In This Section Combi Controls M-A-P M-A-X Electric Combi Steamer HME 061 M-1-E Gas Combi Steamer HMG 061 M-1-G...

Transcription

1 M Combi Steamers In This Section Combi M-A M-A Electric Combi Steamer HME 061 M-1-E Gas Combi Steamer HMG 061 M-1-G Electric Combi Steamer HME 072 M-2-E Gas Combi Steamer HMG 072 M-2-G Electric Combi Steamer HME 101 M--E Gas Combi Steamer HMG 101 M--G Electric Combi Steamer HME 102 M-4-E Gas Combi Steamer HMG 102 M-4-G Electric Combi Steamer HME 142 M-5-E Gas Combi Steamer HMG 142 M-5-G Electric Combi Steamer HME 201 M-6-E Gas Combi Steamer HMG 201 M-6-G Electric Combi Steamer HME 202 M-7-E Gas Combi Steamer HMG 202 M-7-G...294

2 Combi Version VERSION Manual controls with electronic control, programmability of 91 cooking programs of 9 cycles each for sequencial cooking, three Regenerating programs are available with one modifiable, numerical displays, Autoclima with Fast- Dry, automatic vent, self-diagnosis, automatic reverse (distribution of the air in the chamber with automatic reversing of the fan direction), cavity fast cooling with open door, humidifi er and cavity lights. OTIONAL: core probe, hand shower, automatic washing system WCS (Washing Combi System) OERATING MODES Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F Reheating with Autoclima 248 F F Automatic sequence cooking Temperature hold with Autoclima function OERATIONAL FUNCTIONS Electronic and programmable control panel with pushbuttons for manual functions Self-diagnosis at the start of the unit with fault display and alarm Cooking modes choice with display of pre-set time and temperature rogrammability of 91 cooking programs of 9 cycles each for sequencial cooking; three Regenerating programs are available with one modifiable Cook & Hold mode controlled by the meat probe or by the timer Autoreversing fan rotation Cavity fast cool down with automatic stop at 122 F Automatic cavity cooling between a high temperature cycle and the next cycle featuring a lower temperature Manual humidifier AUTOCLIMA system to control the percentage of humidity during the cooking and food rethermalisation FAST-DRY cavity vent for a fast evacuation of moisture Timed oven lights with halogen lamps positioned between the inner & outer doors Automatic boiler pre-heating Cavity clean program CL Boiler De-scaling program DE Boiler De-scale alarm Automatic boiler drain (with controlled water temperature) and rinsing Automatic quenching of vapours into the oven drain Check of cavity steam saturation with automatic energy saving Easily accessible Service program for: C board diagnosis, Check of internal probes, Check of cavity and boiler operating hours M-A- 00 S. 84th Avenue hone: Fax:

3 01/02/06 re-heat the oven VERSION Electronic control panel with high definition colour liquid crystal display (LCD) and Touch Screen technology. SCROLLER LUS with ush function to confi rm settings. ICS Interactive Cooking System. AUTOCLIMA with FAST DRY and automatic vent. Six-speed fan, autoreverse (distribution of the air in the cavity with automatic reversing of fan direction). Multipoint core temperature sensor. ush buttons for: humidifier, cavity fast cooling with open door, FAST DRY and cavity lights. OTIONAL: self wash WCS (Washing Combi System) OERATING MODES Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start 267 M-A MANUAL ROGRAMS Cooking Interactive FAVORITES? ETRA 00 S. 84th Avenue hone: Fax: Combi Version OERATIONAL FUNCTIONS Electronic control panel with high defi nition colour liquid crystal display (LCD - TFT) and Touch Screen technology SCROLLER LUS with ush function to confi rm settings ush buttons for manual functions Self-diagnosis at the start of the unit with displayed faults and alarms Sequencial cooking with up to 15 cycles Cooking modes choice with display of pre-set time and temperature rogrammability of 400 cooking programs (15 cycles each) with displayed recipe name ICS Interactive Cooking System: automatic cooking made available by iper chefs and easily available for the user Choice of 6 fan speeds and intermittent fan mode; three lower speeds enable a reduced heating suitable for slow cooking programs Autoreverse: distribution of the air in the cavity with automatic reversing of fan direction ETRA cooking functions: Cook & Hold controlled by the meat probe or by timer, Multilevel cooking, Reheating of plated meals or pans, Defrosting LUS: timer of cooking in progress, DELTA T cooking, vent programmability, fan programmability, Hold and Finishing Multipoint core temperature sensor Interchangeable meat probes (Multipoints or needle for vaccum packs) with external socket Cavity fast cool down with stop at 122 F Automatic cavity cooling between a high temperature cycle and the next cycle featuring a lower temperature Manual humidifier AUTOCLIMA system to control the percentage of humidity during the cooking and food rethermalisation rogrammable and automatic cavity vent system with FAST DRY for a quick evacuation of moisture Timed oven lights with halogen lamps positioned between the inner & outer doors Automatic boiler pre-heat Automatic boiler drain (with controlled water temperature at 140 F) and rinsing Automatic quenching of vapours into the oven drain Check of cavity steam saturation with automatic energy saving rogrammable delayed (over 24 hours) start of the oven Multiple languages choice for menues and messages Easily accessible software parameters for personalized oven pre-setting USB port for software and recipe upload and for download of HACC recorded datas and recipes SERVICE program for: C board auto-test, check of internal probes setting, check of cavity and boiler operating hours for a programmed maintenance, boiler De-scaling program rogram for manual cavity clean LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes.

