INSTALLATION AND OPERATIONS MANUAL
|
|
- Piers Morgan
- 6 years ago
- Views:
Transcription
1 MODEL 6001 REVERSE OSMOSIS High Purity Water Production System THREE STAGE Filtration for the reduction of: Organic Matter Total Dissolved Solids (TDS) Suspended Solids Chemical Contaminants Bad Taste and Odors MEMBRANE PROCESS for protection against: Cysts Bacteria Virus Micro-organisms PSI -72F INSTALLATION AND OPERATIONS MANUAL YACHT-MATE PRODUCTS, Inc. Ft. Lauderdale FL (YACHTMATE) * (954) sales@yachtmate.com GM-5001 Manual Revised
2 INTRODUCTION READ THIS ENTIRE MANUAL BEFORE BEGINNING INSTALLATION This Galley-Mate Reverse Osmosis ( RO ) Drinking Water System has been designed for quick and simple installations and maintenance. By carefully reading this instruction manual and following our operational guidelines you will insure a successful installation and a reliable operation. Routine maintenance is essential to the longevity and overall performance of the Galley-Mate RO System. Filters should be changed every six to twelve months depending on the quality of the feed water supply. GALLEY-MATE REVERSE OSMOSIS MEMBRANE STANDARD MEMBRANE THIN FILM COMPOSITE ( TFCM ) POLYAMIDE FEED WATER SPECIFICATIONS AND OPERATING PARAMETERS CAUTION NO DRINKING WATER SYSTEM SHOULD BE CONSIDERED YOUR PRIMARY SOURCE OF DISINFECTION FOR POTENTIALLY MICROBIOLOGICALLY UNSAFE WATERS. EVEN THOUGH YOUR GALLEY-MATE SYSTEM IS A WATER PURIFICATION APPLIANCE, WE CAN ONLY CLAIM 99.99% REDUCTION OF MICRO- ORGANISMS., THOUGH IN THEORY SMALLER THAN OUR MEMBRANE PORES. FOR WATER DISINFECTION OF STORED FRESH WATER CONTACT FACTORY. 2
3 STARTING YOUR INSTALLATION PREPARATION Check the following list of components to ensure that all parts are packed with your system. Note, installation requirements will vary from vessel to vessel. Often we find the location for the installation is under the galley sink, nevertheless, many systems are installed in remote locations such as the engine room, at which point added materials may be required. Your distributor will be able to supply additional fittings, tanks and longer tubing runs if your installation were to require those. 1 Water Storage Tank (Remote Tanks boxed separately if required for your installation) 1 Reverse Osmosis Purification assembly 1 Box with Pre & Post Filters plus Membrane element 1 Installation Kit with assorted fittings and tubing (5ft) Determine the location for the installation of the RO system. Avoid locations where the system might come in contact with hot surfaces such as engines, exhaust, hot water pipes, electrical panels and other hazards. Determine the location for the pure water faucet. Check to see that drilling a hole in a galley counter or sink will not damage pipes or wires running under the sink. If a second faucet is being installed in a remote sink or entertainment bar area, and there is no cabinet under sink, verify that there is a removable access panel. Determine location(s) of storage tank(s). A maximum of 15 feet is possible for close installations from tank to faucet(s). If added faucets are being used, you will need to add additional storage tanks at those locations. All tubing is individually labeled and color coded for ease of your installation. 1/4 Red Connects the feed water line valve to the RO Pre-Filter 3/8 Blue Connects the RO Membrane Product Port to the Storage Tank(s)* 1/4 Red Connects the Membrane Reject Port to the Drain Connector** 3/8 White Connects the Post Filter to the Faucet*** * For Remote Tanks to Bridge or Wet Bars, order special FDA approved tubing from our Distributor ** On certain installations, depending on water source and tank size, reject may be returned to fresh tank, to an existing drain or to a thru the hull fitting. *** On Remote Tank installs, a 3/8 Quick Connect T can be located on blue line (3/8 ) interconnecting the tanks. Kit includes an in-line shut off. An Optional in-line polishing filter at the remote faucet connection is available to pick up any possible taste from long tubing runs. Fittings and Tubing John Guest fittings are used throughout the system. To insure optimal seal, tubing should be cut with the end perfectly square. An angled cut or distortion of the tubing will not provide an efficient seal and may cause leaks. To install a tube, push it through the collet until it seats firmly. To remove a tube, push in the collet towards fitting, and pull out the tube. 3
4 PURE WATER FAUCET INSTALLATION Drilling with the Recommended Relton Cutter 4
5 1- PRE MEMBRANE POST 10
6 GALLEY-MATE FAUCET AND SYSTEM COMPONENTS PARTS BREAKDOWN Standard Faucet Assembly Each Galley-Mate Reverse Osmosis System is packed with a long reach polished chrome faucet. The instructions shown below will cover most variations of the Standard Faucet, which is available in decorator colors, polished brass, gold plated, and brushed antique finishes. Were you to have specified a special decorator faucet, mounting would be the same. Yacht-Mate Products in addition, offers several lines of specialty faucets, such as the handsome OPELLA Line. In some cases, the hole size for mounting specialty faucets as well as the connecting assemblies may differ. STANDARD SYSTEMS USE 65 GPD MEMBRANE CERTAIN APPLICATIONS MAY USE A DIFFERENT CONFIGURATION If you have ordered a specialty faucet from our distributor, please refer to the installation instructions included with the alternate faucet, before you locate and drill any holes for mounting. NOTE: For certain ice line applications, the ice line is provided in 1/4 copper coil tubing. Cut /reduce length of 1/4 copper to feed with 3/8 tubing (leaving enough to pull out fridge).when adapting plastic to copper, use a brass compression fitting to adapt either 3/8 or 1/4 plastic tube to 1/4 copper, using a 1/4 X 1/4 union or a 3/8 X 1/4 reducing union in brass, with plastic ferrules and plastic tube inserts on the plastic tube, brass ferrules on the copper tube. CARBON BLOCK POST 55710G2 Short Spout, Gooseneck, or Long Reach Faucet Spout TFC MEMBRANE Faucet Water Actuator Faucet Body and Actuator Valve 65 GPM FCM TMEMBRANE 5709G2 Escutcheon Plate Black Rubber Washer Galley or Head Vanity Counter Top CARBON PRE FILTER 55706G2 SED /CARBON Black Locating Washer Fastening Nut Lock Washer John Guest Female X 3/8 Tubing Quick Connect Plastic Fitting ELEGANT PLASTIC MOLDED COVER INCLUDED NOT SHOWN 3/8 FDA Pure Water Tubing REMOVABLE COVER 5
