CHILLER. Operator s & Installation Manual

Size: px
Start display at page:

Download "CHILLER. Operator s & Installation Manual"

Transcription

1 CHILLER MODEL: CFF-500 Operator s & Installation Manual Release Date: November 3, 1996 Publication Number: Revision Date: May 10, 2010 Revision: E Visit the IMI Cornelius web site at for all your Literature needs.

2 CH SERIES CHILLER OPERATOR S & INSTALLATION MANUAL The products, technical information and instructions contained in this manual are subject to change without notice. These instructions are not intended to cover all details or variations of the equipment, nor to provide for every possible contingency in the installation, operation or maintenance of this equipment. This manual assumes that the person(s) working on the equipment have been trained and are skilled in working with electrical, plumbing, pneumatic and mechanical equipment. It is assumed that appropriate safety precautions are taken and that all local safety and construction requirements are being met, in addition to the information contained in this manual. To inquire about current revisions of this and other documentation or for assistance with any Cornelius product contact: This document contains proprietary information and it may not be reproduced in any way without permission from Cornelius. Printed in U.S.A. Copyright , All Rights Reserved, IMI Cornelius Inc.

3 Description Installation Front Panel Removal Locations Water Connections Electrical Connections Start-Up Operation Maintenance Pump Heater Cooling System Thermostat CFF Performance Data All Data is Based on Water Heating Capacity (3412 BTUH-858 K-CAL/HR) Fluid Recommendations Troubleshooting Warranty

4

5 DESCRIPTION The Cornelius Model CFF-500 Water Circulator is a self-contained unit consisting of a pump, heater, cooling system, and 2-stage thermostat housed in a rugged cabinet with a baked-on finish. It operates with any water system up to a maximum of 30 gallons (113 liters). The CFF-500 is not designed for continuous cooling at water temperatures above 85 F (29 C); although short term operation at higher temperatures with no external heat load is acceptable for pulling down the system temperature. Physical CFF-500 Shipping Weight 135 Lbs. Internal Liquid Volume 1.5 Gal. Inlet/Outlet Connectors 5/8 in. ID. Hose Construction Materials (In contact with liquid) Pump Polypropylene, 316 SS Buna-N Tank 316 SS Tubing PVC Electrical Operating Voltage 115/1/60 Full Load Current 14A Inrush Current 48A Technical Temperature Range F Temperature Differential (max.) 3/4 F (0.4 C) Compressor 1/2 HP Heater 1 kw Refrigerant (134a) 2 Lbs , IMI Cornelius Inc Publication Number: 90667

6 FRONT PANEL REMOVAL INSTALLATION In order to make connections to the chiller, it is necessary to remove the front panel by removing the fasteners on the front of the unit and then sliding the panel forward. When replacing the panel, slide it straight back until it is engaged under the rear retaining flange, and replace the front fasteners. LOCATIONS The chiller must be located so that the pump inlet is below the normal operating level of the bath to which it is connected. Failure to do so causes improper operation and damage to the pump. The following clearances must be maintained around the unit for proper operation: Top Right Side Left Side Open 24 in. 12 in. WATER CONNECTIONS 2 shows the proper and improper methods of making water connections. Water tubing should be 5/8 I. D., and hose clamps should be used to insure a leak-free connection. The inlet hose should run through the hole in the rear panel and connect to the pump suction connection. This line must run from a drain at the lowest point in the bath, and should not contain any inverted traps which could cause air binding to loss of prime. In open systems where foreign material may be present the bath drain should be raised slightly and fitted with a screen to prevent the entrance of such material into the inlet hose. The outlet hose connects to the top of the chiller tank and may enter the bath at any convenient point. Care should be taken to prevent short circuiting of water between inlet and outlet connections which are too close together in the bath. This may cause wide temperature variations. If an air trap must be present in the outlet line, then it should be provided with a vent valve to allow the complete removal of air. In closed systems (where the system is not open to the atmosphere) 3, the installation should include a surge pot located at the highest point in the outlet line, to facilitate proper purging of air and to allow for expansion and contraction of the water in the system with changes in temperature. This pot should normally have approximately 1/10th the total volume of the system, and small air space must remain at the top for proper operation. Figure 1. Water Connections Publication Number: , IMI Cornelius Inc.

7 ELECTRICAL CONNECTIONS All wiring must conform to NEC and local Codes. The unit must be permanently wired by means of conduit. The conduit should be run through the hole provided in the rear of the cabinet & be connected by means of a fitting to the 1/2 knockout in the electric box. The field supply wires must be spliced to the pigtails provided in the electric box. Keep all wiring way from the relay, to avoid interfering with its proper operation. Do not operate the unit until the start-up procedure has been followed. START-UP When the installation steps have been completed, the system is ready to fill (see Page 8). With the power switch Off, begin adding water to the system until the inlet hose and pump housing are completely full. This occurs automatically if the unit has been properly installed. If this priming action does not occur, go back and review the installation to be sure that there are no restrictions or air traps in the inlet hose. Once the inlet hose is full, the pump may be started by turning the power switch on. As water is pumped through the system, air is expelled from the outlet hose. (In closed systems, the vents valve must be opened to allow air to escape from the system). Figure 2. Typical Closed System Once the pump has been started, it is important to add liquid at a sufficient rate so the inlet hose remains full. Continue adding liquid until all of the air has been expelled and the liquid is at its normal operating level. After filling, check all connections for tightness. In many cases, a leaking connection on the inlet side of the pump allows air to enter the system. This can be observed as a stream of bubbles in the hose accompanied by a growling noise in the pump. If not eliminated, this air can interfere with proper system operation and can shorten the pump life. Once the system has been properly filled and purged of air, it maintains its prime automatically. The Start-Up procedure only needs to be repeated if the system has been drained. OPERATION The unit should be turned on and off by means of the power switch. The pilot light indicates the presence of power when the switch is on. Setting the thermostat dial to the desired temperature causes either the heater or cooling system to operate, depending on the water temperature. In applications requiring extreme accuracy, a thermometer should be used in the liquid bath to determine the temperature. In operation, the circulating pump runs continuously, drawing water from the system and pumping it through the tank and back out to the system. The 2-stage thermostat senses the water temperature in the tank and cycles the heater or cooling system in response to temperature changes below or above the setpoint respectively. Heating is accomplished by means of an immersion heater located at one end of the tank. The cooling system is completely sealed and consists of a compressor, condenser, receiver, thermal expansion valve and a heat exchanger which is an integral part of the tank. It utilizes refrigerant 134a to remove heat from the liquid in the tank , IMI Cornelius Inc Publication Number: 90667