4 Electric Combi Steamer HME 061 JOB ITEM # QTY # MODEL NUMBER With Boiler Without Boiler HME 061 HVE 061 HME 061 HVE 061 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Fan motor thermic protection Magnetic door switch Boiler water level probes (Boiler Unit Only) Lack of water displayed alarm Displayed diagnostic (specific for "" controls) Component cooling system COntrols HME 061 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with trapezium shape, long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service AISI 04 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 6-12x20 steam table pans; 2.76" shelf spacing High quality world wide available components ELECTRIC HEATING SYSTEM Cavity heating elements of armoured INCOLOY 800 type Steam generator heating elements of armoured INCOLOY 800 type Energy Saving device for reduced energy consumption Additional Construction Details For () Control Built-in and retractable hand shower with tap External connection for meat probe CAACITY With side racks: 6-12x20 steam table pan and 2.76" shelf spacing With rack SG061: 6-12x20 steam table pan and 2.56" shelf spacing With plated meals rack R061: 14 plates (12.20") at 2.28" distance OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Chamber heating output Steam heating output Fan power ower supply voltage 6.61"W x 29.5"D x 1.89"D 11 lbs 8,000 Watts 7,500 Watts 7,500 Watts 500 Watts ph/208v/60 hz M-1-E 00 S. 84th Avenue hone: Fax:

5 HME Electric Combi Steamer HME N AC 400 Voltage AC 20 Voltage AC 20 Voltage N AC 400 Voltage Automatic washing WCS (Washing Combi System) KL061 Cavity self 4.65 wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD Stainless steel trolley to hold washing kit CD Two step safety door handle mechanism Right hinged door S001 Special and marine voltages LG version Removable rack SG061 lated meals rack R061 Thermal cover C061 Trolleys CR061 Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Fat filter F061 Standard core probe SC with Extraction hood with steam condenser HKA061 Stands SR061 - S061 Shelf for cleanser tank KD061 Holding cabinets AC061 - MA061 Cabinet AN061 Connection for an external printer (type RS 22) Connection for Energy Saving System SN M-1-E 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 269

6 Gas Combi Steamer HMG 061 COntrols Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with trapezium shape, long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation. Hinged inner glass for cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service AISI 16 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 6-12x20 steam table pans; 2.76" shelf spacing High quality world wide available components Additional Construction Details For () COntrol Built-in and retractable hand shower with tap External connection for meat probe GAS HEATING SYSTEM Blown air type for the cavity burner and boiler heating system (Boiler system on HMG models only) Automatic flame ignition with electronic flame control; automatic ignition re-set and diagnosis with display fault Energy Saving device for reduced energy consumption High efficiency heat exchanger with expansion cabinet of steel AISI 10 S CAACITY With side racks: 6-12x20 steam table pans and 2.76" shelf spacing With rack SG061: 6-12x20 steam table pans and 2.56" shelf spacing With plated meals rack R061: 14 plates (12.20") at 2.28" distance JOB ITEM # QTY # MODEL NUMBER With Boiler Without Boiler HMG 061 HVG 061 HMG 061 HVG 061 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Flame detection sensor Low gas pressure switch Fan motor thermic protection Magnetic door switch HMG 061 Boiler water level probes (Boiler Unit Only) (Shown with controls) Lack of water displayed alarm Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Nominal heating output Chamber heating output Steam heating output Fan power ower supply voltage 6.61"W x 29.5"D x 1.89"H 64 lbs. 500 Watts 14,000 Watts / 47,767 BTU's 10,000 Watts / 4,119 BTU's 10,000 Watts / 4,119 BTU's 250 Watts 1ph/120v/60hz M-1-G 00 S. 84th Avenue hone: Fax:

7 Gas Combi Steamer HMG G / / AC 120 Voltage AC 120 Voltage Automatic washing WCS (Washing Combi System) KL061 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Two step safety door handle mechanism Right hinged door S001 Special and marine voltages LG version Removable rack SG061 lated meals rack R061 Thermal cover C061 Trolleys CR Fat filter F061 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA061 Stands SR061 - S061 Shelf for cleanser tank KD061 Holding cabinets AC061 - MA061 Cabinet AN061 Connection for an external printer (type RS 22) Connection for Energy Saving System SN M-1-G 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 271

