Heater Selection Guide SELECTING THE CORRECT SIZE HEATER FOR POOLS & SPAS

Transcription

1 Heater Selection Guide SELECTING THE CORRECT SIZE HEATER FOR POOLS & SPAS Pool Sizing Determine your pool s surface area in square feet: Locate in the desired table below, the surface area equal to or just greater than the pool s surface area, read to the left and select the appropriate heater. For indoor pool installations divide the pool s surface area by 3. Tables are based on a 30 F temperature rise, MPH average wind velocity and elevation of up to 2,000 feet above sea level. Recommended H-Series for Spas/Hot Tubs Spa/Tub Size in Gallons Model Time in minutes to Raise Spa/Tub Temperature 30 F H H H H H H Recommended H-Series for Swimming Pools Model Surface Area H H H H H H Example: Rectangular pool: 20 feet x 30 feet: 20 multiply ft. 2 Surface Area Recommended H-Series Model Heater H200 Saving Money by Saving Energy Selecting a high efficiency heater for your new installation, or replacing an older inefficient model can have a significant impact on your fuel bill. Here are some additional energy saving tips. Check your pool chemistry regularly to maintain top operating condition. Set your pool water s temperature between 78 to 82 for most applications Use a pool cover or thermal blanket on your pool when it s not in use. Evaporation accounts for 70% of heat loss from your pool. Add wind breaks to your pool. A 7-mph wind at the surface of a pool can increase energy consumption 300%! Spa Sizing Determine your spa capacity in gallons (Surface area x average depth x 7 1 2). The reference tables list the time required in minutes to raise the temperature of the spa/hot tub by 30 F. Locate in the desired table below the spa/hot tub size in gallons equal to or just greater than the spa/hot tub size in gallons. Select the desired time to raise the spa/hot tub temperature 30 F, read to the left and select the appropriate heater. This guide can be adjusted for other temperature rises. For example, if you desire a 15 F increase in temperature, simply divide the time for 30 F rise by the ratio of 30/15 = 2. Note: Heat losses and/or heat absorbed by spa walls or other objects will add to heat-up time. Spa sizing is based on an insulated and covered spa. Always cover your spa or hot tub when not in use to minimize heat loss and evaporation. Recommended H100 Induced Draft Model for Spas Spa/Tub Size in Gallons Model Time in minutes to Raise Spa/Tub Temperature 30 F H Recommended H100 Induced Draft Model for Above Ground Pools H100 Induced Draft Heater will raise temperature of Above Ground Pool in 8 Hour period as follows: Temperature Rise in 8 Hours Pool Size Gallons Avg. Temp Rise (f) 15' Round 5, ' Round 7, ' x 24' Rectangle 8, ' Round 10, ' Round 13, ' Round 17, We highly recommend that your Hayward Above Ground Pool heater be used in conjunction with a solar blanket to maximize your heating efficiency. Recommended CSpaXI Models Model Spa/Tub Size in Gallons Time in minutes to Raise Spa/Tub Temperature 30 F CSPAXI CSPAXI Example: Want a 300 gallon spa to go from 70 F to 100 F in 120 minutes. 100 F subtract 70 F 30 F Requested Temperature Rise Recommended CSPA Model Heater CPAXI11

2 PAGE 1186 PRODUCT DESCRIPTION - HAYWARD HEATPRO HPABG & HP380 HAYWARD HEATPRO HPABG & HP380

3 PAGE 1187 PRODUCT DESCRIPTION - HAYWARD HEATPRO HPABG & HP380 HAYWARD HEATPRO HPABG & HP380 ILLUSTRATED PARTS BREAKDOWN ON PAGE 1186 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W---NLA HPX Fan Top $ NLA 02W---NLA HPX2427H 2 Side Panel - HP380 NLA 03W---NLA HPX2428H Side Panel - HPABG NLA 04W---NLA HPX Control Box Assembly NLA 05W HPX Contactor W HPX Thermostat W HPX Time Delay Relay W HPX Water Pressure Switch W HPX Capacitor W---NLA HPX Bent Coil with Guard NLA 11W HPX Compressor Ton 1, W---NLA HPX Condenser NLA 13W HPX Fan Motor W HPX Fan Motor (use on units HP380 and HPAB built prior to S/N ) 15W HPX Fan Guard W HPX Condenser Bracket W HPX Fan Blade W HPX Fan Motor Mount NOT SHOWN ITEM NO. KEY# DESCRIPTION SUGG. LIST 19W---NLA HPX2001 ** 1/2 Bulb Well $ NLA 20W HPX2179 ** Replacement LP Switch W HPX2186 ** High Pressure Switch W HPX ** Expansion Valve Assembly W-Quote HPX2261A ** Tie-Down Kit QUOTE 24W HPX0054 ** Compressor Mount Kit W HPX ** Knob Kit for HPX1105 Thermostat Kit W HPX ** Cover Gasket 27.53

4 PAGE 1188 PRODUCT DESCRIPTION - HAYWARD HEATPRO HP20854T & HP21104T HAYWARD HEATPRO HP20854T & HP21104T

5 PAGE 1189 PRODUCT DESCRIPTION - HAYWARD HEATPRO HP20854T & HP21104T HAYWARD HEATPRO HP20854T & HP21104T ILLUSTRATED PARTS BREAKDOWN ON PAGE 1188 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W HPX Fan Top $ W HPX Side Panel W HPX Control Box Cover W HPX Control Box W HPX Contractor W HPX Control Board Assembly W HPX Interface Board W HPX Water Pressure Switch W HPX Transformer W HPX Capacitor - HP20854T W HPX Capacitor - HP21104T W HPX Bend Coil with Guard - HP20854T 1, W HPX Bend Coil with Guard - HP21104T 2, W HPX Compressor - HP20854T 1, W HPX Compressor - HP21104T 1, W HPX Condensor - HP20854T 1, W HPX Condensor - HP21104T 1, W HPX Cover Gasket W HPX Fan Motor, 1/3 HP W HPX Fan Guard W HPX Fan Blade W HPX Replacement HP Switch W HPX Replacement LP Switch W HPX Expansion Valve Assembly - HP20854T W HPX Expansion Valve Assembly - HP21104T W HPX Temperature Sensor W HPX Electrical Entry Plug W HPX Fan Run Capactor W HPX Defrost Sensor NOT SHOWN ITEM NO. KEY# DESCRIPTION SUGG. LIST 30W HPX HPC Cable $ W HPX Compressor Blanket W HPX Compressor Mount Kit W HPX Compressor Electrical Plug For product info., see page 297 in the product section.

6 PAGE 1190 PRODUCT DESCRIPTION - HAYWARD H-SERIES 100,000 BTU HEATER HAYWARD H-SERIES HEATER 100,000 BTU

7 PAGE 1191 PRODUCT DESCRIPTION - HAYWARD H-SERIES 100,000 BTU HEATER HAYWARD H-SERIES HEATER 100,000 BTU ILLUSTRATED PARTS BREAKDOWN ON PAGE 1190 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W IDXJKT Jacket Top $ W IDXBWR Conversion Kit, Combustion Blower W IDXBLG Blower Gasket W IDXHLK Hi Limits, Kit W CZXPRS Water Pressure Switch W---NLA IDXHXA Heat Exchanger Assembly NLA 07W IDXHXA Heat Exchanger Assembly (used starting at S/N 29F30088) 08W IDXGKT Heat Exchanger Gasket W IDXWHA Wire Harness W IDXWHA Wire Harness (used starting at S/N 20A01209) W IDXBRG Burner Gasket W IDXBNR Burner W IDXIGN Ignitor W IDXAGK & 13 Burner Orifice & Air Orifice Bracket Kit NG W IDXAGK & 13 Burner Orifice & Air Orifice Bracket Kit NG W IDXVAL Gas Valve W IDXMAN Gas Manifold W IDXAPS Air Pressure Switch W IDXMOD Control Module (ignition) W IDXILS Interlock Switch W---NLA IDXCPG Coupling NLA 22W IDXCPG Coupling (used starting at S/N 29F30088) W IDXTST Thermostat W IDXCPA Control Panel W IDXLBL Label, Control Panel W IDXFAD Front Access Door W IDXFAD Front Access Door (used starting at S/N 20A01209) 28W IDXBLS Blower Switch NOT SHOWN ITEM NO. DESCRIPTION SUGG. LIST 29W IDXCST1930 Cordset $ W IDXCNK1933 Conversion Kit NG-LP W IDXCNK1934 Conversion Kit LP-NG For product info., see page 284 in the product section.

8 PAGE 1192 PRODUCT DESCRIPTION - HAYWARD H-SERIES ED-1 STYLE MV HEATER HAYWARD H-SERIES HEATER ED-1 STYLE

9 PAGE 1193 PRODUCT DESCRIPTION - HAYWARD H SERIES HEATER ED-1 STYLE/MV ED-1 HAYWARD H-SERIES HEATER ED-1 STYLE ILLUSTRATED PARTS BREAKDOWN ON PAGE 1192 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote Jacket Top (specify model) $ QUOTE 02W HAXDHO DHO Insert W-PCAT Indoor Draft Hood (see product catalog page 235) W-PCAT High Wind Stack (see product catalog page 235) W HAXHXA Heat Exchanger Assembly 150 1, W HAXHXA1203 Heat Exchanger Assembly 200 1, W HAXHXA1253 Heat Exchanger Assembly 250 1, W HAXHXA1303 Heat Exchanger Assembly 300 (all styles) 1, W HAXHXA1353 Heat Exchanger Assembly 350 (all styles) 1, W HAXHXA1403 Heat Exchanger Assembly 400 (all styles) 1, W HAXWHA Wire Harness, Rear - Elec W HAXWHA0007 Wire Harness, Rear - Elec. (after ) W HAXWHA0002 Wire Harness, Rear - MV W HAXWHA0006 Wire Harness, Rear - MV (after ) W HAXFOR Heater Union O-Ring (set of 2) W HAXNIP Heater Union Nipples W HAXNUT Heater Union Nut (set of 2) W---NLA HAXBPI Bypass Valve Insert NLA (sub HAXBPK1930 or HAXBPK1931) 19W HAXFCT Flow Control Thermostat W CHXPLG /4" NPT Brass Plug W HAXBPK By-Pass Kit (includes bypass valve insert, bypass valve, valve spring, brass shaft)(before ) 22W HAXBPK By-Pass Kit (includes bypass valve insert, bypass valve, valve spring, brass shaft)(after ) 23W HAXHLI Hi-Limit 135 F W HMXHLI Hi-Limit 160 F W HAXDRV Drain Valve Assembly W CHXPSA Pressure Switch Adapter W CHXTBW a Bulb Well (before ) W HAXTBW b Bulb Well (after )(cotherm) W HAXFHD Front Header Only, Heaters (made before ) W HAXFHD1931 Front Header Only, Heaters (made after ) W HAXLAC Left Access Cover W HAXURA Upper Right Access Cover W HAXLRA Lower Right Access Cover W HAXPHK Plastic Hardware Kit W HAXTLK Temperature Limiters Kit W HAXTBK Pole Terminal Block W---NLA HAXTBK Pole Terminal Block NLA 38W---NLA CHXGRL TA-2 Ground Lug NLA 39W HAXMOD Control Module W CHXTRF Transformer W HAXPSA Pressure Switch W HAXTST Thermostat W HAXLDK LED Kit W CHXTSW System Switch Single W CHXTSW1931 System Switch Dual 22.58