8 MAINTENANCE The CFF-500 requires very little normal maintenance. The condenser fins should be cleaned occasionally with a brush or compressed air to keep them from becoming blocked by dirt. If the unit is to be shut off for a prolonged period, it should be flushed with clean water and then drained completely. Every 6 months, the pump should be oiled with SAE20 non-detergent oil at the two motor oil ports. Except for the refrigeration system, the CFF-500 is easily serviced in the field, if required. The following section serves as a guide to making general repairs. PUMP The pump consists of only one moving part, the impeller, which is magnetically driven by an open type, thermally protected motor. This magnetic drive construction eliminates shaft seals and their associated leakage and wear problems. The most common source of pump failure is dry operation, which causes the impeller to bind. HEATER The immersion heater is installed in a threaded connection in the tank. Electrical connections are made through slipon terminals. When installing a new heater, teflon tape should be used on the threads to insure a leak proof seal. COOLING SYSTEM The cooling system is hermetically sealed, and repairs to the refrigeration components should only be made by the factory. Field replaceable parts include the compressor electrical equipment and the condenser fan. The compressor electrical equipment consists of a thermal protector, starting relay and a starting capacitor. These components are located in the compressor terminal box. Care should be taken to ensure that the wires are reconnected properly when replacing these components. THERMOSTAT The thermostat consists of a temperature actuated bellows assembly which operates two micro-switches. These switches operate at slightly different temperatures to control the heating or cooling of the water in the tank. The internal thermostat parts are not field replaceable or adjustable. In case of any failure, the thermostat should be replaced. When replacing the thermostat, note the routing of the capillary, and be sure to avoid any kinks or sharp bends. The bulb is located in a well in the tank and can be removed or replaced simply by sliding it in and out. When reinstalling a new thermostat, the bulb should be coated with a heat conducting compound such as silicone grease or thermal mastic, which is available at most refrigeration supply houses. Publication Number: , IMI Cornelius Inc.

9 Figure 3. Wiring Diagram , IMI Cornelius Inc Publication Number: 90667

10 Figure 4. Circulator Dimensions Publication Number: , IMI Cornelius Inc.

11 CFF PERFORMANCE DATA ALL DATA IS BASED ON WATER HEATING CAPACITY (3412 BTUH-858 K-CAL/HR) Figure 5. Performance Data , IMI Cornelius Inc Publication Number: 90667

12 Ice Frost Operator s Manual FLUID RECOMMENDATIONS Cornelius chillers are designed to operate with water to provide maximum performance for temperatures of 40 F (4.4 C) to 100 F (37.8 C). Distilled Water De-Ionized Water (1-5 Meg ohms) De-Ionized Water (5+ Meg ohms) Propylene Glycol (Lab & Industrial Grade) Lab & Industrial Grade Ethylene Glycol Mineral/Hydraulic Oils (Commercial/Automotive Antifreeze) Acidic/Basic Solutions (Above 8 or below 6 PH) Mineral/Hydraulic Oils (Viscosity > 50 Centistrokes) Acceptable Acceptable Acceptable with Stainless Steel & PVC only (No Copper or Brass) Acceptable - 30% Glycol/70% Water (For Applications with Temperatures below 40 F) Acceptable - 30% Glycol/70% Water (For Applications with Temperatures below 40 F) NOT Acceptable (Silicate Rust Inhibitors in Automotive/Commercial antifreeze damages pump seals and housing which lead to failure.) Not Acceptable Not Acceptable For questions regarding special or other fluids contact IMI Cornelius at To purchase Lab or Industrial Glycol contact: IMI Cornelius, Part No , 5 Gal. Publication Number: M OPR , IMI Cornelius Inc.

13 TROUBLESHOOTING WARNING: Disconnect electrical power to the chiller to prevent personal injury before attempting any internal maintenance. Only qualified personnel should service the internal components or electrical wiring. If repairs to the chiller must be made, disconnect electrical power to the unit, then shut off the water source. Trouble Problem Cause Remedy Unit does not operate, Power Light OFF. Unit does not pump water. Unit does not heat. Unit runs continuously, but is not cooling. Compressor doesn t run, body cool. Compressor doesn t run, body hot. System Temerature Erratic A. Power switch off. A. Check main disconnect fuses, wiring and power lead to unit. A. Pump motor burned out or pump impeller frozen. B. Restriction or air trap in inlet line. C. Restriction in outlet line. A. Heater burned out. B. Bad Heat switch on thermostat. A. Condenser is restricted. B. Unit low on refrigerant. C. Bad expansion valve. D. Fan motor burned out. A. Bad cool switch on thermostat. B. Bad thermal protector. C. Bad control relay in electric box. D. Compressor burned out. A. Bad starting relay. B. Bad start capacitor C. Compressor burned out. A. Air in system. B. Bad thermostat. A. Replace pump. B. Clean inlet line. C. Remove restriction for outlet line. A. Replace heater. B. Replace heat switch on thermostat. A. Clean condenser. B. Call service C. Call service. D. Replace fan motor. A. Replace cool switch on thermostat. B. Replace thermal protector. C. Replace control relay in electric box. D. Replace compressor. A. Replace starting relay. B. Replace start capacitor. C. Replace compressor. A. Purge air from system. B. Replace thermostat , IMI Cornelius Inc Publication Number: 90667

14 WARRANTY IMI Cornelius Inc. warrants that all equipment and parts are free from defects in material and workmanship under normal use and service. For a copy of the warranty applicable to your Cornelius or Wilshire product, in your country, please write, fax or telephone the IMI Cornelius office nearest you. Please provide the equipment model number, serial number and the date of purchase. Publication Number: , IMI Cornelius Inc.