7 WATER FEED SOURCE AND REJECT DRAIN CONNECTIONS FEED WATER CONNECTIONS: The feed water connection to the Galley-Mate marine water purification system will vary from vessel to vessel, depending on vessel size and type of piping used on board. We include a 1/4 Self-Piercing valve that is normally used under the galley sink on vessels that have the cold water faucet piped with rigid copper risers. (See figure 1-A.) Today, many vessels use quick connect plastics for DRAIN CONNECTIONS: All Membrane Purification Systems have one feed water inlet and two outlets, a purified water stream and the reject drain stream. The reject flow must be taken to a drain, which will vary from vessel to vessel. We include a standard drain saddle valve which fits any 1 1/2 OD straight wall pipe. This fitting may be used in under galley sink installations where the riser above the P Trap is 1 1/2 in diameter. This fitting can be installed either in a vertical position or on a horizontal position as long as the fitting is above the trap. When installing the Galley-Mate assembly in an engine room you may utilize the saddle fitting on any non pressurized straight wall pipe such as PVC. Do not install into any pipe sections that are pressurized or in the position of holding water in a void. ( See Figure 1-C ). Select location for the drain clamp. Position the threaded Figure 1-C FIGURE 1-A 1/4 Self Piercing Saddle Valve fittings and connectors along with the plastic tubing that is available with specialty fittings such as those supplied by Neptune Plumbing Systems, on a wide range of production boats. For connection to plastic tubes, we recommend locating a T with ball valve (not supplied) to make the 1/4 connection to the Galley-Mate Feed Water port. (See Figure 1-B) Other connection fittings are available. Feed connection can be achieved with shut off of a variety of styles. Although pre-filter has a built in shut off a feed water shut off is required for a proper install. Figure 1-B Feed Water Source Plastic T Fitting 1/4 RO Feed 1/2 of the saddle on pipe and mark the pipe through the threaded opening. Drill a 1/4 hole at marked location into pipe. On board drain connections will vary depending on the location for the installation of the system. Different adaptors may be utilized when draining to an existing thru-hull drain line. On some vessels, with larger fresh water tanks and frequent water-maker fills from sea water, the RO drain may be diverted back to the fresh water storage tank for a O waste system. If the TDS is low in the tank, the rise of TDS from the RO will be insignificant to the tank volume. We recommend our Water- Mate systems if this drain connection is used. Ask your Distributor for Water-Mate product data. Brass/Plastic Valve 6
8 ACTIVATION, TROUBLESHOOTING, MAINTENANCE Activating the System For the First Time Connect the feed line if fed from a chlorinated city water source, to the storage tank connection. If feed line is fed from a fresh water storage tank or a non chlorinated water supply, procure a thin ended medicine dropper and drop three to five drops of plain unscented laundry bleach into the tubing or an open ball valve on top of tank. The ball valve handle is in line with the connection port when open. Connect tubing to pressurized water source and turn water on. When tank is full, it will feel heavy. Close the ball valve and remove system feed tube. Make sure all water supply & drain lines are secure and free from leakage. Slowly turn the system feed valve to on position. Connect tank line to tank. Open faucet by lifting handle to allow the air out of the system. Slowly open feed water valve to system. Open the tank valve and drain through the open faucet. This will flush the post filter and pressurize the post membrane side of your system. Once water has stopped running from the tank, leave faucet handle in the open position until all air is out of the system, and water is constantly dripping from the end of the faucet. Close the faucet and allow 1/2 hour for system to pressurize the tank. Again check for leaks at all connections. Tank should be full in approximately hours. Leave tank valve open. Do Not Use the First Two Fills of the Tank Reservoir Allow the RO Tank two fills ( hours each, dependant on pressure) and drain both fills to drain through faucet. This will remove factory installed sanitizing solution from the entire system. The sanitizing solution is of course non toxic, yet should be removed prior to routine use of this appliance. A single flush of the system should suffice, nevertheless we suggest a double flush on start up and after pickling Maintenance 1) Close the ball valve on top of the storage tank(s). NOTE: If your vessel has additional storage tanks in remote locations such as Fly-Bridge, Wet Bar or Master Suite, make sure all tank valves are closed. 2) Open Faucet(s) at galley and any remote locations, to relieve pressure from the system. Standard faucets will remain open when handle is lifted to up (on) position. 