8 Electric Combi Steamer HME 072 COntrols Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for perfect cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service and check component AISI 04 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 20-12x20 steam table pans or 10-18x26 sheet pans; 2.76" shelf spacing High quality world wide available components Additional Construction Details For () COntrol Built-in and retractable hand shower with tap External connection for meat probe ELECTRIC HEATING SYSTEM Cavity heating elements of armoured INCOLOY 800 type Steam generator heating elements of armoured INCOLOY 800 type Energy Saving device for reduced energy consumption CAACITY With side racks: 14-12x20 steam table pans or 7-18x26 sheet pans; 2.76" shelf spacing With rack SG072: 14-12x20 steam table pans or 7-18x26 sheet pans; 2.56" shelf spacing With plated meals rack R072: 4 plates (12.20") at 2.68" distance JOB ITEM # QTY # MODEL NUMBER With Boiler HME 072 HME 072 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Fan motor thermic protection Magnetic door switch Boiler water level probes (Boiler Unit Only) Lack of water displayed alarm HME 072 Displayed diagnostic (Shown with controls) Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Chamber heating output Steam heating output Fan power ower supply voltage Without Boiler HVE 072 HVE "W x 5.24"D x 4.65"D 452 lbs. 16,000 Watts 15,000 Watts 15,000 Watts 1,000 Watts ph/208v/60 hz M-2-E 00 S. 84th Avenue hone: Fax:

9 1 1,7 4,6" Electric Combi Steamer HME 072 5,1" 5," 1,8" 5,6" 4,1" 46,1" AC 208 V AC 480 V 4,6 1,8 " 1,9" 29,5" 2,8 4,6" 5, 5,1" 5," 1,8" 5,6" 4,1" 46,1" 4,6 1,8 " AC 208 V AC 480 V 10,2 1,9" 29,5" 4,6 1" 1,7 2,8 2,4,1 2 1,7 Ø 129 7,1" 4,1" 5,5" 40" ABOVE THE ALIANCE 65,4" 1" 46,1" 10,2 1,9" 29,5" 4,6 1" 1,7 2,8 2,4,1 2 1, ,1" 5,5" 65,4" 1" 20" " Ø 7,1" 40" ABOVE THE ALIANCE Automatic washing WCS (Washing Combi System) KL072 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Two step safety door handle mechanism Right hinged door S001 Special and marine voltages Removable rack SG072 lated meals rack R072 Thermal cover C072 Trolleys CR07 Fat filter F072 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA102 Stands SR102 - S102 Shelf for cleanser tank KD102 Holding cabinets AC102 - MA102 Cabinet AN102 Connection for an external printer (type RS 22) Connection for Energy Saving System SN USB Key With Software Update M-2-E 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 27

10 Gas Combi Steamer HMG 072 JOB ITEM # QTY # COntrols HMG 072 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation. Hinged inner glass for perfect cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service and check component AISI 16 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 20-12x20 steam table pans or 10-18x26 sheet pans; 2.76" shelf spacing High quality world wide available components Additional Construction Details For () COntrol Built-in and retractable hand shower with tap External connection for meat probe GAS HEATING SYSTEM Blown air type for the cavity burner and boiler heating system (Boiler system on HMG models only) Automatic flame ignition with electronic flame control; automatic ignition re-set and diagnosis with display fault Energy Saving device for reduced energy consumption High efficiency heat exchanger with expansion cabinet of steel AISI 10 S Capacity With side racks: 7-18x26 sheet pans or 14-12x20 steam table pans and 2.76" shelf spacing With rack SG072: 7-18x26 sheet pans or 14-12x20 steam table pans and 2.56" shelf spacing With plated meals rack R072: 4 plates (12.20") at 2.68" distance MODEL NUMBER With Boiler HMG 072 HMG 072 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Flame detection sensor Low gas pressure switch Fan motor thermic protection Magnetic door switch Boiler water level probes (Boiler Unit Only) Lack of water displayed alarm Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Nominal heating output Chamber heating output Steam heating output Fan power ower supply voltage Without Boiler HVG 072 HVG "W x 5.24"D x 4.65"H 529 lbs. 1,000 Watts 28,000 Watts / 95,500 BTU's 18,000 Watts / 62,000 BTU's 18,000 Watts / 62,000 BTU's 1,000 Watts 1ph/120v/60hz M-2-G 00 S. 84th Avenue hone: Fax:

11 ,1" 9 1" 14,1" 4,6" 5, 46" 9,1" Ø 5,9" 1, 7,1" 7,9" 1,4" 4,6" 7,1" 10, 9, 75 29,5" 4,1" 1,9" 5,,7" 1,8" 1,4" 4,1" 2,4",1 2,4" 2," 5, 7,1" 1" 2,8" 46" (HVG) 9, 10" Ø 5,9" 1,6" 5,4" 2,4" 2," AC 120 V 7,1" 1,4" 1, 4,1" 1,4" 9,7" 1,8" 1/ 7,1" mm Gas Combi Steamer HMG ,5" 1,4" 10, 9, 4,1" 1,9",7" 1,8" 1,4" 4,1" 2,4",1 2,4" 2," 1" 2,8" 65," 1,6" 5, 46" 40" ABOVE THE ALIANCE 9, 5,4" 2,4" 2," AC 120 V 1/ 10" 7,1" mm 1,4" 20" 4,1" 1,4" 9,7" 1,8" 10, 1,9" 75 29,5" 1" 2,8" 65," 1,6" 40" ABOVE THE ALIANCE Automatic washing WCS (Washing Combi System) KL072 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Two step safety door handle mechanism Right hinged door S001 Special and marine voltages LG version Removable rack SG072 lated meals rack R072 Thermal cover C072 Trolleys CR07 Fat filter F072 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA102 Stands SR102 - S102 Shelf for cleanser tank KD102 Holding cabinets AC102 - MA102 Cabinet AN102 Connection for an external printer (type RS 22) Connection for Energy Saving System SN USB Key With Software Update M-2-G 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 275