15

16 IMI Cornelius Inc.

CFF-500 CHILLER. Operator s & Installation Manual. Release Date: November 3, 1996 Publication Number: Revision Date: March 25, 2014 Revision: F

CFF-500 CHILLER. Operator s & Installation Manual. Release Date: November 3, 1996 Publication Number: Revision Date: March 25, 2014 Revision: F CFF-500 CHILLER Operator s & Installation Manual Release Date: November 3, 1996 Publication Number: 90667 Revision Date: March 25, 2014 Revision: F Visit the Cornelius web site at www.cornelius.com for

More information

CHILLERS. Operator s & Installation Manual

CHILLERS. Operator s & Installation Manual CHILLERS MODELS: CH750, CH751 & CH951 Operator s & Installation Manual Release Date: April 19, 2002 Publication Number: 91256 Revision Date: May 5, 2010 Revision: D Visit the IMI Cornelius web site at

More information

CHILLER. Operator s & Installation Manual

CHILLER. Operator s & Installation Manual CHILLER MODELS: CH1001-A Operator s & Installation Manual Release Date: August 9, 2002 Publication Number: 620914301 Revision Date: May 6, 2010 Revision: E Visit the IMI Cornelius web site at www.cornelius.com

More information

CH750, CH751 & CH951 CHILLERS

CH750, CH751 & CH951 CHILLERS CH750, CH751 & CH951 CHILLERS Operator s & Installation Manual Release Date: April 19, 2002 Publication Number: 91256 Revision Date: March 25, 2014 Revision: F Visit the Cornelius web site at www.cornelius.com

More information

CH250 AND CH251 CHILLERS

CH250 AND CH251 CHILLERS CH250 AND CH251 CHILLERS Operator s & Installation Manual Release Date: April 19, 2004 Publication Number: 620914801 Revision Date: May 15, 2015 Revision: G Visit the Cornelius web site at www.cornelius.com

More information

CHILLER. Model CH3000. Operator s & Installation Manual

CHILLER. Model CH3000. Operator s & Installation Manual CHILLER Model CH3000 Operator s & Installation Manual Release Date: February 14, 2011 Publication Number: 620054173OPR Revision Date: May 08, 2014 Revision: B Visit the Cornelius web site at www.cornelius.com

More information

IMI CORNELIUS CHILLER

IMI CORNELIUS CHILLER IMI CORNELIUS CHILLER Service Manual Release Date: November 9, 2005 Publication Number: 620920816SER Revision Date: NA Revision: A Visit the IMI Cornelius web site at www.cornelius.com for all your Literature

More information

CHILLER MODEL: CH1500, 2000 AND 3000

CHILLER MODEL: CH1500, 2000 AND 3000 CHILLER MODEL: CH1500, 2000 AND 3000 Operator s & Installation Manual Release Date: February 12, 2010 Publication Number: 621055837OPR Revision Date: March 25, 2014 Revision: E Visit the Cornelius web

More information

Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951

Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951 IMI CORNELIUS REMCOR INC 500 REGENCY DRIVE GLENDALE HEIGHTS, IL 60139 2268 Telephone (800) 551 4423 Facsimile (800) 519 4423 Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951 Part

More information

ABS HOPPER LID SWITCH KIT ASSEMBLY

ABS HOPPER LID SWITCH KIT ASSEMBLY ABS HOPPER LID SWITCH KIT ASSEMBLY Installation Instructions Release Date: 2010 Publication Number: 629097021INS Revision Date: October 15, 2012 Revision: C Visit the IMI Cornelius web site at www.cornelius.com

More information

Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951

Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951 IMI CORNELIUS REMCOR INC 500 REGENCY DRIVE GLENDALE HEIGHTS, IL 60139 2268 Telephone (800) 551 4423 Facsimile (866) 394 5140 Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951 Part

More information

COMPRESSOR SERVICE REPLACEMENT KIT P/N (WCC 500A, 115/60, AIR COOLED)

COMPRESSOR SERVICE REPLACEMENT KIT P/N (WCC 500A, 115/60, AIR COOLED) COMPRESSOR SERVICE REPLACEMENT KIT P/N 629097166 (WCC 500A, 115/60, AIR COOLED) INSTALLATION INSTRUCTIONS Release Date: July 05, 2012 Publication Number: 620056387INS Revision Date: March 18, 2014 Revision:

More information

Operator s Manual CHILLER ( CHILLER SERIES) Models: CH550 and CH 551

Operator s Manual CHILLER ( CHILLER SERIES) Models: CH550 and CH 551 IMI CORNELIUS REMCOR INC g 500 REGENCY DRIVE g GLENDALE HEIGHTS, IL 60139--2268 Telephone (800) 551--4423 Facsimile (800) 519--4423 Operator s Manual CHILLER ( CHILLER SERIES) Models: CH550 and CH 551

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS FCB Pinnacle 4 Flavor Wide Body Units Thermostat Reset Upgrade Kit P/N 629088712 Release Date: January 23, 2006 Publication Number: 629088712INS Revision Date: March 24, 2014

More information

ED200/250 KSTYLE LID KITS

ED200/250 KSTYLE LID KITS ED200/250 KSTYLE LID KITS P/N 629097237, 629097239, 629097245 Installation Instructions Release Date: June 25, 2014 Publication Number: 629097240INS Revision: A Visit the Cornelius web site at www.cornelius.com

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS DF/EDXXX Lid Kits for Ice Makers Release Date: July 22, 2011 Publication Number: 620919549 Revision Date: February, 2014 Revision: H Visit the Cornelius web site at www.cornelius.com

More information

A910.8A Remote Water Chiller, 8 GPH A A / A A-220V TECHNICAL ASSISTANCE TOLL FREE TELEPHONE NUMBER:

A910.8A Remote Water Chiller, 8 GPH A A / A A-220V TECHNICAL ASSISTANCE TOLL FREE TELEPHONE NUMBER: Remote Water Chiller, 8 GPH A9100080-A / A9100080-A-220V TECHNICAL ASSISTANCE TOLL FREE TELEPHONE NUMBER: 1.800.591.9360 Technical Assistance Fax: 1.626.855.4894 NOTES TO INSTALLER: 1. Please leave this

More information

ICE COOLED DISPENSER ALTA 1522 DROP-IN DISPENSER

ICE COOLED DISPENSER ALTA 1522 DROP-IN DISPENSER ICE COOLED DISPENSER ALTA 1522 DROP-IN DISPENSER Operators Manual Release Date: June 10, 2013 Publication Number: 741200028OPR Revision Date: May 9, 2014 Revision: B Visit the Cornelius web site at www.cornelius.com

More information

INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS

INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS AquaArctic Remote Water Chiller A9100080 -A TECHNICAL ASSISTANCE TOLL FREE TELEPHONE NUMBER: 1.800.591.9360 Technical Assistance Fax: 1.626.855.4894

More information

ICE DISPENSER. D45 and D90 Installation Manual. Release Date: August, 1995 Publication Number: Revision Date: March 27, 2014 Revision: D

ICE DISPENSER. D45 and D90 Installation Manual. Release Date: August, 1995 Publication Number: Revision Date: March 27, 2014 Revision: D ICE DISPENSER D45 and D90 Installation Manual Release Date: August, 1995 Publication Number: 91561 Revision Date: March 27, 2014 Revision: D Visit the Cornelius web site at www.cornelius.com for all your

