5' 1" 35" 56" U 110 3" 10" 60" 4.5" 1" 26" 54" U " 6" 42" 3.5" 1" 23" 38" U " 5.5" 33" 3" 1" 17" 34" A B C UP TO 45 SECTION DETAILS U TUBE SIDE VIEW END VIEW 4 1/2" 16" 9 10' 8 TO TO 30' 29 10" 21" Page 6 Submittal
7 TOP VIEWS OF SYSTEMS OPTIONAL ACCESSORIES PROJECT QTY 90 DEGREE ELBOW KIT JM-0508-KT 1 ELBOW, 2 REFLECTOR END CAPS, 1 CLAMP. 180 DEGREE ELBOW KIT JM-0513-KT 1 ELBOW, 2 REFLECTOR END CAPS, 1 CLAMP. 4" FRESH AIR INTAKE ADAPTER JS-0532-SE CUT-AWAY BURNER VIEW 4" FRESH AIR INTAKE CAP JS-0532-VC 4" ROOF FLUE VENT TERMINAL JA-0530-XX 6" ROOF FLUE VENT TERMINAL JA-0531-XX 4" WALL FLUE VENT TERMINAL JA-0528-XX 6" WALL FLUE VENT TERMINAL JA-0529-XX FLUE VENT TEE (4" x 4" x 6") JA-0514-AA USA ONLY: FLEX GAS CONNECTOR 1/2 x 24 45,000 TO 155,000 BTUH JL-0771-XX FLEX GAS CONNECTOR 3/4 x ,000 TO 200,000 BTUH JL-0771-XX CANADA ONLY: HOSE GAS CONNECTOR 1/2 x 36 45,000 TO 155,000 BTUH JL-0771-RC HOSE GAS CONNECTOR 3/4 x ,000 TO 200,000 BTUH JL-0771-RB TRU-TEMP THERMOSTAT THERMOSTAT 120 VOLT THERMOSTAT 24 VOLT DIGITAL 24V THERMOSTAT RELAY KITS: Single Heater per 24V T-stat Multiple Heaters per 24V T-stat JM-0150-XX JL-0772-XX JL-0569-WR JS-0568-KT JM-0303-KT Page 7 Submittal
8 COMPONENT DESCRIPTION - SEM & SEMU IGNITION DIRECT SPARK MODULE HONEYWELL COMBINATION GAS VALVE REFLECTORS REFLECTOR END CAPS TUBES 45 THRU 155 MBTUH INPUT TUBES 175 & 200 MBTUH INPUT HANGERS COUPLING KIT HONEYWELL 24 VOLT 10 LONG, OVERLAPPING ENTIRE LENGTH OF THE HEATER- EXCEPT FOR 15 SYSTEMS WHICH WILL ALSO HAVE 5 REFLECTORS ALUMINIZED STEEL FIRST SECTION IS 10' LONG, 4" DIAMETER, 16 GA.ALUMINIZED STEEL WITH ONE SWAGED END EACH ADDITIONAL SECTION IS 10' LONG, 4" DIAMETER, 16 GA. HOT ROLLED STEEL AND ONE SWAGED END EXCEPT FOR 15 SYSTEMS WHICH WILL ALSO HAVE 5 TUBES FIRST SECTION IS 10' LONG, 4" DIAMETER, 16 GA. ALUMA-THERM WITH ONE SWAGED END. SECOND SECTION IS 10' LONG, 4" DIAMETER, 16 GA. ALUMINIZED STEEL WITH ONE SWAGED END. EACH ADDITIONAL SECTION IS 10' LONG, 4" DIAMETER, 16 GA. HOT ROLLED STEEL WITH ONE SWAGED END. TWO HANGERS SUPPORT EACH LENGTH OF TUBE / REFLECTOR TORCTITE COUPLER C/W 2 BOLTS 100,000, 175,000, & 200,000 Btuh HAVE ACCUSEAL TUBE CLAMP AT JUNCTION OF FIRST TO SECOND TUBE MANIFOLD PRESSURE: -NATURAL GAS 3.5" W.C. -PROPANE 10" W.C. ELBOWS 90 DEGREE ELBOW 4" DIAMETER, 16 GA. ALUMINIZED STEEL, 8 ½" CENTRE RADIUS WITH ONE SWAGED END. 180 DEGREE ALUMINIZED STEEL TURN-AROUND BOX WITH ONE SWAGED END. BURNER HOUSING BURNER TRANSFORMER SAFETY SWITCHES BLOWER BOTTOM FOLDS AWAY, PROVIDING ACCESS FROM TWO SIDES, END, AND BOTTOM INCORPORATES EFFECTILE CERAMIC BURNER HEAD. 120/24VAC; 20VA TWO SEPARATE AIR PRESSURE SWITCHES SENSE ADEQUATE COMBUSTION AIR AND POTENTIAL BLOCKED FLUE 3300 RPM 110 VOLT THERMOSTAT OPTIONS LINE VOLTAGE THERMOSTAT FACTORY READY CONTROL SCHWANK TRU-TEMP (24V) SET CK THERMOSTAT WITH RADIANT & AMBIENT SENSORS, AND AUTOMATIC UNOCCUPIED SETCK MODE 24V THERMOSTAT THE ABOVE 24V THERMOSTATS REQUIRE FIELD MOUNTED 24V CON- TROL OPTION: SINGLE HEATER PER THERMOSTAT: RELAY KIT JS-0568-KT MULTIPLE HEATERS PER THERMOSTAT: TRANSFORMER/RELAY KIT JM-0303-KT Page 8 Submittal
STS-JZ (premierschwank) POSITIVE PRESSURE SERIES GAS FIRED INFRA-RED TUBE HEATERS
SUBMITTAL DATA (premierschwank) POSITIVE PRESSURE SERIES GAS FIRED INFRA-RED TUBE HEATERS PROJECT: ENGINEER: CONTRACTOR: DISTRIBUTOR: SCHWANK MODEL #: FUEL: APPROVED BY: DATE: APPROVAL #: 1 Submittal NOTICE:
More informationLine Pressure ( w.c.) Gas Supply Min. Max. Pressure ( w.c.) Natural Gas Propane Gas
HVAC Guideline Specifications WHISPER-JET: SET SERIES Two Stage Positive Pressure Gas-Fired Infrared Radiant Tube Type Heater Commercial/Industrial Applications Technical Summary Input Range: 80,000/60,000
More informationINSTALLATION / OWNER S MANUAL SERIES BROODER LOW INTENSITY TUBE TYPE INFRA RED HEATERS
INSTALLATION / OWNER S MANUAL ATH & SERIES BROODER IA LOW INTENSITY TUBE TYPE INFRA RED HEATERS FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapours and liquids in the vicinity of this
More informationINSTALLATION / OWNER S MANUAL
INSTALLATION / OWNER S MANUAL Member of the International Schwank Group, Companies in: Germany, Netherlands, France, United Kingdom, Austria, Belgium, United States and Canada. Licensees Worldwide. NOTICE:
More informationSERIES. 10 year limited warranty on Burner Core 5 year limited warranty on All combustion and. 2 year limited warranty on All Burner Controls
TM SERIES Available with 40,000 to 200,000 BTU/Hr. inputs and tube lengths from 10 feet to 70 feet. Aircraft Hangars Auto Dealerships Farm Buildings Fire Stations Body Shops Car Washes Sports Facilities
More informationINSTALLATION / OWNER S MANUAL
ultraschwank Models: UHE & InfraSave Ultimate Models: EIH HIGH RADIANT OUTPUT LOW INTENSITY TUBE TYPE INFRA RED HEATER INSTALLATION / OWNER S MANUAL WARNING Improper installation, adjustment, alteration,
More informationParts List for Ener-Radiant XL Tube Heaters
Parts List for Ener-Radiant XL Tube Heaters ERXL-0 F09XL ERXL-0 NG / BRN & Cont Box 0 Front Flange F09XL ERXL-0 LP / BRN & Cont Box 009 Reflector End Cap F00XL Tube Set- 0' 099 Spring Clips 0 Tube H.E.
More informationCLEARANCES TO COMBUSTIBLES
12288 Brawn Road 22, Wainfleet, Ontario, Canada L0S 1V0 Phone: 905-899-3473 Fax: 905-899-2262 www.easyradiantworks.com email: erw@vaxxine.com Engineering Submittal Data EZB series straight and U shape
More informationEngineering Submittal Data PPRTH Patio Radiant Tube Heaters.
12288 Brawn Road 22, Wainfleet, Ontario, Canada L0S 1V0 Phone: 905-899-3473 Fax: 905-899-2262 www.easyradiantworks.com email: erw@vaxxine.com P For either indoor or outdoor installation. Not for use in
More informationOmega II SUBMITTAL DATA. Pre Engineered Packages. Products by: COMBUSTION RESEARCH CORPORATION PROJECT: LOW-INTENSITY INFRARED HEATING SYSTEMS
LOW-INTENSITY INFRARED HEATING SYSTEMS Omega II Pre Engineered Packages Products by: COMBUSTION SUBMITTAL DATA PROJECT: Specifications for Omega II UNITARY P.E.P. SYSTEMS PART 1 - GENERAL It is the intent
More informationINSTALLATION / OWNER S MANUAL SCHWANK GAS FIRED INFRA RED HEATERS supraschwank 40 primoschwank 40 SERIES HIGH EFFICIENCY COMBINED INTENSITY
INSTALLATION / OWNER S MANUAL SCHWANK GAS FIRED INFRA RED HEATERS supraschwank 40 primoschwank 40 SERIES HIGH EFFICIENCY COMBINED INTENSITY FOR YOUR SAFETY: Do not store or use gasoline or other flammable
More informationGUIDE SPECIFICATION ADVANCED RADIANT SYSTEMS DU/DUH DUAL OUTPUT RANGE INFRARED TUBE HEATERS
GUIDE SPECIFICATION ADVANCED RADIANT SYSTEMS DU/DUH DUAL OUTPUT RANGE INFRARED TUBE HEATERS SECTION 15540 FUEL- FIRED HEATERS (Alternate - SECTION 235523 - GAS-FIRED RADIANT HEATERS) This section is based
More information1.03 DELIVERY, STORAGE, AND HANDLING Heater will be stored to secure against damage and handled per manufacturer s recommendations.
