CFF-500 CHILLER. Operator s & Installation Manual. Release Date: November 3, 1996 Publication Number: Revision Date: March 25, 2014 Revision: F

Size: px
Start display at page:

Download "CFF-500 CHILLER. Operator s & Installation Manual. Release Date: November 3, 1996 Publication Number: Revision Date: March 25, 2014 Revision: F"

Transcription

1 CFF-500 CHILLER Operator s & Installation Manual Release Date: November 3, 1996 Publication Number: Revision Date: March 25, 2014 Revision: F Visit the Cornelius web site at for all your Literature needs.

2 The products, technical information, and instructions contained in this manual are subject to change without notice. These instructions are not intended to cover all details or variations of the equipment, nor to provide for every possible contingency in the installation, operation or maintenance of this equipment. This manual assumes that the person(s) working on the equipment have been trained and are skilled in working with electrical, plumbing, pneumatic, and mechanical equipment. It is assumed that appropriate safety precautions are taken and that all local safety and construction requirements are being met, in addition to the information contained in this manual. This Product is warranted only as provided in Cornelius Commercial Warrant applicable to this Product and is subject to all of the restrictions and limitations contained in the Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal service conditions with respect to the Product, (2) improper voltage, (3) inadequate wiring, (4) abuse, (5) accident, (6) alteration, (7) misuse, (8) neglect, (9) unauthorized repair or the failure to utilize suitably qualified and trained persons to perform service and/or repair of the Product, (10) improper cleaning, (11) failure to follow installation, operating, cleaning or maintenance instructions, (12) use of non-authorized parts (i.e., parts that are not 100% compatible with the Product) which use voids the entire warranty, (13) Product parts in contact with water or the product dispensed which are adversely impacted by changes in liquid scale or chemical composition. Contact Information: To inquire about current revisions of this and other documentation or for assistance with any Cornelius product contact: Trademarks and Copyrights: This document contains proprietary information and it may not be reproduced in any way without permission from Cornelius. This document contains the original instructions for the unit described. CORNELIUS INC 101 Regency Drive Glendale Heights, IL Tel: Printed in U.S.A.

3 TABLE OF CONTENTS Safety Instructions Read and Follow ALL Safety Instructions Safety Overview Recognition Different Types of Alerts Safety Tips Qualified Service Personnel Safety Precautions Shipping And Storage Description Installation Front Panel Removal Locations Water Connections Electrical Connections Start-Up Operation Maintenance Pump Heater Cooling System Thermostat CFF Performance Data All Data is Based on Water Heating Capacity (3412 BTUH-858 K-CAL/HR) Fluid Recommendations Troubleshooting

4

5 SAFETY INSTRUCTIONS READ AND FOLLOW ALL SAFETY INSTRUCTIONS Safety Overview Read and follow ALL SAFETY INSTRUCTIONS in this manual and any warning/caution labels on the unit (decals, labels or laminated cards). Read and understand ALL applicable OSHA (Occupational Safety and Health Administration) safety regulations before operating this unit. Recognition DIFFERENT TYPES OF ALERTS Recognize Safety Alerts! DANGER: Indicates an immediate hazardous situation which if not avoided WILL result in serious injury, death or equipment damage.! This is the safety alert symbol. When you see it in this manual or on the unit, be alert to the potential of personal injury or damage to the unit.! WARNING: Indicates a potentially hazardous situation which, if not avoided, COULD result in serious injury, death, or equipment damage.! CAUTION: Indicates a potentially hazardous situation which, if not avoided, MAY result in minor or moderate injury or equipment damage. SAFETY TIPS Carefully read and follow all safety messages in this manual and safety signs on the unit. Keep safety signs in good condition and replace missing or damaged items. Learn how to operate the unit and how to use the controls properly. Do not let anyone operate the unit without proper training. This appliance is not intended for use by very young children or infirm persons without supervision. Young children should be supervised to ensure that they do not play with the appliance. Keep your unit in proper working condition and do not allow unauthorized modifications to the unit. QUALIFIED SERVICE PERSONNEL! WARNING: Only trained and certified electrical, plumbing and refrigeration technicians should service this unit. ALL WIRING AND PLUMBING MUST CONFORM TO NATIONAL AND LOCAL CODES. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE , Cornelius Inc Publication Number: 90667

6 SAFETY PRECAUTIONS This unit has been specifically designed to provide protection against personal injury. To ensure continued protection observe the following:! WARNING: Disconnect power to the unit before servicing following all lock out/tag out procedures established by the user. Verify all of the power is off to the unit before any work is performed. Failure to disconnect the power could result in serious injury, death or equipment damage.! CAUTION: Always be sure to keep area around the unit clean and free of clutter. Failure to keep this area clean may result in injury or equipment damage. SHIPPING AND STORAGE! CAUTION: Before shipping, storing, or relocating the unit, the unit must be sanitized and all sanitizing solution must be drained from the system. A freezing ambient environment will cause residual sanitizing solution or water remaining inside the unit to freeze resulting in damage to internal components. Publication Number: , Cornelius Inc.

7 DESCRIPTION The Cornelius Model CFF-500 Water Circulator is a self-contained unit consisting of a pump, heater, cooling system, and 2-stage thermostat housed in a rugged cabinet with a baked-on finish. It operates with any water system up to a maximum of 30 gallons (113 liters). The CFF-500 is not designed for continuous cooling at water temperatures above 85 F (29 C); although short term operation at higher temperatures with no external heat load is acceptable for pulling down the system temperature. Physical CFF-500 Shipping Weight 135 Lbs. Internal Liquid Volume 1.5 Gal. Inlet/Outlet Connectors 5/8 in. ID. Hose Construction Materials (In contact with liquid) Pump Polypropylene, 316 SS Buna-N Tank 316 SS Tubing PVC Electrical Operating Voltage 115/1/60 Full Load Current 14A Inrush Current 48A Technical Temperature Range F Temperature Differential (max.) 3/4 F (0.4 C) Compressor 1/2 HP Heater 1 kw Refrigerant (134a) 2 Lbs , Cornelius Inc Publication Number: 90667

8 FRONT PANEL REMOVAL INSTALLATION In order to make connections to the chiller, it is necessary to remove the front panel by removing the fasteners on the front of the unit and then sliding the panel forward. When replacing the panel, slide it straight back until it is engaged under the rear retaining flange, and replace the front fasteners. LOCATIONS The chiller must be located so that the pump inlet is below the normal operating level of the bath to which it is connected. Failure to do so causes improper operation and damage to the pump. The following clearances must be maintained around the unit for proper operation: Top Right Side Left Side Open 24 in. 12 in. WATER CONNECTIONS 4 shows the proper and improper methods of making water connections. Water tubing should be 5/8 I. D., and hose clamps should be used to insure a leak-free connection. The inlet hose should run through the hole in the rear panel and connect to the pump suction connection. This line must run from a drain at the lowest point in the bath, and should not contain any inverted traps which could cause air binding to loss of prime. In open systems where foreign material may be present the bath drain should be raised slightly and fitted with a screen to prevent the entrance of such material into the inlet hose. The outlet hose connects to the top of the chiller tank and may enter the bath at any convenient point. Care should be taken to prevent short circuiting of water between inlet and outlet connections which are too close together in the bath. This may cause wide temperature variations. If an air trap must be present in the outlet line, then it should be provided with a vent valve to allow the complete removal of air. In closed systems (where the system is not open to the atmosphere) 5, the installation should include a surge pot located at the highest point in the outlet line, to facilitate proper purging of air and to allow for expansion and contraction of the water in the system with changes in temperature. This pot should normally have approximately 1/ 10th the total volume of the system, and small air space must remain at the top for proper operation. Figure 1. Water Connections Publication Number: , Cornelius Inc.