More information

VISUAL DISPLAY DISPENSER OWNERS MANUAL

VISUAL DISPLAY DISPENSER OWNERS MANUAL VISUAL DISPLAY DISPENSER OWNERS MANUAL MODEL: JT20, JT20-W25, JT20-W26 Publication Number: 621058565INS Revision Date: June 24, 2014 Revision: A Visit the Cornelius web site at www.cornelius.com for all

More information

INSTALLATION MANUAL. Series 322 Ice Cube Machine SPECIFICATIONS UNPACKING. Series 322 Ice Cube Machine Installation Instructions

INSTALLATION MANUAL. Series 322 Ice Cube Machine SPECIFICATIONS UNPACKING. Series 322 Ice Cube Machine Installation Instructions INSTALLATION MANUAL Series 322 Ice Cube Machine SPECIFICATIONS 7.00 15.00 C A 6 ft electrical cord 1.00 2.00 22.00 5.00 Front 16.38 11.25 5.00 F E Air In D 2.75 2.25 14.75.75 B 23.50 21.00 Opening 23.50

More information

INSTALLATION INSTRUCTIONS TXV Horizontal Duct Coils EHD

INSTALLATION INSTRUCTIONS TXV Horizontal Duct Coils EHD TXV Horizontal Duct s EHD These instructions must be read and understood completely before attempting installation. It is important that the Blower and Duct System be properly sized to allow the system

More information

ILLUSTRATED PARTS LIST ENDURO VALVE

ILLUSTRATED PARTS LIST ENDURO VALVE ILLUSTRATED PARTS LIST ENDURO 175 8 VALVE Publication Number: 620917901IPL Revision Date: October 10, 2011 Revision: G Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs.

More information

INSTALLATION INSTRUCTIONS TXV Horizontal Slab Coils WLSH

INSTALLATION INSTRUCTIONS TXV Horizontal Slab Coils WLSH TXV Horizontal Slab Coils WLSH These instructions must be read and understood completely before attempting installation. It is important that the Blower and Duct System be properly sized to allow the system

More information

Series 1140 and 1141 Temperature Regulators

Series 1140 and 1141 Temperature Regulators Hoffman Specialty Installation & Maintenance Instructions HS-504(E) Series 1140 and 1141 Temperature Regulators! CAUTION FOLLOW ALL INSTALLATION AND OPERATING INSTRUCTIONS. TURN OFF WATER OR STEAM BEFORE

More information

INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO-200/250

INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO-200/250 INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO-200/250 Release Date: March 24, 2004 Publication Number: 92181INS Revision Date: April 07, 2014 Revision: G Visit the Cornelius web site at www.cornelius.com

More information

WATLOW IND. WATROD Circulation Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date: 6/11/2008 Rev: 2.00

WATLOW IND. WATROD Circulation Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date: 6/11/2008 Rev: 2.00 I&M NUMBER: 316-42-5-1 Page: 1 Pre Installation Check to make sure that heater received is the same as that ordered. Watlow heaters are built to comply with UL and CSA dielectric requirements, it may be

More information

WMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS

WMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS WMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS **WARNING TO INSTALLER, SERVICE PERSONNEL AND OWNER** Altering the product or replacing parts with non authorized factory parts voids all warranty

More information

INSTRUCTIONS! DO NOT DISCARD!

INSTRUCTIONS! DO NOT DISCARD! INSTRUCTIONS! DO NOT DISCARD! CAUTION! Do NOT install where injury might occur due to Moving parts, Sharp corners, Hot surfaces or electrical components dn0521 Page 1 of 12 INSTALLATION INSTRUCTIONS CAUTION

More information

ICE/BEVERAGE DISPENSER MODELS: ENDURO-150 (SIX VALVE) INSTALLATION MANUAL

ICE/BEVERAGE DISPENSER MODELS: ENDURO-150 (SIX VALVE) INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODELS: ENDURO-150 (SIX VALVE) INSTALLATION MANUAL Release Date: February 24, 2004 Publication Number: 91971RINS Revision Date: August 3, 2010 Revision: E Visit the IMI Cornelius

More information

Power Pack Service Manual

Power Pack Service Manual Power Pack Service Manual MMPP4301-EP MMPP4301 MMPP4301-WC MMPP4301-PKG MMPP4301-PKG-WC MMPP4302 MMPP4302-WC MMPP4302-PKG MMPP4302-PKG-WC MMPP4303-PKG MMPP4303-PKG-WC MMPP4303-PKG-3 MMPP4305-PKG MMPP4305-PKG-WC

More information

INSTRUCTIONS! DO NOT DISCARD!

INSTRUCTIONS! DO NOT DISCARD! INSTRUCTIONS! DO NOT DISCARD! CAUTION! Do NOT install where injury might occur due to Moving parts, Sharp corners, Hot surfaces or electrical components dcn0620 Page 1 of 12 INSTALLATION INSTRUCTIONS CAUTION

More information

INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO VALVE

INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO VALVE INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO--175 8 VALVE Release Date: March 24, 2004 Publication Number: 620917902INS Revision Date: April 08, 2014 Revision: E Visit the Cornelius web site

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS FOR AQUECOIL HYDRONIC HEATING UNITS GENERAL INFORMATION The AQUECOIL Hydronic Heating Unit is offered in many different capacities and physical configurations in order to match

More information

CONTINUOUS FLOW ICEMAKER

CONTINUOUS FLOW ICEMAKER CONTINUOUS FLOW ICEMAKER 500-700 - 1000-2000 Series Installation and Service Manual Release Date: August 1, 2002 Publication Number: 638085278 Revision Date: March 19, 2014 Revision: F Visit the Cornelius

More information

SERVICE MANUAL. Bradford White ElectriFLEX HD (Heavy Duty) Commercial Electric Water Heater CEHD SERIES Immersion Thermostat Models

SERVICE MANUAL. Bradford White ElectriFLEX HD (Heavy Duty) Commercial Electric Water Heater CEHD SERIES Immersion Thermostat Models Bradford White ElectriFLEX HD (Heavy Duty) Commercial Electric Water Heater CEHD SERIES Immersion Thermostat Models SERVICE MANUAL Troubleshooting Guide and Instructions for Service (To be performed ONLY

More information

INSTALLATION, OPERATING & MAINTENANCE INSTRUCTIONS FOR 350 SERIES CIRCULATION HEATERS

INSTALLATION, OPERATING & MAINTENANCE INSTRUCTIONS FOR 350 SERIES CIRCULATION HEATERS INDEECO Circulation Heaters are designed to provide years of trouble free operation if properly installed and maintained. Please read and follow these instructions for installing and maintaining the heater.

More information

Power Pack Service Manual

Power Pack Service Manual Power Pack Service Manual MMPP4301-EP MMPP4301 MMPP4301-PKG MMPP4302 MMPP4302-PKG MMPP4305-PKG MMPP4301-WC MMPP4302-WC MMPP4305-PKG-WC www.micromatic.com 1 TABLE OF CONTENTS Equipment Specifications...

More information

WATLOW IND. WATROD Flange Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date:6/11/2008 Rev: 2.00

WATLOW IND. WATROD Flange Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date:6/11/2008 Rev: 2.00 I&M NUMBER: 316-42-8-1 Page: 1 _ Pre Installation Check to make sure that heater received is the same as that ordered. Elements may come in contact with each other during shipment. Minor adjustments to

More information

AACH50 1/2 HP GALLONS (200 TO 1200L) INSTRUCTION MANUAL

AACH50 1/2 HP GALLONS (200 TO 1200L) INSTRUCTION MANUAL Ideal for ponic System Reservoirs 1/2 HP 53-317 GALLONS (200 TO 1200L) AACH50 INSTRUCTION MANUAL Before operating this appliance, please read the instruction manual thoroughly and keep on file for future

More information

Installation, Operation and Maintenance Manual

Installation, Operation and Maintenance Manual Installation, Operation and Maintenance Manual Packaged Chiller Models CC 6601, 6501, 6401, 6301, 6201, 6101 For Service, please contact Pfannenberg Service Company: U.S.A. Pfannenberg Inc. 68 Ward Road.

More information

VANTAGE. Installation Manual. Release Date: April 16, 2003 Publication Number: INS Revision Date: January 22, 2015 Revision: E

VANTAGE. Installation Manual. Release Date: April 16, 2003 Publication Number: INS Revision Date: January 22, 2015 Revision: E VANTAGE Installation Manual Release Date: April 16, 2003 Publication Number: 3120031005INS Revision Date: January 22, 2015 Revision: E Visit the Cornelius web site at www.cornelius.com for all your Literature

More information

ICE/BEVERAGE DISPENSER

ICE/BEVERAGE DISPENSER Illustrated Parts List ICE/BEVERAGE DISPENSER Model: Enduro-2XX intellicarb Publication Number: 6209956IPL Revision Date: August 3, 200 Release Date: March 26, 204 Revision: B Visit the Cornelius web site

More information

INSTALLATION and OPERATION INSTRUCTIONS

INSTALLATION and OPERATION INSTRUCTIONS INSTALLATION and OPERATION INSTRUCTIONS Utility Coolers MODEL NOS. US4KP US10KP IMPORTANT INFORMATION This manual has been prepared to assist you in the installation of your Utility Cooler and to acquaint

More information

POWER PACK SERVICE MANUAL

POWER PACK SERVICE MANUAL POWER PACK SERVICE MANUAL MMPP4301-EP MMPP4301 MMPP4301-WC MMPP4301-PKG MMPP4301-PKG-WC MMPP4302 MMPP4302-WC MMPP4302-PKG MMPP4302-PKG-WC MMPP4303-PKG MMPP4303-PKG-WC MMPP4303-PKG-3 MMPP4305-PKG MMPP4305-PKG-WC

More information

ERGOMAX 7 INSTALLATION

ERGOMAX 7 INSTALLATION ERGOMAX 7 INSTALLATION INSTALLATION MUST CONFORM TO LOCAL CODES 1. WITH HYDRONIC BOILERS All ERGOMAX 7 units must be installed vertically. Adjustable feet for levelling are provided. PRESSURE RELIEF VALVE:

More information

INSTRUCTIONS! DO NOT DISCARD!

INSTRUCTIONS! DO NOT DISCARD! INSTRUCTIONS! DO NOT DISCARD! CAUTION! Do NOT install where injury might occur due to Moving parts, Sharp corners, Hot surfaces or electrical components d N0417 Page 1 of 10 INSTALLATION INSTRUCTIONS CAUTION

More information

FCB PINNACLE. Operator s Manual. 2 and 4 Flavor

FCB PINNACLE. Operator s Manual. 2 and 4 Flavor FCB PINNACLE 2 and 4 Flavor Operator s Manual FCB - 2 Flavor FCB - 4 Flavor Release Date: November 24, 2003 Publication Number: 560006533OPR Revision Date: September 28, 2004 Revision: C CONTACT INFORMATION

More information

Prime Chiller Modular Upgradable Chiller

Prime Chiller Modular Upgradable Chiller Prime Chiller Modular Upgradable Chiller Instructions for Models Single Stage Thermostat #2604, 2606 Dual Stage Thermostat #2614, 2616 Single Stage Thermostat w/ TXV #2626, 2627 Warning and Safety Instructions...

More information

WATLOW IND. WATROD Modular Duct Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date:6/11/2008 Rev: 2

WATLOW IND. WATROD Modular Duct Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date:6/11/2008 Rev: 2 I&M NUMBER: 316-42-15-1 Page: 1 _ Pre Installation Check to make sure that heater received is the same as that ordered. Elements may come in contact with each other during shipment. Minor adjustments to

More information

INSTALLATION INSTRUCTIONS TXV Horizontal Duct Coils EHD

INSTALLATION INSTRUCTIONS TXV Horizontal Duct Coils EHD TXV Horizontal Duct s EHD These instructions must be read and understood completely before attempting installation. It is important that the Blower and Duct System be properly sized to allow the system

More information

P/N CC-100. Coolant Circulator. Operation manual

P/N CC-100. Coolant Circulator. Operation manual P/N 4411-0019 CC-100 Coolant Circulator Operation manual Manual Version 1 Revision B July 1, 1998 Table of Contents Chapter 1 Introduction... 5 Description...5 Specifications...5 Chapter 2 Warnings...

More information

MACH N-407 Heat Pump Air-Cooled Chiller

MACH N-407 Heat Pump Air-Cooled Chiller MACH060-01-N-407 Heat Pump Air-Cooled Chiller Heat Pump Air-Cooled Chillers for Global Residential and Light Commercial Microclimates MACH NOMENCLATURE BREAKDOWN MACH-060-01 - N - 407 Refrigerant Type

More information

TABLE 1 Electrical Specifications

TABLE 1 Electrical Specifications CHRONOMITE HIGH CAPACITY INSTANT-TEMP WATER HEATERS INSTALLATION AND OPERATION INSTRUCTIONS (208-240V Models) (Before installation, compare electrical requirements needed for the model of heater selected)

More information

WATLOW IND. FIREBAR Flange Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date: 6/11/2008 Rev: 2.00

WATLOW IND. FIREBAR Flange Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date: 6/11/2008 Rev: 2.00 I&M NUMBER: 316-42-2-1 Page: 1 Pre Installation Check to make sure that heater received is the same as that ordered. Elements may come in contact with each other during shipment. Minor adjustments to elements

More information

Power Pack Service Manual

Power Pack Service Manual Power Pack Service Manual MMPP4301-EP MMPP4301 MMPP4301-WC MMPP4301-PKG MMPP4301-PKG-WC MMPP4302 MMPP4302-WC MMPP4302-PKG MMPP4302-PKG-WC MMPP4303-PKG MMPP4303-PKG-WC MMPP4303-PKG-3 MMPP4305-PKG MMPP4305-PKG-WC

More information

Installation, Operation, and Maintenance Information

Installation, Operation, and Maintenance Information Installation, Operation, and Maintenance Information Low Velocity Unit Coolers Bulletin No. IOM 110.3 Table of Contents Inspection... 2 Installation... 2 4 General... 2 Location... 2 Drain Line... 3 Refrigerant

More information

POWER PACK SERVICE MANUAL

POWER PACK SERVICE MANUAL POWER PACK SERVICE MANUAL MMPP4301-EP MMPP4301 MMPP4301-WC MMPP4301-PKG MMPP4301-PKG-WC MMPP4302 MMPP4302-WC MMPP4302-PKG MMPP4302-PKG-WC MMPP4303-PKG MMPP4303-PKG-WC MMPP4303-PKG-3 MMPP4305-PKG MMPP4305-PKG-WC

More information

Prime chiller. Inline Chiller. Instructions for Models #2645,2646

Prime chiller. Inline Chiller. Instructions for Models #2645,2646 Prime chiller Inline Chiller Instructions for Models #2645,2646 Warning and Safety Instructions... Page 2 Chiller Installation... Page 3 Temperature Controller Programming... Page 5 Warranty... Page 7

More information

Surna 25-Ton Chiller Operating & Maintenance Manual

Surna 25-Ton Chiller Operating & Maintenance Manual www.surna.com 303.993.5271 Surna 25-Ton Chiller Operating & Maintenance Manual Models: 300F3-3. 300F4-3, 300FW-3 Revised: July 2015 Table of Contents Warranty Information 4 Limited Warranty 4 Limitation

More information

TABLE 1 Electrical Specifications. Phase

TABLE 1 Electrical Specifications. Phase CHRONOMITE HIGH CAPACITY INSTANT-TEMP WATER HEATERS INSTALLATION AND OPERATION INSTRUCTIONS (208-240V 3 Φ Models) (Before installation, compare electrical requirements needed for the model of heater selected)

More information

DRY AIR SYSTEMS, INC Metro Boulevard Maryland Heights, Missouri (314) fax (314)

DRY AIR SYSTEMS, INC Metro Boulevard Maryland Heights, Missouri (314) fax (314) DRY AIR SYSTEMS, INC. 2655 Metro Boulevard Maryland Heights, Missouri 63043 (314) 344-1114 fax (314) 344-0677 HD SERIES DRIERS TABLE OF CONTENTS WHY AN AIR DRYER 3 WHAT IS A DESICCANT AIR DRYER 3 Desiccant

More information

WATLOW ELECTRIC MFG CO. WATROD Duct Heater (module only) I& M Manual I&M NUMBER: Page: 1 Date: 11/25/2013 Rev: 4.00

WATLOW ELECTRIC MFG CO. WATROD Duct Heater (module only) I& M Manual I&M NUMBER: Page: 1 Date: 11/25/2013 Rev: 4.00 I&M NUMBER: 316-42-16-1 Page: 1 Pre Installation Check to make sure that heater received is the same as that ordered. Elements may come in contact with each other during shipment. Minor adjustments to

More information

PDF Created with deskpdf PDF Writer - Trial ::

PDF Created with deskpdf PDF Writer - Trial :: Instruction Manual Index Introduction Uncrating and Checking for Damage Locating Your Unit Installation Fill Tank Process Connections Pre Startup Startup Sequence Trouble Shooting Chart Operating Lights

More information

! The Caution Symbol (exclamation point) alerts you to a "CAUTION", a safety or

! The Caution Symbol (exclamation point) alerts you to a CAUTION, a safety or I&M NUMBER: 316-42-10-1 Page: 1 Pre Installation Check to make sure that heater received is the same as that ordered. Elements may come in contact with each other during shipment. Minor adjustments to

More information

INSTALLATION INSTRUCTIONS WARRANTY

INSTALLATION INSTRUCTIONS WARRANTY QT FLOW CENTER INSTALLATION INSTRUCTIONS Fig. 1. Low Head Pump Center Flow Chart Fig. 2. High Head Pump Center Flow Chart NOTE: Read the entire instruction manual before starting the installation. WARRANTY

More information

Fan Motor. user manual INSTALLATION - OPERATION - MAINTENANCE

Fan Motor. user manual INSTALLATION - OPERATION - MAINTENANCE user manual Fan Motor INSTALLATION - OPERATION - MAINTENANCE Z0239042_B ISSUED 8/2017 READ AND UNDERSTAND THIS MANUAL PRIOR TO OPERATING OR SERVICING THIS PRODUCT installation Receiving Storing A motor

More information

EBAC MODEL AD850 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL

EBAC MODEL AD850 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL EBAC MODEL AD850 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL Ebac Industrial Products 704 Middle Ground Boulevard Newport News VA 23606 Telephone (757) 873-6800 FAX (757) 873-3632 Website: www.ebacusa.com INTRODUCTION

More information

RTE-5/5B & RTE-9/9B Refrigerated Bath Circulators. NESLAB Manual P/N Installation, Operation and Service Manual

RTE-5/5B & RTE-9/9B Refrigerated Bath Circulators. NESLAB Manual P/N Installation, Operation and Service Manual RTE-5/5B & RTE-9/9B Refrigerated Bath Circulators NESLAB Manual P/N 013529 Installation, Operation and Service Manual RTE-5 & RTE-9 Bath and Circulator Instruction and Operation Manual Table of Contents

More information

Installation & Maintenance Instructions

Installation & Maintenance Instructions PRH Series Plenum Heaters Installation & Maintenance Instructions Dear Owner, Congratulations! Thank you for purchasing this new heater manufactured by Marley Engineered Products. You have made a wise

More information

A/C-HEATER SYSTEM - MANUAL

A/C-HEATER SYSTEM - MANUAL A/C-HEATER SYSTEM - MANUAL 1986 Isuzu Trooper II 1986 A/C-HEATER SYSTEM Isuzu A/C-Heater Systems - Manual P UP, Trooper II * PLEASE READ THIS FIRST * CAUTION: When discharging air conditioning system,

More information

OPERATING AND MAINTENANCE MANUAL FOR ELECTRIC STAINLESS STEEL HEATER FOR DEIONIZED (DI) WATER ELECTRIC HEATER COMPANY BASE MODEL D

OPERATING AND MAINTENANCE MANUAL FOR ELECTRIC STAINLESS STEEL HEATER FOR DEIONIZED (DI) WATER ELECTRIC HEATER COMPANY BASE MODEL D OPERATING AND MAINTENANCE MANUAL FOR ELECTRIC STAINLESS STEEL HEATER FOR DEIONIZED (DI) WATER ELECTRIC HEATER COMPANY BASE MODEL D HUBBELL ELECTRIC HEATER COMPANY P.O. BOX 288 STRATFORD, CT 06615 PHONE:

More information

ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 INSTALLATION/SERVICE MANUAL

ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 INSTALLATION/SERVICE MANUAL ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 INSTALLATION/SERVICE MANUAL Ice-O-Matic 111000 East 45th Ave Denver, Colorado 80239 Part Number 9081305-01 Rev. C Revision Date: September 19, 2011

More information

Installation GUIDE VDWU524SS VDWU524WSSS FDWU524WS FDWU524 VDWU324SS FDWU324

Installation GUIDE VDWU524SS VDWU524WSSS FDWU524WS FDWU524 VDWU324SS FDWU324 Installation GUIDE VDWU524SS VDWU524WSSS FDWU524WS FDWU524 VDWU324SS FDWU324 To prevent accidents, which could cause serious injury or death, as well as machine damage read these instructions before installation

More information

RSIF Power Venter USA CAN. Product Information. ... Chapters Mechanical Installation. ... Chapter 3. Electrical Installation. ...

RSIF Power Venter USA CAN. Product Information. ... Chapters Mechanical Installation. ... Chapter 3. Electrical Installation. ... Installation & Operating Manual RSIF Power Venter USA CAN Product Information... Chapters 1 + 2 Mechanical Installation... Chapter 3 Electrical Installation... Chapter 4 Start Up and Configuration... Chapter

More information

SERVICE/INSTALLATION MANUAL ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250

SERVICE/INSTALLATION MANUAL ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 SERVICE/INSTALLATION MANUAL ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 Ice-O-Matic 11100 East 45th Ave Denver, Colorado 80239 Part Number 9081305-01 Date 10/08 Introduction IOD150,IOD200,IOD250

More information

INSTALLATION, OPERATING & MAINTENANCE INSTRUCTIONS FOR 870 SERIES INDUSTRIAL CONTROL PANELS

INSTALLATION, OPERATING & MAINTENANCE INSTRUCTIONS FOR 870 SERIES INDUSTRIAL CONTROL PANELS INSTALLATION, OPERATING & MAINTENANCE INSTRUCTIONS FOR 870 SERIES INDUSTRIAL CONTROL PANELS GENERAL INDEECO Industrial Control Panels are designed to provide years of trouble free operation if properly

More information

FLUID COIL INSTALLATION OPERATION AND MAINTENANCE

FLUID COIL INSTALLATION OPERATION AND MAINTENANCE LUID COIL INSTALLATION OPERATION AND MAINTENANCE Commercial Products PO Box 1457 / 1000 Heatcraft Drive, Grenada, MS 38902-1457 Tel: 800-225-4328 / 662-229-4000 ax: 662-229-4212 Email: coils@heatcraft.com

More information

Component. Maintenance. Manual Z SERIES. Evaporator Assembly

Component. Maintenance. Manual Z SERIES. Evaporator Assembly Component Maintenance Manual with Illustrated Parts List for Z21-701-SERIES Evaporator Assembly 1 of 16 Record of Revision REVISION ISSUE POSTED NO: DATE DATE INSERTED BY: 2 of 16 List of Effective Pages

More information

Nordic Model CCU0150, 0220 Service Parts Manual (Includes 50Hz. Units)

Nordic Model CCU0150, 0220 Service Parts Manual (Includes 50Hz. Units) IMI CORNELIUS INC. www.cornelius.com Nordic Model CCU0150, 0220 Service Parts Manual (Includes 50Hz. Units) Distributed By: Commercial Refrigeration Service, Inc. WWW.866IceMakers.COM 866-IceMakers 623-869-8881

More information

Prime Chiller 1/10th HP Chiller

Prime Chiller 1/10th HP Chiller Prime Chiller 1/10th HP Chiller Instructions for Model# 2635 Warning and Safety Instructions... Page 2 Chiller Installation... Page 3 Programming Thermostat... Page 4 Warranty... Page 5 EMAIL:INFO@CURRENT-USA.COM

More information

Prime Tower. Inline Chiller. Instructions for Models #2645,2646

Prime Tower. Inline Chiller. Instructions for Models #2645,2646 Prime Tower Inline Chiller Instructions for Models #2645,2646 Warning and Safety Instructions... Page 2 Chiller Installation... Page 3 Temperature Controller Programming... Page 5 Warranty... Page 6 JEE

More information

INSTALLER'S GUIDE. ALL phases of this installation must comply with NATIONAL, STATE AND LOCAL CODES

INSTALLER'S GUIDE. ALL phases of this installation must comply with NATIONAL, STATE AND LOCAL CODES 11-AC11D2-5 INSTALLER'S GUIDE ALL phases of this installation must comply with NATIONAL, STATE AND LOCAL CODES Models: Condensing Units 2A7A5024-048, 2A7A4018-060, 2A7A2018-060 & 2A7A1018-060 IMPORTANT

More information

INSTRUCTIONS! DO NOT DISCARD!

INSTRUCTIONS! DO NOT DISCARD! INSTUCTIONS! DO NOT DISCAD! CAUTION! Do NOT install where injury might occur due to Moving parts, Sharp corners, Hot surfaces or electrical components dcn0812 Page 1 of 11 INSTALLATION INSTUCTIONS CAUTION

More information

AC6 & AC8 HORIZONTAL SERIES Sealed Metallic Centrifugal Pumps Installation and Maintenance Instructions

AC6 & AC8 HORIZONTAL SERIES Sealed Metallic Centrifugal Pumps Installation and Maintenance Instructions AC6 & AC8 HORIZONTAL SERIES Sealed Metallic Centrifugal Pumps Installation and Maintenance Instructions ASSEMBLY PUMPS WITH MOTORS 1. No assembly required. Unpack the pump and motor and examine for any

More information

Daikin Water Cooling, Heating, and High Capacity Booster Coils

Daikin Water Cooling, Heating, and High Capacity Booster Coils Installation and Maintenance Manual IM 900 Daikin Water Cooling, Heating, and High Capacity Booster Coils Group: Applied Air Part Number: IM 900 Date: February 2008 Types HI-F5, E-F5 2008 Daikin International

More information

SECTION PLUMBING EQUIPMENT

SECTION PLUMBING EQUIPMENT PART 1 GENERAL 1.1 SECTION INCLUDES A. Water heaters B. Packaged water heating systems C. Water storage tanks D. Water softeners E. Pumps F. Circulators 1.2 REFERENCES SECTION 22 30 00 PLUMBING EQUIPMENT

More information

Room Air Conditioner Service and Parts Manual

Room Air Conditioner Service and Parts Manual Cool Dry Temp Mode Room Air Conditioner Service and Parts Manual F Fan Speed hr Timer 0n 0ff Money Saver Fan Only Auto Swing Power CP06 CP08 93011401_01 CONTENTS 1. PREFACE 1.1 SAFETY PRECAUTIONS...2 1.2

More information

GLYCOL CHILLER INSTRUCTIONS IMPORTANT: BEFORE OPERATING PLEASE SEE INSTRUCTIONS ON PAGE 5

GLYCOL CHILLER INSTRUCTIONS IMPORTANT: BEFORE OPERATING PLEASE SEE INSTRUCTIONS ON PAGE 5 GLYCOL CHILLER INSTRUCTIONS IMPORTANT: BEFORE OPERATING PLEASE SEE INSTRUCTIONS ON PAGE 5 CONTENTS Key features...p.1 Product contents...p.1 Safety information...p.2 Maintenance...p.2 How it works...p.5

More information

Table of Contents SPECIFICATIONS Page 2. FOR THE INSTALLER Page 3. FOR THE PLUMBER Page 4. INSTALLATION Page 5. INITIAL START UP Page 6

Table of Contents SPECIFICATIONS Page 2. FOR THE INSTALLER Page 3. FOR THE PLUMBER Page 4. INSTALLATION Page 5. INITIAL START UP Page 6 INTRODUCTION This service manual covers the installation, operation, maintenance and service of this ice machine. Table of Contents SPECIFICATIONS Page 2 FOR THE INSTALLER Page 3 FOR THE PLUMBER Page 4

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Crescent Cuber Models KM-900MAH50 KM-900MRH50 A Superior Degree of Reliability INSTRUCTION MANUAL www.hoshizaki.com Issued: 6-25-2008 IMPORTANT Only qualified service technicians

More information

THERMAPHASE INSTALLATION AND OPERATING INSTRUCTIONS

THERMAPHASE INSTALLATION AND OPERATING INSTRUCTIONS Page 1 of 10 THERMAPHASE INSTALLATION AND OPERATING INSTRUCTIONS Purpose of Manual The purpose of this manual is to provide operating, servicing and repair instructions for the Summit standard models ThermaPhase

More information

Installation Instructions. For the 18 Built-In Dishwasher and Front Color Panels

Installation Instructions. For the 18 Built-In Dishwasher and Front Color Panels Installation Instructions For the 18 Built-In Dishwasher and Front Color Panels Printed in USA 154232102 Before You Begin DO NOT INSTALL DISHWASHER UNTIL YOU HAVE READ ALL INSTRUCTIONS. FOR YOUR SAFETY,

More information

2.4 Cu. Ft. Compact Refrigerator

2.4 Cu. Ft. Compact Refrigerator 2.4 Cu. Ft. Compact Refrigerator User s Manual PLEASE READ THIS MANUAL CAREFULLY BEFORE USING YOUR REFRIGERATOR AND KEEP IT FOR FUTURE REFERENCE. Model MCBR240B Product Registration Thank you for purchasing

More information

SECTION STEAM CONDENSATE PUMPS

SECTION STEAM CONDENSATE PUMPS PART 1 - GENERAL 1.1 DESCRIPTION SECTION 23 22 23 STEAM CONDENSATE PUMPS SPEC WRITER NOTES: 1. Delete between // ---- // if not applicable to project. Also delete any other item or paragraph not applicable

More information

WATLOW ELECTRIC MFG CO. FIREBAR Screw Plug Installation & Maintenance Manual I&M NUMBER: Page: 1 Date: 11/25/2013 Rev: 4.

WATLOW ELECTRIC MFG CO. FIREBAR Screw Plug Installation & Maintenance Manual I&M NUMBER: Page: 1 Date: 11/25/2013 Rev: 4. I&M NUMBER: 316-42-3-1 Page: 1 Pre Installation Check to make sure that heater received is the same as that ordered. Elements may come in contact with each other during shipment. Minor adjustments to elements

More information

HOSHIZAKI ICE DISPENSING BIN/ WATER DISPENSER MODEL DM-90A SERVICE MANUAL

HOSHIZAKI ICE DISPENSING BIN/ WATER DISPENSER MODEL DM-90A SERVICE MANUAL NO.: ISSUED: REVISED: 73091 DEC. 21, 1999 DEC. 17, 2003 HOSHIZAKI ICE DISPENSING BIN/ WATER DISPENSER MODEL DM-90A SERVICE MANUAL IMPORTANT Only qualified service technicians should attempt to service

More information

DUAL VOLTAGE ICE BOX CONVERSION SYSTEM 120 VOLTS A.C. & 12/24 VOLTS D.C. MODELS: SCQT-4408F-U1-L SCQT-4408F-U1-I OWNER'S GUIDE

DUAL VOLTAGE ICE BOX CONVERSION SYSTEM 120 VOLTS A.C. & 12/24 VOLTS D.C. MODELS: SCQT-4408F-U1-L SCQT-4408F-U1-I OWNER'S GUIDE DUAL VOLTAGE ICE BOX CONVERSION SYSTEM 120 VOLTS A.C. & 12/24 VOLTS D.C. MODELS: SCQT-4408F-U1-L SCQT-4408F-U1-I OWNER'S GUIDE SAWAFUJI ELECTRIC CO., LTD. GENERAL: This appliance is designed to convert

More information

Design and Construction Standards SECTION PLUMBING EQUIPMENT

Design and Construction Standards SECTION PLUMBING EQUIPMENT SECTION 15450 PLUMBING EQUIPMENT PART 1 GENERAL 1.1 SECTION INCLUDES: A. Water heaters. B. Packaged water heating systems. C. Water storage tanks. D. Water softeners. E. Pumps. F. Circulators. 1.2 REFERENCES

More information