3) Remove the Pre-Filter by turning counter clockwise. Removal of the pre-filter automatically shuts off the feed water supply. You may close the feed water shut off valve if so desired, for added assurance. 4) Remove the Post Filter by turning counterclockwise. 5) Install new replacement post filter. (Use activated carbon post filter only) Available through our distributor. Element threads on clockwise. Do not over-tighten as a snug fit with the O rings will provide a proper seal. 6) Install the new Pre-Filter. Thread into housing clockwise, without over tightening, to achieve an O ring seal. Replacing the Pre-Filter will re-actuate the feed water automatically. If you closed any feed water valves, re-open them. Close all faucet handles. 7) Open the Ball Valves on all the storage tanks throughout the vessel. Check for leaks. 8) Open faucet once again, and empty the storage tank(s). This will flush the Post Filters and allow for a fresh tank fill with newly cartridges. 9) Allow hours for tanks to be replenished with a fresh fill of highly pure water. THIS MAINTENANCE SHOULD BE PERFORMED EVERY 6 MONTHS TO 1 YEAR OR AS NECESSARY 7
9 GALLEY-MATE ADDITIONAL REMOTE TANK INSTALLATION AS A SPACE SAVING MOVE, VESSELS OFTEN REQUIRE INSTALLATION OF THE GALLEY-MATE SYSTEM IN ENGINE ROOMS, OR QUARTERS BELOW THE GAL- LEY. ON SUCH INSTALLATIONS, RUN THE 3/8 LINE FOR FAUCET UP TO GAL- LEY SINK. FOR A REMOTE TANK INSTALLATION, PLACE A QUICK CONNECT T ON THE LINE TO PRIMARY TANK, AND INTERCONNECT TANK LINES. TO GALLEY SINK FAUCET 3/8 WHITE 3/8 T NOTICE: ( OPTION B ) FOR INSTALLATIONS TO UPPER DECKS OR BRIDGE, TO FEED ICE-MAKERS, CONNEC- TION SHOULD BE MADE FROM TANK LINE, UTILIZING A 10 INLINE FILTER AT THE POINT OF USE TO KEEP TASTE OUT OF LINE THIS IS TO BE RUN IN 3/8 MINIMUM. NOTE:LARGER TANKS ARE AVAILABLE FEED 1/4 3/8 TO TANK Blue PRIMARY STORAGE TANK 3.2 GAL GALLEY-MATE SYSTEM REVERSE OSMOSIS 65GPD 3/8 BLUE OPTION B TO REMOTE ICE-MAKER AND/OR FAUCET WITH 10 3/8 QC IN-LINE FILTER REMOTE STORAGE TANK 3.2 GAL GALLEY-MATE IS A PRODUCT OF YACHT-MATE PRODUCTS, Inc.. NOTE: LARGER TANKS ARE AVAILABLE 8
10 WHAT YOU SHOULD KNOW ABOUT THIS PURE WATER APPLIANCE FACTS ABOUT REVERSE OSMOSIS TECHNOLOGY AND TIPS FOR START-UP AND USE Reverse Osmosis (RO) is the technology of membrane separations of fluids. When water is processed through the Galley-Mate RO System, it is important to know that the system is not an ordinary filter, with one inlet and one outlet. Your RO has one inlet and two outlets. One outlet is comprised of a pure water outlet that takes your high purity water to a storage tank, and then to a dispensing faucet. The other outlet carried unwanted impurities to a reject drain. In essence, we are not taking anything out of water, we are removing just the water in a nearly pure state, and virtually sending everything else to a waste drain. This process utilizes several components, principal of which is the RO Membrane. A membrane is like a muscle, as the more you use it, the better it will work for you, producing greater quantities of water, of even higher qualities. Once the water is produced and stored, the system will shut off to avoid any unnecessary waste. Nevertheless, when feed tanks and/or dock supplies are plentiful, be sure to use as much water as you wish. There are varied uses beyond beverage preparation which you may consider, ranging from plant watering to cleaning fine crystal, glass, appliances, varnished wood surfaces, and watering pets. Enjoy this appliance, and put it to work for you! START-UP TIPS: YOUR REVERSE OSMOSIS SYSTEM WILL PRODUCE UP TO 65 GALLONS/DAY, DEPENDING ON THE TEMPERATURE, THE PRESSURE AND THE LEVEL OF DISSOLVED SOLIDS TO BE REMOVED FROM THE WATERS THAT FEED THE SYSTEM. For example, on start-up, we advise that you wait up an average of 4 hours for a tank to fill, discard the water, and repeat the process. This is based on lower pressures often found on board vessels, as well as on average temperatures between cold and warm climates. The Dissolved Solids start out higher than normal as our membranes have a sterilizing non toxic solution packed in them. The initial flush will rid the system of the solution as well as any black carbon fines coming from post filters. Often, the tank fill may take only one to two hours, and should provide approximately gallons when drained completely. This often can be completed within 2.5 to 3 hours total, allowing you to complete both flushes and have water ready for use within 4-5 hours after installation. NOTE: When the storage tank is empty, you will only see fast series of drops and drips coming from the faucet. That is normal, as the production rate for pure water at 77 degrees F. is 0.03 gallons/minute. The faucet may be depressed to pour a glass of water or fill a small container. To fill a larger container, lift the faucet handle, and you will have a steady flow. Were you to have any questions or concerns, call (yachtmate) or sales@yachtmate.com. * visit: 9
Installation & Service Guide
Reverse Osmosis Ontario Soft Water.ca Kitchener, Canada 519-579-0500 Installation & Service Guide Pentair 75 gpd Encapsulated Membrane System Standard System 75gpd Membrane Your New Reverse Osmosis System
More informationAPEX Water Filters MODEL RO 5. Treat your body to pure goodness with Apex filtered water INSTRUCTION MANUAL. pure water in every drop
APEX Water Filters pure water in every drop MODEL RO 5 INSTRUCTION MANUAL Treat your body to pure goodness with Apex filtered water A Water supply adapter valve B Cold water shut-off valve C Hot water
More informationAQUA ONE. Reverse Osmosis System Model ARO5000. Installation and Service Guide PLEASE READ THIS MANUAL CAREFULLY BEFORE ATTEMPTING INSTALLATION
