ENVIRO-PAK. Operation and Maintenance Manual. Manufacturer of
|
|
- Maryann Clark
- 5 years ago
- Views:
Transcription
1 ENVIRO-PAK H Series Single Chamber Compactor Operation and Maintenance Manual Manufacturer of ENVIRO-PAK SAFESUB WINDCHILLER SALES@ENVIRO-PAK.NET 4308 West Admiral Doyle Drive, New Iberia, LA
2 Table of Contents H Series Compactors 3 Safety 4-8 Marpol 9 Installation Electric Installation 12 Air Installation 13 Installation of Bags Compactor Sequence of Operations Removal of Full Compactor Bag Maintenance Schedule 21 Troubleshooting Guide 22 Master Part List 23 General Arrangement and Layout Drawing 24 Electric Schematic 25 Wiring Diagram 26 Hydraulic Schematic 27 2
3 H-Series Single Chamber Compactors Benefits Features Rugged marine environment design needs little Compactor Features maintenance Improves MARPOL Compliance and waste handling practices Obtain lower disposal costs by reducing volumes Maximizes storage space and extend time between offloading Safe, user friendly design Compact unit with a small unit footprint Stainless steel construction Electric or Air configuration Explosion proof option available High compaction ratio On deck and Enclosed space installation Fail Safe controls and enclosed compactor ram unit Safety limit switch inside the compactor Compactor Specs Unit H2 H5 Height Width Depth Weight Capacity Deck space Compaction Force 2006 mm / mm / mm / kg / 520 lbs 0.2 m³ / 6 ft³ 0.5 m² / 6 ft² 4536 kg / lbs 2261 mm / mm / mm / kg / 1615 lbs 0.56 m³ / 20 ft³ 1.4 m² / 15 ft² kg / lbs H mm / mm / mm / kg / 1930 lbs 1.2 m³ / 45ft³ 1.7 m² / 19 ft² kg / lbs H mm / mm / mm / kg / 2100 lbs 1.6 m³ / 58 ft³ 1.9 m² / 21 ft² kg / lbs Marine Green and ENVIRO-PAK are registered trademarks of Tech Oil Products, Inc. 3
4 Safety ATTENTION: This unit uses high hydraulic pressures to acquire the compaction force needed. Caution should be at all times. THIS UNIT IS DESIGNED FOR COMPACTING TRASH: 1. Due to the close fit between the ram and the compaction chamber, always keep hands and loose clothing clear of the container during operation. 2. Under no circumstances should materials considered to be explosive be placed in the compactor. Serious injury may occur. 3. All adjustments on the unit are preset prior to delivery. Any attempt to alter or adjust the hydraulic, mechanical, or pneumatic systems may cause a dangerous situation. 4. Do not try to remove the bag from the container without first opening the doors on the container. Failure to open the doors may result in weakened or broken lifting straps. Always lift the bag using all four straps. 5. Notify Tech Oil Products, Inc. of any malfunctions WARNING: ARC FLASH AND SHOCK HAZARD: Do not operate controls or open covers without appropriate personal protection equipment. Failure to comply may result in injury or death! EXPLOSION HAZARD: Do not disconnect equipment unless power has been switched off or area is known to be non-hazardous 4
5 Safety HYDRAULIC TANK: For shipping purposes, the hydraulic oil tank was sealed. This tank must be opened to ambient air in order for the compactor to operate. Remove the plug in the top of the tank and replace it with the tank breather that is provided. Hydraulic Tank and Breather Cap DO NOT OPERATE THIS EQUIPMENT UNTIL THE HYDRAULIC TANK BREATHER IS INSTALLED 5
6 Safety ATTENTION: This unit has access doors that must be closed during operation and that may have pinch points. Use proper PPE and observe these areas. 6
7 Safety ATTENTION: This unit has access doors must be closed during operation and that may have pinch points. Use proper PPE and observe these areas. 7
8 Safety ATTENTION: Process only proper wastes with approved bags. 8
9 Marpol 9
10 Installation 1. To ensure that the compactor operates properly, it must be placed on a level surface. Bolt down tabs have been provided for anchoring the unit to the floor. (Refer to pictures on the side for location of anchor bolt tabs.) There will be one on the inside of each leg. 2. The unit may have been shipped with the hydraulic cylinder and ram assembly lowered into the compaction chamber. This is done to accommodate height restriction of freight carriers. 3. After the unit is placed on a level surface, if the cylinder was lowered, the cylinder and ram assembly must be installed into the operating position. A crane or forklift and at least two people are required. 4. Open chamber door to reveal the cylinder and 4 cylinder mounting bolts. 5. Attach a lifting cable to the lifting eye on top of the hydraulic cylinder. 6. Slowly lift the hydraulic cylinder **CAUTION: Be careful not to jam the hydraulic hoses or fittings during lifting. 7. When the mount plate on the cylinder aligns with the mounting holes on the compactor frame, install the four bolts provided with the unit. 8. Disconnect the lifting cable. Remove the lifting eye and circular stabilizing plate. 9. Connect the hydraulic hoses; SEE WARNING BELOW!! Connecting Hydraulic Hoses **CAUTION: At any time during installation there is danger of the ram free falling. Introducing air into the cylinder by removing a hose, cap, or any hydraulic fitting would be a dangerous situation. Take appropriate precautions such as a support system being placed under the ram to prevent it from free falling. 10
11 Installation WARNING: HYDRAULIC OIL TANK. For shipping purposes, the hydraulic oil tank was sealed. This tank must be opened to ambient air in order for the compactor to operate. Remove the plug in the top of the tank and replace it with the tank breather that is provided. DO NOT OPERATE THIS EQUIPMENT UNTIL THE HYDRAULIC TANK BREATHER IS INSTALLED. Remove the hydraulic tank plug before connecting the electrical system. Your unit s motor and pump configuration may differ, but the tank plug is the same on all units. 11