HVAC Guideline Specifications supraschwank Packaged Luminous Infrared Radiant Gas Heater Combined Intensity (produces both Low and High Intensity radiant output) Commercial/Industrial Applications Size
More informationT-CLASS GAS-FIRED UNIT HEATERS Separated Combustion - Direct Vent - Horizontal - 60 HZ. Thermal Efficiency - up to 82% Input - 40,000 to 300,000 Btuh
PRODUCT SPECIFICATIONS GAS UNIT HEATERS / DUCT FURNACES TU T-CLASS GAS-FIRED UNIT HEATERS Separated Combustion - Direct Vent - Horizontal - 60 HZ Bulletin No. 20402 November 207 Supersedes November 206
More informationTypical Mount Height. Combustion Chamber
! WARNING: This heater must be installed and serviced by trained gas installation and service personnel only! Improper installation, adjustment, alteration, service or maintenance can cause property damage,
More informationGAS-FIRED PRESSURIZED LOW INTENSITY INFRARED HEATERS SERIES TLP
GAS-FIRED PRESSURIZED LOW INTENSITY INFRARED HEATERS SERIES TLP CATALOG 9-117.1 JUNE, 2003 TABLE OF CONTENTS Modine's TLP Series sets the industry standard for low intensity infrared heating performance
More informationCATALOG: HVAC - Gas Space Unit Heating
CATALOG: HVAC - **Wolff Bros. Supply, Inc. reserves the right to substitute like products. Product information is subject to Manufacturer rolling changes and/or typographical errors. Wolff Bros. Supply,
More informationThe Economical, Unitary Infrared Heater Submittal: BH Series
Blackheat BH The Economical, Unitary Infrared Heater Submittal: BH Series Job: Location: Engineer: Gas Specs: Date: QTY. MODEL NO. BH UNIT INPUT BTU/HR QTY. MODEL NO. BH UNIT INPUT BTU/HR QTY. MODEL NO.
More informationGARAGE / WORKSHOP INFRARED HEATERS
GARAGE / WORKSHOP INFRARED HEATERS 22,000-25,000 BTU/HR Heater For: Garages / Workshops Barns / Utility Buildings / Storage Sheds Animal Pens / Stalls Loading Docks Building Construction Sites Doorways
More informationINFRARED RADIANT HEATERS
IRH-1R INFRARED RADIANT HEATERS High and Low Intensity RSU SERIES Unit is shown rotated at a 45 angle. RSD SERIES HIGH INTENSITY INFRARED HEATERS RSD Series Ceramic Heaters Special Honeycomb Tile Design
More informationCumberland Heating Systems
Cumberland Heating Systems Cumberland "Radiant" Brooder Clean Burning...Fuel Efficient Maintaining proper in-house temperature is critical in climate control. A consistent, stressfree environment promotes
More informationCOMPACT UNIT HEATERS Low Profile - Horizontal - 60 HZ. Steady-State Efficiency - up to 81% Input - 30,000 to 75,000 Btuh
GAS UNIT HEATERS / DUCT FURNACES LF24 COMPACT UNIT HEATERS Low Profile - Horizontal - 60 HZ PRODUCT SPECIFICATIONS Bulletin 2008 July 206 Supersedes October 20 Steady-State Efficiency - up to 8% Input
More informationLow-Intensity, Infrared Heating Systems Submittal: HE Series
Low-Intensity, Infrared Heating Systems Submittal: HE Series Job: Location: Engineer: Gas Specs: Date: QTY. MODEL NO. HE UNIT INPUT BTU/HR QTY. MODEL NO. HE UNIT INPUT BTU/HR QTY. MODEL NO. HE UNIT INPUT
More informationGUIDE SPECIFICATION ADVANCED RADIANT SYSTEMS KMI GoGas RANGE HIGH EFFICIENCY, HIGH INTENSITY INFRARED HEATERS
GUIDE SPECIFICATION ADVANCED RADIANT SYSTEMS KMI GoGas RANGE HIGH EFFICIENCY, HIGH INTENSITY INFRARED HEATERS SECTION 15540 - FUEL - FIRED HEATERS (Alternate - SECTION 235523 - GAS-FIRED RADIANT HEATERS)
More informationModel VPT 120V 60Hz Gas-Fired, Tubular, Radiant, Low-Intensity Infrared Heater
INSTALLATION / OPERATION / MAINTENANCE Applies to: Model VPT 120V 60Hz Gas-Fired, Tubular, Radiant, Low-Intensity Infrared Heater Model VPT High/Low Burner/Control Box with 20-70 ft Tube/Reflector Length
More informationGUIDE SPECIFICATION ADVANCED RADIANT SYSTEMS SL/SLV SIRIUS LINEAR RANGE HIGH EFFICIENCY CONTINUOUS INFRARED SYSTEMS
GUIDE SPECIFICATION ADVANCED RADIANT SYSTEMS SL/SLV SIRIUS LINEAR RANGE HIGH EFFICIENCY CONTINUOUS INFRARED SYSTEMS SECTION 15540 FUEL- FIRED HEATERS (Alternate - SECTION 235523 - GAS-FIRED RADIANT HEATERS)
More informationBoiler & Water Heater
MIGHTY THERM2 Date: Project #: Pump-Mounted Boiler & Water Heater MT2H Hydronic Heater MT2V Volume Water Heater Indoor/Outdoor Sizes 500-2000 Submittal Engineer: Project Name: Prepared By: Location: Bid
More informationBid Date: Date: Project Name: Project #: City/St/ZIP: Fuel Type: Natural Gas Propane. Engineer: Factory Option: Contractor: Key Features.