12 Electric Combi Steamer HME 101 COntrols HME 101 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with trapezium shape, long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service AISI 04 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 10-12x20 steam table pans; 2.76" shelf spacing High quality world wide available components Additional Construction Details For () COntrol Built-in and retractable hand shower with tap External connection for meat probe ELECTRIC HEATING SYSTEM Cavity heating elements of armoured INCOLOY 800 type Steam generator heating elements of armoured INCOLOY 800 type Energy Saving device for reduced energy consumption Capacity With side racks: 10-12x20 steam table pans and 2.76" shelf spacing With rack SG101: 10-12x20 steam table pans and 2.56" shelf spacing With plated meals rack R101: 0 plates (12.20") at 2.68" distance JOB ITEM # QTY # MODEL NUMBER With Boiler HME 101 HME 101 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Fan motor thermic protection Magnetic door switch Boiler water level probes (Boiler Unit Only) Lack of water displayed alarm Displayed diagnostic (specific for "" controls) Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Chamber heating output Steam heating output Fan power ower supply voltage Without Boiler HVE 101 HVE "W x.86"d x 42.91"H 452 lbs. 16,000 Watts 15,000 Watts 15,000 Watts 1,000 Watts ph/208v/60hz M--E 00 S. 84th Avenue hone: Fax:

13 HME Electric Combi Steamer HME N AC 400 Voltage AC 20 Voltage N AC 400 Voltage Automatic washing WCS (Washing Combi System) KL101 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Two step safety door handle mechanism Right hinged door S001 Special and marine voltages LG version Side runners for 600x400 trays A604 (8 trays) Removable rack SG101 lated meals rack R101 Thermal cover C101 Trolleys CR101 Fat filter F101 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA101 Stands SR101 - S101 Shelf for cleanser tank KD101 Holding cabinets AC101 - MA101 Cabinet AN101 Connection for an external printer (type RS 22) Connection for Energy Saving System SN M--E 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 277

14 Gas Combi Steamer HMG 101 COntrols HMG 101 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with trapezium shape, long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service AISI 16 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 10-12x20 steam table pans; 2.76" shelf spacing High quality world wide available components Additional Construction Details For () COntrol Built-in and retractable hand shower with tap External connection for meat probe GAS HEATING SYSTEM Blown air type for the cavity burner and boiler heating system (Boiler system on HMG models only) Automatic flame ignition with electronic flame control; automatic ignition re-set and diagnosis with display fault Energy Saving device for reduced energy consumption High efficiency heat exchanger with expansion cabinet of steel AISI 10 S Capacity With side racks: 10-12x20 steam table pans and 2.76" shelf spacing With rack SG101: 10-12x20 steam table pans and 2.56" shelf spacing With plated meals rack R101: 0 plates (12.20") at 2.68" distance JOB ITEM # QTY # MODEL NUMBER With Boiler HMG 101 HMG 101 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Flame detection sensor Low gas pressure switch Fan motor thermic protection Magnetic door switch Boiler water level probes (Boiler Unit Only) Lack of water displayed alarm Displayed diagnostic (specific for "" controls) Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Nominal heating output Chamber heating output Steam heating output Fan power ower supply voltage WithOUT Boiler HVG 101 HVG "W x.86"d x 42.91"H 474 lbs. 1,000 Watts 28,000 Watts / 95,54 BTU's 18,000 Watts / 61,414 BTU's 18,000 Watts / 61,414 BTU's 550 Watts 1ph/120v/60hz M--G 00 S. 84th Avenue hone: Fax:

15 G Gas Combi Steamer HMG AC 120 Voltage / AC 120 Voltage 1/ Automatic washing WCS (Washing Combi System) KL101 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Two step safety door handle mechanism Right hinged door S001 Special and marine voltages LG version Wind protection device CAM101 Side runners for 600x400 trays A604 (8 trays) Removable rack SG101 lated meals rack R101 Thermal cover C Trolleys CR101 Fat filter F101 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA101 Stands SR101 - S101 Shelf for cleanser tank KD101 Holding cabinets AC101 - MA101 Cabinet AN101 Connection for an external printer (type RS 22) Connection for Energy Saving System SN M--G 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 279

