USER MANUAL TRAMONTINA PRESSURE COOKER. MODEL TRAS litres.

Transcription

1 READ BEFORE USING THE PRESSURE COOKER USER MANUAL TRAMONTINA PRESSURE COOKER MODEL TRAS litres

2

3 TRAMONTINA PRESSURE COOKER USER MANUAL CONTENT IMPORTANT SAFEGUARDS INTRODUCTION AND BENEFITS SAFETY PRECAUTIONS QUICK INFORMATION COMPONENTS & FEATURES OPERATING INSTRUCTIONS RELEASING THE PRESSURE CLEANING AND MAINTENANCE TROUBLE-SHOOTING COOKING TIME FOR REFERENCE SPARE PARTS PLEASE READ ALL INSTRUCTIONS BEFORE FIRST USE. KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE. PRODUCT INFORMATION ITEM NUMBER TRAS 0536 NOMINAL CAPACITY 6.0 L BODY DIAMETER 22cm WORKING PRESSURE 50 (kpa or 7.25 psi - Max. 120 C 90 (kpa) or psi- Max. 125 C IMPORTANT! When any parts are replaced, only our own ORIGINAL spare parts designed for this pressure cooker may be used. If repairs are necessary, please contact our Customer service department. Repairs may only be undertaken by authorised repairers. 3

4 USER MANUAL TRAMONTINA PRESSURE COOKER IMPORTANT SAFEGUARDS When using pressure cookers, basic safety precautions should always be followed: 1. Read all instructions thoroughly. 2. Do not touch hot surfaces; use handles or knobs. 3. Close supervision is necessary when the pressure cooker is used near children. 4. Do not place the pressure cooker in a heated oven. 5. Extreme caution must be used when moving a pressure cooker containing hot liquids. 6. Do not use the pressure cooker other than for its intended use. 7. This appliance cooks under pressure improper use may result in a scalding injury. Ensure the unit is properly closed before operating. See page 7, 8 and Do not fill the unit over 2/3 (two-thirds) full. When cooking foods that expand during cooking, such as rice or dried vegetables, do not fill the unit over ½ (half) full. Overfilling may cause the vent pipe to clog, causing the unit to develop excess pressure. See page Be aware that certain foods, such as apple sauce, cranberries, pearl barley, oatmeal or other cereals, split peas, noodles, macaroni, rhubarb or spaghetti can foam and froth and clog the pressure release device (steam vent). These foods should not be cooked in a pressure cooker. 10. Always check the pressure release devices for clogging before use. 11. Do not open the pressure cooker until the unit has cooled and all internal pressure has been released. If the handles are difficult to push apart, this indicates that the cooker is still pressurised do not force it open. Any pressure in the cooker can be hazardous. See page Do not use this pressure cooker for pressure frying with oil. 13. When the normal operating pressure is reached, turn the heat down so all the liquid, which creates the steam, does not evaporate. 4

5 TRAMONTINA PRESSURE COOKER USER MANUAL INTRODUCTION & BENEFITS The structure of a pressure cooker consists of a regular cooking pot and a special lid that locks in place on the top of the cook pot. When the cooker is heated up, steam is sealed inside and creates pressure. With this high pressure, the internal temperature in the cooker is raised above the normal boiling point of water, which leads to a faster and healthier cooking process. FASTER On average, a TRAMONTINA pressure cooker prepares food up to 3 times faster than conventional cooking methods. Meals that can take up to one hour with conventional cooking can be ready in as little as 20 minutes with a TRAMONTINA pressure cooker. TASTIER Food tastes better when it is prepared by a TRAMONTINA pressure cooker. The shorter cooking time allows food to retain its full and natural flavour. Less seasoning is required, up to half of what you would normally use and very little flavour is actually lost during cooking. Unlike microwave cooking, meat prepared in a TRAMONTINA pressure cooker is golden brown. Simply sauté, then cook under pressure. It is delicious! HEALTHIER More Vitamins and minerals are retained in food prepared by a TRAMONTINA pressure cooker. We all know that the longer food cooks, the more nutrients will be lost. TRAMONTINA pressure cookers help food retain more than twice their vitamins and nutrients compared to conventional stove-top cooking, by using less water. ENERGY EFFICIENT & MULTI FUNCTIONAL As the pressure cooker reduces cooking time it also saves energy. A Tramontina pressure cooker can be used for steaming, simmering, stewing and even defrosting. You can save on cooking time for everything from delicate soups and desserts to hearty meat dishes such as casseroles. 5

6 USER MANUAL TRAMONTINA PRESSURE COOKER PEOPLE NOT FAMILIAR WITH THE USE OF THIS PRESSURE COOKER SHOULD NOT BE ALLOWED TO USE IT. IF YOU USE THIS PRESSURE COOKER WHEN CHILDREN ARE IN THE VICINITY, PLEASE BE PARTICULARLY CAREFUL. 6 This pressure cooker may only be used for the purpose for which it was designed fast cooking. It may only be used as a normal saucepan WITHOUT a lid. Please never use it in a baking oven or in a microwave. The pressure cooker may only be placed on the appropriate hob for its size. For example, if the gas flame overlaps the sides of the cooker, the handles may be damaged. When using an electric hotplate, the diameter of the hotplate must be smaller than or equal to that of the cooker. When using a ceramic hob, the base of the cooker must be absolutely clean and dry. Never touch the outside of the pressure cooker during the cooking procedure as you may burn yourself. If the pressure cooker is still hot, it must only be touched or moved with great care and by the handles on the pressure cooker itself, not by the handle on the lid. This pressure cooker must never be used without liquid or it may be permanently damaged. The minimum amount of liquid should always be ca. 1/3 litres. The pressure cooker must never be filled more than 2/3 (two-thirds) full, or when cooking food which expands or bubbles strongly (e.g. rice or pulses) it should not be filled more than ½ (half) full. These foods should first be brought to the boil in the uncovered pressure cooker and then skimmed before the lid is closed. Under pressure, the pressure cooker must never be used for roasting or frying using fat or oil. When preparing foods with an artificial skin, for example, sausages, this must first be pierced. If the skin is not pierced it will expand under pressure and may burst. If you have cooked meat with the skin on which is swollen after cooking, do not pierce it but simply let it go down naturally in order not to burst and burn yourself.

7 TRAMONTINA PRESSURE COOKER USER MANUAL SAFETY PRECAUTIONS You should not pressure-cook foods which tend to cause foaming, such as apple purée, rhubarb, spaghetti, rolled oats or other types of cereals. As these foods can be swirled upwards during cooking, there is a risk of the cooker valve becoming blocked. If the contents are mushy, the pressure cooker must be agitated gently before opening. During cooking, bursts of steam will be given off vertically from the centre of the regulator valve. Please take care that you do not come into contact with this hot steam. BEFORE FIRST USING THE PRESSURE COOKER, PLEASE READ ALL INSTRUCTIONS THOROUGHLY. During the cooking process, the safety devices must not be interfered with. When the pressure cooker is under pressure, force must never be used to open it; the pressure cooker must be allowed to cool down before it is opened. Steam pressure must be completely released otherwise it will not be possible to open the cooker. Please observe the opening instructions (page 15). Do not undertake any modifications to the safety devices, otherwise there is risk of scalding. When releasing the steam, keep hands, head and body clear of the steam. Only original accessories and spare parts or lids and pans, specifically designed for these pressure cookers should be used. Pressure cookers or accessories which are deformed or damaged in any way should not be used under any circumstances. If repairs are necessary at any time, please contact our Customer Service department on within Australia or overseas. For Spare Parts visit our website at BEFORE COOKING Each time before using the pressure cooker, check that the safety valve, pressure regulator valve and sealing ring are clean and in proper working order. Pay special attention to the fact that the safety valve on the underside of the lid should be free to move ( wiggles ) and cannot be pushed so far into the recess of the lid that the red pin can be seen on top of the lid this should only happen when the lid is locked and pressure has built up inside the cooker. 7

8 USER MANUAL TRAMONTINA PRESSURE COOKER QUICK INFORMATION Before using your pressure cooker for the first time, please read these instructions for use carefully and keep them in a safe place for future reference. 1. OPEN Release the lid-lock but pushing it towards the cooker body. Draw the lid and cooker handles apart. Remove the lid. 2. CLOSING The circle symbols on the lid and the cooker handle should be opposite one another. Push the lid and cooker handles together, then pull the red push button towards yourself to lock. 3. FILL WITH THE FOOD TO BE COOKED Take care to observe the minimum liquid level of approx. 1/3 litre! Now add the food to be cooked maximum ½ (half) full for foods which swell up or foam; maximum 2/3 (two-thirds) full for all other foods. 8

9 TRAMONTINA PRESSURE COOKER USER MANUAL 4. SET PRESSURE LEVEL 5. TURN THE HEATING ELEMENT UP TO FULL 6. PRESSURE COOKING STARTS When steam escapes, turn the heating element down to the lowest setting. 7. COOKING TIME FINISHED Switch off the stove. 8. RELEASE THE PRESSURE SLOWLY IN STAGES... or, depending on the recipe, wait until the pressure has subsided. Caution: the steam is extremely hot. (See page 15) 9. OPEN THE PRESSURE COOKER 9

10 USER MANUAL TRAMONTINA PRESSURE COOKER COMPONENTS & FEATURES Pressure regulator valve 2. Safety valve/pressure indicator 3. Push Button 4. Safety window 5. Locking marks 6. Lid Safety Window 7. Handle with flame protection 8. Body of the pot 9. Triply Bottom The pressure regulator valve allows variable cooking settings. The valve automatically keeps the pressure and temperature at the desired setting. Position 1 for gradual cooking (0.5 bar/50 kpa or 7.25 psi) Position 2 for quick cooking (0.9 bar/90 kpa or psi) Position Position for gradual release of pressure for cleaning the valve 10

11 TRAMONTINA PRESSURE COOKER USER MANUAL THE SAFETY VALVE, WHICH ALSO ACTS AS A PRESSURE INDICATOR: While pressure in the cooker is building up, the RED pressure indicator is visible and the cooker is locked (never attempt to open it using force). If the pressure indicator is not visible, the cooker is no longer under pressure. It can then be safely opened by following the opening instructions. If for any unexpected reason the pressure regulator valve does not release steam as it should, this valve will open in accordance with the prescribed values. THE LOCKING SYSTEM: Place the lid on the cooker so that the locking markings are opposite each other and slide lid and cooker handles one above the other. As a pressure cooker generates very high pressure and steam temperature, under the subject OPENING please be certain to observe the instructions on page 15 of these instructions for use. THE SAFETY WINDOW: An additional safety element is the safety window let into the top of the lid. If there is excessive pressure in the cooker, the sealing ring forces its way out through this window, and the steam can escape. If excessive pressure is built and this valve is activated, the pressure cooker may be ejected from the stove top by steam (rocketing) which may cause damage. FOLLOW ALL INSTRUCTIONS FOR THIS NOT HAPPEN. WHILST USING A PRESSURE COOKER, KEEP CHILDREN AWAY FROM THE KITCHEN AT ALL TIMES. 11

12 USER MANUAL TRAMONTINA PRESSURE COOKER THE LID AND SEALING RING: Sealing rings are subject to wear and tear and must be replaced when necessary. Important: You should use Tramontina sealing rings for this specific model only. THE PUSH BUTTON: When the lid is closed, the push button is pulled away towards the long handle. The lid can then only be unlocked by pressing the push button in the direction of the cooker body. Note that you can only open the pressure cooker after all pressure has been released. THE PRESSURE COOKER: This pressure cooker with its attractive, timeless design is made of high quality, 18/10 stainless steel, is easily cared for and WITHOUT ITS LID may also be cleaned in the dishwasher. It may also be used as a stock pot WITHOUT the lid. THE THERMAL SANDWICH CAPSULE BASE: The Tramontina pressure cooker has a super-strong base for all hob types. It is absolutely stable, guarantees efficient heating and saves energy. 12

13 TRAMONTINA PRESSURE COOKER USER MANUAL OPERATING INSTRUCTIONS FILL THE PAN WITH SUFFICIENT LIQUID TO GENERATE THE NECESSARY STEAM (WATER, SAUCE OR STOCK). WARNING: Always add adequate liquid. NEVER let the pressure cooker cook dry. MINIMUM & MAXIMUM AMOUNT OF FOOD Minimum 1/3 (one-third) of a litre of liquid (330ml). Maximum 1/2 (half) full for foods that swell or tend to foam up. Maximum 2/3 (two-thirds) full for all other cooking. CLOSING THE PRESSURE COOKER Before placing the lid on the pressure cooker, ensure the silicone ring/gasket is placed correctly. Then, place the lid so that the markings on the lid and handle are adjacent, and slide handles so they end up one over the other. Pull the Red Push Button towards you (longer handle). It is locked. 13

14 USER MANUAL TRAMONTINA PRESSURE COOKER Select the desired cooking level with the help of the pressure regulator valve: POSITION 1: Gentle cooking at about 113 C/0.5 bar. For steaming and stewing more delicate foods such as vegetables, fish, fruit, etc. POSITION 2: Fast cooking at about 125 C/0.9 bar. For cooking and braising, e.g. meat, soups, stews, etc. PLACE THE PRESSURE COOKER WITH PRESET COOKING SETTING ON THE CORRECT SOURCE OF HEAT, AND TURN THIS UP TO FULL POWER. As soon as the pressure indicator becomes visible, it will still take a few minutes until the working pressure is reached and the cooker is correctly sealed. When working pressure is reached, the regulator valve releases steam continuously so that no excess pressure can build up. Only at this point should the source of heat be turned down. In this way, you avoid unnecessary consumption of energy and the risk of the cooker boiling dry. THE ACTUAL COOKING TIME STARTS AT THIS MOMENT. 14

15 TRAMONTINA PRESSURE COOKER USER MANUAL RELEASING THE PRESSURE The heating source is turned off when cooking time is finished, and the pressure in the cooker must be released. Take the cooker away from the hob and place it on a suitable surface. For releasing the pressure, you have the following options: LET IT COOL DOWN: Wait until the safety valve has completely disappeared. This is the recommended method for foods which are mushy or tend to foam. GRADUAL RELEASE OF PRESSURE: Turn the pressure regulator valve slowly to this position: WARNING: The escaping steam is extremely hot. The steam escapes vertically, so please do not hold your hands above the valve. Wait until all the steam has escaped and the pressure indicator is no longer visible. This method is not suitable for foods which are mushy or tend to foam. QUICK RELEASE OF PRESSURE: This model does not support the quick release method. DO NOT release pressure by running tap water on top of the lid. WARNING: Never use force to open the lid, and never interfere with the safety systems. The cooker can only be opened when it is no longer under pressure. WARNING: Never submerge the cooker in water. 15

16 USER MANUAL TRAMONTINA PRESSURE COOKER CLEANING & MAINTENANCE Clean your pressure cooker after every use with hot water and washing-up liquid. Please do not use any abrasive or caustic cleaners, or cleaners containing chlorine. The cooker without its lid can also be cleaned in the dishwasher. The lid should always be cleaned by hand. CLEANING & REPLACING THE SEALING RING (GASKET) To clean the sealing ring, rinse it under hot running water and dry it. As soon as the sealing ring becomes hard and turns a brownish colour it should be replaced. CLEANING THE SAFETY VALVE Clean the base of the valve on the inside of the cooker. Check that it is functioning properly with light pressure on the pin. FIG. 1 FIG. 2 CLEANING THE PRESSURE REGULATOR VALVE: Check against the light that the valve passages under the regulator valve are not blocked. Clean these with a needle or a pin. (FIG.1) Turn the plastic top into position. (FIG.2) Press the pressure regulator valve against the lid, and pull the pressure regulator until it comes off (FIG.3). Clean with water and mild soap. After cleaning the pressure valve, assemble using the reverse method. FIG. 3 FIG. 4 16