iq751 Submittal Data Date: Bid Date: Project Name: Project #: City/St/ZIP: Engineer: Contractor: Fuel Type: Natural Gas Propane Factory Option: intouch-bms Key Features Multiple Stainless (316L) heat exchanger
More informationMin. Mount Height. Min. Mount Height. Length Weight
*! ARNING: This heater must be installed and serviced by trained gas installation and service personnel only! Improper installation, adjustment, alteration, service or maintenance can cause property damage,
More informationiq1001, Gen II Submittal Data
, Gen II Submittal Data Date: Project Name: Bid Date: Fuel Type: Natural Gas Propane Project #: City State Zip: Engineer: Contractor: Factory Option: intouchbms KEY FEATURES Multiple Stainless (316L) Heat
More informationINSTALLATION AND OPERATION INSTRUCTIONS. INFRARED RADIANT TUBE HEATER Single and Two Stage Pull Through System (Negative Pressure)
INSTALLATION AND OPERATION INSTRUCTIONS OWNER / INSTALLER: For your safety this manual must be carefully and thoroughly read and understood before installing, operating or servicing this heater. INFRARED
More informationSUBMITTAL SCHEDULE & DATA
SUBMITTAL SCHEDULE & DATA Gas- and Oil-Fired Unit Heaters, Infrared Heaters, and Indoor Duct Furnaces Job Name: Date: 10/31/2016 Location: Engineer: Submitted by: Jeff Musto Architect: Contractor: Model
More informationINSTALLATION / OWNER S MANUAL LUMINOUS GAS FIRED INFRA RED HEATERS
INSTALLATION / OWNER S MANUAL ECOSCHWANK & ECOSCHWANK X-Series IL & IL X-Series LUMINOUS GAS FIRED INFRA RED HEATERS FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapours and liquids
More informationINSTALLATION / OWNER S MANUAL
ecoschwank-x 36, 52 IL-X 150, 200 Gas-Fired Luminous (High Intensity) Infrared Heaters INSTALLATION / OWNER S MANUAL WARNING Improper installation, adjustment, alteration, service or maintenance can cause
More informationINFRARED RADIANT TUBE HEATER
INFRARED RADIANT TUBE HEATER LTS 40 250 SERIES PROJECT: ADDRESS: ARCHITECT/ENGINEER: ADDRESS: CONTRACTOR: ADDRESS: SUBMITTED BY: N-NATURAL GAS (CHECK ONE) L-PROPANE GAS EQUIPMENT USED: 5-SINGLE STAGE (CHECK
More informationUNIT HEATER CATALOG. Form RZ-NA-C-UH (Version F)
UNIT HEATER CATALOG Form RZ-NA-C-UH (Version F) BACKGROUND Reznor was founded in 1888 to manufacture the Reznor reflector heater, which used a luminous flame gas burner developed by George Reznor. This
More informationRADIANT HEATER CATALOG
RADIANT HEATER CATALOG COMMERCIAL/INDUSTRIAL RADIANT HEATERS Heats Objects and People, Not the Air STYLES Low Intensity Tubular Radiant - Single-Stage - Two-Stage - Harsh Environment High Intensity Radiant
More informationM3RL Series TECHNICAL SPECIFICATIONS. FEATURES and BENEFITS. High Efficiency / Direct Vent Condensing Downflow Gas Furnace
TECHNICAL SPECIFICATIONS M3RL Series High Efficiency / Direct Vent Condensing Downflow Gas Furnace Induced Draft - 90+ AFUE Input 60,000 & 80,000 Btuh The high efficiency downflow gas furnace is especially
More informationNAVIEN AMERICA INC FITCH AVENUE IRVINE, CALIFORNIA, USA
Navien America Inc. Specification Details for the Navien models: CR-210 CR-210A For Indoor Installation Only For Potable Water Heating and Space Heating NAVIEN AMERICA INC. 17855 FITCH AVENUE IRVINE, CALIFORNIA,
More informationOPERATING INSTRUCTIONS MANUAL (Please retain for future reference) FVN/P-400 INDIRECT FIRED SPACE HEATERS
OPERATING INSTRUCTIONS MANUAL (Please retain for future reference) For FVN/P-400 INDIRECT FIRED SPACE HEATERS CERTIFIED FOR USE IN CANADA AND U.S.A. As per Standard ANSI Z83.7/CSA 21.4 2000 Gas Fired Construction
More informationMASTERTEMP HEATER REPLACEMENT PARTS
0 Section. Maintenance/Replacement Parts Electrical System (Key Nos. through 4), See Page 2 Burner System (Key Nos. through ), See Page 4 Water System (Key Nos. through ), see Page 2 Repair Parts are available
More informationINSTALLATION AND OPERATION INSTRUCTIONS. INFRARED RADIANT TUBE HEATER Single and Two Stage Push Through System (Positive Pressure)
INSTALLATION AND OPERATION INSTRUCTIONS OWNER / INSTALLER: For your safety this manual must be carefully and thoroughly read and understood before installing, operating or servicing this heater. INFRARED
More informationASSEMBLY INSTRUCTIONS - NXS SERIES. INFRARED RADIANT TUBE HEATER Single and Two Stage Pull Through System (Negative Pressure)
ASSEMBLY INSTRUCTIONS - NXS SERIES OWNER / INSTALLER: For your safety this manual must be carefully and thoroughly read and understood before installing, operating or servicing this heater. INFRARED RADIANT