16 Electric Combi Steamer HME 102 COntrols HME 102 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service AISI 04 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 20-12x20 steam table pans or 10-18x26 sheet pans; 2.76" shelf spacing. High quality world wide available components Additional Construction Details For () COntrol Built-in and retractable hand shower with tap External connection for meat probe ELECTRIC HEATING SYSTEM Cavity heating elements of armoured INCOLOY 800 type Steam generator heating elements of armoured INCOLOY 800 type Energy Saving device for reduced energy consumption Capacity With side racks: 10-18x26 sheet pans or 20-12x20 steam table pans and 2.76" shelf spacing With rack SG102: 10-18x26 sheet pans or 20-12x20 steam table pans and 2.56" shelf spacing With plated meals rack R102: 49 plates (12.20") at 2.68" distance JOB ITEM # QTY # MODEL NUMBER With Boiler HME 102 HME 102 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Fan motor thermic protection Magnetic door switch Boiler water level probes (Boiler Unit Only) Lack of water displayed alarm Displayed diagnostic (specific for "" control) Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Chamber heating output Steam heating output Fan power ower supply voltage Without Boiler HVE 102 HVE "W x 5.24"D x 42.91"H 584 lbs. 1,000 Watts 0,000 Watts 0,000 Watts 1,000 Watts ph/208v/60hz M-4-E 00 S. 84th Avenue hone: Fax:

17 HME Electric Combi Steamer HME N AC 400 Voltage AC 20 Voltage N 4.65 AC 400 Voltage Automatic washing WCS (Washing Combi System) KL102 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Two step safety door handle mechanism Right hinged door S001 Special and marine voltages LG version Removable rack SG102 lated meals rack R102 Thermal cover C102 Trolleys CR Fat filter F102 Standard core probe SC with Needle probe for vacuum packs SE002 with external connection Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA102 Stands SR102 - S102 Shelf for cleanser tank KD102 Holding cabinets AC102 - MA102 Cabinet AN102 Connection for an external printer (type RS 22) Connection for Energy Saving System SN M-4-E 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 281

18 Gas Combi Steamer HMG 102 COntrols HMG 102 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation. Hinged inner glass for cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service AISI 16 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 10-18x26 sheet pans or 20-12x20 steam table pans capacity; 2.76" shelf spacing High quality world wide available components Additional Construction Details For () COntrol Built-in and retractable hand shower with tap External connection for meat probe GAS HEATING SYSTEM Blown air type for the cavity burner and boiler heating system (Boiler system on HMG models only) Automatic flame ignition with electronic flame control; automatic ignition re-set and diagnosis with display fault Energy Saving device for reduced energy consumption High efficiency heat exchanger with expansion cabinet of steel AISI 10 S Capacity With side racks: 10-18x26 sheet pans or 20-12x20 steam table pans and 2.76" shelf spacing With rack SG102: 10-18x26 sheet pans or 20-12x20 steam table pans and 2.56" shelf spacing With plated meals rack R102: 49 plates (12.20") at 2.68" distance JOB ITEM # QTY # MODEL NUMBER With Boiler HMG 102 HMG 102 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Flame detection sensor Low gas pressure switch Fan motor thermic protection Magnetic door switch Boiler water level probes (Boiler Unit Only) Lack of water displayed alarm Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Nominal heating output Chamber heating output Steam heating output Fan power ower supply voltage Without Boiler HVG 102 HVG "W x 5.24"D x 42.91"H 569 lbs. 1,000 Watts 40,000 Watts / 16,477 BTU's 27,000 Watts / 92,122 BTU's 27,000 Watts / 92,122 BTU's 550 Watts 1ph/120v/60hz M-4-G 00 S. 84th Avenue hone: Fax:

19 MG Gas Combi Steamer /4 HMG / Ø 5,9" /4 7,9" 7,1" ,1" (HVG) (HVG) /4 / / AC 120 Voltage AC 120 Voltage Automatic washing WCS (Washing Combi System) KL102 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Two step safety door handle mechanism Right hinged door S001 Special and marine voltages LG version Wind protection device CAM102 Removable rack SG102 lated meals rack R102 Thermal cover C Trolleys CR102 Fat filter F102 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA102 Stands SR102 - S102 Shelf for cleanser tank KD102 Holding cabinets AC102 - MA102 Cabinet AN102 Connection for an external printer (type RS 22) Connection for Energy Saving System SN M-4-G 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 28

20 Electric Combi Steamer HME 142 JOB ITEM # QTY # COntrols HME 142 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for perfect cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service and check component AISI 04 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 28-12x20 steam table pans or 14-18x26 sheet pans; 2.76" shelf spacing High quality world wide available components Additional Construction Details For () COntrol Built-in and retractable hand shower with tap External connection for meat probe ELECTRIC HEATING SYSTEM Cavity heating elements of armoured INCOLOY 800 type Steam generator heating elements of armoured INCOLOY 800 type Energy Saving device for reduced energy consumption Capacity With side racks: 14-12x20 steam table pans or 7-18x26 sheet pans(x2) and 2.76" shelf spacing MODEL NUMBER With Boiler HME 142 HME 142 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Fan motor thermic protection Magnetic door switch Boiler water level probes (Boiler Unit Only) Lack of water displayed alarm Displayed diagnostic Component cooling system OERATING MODES Without Boiler HVE 142 HVE 142 Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions 46.06"W x 5.24"D x 7.2H Weight 849 lbs. Total electric power 16,000 Watts x 2 Chamber heating output 15,000 Watts x 2 Steam heating output 15,000 Watts x 2 Fan power 1,000 Watts x 2 ower supply voltage ph/208v/60hz x 2 M-5-E 00 S. 84th Avenue hone: Fax:

21 46" Electric Combi Steamer HME 142 2,9" 29,5" 69," 6" 5" 1,9" 1, 5, 4," 2,8" 66",9",5"," 1,8" 4,1" 20"," 4," 2,8" 4,6" 1,8",5" 4,1" 10, 1,9" 1, 2,4" " 4,6" AC 208 V AC 480 V 46" 2,9" 29,5" 69," 6" 5" 1" 1,9" 4,6" 2,4"" 66",9" 20" 10, 1,9" 1" AC 208 V AC 480 V 2,8" 46" 2,9" 29,5" 66",9" Automatic washing WCS (Washing Combi System) KL142 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity 20" rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Two step safety door handle mechanism Special and marine voltages Fat filter F072 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 Extraction hood with steam condenser HKA102 Wind protection device CAM 102 Connection for an external printer (type RS 22) Right hinged door S001 USB Key With Software Update M-5-E 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 285

22 Gas Combi Steamer HMG 142 JOB ITEM # QTY # COntrols HMG 142 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation. Hinged inner glass for perfect cleaning Door handle mechanism moving to either left or right Adjustable door hinges ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheel Front removable control panel for easy service and check component AISI 16 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Removable side racks for 28-12x20 steam table pans or 14-18x26 sheet pans with 2.76" shelf spacing. High quality world wide available components Additional Construction Details For () COntrol Built-in and retractable hand shower with tap External connection for meat probe GAS HEATING SYSTEM Blown air type for the cavity burner and boiler heating system (Boiler system on HMG models only) Automatic flame ignition with electronic flame control; automatic ignition re-set and diagnosis with display fault Energy Saving device for reduced energy consumption High efficiency heat exchanger with expansion cabinet of steel AISI 10 S Capacity With side racks: 14-12x20 steam table pans or 7-18x26 sheet pans(x2) and 2.76" shelf spacing MODEL NUMBER With Boiler HMG 142 HMG 142 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat (Boiler Unit Only) Device against pressure built-up in cavity and boiler Flame detection sensor Low gas pressure switch Fan motor thermic protection Magnetic door switch Boiler water level probes (Boiler Unit Only) Lack of water displayed alarm Component cooling system OERATING MODES With Boiler HVG 142 HVG 142 Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions 46.06"W x 5.24"D x 7.2H Weight 1,246lbs. Total electric power 1,000 Watts x 2 Nominal heating output 28,000 Watts / 95,000 BTU's x 2 Chamber heating output 18,000 Watts / 62,000 BTU's x 2 Steam heating output 18,000 Watts / 62,000 BTU's x 2 Fan power 1,000 Watts x 2 ower supply voltage 1ph/120v/60hz x 2 M-5-G 00 S. 84th Avenue hone: Fax:

23 " Gas Combi Steamer HMG 142 1,6" 1,4" 5, 1," 1, 2,6" 5,1" 9," 4," 2,8" 5,6" 10" 2,7",5",7" 1,8" 4,1"," 5,9" 1,9" 66" 4" 20" 1,4" 5,6" 2,6" 5,6" 2,4" 2," 46",7" 1,8" 14,7" 1,4" 2,8",5" 4,1" 10" 10, 1,9" 2,8" 29,5" 1,7 1,4" 2,4"2," 2,4",1" AC 120 V 4," 2,8" 69," 5,9" 5" 1" 1/ 1,9" 10, 1,4" 1,9" 2,4"2," 1" 2,4",1" AC 120 V 66" 4" 20" 2,8" Ø 1/ 46" 2,8" 29,5" 66" 4" Automatic washing WCS (Washing Combi System) KL142 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley 20" to hold washing kit CD002 Two step safety door handle mechanism LG version Fat filter F072 1,4" 5,6" 2,6" 5,6" Standard core probe SC with 2,4" 2,",7" 14,7" 4," 2,8" Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 1,4" Extraction hood with steam condenser HKA102 4,1" Wind protection device CAM 102 Connection for an external printer (type RS 22) 1,8",5" 2,8" Right hinged door S001 10" USB Key With Software Update M-5-G 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 287