10 PAGE 1194 PRODUCT DESCRIPTION - HAYWARD H SERIES ED-1 STYLE/MV HAYWARD H-SERIES HEATER ED-1 STYLE continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1192 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote Control Panel Assy. (specify model) $ QUOTE 02W HAXGSV Gas Valve ( NA, MV) W HAXGSV0003 Gas Valve ( LP, MV) W HAXGSV0004 Gas Valve ( LP, DS) W HAXGSV0005 Gas Valve ( NA, DS) W-Quote Gas Manifold (specify model) QUOTE 07W HAXBRN Burner Tube W HAXBON Burner Orifice NA W HAXBON1931 Burner Orifice NA HA W---NLA HAXBOP1930 Burner Orifice LP NLA 11W HAXBOP1931 Burner Orifice LP HA W-Quote Burner Manifold (specify model) QUOTE 13W-Quote Front Access Door Assembly (specify model) QUOTE 14W HAXIGN Ignitor Assembly W HAXPLT Pilot, NA W HAXPLT1932 Pilot, LP W HAXTRK Pilot Tube Replacement Kit W HAXHOR Header O-Ring W HAXRHD Rear Header Only, (heaters made before ) W HAXPLG /4" NPT Brass Plug W HAXCIA Corner Piece Kit (4 pcs) W HAXFHA Front Header Assembly (before ) W HAXFHA1931 Front Header Assembly (after ) NOT SHOWN ITEM NO. DESCRIPTION SUGG. LIST 24W HAXWHA0005 Wire Harness, Main - Elec. $ W HAXWHA0001 Wire Harness, Main - MV W HAXWHA0004 Wire Harness Control Panel W-Quote HAXRFK1930 Retro Fit Kit QUOTE 28W-Quote "V" Baffle (specify model) QUOTE 29W HAXCNK0001 MV Conversion Kit NA to LP ( ) W HAXCNK0002 MV Conversion Kit LP to NA ( )

11 PAGE 1195 PRODUCT DESCRIPTION - HAYWARD H SERIES ED-2 ELECTRONIC STYLE HEATER HAYWARD H-SERIES HEATER ED-2 STYLE

12 PAGE 1196 PRODUCT DESCRIPTION - HAYWARD H SERIES ED-2 ELECTRONIC STYLE HEATER HAYWARD H-SERIES HEATER ED-2 STYLE ILLUSTRATED PARTS BREAKDOWN ON PAGE 1195 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote 1 Jacket Top Assembly (specify model) $ QUOTE 02W HAXDHO DHO Insert W---PCAT 3 Indoor Draft Hood (see product cat. page 235) W---PCAT 3 High Wind Stack (see product cat. page 235) W HAXHXA Heat Exchanger Assembly 150 1, W HAXHXA Heat Exchanger Assembly 200 1, W HAXHXA Heat Exchanger Assembly 250 1, W HAXHXA Heat Exchanger Assembly 300 1, W HAXHXA Heat Exchanger Assembly 350 1, W HAXHXA Heat Exchanger Assembly 400 1, W HAXWHA Rear Wire Harness, DS W HAXFOR O-Rings (set of 2) W HAXNIP Flange Pipe Nipples W HAXNUT Union Nuts (set of 2) W---NLA HAXBPI Bypass Insert NLA 16W HAXFCT Flow Control Thermostat W CHXPLG /4 NPT Brass Plug W HAXBPK Bypass Kit (includes bypass valve insert, bypass valve, valve spring, brass shaft) 19W HAXHLI Hi-Limit 135 F W HMXHLI Hi-Limit 160 F W HAXDRV Drain Valve Assembly W HAXPSA Pressure Switch Adapter W IDXLTER Thermistor W HAXFHD Front Header Only W HAXLAC Left Access Cover W HAXURA Upper Right Access Cover W HAXLRA Lower Right Access Cover W HAXPHK Plastic Hardware Kit W HAXTLK Temperature Limiters Kit W IDXLTMB Pole Terminal Block W---NLA CHXGRL TA-2 Ground Lug NLA 32W CHXTRF Transformer W HAXPSA Pressure Switch Assembly W HAXCPA Control Bezel Assembly W HAXCPA Control Panel Assembly 150 DS W HAXCPA Control Panel Assembly 200 DS W HAXCPA Control Panel Assembly 250 DS W HAXCPA Control Panel Assembly 300 DS W HAXCPA Control Panel Assembly 350 DS W HAXCPA Control Panel Assembly 400 DS

13 PAGE 1197 PRODUCT DESCRIPTION - HAYWARD H SERIES ED-2 ELECTRONIC STYLE HEATER HAYWARD H-SERIES HEATER ED-2 STYLE continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1195 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W HAXGSV Gas Valve, DS Propane $ W HAXGSV Gas Valve, DS Natural Gas W HAXMAN Gas Manifold W HAXMAN Gas Manifold W HAXMAN Gas Manifold W HAXMAN Gas Manifold W HAXMAN Gas Manifold W HAXMAN Gas Manifold W HAXBRN Burner Tube W HAXBON Burner Orifice, Natural Gas W HAXBON Burner Orifice, Natural Gas HA W HAXBOP Burner Orifice, Propane HA W HAXBOP Burner Orifice, Propane W---NLA HAXBMA Burner Manifold Assembly 150 DS NA NLA 15W---NLA HAXBMA Burner Manifold Assembly 150 DS LP NLA 16W---NLA HAXBMA Burner Manifold Assembly 200 DS NA NLA 17W-Quote HAXBMA Burner Manifold Assembly 200 DS LP QUOTE 18W---NLA HAXBMA Burner Manifold Assembly 250 DS NA NLA 19W-Quote HAXBMA Burner Manifold Assembly 250 DS LP QUOTE 20W---NLA HAXBMA Burner Manifold Assembly 300 DS NA NLA 21W---NLA HAXBMA Burner Manifold Assembly 300 DS LP NLA 22W---NLA HAXBMA Burner Manifold Assembly 350 DS NA NLA 23W-Quote HAXBMA Burner Manifold Assembly 350 DS LP QUOTE 24W-Quote HAXBMA Burner Manifold Assembly 400 DS NA QUOTE 25W-Quote HAXBMA Burner Manifold Assembly 400 DS LP QUOTE 26W---NLA HAXFAD Front Access Door Assembly 150 NLA 27W-Quote HAXFAD Front Access Door Assembly 200 QUOTE 28W-Quote HAXFAD Front Access Door Assembly 250 QUOTE 29W---NLA HAXFAD Front Access Door Assembly 300 NLA 30W-Quote HAXFAD Front Access Door Assembly 350 QUOTE 31W---NLA HAXFAD Front Access Door Assembly 400 NLA 32W HAXIGN Ignitor Assembly W HAXHOR Header O-Ring W HAXCIA Corner Piece Kit (4) W IDXLFHA Front Header Assembly W HAXPLG /8 Brass Plug NOT SHOWN 37W HAXWHA0008 ** Main Wire Harness $ W HAXCNK0009 ** Conversion Kit NG to LP (150E-400E) W HAXCNK0010 Conversion Kit LP to NG (150E-400E)

14 PAGE 1198 PRODUCT DESCRIPTION - HAYWARD H SERIES LOW NOx HEATER HAYWARD H-SERIES LOW NOx HEATER ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote FDXLJKT 1 Jacket Top & Flue Cover (specify model) $ QUOTE 02W-Quote FDXLTFC 2 Top/Flue Cover (specify model) QUOTE 03W-Quote FDXLFAD 3 Front Access Door Assembly (specify model) QUOTE 04W-Quote FDXLRAD 4 Rear Access Door Assembly (specify model) QUOTE 05W-Quote FDXLTFP 5 Top and Front Panel (specify model) QUOTE 06W FDXLUEC Upper End Cap W FDXLLEC Lower End Cap W FDXLLTP Left Trim Panel Kit W FDXLRTP Right Trim Panel Kit For product info., see page 284 in the product section.

15 PAGE 1199 PRODUCT DESCRIPTION - HAYWARD H SERIES LOW NOx HEATER HAYWARD H-SERIES LOW NOx HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1198 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W FDXLLCB Left Connection Box $ W-Quote FDXRCB Right Connection Box QUOTE 03W-Quote FDXLLJB Left Junction Box QUOTE 04W-Quote FDXLRJB Right Junction Box QUOTE 05W FDXLPBL Base Leg W FDXLFCS Flue Collector Side Panel W-Quote FDXLRGK 13 Rain Guard Assembly (specify model) QUOTE 08W-Quote FDXLHBP 14 Heat Barrier Panel (specify model) QUOTE 09W-Quote FDXLBBN 15 Blower Inlet Baffle (specify model) QUOTE 10W FDXLIAC Ignitor Access Cover W FDXLCBC Control Box Cover Assembly W FDXLGSV Gas Valve - NG W FDXLGSV Gas Valve - LP W FDXLBON Burner Orifice Kit - NG W FDXLBOP Burner Orifice Kit - LP W-Quote FDXLMAN 21 Gas Manifold (specify model) QUOTE 17W-Quote IDXLTMB Terminal Block, Remote Connection QUOTE 18W FDXLBWR Combustion Blower W FDXLBVS Blower Vacuum Switch W FDXLICB Integrated Control Board W FDXLFWP Field Wiring Panel W FDXLIGN Ignitor W-Quote IDXLFLS Flame Sensor QUOTE 24W-Quote IDXL2TRF Transformer QUOTE 25W FDXLWPS Water Pressure Switch W IDXL2DB Display Board Only W FDXLBKP Bezel and Keypad Assembly (taupe) W FDXLHLI High Limit 135 F W FDXLTER Thermistor W FDXLGSK Gasket, Bezel/Top W FDXLGSK Gasket, CC Front/Air Box W FDXLHXA Heat Exchanger Assembly - H150FD 1, W FDXLHXA Heat Exchanger Assembly - H200FD 1, W FDXLHXA Heat Exchanger Assembly - H250FD 1, W--Quote FDXLHXA1250A 37 Heat Exchanger Assembly - H250FD ASME QUOTE 36W FDXLHXA Heat Exchanger Assembly - H300FD 1, W FDXLHXA Heat Exchanger Assembly - H350FD 1, W FDXLHXA Heat Exchanger Assembly - H400FD 1, W-Quote FDXLHXA1400A 37 Heat Exchanger Assembly - H400FD ASME QUOTE 40W FDXLFHA Header Assembly W FDXLHDW Header Hardware Kit W FDXLHMB Header Mounting Base Kit W FDXLBPK Bypass Cartridge Kit W-Quote FDXLPGL /8 NPT Brass Plug QUOTE 45W CHXPLG /4 NPT Brass Plug W FDXLFHA Header Assembly W-Quote FDXLCRN Header Cartridge Retaining Nut QUOTE 48W SPX4000FG 46 Drain Plug with Gasket W FDXLBRN Burner W FDXLFOR Header O-Ring Kit W FDXLFSK Fuse Service Kit W FDXLGSK Gasket Kit - Air Side W FDXLGSK Gasket Kit - Exhaust Side (all models) For product info., see page 284 in the product section.

