CG Section and Base Assembly Series 1 through 12

Transcription

1 GAS CG Section and Base Assembly Series through B 0A 7 22 Discontinued Service Parts

2 CG Section and Base Assembly Series through 2 GAS Fig. No. Part No. Description Series No Left Hand End Section Right Hand End Section Intermediate Section Section Assembly: CGM, P-CG(m) 25, Section Assembly: CGM, P-CG9(m) Section Assembly: CGM, P-CG(m) Section Assembly: CGM, P-CG(m) Section Assembly: CGM, P-CG(m) Section Assembly: CGM, P-CG(m) Section Replacement Kit (one per Joint) Square Cut Seal 2" Retort Cement quart Silicone Sealant RTV 700, 0.3 oz. tube Flue-way Brush Well for Limit Control Vertical Draft Hood CG(m) Vertical Draft Hood CG(m) Vertical Draft Hood CG(m) Vertical Draft Hood CG(m) Vertical Draft Hood CG(m) Vertical Draft Hood CG(m) Vertical Draft Hood CG(m) Collector Hood Replacement Kit, CG Collector Hood Replacement Kit, CG Collector Hood Replacement Kit, CG Collector Hood Replacement Kit, CG Collector Hood Replacement Kit, CG Collector Hood Replacement Kit, CG Collector Hood Replacement Kit, CG Natural Gas Orifice 46 Drill 7/6" Hex, /8" N.P.T LP Gas Orifice 56 Drill 7/6" Hex, /8" N.P.T Natural Gas Orifice 2.0mm Drill, 7/6" Hex, /8" N.P.T LP Gas Orifice.3mm Drill, 7/6" Hex, /8" N.P.T Stainless Steel Burner with Pilot Bracket, See Note Stainless Steel Regular Burner, See Note Steel Pilot Burner with Pilot Bracket, PI version only, See Note Steel Regular Burner with Pilot Bracket, SP version only, See Note 9-2 Discontinued Service Parts 23

3 GAS CG Section and Base Assembly Series through Base Burner Rest CG(m) Base Burner Rest CG(m) Base Burner Rest CG(m) Base Burner Rest CG(m) Base Burner Rest CG(m) Base Burner Rest CG(m) Base Burner Rest CG(m) Manifold CG(m) Manifold CG(m) Manifold CG(m) Manifold CG(m) Manifold CG(m) Manifold CG(m) Manifold CG(m) Base Front Cross Tie CG(m)-25, Base Front Cross Tie CG(m) Base Front Cross Tie CG(m) Base Front Cross Tie CG(m) Base Front Cross Tie CG(m) Base Front Cross Tie CG(m) Base Access Panel CG(m)-25, Base Access Panel CG(m) B Base Access Panel CG(m) Base Access Panel CG(m) Base Access Panel CG(m) Base Access Panel CG(m) Base Back Cross Tie CG(m)-25, Base Back Cross Tie CG(m) Base Back Cross Tie CG(m) Base Back Cross Tie CG(m) Base Back Cross Tie CG(m) Base Back Cross Tie CG(m) Base Side Panel Base Replacement Carton CG9(m) Base Replacement Carton CG(m) Base Replacement Carton CG(m) Base Replacement Carton CG(m) Base Replacement Carton CG(m) Base Replacement Carton CG(m) Base Replacement Carton CG(m) Base Pan Angle R.H Base Pan Angle L.H Discontinued Service Parts

4 CG Section and Base Assembly Series through 2 GAS Base Pan CG(m)-25, Base Pan CG(m) A Base Pan CG(m) Base Pan CG(m) Base Pan CG(m) Base Pan CG(m) Radiation Plate with Horizontal Bends ( per Joint) Base Replacement Insulation Carton CG(m) Base Replacement Insulation Carton CG(m) Base Leg Assembly -/2" gray (4 per boiler) /6" X 9" Tie Rod without Nut (3 per boiler) CG(m)-25, /6" X 2" Tie Rod without Nut (3 per boiler) CG(m) /6" X 5" Tie Rod without Nut (3 per boiler) CG(m) /6" X 8" Tie Rod without Nut (3 per boiler) CG(m) /6" X 2" Tie Rod without Nut (3 per boiler) CG(m) /6" X 24" Tie Rod without Nut (3 per boiler) CG(m) /6" Washer Medium Plain Split Lock 8-2 NOTE : : Number of burners: CG-25 2 main burners & burner w/ Pilot bracket, CG-3 3 main burners & burner w/ Pilot bracket, CG-4 5 main burners & burner w/ Pilot bracket, CG-5 7 main burners & burner w/ Pilot bracket, CG-6 9 main burners & burner w/ Pilot bracket, CG-7 main burners & burner w/ Pilot bracket, CG-8 3 main burners & burner w/ Pilot bracket. Discontinued Service Parts 25

5 GAS CG/CGM Series 9 & 0 Standing Pilot Fig. No. Part No. Description Mfr. Mfr. s Part No. Boiler Size Components for Natural Gas Combination Gas Valve, ½" X ½" N.P.T., 24 Volt Combination Gas Valve (step opening (.2 step) 3/4" X 3/4" N.P.T., 24 Volt) Robertshaw VR8200A26 7AO-AB-042 VR8300C4050 VR800C307 NS Natural Gas Pilot Orifice,.08 Dia. Beckett Gas P8U2 Components for Propane Gas NS NA Combination Gas Control Valve, ½" x ½" N.P.T., 24 Volt, propane gas, need regulator below VR800A Propane Regulator for VR800A-52 V5306B Combination Gas Control Valve, ¾" x ¾" N.P.T., 24 Volt propane gas, need regulator below, CG7 CG8 VR800C NA Propane Regulator for VR800C-302 V5307A NS Propane Gas Pilot Orifice,.00 Dia. Beckett Gas P0U Components for Natural and Propane Gas Safety Pilot Burner, constant burning, thermally supervised Beckett Gas E38A Thermocouple, 48" Long White-Rodgers H06E048-02B Pilot Tubing, /8" O.D. Alum. X 22 ¾" long with Compression Fittings Combination Transformer-Relay Receptacle, 20/24 Volt, 40VA White-Rodgers S84A-85 R8285K-004 Products Unlimited 57-0E07C5F23 26 Discontinued Service Parts

6 CG/CGM Series 9 & 0 Standing Pilot GAS Fig. No. Part No. Description Mfr. Mfr. s Part No. Boiler Size Plug-In Relay, DPST, 24 Volt Holding Coil 6, Combination Transformer and DPST Relay, 20/24 Volt, 40 VA Rollout Thermal Fuse Element, 228 C Spill Switch with reset, 20 C Spill Switch with reset, 2400 C R8222U-006 White-Rodgers R8285D000 Elmwood Sensors Thermodisc Inc. Elmwood Sensor Elmwood Sensor RD GM06042C 2455RM RM CG(m) 25 CG(m) 3-8 Discontinued Service Parts 27

7 GAS CG/CGM Series 7-0 Spark Ignition Components Control List Part No. Description Mfr. Mfr. s Part No. Boiler Size Conversion Kit (Includes: /2 Gas Valve, Pilot Assy with Sparker and Sensor. United Technology Control Module, wiring and instructions) Conversion Kit (Includes: 3/4 Gas Valve, Pilot Assy with Sparker and Sensor. United Technology Control Module, wiring and instructions) Johnson G60 Pilot Assembly Repair Parts Pilot Assy, natural gas, includes Sparker and Sensor and wires Johnson J992 LYW Flame Sensor for above Pilot Assy Johnson Y75AA Sensor Wire for above Pilot Assy Johnson Y57HH-30 Common Control Parts for Series High Limit Temperature Control, auto recycle, F, 30 fixed subtractive differential, with ½ NPT well Combination Transformer-Relay Receptacle, 20/24 Volt, 40VA L4080D-036 R8285K Plug-In Relay, DPST, 24 Volt Holding Coil R8222U Combination Transformer and DPST Relay, 20/24 Volt, 40 VA Rollout Thermal Fuse Element, 228 C Spill Switch with Reset, 20 C Spill Switch with Reset, 240 C R8285D000 Elmwood Sensors Thermodisc Inc. Elmwood Sensor Elmwood Sensor RD GM06042C 2455RM RM CG(m) 25 CG(m) Discontinued Service Parts

8 CG/CGM Series 0 Millivolt GAS Fig. No. Part No. Description Mfr. Mfr. s Part No. Boiler Size Components for Natural Gas N Combination Gas Valve, ½" X ½" N.P.T., Milli-volt VS820A N Natural Gas Pilot Orifice,.026 Dia. Beckett Gas P8U2 P P NA NA Components for Propane Gas Combination Gas Control Valve, ½" x ½" N.P.T., 24 Volt, Propane Gas, need regulator below Combination Gas Control Valve (¾" x ¾" N.P.T., milli-volt, step opening with 3.0 step, need propane regulator below) VS820A VS820C P NA Propane Regulator V5307A l Components for Natural and Propane Gas Safety Pilot Burner, constant burning, thermally supervised Pilot Tubing, /8" O.D. Alum. X 22 ¾" long with Compression Fittings Combination Transformer and DPST Relay, 20/24 Volt, 40 VA Rollout Thermal Fuse Element, 228 C Q327A-642 R8285D000 Elmwood Sensors RD Thermodisc Inc. GM06042C Spill Switch with Reset, 20 C Elmwood Sensor Spill Switch with Reset, 240 C Elmwood Sensor 2455RM RM Discontinued Service Parts 29