9 ELECTRICAL CONNECTIONS! CAUTION: All wiring must conform to NEC and local Codes. The unit must be permanently wired by means of conduit. The conduit should be run through the hole provided in the rear of the cabinet & be connected by means of a fitting to the 1/2 knockout in the electric box. The field supply wires must be spliced to the pigtails provided in the electric box. Keep all wiring way from the relay, to avoid interfering with its proper operation. Do not operate the unit until the start-up procedure has been followed. START-UP When the installation steps have been completed, the system is ready to fill (see Page 10). With the power switch Off, begin adding water to the system until the inlet hose and pump housing are completely full. This occurs automatically if the unit has been properly installed. If this priming action does not occur, go back and review the installation to be sure that there are no restrictions or air traps in the inlet hose. Once the inlet hose is full, the pump may be started by turning the power switch on. As water is pumped through the system, air is expelled from the outlet hose. (In closed systems, the vents valve must be opened to allow air to escape from the system). Figure 2. Typical Closed System Once the pump has been started, it is important to add liquid at a sufficient rate so the inlet hose remains full. Continue adding liquid until all of the air has been expelled and the liquid is at its normal operating level. After filling, check all connections for tightness. In many cases, a leaking connection on the inlet side of the pump allows air to enter the system. This can be observed as a stream of bubbles in the hose accompanied by a growling noise in the pump. If not eliminated, this air can interfere with proper system operation and can shorten the pump life. Once the system has been properly filled and purged of air, it maintains its prime automatically. The Start-Up procedure only needs to be repeated if the system has been drained. OPERATION The unit should be turned on and off by means of the power switch. The pilot light indicates the presence of power when the switch is on. Setting the thermostat dial to the desired temperature causes either the heater or cooling system to operate, depending on the water temperature. In applications requiring extreme accuracy, a thermometer should be used in the liquid bath to determine the temperature. In operation, the circulating pump runs continuously, drawing water from the system and pumping it through the tank and back out to the system. The 2-stage thermostat senses the water temperature in the tank and cycles the heater or cooling system in response to temperature changes below or above the set point respectively. Heating is accomplished by means of an immersion heater located at one end of the tank. The cooling system is completely sealed and consists of a compressor, condenser, receiver, thermal expansion valve and a heat exchanger which is an integral part of the tank. It utilizes refrigerant 134a to remove heat from the liquid in the tank , Cornelius Inc Publication Number: 90667

10 MAINTENANCE The CFF-500 requires very little normal maintenance. The condenser fins should be cleaned occasionally with a brush or compressed air to keep them from becoming blocked by dirt. If the unit is to be shut off for a prolonged period, it should be flushed with clean water and then drained completely. IMPORTANT: Every 6 months, the pump should be oiled with SAE20 non-detergent oil at the two motor oil ports. Except for the refrigeration system, the CFF-500 is easily serviced in the field, if required. The following section serves as a guide to making general repairs. PUMP The pump consists of only one moving part, the impeller, which is magnetically driven by an open type, thermally protected motor. This magnetic drive construction eliminates shaft seals and their associated leakage and wear problems. The most common source of pump failure is dry operation, which causes the impeller to bind. HEATER The immersion heater is installed in a threaded connection in the tank. Electrical connections are made through slipon terminals. When installing a new heater, PTFE tape should be used on the threads to insure a leak proof seal. COOLING SYSTEM The cooling system is hermetically sealed, and repairs to the refrigeration components should only be made by the factory. Field replaceable parts include the compressor electrical equipment and the condenser fan. The compressor electrical equipment consists of a thermal protector, starting relay and a starting capacitor. These components are located in the compressor terminal box. Care should be taken to ensure that the wires are reconnected properly when replacing these components. THERMOSTAT The thermostat consists of a temperature actuated bellows assembly which operates two micro-switches. These switches operate at slightly different temperatures to control the heating or cooling of the water in the tank. The internal thermostat parts are not field replaceable or adjustable. In case of any failure, the thermostat should be replaced. When replacing the thermostat, note the routing of the capillary, and be sure to avoid any kinks or sharp bends. The bulb is located in a well in the tank and can be removed or replaced simply by sliding it in and out. When reinstalling a new thermostat, the bulb should be coated with a heat conducting compound such as silicone grease or thermal mastic, which is available at most refrigeration supply houses. Publication Number: , Cornelius Inc.

11 Figure 3. Wiring Diagram , Cornelius Inc Publication Number: 90667

12 Figure 4. Circulator Dimensions Publication Number: , Cornelius Inc.

13 CFF PERFORMANCE DATA ALL DATA IS BASED ON WATER HEATING CAPACITY (3412 BTUH-858 K-CAL/HR) Figure 5. Performance Data , Cornelius Inc Publication Number: 90667

14 CH1001-A Chiller Operator s & Installation Manual FLUID RECOMMENDATIONS Cornelius chillers are designed to operate with water to provide maximum performance for temperatures of 40 F (4.4 C) to 100 F (37.8 C). Distilled Water De-Ionized Water (1-5 Meg ohms) De-Ionized Water (5+ Meg ohms) Propylene Glycol (Lab & Industrial Grade) Lab & Industrial Grade Ethylene Glycol Mineral/Hydraulic Oils (Commercial/Automotive Antifreeze) Acidic/Basic Solutions (Above 8 or below 6 PH) Mineral/Hydraulic Oils (Viscosity > 50 Centistrokes) Acceptable Acceptable Acceptable with Stainless Steel & PVC only (No Copper or Brass) Acceptable - 30% Glycol/70% Water (For Applications with Temperatures below 40 F) Acceptable - 30% Glycol/70% Water (For Applications with Temperatures below 40 F) NOT Acceptable (Silicate Rust Inhibitors in Automotive/Commercial antifreeze damages pump seals and housing which lead to failure.) Not Acceptable Not Acceptable For questions regarding special or other fluids contact Cornelius at To purchase Lab or Industrial Glycol contact: Cornelius, Part No , 5 Gal. Publication Number: M OPR , Cornelius Inc.