AQUA ONE Reverse Osmosis System Model ARO5000 Congratulations on your purchase of the most sophisticated water purifier system available! Installation and Service Guide PLEASE READ THIS MANUAL CAREFULLY
More informationby Water Purification Supplies
REVERSE OSMOSIS PURIFIER With Booster Pump by Water Purification Supplies Member, Water Quality Association Read these instructions carefully before using the purifier. Retain these instructions in safe
More information475 PRO SERIES Reverse Osmosis System Installation & Operation Manual
PLEASE READ ALL INSTRUCTIONS BEFORE INSTALLING AND USING THIS SYSTEM 475 PRO SERIES Reverse Osmosis System Installation & Operation Manual Model STAGE 1 STAGE 2 STAGE 3 STAGE 4 OUTPUT 475 SEDIMENT CARBON
More informationInstallation and Operation Manual
How To Install, Operate and Maintain Your Reverse Osmosis System FILTER CARTRIDGE CONFIGURATION MAY BE SUBJECT TO CHANGE. 475 PRO SERIES 475BP PRO SERIES INSTALLERS: PLEASE READ ALL INSTRUCTIONS BEFORE
More informationULTIMATE REVERSE OSMOSIS SYSTEM
ULTIMATE REVERSE OSMOSIS SYSTEM INSTALLATION INSTRUCTION & OWNER S MANUAL Ver 3.1 All Rights Reserved APEC Water Systems Please keep this Owner s Manual for future reference. It contains useful information
More informationINSTALLATION & SERVICE MANUAL
INSTALLATION & SERVICE MANUAL Countertop Reverse Osmosis Systems Series CT CT-315 CT-315TFC CT-445 CT-445P CT-D425 CT-D425P CT-550UP 3 STAGE CTA RO SYSTEM 3 STAGE TFC RO SYSTEM 4 STAGE TFC RO SYSTEM 4
More informationPRF-RO Pentair Reverse Osmosis System Installation and Maintenance Manual SAFETY GUIDES THE BASIC REVERSE OSMOSIS SYSTEM. Tools and Materials Required
PRF-RO Pentair Reverse Osmosis System Installation and Maintenance Manual SAFETY GUIDES Read and follow all steps and guides carefully before installing and using your reverse osmosis system. Do not use
More informationINSTALLATION & SERVICE MANUAL
INSTALLATION & SERVICE MANUAL Countertop Reverse Osmosis Systems Series CT System Tested and Certified by WQA against NSF/ANSI Standard 58 for the reduction of Arsenic, Barium, Cadmium, Copper, Cyst, Hexavalent
More informationTap Master Artesian Hydro Gardener Series Installation & Service Manual
Perfect Water Technologies 7 Tips for an Easy and Successful Installation 1. Keep it simple - there are 3 connections to make, and the tubing is color coded. 2. Have plenty of time, light, space, and towels
More informationWATERSHIELIJrM REVERSE OSMOSIS INSTALLA TION MANUAL ~ ~ ~ ~ ~ l ~ TO INSURE THIS PRODUCT AND THE INSTALLATION THEREOF. ~ ~ ~ ~ ~
WATERSHIELIJrM REVERSE OSMOSIS SYSTEM INSTALLA TION MANUAL p 1 ~ -~ I IMPORTANT I ITHIS REVERSE OSMOSIS SYSTEM WAS SOLD IN KIT FORM. IT HAS ~ INOT BEEN PRESSURE TESTED IN ANY WAY. UPON INSTALLATION IT
More informationParasitic Cysts - Cryptosporidium and Giardia, Chemicals, Heavy Metals, Dissolved Salts, Offensive Tastes and Odours, Sediment, Dirt,
Aqua-Pure is a market leader in water filtration. In addition to our comprehensive range of Domestic Water Purifiers, we design and manufacture an extensive commercial and industrial range of purification
More informationModel #: PT3000T36-GOLD
Good Water Warehouse Inc. 1700 E Walnut Ave Fullerton CA 92831 (714) 441-2893 (714) 441-0525 FAX Reverse Osmosis System Installation & Service Guide Model #: PT3000T36-GOLD Do not use with water that is
More informationThe Coffee Professor Reverse Osmosis System Model Genesis Cafe
The Coffee Professor Reverse Osmosis System Model Genesis Cafe Congratulations on your purchase of the most advanced water purifier system available! Installation and Service Guide PLEASE READ THIS MANUAL
More informationREVERSE OSMOSIS WATER FILTRATION SYSTEM MODEL PB-TLRO4H50T INSTRUCTION MANUAL
REVERSE OSMOSIS WATER FILTRATION SYSTEM MODEL PB-TLRO4H50T INSTRUCTION MANUAL Pure Blue H20, LLC 13813 Monroes Business Park Tampa, FL 33635 USA www.pureblueh2o.com (844) 787-3148 (844) PURE-1-4-U 2015.02.25
More informationInstallation Instructions Residential Reverse Osmosis Drinking Water System
Your Reverse Osmosis System has been tested to ensure it will operate correctly. The following periodic maintenance is recommended so your system will provide years of trouble-free service: Replacement
More informationInstallation and Operation Manual
How To Install, Operate and Maintain Your Reverse Osmosis System INSTALLERS: PLEASE READ ALL INSTRUCTIONS BEFORE IN- STALLING AND USING THIS SYSTEM. IT IS RECOMMENDED TO WAIT UNTIL THE ENTIRE SYSTEM IS
More informationOWNER S MANUAL AND INSTALLATION GUIDE PLEASE READ THIS MANUAL CAREFULLY BEFORE ATTEMPTING INSTALLATION
ClearChoice Economy Under Sink Drinking Water System OWNER S MANUAL AND INSTALLATION GUIDE PLEASE READ THIS MANUAL CAREFULLY BEFORE ATTEMPTING INSTALLATION Congratulations on the purchase of your ClearChoice
More informationWATER FILTRATION SYSTEM (USF3) OWNER S MANUAL
WATER FILTRATION SYSTEM (USF3) OWNER S MANUAL 1 INTRODUCTION Congratulations on choosing Permatech to improve the quality of your water. You will immediately begin to notice the numerous benefits of having
More informationGROWMAX WATER Perfect Water for Plants and Gardens
GROWMAX WATER Perfect Water for Plants and Gardens WATER SYSTEMS FOR HYDROPONICS AND GARDENING GROWMAX 3000 Ultra-Pure Reverse Osmosis Water System Up to 3000 L/D of Pure Water Don't forget to register
More informationTABLE OF CONTENT WARNING: READ ENTIRE MANUAL. FAILURE TO FOLLOW ALL GUIDES AND RULES COULD CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.
TABLE OF CONTENT I. COMPONENTS AND TOOLS IDENTIFICATION... 3 II. PRE-INSTALLATION... 3 System Location... 4 Site Preparation... 4 Unit Preparation... 4 III. INSTALLATION INSTRUCTIONS... 4 Faucet Installation...