9 GAS 7 CG/CGM Series 0 Trim Fig. No. Part No. Description Mfr High Limit Temperature Control, auto recycle, F gixed subtractive differential with /2" N.P.T. well Mfr. s Part No. L4080D Combination Operating Limit, F, fixed high limit, 240 F Carlin ASME Pressure Relief Valve, set to relieve at 30 PSIG, 3/4: N.P.T. female Inlet Combination Pressure-Temperature Gauge, 3" Dia., 0-75 PSIG, F, short shank, back connection, /4" N.P.T Drain Valve, 3/4" N.P.T., /2" shank, brass Watts 335 Conbraco Amekai OS234- JDTW Circulator, /25 HP, 20/60/ motor,,750 R.P.M.,.75 Amps Taco Circulator, /2 HP, 20/60/ motor,,750 R.P.M. Bell & Gossett 00 Series Circulator Gasket for Taco 007, (two required per circulator) Taco Circulator Gasket for B & G 00, (two required per circulator) Bell & Gossett PO Circulator Hardware Kit (Includes: Flange, 2 Bolts, 2 Nuts, Diamond Gasket, 3/4" N.P.T.) Circulator Hardware Kit (Includes: Flange, 2 Bolts, 2 Nuts, Diamond Gasket, " N.P.T.) Circulator Hardware Kit (Includes: Flange, 2 Bolts, 2 Nuts, Diamond Gasket, /4" N.P.T.) Circulator Hardware Kit (Includes: Flange, 2 Bolts, 2 Nuts, Diamond Gasket, /2" N.P.T.) Fill-Trol Diaphragm Expansion Tank with O" Ring and Machine Thread Connector to Fill Valve, Tank Only Fill-Trol Diaphragm Expansion Tank with O" Ring and Machine Thread Connector to Fill Valve, Tank Only Fill Valve Angle Style-90 with Built-in Strainer, Pressure Reducer, Check Valve requires user provided shut-off valve Am-Trol 09 Am-Trol 0 Conbraco Discontinued Service Parts

10 CG Series & 2 Universal Control System GAS Fig. No. Part No. Description Mfr. Mfr. s Part No Combination Gas Valve, /2" x /2" N.P.T., 24 Volt CG-25 to CG-6 Combination Gas Valve (step opening (.2" WC step) 3/4" x 3/4" N.P.T., 24 Volt, CG-7,8) Pilot Assembly Kit (includes: Orifice, Aluminum Pilot Gas Tubing, Spark Wire and Sense Wire) Robertshaw White-Rodgers White-Rodgers Precision Speed Equipment VR8204A200 7D-D5B E S VR8304P C S PSE-NA Pilot tubing, /8" O.D. x 22-3/4", with fittings White-Rodgers F Ignition Sensing Control Module without Damper Molex, 24 Volt, series 2 only United Technology Wiring Harness, PIDN, series 2 only Ignition Sensing Control Module with Damper Molex, 24 volt, series only United Technology S8620C Series 6 0 Boilers White-Rodgers Cycle Pilot Ignition Systems and Johnson Control Ignition Systems are obsolete and replaced by the following conversion kits: Spark Pilot Conversion Kit (Includes: UT Control Module, /2" Gas Valve, Pilot Assembly, Wiring and instructions) Natural gas only CG 25-6 Spark Pilot Conversion Kit (Includes: UT Control Module, 3/4" Gas Valve, Pilot Assembly, Wiring and instructions) Natural gas only CG 7-8 Note: There is no Wiring Harness for series boilers. Boiler had individual wires. Discontinued Service Parts 3