12 Electric Installation 1. To ensure proper operation and highest performance, the unit should be placed on a level surface. 2. If installation location guidelines require the unit to be electrically grounded in addition to the grounding that occurs when the unit is bolted down, locate and connect a grounding wire to the grounding lug provided on the compactor. 3. Voltage required for unit is shown on the electrical schematic and wiring diagram. The unit will be tagged on the electrical enclosure to identify the correct voltage. 4. Connect the three wires into the starter box and onto the magnetic starter. Rotation on the motor is checked by viewing the fan end of the motor. Turn the power to the motor on momentarily and then turn the power off. Determine which way the fan is rotating (clockwise or counter clockwise). Proper rotation is indicated on the motor. If the fan is rotating clockwise, the unit is wired properly. Step 2 Step 3 Step 4 12
13 Air Installation 1. To assure proper operation and rolling of the carriage, the unit should be placed on a level surface. 2. To put unit into service, simply connect a 1" air line to the crowfoot connection. Make sure the ON/OFF valve is off before applying pressure. Air supply should have a minimum of 90 psi and 60 cfm. 13
14 Installation of Compactor Bags H 2 Open both of the doors of the unit. Pass the two (2) metal lifting bag holders provided through the side loops on the compactor bag. Insert the two metal lifting bag holders through the corner slots in the rear of the unit. Attach the metal lifting bag holders to the pins located on the compactor door. Close the chamber and load doors.(refer to Picture 1) Bag Removal Open the load door. Slide the lifting bag holders out from the compactor. Open the main door. Remove compactor bag. 14
15 Installation of Compactor Bags 1. Open the main door of the compactor. H 5 / 10 / Fully open the compactor bag and pull the lifting straps through the slots provided in the top of the bag at each corner so that the duffel material lays flat on the outside of the compactor bag. This prevents the duffel material being compacted into the bag during the compaction process. PUT THE BACK STRAPS ON THE HOOKS PROVIDED FIRST, THEN THE FRONT STRAPS. 3. Pull the straps through the slots provided in each corner of the compaction chamber. 4. Pull the bag straps very tight so that the bag sides are fully against the inside compaction chamber walls. 5. Attach the straps to the strap hooks provided around the outside of container, starting with the rear straps. (SEE PHOTO # 1A BELOW) 6. Press down on the handle to tighten the bag into place. Repeat on all other bag straps. 7. Close the compactor door and lock. 1a COMPACTOR IS NOW READY FOR OPERATION Slot to Pass Strap Through Strap Hooks for Securing Bag Straps LOADING THE CHAMBER The top door of the unit is used for introducing waste into the compactor bag. 1. Open the load door. 2. Load the compactor with waste. 3. When finished loading, close and secure the load door. 15
16 Sequence of Operations Electric Powered Compactors This section, along with diagrams, is designed to assist in understanding the operations of the compactor. An electric motor is used to turn the hydraulic pump. The motor will start when the following conditions are met: a: The electrical supply must be connected to the unit. b: The door of the compactor is securely closed. Electric Motor 16
17 Sequence of Operations Electric Powered Compactors Once the compactor bag has been installed, begin loading trash through the load door. Once the compactor bag has been installed, begin loading trash through the load door. When you have finished loading the compactor, close the load door and latch securely. Pull the red Stop button out. The green Start button will illuminate. Press the green START button to engage the motor. WHILE PRESSING THE START BUTTON push down on the Manual Control Valve Arm to the RAM DOWN position. After compacting, move the Manual Control Valve Arm to the RAM UP position while pressing the green START button until the ram returns to the top position. Turn the unit off by releasing the green START button and the Manual Valve Arm. AS A SAFETY PRECAUTION, if the motor continues to run even after the START button is released, press Latch must be closed causing the door to depress the safety switch / valve for the unit to operate. Illuminated START button STOP button Ram UP / DOWN Manual Valve control lever 17
18 Sequence of Operations Air Powered Compactors This section, along with diagrams, is designed to assist in understanding the operations of the compactor. An air motor is used to turn the hydraulic pump. The motor will start when the following conditions are met: a. The air supply must be connected to the unit. b: The door of the compactor must be securely closed. AIR VALVE RAM UP/ RAM DOWN CONTROL VALVE 1. After compactor bag is loaded into the cart, secure the cart into the unit. 2. The front access door is used for introducing waste into the compactor bag. Load the compactor with waste. When finished loading, close and secure the load door. 3. Turn the air valve to turn on the air supply. 4 Press the air valve down and hold to turn the air motor on. 5. Pull DOWN the control valve lever and the ram cylinder rod will move downward. The ram extends fully into the chamber. 6. Push the control valve lever UP and the cylinder rod and ram will retract. 7. When the ram fully retracts, release the air valve handle and turn off the air supply. 18
19 H2 Compactor Bag Removal 1. Fully retract compactor ram and turn unit off. 2. Open front access door 3. Remove the metal lifting bag holder. 4. Remove the bag 19