24 Electric Combi Steamer HME 201 JOB ITEM # QTY # COntrols HME 201 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with trapezium shape, long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for cleaning Locking mechanism with catches; two of them adjustable Adjustable door hinges Door opening with progressive brake ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheels Front removable control panel for easy service AISI 04 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Supplied with monoblock trolley HKS201 of AISI 04 s. steel construction, with drip tray, holds 20 pans (2.64" distance); 4 polyamide and polyurethane wheels two of them with brakes High quality world wide available components Additional Construction Details For () COntrol Hand Shower LD25 External connection for meat probe ELECTRIC HEATING SYSTEM Cavity heating elements of armoured INCOLOY 800 type Steam generator heating elements of armoured INCOLOY 800 type Energy Saving device for reduced energy consumption Capacity 1 x HKS201 trolley 20-12x20 steam table pans and 2.64" shelf spacing With HK201 plated meals trolley: 60 plates (12.20") at 2.68" distance MODEL NUMBER With Boiler HME 201 HME 201 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat Device against pressure built-up in cavity and boiler Fan motor thermic protection Magnetic door switch Boiler water level probes Lack of water displayed alarm Displayed diagnostic (specific for "" control) Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Chamber heating output Steam heating output Fan power ower supply voltage 9.76"W x.86"d x 76.77"H 926 lbs. 1,800 Watts 0,000 Watts 0,000 Watts 1,800 Watts ph/208v/60hz M-6-E 00 S. 84th Avenue hone: Fax:

25 ME Electric Combi Steamer HME AC 20 Voltage. N AC 400 Voltage / AC 20 Voltage / N AC 400 Voltage / / Automatic washing WCS (Washing Combi System) KL201 Cavity self wash 2.56 system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Special and marine voltages LG version lated meals trolley HK201 Thermal cover C201 Fat filter F201 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA201 Holding cabinet Connection for an external printer (type RS 22) Connection for Energy Saving System SN M-6-E 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 289

26 Gas Combi Steamer HMG 201 JOB ITEM # QTY # COntrols HMG 201 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with trapezium shape, long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for cleaning Locking mechanism with catches; two of them adjustable Adjustable door hinges Door opening with progressive brake ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Hinged fan protection cover for a proper cleaning of cavity back wall and fan wheels Front removable control panel for easy service AISI 16 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Supplied with monoblock trolley HKS201 of AISI 04 s. steel construction, with drip tray, holds 20 pans (2.64" distance); 4 polyamide and polyurethane wheels two of them with brakes High quality world wide available components Additional Construction Details For () COntrol Hand Shower LD25 External connection for meat probe GAS HEATING SYSTEM Blown air type for the cavity burner and boiler heating system Automatic flame ignition with electronic flame control; automatic ignition re-set and diagnosis with display fault Energy Saving device for reduced energy consumption High efficiency heat exchanger with expansion cabinet of steel AISI 10 S Capacity 1 x HKS201 trolley 20-12x20 steam table pans and 2.64" shelf spacing With HK201 plated meals trolley: 60 plates (12.20") at 2.68" distance MODEL NUMBER With Boiler HMG 201 HMG 201 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat Device against pressure built-up in cavity and boiler Flame detection sensor Low gas pressure switch Fan motor thermic protection Magnetic door switch Boiler water level probes Lack of water displayed alarm Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Nominal heating output Chamber heating output Steam heating output Fan power ower supply voltage 9.76"W x.86"d x 76.77"H 970 lbs. 1,800 Watts 48,000 Watts / 16,77 BTU's 6,000 Watts / 122,829 BTU's 27,000 Watts / 92,122 BTU's 1,100 Watts 1ph/120v/60hz M-6-G 00 S. 84th Avenue hone: Fax:

27 MG Gas Combi Steamer HMG AC Voltage AC 120 Voltage Automatic washing WCS (Washing Combi System) KL201 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Special and marine voltages LG version Wind rotection Device CAM201 lated meals trolley HK201 Thermal cover C Fat filter F201 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA201 Holding cabinet Connection for an external printer (type RS 22) Connection for Energy Saving System SN M-6-G 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 291

28 Electric Combi Steamer HME 202 JOB ITEM # QTY # COntrols HME 202 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for cleaning Locking mechanism with catches; two of them adjustable Adjustable door hinges Door opening with progressive brake ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Two hinged fan protection covers for a proper cleaning of cavity back wall and fan wheels Front removable control panel for easy service AISI 04 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Supplied with monoblock trolley HKS202 of AISI 04 s. steel construction, with drip tray, holds 20 pans (2.64" distance); 4 polyamide and polyurethane wheels two of them with brakes High quality world wide available components Additional Construction Details For () COntrol Hand Shower LD25 External connection for meat probe ELECTRIC HEATING SYSTEM Cavity heating elements of armoured INCOLOY 800 type Steam generator heating elements of armoured INCOLOY 800 type Energy Saving device for reduced energy consumption Capacity 1 x HKS202 trolley 20-18x26 sheet pans or 40-12x20 steam pans and 2.64" shelf spacing With HK202 plated meals trolley: 100 plates (12.20") at 2.68" distance MODEL NUMBER With Boiler HME 202 HME 202 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat Device against pressure built-up in cavity and boiler Fan motor thermic protection Magnetic door switch Boiler water level probes Lack of water displayed alarm Displayed diagnostic (specific for "" control) Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Chamber heating output Steam heating output Fan power ower supply voltage 50.79"W x 5.24"D x 76.77"H 1,15 lbs. 61,800 Watts 60,000 Watts 60,000 Watts 1,800 Watts ph/208v/60hz M-7-E 00 S. 84th Avenue hone: Fax:

29 HME Electric Combi Steamer HME AC 20 Voltage. N AC 400 Voltage AC 20 Voltage N AC 400 Voltage Automatic washing WCS (Washing Combi System) KL202 Cavity self wash system with SOFT and HARD cleaning programs with detergent injection and cavity rinsing by the means of a dedicated rotating shower Hand shower LD25 Stainless steel trolley to hold washing kit CD002 Special and marine voltages LG version lated meals trolley HK202 Thermal cover C202 Fat filter F202 Standard core probe SC with Needle probe for vacuum packs SE002 with Needle probe for vacuum packs SE005 with Extraction hood with steam condenser HKA202 Holding cabinet Connection for an external printer (type RS 22) Connection for Energy Saving System SN M-7-E 00 S. 84th Avenue hone: Fax: LIMITED WAANTY: piper products warrants to the original purchaser parts and labor for a period of twelve (12) months from the date of purchase. See manufacturer s complete warranty for details. It is our policy to build equipment which is design certified by companies that have been accredited at the Federal Level by the Occupational Safety and Health Agency (OSHA) and ANSI as a National Recognized Testing Laboratory. These companies include CSA International, Underwriters Laboratories, and the National Sanitation Foundation. However, a continuing program of product improvement makes it necessary to submit new models to the agencies as they are developed. Consequently, all models may not bear the appropriate labels at all times. We reserve the right to change specifications and product design without notice. Such revisions do not entitle buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Information is not for design purposes. 29

30 Gas Combi Steamer HMG 202 JOB ITEM # QTY # COntrols HMG 202 (Shown with controls) Unit is available with either or style controls. Operating Modes and Options/Accessories are dependent upon control type. lease refer to the included charts and/or Spec-Sheets M-A- and M-A- for details. CONSTRUCTION DETAILS Stainless steel 18/10 AISI 04 cooking compartment with long radius rounded corners for a perfect cleaning (HACC requirements) and fully water-proof Thermic insulation of 1.8" rock wool Thermic brake between the cavity and oven front panel, to absorbe steel expansion Double glazed door with large air interspace for heat insulation Hinged inner glass for cleaning Locking mechanism with catches; two of them adjustable Adjustable door hinges Door opening with progressive brake ush-in type door seal of heat resistant silicon rubber Built-in door drip tray collecting the condensate into the cavity drip tray; then into the oven drain Two hinged fan protection covers for a proper cleaning of cavity back wall and fan wheels Front removable control panel for easy service AISI 16 fully insulated steam generator Oven drain with built-in air gap; it can be plumbed with a permanent connection and it can also be opened for service purposes Two water inlets (soft and hard water) Connections gathered at the oven right hand side Supplied with monoblock trolley HKS202 of AISI 04 s. steel construction, with drip tray, holds 20 pans (2.64" distance); 4 polyamide and polyurethane wheels two of them with brakes High quality world wide available components Additional Construction Details For () COntrol Hand Shower LD25 External connection for meat probe GAS HEATING SYSTEM Blown air type for the cavity burner and boiler heating system Automatic flame ignition with electronic flame control; automatic ignition re-set and diagnosis with display fault Energy Saving device for reduced energy consumption High efficiency heat exchanger with expansion cabinet of steel AISI 10 S Capacity 1 x HKS202 trolley 20-18x26 sheet pans or 40-12x20 steam table pans and 2.64" shelf spacing With HK202 plated meals trolley: 100 plates (12.20") at 2.68" distance MODEL NUMBER With Boiler HMG 202 HMG 202 SAFETY FEATURES Cavity safety thermostat Boiler safety thermostat Device against pressure built-up in cavity and boiler Flame detection sensor Low gas pressure switch Fan motor thermic protection Magnetic door switch Boiler water level probes Lack of water displayed alarm Component cooling system OERATING MODES Control Convection with Autoclima 86 F F Steam 86 F F (low temperature, atmospheric, forced) Combined steam/convection with Autoclima 86 F F ICS - Interactive Cooking System Temperature hold - Reheating - Defrosting - Multilevel cooking Reheating with Autoclima 248 F F Temperature hold with Autoclima function Slow cooking Automatic sequence cooking Delta-T cooking Three finishing modes Cook & Hold Automatic delayed start TECHNICAL DATA External dimensions Weight Total electric power Nominal heating output Chamber heating output Steam heating output Fan power ower supply voltage 50.79"W x 5.24"D x 76.77"H 1,268 lbs. 1,800 Watts 80,000 Watts / 272,955 BTU's 54,000 Watts / 184,244 BTU's 54,000 Watts / 184,244 BTU's 1,100 Watts 1ph/120v/60hz M-7-G 00 S. 84th Avenue hone: Fax: