Asset: P.S. 22 - STATEN ISLAND, 1860 FOREST AVENUE, New York, 10303 Inspection Id Inspection Type Time In Last Edited ME : Mechanical 2017-12-08 8:51 AM 2017-12-18 4:14 PM Asset Data Are there fuel tanks? Total # of above ground tanks 2 Answer Total capacity of all above ground tanks in gal. 5,275 Total # of below ground tanks 0 Total capacity of all below ground tanks in gal. 0 Total # of water main service entries to the asset 3 MERs/Fan Rooms Locations Are there any spaces with Missing or Defective CO Detectors? Are there any Emergency Stop Switches with Missing Hammers? Are there any Painted/Obstructed Sprinkler Heads? Have any Systems/Major Building Components been upgraded? Priority NYC Department of Education Building Assessment Survey 2017-2018 Yes Basement MER, MER next to Gas Meter Room, MER below Gymnasium, Stair E Bulkhead Fan Room No No No Yes Systems: Fixtures - Toilets, Urinals (50%) Years: 2017 Systems: Years: 2015 Systems: Years: 2011 Systems: Years: 2010 Systems: Years: 2009 MDF Room - Dedicated A/C (DX Split System) Climate Control System - Electric System Kitchen - Hot Water Temperature Booster Chilled Water System Systems: DX Split System for Suite 101 (1 of 2) Years: 2008 Priority Priority Exist Category Last Year? Description Component Affected Location Description Person(s) Notified Person(s) Title Status PhotoImage No Defective CO/Gas Leak Detection Defective Sensor GAS SERVICE CO/Gas Leak Detection Boiler Room near Gas Fired Domestic Water Heater Ed Florkiewicz Fireman Sent to DSF Inspection Mechanical AIR CONDITIONING Chilled Water System Absorption Chiller Air Cooled Chiller Air Cooled Condenser Chilled Water Distribution: Piping, Pumps and Auxiliaries Backflow Preventer Central Station Air Handler Basement MER PB/A&W Page 1 of 15
Building Assessment Survey 2017-2018 AIR CONDITIONING Chilled Water System Central Station Air Handler Quantity 1 Manufacturer Carrier AHU-1 Capacity/Size Quantity 7,300 CFM Installation Year 2009 Custodial Staff Fan Coil Unit Packaged Air Cooled Chiller 1st Building Addition - Roof Quantity 1 Manufacturer Carrier CH-1 Capacity/Size Quantity 30 Tons Installation Year 2009 Custodial Staff Water Cooled Chiller Condenser Water Distribution: Piping, Pumps and Auxiliaries Cooling Coil in Ductwork Cooling Tower DX Split System Indoor Unit Outdoor Unit Dry Cooler Packaged / Rooftop Unit 3rd Building Addition - Roof Quantity 1 Source of Heating Gas Manufacturer Trane AC-3 Capacity/Size Quantity 17 PB/A&W Page 2 of 15
Building Assessment Survey 2017-2018 AIR CONDITIONING Packaged / Rooftop Unit Tons Inspector Estimate 3rd Building Addition - Roof Quantity 1 Source of Heating Gas Manufacturer Trane AC-7 Capacity/Size Quantity 8 Tons Inspector Estimate 3rd Building Addition - Roof Quantity 1 Source of Heating Gas Manufacturer Trane AC-4 Capacity/Size Quantity 5 Tons Inspector Estimate 3rd Building Addition - Roof Quantity 2 Source of Heating Gas Manufacturer Trane AC-2-1, AC-2-2 Capacity/Size Quantity 30 Tons Inspector Estimate 3rd Building Addition - Roof Quantity 2 PB/A&W Page 3 of 15
Building Assessment Survey 2017-2018 AIR CONDITIONING Packaged / Rooftop Unit Source of Heating Gas Manufacturer Trane AC-1-1, AC-1-2 Capacity/Size Quantity 22 Tons Inspector Estimate Packaged Terminal A/C Refrigerant Piping Return Fan CENTRAL ACID WASTE NEUTRALIZING TANK CLIMATE CONTROL SYSTEM BMS 3rd Building Addition - Throughout Quantity 1 Building Area Covered by Operational System 81-100% BEYOND USEFUL LIFE Location/ 3rd Building Addition - Throughout Quantity 1 REPLACE Urgency of Action PRIORITY 1 Photo1 Pneumatic System Quantity 1 Original Building, 1st, 2nd Building Additions - Throughout except Library Building Area Covered by Operational System 21-40% Location/ Quantity 25 DEFECTIVE TEMPERATURE CONTROL THERMOSTAT Rooms 106, 204, 207, 227, 228 and other locations PB/A&W Page 4 of 15
