KITCHENAID CONSUMER SERVICES Technical Training Department

Transcription

1 KITCHENAID CONSUMER SERVICES Technical Training Department Failure Codes & Wiring Diagrams for KitchenAid Freestanding & Slide-In Ranges And Built-In Ovens All rights reserved. No portion of this document may be reproduced in any form without written permission from Whirlpool Corporation. Part No. 66

2 ELECTRONIC OVEN CONTROLS BAKE BAKE AUTO SET BROIL CLEAN CONVECTION BROIL ROAST TEMP PROBE START : DELAY/D STOP CLOCK SET OVEN LIGHT KITCHEN R SET CANCEL START ENTER CANCEL OFF Figure BAKE BROIL CLEAN START : DELAY/D STOP CLOCK SET OVEN LIGHT KITCHEN R SET CANCEL START ENTER CANCEL OFF Figure ON : :0 : : 5 6 HR. MIN MIN SEC START BAKE BROIL CLEAN CONVECTION BAKE BROIL ROAST EASY CONVECT BAKED OTHER GOODS MEATS FOODS COOK STOP CONVECT 0 OVEN FULL LIGHT MEAL SURFACE LIGHT ON LIGHT OFF CLOCK SET START R SET-START CANCEL CANCEL OFF Figure ON : START 5 6 BAKE BROIL CLEAN CLOCK SET START R SET-START CANCEL COOK STOP SURFACE LIGHT 0 OVEN LIGHT CANCEL OFF Figure

3 EASY CONVECT 50 ON F :0 :00 :0 5 F 5 6 :00 CHECK FOOD AT START CONVECTION COOK EASY CONVECT ON CONTROL LOCK START UPPER OVEN BAKE BROIL MAXI ECONO CLEAN LOWER CONVECTOIN OVEN BAKE BROIL ROAST EasyConvect CONVERSION BAKED GOODS MEATS OTHER FOODS COOK STOP CONVECT FULL MEAL 0 OVEN LIGHT CLOCK SET-START R SET-START CANCEL UPPER OVEN CANCEL / OFF LOWER OVEN CANCEL / OFF Superba Figure 5 EASY CONVECT 50 ON F :0 :00 :0 50F 5 6 :00 CONVECTION COOK CHECK FOOD AT START ON CONTROL LOCK START UPPER OVEN BAKE BROIL MAXI ECONO CLEAN LOWER CONVECTOIN OVEN BAKE BROIL ROAST EasyConvect CONVERSION BAKED GOODS MEATS OTHER FOODS COOK STOP CONVECT FULL MEAL 0 OVEN LIGHT CLOCK SET-START R SET-START CANCEL UPPER OVEN CANCEL / OFF LOWER OVEN CANCEL / OFF Superba Figure 6 EASY CONVECT 50 ON F :00 CONVECTION START :0 :0 5 6 :00 CONTROL LOCK CHECK FOOD AT COOK START BROIL BAKE CLEAN MAXI ECONO CONVECTOIN BAKE BROIL ROAST EasyConvect BAKED MEATS GOODS CONVERSION OTHER FOODS COOK STOP CONVECT FULL MEAL 0 OVEN LIGHT CLOCK SET-START SET-START R CANCEL CANCEL OFF Superba Figure ON :00 ON START UPPER OVEN LOWER OVEN COOK CLOCK BROIL SET-START BAKE MAXI CLEAN ECONO R SET-START CANCEL COOK STOP CONTROL LOCK OVEN LIGHT UPPER OVEN CANCEL / OFF LOWER OVEN CANCEL / OFF Figure EASY CONVECT 50 ON F :00 CONVECTION COOK LOWER OVEN CHECK FOOD AT :0 :0 START 50F ON 5 6 CONTROL LOCK :00 MICRO OVEN CLOCK SET-START SET-START R CANCEL BROIL BAKE CLEAN MAXI ECONO CONVECTION BAKE BROIL ROAST EasyConvect BAKED MEATS GOODS CONVERSION OTHER FOODS COOK STOP START LOWER OVEN CANCEL / OFF CONVECT FULL MEAL 0 OVEN LIGHT POPCORN MINS MICRO COOK POWER CUSTOM REHEAT BROIL CUSTOM DEFROST CRISP CUSTOM COOK KEEP WARM EasyMinute START MICRO OVEN CANCEL Superba Figure