11 GAS CG Series & 2 Trim Discontinued Service Parts

12 CG Series & 2 Trim GAS Fig. No. Part No. Description Mfr. Mfr. s Part No High Limit Temperature Control, auto recycle, F fixed subtractive differential with /2" N.P.T. well ASME Pressure Relief Valve, set to relieve at 30 PSIG, 3/4" N.P.T. female inlet ASME Pressure Relief Valve, set to relieve at 30 PSIG, 3/4" N.P.T. male inlet Combination Pressure-Temperature Gauge, 3" Dia., 0-75 PSIG, F, short shank, back connection, /4" N.P.T Drain Valve, 3/4" N.P.T., /2" shank, brass 9 0 0, Circulator, /25 HP, 20/60/ motor,,750 R.P.M.,.75 Amps Circulator, /2 HP, 20/60/ motor,,750 R.P.M. Circulator Gasket for Taco 007, (two required per circulator) Circulator Gasket for B & G 00, (two required per circulator) Circulator Hardware Kit (Includes: Flange, 2 Bolts, 2 Nuts, Diamond Gasket, 3/4" N.P.T.) Circulator Hardware Kit (Includes: Flange, 2 Bolts, 2 Nuts, Diamond Gasket, " N.P.T.) Circulator Hardware Kit (Includes: flange, 2 bolts, 2 nuts, Diamond gasket, /4" N.P.T.) Circulator Hardware Kit (Includes: Flange, 2 Bolts, 2 Nuts, Diamond Gasket, /2" N.P.T.) L4080D-036 Watts 335 Conbraco Watts Amekai M330 OS234-JDTW-00 Taco 007 Bell & Gossett 00 Series Taco Bell & Gossett Damper Wiring Harness with Molex 4 PO Vent Damper Motor Operator with Molex Effikal RVGP Vent Damper Assembly, 4", CG-25, Vent Damper Assembly, 5", CG Vent Damper Assembly, 6", CG-5, Vent Damper Assembly, 7", CG-7, 8 5, Combination Transformer and DPST Relay, 20/24 Volt, 40 VA Feld Controls Effikal Feld Controls Effikal Feld Controls Effikal Feld Controls Effikal GVD-4 RVGP-KS-4BKF GVD-5 RVGP-KS-5BKF GVD-6 RVGP-KS-6BKF GVD-7 RVGP-KS-7BKF R8285D000 Discontinued Service Parts 33

13 GAS CG Series & 2 Trim Fig. No. Part No. Description Mfr. Mfr. s Part No Combination Transformer and Relay Receptacle (relay ordered separately)20/24 Volt, 40VA Plug-In Relay, DPST, with 24 Volt Holding Coil R8285K004 R8222U006 Products Unlimited Q223 White-Rodgers Rollout Thermal Fuse, 228 C Elmwood Sensors RD Spill Switch with Manual Reset, 20 F CG-25 only Spill Switch with Manual Reset, 240 F CG-3 thru 8 Fill-Trol Diaphragm Expansion Tank with O" Ring and Machine Thread Connector to Fill Valve, Tank Only Fill-Trol Diaphragm Expansion Tank with O" Ring and Machine Thread Connector to Fill Valve, Tank Only Fill Valve Angle Style-90 with Built-in Strainer, Pressure Reducer, Check Valve requires user provided shut-off valve Elmwood Sensors Elmwood Sensors 2455RM RM Am-Trol 09 Am-Trol 0 Conbraco Discontinued Service Parts

14 CG Series & 2 Standing Pilot GAS 2 Fig. No. Part No. Description Mfr. Mfr. s Part No. Components for Natural Gas Combination Gas Valve, ½" X ½" N.P.T., 24 Volt Combination Gas Valve (step opening (.2 step) 3/4" X 3/4" N.P.T., 24 Volt) Natural Gas Pilot Replacement Kit (Includes: Main Burner with Pilot Bracket, Pilot Burner, Thermocouple) Thermo-couple 30", screw in (Natural Gas) Components for Propane Gas Combination Gas Valve, /2" x /2" N.P.T., 24 Volt Combination Gas Control Valve, ¾" x ¾" N.P.T., 24 Volt propane gas LP Gas Pilot Replacement Kit (Includes: Main Burner with Pilot Bracket, Pilot Burner, Thermocouple) Robertshaw VR8200A26 7AO-AB-042 VR8300C4050 VR800C307 Boiler Size Q350A305 VR8200A VR82A VR800C Thermo-couple 48", push in (propane gas) Components for Natural and Propane Gas NS Wiring Harness series Pilot Tubing, /8" O.D. Alum. X 22 ¾" long with Compression Fittings Pilot Regulator Kit (Includes: Maxitrol RV-2 Regulator, Tubing and Fittings) Wiring Harness for Standing Pilot Damper Precision Speed Equipment E38A2 Maxitrol RV-2LT 25-3 Discontinued Service Parts 35