More informationProduct Data. 95% AFUE Single Stage Furnace Upflow / Downflow / Horizontal. ama ! WARNING
DIRECT OR NON -DIRECT VENT 4-WAY MULTIPOISE CONDENSING GAS FURNACE 95% AFUE Single Stage Furnace Upflow / Downflow / Horizontal FLEXIBILITY S Dual certified venting (1 or 2 pipes) Direct Vent furnace S
More informationSTERLING RSS SERIES INFRARED RADIANT TUBE HEATER
RSUS-1 RSS 40-200 SERIES (Check One) RSU 40-200 SERIES NATURAL GAS (Check One) PROPANE GAS STANDARD CONSTRUCTION ALC CONSTRUCTION (All Heat Treated Emitter Tubes) SINGLE STAGE TWO STAGE EQUIPMENT USED:
More informationResidential/Commercial Gas Condensing Tankless Models
15-Year Residential/1-Year Commercial Heat Exchanger Limited Warranty/5-Year Parts Warranty* FEATURES Ultra-Low NOx Condensing Technology Provides Unprecedented.95 Energy Factor Durable Heat Exchanger
More informationUNIT HEATER CATALOG. Form C-UH-0516 COMMERCIAL/INDUSTRIAL HEATERS RESIDENTIAL GARAGE HEATERS. FUEL Natural Gas Propane Fuel Oil
UNIT HEATER CATALOG COMMERCIAL/INDUSTRIAL HEATERS RESIDENTIAL GARAGE HEATERS FUEL Natural Gas Propane Fuel Oil CAPACITIES 25-1,200 MBH 80% - 93% Thermal Efficiency 380-16,750 CFM AIR DELIVERY Propeller
More informationHeater Install Manual
Heater Install Manual INSTALLATION / OPERATION / MAINTENANCE Applies to: ULT Series 120V 60Hz Gas- Fired, Tubular, Radiant, Low- Intensity Infrared Heater Model PT (Harsh Environment) On/Off & High/Low
More informationMascot. Gas-Fired Residential and Commercial Wall-Mounted Boiler. Easy Installation, 96% Efficiency, Fully Condensing
Mascot Gas-Fired Residential and Commercial Wall-Mounted Boiler Easy Installation, 96% Efficiency, Fully Condensing Mascot is a high-efficiency, wall-mounted boiler available in three BTU sizes 126, 167,
More informationFEATURES. Gas Furnace provides the efficiency customers want with 78% Annual Fuel Utilization Efficiency (AFUE).
This document was created with FrameMaker 4.0.4 SIZES AVAILABLE: 024065 through 060150 EFFICIENCY: IGNITION: HEAT EXCHANGER: CONTROL BOARD: The GA1A Induced-Combustion Gas Furnace provides the efficiency
More informationTECHNICAL SPECIFICATIONS
TECHNICAL SPECIFICATIONS Model PGF1RA Series M1010 Product Line High Efficiency / Upflow / Horizontal Gas Furnace Induced Draft - 80+ AFUEurnace 2 10 YEAR WARRANTY WORRY-FREE PERFORMANCE 5 YEAR DEPENDABILITY
More informationProduct Data. 58EFA Horizontal Gas Furnace. 50, ,000 Btuh Input
Product Data 58EFA Horizontal Gas Furnace 50,000 125,000 Btuh Input GAS SUPPLY MANUAL SHUTOFF VALVE SEDIMENT TRAP UNION Carrier presents the 58EFA, a dedicated horizontal gas furnace that excels in the
More informationLAARS MIGHTY THERM 2. High Efficiency Boilers and Volume Water Heaters
LAARS MIGHTY THERM High Efficiency Boilers and Volume Water Heaters The Ideal Replacement Boiler % Thermal Efficiency Straight Forward, Easy to Use Controls - 000 MBH s Industry Leading Low NOx, ppm Indoor/Outdoor
More informationSECTION GAS-FIRED RADIANT HEATERS
SECTION 23 55 23 PART 1 - GENERAL 1.1 DESCRIPTION SPEC WRITER NOTES: 1. Use this section only for NCA projects. 2. Delete between // // if not applicable to project. Also delete any other item or paragraph
More informationINSTALLATION / OWNER S MANUAL
primoschwank & supraschwank HIGH EFFICIENCY COMBINED INTENSITY Gas-Fired Luminous (High Intensity) Infrared Heaters INSTALLATION / OWNER S MANUAL WARNING Improper installation, adjustment, alteration,
More informationA. Product Data: Include rated capacities, furnished specialties and accessories.
BASE BID: SECTION 15542 FUEL-FIRED RADIANT HEATERS PART 1 - GENERAL 1.1 SUMMARY A. Furnish and install a Co-Ray-Vac Low Intensity Vented Infrared Radiant Vacuum Gas Heating System. System must be certified
More informationNPE-A and NPE-S Condensing Tankless Water Heaters
The Leader in Condensing Technology NPE-A and NPE-S Condensing Tankless Water Heaters Navien makes it easy to go tankless in residential and commercial applications. New NaviLink Wi-Fi remote control system...now
More informationRapid NP. Negative Pressure Unitary or Multiburner Infrared Heater. Installation, Operation & Service Manual WARNING
FOR YOUR SAFETY If you smell gas: 1. Open windows. 2. DO NOT try to light any appliance. 3. DO NOT use electrical switches. 4. DO NOT use any telephone in your building. 5. Extinguish any open flame. 6.