4 TECH SHEET LOCATIONS Behind Control Panel 5 5 Behind Control Panel Behind Control Panel Behind Control Panel

5 Model # Figure # (Page ) Touch Panel Part # Description Tech Sheet Part # Page # KERC500EAL KERC500EAL KERC500EWH0 KERC500EWH KERC500EWH KERC500EWH KERC500YAL KERC500YAL KERC500YAL KERC500YAL5 KERC500YBL KERC500YBL KERC500YBL KERC500YBL5 KERC50EAL KERC50EAL KERC50EBL KERC50EBL KERC50EWH0 KERC50EWH KERC50EWH KERC50EWH KERC50YAL KERC50YAL KERC50YAL5 KERC50YWH KERC50YWH KERC50YWH KERC50YWH5 KERC600EAL0 KERC600EAL KERC600EAL KERC600EWH0 KERC600EWH KERC600EWH KERC60EAL0 KERC60EAL KERC60EAL KERC60EWH0 KERC60EWH KERC60EWH KERH50EWH0 KERH50EWH CW 5CW CT 5CT 5CB 5CB 0 5CW 5CW A.C.T. NON-CONVECTION A.C.T. NON-CONVECTION A.C.T. NON-CONVECTION A.C.T. NON-CONVECTION KITCHENAID R THERMOSTAT KITCHENAID R THERMOSTAT KITCHENAID R THERMOSTAT KITCHENAID R THERMOSTAT KITCHENAID R ASSEMBLY KITCHENAID R ASSEMBLY KITCHENAID R ASSEMBLY KITCHENAID R ASSEMBLY A.C.T. CONVECTION A.C.T. CONVECTION A.C.T. CONVECTION A.C.T. CONVECTION A.C.T. CONVECTION A.C.T. CONVECTION KITCHENAID CONVECTION KITCHENAID CONVECTION KITCHENAID CONVECTION KITCHENAID KITCHENAID KITCHENAID KITCHENAID D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION

6 Model Figure # (Page ) Touch Panel Part # Description Tech Sheet Part # Page # KERH50YAL KERH50YAL KERH50YAL KERH50YAL5 KERH50YBL KERH50YBL KERH50YBL KERH50YBL5 KERH50YWH KERH50YWH KERH50YWH KERH50YWH5 KERI500EAL KERI500EWH KERI500YAL KERl500YAL KERS50EAL KERS50EWH0 KERS50EWH KERS50YAL KERS50YAL KERS50YWH KERS50YWH KERS50YWH KESC00BAL KESC00BAL KESC00BAL KESC00BAL KESC00BAL5 KESC00BAL6 KESC00BBL KESC00BBL KESC00BBL KESC00BBL KESC00BBL5 KESC00BBL6 KESC00BWH0 KESC00BWH KESC00BWH KESC00BWH KESC00BWH KESC00BWH5 KESC00BWH CW CT 5CW 5CW KITCHENAID CONVECTION KITCHENAID CONVECTION KITCHENAID CONVECTION KITCHENAID CONVECTION KITCHENAID R ASSY. CONV. KITCHENAID R ASSY. CONV. KITCHENAID R ASSY. CONV. KITCHENAID R ASSY. CONV. KITCHENAID KITCHENAID KITCHENAID KITCHENAID A.C.T. NON-CONVECTION A.C.T. NON-CONVECTION KITCHENAID R THERMOSTAT KITCHENAID R THERMOSTAT A.C.T. CONVECTION A.C.T. CONVECTION A.C.T. CONVECTION KITCHENAID CONVECTION KITCHENAID CONVECTION KITCHENAID KITCHENAID KITCHENAID D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION

7 Model Figure # (Page ) Touch Panel Part # Description Tech Sheet Part # Page # KESC0BAL KESC0BAL KESC0BAL KESC0BAL KESC0BAL5 KESC0BAL6 KESC0BWH KESC0BWH KESC0BWH KESC0BWH KESC0BWH5 KESC0BWH6 KESH0BAL KESH0BAL KESH0BAL KESH0BAL KESH0BAL5 KESH0BAL6 KESH0BBL KESH0BBL KESH0BBL KESH0BBL KESH0BBL5 KESH0BBL6 KESH0BWH KESH0BWH KESH0BWH KESH0BWH KESH0BWH5 KESH0BWH6 KESS00BAL0 KESS00BWH0 KGRT500BAL KGRT500BAL KGRT500BAL KGRT500BAL KGRT500BWH KGRT500BWH KGRT500BWH KGRT500BWH KGRT500FAL0 KGRT500FWH0 KGRT50BAL D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION

8 Model Figure # (Page ) Touch Panel Part # Description Tech Sheet Part # Page # KGRT50BAL KGRT50BAL KGRT50BAL KGRT50BBL KGRT50BBL KGRT50BBL KGRT50BBL KGRT50BWH KGRT50BWH KGRT50BWH KGRT50BWH KGRT50FAL0 KGRT50FBL0 KGRT50FWH0 KGST00BAL0 KGST00BAL KGST00BAL KGST00BAL KGST00BWH0 KGST00BWH KGST00BWH KGST00BWH KGST00FAL0 KGST00FWH0 KGST0BAL0 KGST0BAL KGST0BAL KGST0BAL KGST0BBL0 KGST0BBL KGST0BBL KGST0BBL KGST0BWH0 KGST0BWH KGST0BWH KGST0BWH KGST0FAL0 KGST0FBL0 KGST0FWH D.A.C. CONTROL CONVECTION D.A.C. CONTROL CONVECTION D.A.C. CONTROL CONVECTION D.A.C. NON-CONVECTION D.A.C. NON-CONVECTION D.A.C. CONTROL CONVECTION D.A.C. CONTROL CONVECTION D.A.C. CONTROL CONVECTION

9 BUILT-IN MODEL OVENS TOUCH PANEL COLORS Black White Almond Biscuit Black Stainless NOTE: The charts on the following pages show only white touch panels. For other touch panel colors, refer to the above chart.

10 Model Figure # (Page ) Touch Panel Part # Description Electronic Control Tech Sheet Part # Page # KEBI0DWH0 KEBI0DWH KEBI0DWH KEBI0DWH KEBI0DWH6 KEBI0DWH KEBIDWH0 KEBIDWH KEBIDWH KEBIDWH KEBIDWH6 KEBIDWH KEBIDWH0 KEBIDWH KEBIDWH KEBIDWH KEBIDWH6 KEBIDWH KEBI6DWH0 KEBI6DWH KEBI6DWH KEBI6DWH KEBI6DWH6 KEBS0DWH0 KEBS0DWH KEBS0DWH KEBS0DWH KEBS0DWH6 KEBS0DWH KEBSDWH0 KEBSDWH KEBSDWH KEBSDWH KEBSDWH6 KEBSDWH KEBSDWH0 KEBSDWH KEBSDWH KEBSDWH KEBSDWH6 KEBSDWH Thermal Double Oven Thermal Double Oven Thermal Double Oven Thermal Double Oven Thermal Double Oven

11 Model Figure # (Page ) Touch Panel Part # Description Electronic Control Tech Sheet Part # Page # KEBS0DWH0 6 Upper 500 KEBS0DWH 6 55 Upper 050 KEBS0DWH 6 55 Upper 5 KEBS0DWH 6 55 Upper 5 KEBS0DWH Upper KEBS0DWH0 5 Double 500 KEBS0DWH 5 56 Double 5 KEBS0DWH 5 56 Double 5 KEBS0DWH 5 56 Double 5 KEBS0DWH Double KEBSDWH0 6 Upper KEBSDWH 6 5 Upper 5 KEBSDWH 6 5 Upper 5 KEBSDWH 6 5 Upper 5 KEBSDWH6 6 5 Upper KEBSDWH0 6 Upper KEBSDWH 6 5 Upper 5 KEBSDWH 6 5 Upper 5 KEBSDWH 6 5 Upper 5 KEBSDWH6 6 5 Upper KEBSDWH0 5 Double 500 KEBSDWH 5 50 Double 5 KEBSDWH 5 50 Double 5 KEBSDWH 5 50 Double 5 KEBSDWH Double KEMS0DWH 506 Microwave/Thermal Oven KEMS0DWH 506 Microwave/Thermal Oven 6 5 KEMS0DWH 506 Microwave/Thermal Oven 6 5 KEMS0DWH6 506 Microwave/Thermal Oven 6 50 KEMS0DWH0 Microwave/ KEMS0GWH0 566 Microwave/ KEMSDWH 506 Microwave/Thermal Oven KEMSDWH 506 Microwave/Thermal Oven 6 5 KEMSDWH 506 Microwave/Thermal Oven 6 5 KEMSDWH6 KEMSGWH0 KEMSDWH0 KEMSGWH Microwave/Thermal Oven Microwave/Thermal Oven Microwave/ Microwave/

12 F F F F Control out of calibration: Place the sensor in ice water ( F) and check the resistance (000 ±0 Ω). If the resistance is not within the specified range, replace the sensor. If sensor resistance is okay, replace the control module. Keyboard shorted. Cancel not operating: Press the CANCEL keypad. Press the BAKE keypad and wait for 0 seconds. If the F code remains, replace the electronic control. Oven probe shorted or open: Place the sensor in ice water ( F) and check resistance (000 ±0 Ω). If the resistance is not within the specified range, replace the sensor. If sensor resistance is okay, replace the control module. Meat probe shorted: Make sure the meat probe is plugged in. Check the probe for 5000 Ω at room temperature and 000 Ω at 00 F. FAILURE CODES F 5 F 6* F * Door signal inconsistent: Open and close the door to see if the oven light responds. If the oven light does not operate properly, replace the door switch. Ambient (console bimetal) sensor open (too hot): Check control bimetal. Control or keypad switches shorted: Check continuity of door and latch switches. P F Power Failure: Power has been turned on for the first time, or power has been interrupted. Temperature Calibration Press and hold the BAKE keypad for seconds. The timer will show the current setting. Press the Bake keypad again to calibrate the oven temperature. Each press of the up s or down t keypad will change the calibration temperature by 5 F to a maximum of ±5 F. * Not used on some oven controls. HIDDEN CODES To obtain the hidden codes, press and hold each of the following pads for 5 seconds: BAKE Oven calibration allows bake temperature to be varied ± 5 BROIL Toggles between Fahrenheit (F) and Celsius (C). 0 Displays the last failure (F/E) code that was used and the latest ROM revision. Shows the type of range the electronic control is configured for. Locks out the keypads so they cannot be used. 6 Switches the range to SABBATH mode. Changes the tone frequency.

13 F = F = F = F = F 5 = F 6 = F = UNIVERSAL FAILURE & ERROR CODES Electronics Subsystem Failure. Replace the electronic control board. E0 = EEPROM communication error. E = EEPROM checksum error. E = A/D converter error (is there an error bit in the microprocessor?; does this mean lost a voltage rail?) E = Configuration jumper (cavity size or gas/electric) does not match setting defined in EEPROM (this was designed to notify the installer that the jumpers were not reconnected properly). E5 = Calibration shifted. E = Stack overflow. Keypad Subsystem Failure. Replace the keypad if properly connected and this F code is displayed. E0 = Shorted keypad or keypad stuck. E = Keypad or keytail not connected. E = Keypads unsettled (applies to capacitive glass when a constant reading cannot be taken). E5 = Cancel key low or open. Cavity Temperature Sensor Failure. Check for welded relays. If okay, replace the temperature sensor. E0 = Sensor open. E = Sensor shorted. E = Non self-clean over-temperature (usually 550 F). E = Self-clean over-temperature (usually 00 F). Meat Probe Failure. Check for proper resistance on probe. If okay, replace the meat probe jack. E = Meat probe shorted. Latch Subsystem Failure. Check for proper latch movement, switch actuation, and clearance between the latch and door. E0 = Latch switch does not agree with door switch (i.e. Iatch in locked position with door open). E = Latch will not lock. E = Loss of ground or L to N is reversed. Check to make sure that the voltage from L to ground is 0-volts AC. E5 = Self-clean temperature set point is not reached within the required time range (usually 0-5 minutes). E = Latch will not unlock. Electronics Over-Temperature. Check the blower and ventilation system. E0 = Over-temperature with blower on high speed. E = Over-temperature with blower on low speed. E = Over-temperature with blower off. Digital Switch Signal (i.e. 5 khz) Failure. Check for shorted door or latch switch wiring to chassis ground. E0 = Signal line shorted to ground.

14 WIRING DIAGRAMS Tech Sheet #5 & #

15 Tech Sheet #5

16 Tech Sheet #

17 Tech Sheet #

18 Tech Sheet #500

19 Tech Sheet #500

20 Tech Sheet #500 0

21 Tech Sheet #50

22 Tech Sheet #505

23 Tech Sheet #50

24 Tech Sheet #50

25 Tech Sheet #505 5

26 Tech Sheet #506 6

27 Tech Sheet #50

28 Tech Sheet #56

29 Tech Sheet #56

30 Tech Sheet #50 0

31 Tech Sheet #5

32 Tech Sheet #5