20 H5/10/15 Compactor Bag Removal 1. Fully retract compactor ram and turn unit off. 2. Open front access door 3. Release the bag straps from the locking arms. 4. Press and hold the green START button or push down on the air valve to engage the motor. 5. Push down on the Eject Control Valve Arm to the Out position until the eject system is in the full eject position. 6. Release the Start button or the air valve to stop the motor. 7. Remove the bag. 8. Press and hold the green START button or push down on the air valve to engage the motor. 9. Push up on the Eject Control Valve Arm to the In position until the eject system is in the full retract position. 10.Turn the unit off by releasing the green START button or the air valve. 20
21 Maintenance Schedule Task Frequency Procedure Hydraulic Fluid in Tank Hydraulic Cylinder Bolts Motor and Pump Bolts As Needed Three (3) Months Ninety (90) Days The hydraulic system contains 2 to 3 gallons of hydraulic fluid. To check this fluid level the hydraulic cylinder must be in the UP position. Unscrew the cap on the hydraulic reservoir. Maximum level in the reservoir is 2 to 3 inches from the top of the tank. Should fluid need to be added, a check for leaks is advised. Hydraulic fluid used is Rando 68 or equivalent. Check for tightness. Adjust as needed Hydraulic Filter As Needed Remove the suction line from the bottom of the tank. Unscrew the filter from the line fitting. Installation is in reverse. Hydraulic Hose Sixty (60) Days Check hydraulic hose for weather degradation and/or rub spot wear. If signs are evident of either condition, remove the existing hose and replace with a new hose. 21
22 Troubleshooting Guide Problem Probable Cause Solution Motor will not start No electrical power Check that unit has power Blown fuse or overload circuit breaker tripped Replace fuse or reset circuit breaker Unit will not retract Load door and chamber door not closed Close the doors Motor running backwards Proper rotation of electrical motor Low hydraulic fluid Check hydraulic fluid, add as necessary Hydraulic hose leak Check all hydraulic hose for leakage, replace as necessary 22
23 Master Parts List 23
24 General Arrangement 24
25 Electric Schematic 25
26 Wiring Diagram 26
27 Hydraulic Schematic 27
28 Rev. 1-03/2016
Always keep this manual in a safe readily accessible location. MODEL SERIAL SERVICE COMPANY TELEPHONE NUMBER
Always keep this manual in a safe readily accessible location. MODEL SERIAL SERVICE COMPANY TELEPHONE NUMBER For Operating Instructions or Technical Support Call 1-507-886-6666 Last Revision: 1/31/12 Starting
More informationTC-720 RECYCLING BALER
OPERATING AND MAINTENANCE INSTRUCTIONS TC-720 RECYCLING BALER READ INSTRUCTIONS THOROUGHLY BEFORE OPERATING Sept. 06, 2013 3451 S. 40th Street Phoenix, AZ 85040 602.437.5020 800.223.4540 www.tsissg.com
More informationCP1-C5 COMPACTOR SPECS 2009
SECTION 11172 / 14560 TRASH COMPACTOR This section is based on a system produced by: Architectural Refuse Solutions, LLC 525 Kennedy Road Akron, Ohio 44305 Part 1 GENERAL 1.1 RELATED DOCUMENTS A. The general
More informationBWS 1000 OPERATION AND MAINTENANCE MANUAL
1000 Table of Contents Table of Contents 2 Method of Operation 3 BWS 1000 Built-In Safety Features 4 1. Set -up 5 Inspecting the Unit 5 1.1 Selecting the Location 5 - BWS Items 6 1.2 Powering up the Unit
More informationOWNER S MANUAL COMMERCIAL COLD PRESS JUICER
COMMERCIAL COLD PRESS JUICER REV.3 Introduction WARNING: To limit risk of personal injury and material damage, all users must read these instructions in their entirety and follow them strictly. MACHINE
More informationOPERATOR S MANUAL HWH HYDRAULIC SPACEMAKER ROOM EXTENSION SYSTEM FEATURING: DUAL CYLINDER ROOM EXTENSION (WITH RACK SENSING VALVE) HCORPORATION
HCORPORATIONH W R OPERATOR S MANUAL HWH HYDRAULIC SPACEMAKER ROOM EXTENSION SYSTEM FEATURING: DUAL CYLINDER ROOM EXTENSION (WITH RACK SENSING VALVE) WH HCORPORATION HYDRAULIC ROOM EXTENSION R OFF EXTEND
More informationrev3 INSTALLATION & OPERATION MANUAL OIL CIRCULATING HEATING SYSTEM MODEL OSM
216279-000 rev3 INSTALLATION & OPERATION MANUAL OIL CIRCULATING HEATING SYSTEM MODEL OSM IDENTIFYING YOUR SYSTEM IOM216279-000 The HOTSTART heating system is designed to heat fluids for use in marine
More informationMANUAL VERSION SERIAL # X-1 MINI PRO OWNER S MANUAL ASSEMBLY & OPERATOR INSTRUCTIONS 1.0
SERIAL # MANUAL VERSION 1.0 Introduction WARNING: To limit risk of potential injury and material damage, all users must read these instructions in their entirety and follow them strictly. Check our YouTube
More informationUNIQUE USER FRIENDLY MICROMETER STYLE ADJUSTMENT
The series hose crimper with Micrometer Style Adjustment and 80 ton cylinder has the capacity to crimp hoses up to 1-¼" 4 wire (with standard dies) and up to 1-¼" 6 wire and 2" 4 wire (with larger dies).
More informationOWNER S MANUAL VERSION 4.4 SERIAL # X-1 SINGLE LAYER PRESS. With EG-260 Variable Speed Grinder
OWNER S MANUAL VERSION 4.4 CONFORMS TO UL STD 763, NSF/ANSI STD 8 CERTIFIED TO CSA STD C22.2 #195 CONFORMS TO CE, IEC TESTED X-1 SINGLE LAYER PRESS With EG-260 Variable Speed Grinder SERIAL # 2 20 INTRODUCTION
More informationOPERATOR S MANUAL HWH HYDRAULIC SPACEMAKER ROOM EXTENSION SYSTEMS
HCORPORATIONH W R OPERATOR S MANUAL HWH HYDRAULIC SPACEMAKER ROOM EXTENSION SYSTEMS R R FEATURING: Three Dual Cylinder Room Extensions (With Synchronizing Cylinders) Single Cylinder Generator Slide HWH
More informationOPERATING & SERVICE INSTRUCTION MANUAL FOR
OPERATING & SERVICE INSTRUCTION MANUAL FOR THETFORD INTERNATIONAL ULTIMATE 5P COMPACTORS AND ASSOCIATED EQUIPMENT Printed in England by Thetford International Compactors Ltd COPYRIGHT 1 LIST OF CONTENTS
More informationService and Parts Manual. NO LONGER IN PRODUCTION Some service parts may not be available for this product- Examination.
thru 30-00 -0 Examination Table Serial Number Prefixes: GJ, GK, GL, JE, JF, JG JH, KV, KW, KX, KZ, LC & V Service and Parts Manual NO LONGER IN PRODUCTION Some service parts may not be available for this
More informationPLAY IT SAFE! OPERATION, MAINTENANCE AND INSTALLATION MANUAL FOR VERTICAL RECYCLER BALER INCLUDING THESE MODELS:
PLAY IT SAFE! OPERATION, MAINTENANCE AND INSTALLATION MANUAL FOR VERTICAL RECYCLER BALER INCLUDING THESE MODELS: V-4830 V-4830HD V-6030LP V-6030 V-6030HD V-6042LP V-7230HD A DOVER INDUSTRIES COMPANY VERNON,
More informationChicagoTM. Instruction Manual. Includes our new CoolTouch TM Control System Looks permanent, but goes wherever you go! U.S.
Includes our new CoolTouch TM Control System Looks permanent, but goes wherever you go! U.S. Patent Pending ChicagoTM A Kichler Decor ceiling fan Kichler Lighting 7711 East Pleasant Valley Road P.O. Box
More informationSQUEEZEBOX PRESS OWNER S MANUAL
SQUEEZEBOX PRESS SERIAL # MANUAL VERSION.0 Introduction IMPORTANT WARNING: To limit the risk of electrical shock, personal injury or material damage due to misuse, please read these instructions carefully
More informationMTC-Series Manual Trash Compactors Instruction Manual
Vestil Manufacturing Co. 2999 North Wayne Street, P.O. Box 507, Angola, IN 46703 Telephone: (260) 665-7586 -or- Toll Free (800) 348-0868 Fax: (260) 665-1339 Website: www.vestilmfg.com e-mail: info@vestil.com
More information60" Hatteras BayTM. Patio. Instruction Manual. Includes our new Wall Control System. A Kichler Décor ceiling fan
Includes our new Wall Control System 60" Hatteras BayTM Patio A Kichler Décor ceiling fan Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010 Cleveland, Ohio 44131-8010 Customer Service 866.558.5706
More information52 DorsetTM. Instruction Manual. Basic Function Wall Control System Included. A Kichler Decor ceiling fan
Basic Function Wall Control System Included 52 DorsetTM II A Kichler Decor ceiling fan Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010 Cleveland, Ohio 44131-8010 Customer Service 866.558.5706
More informationSuperKlean Washdown Products
DURAREEL DR8 & DR8S INSTALLATION AND MAINTENANCE INSTRUCTIONS **DO NOT THROW AWAY AFTER INSTALLATION** **SAVE AND DISPLAY PROMINENTLY WHERE THIS EQUIPMENT IS USED** GENERAL WARNINGS High pressure and hot
More informationEasy-Lam School Budget Roll Laminator
DO NOT DISCARD BOX! (If for any reason you need to ship your machine back and you discard your box you will be responsible for purchasing another one plus any freight charges to ship the box to you) Easy-Lam
More informationHatteras BayTM. Patio. Instruction Manual. Includes our new CoolTouch TM Control System Looks permanent, but goes wherever you go! U.S.
Hatteras BayTM Patio A Kichler Décor ceiling fan Designed to coordinate with a popular Kichler Lighting collection. Includes our new CoolTouch TM Control System Looks permanent, but goes wherever you go!
More information16 OUTDOOR MISTING FAN
16 OUTDOOR MISTING FAN Model: SF-1670M READ AND SAVE THESE SAFETY INSTRUCTIONS BEFORE USE IMPORTANT SAFETY INSTRUCTIONS When using electrical appliances, basic precautions should always be followed to
More informationGeneral Characteristics.3. S.M.A.R.T System Set-up...5. Start-up Procedures.6. Shut-down Procedures 8. General Maintenance..8
1-800-661-3842 1 TABLE OF CONTENTS General Characteristics.3 How the S.M.A.R.T System Works..3 S.M.A.R.T Technical Specifications..3 Erecting the S.M.A.R.T System..4 S.M.A.R.T System Set-up...5 Start-up
More information1. SAFETY RULES WARNING WARNING. 8. Avoid placing objects in the path of the blades.
1 1. SAFETY RULES 1. To reduce the risk of electric shock, insure electricity has been turned off at the circuit breaker or fuse box before beginning. 2. All wiring must be in accordance with the National
More informationSx-280. Squeezebox press California Road, Orchard Park, NY USA Fax:
Sx-280 Squeezebox press 3860 California Road, Orchard Park, NY 14127 USA 1-800-875-3381 Fax: 716-667-3328 www.goodnature.com OWNER S MANUAL Serial # 1 SECTION 1: Safety Precautions IMPORTANT WARNING: To
More informationTechnical Data. Name: ERIKA Automat fully automatic machine to divide and to round dough pieces of the same size
AUTOMAT MANUAL 1 Technical Data Name: ERIKA Automat fully automatic machine to divide and to round dough pieces of the same size Type Divisions Dough Portions (in ounces) Plate Nos. 3 30 1.0 3.5 #35 4/40A
More informationOPERATIONS AND MAINTENANCE MANUAL FOR THE 8-TON TURF CART ENVIRONMENTAL CONTROL UNIT (ECU) PART NUMBER
OPERATIONS AND MAINTENANCE MANUAL FOR THE 8-TON TURF CART ENVIRONMENTAL CONTROL UNIT (ECU) PART NUMBER 2001927 Prepared by: 860 Douglas Way PO Box 530 Natural Bridge Station, VA 24579 1 1.0 SCOPE: This
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS BUILT-IN FULL HEIGHT WINE CELLAR (VCWB300 PROFESSIONAL MODEL) Retain for Future Reference VIKING RANGE CORPORATION 111 Front Street Greenwood, Mississippi 38930 USA (662) 455-1200
More informationAquaSaver DISPOSER CONTROL CENTER Installation Manual. Model AS-101K
AquaSaver DISPOSER CONTROL CENTER Installation Manual Model AS-1K The Danger signal indicates an immediately hazardous situation which, if not avoided, will result in death or serious injury. The Warning
More informationREAD AND UNDERSTAND THESE INSTRUCTIONS BEFORE OPERATING THE MACHINE
XAACT Xtract 200 INFORMATION & OPERATING INSTRUCTIONS READ AND UNDERSTAND THESE INSTRUCTIONS BEFORE OPERATING THE MACHINE 78-00018 Rev B 032912 1 CONTENTS: Machine Specifications............ 2 Record Important
More informationUNIQUE USER FRIENDLY MICROMETER STYLE ADJUSTMENT
The series hose crimper with Micrometer Style Adjustment and 62 tons of crimping force has the capability to crimp hoses up -¼" -2 wire, -¼" 4 wire, and " 6 wire. UNIQUE USER FRIENDLY MICROMETER STYLE
More informationSunburst. Instruction Manual. Includes our new Wall Control System. A Kichler Décor ceiling fan
Includes our new Wall Control System Sunburst A Kichler Décor ceiling fan Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010 Cleveland, Ohio 44131-8010 Customer Service 866.558.5706 8:30 AM
More informationPanel Fan Series Operators Manual (Galvanized and Polymer)
Panel Fan Series Operators Manual (Galvanized and Polymer) Galvanized Panel Fan with Three Wing Blade IMPORTANT: READ AND SAVE THESE INSTRUCTIONS Read all instructions carefully before attempting to assemble,
More information52 StarkkTM. Instruction Manual. A Kichler Select ceiling fan
52 StarkkTM A Kichler Select ceiling fan Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010 Cleveland, Ohio 44131-8010 Customer Service 866.558.5706 8:30 AM to 5:00 PM EST, Monday - Friday
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS BUILT-IN FULL HEIGHT WINE CELLAR Retain for Future Reference VIKING RANGE CORPORATION 111 Front Street Greenwood, Mississippi 38930 USA (662) 455-1200 IMPORTANT - PLEASE READ
More informationPanel Fan Series Operators Manual (Galvanized and Polymer)
Panel Fan Series Operators Manual (Galvanized and Polymer) 52" Belt Drive, Galvanized Panel Fan with Three Wing Blade IMPORTANT: READ AND SAVE THESE INSTRUCTIONS Read all instructions carefully before
More information100T Electric Shop Press
100T Electric Shop Press Operation Manual 1 Important Information 1.1 Safety Information 1.1.1 Hazard Symbols Used in the Manuals This manual includes the hazard symbols defined below when the operations
More informationHanson LED C e i l i n g F a n
Hanson LED C e i l i n g F a n model no. 052-8398-2 Toll-free 1-866-827-4985 IMPORTANT: For your safety please read and understand this manual before installing or operating this product. OWNER S MANUAL
More informationOrrin. Instruction Manual. Includes our new CoolTouch TM Control System Looks permanent, but goes wherever you go! U.S.
Includes our new CoolTouch TM Control System Looks permanent, but goes wherever you go! U.S. Patent Pending Orrin A Kichler Select ceiling fan Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010
More informationASG EZ-9000GR Tape Dispenser User Manual ASG #66136
ASG EZ-9000GR Tape Dispenser ASG #66136 Revision Date: 03/27/18 1 Read Before Use Warnings and Cautions The safety guidelines in this instruction manual must be observed in order to prevent injury to the
More information42 Kevlar. Instruction Manual. Kichler Lighting 7711 East Pleasant Valley Road P.O. Box Cleveland, Ohio
42 Kevlar Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010 Cleveland, Ohio 44131-8010 Customer Service 866.558.5706 8:30 AM to 5:00 PM EST, Monday - Friday Instruction Manual 1 1. SAFETY
More information60" Tulle PatioTM. Instruction Manual. A Kichler Select ceiling fan
60" Tulle PatioTM A Kichler Select ceiling fan cul Certified for Wet Location Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010 Cleveland, Ohio 44131-8010 Customer Service 866.558.5706 8:30
More informationFitchTM. Instruction Manual. Includes our Basic Function CoolTouch TM Control System Looks permanent, but goes wherever you go!
Includes our Basic Function CoolTouch TM Control System Looks permanent, but goes wherever you go! FitchTM A Kichler Décor ceiling fan U.S. Patent Pending Kichler Lighting 7711 East Pleasant Valley Road
More informationInstallation & Operating Guide
5-036 HOT WATER TANK Installation & Operating Guide Read all instructions thoroughly. Keep this guide for future reference. Proof of purchase is required for Warranty. Staple receipt or proof of purchase
More informationValkyrieTM. Instruction Manual. Includes our new CoolTouch TM 6 Speed DC Control System Looks permanent, but goes wherever you go! U.S.
ValkyrieTM A Kichler Décor ceiling fan Designed to coordinate with a popular Kichler Lighting collection. Includes our new CoolTouch TM 6 Speed DC Control System Looks permanent, but goes wherever you
More informationKH-80 HYDRAULIC CRIMPER OPERATORS MANUAL
KH-80 HYDRAULIC CRIMPER OPERATORS MANUAL 1 SAFETY PRECAUTIONS READ AND IDENTIFY ALL COMPONENT PARTS BEFORE USING CRIMPER. CRIMPER CAN PRODUCE 80 TONS OF FORCE. KEEP BOTH HANDS AWAY FROM PINCH POINTS. CONSULT
More informationCOMMERCIAL COLD PRESS JUICER OWNER S MANUAL
COMMERCIAL COLD PRESS JUICER SERIAL # MANUAL VERSION CONFORMS TO UL STD 763, CERTIFIED TO CSA STD C22.2 #95 CONFORMS TO CE, IEC TESTED 5.4 Introduction WARNING: To limit risk of personal injury and material
More informationSELF-CONTAINED POWER MISTER
00 North Main St. Fostoria, OH 0 Phone: 00-95-55 Fax: 9-5-0 www.tpicorp.com If you have questions about the product you have purchased or would like to leave us feedback please contact us via our website
More informationOwner s Guide. Powerhead Canister Vacuum Cleaner
Owner s Guide Powerhead Canister Vacuum Cleaner INDEX 1. Important Safety Instructions 2. Components & Accessories 3. Assembly 4. How to Operate a. On/Off Switch b. Check bag indicator c. Variable suction
More informationDISHWASHER. Models DW2432 and DW2432SS. Installation Manual. Write Serial Number (on inner door of unit) here:
DISHWASHER Models DW2432 and DW2432SS Installation Manual Write Serial Number (on inner door of unit) here: Felix Storch, Inc. Summit Appliance Division 770 Garrison Avenue Bronx, New York 10474 www.summitappliance.com
More informationπ H-2268 SANITAIRE UPRIGHT VACUUM SAFETY uline.com
π H-2268 SANITAIRE UPRIGHT VACUUM 1-800-295-5510 uline.com SAFETY PAGE 1 OF 7 NOTE: When using an electrical appliance, basic precautions should always be followed, including the following: READ ALL INSTRUCTIONS
More information52 Lacey LED. Instruction Manual. 6 Speed DC Wall Control System
6 Speed DC Wall Control System 52 Lacey LED HIGH EFFICIENCY DC MOTOR Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010 Cleveland, Ohio 44131-8010 Customer Service 866.558.5706 8:30 AM to
More informationInstallation Instructions
Installation Instructions For Fully Integrated NoFrost Combined Refrigerator-Freezers HCB 1560/1561 7084 429-00 Important Please read and follow these instructions These instructions contain Danger, Warning
More informationFerronTM. Instruction Manual A Kichler Decor ceiling fan
Includes our new CoolTouch TM 6 Speed DC Control System Looks permanent, but goes wherever you go! U.S. Patent Pending 300160 A Kichler Decor ceiling fan HIGH EFFICIENCY DC MOTOR FerronTM Kichler Lighting
More informationOperator s Manual for Morse Hydra-Lift Drum Karrier Model 400A
Contents Page Receiving Procedures................. 1 Warranty............................... 1 Safety Information..................... 1-2 Machine Description................... 3-4 Operating Instructions...................
More information8 lb Lightweight Vacuum Model CK LW 13/1
TORNADO INDUSTRIES 7401 W. LAWRENCE AVENUE CHICAGO, IL 60706 (708) 867-5100 FAX (708) 867-6968 www.tornadovac.com Operations & Maintenance Manual For Commercial Use Only 8 lb Lightweight Vacuum Model CK
More informationInstallation Guide BUILT-IN SXS REFRIGERATOR UPSXB2627**
Installation Guide BUILT-IN SXS REFRIGERATOR UPSXB2627** www.thesignaturekitchen.com 2 Contents 1. Precaution before installation... 3 2. Product and Cutout dimension... 4 3. Precaution when moving the
More informationElectronic Service Manuals
Electronic Service Manuals This electronic document is provided as a service to our customers. We do not create the contents of the information contained in this document. Should you have detailed questions
More informationProStar Ceiling Fan PS52. Installation Instructions Instrucciones de instalación Instructions d installation
ProStar Ceiling Fan PS52 Installation Instructions Instrucciones de instalación Instructions d installation Read and Save These Safety Precautions. Turn off electricity at main switch before wiring or
More informationAmerican Dish Service
American Dish Service INSTALLATION INSTRUCTIONS Model JDS12 (T) or (R) Muffler Booster (T) 12kW, 240v, 3-ph, (R) 12kW, 208v, 3-ph Manufactured by Hubbell Electric Heater Company for use on American Dish
More informationMANUAL RESET ALARM RELEASE
Fire Door Release MODEL AR-D MANUAL RESET ALARM RELEASE INSTRUCTION MANUAL AR-D GENERAL INFORMATION 1. Review all installation instructions, procedures, cautions and warnings contained within this manual
More informationMODEL A5-2 SOLVENT & WATER RECOVERY SYSTEMS (EXPLOSION PROOF UNITS)
MODEL A5-2 SOLVENT & WATER RECOVERY SYSTEMS (EXPLOSION PROOF UNITS) FOR PROPER AND SAFE USE OF THIS CHEMCHAMP EQUIPMENT, PLEASE FOLLOW THIS DOCUMENT AND LOCAL AUTHORITY. KEEP THIS DOCUMENT FOR FUTURE REFERENCE.
More informationOPERATIONAL & MAINTENANCE MANUAL
Security Engineered Machinery Co., Inc OPERATIONAL & MAINTENANCE MANUAL SEM Model 0101 Hard Drive Crusher 110 volt or 220 volt (Serial Numbers 2000 and up) Contents IMPORTANT SAFETY PROCEDURES... 3 INSTALLATION
More informationLED. 60 StarkkTM. Instruction Manual. A Kichler Select ceiling fan
60 StarkkTM LED A Kichler Select ceiling fan Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010 Cleveland, Ohio 44131-8010 Customer Service 866.558.5706 8:30 AM to 5:00 PM EST, Monday - Friday
More informationInstallation. Built-in Full Height Wine Cellar VCWB301
Installation Built-in Full Height Wine Cellar VCWB301 Table of Contents Warnings & Important Information _ 3 Dimensions _ 5 Specifications _ 6 Cutout Dimensions 7 Cabinet Information _ 8 Cabinet Information
More informationTWLRZ-238 REFRIGERATOR
TWLRZ-238 REFRIGERATOR May 2013 CONTENTS Parts and Features Instructions for Installation Cautions for Safety Operation Cleaning and Maintenance Changing the Light Bulb Reversing the Door 2 3 4 5 6 7 7
More informationOperator s Manual S-333. Automated Soil Compactor. Version 3.3. Durham Geo Slope Indicator 2175 West Park Court Stone Mountain, GA USA
Automated Soil Compactor S-333 Operator s Manual Version 3.3 Durham Geo Slope Indicator 2175 West Park Court Stone Mountain, GA 30087 USA Phone: 800-837-0864 or +1.770.465.7557 Fax: 770.465.7447 e-mail:
More informationGet Cleaning... What s your Vax s model number? User Guide. Carpet Washer Vax Careline: AU: NZ:
User Guide Vax Careline: AU: 1300 361 505 NZ: 0800 800 900 Carpet Washer Get Cleaning... What s your Vax s model number? W8 W8 W0 W0 W0 W W W W W What s your serial number? (Located on the base of the
More informationPANEL FAN SERIES OPERATORS MANUAL (Galvanized and Polymer)
PANEL FAN SERIES OPERATORS MANUAL (Galvanized and Polymer) Galvanized Panel Fan IMPORTANT: READ AND SAVE THESE INSTRUCTIONS Read all instructions carefully before attempting to assemble, install, operate
More informationMODEL SF-420. Fabric Steamer. by Top Innovations, Inc. Please read all instructions before use. Mail in your warranty registration card.
MODEL SF-420 Fabric Steamer by Top Innovations, Inc. Please read all instructions before use. Mail in your warranty registration card. LETTER FROM THE CEO Dear Valued Customer, Congratulations on purchasing
More informationUser Manual AIR HOG. Vacuum Booster REV. 3/20/ Stowe Dr. Poway, CA P: (858) F: (858)
User Manual AIR HOG Model: 7303L Vacuum Booster REV. 3/20/18 13655 Stowe Dr. Poway, CA 92064 P: (858) 679-1191 F: (858) 726-6005 INTRODUCTION Dear Customer: Congratulations on the purchase of your new
More informationDual Zone Wine Cellar
Dual Zone Wine Cellar Instruction Booklet Model: WC-2012 IMPORTANT SAFEGUARDS Before the appliance is used, it must be properly positioned and installed as described in this manual. To reduce the risk
More informationAC6 & AC8 HORIZONTAL SERIES Sealed Metallic Centrifugal Pumps Installation and Maintenance Instructions
AC6 & AC8 HORIZONTAL SERIES Sealed Metallic Centrifugal Pumps Installation and Maintenance Instructions ASSEMBLY PUMPS WITH MOTORS 1. No assembly required. Unpack the pump and motor and examine for any
More informationOPERATING INSTRUCTIONS MIGHTYLAM 2700 ROLL LAMINATOR
OPERATING INSTRUCTIONS MIGHTYLAM 2700 ROLL LAMINATOR TABLE OF CONTENTS Safety Messages and Electrical Safeguards...3-4 Introduction... Laminator Features...5 Specifications...5 Intial Set-up...6 Operating
More informationMASTER JOCKEY PUMP CONTROLLER. Model JPCE INSTRUCTION MANUAL. C 2018 Master Control Systems, Inc
MASTER JOCKEY PUMP CONTROLLER Model JPCE INSTRUCTION MANUAL C 2018 Master Control Systems, Inc TABLE OF CONTENTS Important Safety Information. Page 3 General Description and Installation.. Page 4 Model
More informationTC-710 RECYCLING BALER
OPERATING AND MAINTENANCE INSTRUCTIONS TC-710 RECYCLING BALER READ INSTRUCTIONS THOROUGHLY BEFORE OPERATING 3451 S. 40th Street Phoenix, AZ 85040 602.437.5020 800.223.4540 www.tsissg.com info@tsissg.com
More informationLos Angeles Abrasion Machine HM-70A & HM-70AF
Operating Manual Los Angeles Abrasion Machine HM-70A & HM-70AF Rev: 07/24/2018 PHONE: 800-444-1508 740-548-7298 P.O. Box 200, Lewis Center, Ohio 43035-0200 E-mail: customerservice@gilsonco.com Website:
More informationMODEL Vertical-Lift, 60, DC Power Lift, Manual Tilt
Contents Page Receiving Procedures.................... 1 Warranty............................. 1 Safety Information..................... 1-2 Machine Description................... 3-4 Operating Instructions....................