17 TRAMONTINA PRESSURE COOKER USER MANUAL TROUBLE-SHOOTING The pressure cooker takes a long time to come to the boil: The source of heat is not hot enough Turn up the source of heat to maximum The pressure indicator does not rise, and during cooking no steam escapes from the valve: This is perfectly normal in the first few minutes If this persists, check whether: the source of heat is hot enough; if not, turn it up there is sufficient liquid in the cooker the pressure regulator valve is set at 1 or 2 (if so, it s correct!) the pressure cooker is closed properly the sealing ring or the rim of the cooker is damaged The safety valve has risen, and during cooking no steam escapes from the pressure regulator valve: Turn off the heat source, remove pressure cooker from burner and release pressure. Open the cooker, check if there is enough liquid. Clean the pressure regulator valve and the safety valve Note: If you are unable to solve a problem or correct a defect, please contact Tramontina Customer Service for further guidance on or if overseas. Use only the appropriate spare parts for the TRAMONTINA pressure cooker Steam escapes from all around the lid: Check the lid is properly closed Check the gasket is properly fitted Check the condition of the gasket (if necessary, change it) Check the lid, the safety valve and the pressure regulator valve are clean Check that the rim of the cooker is in good order The lid cannot be opened: Check whether the safety valve has dropped completely; if not, release the pressure. The food being cooked is either not fully cooked or overcooked: Verify the cooking time (It may vary depending on foods) Check the hotplate output Ensure that the pressure regulator valve is correctly set (1 or 2) Check the amount of liquid The food being cooked has burnt onto the cooker: Leave your pressure cooker to soak for a good time before cleaning it Do not use any caustic cleaners or cleaners containing chlorine Cooking times may vary according to each foods and meat tenderness. Change cooking time accordingly. Increase amount of water in the recipe next time. One of the safety devices is triggered: Turn off the source of heat and remove the cooker from it Allow the cooker to cool down completely Open it, following the instructions Check the pressure regulator valve, the safety valve and the sealing ring and clean them. 17

18 USER MANUAL TRAMONTINA PRESSURE COOKER COOKING CHARTS Food Time (min.) Pressure Config. Bean soup 20 2 Pea soup Vegetable soup Semolina soup Goulash soup Potato soup Minestrone Boiling chicken Cabbage stew 15 2 Lentil (soaked) Beef Stew Turkey Veal (sliced) 6 2 Veal (fricassee) 5 2 Veal (roast) Food Time (min.) Pressure Config. Cauliflower Peas, green Carrots Stuffed capsicum Mushrooms Beetroot Cabbage Spinach Beans Potatoes Knuckle of pork Goulash Chicken Beef roast Pork roast * Cooking times shown above are guidelines only, due to the variations in tenderness of meat and vegetables. Adjust to suit your own taste. WARRANTY The TRAMONTINA Pressure Cooker has a five year warranty against material & manufacturing defects. The warranty only covers the body; it does not cover parts of the pressure cooker which are subject to wear (e.g. gasket and O-ring for safety valve, etc.). Improper use will result in cancellation of the warranty. The warranty will only be considered valid if the product is used in accordance with these Instructions for Use and upon presentation of a dated proof of purchase. 18

19 TRAMONTINA PRESSURE COOKER USER MANUAL SPARE PARTS It is recommended to change the Gasket once a year or whenever it is worn. Other Spare parts are changed when necessary (damaged for example). GASKET ref. TRAS0536-SP1 STEAMER BASKET/TRIVET ref. TRAS0536-SP2 LONG HANDLE PUSH ref. TRAS0536-SP3 PRESSURE REGULATOR ref. TRAS0536-SP4 BODY LONG HANDLE ref. TRAS0536-SP5 BODY FRONT HANDLE ref. TRAS0536-SP6 O-RING ref. TRAS0536-SP7 PRESSURE INDICATOR ref. TRAS0536-SP8 ANTI-CLOGGING NUT ref. TRAS0536-SP9 SAFETY VALVE ref. TRAS0536-SP10 TO ORDER SPARE PARTS visit Spare parts with red titles can not be shipped to customers. Pressure Cooker Lid must be returned to Tramontina s office for installation. Please call customer service at in Australia or overseas. 19

20 Tramontina Australia Tras Marketing & Sales Pty Ltd Unit 7, 167 Prospect Hwy Seven Hills NSW within Australia or overseas