15 TROUBLESHOOTING! WARNING: Disconnect electrical power to the chiller to prevent personal injury before attempting any internal maintenance. Only qualified personnel should service the internal components or electrical wiring. If repairs to the chiller must be made, disconnect electical power to the unit, then shut off the water source. Trouble Problem Cause Remedy Unit does not operate, Power Light OFF. Unit does not pump water. Unit does not heat. Unit runs continuously, but is not cooling. Compressor doesn t run, body cool. Compressor doesn t run, body hot. System Temperature Erratic A. Power switch off. A. Check main disconnect fuses, wiring and power lead to unit. A. Pump motor burned out or pump impeller frozen. B. Restriction or air trap in inlet line. C. Restriction in outlet line. A. Heater burned out. B. Bad Heat switch on thermostat. A. Condenser is restricted. B. Unit low on refrigerant. C. Bad expansion valve. D. Fan motor burned out. A. Bad cool switch on thermostat. B. Bad thermal protector. C. Bad control relay in electric box. D. Compressor burned out. A. Bad starting relay. B. Bad start capacitor C. Compressor burned out. A. Air in system. B. Bad thermostat. A. Replace pump. B. Clean inlet line. C. Remove restriction for outlet line. A. Replace heater. B. Replace heat switch on thermostat. A. Clean condenser. B. Call service C. Call service. D. Replace fan motor. A. Replace cool switch on thermostat. B. Replace thermal protector. C. Replace control relay in electric box. D. Replace compressor. A. Replace starting relay. B. Replace start capacitor. C. Replace compressor. A. Purge air from system. B. Replace thermostat , Cornelius Inc Publication Number: 90667

16 Publication Number: , Cornelius Inc.

17

18 Cornelius Inc.

CHILLER. Operator s & Installation Manual

CHILLER. Operator s & Installation Manual CHILLER MODEL: CFF-500 Operator s & Installation Manual Release Date: November 3, 1996 Publication Number: 90667 Revision Date: May 10, 2010 Revision: E Visit the IMI Cornelius web site at www.cornelius.com

More information

CH750, CH751 & CH951 CHILLERS

CH750, CH751 & CH951 CHILLERS CH750, CH751 & CH951 CHILLERS Operator s & Installation Manual Release Date: April 19, 2002 Publication Number: 91256 Revision Date: March 25, 2014 Revision: F Visit the Cornelius web site at www.cornelius.com

More information

CH250 AND CH251 CHILLERS

CH250 AND CH251 CHILLERS CH250 AND CH251 CHILLERS Operator s & Installation Manual Release Date: April 19, 2004 Publication Number: 620914801 Revision Date: May 15, 2015 Revision: G Visit the Cornelius web site at www.cornelius.com

More information

CHILLER. Model CH3000. Operator s & Installation Manual

CHILLER. Model CH3000. Operator s & Installation Manual CHILLER Model CH3000 Operator s & Installation Manual Release Date: February 14, 2011 Publication Number: 620054173OPR Revision Date: May 08, 2014 Revision: B Visit the Cornelius web site at www.cornelius.com

More information

CHILLERS. Operator s & Installation Manual

CHILLERS. Operator s & Installation Manual CHILLERS MODELS: CH750, CH751 & CH951 Operator s & Installation Manual Release Date: April 19, 2002 Publication Number: 91256 Revision Date: May 5, 2010 Revision: D Visit the IMI Cornelius web site at

More information

CHILLER MODEL: CH1500, 2000 AND 3000

CHILLER MODEL: CH1500, 2000 AND 3000 CHILLER MODEL: CH1500, 2000 AND 3000 Operator s & Installation Manual Release Date: February 12, 2010 Publication Number: 621055837OPR Revision Date: March 25, 2014 Revision: E Visit the Cornelius web

More information

ABS HOPPER LID SWITCH KIT ASSEMBLY

ABS HOPPER LID SWITCH KIT ASSEMBLY ABS HOPPER LID SWITCH KIT ASSEMBLY Installation Instructions Release Date: 2010 Publication Number: 629097021INS Revision Date: October 15, 2012 Revision: C Visit the IMI Cornelius web site at www.cornelius.com

More information

ICE DISPENSER. D45 and D90 Installation Manual. Release Date: August, 1995 Publication Number: Revision Date: March 27, 2014 Revision: D

ICE DISPENSER. D45 and D90 Installation Manual. Release Date: August, 1995 Publication Number: Revision Date: March 27, 2014 Revision: D ICE DISPENSER D45 and D90 Installation Manual Release Date: August, 1995 Publication Number: 91561 Revision Date: March 27, 2014 Revision: D Visit the Cornelius web site at www.cornelius.com for all your

More information

VISUAL DISPLAY DISPENSER OWNERS MANUAL

VISUAL DISPLAY DISPENSER OWNERS MANUAL VISUAL DISPLAY DISPENSER OWNERS MANUAL MODEL: JT20, JT20-W25, JT20-W26 Publication Number: 621058565INS Revision Date: June 24, 2014 Revision: A Visit the Cornelius web site at www.cornelius.com for all

More information

CHILLER. Operator s & Installation Manual

CHILLER. Operator s & Installation Manual CHILLER MODELS: CH1001-A Operator s & Installation Manual Release Date: August 9, 2002 Publication Number: 620914301 Revision Date: May 6, 2010 Revision: E Visit the IMI Cornelius web site at www.cornelius.com

More information

INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO-200/250

INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO-200/250 INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO-200/250 Release Date: March 24, 2004 Publication Number: 92181INS Revision Date: April 07, 2014 Revision: G Visit the Cornelius web site at www.cornelius.com

More information

VANTAGE. Installation Manual. Release Date: April 16, 2003 Publication Number: INS Revision Date: January 22, 2015 Revision: E

VANTAGE. Installation Manual. Release Date: April 16, 2003 Publication Number: INS Revision Date: January 22, 2015 Revision: E VANTAGE Installation Manual Release Date: April 16, 2003 Publication Number: 3120031005INS Revision Date: January 22, 2015 Revision: E Visit the Cornelius web site at www.cornelius.com for all your Literature

More information

ICE COOLED DISPENSER ALTA 1522 DROP-IN DISPENSER

ICE COOLED DISPENSER ALTA 1522 DROP-IN DISPENSER ICE COOLED DISPENSER ALTA 1522 DROP-IN DISPENSER Operators Manual Release Date: June 10, 2013 Publication Number: 741200028OPR Revision Date: May 9, 2014 Revision: B Visit the Cornelius web site at www.cornelius.com