More informationINFRARED RADIANT HEATER RSCA SERIES CERAMIC HEATERS NATURAL GAS PROPANE GAS DATE: PROJECT: ARCHITECT/ENGINEER: CONTRACTOR: SUBMITTED BY:
INFRARED RADIANT HEATER RSCA SERIES CERAMIC HEATERS NATURAL GAS (CHECK ONE) PROPANE GAS PROJECT: ARCHITECT/ENGINEER: NAME: ADDRESS: NAME: ADDRESS: DATE: CONTRACTOR: SUBMITTED BY: NAME: ADDRESS: EQUIPMENT
More informationFG7T (C and L Series)
TECHNICAL SPECIFICATIONS FG7T (C and L Series) WARRANTY Smartlite Two Stage, Variable Speed, Condensing Upflow/Horizontal and Downflow Gas Furnaces Induced Draft - 95.1 AFUE Input 60,000-120,000 Btuh The
More informationProduct Data BW9 WATER BOILER SERIES B
GAS --- FIRED CONDENSING WATER BOILER SERIES B Product Data Fig. 1 - Model 50-100 Series B Fig. 2 - Model 125-200 Series B C US Use of the AHRI Certified TM Mark indicates a manufacturer s participation
More informationInsert Manual. RHT Series WARNING. For Your Safety
RHT Series Insert Manual For complete installation instructions, see the Tube Heater General Manual that accompanies this Series Insert Manual. The RHT Series Infrared Tube Heater is a positive pressure,
More informationCast Iron Gas Boiler For Forced Hot Water REPAIR PARTS AND OPTIONAL ACCESSORIES
Cast Iron Gas Boiler For Forced Hot Water REPAIR PARTS AND OPTIONAL ACCESSORIES Models BWBBAN00005 BWBBAN000070 BWBBAN00006 BWBBAN0000 BWBBAN0005 BWBBAN00070 BWBBAN0005 BWBBAN0005 BWBBAN0005 Ordering Instructions
More informationGAS-FIRED HIGH INTENSITY INFRARED HEATERS
GAS-FIRED HIGH INTENSITY INFRARED HEATERS CATALOG 9-116.1 MARCH, 2003 TABLE OF CONTENTS Modine's MT Series is a gas-fired, high intensity ceramic infrared heater. Ideal for spot heating, the MT series
More informationG6RC Series TECHNICAL SPECIFICATIONS
TECHNICAL SPECIFICATIONS G6RC Series High Efficiency / Direct Vent or Non Direct Vent Condensing Upflow/ Horizontal Gas Furnace Induced Draft - 92+ AFUE Input 40,000-120,000 Btuh The high effi ciency upfl
More informationOPERATING INSTRUCTIONS MANUAL (Please retain for future reference) F-1500T DUAL FUEL CONSTRUCTION HEATER
OPERATING INSTRUCTIONS MANUAL (Please retain for future reference) For F-1500T DUAL FUEL CONSTRUCTION HEATER CERTIFIED FOR USE IN CANADA AND U.S.A. As per Standard ANSI Z83.7 2000/ CSA 2.14 2000 Gas Fired
More informationNPE-A and NPE-S Condensing Tankless Water Heaters
NPE-A and NPE-S Condensing Tankless Water Heaters Navien makes it easy to go tankless in residential and commercial applications. New NaviLink Wi-Fi remote control system...now available as an add-on accessory.
More informationH9MPV. 2- Stage Variable Speed 90. Flexibility. Quality. Comfort. Efficiency. Service (7/2004)
H9MPV 2- Stage Variable Speed 9 Flexibility Dual Certified venting (1 or 2 pipe). Direct Vent Furnace 4 high with wider cabinets, for noise reduction and ease of installation. Factory shipped as natural
More informationNPE-A and NPE-S Condensing Tankless Water Heaters
The Leader in Condensing Technology NPE-A and NPE-S Condensing Tankless Water Heaters Navien makes it easy to go tankless in residential and commercial applications. New NaviLink Wi-Fi remote control system...now
More informationINSTALLATION AND OPERATION INSTRUCTIONS OVERHEAD RADIANT TUBE HEATERS
INSTALLATION AND OPERATION INSTRUCTIONS OVERHEAD RADIANT TUBE HEATERS Models: ADU5, ADU30, ADU35, ADU40, ADU45, ADL5, ADL30, ADL35, ADL40, ADL45 Single Stage Pull Through System (Negative Pressure) 0086
More informationForm C-IR (Version F) COMMERCIAL/INDUSTRIAL RADIANT HEATERS. Heats Objects and People, Not the Air
Page of RADIANT HEATER CATALOG COMMERCIAL/INDUSTRIAL RADIANT HEATERS Heats Objects People, Not the Air STYLES Low Intensity Tubular Radiant - Single-Stage - Two-Stage - Harsh Environment High Intensity
More informationT9MPV. 2- Stage Variable Speed 90. Flexibility. Comfort. Efficiency. Quality. Service (05/2006)
T9MPV 2- Stage Variable Speed 9 Flexibility Dual Certified venting (1 or 2 pipe), Direct Vent Furnace 4 high with wider cabinets, for ease of installation. Factory shipped as natural gas, with LP Gas conversion
More informationFor More Information Click Here or Call General Supply M7RL Series TECHNICAL SPECIFICATIONS. FEATURES and BENEFITS
TECHNICAL SPECIFICATIONS M7RL Series High Efficiency / Direct Vent Condensing Downflow Gas Furnace Induced Draft - 95%+ AFUE Input 45,000 thru 7,000 Btuh The high efficiency downflow gas furnace is especially
More informationINSTALLATION AND OPERATION INSTRUCTIONS. INFRARED RADIANT TUBE HEATER Single Stage Pull Through System (Negative Pressure)
INSTALLATION AND OPERATION INSTRUCTIONS OWNER / INSTALLER: For your safety this manual must be carefully and thoroughly read and understood before installing, operating or servicing this heater. INFRARED
More informationModel GB1AAV UPFLOW GAS FURNACE. Series G SS-GB1A-04 FEATURES
SIZES AVAILABLE: 024045 through 060155 EFFICIENCY: The GB1AAV Induced-Combustion Gas Furnace provides the efficiency customers want with 80% Annual Fuel Utilization Efficiency (AFUE). IGNITION: The field-proven
More informationModel UDAP. Power Vented, Low Static Axial Fan Commercial/Industrial Unit Heaters DESCRIPTION STANDARD FEATURES OPTIONAL FEATURES - FACTORY INSTALLED
Power Vented, Low Static Axial Fan Commercial/Industrial Unit Heaters Sizes 30-125 carry an additional approval for use in residential garage/workshops under CSA International Requirement 10.96 - U.S.
More informationINSTALLATION AND OPERATION INSTRUCTIONS. INFRARED RADIANT TUBE HEATER Two Stage Pull Through System (Negative Pressure)
INSTALLATION AND OPERATION INSTRUCTIONS OWNER / INSTALLER: For your safety this manual must be carefully and thoroughly read and understood before installing, operating or servicing this heater. INFRARED
More informationWeil-McLain part numbers are found in Weil-McLain Boilers and Controls Repair Parts Lists.
gas-fired water boiler Manual Replacement parts Replacement parts must be purchased through a local Weil-McLain distributor. When ordering, specify boiler model and size and include description and part
More informationFSA, FOA, SEP & HED Series Unit Heaters and Duct Furnaces
SG-UUH-03 November 2014 Specification Guide FSA, FOA, & HED Series Unit Heaters and Duct Furnaces Product improvement is a continuous process at Advanced Distributor Products. Therefore, product specifications
More informationTECHNICAL SPECIFICATIONS
TM TECHNICAL SPECIFICATIONS Model PGF1TE 2 Stage Series Upflow/Horizontal M1010 Product Line High Efficiency / 95.1 AFUE Direct Vent or Non Direct Vent Condensing Furnace 10 YEAR WARRANTY WORRY-FREE PERFORMANCE
More informationLF24. UNIT HEATERS Horizontal - 60 HZ. Thermal Efficiency - up to 80.5% Input - 100,000 to 390,000 Btuh LF A MODEL NUMBER IDENTIFICATION
E N G I N E E R I N G D ATA G A S U N I T H E A T E R S / D U C T F U R N A C E S LF4 UNIT HEATERS Horizontal - 60 HZ Bulletin. 0000 June 0 Supersedes February 0 Front View Tubular Heat Exchanger Thermal
More informationModel VPT 120V 60Hz Gas-Fired, Tubular, Radiant, Low-Intensity Infrared Heater for generation code BB
Obsoletes Part No. 270684 R1 INSTALLATION / OPERATION / MAINTENANCE Applies to: Model VPT 120V 60Hz Gas-Fired, Tubular, Radiant, Low-Intensity Infrared Heater for generation code BB Model VPT High/Low
More informationP P Gas Fireplace. P See Thru
P121-10 - P131-10 Gas Fireplace Model P121/P131-NG10 P121/P131-LP10 Fuel Type Natural Gas Propane Minimum Supply Pressure 5 W.C. (1.25 kpa) 12 W.C. (3.00 kpa) Manifold Pressure - High 3.8 W.C. (0.95 kpa)
More informationProduct Data. ama. BW1, BW2 & BW3 Gas-Fired Water Boilers Series B
BW1, BW2 & BW3 Gas-Fired Water Boilers Series B Product Data MODEL BW1, BW2 Series B MODEL BW3 Series B MODELS BW1, BW2, and BW3 Models BW1 and BW2 Gas-Fired Hot Water Boilers provide fast heat quietly
More informationINSTALLATION AND OPERATION INSTRUCTIONS. INFRARED RADIANT TUBE HEATER Single and Two Stage Push Through System (Positive Pressure)
INSTALLATION AND OPERATION INSTRUCTIONS OWNER / INSTALLER: For your safety this manual must be carefully and thoroughly read and understood before installing, operating or servicing this heater. INFRARED
More informationTECHNICAL SPECIFICATIONS
TECHNICAL SPECIFICATIONS Model PGC2T (C and L) Series SmartStart M1200 Product Line Two Stage, Variable Speed, High Efficiency Upflow/Horizontal and Downflow Gas Furnaces 95.1 AFUE Input 60,000-120,000
More informationRADIANT HEATER CATALOG
RADIANT HEATER CATALOG COMMERCIAL/INDUSTRIAL RADIANT HEATERS Heats Objects and People, Not the Air STYLES Low Intensity Tubular Radiant - Single-Stage - Two-Stage - Harsh Environment High Intensity Radiant
More informationTECHNICAL GUIDE MODELS: P*UR GAS-FIRED CONDENSING / HIGH EFFICIENCY UPFLOW FURNACES 92 AFUE DESCRIPTION WARRANTY FEATURES Rev.
036-1349-001 Rev. A (30) Heating TECHNICAL GUIDE MODELS: P*UR GAS-FIRED CONDENSING / HIGH EFFICIENCY UPFLOW FURNACES 9 AFUE NATURAL GAS 37-130 MBH OUTPUT Air Conditioning EFFICIENCY RATING CERTIFIED R
More informationINSTALLATION AND OPERATION INSTRUCTIONS INFRARED RADIANT POULTRY TUBE HEATER Single and Two Stage Push Through System (Positive Pressure) Models:
INSTALLATION AND OPERATION INSTRUCTIONS INFRARED RADIANT POULTRY TUBE HEATER Single and Two Stage Push Through System (Positive Pressure) Models: (Hot Rolled Steel) (Aluminized Steel) PCS75 (N5,L5,N7,L7)
More informationITH-SERIES GAS-FIRED INFRARED TUBE HEATERS TECHNICAL MANUAL
ITH-SERIES GAS-FIRED INFRARED TUBE HEATERS TECHNICAL MANUAL mwarning: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read the installation,
More informationINSTALLATION AND OPERATION INSTRUCTIONS. INFRARED RADIANT TUBE HEATER Two Stage Push Through System (Positive Pressure)
INSTALLATION AND OPERATION INSTRUCTIONS OWNER / INSTALLER: For your safety this manual must be carefully and thoroughly read and understood before installing, operating or servicing this heater. INFRARED
More informationCast Iron Gas Boiler For Forced Hot Water REPAIR PARTS AND OPTIONAL ACCESSORIES
Cast Iron Gas Boiler For Forced Hot Water REPAIR PARTS AND OPTIONAL ACCESSORIES Models BWBAAN0000 BWBAAN000070 BWBAAN0000 BWBAAN0000 BWBAAN000 BWBAAN00070 BWBAAN000 BWBAAN000 BWBAAN000 Ordering Instructions
More informationSeries MA/MX/MXR Infrared Heater Installation, Operation and Service Instructions
Series MA/MX/MXR Infrared Heater Installation, Operation and Service Instructions FOR YOUR SAFETY If you smell gas: 1. Open windows 2. Don t touch electrical switches 3. Extinguish any open flame 4. Immediately
More informationSeries RE Infrared Heater
Series RE Infrared Heater Installation, Operation and Service Instructions WARNING: If the information in these instructions are not followed exactly, a fire or explosion may result causing property damage,
More informationTECHNICAL GUIDE MODELS: P*DH GAS-FIRED CONDENSING / HIGH EFFICIENCY DOWNFLOW / HORIZONTAL FURNACES 91 AFUE DESCRIPTION WARRANTY FEATURES
036-1354-001 Rev. D (110) Heating TECHNICAL GUIDE MODELS: P*DH GAS-FIRED CONDENSING / HIGH EFFICIENCY DOWNFLOW / HORIZONTAL FURNACES 91 AFUE NATURAL GAS 37-111 MBH OUTPUT Air Conditioning EFFICIENCY RATING
More informationInstallation, Operation and Service Instructions DU/DUH RANGE DUAL OUTPUT INFRARED HEATERS
Installation, Operation and Service Instructions DU/DUH RANGE DUAL OUTPUT INFRARED HEATERS WARNINGS WARNING Improper installation, adjustment, alteration, service or maintenance can cause property damage,
More informationsportschwank HIGH EFFICIENCY INFRARED HEATER INSTALLATION / OWNER S MANUAL
sportschwank HIGH EFFICIENCY INFRARED HEATER INSTALLATION / OWNER S MANUAL INSTALLER: LEAVE THESE INSTRUCTIONS WITH THE CONSUMER CONSUMER: RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE DANGER If you smell
More informationNPE-A and NPE-S Condensing Tankless Water Heaters
The Leader in Condensing Technology NPE-A and NPE-S Condensing Tankless Water Heaters Navien makes it easy to go tankless in residential and commercial applications. New NaviLink Wi-Fi remote control system...now
More informationFG6T(C,L) Series. High Efficiency / Direct Vent or Non Direct Vent 2-Stage Condensing Gas Furnace with Variable Speed Blower TECHNICAL SPECIFICATIONS
TECHNICAL SPECIFICATIONS FG6T(C,L) Series High Efficiency / Direct Vent or Non Direct Vent 2-Stage Condensing Gas with Variable Speed Blower 92+ Upflow/Horizontal 90+ Downflow The high effi ciency 2-Stage
More informationKG6RC Series TECHNICAL SPECIFICATIONS FEATURES AND BENEFITS
TECHNICAL SPECIFICATIONS KG6RC Series High Efficiency / Direct Vent or Non Direct Vent Condensing Upflow/ Horizontal Gas Furnace Induced Draft - 92+ AFUE Input 40,000-120,000 Btuh The high effi ciency
More information