More information1 P a g e. G4 Counter Top OPERATION MANUAL
1 P a g e G4 Counter Top OPERATION MANUAL Table of Contents Introduction. 3 Receiving....4 Description Model G3 & G4...5/6 Water Production Flow Chart...7 Positioning the Cooler...8 Water Cooler Connections..9
More informationMKTF CRO-Series 5-Stage Reverse Osmosis System Installation and Maintenance Manual
MKTF - 215 CRO-Series 5-Stage Reverse Osmosis System Installation and Maintenance Manual Please fill out the following information at the time of installation. Save for future reference. Model: Date Code:
More informationAlkaline RO System INSTALLATION MANUAL
Alkaline RO System INSTALLATION MANUAL 1-800-992-8876 Customer Support Disclaimer All rights reserved. All material published on this site by Express Water Inc., including all portions of the website,
More informationInstallation and Operation Manual
Installation and Operation Manual Canature North America Inc. How To Install, Operate and Maintain Your Reverse Osmosis System FILTER CARTRIDGE CONFIGURATION MAY BE SUBJECT TO CHANGE. 475 PRO SERIES 475BP
More informationTable of Contents. List of Figures
1 P a g e Table of Contents Introduction. 3 Receiving....4 Description Model G3 & G4...5/6 Water Production Flow Chart...7 Positioning the Cooler...8 Water Cooler Connections..9 Feed Water Connection....10
More informationReverse Osmosis System OWNERS MANUAL
APS Water Services Corporation Quick Change, Twist & Loc Reverse Osmosis System OWNERS MANUAL Installation, Operation & Maintenance Sold By : APS Water Services Corp 818-786-0600 NOTE: Please read through
More informationWATER FILTRATION SYSTEM (RO5) OWNER S MANUAL
WATER FILTRATION SYSTEM (RO5) OWNER S MANUAL 1 INTRODUCTION Congratulations on choosing Permatech to improve the quality of your water. You will immediately notice the numerous benefits of having quality
More informationERO-175. Undersink REVERSE OSMOSIS DRINKING WATER SYSTEM. u Safety Guides u Installation u Operation u Maintenance u Repair Parts
Undersink REVERSE OSMOSIS DRINKING WATER SYSTEM ERO-175 u Safety Guides u Installation u Operation u Maintenance u Repair Parts EcoWater Systems LLC P.O. Box 64420 St. Paul, MN 55164 TEL (651) 739-5330
More informationOWNERS AND OPERATIONS MANUAL
TM Dock-Mate Wash-Down & Fill Systems MODELS DM-1000, DM-1001, DM-1002, DM1004 OWNERS AND OPERATIONS MANUAL YACHT-MATE PRODUCTS, Ltd. FT. LAUDERDALE, FL 954-527-0112 1 DMOM: 0106 rev YACHT-MATE PRODUCTS
More informationWATER FILTRATION SYSTEM (RO6) OWNER S MANUAL
WATER FILTRATION SYSTEM (RO6) OWNER S MANUAL 1 INTRODUCTION Congratulations on choosing Permatech to improve the quality of your water. You will immediately notice the numerous benefits of having quality
More information3MRO401 Reverse Osmosis Drinking Water Filtration System
Installation and Operating Instructions For 3MRO401 Reverse Osmosis Drinking Water Filtration System Installer: Please leave manual with homeowner. Homeowner: Please retain for operation and future maintenance
More informationBonnie USER'S MANUAL. Cold & Hot Water Dispenser. Memo PURE-PRO REVERSE OSMOSIS SYSTEM. Type of product. Bonnie. Date of purchase.
Type of product Bonnie Memo Date of purchase Name Address Tel REVERSE OSMOSIS SYSTEM 11 Cold & Hot Water Dispenser Bonnie USER'S MANUAL 01 Preface / Parts 02 RO flow chart 03 Piping installation 04 Replacement
More informationWM-450-PT WM-900-PT Commercial Wall Mounted Reverse Osmosis
WM-450-PT WM-900-PT Commercial Wall Mounted Reverse Osmosis Installation And Service Manual Watts Pure Water 1725 W. Williams Dr. C-20., Phoenix, Arizona 85027 Phone: 888-774-7405 Fax: 602-588-0356 www.wattspurewater.com
More informationIMPORTANT! ank You! Model: Twist-In 100 GPD, 3-Stage RO Unit. Installation, Operation & Maintenance Guide
Twist-In 00 GPD, 3-Stage RO Unit WARNING: Please read carefully before proceeding with installation. Your failure to follow any attached instructions and operating parameters may lead to the product s
More informationDWSB-TFC-50 DWSB-50-PUMP
INSTALLATION MANUAL DWSB-TFC-50 DWSB-50-PUMP 12630 US 33 N. Churubusco, IN 46723 Ph. (260)693-1972 Fax (260)693-0602 www.sterlingwatertreatment.com 1 TABLE OF CONTENTS: SECTION I. SECTION II. INTRODUCTION...3
More informationPRO-RO 6-Stage Reverse Osmosis System
PRO-RO 6-Stage Reverse Osmosis System Rev: 1016 Introduction to the PRO-RO Congratulations on your purchase of the PRO-RO six stage reverse osmosis system. The PRO-RO features a four-stage prefilter,
More informationUS Water American Revolution 5-Stage RO System The ONLY RO system on the market that is totally American made!