More information

INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO VALVE

INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO VALVE INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO--175 8 VALVE Release Date: March 24, 2004 Publication Number: 620917902INS Revision Date: April 08, 2014 Revision: E Visit the Cornelius web site

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS DF/EDXXX Lid Kits for Ice Makers Release Date: July 22, 2011 Publication Number: 620919549 Revision Date: February, 2014 Revision: H Visit the Cornelius web site at www.cornelius.com

More information

COMPRESSOR SERVICE REPLACEMENT KIT P/N (WCC 500A, 115/60, AIR COOLED)

COMPRESSOR SERVICE REPLACEMENT KIT P/N (WCC 500A, 115/60, AIR COOLED) COMPRESSOR SERVICE REPLACEMENT KIT P/N 629097166 (WCC 500A, 115/60, AIR COOLED) INSTALLATION INSTRUCTIONS Release Date: July 05, 2012 Publication Number: 620056387INS Revision Date: March 18, 2014 Revision:

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS FCB Pinnacle 4 Flavor Wide Body Units Thermostat Reset Upgrade Kit P/N 629088712 Release Date: January 23, 2006 Publication Number: 629088712INS Revision Date: March 24, 2014

More information

ED200/250 KSTYLE LID KITS

ED200/250 KSTYLE LID KITS ED200/250 KSTYLE LID KITS P/N 629097237, 629097239, 629097245 Installation Instructions Release Date: June 25, 2014 Publication Number: 629097240INS Revision: A Visit the Cornelius web site at www.cornelius.com

More information

ICE/BEVERAGE DISPENSER MODELS: ENDURO-150 (SIX VALVE) INSTALLATION MANUAL

ICE/BEVERAGE DISPENSER MODELS: ENDURO-150 (SIX VALVE) INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODELS: ENDURO-150 (SIX VALVE) INSTALLATION MANUAL Release Date: February 24, 2004 Publication Number: 91971RINS Revision Date: August 3, 2010 Revision: E Visit the IMI Cornelius

More information

IMI CORNELIUS CHILLER

IMI CORNELIUS CHILLER IMI CORNELIUS CHILLER Service Manual Release Date: November 9, 2005 Publication Number: 620920816SER Revision Date: NA Revision: A Visit the IMI Cornelius web site at www.cornelius.com for all your Literature

More information

ICE/BEVERAGE DISPENSER

ICE/BEVERAGE DISPENSER ICE/BEVERAGE DISPENSER MODEL: ENDURO-175 8 VALVE OPERATOR S MANUAL Release Date: March 1, 2004 Publication Number: 620917901OPR Revision Date: August 3, 2010 Revision: C Visit the IMI Cornelius web site

More information

Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951

Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951 IMI CORNELIUS REMCOR INC 500 REGENCY DRIVE GLENDALE HEIGHTS, IL 60139 2268 Telephone (800) 551 4423 Facsimile (800) 519 4423 Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951 Part

More information

STARBUCKS UC100 PROGATE

STARBUCKS UC100 PROGATE STARBUCKS UC100 PROGATE Operator s Manual Release Date: January 24, 2008 Publication Number: 621054211OPR Revision Date: April 07, 2014 Revision: B Visit the Cornelius web site at www.cornelius.com for

More information

OPERATOR S MANUAL ICE/BEVERAGE DISPENSER. Model: Enduro Valve

OPERATOR S MANUAL ICE/BEVERAGE DISPENSER. Model: Enduro Valve OPERATOR S MANUAL ICE/BEVERAGE DISPENSER Model: Enduro-175 8 Valve Release Date: March 1, 2004 Publication Number: 620917901OPR Revision Date: January 14, 2015 Revision: E Visit the Cornelius web site

More information

ICE/BEVERAGE DISPENSER

ICE/BEVERAGE DISPENSER Illustrated Parts List ICE/BEVERAGE DISPENSER Model: Enduro-2XX intellicarb Publication Number: 6209956IPL Revision Date: August 3, 200 Release Date: March 26, 204 Revision: B Visit the Cornelius web site

More information

CONTINUOUS FLOW ICEMAKER

CONTINUOUS FLOW ICEMAKER CONTINUOUS FLOW ICEMAKER 500-700 - 1000-2000 Series Installation and Service Manual Release Date: August 1, 2002 Publication Number: 638085278 Revision Date: March 19, 2014 Revision: F Visit the Cornelius

More information

WMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS

WMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS WMHP Series R410a Heat Pump INSTALLATION INSTRUCTIONS **WARNING TO INSTALLER, SERVICE PERSONNEL AND OWNER** Altering the product or replacing parts with non authorized factory parts voids all warranty

More information

ILLUSTRATED PARTS LIST ENDURO VALVE

ILLUSTRATED PARTS LIST ENDURO VALVE ILLUSTRATED PARTS LIST ENDURO 175 8 VALVE Publication Number: 620917901IPL Revision Date: October 10, 2011 Revision: G Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs.

More information

INSTALLATION INSTRUCTIONS TXV Horizontal Duct Coils EHD

INSTALLATION INSTRUCTIONS TXV Horizontal Duct Coils EHD TXV Horizontal Duct s EHD These instructions must be read and understood completely before attempting installation. It is important that the Blower and Duct System be properly sized to allow the system

More information

Owner / Operator Use and Care Guide I SERIES 224 ICE CUBE MACHINE

Owner / Operator Use and Care Guide I SERIES 224 ICE CUBE MACHINE Owner / Operator Use and Care Guide I SERIES 224 ICE CUBE MACHINE THE HOTTEST MACHINES ON ICE CORNELIUS INC www.cornelius.com IMPORTANT: TO THE INSTALLER. It is the responsibility of the Installer to ensure

More information

QUANTUM SERIES Installation and Service Manual

QUANTUM SERIES Installation and Service Manual QUANTUM SERIES Installation and Service Manual Release Date: November 23, 2004 Publication Number: 720901120 Revision Date: April 24, 2014 Revision: D Visit the Cornelius web site at www.cornelius.com

More information

INSTALLATION INSTRUCTIONS TXV Horizontal Slab Coils WLSH

INSTALLATION INSTRUCTIONS TXV Horizontal Slab Coils WLSH TXV Horizontal Slab Coils WLSH These instructions must be read and understood completely before attempting installation. It is important that the Blower and Duct System be properly sized to allow the system

More information

Surna 25-Ton Chiller Operating & Maintenance Manual

Surna 25-Ton Chiller Operating & Maintenance Manual www.surna.com 303.993.5271 Surna 25-Ton Chiller Operating & Maintenance Manual Models: 300F3-3. 300F4-3, 300FW-3 Revised: July 2015 Table of Contents Warranty Information 4 Limited Warranty 4 Limitation

More information

INSTALLATION MANUAL. Series 322 Ice Cube Machine SPECIFICATIONS UNPACKING. Series 322 Ice Cube Machine Installation Instructions

INSTALLATION MANUAL. Series 322 Ice Cube Machine SPECIFICATIONS UNPACKING. Series 322 Ice Cube Machine Installation Instructions INSTALLATION MANUAL Series 322 Ice Cube Machine SPECIFICATIONS 7.00 15.00 C A 6 ft electrical cord 1.00 2.00 22.00 5.00 Front 16.38 11.25 5.00 F E Air In D 2.75 2.25 14.75.75 B 23.50 21.00 Opening 23.50

More information

Installation Manual CARBONATOR With Plain-Water Booster

Installation Manual CARBONATOR With Plain-Water Booster CORNELIUS INC One Cornelius Place Anoka, MN 55303-6234 Telephone (800) 238-3600 Facsimile (763) 422-3246 Installation Manual CARBONATOR With Plain-Water Booster IMPORTANT: It is the responsibility of the

More information

SPA BLOWER OWNER'S MANUAL XXXX, XXXX, XXXX, XXXX, XXXX, XXXX fax

SPA BLOWER OWNER'S MANUAL XXXX, XXXX, XXXX, XXXX, XXXX, XXXX fax SPA BLOWER OWNER'S MANUAL 80015-XXXX, 80016-XXXX, 80017-XXXX, 80018-XXXX, 80019-XXXX, 80020-XXXX fax 888.610.3839 2015 323300-015 6/15 THIS PAGE INTENTIONALLY LEFT BLANK. 2 Operating Instructions and Parts

More information

Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951

Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951 IMI CORNELIUS REMCOR INC 500 REGENCY DRIVE GLENDALE HEIGHTS, IL 60139 2268 Telephone (800) 551 4423 Facsimile (866) 394 5140 Operator s Manual CHILLER ( CH SERIES) Models: CH750, CH751, and CH951 Part

More information

Installation, Operation and Maintenance Manual

Installation, Operation and Maintenance Manual Installation, Operation and Maintenance Manual Packaged Chiller Models CC 6601, 6501, 6401, 6301, 6201, 6101 For Service, please contact Pfannenberg Service Company: U.S.A. Pfannenberg Inc. 68 Ward Road.

More information

A910.8A Remote Water Chiller, 8 GPH A A / A A-220V TECHNICAL ASSISTANCE TOLL FREE TELEPHONE NUMBER:

A910.8A Remote Water Chiller, 8 GPH A A / A A-220V TECHNICAL ASSISTANCE TOLL FREE TELEPHONE NUMBER: Remote Water Chiller, 8 GPH A9100080-A / A9100080-A-220V TECHNICAL ASSISTANCE TOLL FREE TELEPHONE NUMBER: 1.800.591.9360 Technical Assistance Fax: 1.626.855.4894 NOTES TO INSTALLER: 1. Please leave this

More information

Operator s Manual CHILLER ( CHILLER SERIES) Models: CH550 and CH 551

Operator s Manual CHILLER ( CHILLER SERIES) Models: CH550 and CH 551 IMI CORNELIUS REMCOR INC g 500 REGENCY DRIVE g GLENDALE HEIGHTS, IL 60139--2268 Telephone (800) 551--4423 Facsimile (800) 519--4423 Operator s Manual CHILLER ( CHILLER SERIES) Models: CH550 and CH 551

More information

Daikin Water Cooling, Heating, and High Capacity Booster Coils

Daikin Water Cooling, Heating, and High Capacity Booster Coils Installation and Maintenance Manual IM 900 Daikin Water Cooling, Heating, and High Capacity Booster Coils Group: Applied Air Part Number: IM 900 Date: February 2008 Types HI-F5, E-F5 2008 Daikin International

More information

Series 1140 and 1141 Temperature Regulators

Series 1140 and 1141 Temperature Regulators Hoffman Specialty Installation & Maintenance Instructions HS-504(E) Series 1140 and 1141 Temperature Regulators! CAUTION FOLLOW ALL INSTALLATION AND OPERATING INSTRUCTIONS. TURN OFF WATER OR STEAM BEFORE

More information

JetSpray Visual Display Dispenser JT20C

JetSpray Visual Display Dispenser JT20C JetSpray Visual Display Dispenser JT20C Operator s Manual Release Date: June 27, 2008 Publication Number: 620920865 Revision Date: N/A Revision: Preliminary A2 CONTACT INFORMATION The products, technical

More information

INSTALLATION INSTRUCTIONS TXV Horizontal Duct Coils EHD

INSTALLATION INSTRUCTIONS TXV Horizontal Duct Coils EHD TXV Horizontal Duct s EHD These instructions must be read and understood completely before attempting installation. It is important that the Blower and Duct System be properly sized to allow the system

More information

Power Pack Service Manual

Power Pack Service Manual Power Pack Service Manual MMPP4301-EP MMPP4301 MMPP4301-WC MMPP4301-PKG MMPP4301-PKG-WC MMPP4302 MMPP4302-WC MMPP4302-PKG MMPP4302-PKG-WC MMPP4303-PKG MMPP4303-PKG-WC MMPP4303-PKG-3 MMPP4305-PKG MMPP4305-PKG-WC

More information

FLUID COIL INSTALLATION OPERATION AND MAINTENANCE

FLUID COIL INSTALLATION OPERATION AND MAINTENANCE LUID COIL INSTALLATION OPERATION AND MAINTENANCE Commercial Products PO Box 1457 / 1000 Heatcraft Drive, Grenada, MS 38902-1457 Tel: 800-225-4328 / 662-229-4000 ax: 662-229-4212 Email: coils@heatcraft.com

More information

Frosty Factory of America, Inc.

Frosty Factory of America, Inc. Frosty Factory of America, Inc. 2301 S. Farmerville St., Ruston, LA 71270 frostyfactory.com (318) 255-1162 (800) 544-4071 (318) 255-1170 fax Auto Fill System & Tank Service Manual All technical data, pictures

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS FOR AQUECOIL HYDRONIC HEATING UNITS GENERAL INFORMATION The AQUECOIL Hydronic Heating Unit is offered in many different capacities and physical configurations in order to match

More information

Prime Chiller Modular Upgradable Chiller

Prime Chiller Modular Upgradable Chiller Prime Chiller Modular Upgradable Chiller Instructions for Models Single Stage Thermostat #2604, 2606 Dual Stage Thermostat #2614, 2616 Single Stage Thermostat w/ TXV #2626, 2627 Warning and Safety Instructions...