16 PAGE 1200 PRODUCT DESCRIPTION - JANDY LJ LITE 2 HEATER JANDY LJ LITE 2 HEATER (MFG ) MAIN GAS ASSEMBLY ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote Burner Tray Assembly (by model) $ QUOTE 02W-Quote Burner Tray Shelf Only (by model) QUOTE 03W R Gas Valve NG W R Gas Valve LP W L Gas Orifice LP (0-3,000 ft. alt.) W L Gas Orifice LP (0-5,000 ft. alt.) W-Quote Anti-Rotation Bracket QUOTE 08W R Main Burner W L Burner Manifold W L Burner Manifold W L Burner Manifold W L Burner Manifold W L Burner Manifold

17 PAGE 1201 PRODUCT DESCRIPTION - JANDY LJ LITE 2 HEATER JANDY LJ LITE 2 HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1200 ELECTRICAL SYSTEM ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W R Heater Control Assembly $ W R High Voltage Assembly W R Transformer with Wiring Harness W R Power Control Board W R /230V Conversion Plug W S Bezel W R Temperature Sensor W-Quote E Temperature Sensor Gasket QUOTE 09W Retainer Clip W Temperature Sensor Retainer Bracket W F Retainer Bracket Screw W---NLA R Pressure Switch & Siphon Loop Assembly 2 PSI NLA 13W R Pressure Switch 2 PSI W R Pressure Switch 1-10 PSI W R Siphon Loop Assembly W R High-Limit Switch Assembly W R F Hi-Limit Switch W R F Hi-Limit Switch W---NLA High-Limit Switch Wire Harness NLA 20W-Quote High-Limit Switch Retainer Clip QUOTE 21W High-Limit Switch Cover W R Fusible Link Assembly W Fusible Link Bracket W R Igniter Box Assembly R-Kit (old# R ) W---NLA R Igniter Box Assembly Kit NLA 26W R Igniter (pre-2006 units) W R Igniter (2006 & later units) W---NLA R Igniter Fuse Assembly (set of 2) NLA 29W R Flame Sense Rod VENT SYSTEM 30W-Quote Top Enclosure $ QUOTE 31W-Quote Top Filler Plate QUOTE 32W-Quote Rainshield Kit QUOTE 33W-Quote Flue Collector Assembly QUOTE 34W-Quote Outdoor Vent Cap QUOTE 35W-Quote Indoor Drafthood QUOTE 36W-Quote Flue Transition Plate QUOTE 37W-Quote Adapter Plate QUOTE 38W-Quote Clip QUOTE 39W---NLA Flue Collector Hold Down Clamp NLA WATER SYSTEM 40W R Inlet / Outlet Header, 2 $ W R Inlet / Outlet Header, 2 Bronze 1, W R Return Header, Bronze (includes set of 9 gaskets) W R Header Bolt Assembly (set of 8) W F Bolt for Headers, 2 1/ W F Washers for Headers 1.48

18 PAGE 1202 PRODUCT DESCRIPTION - JANDY LJ LITE 2 HEATER JANDY LJ LITE 2 HEATER continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1200 WATER SYSTEM continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W F Nut for Headers $ W R Header Gasket Assembly (set of 18) W R Flange & Gasket Assembly (set of 2) W Flange W S Flange Gasket W S /2-2 Flange Gasket W S Flange Sleeve W---NLA F Flange Bolt NLA 09W R Rubber Grommet for Drain Plug W P Brass Connector Body W P /4 Brass Drain Plug W P /4 Brass Plug W R By-Pass Assembly without Spring (iron cap) W-Quote By-Pass Assembly with Spring (bronze cap) QUOTE 15W S By-Pass Valve Rod W R By-Pass Valve Disc W-Quote S By-Pass Spring, Purple QUOTE 18W S By-Pass Spring, White W S By-Pass Spring, Red W S By-Pass Spring, Blue W S By-Pass Spring, Black W F Brass Nut (for rod) W R By-Pass Valve Control Cap (iron) W R By-Pass Valve Control Cap (bronze) W F Control Cap Bolts (2 required) W R By-Pass Valve Gasket W-Quote Heat Exchanger Tube Assembly (quote by model) QUOTE (includes set of 18 gaskets) 28W-Quote Heat Exchanger Baffle (8 required) (quote by model) QUOTE 29W S Baffle Retainer W Heat Exchanger Support Clip (2 required) W-Quote Heat Exchanger End Baffles (quote by model) QUOTE (2 required) 32W-Quote Complete Combustion Chamber Assembly QUOTE JACKET COMPONENTS 33W-Quote Door with Latch (quote by model) $ QUOTE 34W-Quote Jacket Assembly, less Top (quote by model) QUOTE 35W R Inlet / Outlet Gap Closure W R Return Gap Closure W F Button Plug 1 3/ W R Button Plug 7/ W R Button Plug 2 (with hole for gas line) 4.86

19 PAGE 1203 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER

20 PAGE 1204 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER continued]

21 PAGE 1205 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER MAIN GAS ASSEMBLY ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote Burner Tray Assembly (by model) $ QUOTE 02W-Quote Burner Tray, Shelf Only (by model) QUOTE 03W R Gas Valve NG W R Gas Valve LP W R Anti-Rotation Bracket W R Hot Surface Igniter W R Flame Sensor Rod W R Main Burner W R Burner Manifold W R Burner Manifold W R Burner Manifold W R Burner Manifold W R Burner Manifold W R Orifice Set NG ( ft. alt.) W R Orifice Set LP ( ft. alt.) W R Manifold Assembly NG W R Manifold Assembly NG W R Manifold Assembly NG W R Manifold Assembly NG W R Manifold Assembly NG For product info., see page 294 in the product section.

22 PAGE 1206 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1204 MAIN GAS ASSEMBLY continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W R Manifold Assembly LP 125 $ W R Manifold Assembly LP W R Manifold Assembly LP W R Manifold Assembly LP W R Manifold Assembly LP electrical system 06W R Universal Control User Interface $ W R Universal Control with Bezel 1, W R Universal Control Power Interface W R Transformer W R Temperature Sensor - Regular W R Temperature Sensor - Salt W R Temperature Sensor Gasket W R Temperature Sensor Mounting Plug W R Cap Sensor/Pressure Swith with O-Ring W R Pressure Switch, 2 PSI W R Pressure Switch, 1-10 PSI W R Water Pressure Switch Tubing W R High-Limit Switch Assembly W R High-Limit Set (130 o F and 150 o F) W R High-Limit Switch, 130 o F W R High-Limit Switch, 150 o F W R Ignition Control W R Fusible Link Assembly W R Fusible Link Bracket W R Wire Harnesses Set VENT system 26W-Quote Top Enclosure (by model) $ QUOTE 27W-Quote Vent Cover (by model) QUOTE 28W-Quote Rainshield - Partition (by model) QUOTE 29W-Quote Flue Collector Assembly (by model) QUOTE 30W-Quote Outdoor Vent Cap (by model) QUOTE 31W-Quote Indoor Drafthood (by model) QUOTE 32W-Quote Adapter Plate (by model) QUOTE 33W R Clip For product info., see page 294 in the product section.

23 PAGE 1207 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1203 WATER SYSTEM - POLYMER ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W R Inlet/Outlet Header Assembly - Polymer $ W R Return Header Assembly - Polymer W R Header Hardware Set - Polymer W R Heat Exchanger Assembly Complete - Copper 125 1, W R Heat Exchanger Assembly Complete - Copper 175 1, W R Heat Exchanger Assembly Complete - Copper 250 1, W R Heat Exchanger Assembly Complete - Copper 325 2, W R Heat Exchanger Assembly Complete - Copper 400 2, W R Heat Exchanger Assembly Complete - CuNi 125 1, W R Heat Exchanger Assembly Complete - CuNi 175 2, W R Heat Exchanger Assembly Complete - CuNi 250 2, W R Heat Exchanger Assembly Complete - CuNi 325 2, W R Heat Exchanger Assembly Complete - CuNi 400 3, W R Heat Exchanger Drain Plugs - Polymer (2) W R Coupling Nut Kit with O-Ring W R Bypass Assembly - Polymer W R Bypass Adjustable Spring - Polymer W R Tailpiece with Union Nut - Polymer (set of 2) WATER SYSTEM - bronze 19W-Quote Inlet/Outlet Header Assemby - Bronze (by model) $ QUOTE 20W R Return Header Assemby - Bronze (includes set of 9 gaskets) 21W-Quote Bypass Assembly - Bronze (by model) QUOTE 22W-Quote Bypass Spring - Bronze (by model) QUOTE 23W R Bypass Gasket - Bronze W R Heat Exchange Hardware Kit - Bronze W R Temp Sensor Mounting Bracket - Bronze W R Water Pressure Switch Tubing - Bronze W R Flange & Gasket Kit - Bronze W R Flange Bolts - Bronze W R /4 NPT Plug - Bronze W R Drain Plug Header - Bronze W R Heat Exchanger Assembly Complete - Copper 125 2, W R Heat Exchanger Assembly Complete - Copper 175 2, W R Heat Exchanger Assembly Complete - Copper 250 2, W R Heat Exchanger Assembly Complete - Copper 325 2, W R Heat Exchanger Assembly Complete - Copper 400 3, W R Heat Exchanger Assembly Complete - CuNi 125 3, W R Heat Exchanger Assembly Complete - CuNi 175 3, W R Heat Exchanger Assembly Complete - CuNi 250 3, W R Heat Exchanger Assembly Complete - CuNi 325 3, W R Heat Exchanger Assembly Complete - CuNi 400 4, For product info., see page 294 in the product section.

24 PAGE 1208 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1204 WATER SYSTEM - all ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W R Header Gasket Assembly (set of 16) $ W R Bypass Hardware, Gaskets W-Quote Heat Exchanger Tube Assembly - Copper (by model) QUOTE 04W-Quote Heat Exchanger Tube Assembly - CuNi (by model) QUOTE 05W-Quote Heat Exchanger Baffles (by model) QUOTE firebox components 06W-Quote Combustion Chamber Panels (by model) $ QUOTE 07W R Igniter Bracket with Shield jacket components 08W-Quote Door with Latch (by model) $ QUOTE 09W R Latch Assembly W R Sealing Grommet W R /8 Button Plug W-Quote Rear Panel Assemby (by model) QUOTE 13W R Right Side Panel W R In/Out Cover Panel - Top W R In/Out Cover Panel - Bottom W R Left Side Panel W R Return Side Cover - Top W R Return Side Cover - Bottom W-Quote Heat Shield (by model) QUOTE 20W-Quote Front Heat Deflector Guard QUOTE 21W-Quote Rear Partition QUOTE 22W-Quote Rear Heat Deflector Guard QUOTE 23W-Quote Controller Mounting Panel QUOTE 24W R Weather Strippping W R /8 Grommet optional components 26W-Quote Noncombustible Base $ QUOTE 27W R Pressure Relief Valve Kit 75 PSI - Bronze W R Pressure Relief Valve Kit 75 PSI - Polymer W-Quote R Touch-Up Spray Paint - Pewter QUOTE 30W R Temp Rise measurement Kit For product info., see page 294 in the product section.

25 PAGE 1209 PRODUCT DESCRIPTION - PENTAIR THERMALFLO HEAT PUMP PENTAIR THERMALFLO HEAT PUMP ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W Acorn Nut S/S $ W Fan Guard W Fan Guard Screw Kit W Fan Motor w/acorn Nuts W /4-20 Acorn Nut S/S 1.38

26 PAGE 1210 PRODUCT DESCRIPTION - PENTAIR THERMALFLO HEAT PUMP PENTAIR THERMALFLO HEAT PUMP ILLUSTRATED PARTS BREAKDOWN ON PAGE 1209 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W Top HP $ W #10 x 3/4 Ph Pan Head - Almond Head Screw W #10 x 1 Button Head Torx - Almond Head Screw W Fan Blade W---NLA Coil Air Evaporator 32 x 80 Formed NLA 06W---NLA Coil Air Evaporator 24 x 80 Formed NLA 07W Orifice, Reversing (model #1200R) W Orifice, (models 500, 700, 900, 1200, 1200C) W Drier (models 500, 700, 900, 1200, 1200C) W Drier, Reversible (model 1200R) W /16-18 x 1 Bolt W Coil, Water (model 500) 1, W Coil, Water (mdls 700, 900, 1200, 1200R, 1200C) 1, W Fender Washer W Switch 90/120 Lo Press W Compression Fitting, Water Line (model 500) W Compression Fitting, Water Line (models 700, 900, 1200, 1200R, 1200C) 18W Thermistor Complete IID (probe) W /4-20 Hex Nut S/S W Pressure Switch W Bracket, Tie Down W PVC Union W Manifold Bypass Assembly / Hartford Loop Small W Manifold Bypass Assembly / Hartford Loop Large W /16-18 x 1 3/4 Bolt S/S W Compressor Isolation Kit, Grommet & Spacer (1 set) W Panel Front Right Small W Panel Front Right Tall W-Quote Panel Front Left Tall QUOTE 30W-Quote Panel Front Left Small QUOTE 31W U-Clip Nut W J-Clip Nut W R Check Valve W Switch 500/380 Hi Press W Z 32 Compressor Trane GH633-LL1-G 2, W Z 32 Compressor Trane GH673-LM1-G 2, W Wire Harness, Compressor W Bezel, Control Board with Label W Control Board W Wire Harness, Fan & Compressor Terminal Block W Transformer W Wire Harness, Main W Relay, Fan W Contactor W Capacitor 5.0/7.5 Mfd 440V W Wire Harness, Sensor Terminal Block W ** Valve, Reversing (model 1200R) W ** Solenoid, Reversing (model 1200R)

27 PAGE 1211 PRODUCT DESCRIPTION - PENTAIR CH HEATER PENTAIR CH HEATER

28 PAGE 1212 PRODUCT DESCRIPTION - PENTAIR CH HEATER PENTAIR CH HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1211 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W---PCAT Indoor Vent (see product catalog page 235) $ W---PCAT a Outdor Vent (see product catalog page 235) W Return Header Assembly W Heat Exchanger Bolt W /8 x 7/8 Washer W Tube Seal Gasket W Thermostat Knob W Rocker Switch W MV Door W MV Door W MV Door W-Quote MV Door QUOTE 13W MV Door W MV Door W Manifold Burner W Manifold Burner W Manifold Burner W Manifold Burner W Manifold Burner W Manifold Burner W Gas Valve ( MV) NG W Gas Valve ( MV) LP W Pilot Tube ( ) W Pilot Tube ( ) W Pilot Tube ( ) W NG Burner Tray Assembly Complete 1, W-Quote NG Burner Tray Assembly Complete QUOTE 28W NG Burner Tray Assembly Complete 1, W NG Burner Tray Assembly Complete 1, W NG Burner Tray Assembly Complete 2, W LP Burner Tray Assembly Complete 1, W LP Burner Tray Assembly Complete 1, W LP Burner Tray Assembly Complete 1, W LP Burner Tray Assembly Complete 1, W LP Burner Tray Assembly Complete 1, W LP Burner Tray Assembly Complete 2, W Burner ( ) W a Burner with Pilot Bracket ( ) W Pressure Switch W Combustion Chamber Assembly Complete W Combustion Chamber Assembly Complete W Combustion Chamber Assembly Complete W Combustion Chamber Assembly Complete W Combustion Chamber Assembly Complete W Combustion Chamber Assembly Complete W Presslite Igniter Assembly W Potentiometer W Flow Valve Assembly W Hi-Limit Thermostat For product info., see page 281 in the product section.

29 PAGE 1213 PRODUCT DESCRIPTION - PENTAIR CH HEATER PENTAIR CH HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1211 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W Bulkhead Adaptor $ W Bulkhead Ring Adaptor W Main Manifold Assembly W Main Header Assembly W Main Manifold Bottom W Main Manifold Bottom Cap W Hi-Limit Thermostat W Heat Exchanger Assembly W Heat Exchanger Assembly W Heat Exchanger Assembly W Heat Exchanger Assembly W Heat Exchanger Assembly 350 1, W Heat Exchanger Assembly 400 1, W Baffle W Baffle W Baffle W Baffle W Baffle W Baffle W Baffle Hold Down (2 on 400) W Flue Collector W Flue Collector W Flue Collector W--NLA Flue Collector 300 NLA 25W Flue Collector W Flue Collector W Outdoor Top Assembly W Outdoor Top Assembly W Outdoor Top Assembly W Outdoor Top Assembly W Outdoor Top Assembly W Outdoor Top Assembly W---Quote Lightback Shield LP Units Only QUOTE (quote by model) 34W Electronic Thermostat MV Models W Return Panel W In / Out Panel W Thermistor Probe Complete MV Models For product info., see page 281 in the product section.

30 PAGE 1214 PRODUCT DESCRIPTION - PENTAIR CH HEATER PENTAIR CH HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1211 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W Plastic Mounting Bracket $ W Clips for Wire Harness W Wire Kit, MV W #8 x 1/4 Hex Hd Screw W #8 x 1/2 Hex Hd Screw W #6 x 1/4 Screw W x 1/4 Screw W x 3/16 Screw W /2 Bushing W Therm Knob Stopper W /16-18 x 3/4 Bolt W Pilot NG, MV W Pilot LP, MV W Pilot Generator W Thermal Cutoff Fusible Link W Power Element Flow Valve W Pilot Rainshield W Pilot Electrode Only W L Brackets W Bracket Adapter Q379 Pilot MV W Jumper W Door Latch For product info., see page 281 in the product section.

31 PAGE 1215 PRODUCT DESCRIPTION - PENTAIR MASTERTEMP HEATER PENTAIR MASTERTEMP HEATER ELECTRICAL SYSTEM REPLACEMENT PARTS ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W Z 2 Heater Display Cover $ W S 3 Igniter Bracket W Igniter / Igniter Gasket Kit W S 5 Igniter Gasket W S 7 Automatic Gas Shutoff Switch AGS W S 8 High Limit Switch W S 9 Thermistor W S 10 Terminal Board W Fireman s Switch Fuse W S 12 Ignition Control Module W S /230V Transformer W S 14 Air Flow Switch W S 15 Control Board Kit W Z 17 Heater Top W Z 18 Membrane Pad W S 19 Stack Flue Sensor NOT SHOWN 17W S 115/230V Heater Wiring Harness $ W S 120/240V Plug Kit For product info., see page 283 in the product section.

32 PAGE 1216 PRODUCT DESCRIPTION - PENTAIR MASTERTEMP HEATER PENTAIR MASTERTEMP HEATER WATER SYSTEM REPLACEMENT PARTS ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W Tube Sheet Coil Assembly Kit 200 $ W Tube Sheet Coil Assembly Kit W Tube Sheet Coil Assembly Kit 333 1, W Tube Sheet Coil Assembly Kit 400 1, W Manifold Kit W Manifold Kit W Manifold Kit W Manifold Kit W Coil / Tubesheet Sealing O-Ring Kit W Coil / Tubesheet Sealing O-Ring Kit W Coil / Tubesheet Sealing O-Ring Kit W Coil / Tubesheet Sealing O-Ring Kit W Z 9 Water Pressure Switch ASME W Connector Tube Kit (includes 1 connector tube and 1 o-ring) 15W Thermal Regulator Kit W S 16 Thermal Regulator (includes spring clip) W Thermal Regulator Cap O-Ring W U178920P 20 Drain Plug W---NLA u7860zps 21 3/4 Pipe Plug NLA 20W Z 22 Pressure Relief Valve NOT SHOWN 21W O-Ring Kit $ For product info., see page 283 in the product section.

33 PAGE 1217 PRODUCT DESCRIPTION - PENTAIR MASTERTEMP HEATER PENTAIR MASTERTEMP HEATER BURNER SYSTEM REPLACEMENT PARTS

34 PAGE 1218 PRODUCT DESCRIPTION - PENTAIR MASTERTEMP HEATER PENTAIR MASTERTEMP HEATER BURNER SYSTEM REPLACEMENT PARTS ILLUSTRATED PARTS BREAKDOWN ON PAGE 1217 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W S 1 Combination Gas Control Valve Kit $ W S 2 3/4 Union W Air Blower Kit NG Units W Air Blower Kit NG Units W Air Blower Kit NG Units W Air Blower Kit NG Units W Air Blower Kit LP Units W Air Blower Kit LP Units W Air Blower Kit LP Units W Air Blower Kit LP Units W---NLA S 7 Air Orifice Grill NLA 12W S 16 1 Pc Metal Chamber Combustion Assembly W S 27 1 Pc Metal Elbow Combustion Chamber Cover Assembly 14W---NLA S 28 Metal Vent Cover NLA NOT SHOWN 15W Gas Orifice Kit NG 200 $ W Gas Orifice Kit NG W Gas Orifice Kit NG W Gas Orifice Kit NG W Gas Orifice Kit LP W Gas Orifice Kit LP W Gas Orifice Kit LP W Gas Orifice Kit LP W NG to LP Conversion Kit W NG to LP Conversion Kit W NG to LP Conversion Kit W NG to LP Conversion Kit W LP to NG Conversion Kit W LP to NG Conversion Kit W LP to NG Conversion Kit W LP to NG Conversion Kit W Air Orifice Kit W Air Orifice Kit W Air Orifice Kit W Air Orifice Kit W Blower Adaptor Plate Gasket Kit W Flameholder Kit W Flameholder Kit W Flameholder Kit W Flameholder Kit W Insulation Kit W S Lower Enclosure Insulation For product info., see page 283 in the product section.

35 PAGE 1219 PRODUCT DESCRIPTION - PENTAIR MINI MAX 100 HEATER PENTAIR MINI MAX 100 HEATER

36 PAGE 1220 PRODUCT DESCRIPTION - PENTAIR MINI MAX 100 HEATER PENTAIR MINI MAX 100 HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1219 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W Indoor Draft Hood Consisting of Indoor Draft $ ( hood) and Items 2 & 3 02W A Outdoor Top W Indoor Top (cover) W---NLA Indoor Stack Adapter NLA 05W Middle Top W---NLA Flue Collector NLA 07W Return Header W Bolt 3/8" x 16 UNC x 3/4" (4 required) W Rubber Seal Tube (10 required) W Heat Exchanger Less Heads W Main Header (inlet/outlet) W---NLA Combustion Chamber NLA 13W Ignitor Electrode Bracket W Burner Natural Gas W Burner Propane W a Burner Tray Assembly (complete) Natural Gas Millivolt 17W a Burner Tray Assembly (complete) Propane Millivolt 18W a Burner Tray Assembly (complete) Natural Gas DSI 19W a Burner Tray Assembly (complete) Propane DSI 20W Ignitor Electode W Gas Valve Natural Gas DSI - (Robertshaw) W Gas Valve Propane DSI - (Robertshaw) W Gas Valve Natural Gas Millivolt -SIT W Gas Valve Propane Millivolt - SIT W Thermostat (electronic) - Direct Spark Models W Thermostat - Millivolt Models W On/Off Switch S.P.S.T W---NLA Heat Shield Burner Tray NLA 29W Control Panel Assembly W Door Assembly W---NLA Control Bracket NLA 32W Ignition Control DSI W Transformer (old # ) W---NLA Jacket Assembly NLA 35W Inspection Panel W---NLA Burner Tray Back Support NLA 37W Burner Tray Side Support (2 required) W Heat Exchanger Support Brackets (2 required) W Hi-Limit Safety Switch (2 required) W Flow Valve Assembly W Pressure Switch W Baffle Hold Down Bracket W Flue Baffle 6.62 For product info., see pages 281 in the product section.

37 PAGE 1221 PRODUCT DESCRIPTION - PENTAIR MINI MAX 100 HEATER PENTAIR MINI MAX 100 HEATER continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1219 NOT SHOWN ITEM NO. DESCRIPTION SUGG LIST 01W---NLA Washer 3/8" I.D. (4 required) $ NLA 02W Thermal Cut-Off Switch W Pilot Natural Gas Millivolt W Pilot Propane Millivolt W Thermopile Generator W Quick-Flange Kit for 2" Slip Connection W Quick-Flange II Kit for 1.5" Thd. Connection W Kit Wiring MMX 100 Millivolt W Kit Wiring MMX 100 DSI W Knob W Knob Stopper W Presslite Piezo Assembly Millivolt W Valve Drain 1/4" NPT W Hi-Tension Ignition Cable W Bushing, 2" I.D W Pilot Bracket/Shield, Millivolt W Manifold For product info., see pages 281 in the product section.

38 PAGE 1222 PRODUCT DESCRIPTION - PENTAIR MINI MAX HEAT EXCHANGER MINIMAX HEAT EXCHANGER ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W Return Header $ W Washer 3/8" I.D., 1" O.D W Bolt 3/8" x 16 x 2" PLT W Bolt HH 3/8" x 16 x 1-1/2" S/S W Washer 3/8" I.D., 1" O.D W Tube Seal Gasket (18 required) W Flow Valve Assembly W Gasket Flow Valve W Bolt 3/8" x 16 x 2-1/2" PLT W---NLA Flange In/Out 2" Brass (pre 1994) NLA 11W Quick Flange Kit (w/quick flange unit, bolts, washers, 2" bushings, 1-1/2" bushings, sleeves) 12W Flange Only W Bushing In/Out 2" Lexan W Sleeve, Rubber In/Out 2" W---NLA Sleeve, Rubber 1-1/2" NLA 16W Hi Limit 135/ W Main Header In/Out W Heat Exchanger Less Heads, W Heat Exchanger Less Heads, W Heat Exchanger Less Heads, 250 1, W Heat Exchanger Less Heads, 300 1, W Heat Exchanger Less Heads, 350 1, W Heat Exchanger Less Heads, 400 1, W-Quote Heat Exchanger w/heads (specify model) QUOTE 25W Valve Boiler Drain 3/4" W---NLA /4" Tee (ASME) NLA 27W Valve Relief 3/4" 50# (ASME) W-Quote Nipple 3/4" x 2 1/2" (ASME) QUOTE

39 PAGE 1223 PRODUCT DESCRIPTION - PENTAIR MINI MAX BURNER TRAY ASSEMBLY MINIMAX BURNER TRAY ASSEMBLY ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W Manifold Burner $ W Manifold Burner W Manifold Burner W Manifold Burner W Manifold Burner W Manifold Burner W Valve Gas Natural IID W Valve Gas Propane IID W Gas Valve Millivolt - Natural, All Models W Gas Valve Millivolt - Propane, All Models W-Quote Gas Valve Replacement Kit (includes gas valve QUOTE bent tubing & fittings) 12W Pilot Tube - Millivolt - 150/ W Pilot Tube - Millivolt - 250/ W Pilot Tube - Millivolt - 350/ W-Quote Burner Tray with Gas Valve & Pilot Assembly QUOTE 16W Burner 50 K, All Models W A Burner with Pilot Bracket NOT SHOWN: ITEM NO. DESCRIPTION SUGG. LIST 18W-Quote Combustion Chamber Assembly $ QUOTE 19W Pilot Assy. - Millivolt, Natural W Pilot Assy. - Millivolt, Propane W Pilot Generator with Cap - Millivolt W Pilot Assy. - Natural IID Electronic W Pilot Assy. - Propane IID Electronic W Control Box Wire Harness IID Complete W Wire Kit - Millivolt - All Models 38.94

40 PAGE 1224 PRODUCT DESCRIPTION - PENTAIR MINI MAX CONTROL PANEL MINIMAX CONTROL PANEL ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W Transformer 1384 C, Dual Voltage $ W---NLA A Circuit Breaker, 1.4 Amp NLA 03W Circuit Board Thermostat - Electronic W Thermostat Assy. Complete - Electronic (includes #2, 10 and thermistor) 05W Module - Natural - S8600F IID Only W Module - Propane - S8600H IID Only W---NLA Light Indicator Board IID Only NLA 08W---NLA Thermostat Knob, All Models NLA 09W Rocker Switch, DPDT 6 Amp, All Models W-Quote Control Panel Assembly IID Only QUOTE 11W Pressure Switch Barks MPS-PA W---NLA Thermostat Stopper Knob NLA 13W Potentiometer Therm. Elec. IID Models W Thermal Cutoff w/o Bracket W---NLA Mounting Screw for Transformer #8 1-1/2" NLA 16W Presslite Matches Assembly - Millivolt W Thermostat 60" Capillary - Millivolt Models Only W Ignitor - Millivolt Models Only 21.90

41 PAGE 1225 PRODUCT DESCRIPTION - PENTAIR MINI MAX PLUS

42 PAGE 1226 PRODUCT DESCRIPTION - PENTAIR MINI MAX PLUS MINIMAX PLUS HEATER REPLACEMENT PARTS ILLUSTRATED PARTS BREAKDOWN ON PAGE 1225 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W-Quote Indoor Vent Kits $ QUOTE 02W-Quote A Outdoor Vent Kits QUOTE 03W Return Header - (1) W Bracket Washer - (1) W Bolt 3/8" x 2 - (1) W Bolt 3/8" x 1 1/2" - (1) W---NLA Washer 3/8" I.D. 1" O.D. - (1) NLA 08W Tube Seal Gasket - (1) W Transformer with Circuit Breaker Duel Voltage - (1) 10W Electronic Thermostat Circuit Board - IID Models - (1) 11W Module Nat. Gas - (1) W Module Propane Gas - (1) W Junction Box (IID Units) - (1) W Thermostat Knob - (1) W Switch Rocker (single pole & double throw) - (1) 16W-Quote Control Panel Assembly Complete QUOTE 17W-Quote Front Heater Door QUOTE 18W Manifold Burner W Manifold Burner W Manifold Burner W Manifold Burner W Manifold Burner W Manifold Burner W Gas Valve Natural - IID - (1) W Gas Valve Propane - IID - (1) W Gas Valve Natural - Millivolt - (1) W Gas Valve Propane - Millivolt - (1) W Pilot Tube - IID - ( ) W Pilot Tube - IID - ( ) W Pilot Tube - IID - ( ) W Pilot Tube - Millivolt - ( ) W Pilot Tube - Millivolt - ( ) W Pilot Tube - Millivolt - ( ) W-Quote Burner Tray Assembly Complete QUOTE 35W Burner (150 uses 2, 400 uses 7) W A Burner With Pilot Bracket W Z 21 Pressure Switch W-Quote Combustion Chamber Assembly Complete QUOTE 39W Valve Drain 3/4" W Ignitor, Millivolt Models Only W Valve Relief 3/4" 50# - (1) - (2) W Potentiometer (millivolt only) - (1) W Flow Valve Assy. Standard Complete - (1) W Flow Valve Gasket - (1) W Bolt 3/8" - 16 X 2 1/2 - (1) W Quick Flange Kit - (1)

43 PAGE 1227 PRODUCT DESCRIPTION - PENTAIR MINI MAX PLUS MINIMAX PLUS HEATER REPLACEMENT PARTS continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1225 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W Bushing In/Out Lexan - (1) $ W Sleeve, Rubber In/Out 2" - (1) W---NLA Sleeve, Rubber In/Out 1 1/2" - (1) NLA 04W Safety Shut-Off - (1) W Main Header In/Out - (1) W Heat Exchanger w/o Heads W Heat Exchanger w/o Heads W Heat Exchanger w/o Heads 1, W Heat Exchanger w/o Heads 1, W Heat Exchanger w/o Heads 1, W Heat Exchanger w/o Heads 1, W-Quote Baffle QUOTE 13W Baffle Hold Down (2 req. on 400) - (1) W-Quote Flue Collector QUOTE 15W-Quote Outdoor Top Assy. QUOTE 16W-Quote Lightback Shield (propane only) QUOTE 17W Electronic Thermostat - Millivolt - (1) W Panel Return - (1) W Panel In/Out - (1) W Thermistor (probe IID models) - (1) NOT SHOWN ITEM NO. DESCRIPTION SUGG. LIST 21W Wire Kit Harness IID Complete - (1) $ W Wire Kit - Millivolt - (1) W Therm. Knob Stopper - (1) W Power Element (flow-valve) - (1) W Pilot - Natural - IID - (1) W Piolt - Propane - IID - (1) W Pilot - Natural - Millivolt - (1) W Pilot - Propane - Millivolt - (1) W Pilot Generator - (1) W Thermistor (probe) Complete - Millivolt - (1) W Thermal Cut-off - Fusible Link - (1) W Pilot Electrode (only) - (1) W Stem, Thermostat Control (IID models) - (1) W Clips for Transformer - (1) W Bracket Adapter Q379 Pilot, MV - (1) W Jumper - (1) W Door Latch - (1) W-Quote Indicator Board LED Lightstrip - (1) - (3) QUOTE 39W Potentiometer (TSTAT) IID - (1) - (3) W Orifice Main Burner Natural - (1) W Orifice Main Burner Propane - (1) 7.42 (1) - Part # Used In Model #, (2) - ASME or Local Code (3) - Previously Manufactured Model

44 PAGE 1228 PRODUCT DESCRIPTION - PENTAIR MINI MAX NT HEATER MINIMAX NT HEATER

45 PAGE 1229 PRODUCT DESCRIPTION - PENTAIR MINI MAX NT HEATER MINIMAX NT HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1228 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W-Quote Exhaust Grill with Gasket $ W Gasket, Exhaust Grill W-Quote Top Cover with Posts QUOTE 04W-Quote Exhaust Assembly QUOTE 05W-Quote Blower with Gasket QUOTE 06W Gasket, Blower W-Quote Flue Collector QUOTE 08W Insulation, Header / Hi-Limit W Return Manifold Assembly W Bolt, Heat Exchanger W Washer, Heat Exchanger W-Quote Fire Box Assembly QUOTE 13W Heat Exchanger w/o Headers W Heat Exchanger w/o Headers W Heat Exchanger w/o Headers W Heat Exchanger w/o Headers 1, W Heat Exchanger Assy ASME w/ Headers 2, W Heat Exchanger Assy ASME w/ Headers 2, W Heat Exchanger Assy ASME w/ Headers 2, W-QUOTE Baffle, Heat Exchanger QUOTE 21W Thermistor Probe W Hi-Limit Thermostat F W Hi-Limit Thermostat F W Water Pressure Switch, ASME W Water Pressure Switch, NON-ASME W In/Out Top Sub-Header Assembly W In/Out Main Header Assembly W In/Out Bottom Sub-Header W In/Out Cap, Bottom Sub-Header W O-Ring Adapter W Adapter, Bulkhead Ring W Adapter, Bulkhead 2" W Gasket, Fin Tube, Seal W Flow Valve Assembly W Power Element Flow Valve W Sub Gas Manifold with Plug W Gas Valve - NG W Gas Valve - LP W-Quote Burner Tray Assembly NG QUOTE 40W Z 32 Igniter W Flame Sensor W-Quote Gas Manifold Assembly NG QUOTE

46 PAGE 1230 PRODUCT DESCRIPTION - PENTAIR MINI MAX NT HEATER MINIMAX NT HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1228 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W Orifice, Natural Gas ft. $ W Orifice, Propane, ft W Burner Only W Burner with Bracket W Jacket, Upper Panel, Left W Jacket, Upper Panel, Right W Jacket, Upper Subplate W Junction Box Assembly W-Quote Air Pressure Switch QUOTE 10W Module, Ignition Control W Temperature Controller Assembly W Right Door Assembly with Controller 1, W Right Door Assembly w/o Controller NOT SHOWN ITEM NO. DESCRIPTION SUGG. LIST 14W Thermal Cut-Off $ W Transformer 40VA W Wire Harness Assembly

47 PAGE 1231 PRODUCT DESCRIPTION - RAYPAK HEATER R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 ( ) continued BURNER TRAY ITEM # KEY# DESCRIPTION SUGG. LIST 01W F 1B Burner w/gas Valve NG - MV R185 $ 1, W F 1B Burner w/gas Valve NG - MV R265 1, W F 1B Burner w/gas Valve NG - MV R335 1, W F 1B Burner w/gas Valve NG - MV R405 2,059.72

48 PAGE 1232 PRODUCT DESCRIPTION - RAYPAK HEATERS R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 ( ) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1231 BURNER TRAY continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W F 1B Burner w/gas Valve LPG - MV R185 $ 1, W F 1B Burner w/gas Valve LPG - MV R265 1, W F 1B Burner w/gas Valve LPG - MV R335 1, W F 1B Burner w/gas Valve LPG - MV R405 2, W F 1B Burner w/gas Valve NG - IID R185 1, W F 1B Burner w/gas Valve NG - IID R W F 1B Burner w/gas Valve NG - IID R335 2, W F 1B Burner w/gas Valve NG - IID R405 2, W F 1B Burner w/gas Valve LPG - IID R185 1, W F 1B Burner w/gas Valve LPG - IID R265 1, W F 1B Burner w/gas Valve LPG - IID R335 2, W F 1B Burner w/gas Valve LPG - IID R405 2, W F 2B Burner Spacer/Hold Down Kit R W F 2B Burner Spacer/Hold Down Kit R W F 2B Burner Spacer/Hold Down Kit R W F 2B Burner Spacer/Hold Down Kit R W B Burner R185 (13 required) W B Burner R265 (19 required) W B Burner R335 (24 required) W B Burner R405 (29 required) W F 4B Burner Orifice LPG #57 R185 (13 required) W F 4B Burner Orifice LPG #57 R265 (19 required) W F 4B Burner Orifice LPG #57 R335 (24 required) W F 4B Burner Orifice LPG #57 R405 (29 required) W F 4B Burner Orifice NG #51 R185 (13 required) W F 4B Burner Orifice NG #51 R265 (19 required) W F 4B Burner Orifice NG #51 R335 (24 required) W F 4B Burner Orifice NG #51 R405 (29 required) W F 5B Burner Tray w/o Manifold or Burners R W F 5B Burner Tray w/o Manifold or Burners R W F 5B Burner Tray w/o Manifold or Burners R W F 5B Burner Tray w/o Manifold or Burners R Controls 33W B 1C AGS (Auto Gas Shut Off)-Red Epoxy $ W B 2C High Limit Black Epoxy W F 3C PC Board Control IID Units W F 6C Fuse PC Board IID Units W F 4C Thermostat Control MV Units Mechanical (old # B) 38W B 5C Temperature Sensor IID Units Gas VALVES 39W F 1G Combination Valve NG - MV $ W F 1G Combination Valve LPG - MV W F 1G Combination Valve NG - IID W F 1G Combination Valve LPG - IID

49 PAGE 1233 PRODUCT DESCRIPTION - RAYPAK HEATERS R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 ( ) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1231 HEAT EXCHANGER ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W F 1H Heat Exchanger Assy. Complete Cast Iron R185 $ 2, W F 1H Heat Exchanger Assy. Complete Cast Iron R265 2, W F 1H Heat Exchanger Assy. Complete Cast Iron R335 2, W F 1H Heat Exchanger Assy. Complete Cast Iron R405 2, W F 1H Heat Exchanger Assy. Complete Brass R185 2, W F 1H Heat Exchanger Assy. Complete Brass R265 3, W F 1H Heat Exchanger Assy. Complete Brass R335 3, W F 1H Heat Exchanger Assy. Complete Brass R405 3, W F 2H Inlet/Outlet Header Cast Iron W F 2H Inlet/Outlet Header Brass W F 3H Return Header Cast Iron W F 3H Return Header Brass W F 4H Heat Exchanger (tube bundle) R185 1, W F 4H Heat Exchanger (tube bundle) R265 1, W F 4H Heat Exchanger (tube bundle) R335 1, W F 4H Heat Exchanger (tube bundle) R405 1, W F 5H Heat Exchanger Tube 1 R185 (single tube) W F 5H Heat Exchanger Tube 1 R265 (single tube) W F 5H Heat Exchanger Tube 1 R335 (single tube) W F 5H Heat Exchanger Tube 1 R405 (single tube) W F 6H Baffle Kit 8 R W F 6H Baffle Kit 8 R W F 6H Baffle Kit 8 R W F 6H Baffle Kit 8 R W F 7H Bolt Kit W B 8H Header Gasket (9) W B 9H Unitherm Governor W F 10H U. G. Retainer Spring W B 11H Bypass Valve W H Bypass Spring R W H Bypass Spring R265 - R335 - R W H Drain Valve W F 14H Sensor Well W H Well Retaining Clip W F 16H Inlet/Outlet Flange W B 17H Flange Gasket 1 1/2" Connection W B 17H Flange Gasket 2" Connection W F 18H Rear Drain Plug & Cover Control Box 39W B 1J Ignition Control IID - NG $ W B 1J Ignition Control IID - LPG W F 2J Transformer 120/240/24V W F 3J Rocker Switch MV W J Rocker Switch IID Models 6.62

50 PAGE 1234 PRODUCT DESCRIPTION - RAYPAK HEATERS R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 ( ) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1231 Miscellaneous Components ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W B 1M Pressure Switch $ W F 2M Pressure Switch Tube Assembly W M Thermostat Knob (1) W F 4M Knob Stop (1) W F 5M Thermal Fuse W F 6M PRV 125 PSI (optional ) R W F 6M PRV 125 PSI (optional ) R265 - R335 - R W F 7M Deliming Kit W F 8M Wire Harness - MV W F 8M Wire Harness - IID W---NLA F 9M LED's (2 green, 2 red) NLA 12W F 10M Control Panel - MV W F 11M Control Panel - IID (inc. switch decal) W F 12M Thermostat Knob Kit - MV W M Thermostat Shaft - IID W F 13M Thermostat Shaft - MV W F 14M CPVC Adapter PILOT 17W B 1P Pilot NG - MV $ W B 1P Pilot LPG - MV W F 3P Pilot NG/LPG - IID W F 5P Pilot Orifice NG - MV W F 5P Pilot Orifice LPG - MV W F 7P Pilot Orifice NG - IID W F 7P Pilot Orifice LPG - IID W B 9P Pilot Generator - MV W B 12P Ignition Control IID - NG W B 12P Ignition Control IID - LPG W P Pilot MTG Bracket - MV W P Pilot MTG Bracket - IID W P Lighter Tube (MV units only) W F 16P Pilot Tube W B 17P Hi Tension Wire - IID W F 17P Hi Tension Wire - IID with Pilot Electrode W P Pilot Shield 3.96 REFRACTORY 34W F 1R Refractory Common (left & right) $ W F 2R Refractory Uncommon (front & rear) W F 3R Refractory Retainer Kit R W F 3R Refractory Retainer Kit R W F 3R Refractory Retainer Kit R W F 3R Refractory Retainer Kit R

51 PAGE 1235 PRODUCT DESCRIPTION - RAYPAK HEATERS R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 ( ) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1231 SHEET METAL ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W F 1S Jacket Top (louvered) R185 $ W F 1S Jacket Top (louvered) R W F 1S Jacket Top (louvered) R W F 1S Jacket Top (louvered) R W F 2S Flue Collector R W F 2S Flue Collector R W F 2S Flue Collector R W F 2S Flue Collector R W F 3S Door Assembly R W F 3S Door Assembly R W F 3S Door Assembly R W F 3S Door Assembly R W F 4S Acess Panel Set (3 pieces) W F 5S Side Panel Right W F 6S Side Panel Left W F 7S Side Panel Cap W F 8S Rear Panel Kit (2 pieces) R W F 8S Rear Panel Kit (2 pieces) R W F 8S Rear Panel Kit (2 pieces) R W F 8S Rear Panel Kit (2 pieces) R W-Quote S Sub-Base For Combustible Flooring R185 QUOTE 22W-Quote S Sub-Base For Combustible Flooring R265 QUOTE 23W-Quote S Sub-Base For Combustible Flooring R335 QUOTE 24W-Quote S Sub-Base For Combustible Flooring R405 QUOTE 25W F 10S High Limit Cover W S Poolstat Cover/Lock W F 12S Up Front Control Panel R W F 12S Up Front Control Panel R W F 12S Up Front Control Panel R W F 12S Up Front Control Panel R VENTING 31W-Quote V Indoor Stack (includes inner adapter panel) R185 $ QUOTE 32W-Quote V Indoor Stack (includes inner adapter panel) R265 QUOTE 33W-Quote V Indoor Stack (includes inner adapter panel) R335 QUOTE 34W-Quote V Indoor Stack (includes inner adapter panel) R405 QUOTE 35W-Quote V "Pagoda" Top R185 QUOTE 36W-Quote V "Pagoda" Top R265 QUOTE 37W-Quote V "Pagoda" Top R335 QUOTE 38W-Quote V "Pagoda" Top R405 QUOTE CONVERSION KITS 39W B NG to LPG MV Pilot R185 - R265 $ W B NG to LPG MV Pilot R335 - R W F LPG to NG MV Pilot R185 - R W F LPG to NG MV Pilot R335 - R

52 PAGE 1236 PRODUCT DESCRIPTION - RAYPAK HEATERS 206A, 266A, 366A, 406A RAYPAK HEATER MODELS 206A - 266A - 366A - 406A Current

53 PAGE 1237 PRODUCT DESCRIPTION - RAYPAK HEATER 206A, 266A, 366A, 406A RAYPAK HEATER MODELS 206A - 266A - 366A - 406A Current ILLUSTRATED PARTS BREAKDOWN ON PAGE 1236 BURNER TRAY ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W F 1B Burner Tray with Gas Valve NG - MV 206A $ 1, W F 1B Burner Tray with Gas Valve NG - MV 266A 1, W F 1B Burner Tray with Gas Valve NG - MV 336A 1, W F 1B Burner Tray with Gas Valve NG - MV 406A 2, W F 1B Burner Tray with Gas Valve LP - MV 206A 1, W F 1B Burner Tray with Gas Valve LP - MV 266A 1, W F 1B Burner Tray with Gas Valve LP - MV 336A 1, W F 1B Burner Tray with Gas Valve LP - MV 406A 2, W F 1B Burner Tray with Gas Valve NG - IID 206A 1, W F 1B Burner Tray with Gas Valve NG - IID 266A 1, W F 1B Burner Tray with Gas Valve NG - IID 336A 2, W F 1B Burner Tray with Gas Valve NG - IID 406A 2, W F 1B Burner Tray with Gas Valve LP - IID 206A 1, W F 1B Burner Tray with Gas Valve LP - IID 266A 1, W F 1B Burner Tray with Gas Valve LP - IID 336A 1, W F 1B Burner Tray with Gas Valve LP - IID 406A 2, W F 2B Burner Spacer / Hold Down Kit 206A W F 2B Burner Spacer / Hold Down Kit 266A W F 2B Burner Spacer / Hold Down Kit 336A W F 2B Burner Spacer / Hold Down Kit 406A W B Burner 206A (13 required) W B Burner 266A (18 required) W B Burner 336A (22 required) W B Burner 406A (27 required) W F 4B Burner Orifice NG #50 206A (13 required) W F 4B Burner Orifice NG #50 266A (18 required) W F 4B Burner Orifice NG #50 336A (22 required) W F 4B Burner Orifice NG #50 406A (27 required) W F 4B Burner Orifice LP #57 206A (13 required) W F 4B Burner Orifice LP #57 266A (18 required) W F 4B Burner Orifice LP #57 336A (22 required) W F 4B Burner Orifice LP #57 406A (27 required) W F 5B Burner Tray w/o Manifold w/o Burners 206A W F 5B Burner Tray w/o Manifold w/o Burners 266A W F 5B Burner Tray w/o Manifold w/o Burners 336A W F 5B Burner Tray w/o Manifold w/o Burners 406A CONTROLS 37W F 1C Thermostat Auto Reset Surface Mount $ W B 2C AGS (auto gas shut-off) Red Epoxy W B 3C High Limit Black Epoxy W F 4C P.C. Board / Controls IID Units W F 5C Thermostat Control MV Units Mechanical W F 6C Temperature Sensor IID Units W-Quote F 7C LCD Display (MFG from 5/2011) QUOTE GAS VALVE 44W F 1G Combination Valve NG - MV $ W F 1G Combination Valve LP - MV W F 1G Combination Valve NG - IID W F 1G Combination Valve LP - IID For product info., see page 289 in the product section.

54 PAGE 1238 PRODUCT DESCRIPTION - RAYPAK HEATER 206A, 266A, 366A, 406A RAYPAK HEATER MODELS 206A - 266A - 366A - 406A continued Current ILLUSTRATED PARTS BREAKDOWN ON PAGE 1236 HEAT EXCHANGER ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W F 1HP Heat Exchanger Assy. Copper 206A $ 2, W F 1HP Heat Exchanger Assy. Copper 266A 2, W F 1HP Heat Exchanger Assy. Copper 336A 2, W F 1HP Heat Exchanger Assy. Copper 406A 2, W F 1HP Heat Exchanger Assy. Cupro Nickel 206A 3, W F 1HP Heat Exchanger Assy. Cupro Nickel 266A 3, W F 1HP Heat Exchanger Assy. Cupro Nickel 336A 3, W F 1HP Heat Exchanger Assy. Cupro Nickel 406A 3, W F 2HP Inlet/Outlet Header Complete W F 2HP Inlet/Outlet Header (includes flange nut kit) W F 3HP Return Header (includes flange nut kit) W F 4HP Tube Bundle Copper 206A W F 4HP Tube Bundle Copper 266A 1, W F 4HP Tube Bundle Copper 336A 1, W F 4HP Tube Bundle Copper 406A 1, W F 4HP Tube Bundle Cupro Nickel 206A 1, W F 4HP Tube Bundle Cupro Nickel 266A 1, W F 4HP Tube Bundle Cupro Nickel 336A 2, W F 4HP Tube Bundle Cupro Nickel 406A 2, W F 5HP Baffle W F 5HP Baffle W F 5HP Baffle W F 5HP Baffle W F 6HP Flange Nut Kit W F 7HP O-Ring Gasket (2) W F 8HP Sensor Adapter Digital Electronic W F 8HP Sensor Well Millivolt W F 9HP Bypass Kit W F 10HP Bypass Valve W F 11HP Bypass Dam / Shaft W F 12HP Bypass Spring (all sizes included) W F 13HP Unitherm Governor W F 14HP Unitherm Governor Plug W F 15HP Drain Plug W F 16HP Inlet / Outlet Header Dam W F 17HP 2 PVC Connector & Nut (2) W F 18HP O-Ring (2) W F 19HP Baffle S/S CONTROL BOX 39W F 1J Transformer 120/240/24V $ W F 2J Rocker Switch MISCELLANEOUS COMPONENTS 41W F 1M Pressure Switch 1.75 PSI $ W F 2M Thermostat Knob 6.62 For product info., see page 289 in the product section.

55 PAGE 1239 PRODUCT DESCRIPTION - RAYPAK HEATER 206A, 266A, 366A, 406A RAYPAK HEATER MODELS 206A - 266A - 366A - 406A continued Current ILLUSTRATED PARTS BREAKDOWN ON PAGE 1236 MISCELLANEOUS COMPONENTS continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W F 4M Knob Stop $ W F 5M Thermal Fuse W F 6M PRV 125 PSI (optional) 206A W F 6M PRV 125 PSI (optional) 266A, 336A, 406A W F 7M Deliming Kit W F 8M Wire / Harness Millivolt W F 8M Wire / Harness IID W F 9M Control Bezel MV (includes dial decal) W F 10M Dial Decal MV W F 11M Control Bezel IID (includes switch decal)(from 5/11) W-Quote F 11M Control Bezel IID (includes switch decal)(prior to 5/11) QUOTE 12W-Quote F 12M Switch / Decal Membrane (Mfg from 5/11) QUOTE 11W F 12M Switch / Decal Membrane(Mfg prior to 5/11) W F 13M Control Bezel Cover W F 14M Gasket Insulation (swaybrace and jacket top) W M Touch-Up Paint - Green PILOT 15W B 1P Pilot NG - MV $ W B 1P Pilot NG - MV W F 2P Pilot NG & LP IID W F 3P Pilot Orifice NG - MV W F 3P Pilot Orifice LP - MV W F 4P Pilot Orifice NG - IID W F 4P Pilot Orifice LP - IID W B 5P Pilot Generator MV W F 6P Pilot Mounting Bracket - MV W P Pilot Mounting Bracket - IID W P Lighter Tube (MV units only) W F 9P Pilot Tube W F 10P Hi Tension Wire IID with Pilot Electrode W F 11P Pilot Shield 9.26 REFRACTORY 29W F 1R Refractory Common Lt. & Rt. $ W F 2R Refractory Uncommon (front and rear) W F 3R Refractory Retainer Kit 206A W F 3R Refractory Retainer Kit 266A W F 3R Refractory Retainer Kit 336A W F 3R Refractory Retainer Kit 406A SHEETMETAL 35W F 1S Jacket Top (louvered) 206A $ W F 1S Jacket Top (louvered) 266A W F 1S Jacket Top (louvered) 336A W F 1S Jacket Top (louvered) 406A For product info., see page 289 in the product section.

56 PAGE 1240 PRODUCT DESCRIPTION - RAYPAK 206A, 266A, 366A, 406A HEATERS RAYPAK HEATER MODELS 206A - 266A - 366A - 406A continued Current ILLUSTRATED PARTS BREAKDOWN ON PAGE 1236 SHEETMETAL continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W F 2S Flue Collector (units w/ polymer headers) 206A $ W F 2S Flue Collector (units w/ polymer headers) 266A W F 2S Flue Collector (units w/ polymer headers) 336A W F 2S Flue Collector (units w/ polymer headers) 406A W F 2S Flue Collector (units w/ metal headers) 206A W F 2S Flue Collector (units w/ metal headers) 266A W F 2S Flue Collector (units w/ metal headers) 336A W F 2S Flue Collector (units w/ metal headers) 406A W F 3S Door Assembly 206A W F 3S Door Assembly 266A W F 3S Door Assembly 336A W F 3S Door Assembly 406A W F 4S Access Panel Set 3 pc (units w/polymer header) W F 4S Access Panel Set 3 pc (units w/metal header) W F 5S Jacket Side Panel Right W F 6S Jacket Side Panel Left W F 7S Jacket Rear Panel 206A W F 7S Jacket Rear Panel 266A W F 7S Jacket Rear Panel 336A W F 7S Jacket Rear Panel 406A W S Poolstat Cover/Lock W F 9S High Limit Cover W F 10S Base Heat Shield W F 11S Up Front Control Panel 206A W F 11S Up Front Control Panel 266A W F 11S Up Front Control Panel 336A W F 11S Up Front Control Panel 406A W F 12S High Limit Shield W F 13S Weather Shield 206A W F 13S Weather Shield 266A W F 13S Weather Shield 336A W F 13S Weather Shield 406A VENTING 33W V Indoor Stack Kit (includes inner adapter panel) 206A $ W V Indoor Stack Kit (includes inner adapter panel) 266A W V Indoor Stack Kit (includes inner adapter panel) 336A W V Indoor Stack Kit (includes inner adapter panel) 406A W F 2V Stack Adapter W V Pagoda Top 206A W V Pagoda Top 266A W V Pagoda Top 336A W V Pagoda Top 406A CONVERSION KITS 42W B ** NG to LP - MV Pilot 206A and 266A $ W B ** NG to LP - MV Pilot 336A and 406A W F ** LP to NG - MV Pilot 206A and 266A W F ** LP to NG - MV Pilot 336A and 406A For product info., see page 289 in the product section.

57 PAGE 1241 PRODUCT DESCRIPTION - RAYPAK 055B HEATER RAYPAK HEATER MODEL 055B (1989-CURRENT)

58 PAGE 1242 PRODUCT DESCRIPTION - RAYPAK HEATER MODEL 055B RAYPAK HEATER MODEL 055B (1989-CURRENT) ILLUSTRATED PARTS BREAKDOWN ON PAGE 1241 BURNER TRAY ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W F 1B Burner Tray w/burners (sea level) $ W B Burner (4 required) W F 3B Burner Orifice #52 NG (4 required) W F 3B Burner Orifice #62 LPG (4 required) 5.28 CONTROLS 05W B 1C High Limit $ W B 2C High Limit W F 3C Thermostat Control MV (mechanical) W F 8C Thermostat Control MV (solid state) W B 5C PC Board W B 6C Potentiometer W B 7C Temperature Sensor W F 9C Thermostat Control IID (solid state) W B 4C PC Board GAS VALVE 14W F 1G Combination Valve NG - MV $ W F 1G Combination Valve LPG - MV W F 1G Combination Valve NG - IID W F 1G Combination Valve LPG - IID HEAT EXCHANGER 18W F 1H Heat Exchanger Assembly Complete $ W F 2H Heat Exchanger (tubed kit) W F 3H Baffle Kit W H Unitherm Governor W H U. G. Cap W H U. G. Spring W F 7H Drain Valve W F 8H Sensor Well W H Bulb Retainer Clip W H U. G. Gasket W H Bypass Baffle W F 11H Inlet/Outlet Flange W B 12H Flange Gasket 9.26 CONVERSION KITS IID Units Not Available 31W B NG to LPG MV Units $ W B LPG to NG MV Units For product info., see page 288 in the product section.

59 PAGE 1243 PRODUCT DESCRIPTION - RAYPAK HEATER MODEL 055B RAYPAK HEATER MODEL 055B (1989-CURRENT) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1241 PILOT ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W B 1P Pilot NG - MV $ W B 1P Pilot LPG - MV W F 3P Pilot NG - IID W F 3P Pilot LPG - IID W F 5P Pilot Orifice NG - MV W F 5P Pilot Orifice LPG - MV W F 5P Pilot Orifice NG - IID W F 5P Pilot Orifice LPG - IID W B 9P Pilot Generator MV W B 11P Ignition Control NG - IID W B 11P Ignition Control LPG - IID W F 12P Pilot Mounting Bracket - IID W F 13P Pilot Mounting Bracket - MV W F 14P Pilot Tube W B 15P Hi Tension Wire - IID REFRACTORY AND SHEET METAL 16W F 1R Refractory Block Kit $ W F 1S Jacket Top W F 2S Flue Collector W F 3S Door Assembly W F 4S Upper Jacket Control Panel W S Wiring Box W S Thermostat Lock/Cover VENTING 23W V Stackless Top (outdoor) $ W V Drafthood (indoor) MISCELLANEOUS COMPONENTS 25W B 1M Pressure Switch $ W F 2M Pressure Switch Tube Assembly W F 3M Thermostat Knob W F 4M Knob Stop W M Dial Plate - MV W M Dial Plate - IID W F 6M Transformer IID Unit (old #005345F) W M Toggle Switch W F 8M Wire Harness - MV W F 8M Wire Harness - IID W F 9M Thermal Fuse For product info., see page 288 in the product section.

60 PAGE 1244 PRODUCT DESCRIPTION - RAYPAK MODEL 105B CAST IRON HEATER RAYPAK HEATER MODEL 105B CAST IRON

61 PAGE 1245 PRODUCT DESCRIPTION - RAYPAK HEATER MODEL 105B CAST IRON RAYPAK HEATER MODEL 105B CAST IRON (1999-CURRENT) ILLUSTRATED PARTS BREAKDOWN ON PAGE 1244 BURNER TRAY ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W F 1B Burner Tray with Burners (sea level) $ W B Burner (8 required) W F 3B Burner Orifice NG #51 (sea level) (8 required) W F 3B Burner Orifice LPG #59 (sea level) (8 required) 5.28 CONTROLS 05W F 1C Thermostat (hi limit) $ W F 2C Thermostat Control GAS VALVE 07W F 1G Combination Valve NG - MV $ W F 1G Combination Valve LPG - MV W F 1G Combination Valve NG - IID W F 1G Combination Valve LPG - IID HEAT EXCHANGER 11W F 1H Heat Exchanger Assembly Complete $ W F 2H Inlet/Outlet Header W F 3H Heat Exchanger (tube bundle) W F 4H Baffle Kit W F 5H Bolt Kit W F 6H Header Gasket (4) W B 7H Bypass Valve W H Bypass Spring W H Well Retaining Clip 1.32 MISCELLANEOUS COMPONENTS 20W F 1M Pressure Switch $ W F 2M Thermostat Knob W F 3M Knob Stop W F 4M Dial Plate MV W F 4M Dial Plate IID W F 5M Transformer IID Unit W F 6M Rocker Switch (SPST) W F 7M Wire Harness MV (not shown) W F 7M Wire Harness IID (not shown) W F 8M Deliming Kit (not shown) W F 9M Thermal Fuse W F 10M Bezel (less label) 27.76

62 PAGE 1246 PRODUCT DESCRIPTION - RAYPAK HEATER MODEL 105B CAST IRON RAYPAK HEATER MODEL 105B CAST IRON (1999-CURRENT) continued ILLUSTRATED PARTS BREAKDOWN ON 1244 PILOT ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W B 1P Pilot NG - MV $ W B 1P Pilot LPG - MV W F 3P Pilot NG/LPG - IID W F 5P Pilot Orifice NG - MV W F 5P Pilot Orifice LPG - MV W F 7P Pilot Orifice NG - IID W F 7P Pilot Orifice LPG - IID W B 9P Pilot Generator MV W B 11P Ignition Control NG - IID W B 11P Ignition Control LPG - IID W F 12P Pilot Mounting Bracket MV W F 13P Pilot Mounting Bracket IID W F Pilot Tube W B 15P Hi Tension Wire IID W F 15P Hi Tension Wire w/pilot Electrode REFRACTORY AND SHEETMETAL COMPONENTS 16W F 1R Refractory Block Kit $ W F 1S Jacket Top W F 2S Flue Collector W F 3S Door Assembly W F 4S Upper Jacket Control Panel W S Wiring Box W F 6S Access Panel (inlet/outlet end) VENTING 23W F 1V Outdoor Stackless Top $ W V Indoor Drafthood W V Outdoor Stack with Adapter W-Quote V Outdoor Stack QUOTE CONVERSION KITS 27W B NG to LPG MV Units $ W B LPG to NG MV Units W F NG to LPG IID Units W F LPG to NG IID Units

63 PAGE 1247 PRODUCT DESCRIPTION - RAYPAK RP2100 HEATER RAYPAK RP2100 HEATER Model P-R185A to P-R335A ( THROUGH 2003) 3-P 14-P 1-P 15-P 9-P 1-P 15-P 3-P 9-P 7-P 16-P Honeywell IID 13-P 13-P 14-P 16-P 16-P Honeywell MV 16-P 5-P 5-P 17-P 7-P Robertshaw MV Robertshaw IID

64 PAGE 1248 PRODUCT DESCRIPTION - RAYPAK RP2100 HEATER RAYPAK RP2100 HEATER Model P-R185A to P-R335A ( THROUGH 2003) ILLUSTRATED PARTS BREAKDOWN ON PAGE 1247 ITEM NO. KEY DESCRIPTION SUGG. LIST 01W-Quote B Burner Tray (specify model) $ QUOTE 02W-Quote B Burner Spacer/Hold Down Kit (specify model) QUOTE 03W B Burner W F 4B Burner Orifice - NG W F Burner Orifice - LP W-Quote B Burner Tray w/o Manifold & Burners QUOTE 07W F 1C Thermostat Auto Reset, 135 Deg W B 2C Auto Gas Shut-Off, 135 Deg. Red Epoxy W B 3C High Limit, 140 Deg. Black Epoxy W F 4C PC Board/Control, Electronic W F 5C Thermostat Control - MV W F 6C Temperature Sensor - Electronic W F 1G Combination Valve NG - MV W F Combination Valve LP - MV W F Combination Valve NG - Electronic W F Combination Valve LP - Electronic W F 1HP Heat Exchanger Assy. Complete , W F Heat Exchanger Assy. Complete , W F Heat Exchanger Assy. Complete , W F Heat Exchanger Assy. Complete , W F 2HP Inlet/Outlet Header with Gaskets W F 3HP Return Header with Gaskets W F 4HP Heat Exchanger (tube bundle) , W F Heat Exchanger (tube bundle) , W F Heat Exchanger (tube bundle) , W F Heat Exchanger (tube bundle) , W F 5HP Bolt Kit W F 6HP O-Ring Gaskets W F 7HP Sensor Adapter Digital - Electronic W F Sensor Well - MV W F 8HP Bypass Kit W F 9HP Bypass Valve W F 10HP Bypass Dam/Shaft W F 11HP Bypass Springs (all sizes incl.) W F 12HP Unitherm Governor W F 13HP Unitherm Governor Plug W F 14HP Drain Plug W---NLA HP Inlet/Outlet Header Dam (Sub F Kit) NLA 39W F 16HP 2" PVC Connector & Nut (2) W F 17HP O-Ring (2) W F 18HP Header Baffle W B 1J Ignition Control NG - Electronic W B Ignition Control LP - Electronic W F 2J Transformer, 120/240/24V W F 3J Rocker Switch 15.86

65 PAGE 1249 PRODUCT DESCRIPTION - RAYPAK RP2100 HEATER RAYPAK RP2100 HEATER CONTINUED Model P-R185A to P-R335A ( THROUGH 2003) ILLUSTRATED PARTS BREAKDOWN ON PAGE 1247 ITEM NO. KEY DESCRIPTION SUGG. LIST 01W F 1M Pressure Switch $ W M Thermostat Knob W F 4M Knob Stop W F 5M Thermal Fuse W F 6M Pressure Relief Valve, 125 PSI W F 8M Wire Harness - MV W F Wire Harness - Electronic W F 9M Control Panel - MV W F 10M Control Panel - Electronic W M Thermostat Shaft, MV W B 1P Pilot NG - MV W B Pilot LP - MV W F 3P Pilot NG/LP - Electronic (after 6/1/2000) W F 5P Pilot Orifice NG - MV W F Pilot Orifice LP - MV W F 7P Pilot Orifice NG - Electronic W F Pilot Orifice LP - Electronic W B 9P Pilot Generator - MV W B 12P Ignition Control NG - Electronic W B Ignition Control LP - Electronic W P Pilot Bracket - MV W P Pilot Bracket - Electronic W P Lighter Tube - MV W F 16P Pilot Tube W F 17P High Tension Wire - IID w/pilot Electrode W P Pilot Shield W F 1R Refractory Common (left & right) W-Quote R Refractory Uncommon (specify model) QUOTE 29W-Quote R Refractory Retainer Kit (specify model) QUOTE 30W-Quote S Jacket Top (specify model) QUOTE 31W-Quote S Flue Collector (specify model) QUOTE 32W-Quote S Door Assembly (specify model) QUOTE 33W F 4S Screw & Retainer W F 5S Access Panel Set (3) W F 6S Side Panel, Right W F 7S Side Panel, Left W F 8S Side Panel Cap W-Quote S Rear Panel Kit (specify model) QUOTE 39W-Quote S Sub Base for Combust. Floor (specify model) QUOTE 40W S Poolstat Cover/Lock W F 12S High Limit Cover W B Conversion Kit - MV, NG to LP W F Conversion Kit - MV, LP to NG

66 PAGE 1250 PRODUCT DESCRIPTION - RAYPAK VERSA HEATER MODEL 155C RAYPAK VERSA HEATER Model 155C ( THROUGH )