US Water American Revolution 5-Stage RO System The ONLY RO system on the market that is totally American made! MEMBRANE POST CARBON PRE SEDIMENT TUBING FAUCET AND MOUNTING KIT FILTER WRENCH DRAIN SADDLE
More informationTANKLESS REVERSE OSMOSIS SYSTEMS USER S MANUAL
Water Systems, LLC www.123filter.com Email: sales@123filter.com TANKLESS REVERSE OSMOSIS SYSTEMS USER S MANUAL Model #RCB4T ABOUT THE SYSTEM Reverse Osmosis process is a separation process. Tap water enters
More informationOwner s Manual AQ-RO-BASE. Aquasana OptimH2O Drinking Water System Reverse Osmosis Filtration Technology
Owner s Manual AQ-RO-BASE Aquasana Drinking Water System Reverse Osmosis Filtration Technology Welcome to the Aquasana experience. You are about to enjoy clean, clear water and the peace of mind that comes
More informationREVERSE OSMOSIS DRINKING WATER SYSTEM
REVERSE OSMOSIS DRINKING WATER SYSTEM INSTALLATION, OPERATION & SERVICE MANUAL Drink With Confidence! TABLE OF CONTENTS SECTION I. Page INTRODUCTION...3 SECTION II. SPECIFICATIONS...4 SECTION III. SECTION
More informationMODEL FW-2000 OPERATION MANUAL
MODEL FW-2000 OPERATION MANUAL 1 P a g e Table of Contents Introduction...pg.3 Receiving..pg.4 Description Model H2O- 2000....pg.5 Operation. pg.6,7 Drain Container Operation. p.g.8 Cup Dispenser Operation.p.g.9
More informationInstalling the Turbo Floor Model System
Installing the Turbo Floor Model System Location 1. Locate as close as possible to water supply source. 2. Locate as close as possible to a three-prong grounding receptacle. 3. Locate the System on a smooth
More informationGallon rating: 2,000 gallons annually before replacing WXC 20 cartridge
Cartridge: WXC 20 Ceramic, Carbon, and Resin Cartridge Height: 16 ¾ Width: 3 Depth: 3 Weight: 8 lbs Quick-connect fittings attach to 3/8 tubing provided or 3/8 copper tubing. Commercial quality, doubletube,
More informationPWC-500/1000/1010/1500
SERVICE MANUAL for by Vertex Model PWC-500/1000/1010/1500 P/N man-7008 Table of Contents 1. Introduction 2. Cooler Set-up 3. Remove Top Cover 4. Remove/Replace Float 5. Remove/Replace Hot Tank 6. Faucet
More informationOwner s Manual AQ-RO-3. Aquasana OptimH2O Drinking Water System. Reverse Osmosis plus Claryum Filtration Technology
Owner s Manual AQ-RO-3 Aquasana OptimHO Drinking Water System Reverse Osmosis plus Claryum Filtration Technology Welcome to the Aquasana experience. You are about to enjoy clean, clear water and the peace
More informationREVERSE OSMOSIS DRINKING WATER SYSTEM
REVERSE OSMOSIS DRINKING WATER SYSTEM 10/10 1 2 Introduction To The Sierra Congratulations on your purchase of the Nimbus Sierra reverse osmosis system. When properly maintained, this system will provide
More informationIMPACT HEALTH SOLUTIONS. Installation & Service Guide
IMPACT HEALTH SOLUTIONS Reverse Osmosis Drinking Water System With Energy Resonance Technology Installation & Service Guide DEALER INFORMATION IMPACT@KINGSLEY.CO.ZA 083 691 4045 021 853 3696 CONGRATULATIONS
More informationReverse Osmosis Install Guide
Reverse Osmosis Install Guide Written by 602abcWATER Start Here Step 1 Con irm All Product Components Open your packages and con irm that you have received all the correct components. If you are missing
More informationR.O. DRINKING WATER SYSTEM
R.O. DRINKING WATER SYSTEM INSTALLATION, OPERATION & SERVICE MANUAL IMPORTANT NOTICES: This reverse osmosis system contains replaceable treatment components critical for effective performance. It is the
More information5-Stage Reverse Osmosis System
5-Stage Reverse Osmosis System 41840 McAlby Court, Suite A Murrieta, CA 92562 800-451-9343, FAX 951-894-2801 www.nimbuswater.com 02/09 1 Introduction to the WaterMaker Five Congratulations on your purchase
More information2-Stage Under Counter Filtration System Model: WP-2 LCV
INSTALLATION, OPERATION AND MAINTENANCE MANUAL Save manual for future reference 2-Stage Under Counter Filtration System Model: WP-2 LCV IMPORTANT If you are unsure about installing your WATTS water filter,
More informationUser Guide Reverse Osmosis Undersink Water Filter Systems RO SERIES
User Guide Reverse Osmosis Undersink Water Filter Systems RO SERIES For correct operation & installation it is essential to observe these instructions. What's Inside What s inside Introduction...3 Operation...3
More informationINSTALLATION MANUAL CRS-3
INSTALLATION MANUAL CRS-3 12630 US 33 N. Churubusco, IN 46723 Ph. (260)693-1972 Fax (260)693-0602 www.sterlingwatertreatment.com 1 TABLE OF CONTENTS: SECTION I. SECTION II. INTRODUCTION...3 SPECIFICATIONS...3
More informationREMOTE FAUCET PUMP SYSTEM
REMOTE FAUCET PUMP SYSTEM Use & Care Guide See Important Safeguards on Page 2 An exclamation point within an equilateral triangle is intended to alert user to the presence of important operating and maintenance
More informationIMPORTANT! ank You! Model: Twist-In 100 GPD 4-Stage RO/DI Unit. Installation, Operation & Maintenance Guide
Model: 54037 Twist-In 00 GPD 4-Stage RO/DI Unit WARNING: Please read carefully before proceeding with installation. Your failure to follow any attached instructions and operating parameters may lead to
More informationParagon PW750F two stage Drinking Water Filtration System Installation & Operation Manual
Paragon PW750F two stage Drinking Water Filtration System Installation & Operation Manual Marketed & Distributed in Singapore by: Quantum Impact Pte Ltd (UEN 201014570H) Add:16 Raffles Quay, #41-07, Hong
More informationRO.. DRINKING WATER SYSTEM
MICROLINE RO.. DRINKING WATER SYSTEM MODEL C. T. A. - 3 INSTALLATION, OPERATION & SERVICE MANUAL IMPORTANT NOTICES: This reverse osmosis system contains replaceable treatment components critical for effective
More information1 P a g e MODEL G5CT COUNTER TOP OPERATION MANUAL
1 P a g e MODEL G5CT COUNTER TOP OPERATION MANUAL Table of Contents Introduction...pg.3 Receiving..pg.4 Description Model G5CT Counter Top.......pg.5 Operation. pg.6,7 Positioning the Cooler....pg.8 Water
More informationREVERSE OSMOSIS DRINKING WATER SYSTEM
REVERSE OSMOSIS DRINKING WATER SYSTEM 12/12 1 Please fill out the following information at the time of installation. Save for future reference. Model: Sierra NS-1N30-00 Date Code: Install Date: Sold by:
More information3-STAGE WATER FILTRATION SYSTEM. INSTALLATION INSTRUCTION & OWNER S MANUAL Ver 1.5
3-STAGE WATER FILTRATION SYSTEM INSTALLATION INSTRUCTION & OWNER S MANUAL Ver 1.5 www.freedrinkingwater.com All Rights Reserved APEC Water Systems Please keep this Owner s Manual for future reference.