More information

ERGOMAX 7 INSTALLATION

ERGOMAX 7 INSTALLATION ERGOMAX 7 INSTALLATION INSTALLATION MUST CONFORM TO LOCAL CODES 1. WITH HYDRONIC BOILERS All ERGOMAX 7 units must be installed vertically. Adjustable feet for levelling are provided. PRESSURE RELIEF VALVE:

More information

INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS

INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS AquaArctic Remote Water Chiller A9100080 -A TECHNICAL ASSISTANCE TOLL FREE TELEPHONE NUMBER: 1.800.591.9360 Technical Assistance Fax: 1.626.855.4894

More information

Power Pack Service Manual

Power Pack Service Manual Power Pack Service Manual MMPP4301-EP MMPP4301 MMPP4301-PKG MMPP4302 MMPP4302-PKG MMPP4305-PKG MMPP4301-WC MMPP4302-WC MMPP4305-PKG-WC www.micromatic.com 1 TABLE OF CONTENTS Equipment Specifications...

More information

Operator Manual Autofill System

Operator Manual Autofill System Operator Manual Autofill System Bubbler Ratio 4:1 Ratio 5:1 Single 2001-001 2001-000 Double 2001-003 2001-002 Remote Single 2001-005 Remote Double 2001-004 Granita* Ratio 4:1 Ratio 5:1 Single 2002-001

More information

LC Series - Light Commercial Pump Station Installation and Operation Manual

LC Series - Light Commercial Pump Station Installation and Operation Manual LC Series - Light Commercial Pump Station Installation and Operation Manual Please keep this manual with the pump station Content Rain Bird LC Series Overview... Safety Instruction... Operation... 3 Pump

More information

OK, OKA, OKAF; ELD; ELDM; ELH; OKC; SC; SCA; SCAF; OK-LN; OKA-LN; OKAF-LN.

OK, OKA, OKAF; ELD; ELDM; ELH; OKC; SC; SCA; SCAF; OK-LN; OKA-LN; OKAF-LN. INSTALLATION, OPERATION & SERVICE MANUAL FOR COOLER TYPES OK, OKA, OKAF; ELD; ELDM; ELH; OKC; SC; SCA; SCAF; OK-LN; OKA-LN; OKAF-LN. 1. Introduction This manual is a guide for the installation, maintenance

More information

INSTALLATION, OPERATING & MAINTENANCE INSTRUCTIONS FOR 350 SERIES CIRCULATION HEATERS

INSTALLATION, OPERATING & MAINTENANCE INSTRUCTIONS FOR 350 SERIES CIRCULATION HEATERS INDEECO Circulation Heaters are designed to provide years of trouble free operation if properly installed and maintained. Please read and follow these instructions for installing and maintaining the heater.

More information

P/N CC-100. Coolant Circulator. Operation manual

P/N CC-100. Coolant Circulator. Operation manual P/N 4411-0019 CC-100 Coolant Circulator Operation manual Manual Version 1 Revision B July 1, 1998 Table of Contents Chapter 1 Introduction... 5 Description...5 Specifications...5 Chapter 2 Warnings...

More information

POWER PACK SERVICE MANUAL

POWER PACK SERVICE MANUAL POWER PACK SERVICE MANUAL MMPP4301-EP MMPP4301 MMPP4301-WC MMPP4301-PKG MMPP4301-PKG-WC MMPP4302 MMPP4302-WC MMPP4302-PKG MMPP4302-PKG-WC MMPP4303-PKG MMPP4303-PKG-WC MMPP4303-PKG-3 MMPP4305-PKG MMPP4305-PKG-WC

More information

INSTALLATION INSTRUCTIONS TXV Coils for Manufactured Housing EMA

INSTALLATION INSTRUCTIONS TXV Coils for Manufactured Housing EMA TXV Coils for Manufactured Housing EMA NOTE: Read the entire instruction manual before starting the installation. SAFETY CONSIDERATIONS Improper installation, adjustment, alteration, service, maintenance,

More information

REMOTE COOLER AIR COOLED & WATER COOLED

REMOTE COOLER AIR COOLED & WATER COOLED REMOTE COOLER AIR COOLED & WATER COOLED Installation & User Instructions (To be left with the user) PLEASE READ CAREFULLY BEFORE INSTALLING THE UNIT Please follow these instructions carefully. Only if

More information

FCB PINNACLE. Operator s Manual. 2 and 4 Flavor

FCB PINNACLE. Operator s Manual. 2 and 4 Flavor FCB PINNACLE 2 and 4 Flavor Operator s Manual FCB - 2 Flavor FCB - 4 Flavor Release Date: November 24, 2003 Publication Number: 560006533OPR Revision Date: September 28, 2004 Revision: C CONTACT INFORMATION

More information

INSTRUCTIONS! DO NOT DISCARD!

INSTRUCTIONS! DO NOT DISCARD! INSTRUCTIONS! DO NOT DISCARD! CAUTION! Do NOT install where injury might occur due to Moving parts, Sharp corners, Hot surfaces or electrical components dn0521 Page 1 of 12 INSTALLATION INSTRUCTIONS CAUTION

More information

"S" SERIES IMMERSIBLE PUMP OWNER'S MANUAL INSTALLATION OPERATION PARTS Models S12 S16

S SERIES IMMERSIBLE PUMP OWNER'S MANUAL INSTALLATION OPERATION PARTS Models S12 S16 Webster Pumps "S" SERIES IMMERSIBLE PUMP OWNER'S MANUAL INSTALLATION OPERATION PARTS Models S12 S16 PLEASE READ THE FOLLOWING INFORMATION PRIOR TO INSTALLING AND USING Webster PUMPS or HAYWARD VALVES,

More information

17 U.S. gallon portable low profile drain with electric pump

17 U.S. gallon portable low profile drain with electric pump Assembly and operation instructions 17 U.S. gallon portable low profile drain with electric pump Model 3669 Date of issue February 2018 Form number 404513 Version 2 Contents Safety...........................

More information

OPERATION MANUAL Dated: 04/09/2018 Document Name: SHV _OM Page 1 of 8. Ion Technologies SHV40, 75 & 100 Sewage Ejector Pump SAFETY WARNINGS

OPERATION MANUAL Dated: 04/09/2018 Document Name: SHV _OM Page 1 of 8. Ion Technologies SHV40, 75 & 100 Sewage Ejector Pump SAFETY WARNINGS Ion Technologies SHV40, 75 & 100 Sewage Ejector Pump Page 1 of 8 biohazard risk exists. Installer(s) and/or service personnel must use proper Personal Protective Equipment and follow handling procedures

More information

Installation Instructions

Installation Instructions 53DS --- 900 --- --- --- 092 Duct---Free Systems Accessory Power Ventilation Kit for In --- Ceiling Cassette Fan Coil Units Size 018 --- 036 Installation Instructions NOTE: Read and become familiar with

More information

Installation & Operation Manual Models:

Installation & Operation Manual Models: SJS-I-O Rev C Installation & Operation Manual Models: 60-119 : If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss

More information

Power Pack Service Manual

Power Pack Service Manual Power Pack Service Manual MMPP4301-EP MMPP4301 MMPP4301-WC MMPP4301-PKG MMPP4301-PKG-WC MMPP4302 MMPP4302-WC MMPP4302-PKG MMPP4302-PKG-WC MMPP4303-PKG MMPP4303-PKG-WC MMPP4303-PKG-3 MMPP4305-PKG MMPP4305-PKG-WC

More information

INSTRUCTIONS! DO NOT DISCARD!

INSTRUCTIONS! DO NOT DISCARD! INSTRUCTIONS! DO NOT DISCARD! CAUTION! Do NOT install where injury might occur due to Moving parts, Sharp corners, Hot surfaces or electrical components dcn0620 Page 1 of 12 INSTALLATION INSTRUCTIONS CAUTION

More information

Water Boilers ME10EN, ME15EN. Table of Contents

Water Boilers ME10EN, ME15EN. Table of Contents Water Boilers ME10EN, ME15EN Operator Manual Model ME15EN Model ME10EN Safety Information...2 Rough-In Drawing...3 Installation...4 Priming...5 Cleaning...5 Table of Contents Adjustments...6 Maintenance...7

More information

POWER PACK SERVICE MANUAL

POWER PACK SERVICE MANUAL POWER PACK SERVICE MANUAL MMPP4301-EP MMPP4301 MMPP4301-WC MMPP4301-PKG MMPP4301-PKG-WC MMPP4302 MMPP4302-WC MMPP4302-PKG MMPP4302-PKG-WC MMPP4303-PKG MMPP4303-PKG-WC MMPP4303-PKG-3 MMPP4305-PKG MMPP4305-PKG-WC

More information

DLCLRA. INSTALLATION INSTRUCTIONS Outdoor Unit Single Zone Ductless System Sizes 36 to 58 TABLE OF CONTENTS

DLCLRA. INSTALLATION INSTRUCTIONS Outdoor Unit Single Zone Ductless System Sizes 36 to 58 TABLE OF CONTENTS DLCLRA INSTALLATION INSTRUCTIONS Outdoor Unit Single Zone Ductless System Sizes 36 to 58 Fig. 1 - Size 36 TABLE OF CONTENTS PAGE SAFETY CONSIDERATIONS... 2 PARTS LIST... 3 SYSTEM REQUIREMENTS... 4 WIRING...

More information

Installation Instructions

Installation Instructions 38MHR Outdoor Unit Single Zone Ductless System Sizes 09 to 24 Installation Instructions NOTE: Read the entire instruction manual before starting the installation. NOTE: Images are for illustration purposes

More information

INSTALLATION INSTRUCTIONS GEO PRIME TANK. (Patent Pending) GPC

INSTALLATION INSTRUCTIONS GEO PRIME TANK. (Patent Pending) GPC INSTALLATION INSTRUCTIONS GEO PRIME TANK (Patent Pending) GPC Table of Contents General Description 2 Installation 3 Flushing and Purging 5 Initial Start up 7 Adding or Checking Fluid 8 Replacing a Pump

More information

EXC-450 User s Manual

EXC-450 User s Manual Superior Liquid Cooling Systems www.koolance.com EXC-450 User s Manual English v1.0 ISO 9001 Printed in Korea A newer version of this User Manual may exist. Please be sure to check our support page for

More information

Truck Edition V-220 / V-320 Series Single Temperature Systems TK IM (Rev. 0, 06/17)

Truck Edition V-220 / V-320 Series Single Temperature Systems TK IM (Rev. 0, 06/17) Installation Manual Truck Edition V-220 / V-320 Series Single Temperature Systems TK 56321-18-IM (Rev. 0, 06/17) Installation Manual Truck Edition V-220 / V-320 Series Single Temperature Systems TK 56321-18-IM

More information

Lime Buster III. Model LB-300P IMS # (CIC1-LB300P) INSTRUCTION MANUAL

Lime Buster III. Model LB-300P IMS # (CIC1-LB300P) INSTRUCTION MANUAL Lime Buster III Model LB-300P IMS # 110226 (CIC1-LB300P) INSTRUCTION MANUAL October, 2007 IMS Company 10373 Stafford Road Chagrin Falls, OH 44023-5296 Telephone: (440) 543-1615 Fax: (440) 543-1069 Email:

More information

Installation & Operating Guide

Installation & Operating Guide 5-036 HOT WATER TANK Installation & Operating Guide Read all instructions thoroughly. Keep this guide for future reference. Proof of purchase is required for Warranty. Staple receipt or proof of purchase

More information

"S" SERIES IMMERSIBLE PUMP OWNER'S MANUAL INSTALLATION OPERATION PARTS Models S2 S4 S5 SS6 SS7 S8

S SERIES IMMERSIBLE PUMP OWNER'S MANUAL INSTALLATION OPERATION PARTS Models S2 S4 S5 SS6 SS7 S8 Webster Pumps "S" SERIES IMMERSIBLE PUMP OWNER'S MANUAL INSTALLATION OPERATION PARTS Models S2 S4 S5 SS6 SS7 S8 PLEASE READ THE FOLLOWING INFORMATION PRIOR TO INSTALLING AND USING Webster PUMPS or HAYWARD

More information

Henny Penny Blast Chiller/Freezer Models BCC/BCR-140 Models BCC/BCR-175 Models BFR/BCR-350

Henny Penny Blast Chiller/Freezer Models BCC/BCR-140 Models BCC/BCR-175 Models BFR/BCR-350 Henny Penny Blast Chiller/Freezer Models BCC/BCR-140 Models BCC/BCR-175 Models BFR/BCR-350 TECHNICAL MANUAL Section TABLE OF CONTENTS Page Section 1. TROUBLESHOOTING... 1-1 1-1. Introduction... 1-1 1-2.