More informationINSTRUCTION MANUAL INSTALLATION OPERATION MAINTENANCE
I.O.M. #083 /08 INSTRUCTION MANUAL INSTALLATION OPERATION MAINTENANCE Covers Models with VE Series Instrument. 525 East Stop 8 Road Greenwood, IN 4642 37-887-0729 fax: 37-88-277 Service Department fax:
More informationIDT-12-N Hydraulic Crimping Tool
INSTRUCTION MANUAL IDT-12-N Hydraulic Crimping Tool Read and understand all of the instructions and safety information in this manual before operating or servicing this tool. 99945282 REV 6 2009 Ilsco
More informationFood Waste Disposer Instruction Manual
Food Waste Disposer Instruction Manual See insert for specific information about your new disposer NOTE: IMPORTANT: CAUTION: This Food Waste Disposer has been designed to operate on 110-120 Volt, 60 Hz
More informationC-IV 60 CEILING FAN READ AND SAVE THESE INSTRUCTIONS. FAN RATING AC 120V. 60Hz
C-IV 60 CEILING FAN READ AND SAVE THESE INSTRUCTIONS FAN RATING AC 120V. 60Hz Please do not use any electric or battery powered tools in the assembly and installation of this or any Matthews Fan Company
More informationMobile Evaporative Cooler. Use & Care Guide MC37 / MC61 INDEX
INDEX Safety Rules... 1 Quick Start.... 2 Features...3 Maintenance......4 Cooler Parts......5 Warranty......6 Trouble Shooting...7 Mobile Evaporative Cooler Use & Care Guide MC37 / MC61 Safety Safety Rules
More information54" Skye. Instruction Manual Customer Service :30 AM to 5:00 PM EST, Monday - Friday A Kichler Decor ceiling fan
54" Skye TM 300167 A Kichler Decor ceiling fan Includes wall mount control system Kichler Lighting 7711 East Pleasant Valley Road P.O. Box 318010 Cleveland, Ohio 44131-8010 Instruction Manual Customer
More informationOPERATOR S MANUAL. BASIC PROJECT CENTERS Some instructions and drawings may not apply to your specific unit. SAFETY SERVICE PARTS CAPACITIES
OPERATOR S MANUAL BASIC PROJECT CENTERS Some instructions and drawings may not apply to your specific unit. SERVICE PARTS LOCATING MODEL # INFORMATION Model number and other information required for service
More informationEAGLE 2000B EAGLE 2000BE EAGLE 2000EBT MUST READ MANUAL PRIOR TO INSTALLING MACHINE
EAGLE 2000B EAGLE 2000BE EAGLE 2000EBT MUST READ MANUAL PRIOR TO INSTALLING MACHINE Contents 1 Machine Safety Information 3 1.5 Safety Precautions Prior to Operating Machine 6 2 Machine Installation 7
More informationInstallation Instructions
Installation Instructions For Fully Integrated NoFrost Combined Refrigerator-Freezers HC 2062 HCB 2062 HC/HCB 2062 7084 445-00 Important Please read and follow these instructions These instructions contain
More informationOWNER S MANUAL CAVS SERIES SELF CONTAINED RETRACTABLE NOZZLE VACUUM SEALER
OWNER S MANUAL CAVS SERIES SELF CONTAINED RETRACTABLE NOZZLE VACUUM SEALER WHAT S IN THE PACKAGE? This Operation Manual. (1) Vacuum Sealer. (1) E-(unit size) Heating Element, inside the manual sheet protector.
More informationSingle Phase Simplex SXL21=3, SXL24=3, SXH21=3, and SXH24=3
Single Phase Simplex SXL21=3, SXL24=3, SXH21=3, and SXH24=3 Manufactured by SJE-Rhombus Installation Instructions and Operation/Troubleshooting Manual 7000 Apple Tree Avenue Bergen, New York 14416 Phone:
More informationOWNER S MANUAL. Important: Read carefully before assembly and use. PORTABLE CANISTER U #961A00007 ID111867
OWNER S MANUAL PORTABLE CANISTER Important: Read carefully before assembly and use. U414300 #961A00007 ID111867 THANK YOU for purchasing an Oreck product please register your product: online at oreck.com
More informationInstruction Manual Item No.: V~, 60Hz
Energy- Saving Mode Portable AC 8,000 BTU Model: MW-O-08C Montgomery Ward Customer Service 1112 7th Avenue, Monroe, WI 53566 8:00 am to Midnight, Monday through Friday Wards.com 1 888 557 3848 Instruction
More informationInstallation and Operation Manual For Hunter Ceiling Fans
Installation and Operation Manual For Hunter Ceiling Fans 1 2 CONGRATULATIONS! Your new Hunter ceiling fan is an addition to your home or office that will provide comfort and performance for many years.
More informationGarment Steamer Model SC620
OWNER S MANUAL Garment Steamer Model SC620 For information or assistance: EURO-PRO Corporation 178 West Service Rd. Champlain, NY 12919 1-800-798-7398 www.euro-pro.com IMPORTANT SAFETY INSTRUCTIONS When
More informationPage 1 of 18. Part# /5/2013
Part# 1002655-06 8/5/2013 This manual contains important information concerning the installation and operation of the gun washers listed above. Read manual thoroughly and keep for future reference INSTRUCTIONS
More informationHydraulic Crimping Systems
ORIGINAL INSTRUCTIONS Hydraulic Crimping Systems Customer Manual 409-35004 04 OCT 17 Rev A SAFETY PRES READ THIS FIRST!... 2 SAFETY PRES AVOID INJURY READ THIS FIRST!... 3 1. INTRODUCTION... 4 2. INSPECTION
More informationOWNER S MANUAL AVN SERIES RETRACTABLE NOZZLE VACUUM SEALER WITH GAS PURGE
OWNER S MANUAL AVN SERIES RETRACTABLE NOZZLE VACUUM SEALER WITH GAS PURGE WHAT S IN THE PACKAGE? This Operation Manual. (1) Vacuum Sealer. (1) E-(unit size) Heating Element, inside the manual sheet protector.
More informationFull Size Canister Service Manual Riccar Models 1700 / 1800 Power Nozzles RPB-100 / RPB-220 / RPB-224 / RPB-250
Full Size Canister Service Manual Riccar Models 1700 / 1800 Power Nozzles RPB-100 / RPB-220 / RPB-224 / RPB-250 Table of Contents I. General Full Size Canister Issues...2 A. Full Bag Indicator...2 1. General
More informationExplorer CleaningPartsDirect.com Carpet Extractor. Operator and Parts Manual. Home Find... Go To.. Model No.: Can.
Explorer 1500 Carpet Extractor Model No.: 608808 609231 Can. Operator and Parts Manual CleaningPartsDirect.com 662-393-3045 NOBLES 12875 RANSOM STREET HOLLAND MI 49424 U.S.A. CUSTOMER SERVICE: 1-800-365-6625
More informationInstallation Instructions
Installation Instructions For Fully Integrated NoFrost Combined Refrigerator-Freezers HC 2060/2061 HCB 2060/2061 7084 349-00 Important Please Read and Follow these Instructions These instructions contain
More information