More informationDock-MateTM Wash-Down & Fill Systems MODELS DM-1000 DM1001 DM1002
Dock-MateTM Wash-Down & Fill Systems MODELS DM-1000 DM1001 DM1002 OWNERS AND OPERATIONS MANUAL YACHT-MATE PRODUCTS, Ltd. 3200 S. ANDREWS AVE #106 FT. LAUDERDALE, FL 33316 954-769-9564 WWW.YACHTMATE.COM
More informationInstallation and Operation Manual
Model EP-RO25 How to install, operate and maintain your Reverse Osmosis Drinking Water System Do not return unit to store If you have any questions or concerns when installing, operating or maintaining
More informationERO-375E. Undersink REVERSE OSMOSIS DRINKING WATER SYSTEM. Safety Guides Installation Operation Maintenance Repair Parts
Undersink REVERSE OSMOSIS DRINKING WATER SYSTEM ERO-375E Safety Guides Installation Operation Maintenance Repair Parts System tested and certified by NSF International against NSF/ANSI Standard 58. See
More information3-STAGE WATER FILTRATION SYSTEM INSTALLATION INSTRUCTION & OWNER S MANUAL
3-STAGE WATER FILTRATION SYSTEM INSTALLATION INSTRUCTION & OWNER S MANUAL Ver 1.2 All Rights Reserved APEC Water Systems Please keep this Owner s Manual for future reference. It contains useful information
More informationInstallation & Service Manual. Reverse Osmosis Drinking Water Systems 75 GPD with Fully Automatic Noiseless Booster Pump
Installation & Service Manual Reverse Osmosis Drinking Water Systems 75 GPD with Fully Automatic Noiseless Booster Pump Distributed by: Serial # Please read this entire service guide prior to beginning
More informationInstallation Instructions for:
Installation Instructions for: Home II Reverse Osmosis System Home II Reverse Osmosis System COMBO Installation Instructions Pre-amble. This Aquasafe Reverse Osmosis System has been specifically designed
More informationQCRO-50 QCRO-50-PUMP SRO-100 INSTALLATION MANUAL
INSTALLATION MANUAL QCRO-50 QCRO-50-PUMP SRO-100 1260 US N. Churubusco, IN 4672 Ph. (260)69-1972 Fax (260)69-0602 www.sterlingwatertreatment.com 1 QCRO Manual 180212.docx TABLE OF CONTENTS: SECTION I.
More informationPRODUCT AND INSTALLATION MANUAL. ESSENTIAL Reverse Osmosis Systems
1 Since 1987 PRODUCT AND INSTALLATION MANUAL ESSENTIAL Reverse Osmosis Systems Model Numbers: RO3, RO3-UV RO4, RO4-UV ALL FILTRATION PRODUCT PROUDLY MADE & ASSEMBLED IN THE USA EWS, Inc./Environmental
More informationWM Stage Reverse Osmosis System
WM5-50 5-Stage Reverse Osmosis System System tested and certified by NSF International against NSF/ANSI Standard 58 for the reduction of substances specified on the performance data sheet. 41840 McAlby
More informationREVERSE OSMOSIS DRINKING WATER SYSTEM
REVERSE OSMOSIS DRINKING WATER SYSTEM Model RO-14C Installation, Operation & Service Manual This system has been tested under Industry Standard S-300-91 for TDS reduction and structural integrity. TABLE
More informationHOT TANK INSTALLATION INSTRUCTIONS
HOT TANK INSTALLATION INSTRUCTIONS Model #: 5000 4500 (PRV) 5000 INSTALLATION GUIDE BEFORE YOU BEGIN YOUR INSTALLATION: 1 2 3 4 Turn off water supply. Observe all local plumbing codes. Inspect waste and
More informationR.O. DRINKING WATER SYSTEM MODEL T.F.C
M I C R O L I N E R.O. DRINKING WATER SYSTEM MODEL T.F.C. - 435 INSTALLATION, OPERATION & SERVICE MANUAL Tested and Certified by NSF International against NSF/ANSI Standard 58 for the reduction of the
More informationINSTALLATION MANUAL ARS-1
INSTALLATION MANUAL ARS-1 First Sales, LLC 12630 US 33 N. Churubusco, IN 46723 Ph. (260) 693-1972 Fax (260) 693-0602 1 ARS-1 Manual 141021 TABLE OF CONTENTS: SECTION I. SECTION II. INTRODUCTION AND LIABILITY...3
More informationINSTALLATION & USER MANUAL for Undercounter WOW RO Systems
INSTALLATION & USER MANUAL for Undercounter WOW RO Systems Place Data Label Here Scan with QR Reader App Visit our website: www.wowwater.com Powered by 23880 Madison Street, Torrance, CA 90505 - (310)
More informationThe High Efficiency Reverse Osmosis Drinking Water System Installation, Operation And Service Manual. + -DLX
The High Efficiency Reverse Osmosis Drinking Water System Installation, Operation And Service Manual. + -DLX TABLE OF CONTENTS Section I. Section II. Section III. Section IV. Section V. Section VI. Section
More informationInstallation, Operation & Service Instructions with Part List. Quick Change Reverse Osmosis Drinking Water System
Installation, Operation & Service Instructions with Part List Quick Change Reverse Osmosis Drinking Water System Models: QCRO4V-50 QCRO4V-50-PL QCRO4V-75 QCRO4V-75-PL QCRO4V-50 system certified by WQA
More informationPWC 1800 PureWaterCooler SERVICE MANUAL. for. PureWaterCooler by Vertex Model PWC P/N man Copyright 2011 Vertex Water Products
SERVICE MANUAL for by Vertex Model PWC-1800 P/N man-7011 Table of Contents 1. Introduction 2. Cooler Set-up 3. Remove Top Cover 4. Remove/Replace Float 5. Remove/Replace Hot Tank 6. Dispensing Solenoid
More informationNSRO42C4. How to Install, operate and maintain your Reverse Osmosis Drinking Water System
NSRO42C4 How to Install, operate and maintain your Reverse Osmosis Drinking Water System If you have any questions or concerns when installing, operating or maintaining your Reverse Osmosis System call
More informationINSTALLATION, OPERATION AND SERVICE MANUAL GUARDIAN R.O. DRINKING WATER SYSTEM WITH WATER QUALITY MONITOR MODEL LRO-35
INSTALLATION, OPERATION AND SERVICE MANUAL GUARDIAN R.O. DRINKING WATER SYSTEM WITH WATER QUALITY MONITOR MODEL LRO-35 Tested and Certified by NSF International against NSF/ANSI Standard 58 for the reduction
More informationDrinking Water Purification Systems
supersedes 200695Cx-2i&o SEAGULL IV X-2KB and X-2KF Drinking Water Purification Systems SEAGULL IV X-2KB SEAGULL IV X-2KF INSTALLATION AND PRODUCT USE GUIDE INSTALLATION INSTRUCTIONS NOTE: Read instructions
More informationOwners Manual. Economy RO. Installation, Operation & Service Instructions with Parts List Economy Reverse Osmosis Drinking Water System
Owners Manual Economy RO Installation, Operation & Service Instructions with Parts List Economy Reverse Osmosis Drinking Water System Models: RO75, RO75BP Canada West 855 Park St., Unit 1 Regina, SK S4N
More informationINSTALLATION INSTRUCTION Ver
ispring Reverse Osmosis Water Filter Systems INSTALLATION INSTRUCTION Ver 2005-6 Copyright 2005-2015 ISPRING WATER SYSTEMS, LLC. All rights reserved. Please keep this owner s manual for future reference.