More information

OWNER S MANUAL FOR AIR ADMIRAL VACUUM/PRESSURE STATION MODELS:

OWNER S MANUAL FOR AIR ADMIRAL VACUUM/PRESSURE STATION MODELS: OWNER S MANUAL FOR AIR ADMIRAL VACUUM/PRESSURE STATION MODELS: 79202-00 79202-05 79202-30 79202-35 Approval Agency s Model 79202-00 & 79202-05 Model 79202-30 & 79202-35 Not recommended for pumping acid,

More information

Installation Instructions

Installation Instructions Electric Heaters 5 --- 20 kw SMALL PACKAGED PRODUCTS (SPP) Accessory Electric Heaters For 13 SEER, R---410A, Z Chassis Installation Instructions NOTE: Read the entire instruction manual before starting

More information

AACH50 1/2 HP GALLONS (200 TO 1200L) INSTRUCTION MANUAL

AACH50 1/2 HP GALLONS (200 TO 1200L) INSTRUCTION MANUAL Ideal for ponic System Reservoirs 1/2 HP 53-317 GALLONS (200 TO 1200L) AACH50 INSTRUCTION MANUAL Before operating this appliance, please read the instruction manual thoroughly and keep on file for future

More information

HALLMARK INDUSTRIES INC. HALLMARK INDUSTRIES INC. Safety WARNING WARNING. Must reset the voltage! Shallow Well Jet Pumps

HALLMARK INDUSTRIES INC. HALLMARK INDUSTRIES INC. Safety WARNING WARNING. Must reset the voltage! Shallow Well Jet Pumps Safety Important Safety Instructions SAVE THESE INSTRUCTIONS - This manual contains important instructions that should be followed during installation, operation, and maintenance of the product. Save this

More information

SERVICE/INSTALLATION MANUAL ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250

SERVICE/INSTALLATION MANUAL ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 SERVICE/INSTALLATION MANUAL ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 Ice-O-Matic 11100 East 45th Ave Denver, Colorado 80239 Part Number 9081305-01 Date 10/08 Introduction IOD150,IOD200,IOD250

More information

WATLOW IND. WATROD Flange Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date:6/11/2008 Rev: 2.00

WATLOW IND. WATROD Flange Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date:6/11/2008 Rev: 2.00 I&M NUMBER: 316-42-8-1 Page: 1 _ Pre Installation Check to make sure that heater received is the same as that ordered. Elements may come in contact with each other during shipment. Minor adjustments to

More information

VIPER. Operator s Manual. Release Date: October 11, 2008 Publication Number: OPR Revision Date: May 19, 2009 Revision: Preliminary B

VIPER. Operator s Manual. Release Date: October 11, 2008 Publication Number: OPR Revision Date: May 19, 2009 Revision: Preliminary B VIPER Operator s Manual Release Date: October 11, 2008 Publication Number: 621260373OPR Revision Date: May 19, 2009 Revision: Preliminary B CONTACT INFORMATION The products, technical information, and

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Crescent Cuber Models KM-900MAH50 KM-900MRH50 A Superior Degree of Reliability INSTRUCTION MANUAL www.hoshizaki.com Issued: 6-25-2008 IMPORTANT Only qualified service technicians

More information

ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 INSTALLATION/SERVICE MANUAL

ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 INSTALLATION/SERVICE MANUAL ICE ONLY DISPENSERS MODELS-IOD150, IOD200 AND IOD250 INSTALLATION/SERVICE MANUAL Ice-O-Matic 111000 East 45th Ave Denver, Colorado 80239 Part Number 9081305-01 Rev. C Revision Date: September 19, 2011

More information

INSTANT HOT WATER DISPENSER

INSTANT HOT WATER DISPENSER INSTANT HOT WATER DISPENSER Tank Installation Materials required (not provided) 2 mounting bracket screws (and 2 plastic anchors if attaching to drywall) Shut-Off valve and T fitting Components When you

More information

User s Guide for the SunDanzer BFRV55

User s Guide for the SunDanzer BFRV55 User s Guide for the SunDanzer BFRV55 SunDanzer, Inc 420 E Aviation #110 Tucson, AZ 85714 INTRODUCTION Before using the appliance, read through this manual carefully including all the information on safety,

More information

V-220 / V-320 Heater Kits Installation Instructions TK IM (Rev. 0, 06/17)

V-220 / V-320 Heater Kits Installation Instructions TK IM (Rev. 0, 06/17) Installation Manual V-220 / V-320 Heater Kits Installation Instructions TK 56340-18-IM (Rev. 0, 06/17) Installation Manual V-220 / V-320 Heater Kits Installation Instructions TK 56340-18-IM (Rev. 0, 06/17)

More information

CONTENTS DESCRIPTION UNPACKING DIMENSIONS

CONTENTS DESCRIPTION UNPACKING DIMENSIONS INSTALLATION INSTRUCTIONS Ventilating Fan ModelNo.FV-08VRE CONTENTS GENERAL SAFETY INFORMATION DESCRIPTION UNPACKING SUPPLIED ACCESSORIES DIMENSIONS WIRING DIAGRAM INSTALLATION (BETWEEN JOISTS MOUNTING)

More information

IDT-12-N Hydraulic Crimping Tool

IDT-12-N Hydraulic Crimping Tool INSTRUCTION MANUAL IDT-12-N Hydraulic Crimping Tool Read and understand all of the instructions and safety information in this manual before operating or servicing this tool. 99945282 REV 6 2009 Ilsco

More information

Installation Instructions

Installation Instructions Installation Instructions Cased Horizontal Furnace Coil CK3B A96318 Fig. 1 Model CK3B Furnace Coil NOTE: Read the entire instruction manual before starting the installation. SAFETY CONSIDERATIONS Improper

More information

WATLOW IND. WATROD Circulation Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date: 6/11/2008 Rev: 2.00

WATLOW IND. WATROD Circulation Heater Installation & Maintenance Manual I&M NUMBER: Page: 1 Date: 6/11/2008 Rev: 2.00 I&M NUMBER: 316-42-5-1 Page: 1 Pre Installation Check to make sure that heater received is the same as that ordered. Watlow heaters are built to comply with UL and CSA dielectric requirements, it may be

More information

2 Gallon Water Boiler

2 Gallon Water Boiler USER S GUIDE 2 Gallon Water Boiler READ AND SAVE THESE INSTRUCTIONS NOTICE TO INSTALLER: Please leave this booklet with the machine. CONTENTS CL39...FS39... IS2...II20...II21...CI16............ES83.........

More information

INSTRUCTIONS! DO NOT DISCARD!

INSTRUCTIONS! DO NOT DISCARD! INSTRUCTIONS! DO NOT DISCARD! CAUTION! Do NOT install where injury might occur due to Moving parts, Sharp corners, Hot surfaces or electrical components d N0417 Page 1 of 10 INSTALLATION INSTRUCTIONS CAUTION

More information

Use & Care Manual. Electric Tankless Water Heaters. With Installation Instructions for the Installer AP15447 (10/10)

Use & Care Manual. Electric Tankless Water Heaters. With Installation Instructions for the Installer AP15447 (10/10) Use & Care Manual With Installation Instructions for the Installer Electric Tankless Water Heaters The purpose of this manual is twofold: one, to provide the installer with the basic directions and recommendations

More information

Powers Controls Low Temperature Detection Thermostat

Powers Controls Low Temperature Detection Thermostat Document No. 155-016P25 ET 134-22 Rev. 1, February, 2000 Powers Controls Low Temperature Detection Thermostat Description The electric Low Temperature Detection Cut-out and Alarm Thermostat is a remote

More information