More informationINSTALLATION MANUAL DWSB-TFC-50
INSTALLATION MANUAL DWSB-TFC-50 12630 US 33 N. Churubusco, IN 46723 Ph. (260)693-1972 Fax (260)693-0602 www.sterlingwatertreatment.com DWSB Manual 180822.docx TABLE OF CONTENTS: SECTION I. SECTION II.
More informationModel MRO-35 INSTALLATION, OPERATION & SERVICE MANUAL
Millennium Reverse Osmosis Drinking Water System Model MRO-35 INSTALLATION, OPERATION & SERVICE MANUAL Tested and Certified by NSF International against NSF/ANSI Standard 58 for the reduction of the claims
More informationInstallation, Operation and Maintenance Manual AQPC-35. TFC Reverse Osmosis Drinking Water System
Installation, Operation and Maintenance Manual AQPC-35 TFC Reverse Osmosis Drinking Water System Tested and Certified by NSF International against NSF/ANSI Standard 58 for the reduction of the claims specified
More informationR.O. Drinking Water System Model No. UltroWater INSTALLATION, OPERATION & SERVICE MANUAL
R.O. Drinking Water System Model No. UltroWater INSTALLATION, OPERATION & SERVICE MANUAL Tested and Certified by NSF International against NSF/ANSI Standard 58 for the reduction of the claims specified
More informationINSTALLATION INSTRUCTIONS
Please read carefully and retain for future reference. CONTENTS 1. Important Information 2. Included Parts 3. Filter Head Assembly Instructions 4. Installation Instructions 4.1. Auxiliary Tap Connection
More informationInstallation Instructions for:
Installation Instructions for: Maximus II Reverse Osmosis System with Remineralization Maximus II Reverse Osmosis System COMBO with Remineralization Installation Instructions Pre-amble. This Aquasafe Reverse
More information25 Year Limited Warranty
REVERSE OSMOSIS APPLIANCE OWNER S MANUAL AND INSTALLATION GUIDE MODELS H2000, H2500, H3000, H3500, LC50P, AND LC100P VERSION 4.4 25 Year Limited Warranty To place the equipment under warranty, the warranty
More informationR.O. DRINKING WATER SYSTEM MODEL T.F.C
M I C R O L I N E R.O. DRINKING WATER SYSTEM MODEL T.F.C. - 335 INSTALLATION, OPERATION & SERVICE MANUAL Tested and Certified by NSF International against NSF/ANSI Standard 58 for the reduction of the
More informationWhole House Descaler Installation Instructions
Whole House Descaler Installation Instructions MODEL HF-SOFT Safe, effective scale prevention without the use of chemicals or salt. HF-SOFT DIRECTION OF FLOW 26" Shut-Off Valve 48" 5-Micron Pre-Filter
More informationWL380 QUICK START GUIDE
WL380 QUICK START GUIDE WARNING! Only trained and qualified technicians should attempt to install, maintain, or service Waterlogic equipment. Failure to follow all instructions in this manual could result
More informationOwners Manual FOR REVERSE OSMOSIS SYSTEMS MODEL ET6500 (P/N )
Owners Manual FOR REVERSE OSMOSIS SYSTEMS MODEL ET6500 (P/N 10-02-1330) Includes: Installation and Service Procedures, Specifications and Operation Guidelines 07\15 RO Manual A TABLE OF CONTENTS Introduction
More informationReverse Osmosis Filter Change Guide
Reverse Osmosis Filter Change Guide Written by 602abcWATER Start Here Con irm Your ilter order. Open your packages and confirm that you have received all the correct filters. If you are missing or sent
More informationAdvanced Two-Stage Drinking Water Filter
OWNER'S MANUAL E L I T E Advanced Two-Stage Drinking Water Filter MODEL NO. 625.385010 Caution: Read and follow all safety rules and operating instructions before first use of this product. Questions?
More informationSERIES OWNER MANUAL DP1000(B) Please read this manual carefully prior to operating your Drinkpod. Retain for future reference.
1000 SERIES DP1000(B) OWNER MANUAL Please read this manual carefully prior to operating your Drinkpod. Retain for future reference. Safety caution & usage Temperature Please use the product in a dry place
More informationHome Master Reverse Osmosis System Installation & Service Manual
Perfect Water Technologies 10 Tips for an Easy and Successful Installation 1. Keep it simple - there are 4 connections to make, and the tubing is color coded. VIDEO INSTRUCTIONS ARE AVAILABLE ONLINE (6
More informationFountain Classic. Installation and Owner s Manual. Page 16
Fountain Classic Installation and Owner s Manual Page 16 4120 NW 44th St Lincoln, NE 68524 USA Tel: 402.467.9300 Toll Free in the USA: 800.875.5915 Fax: 402.467.9393 www.purewaterinc.com Page 2 Fountain
More information