Building Assessment Survey 2017-2018 CLIMATE CONTROL SYSTEM Pneumatic System DEFECTIVE TERMINAL UNIT CONTROLLER Location/ MER below Gymnasium for Gymnasium Supply Fan Quantity 1 Photo1 Hybrid System Electric System Library Quantity 1 Building Area Covered by Operational System 81-100% COMPACTOR CONVEYING Dumbwaiter Elevator Are all the existing elevators operable? Yes Escalator Non-auditorium Handicap Lift - Vertical Non-auditorium Handicap Lift - Stair Ash Hoist Sidewalk Elevator DOMESTIC WATER SYSTEM Domestic Cold Water System Gravity System Pressure Booster System Water Service Crawlspace Below Gymnasium Quantity 1 School Yard - Water Meter Room Quantity 2 Domestic Hot Water System PB/A&W Page 5 of 15
Building Assessment Survey 2017-2018 DOMESTIC WATER SYSTEM Domestic Hot Water System Domestic Hot Water Remote Storage Tank Domestic Water Heat Exchanger Electric Domestic Water Heater Gas Fired Domestic Water Heater Boiler Room Quantity 1 Manufacturer PVI N/A Capacity/Size Quantity 800 MBH Input Capacity/Size2 Quantity 400 Capacity/Size2 UOM Gallons Custodial Staff DEFECTIVE FRESH AIR LOUVER/DAMPER Location/ Boiler Room Quantity 1 Photo1 Oil Fired Domestic Water Heater Domestic Water Distribution Piping DEFECTIVE DOMESTIC HOT WATER CIRCULATING PUMP Location/ Boiler Room near Gas Fired Domestic Water Heater Quantity 1 Photo1 DRAIN/WASTE/VENT AND STORM SYSTEM Interior Storm Piping Sewage/Waste/Vent Piping Sewage Ejector Pump Sump Pump PB/A&W Page 6 of 15
Building Assessment Survey 2017-2018 DRAIN/WASTE/VENT AND STORM SYSTEM Sump Pump DEFECTIVE MOTOR Location/ Boiler Room (1 of 4) Quantity 1 REPLACE Photo1 DUAL TEMPERATURE SYSTEM (CHILLED AND HOT WATER) FIXTURES Staff And Other Janitor Sink Lavatory/Sink Toilet Urinal Student Drinking Fountain Location/ Quantity 1 DEFECTIVE AUXILIARY (FAUCET, SHUT OFF VALVE,ETC.) Basement Cafeteria Photo1 Lavatory/Sink Locker Room Shower Sink And Fountain Combo Unit Toilet Urinal PB/A&W Page 7 of 15
Building Assessment Survey 2017-2018 FIXTURES Student Urinal GAS FIRED FURNACE GAS SERVICE Gas Distribution Piping Gas Meter Room Exhaust Fan Gas Meter Room Vent Gas Pressure Booster CO/Gas Leak Detection Boiler Room, Gas Meter Room Quantity 1 Custodial Staff DEFECTIVE SENSOR Location/ Boiler Room near Gas Fired Domestic Water Heater Quantity 1 REPLACE Urgency of Action PRIORITY 5 Purpose of Action LEVEL 6 Photo1 BEYOND USEFUL LIFE Location/ 3rd Building Addition - Throughout Quantity 1 REPLACE Urgency of Action PRIORITY 1 Photo1 HEATING Heating Coil In Ductwork Hydronic Heating Radiator/Convector/Fin Tube PB/A&W Page 8 of 15
HEATING Radiator/Convector/Fin Tube Steam Heating F&T/Steam Drip Trap Location/ Quantity 20 5 - Poor DEFECTIVE/DETERIORATED MER next to Gas Meter Room, MER below Gymnasium, Crawlspace below Gymnasium REPLACE Photo1 MER Steam and Condensate Piping Steam Condensate Return Piping Steam Condensate Return Pumping System DEFECTIVE TANK Location/ Boiler Room (1 of 5) Quantity 1 REPAIR Photo1 Steam Piping Terminal Unit Thermostatic Trap Location/ Quantity 110 5 - Poor DEFECTIVE/DETERIORATED Original Building, 1st, 2nd Building Additions - Throughout REPLACE Photo1 NYC Department of Education Building Assessment Survey 2017-2018 Steam supplied by External Sources Unit Heater/Cabinet Heater PB/A&W Page 9 of 15
Building Assessment Survey 2017-2018 HEATING Unit Heater/Cabinet Heater DEFECTIVE Location/ Elevator Machine Room 107 Quantity 1 Photo1 HEATING PLANT Replacement Quantity 9,096 Replacement Uom Burner Type Heating Plant Oil Number Boiler Auxiliaries Boiler Auxiliary Piping Boiler Emergency Stop Switch Boiler Feedwater System Boiler Feedwater Treatment(Automatic) Boiler Flue Exhaust Boiler Make-up Water Backflow Preventer Boiler Room Steam And Condensate Piping Boiler Safety Valve MBH Net Dual Fuel (Gas/Oil) 2 PB/A&W Page 10 of 15
Building Assessment Survey 2017-2018 HEATING PLANT Boiler Auxiliaries Boiler Safety Valve Boiler System Coal-fired Boiler Hot Water Boiler Modular Boiler Steam Boiler Boiler Room Quantity 4,548 MBH Net Manufacturer A. L. Eastmond & Sons Inc. 7729-01 Capacity/Size Quantity 4,548 MBH Net Custodial Staff Boiler Room Quantity 4,548 MBH Net Manufacturer A. L. Eastmond & Sons Inc. 7729-02 Capacity/Size Quantity 4,548 MBH Net Custodial Staff Fuel System Boiler Fresh Air Louver/Damper DEFECTIVE ACTUATOR Location/ Boiler Room for Boiler #2 Quantity 1 PB/A&W Page 11 of 15
Building Assessment Survey 2017-2018 HEATING PLANT Fuel System Boiler Fresh Air Louver/Damper Photo1 Burner/Burner Control Panel Fuel Oil Storage/Supply System FUEL OIL LEVEL GAUGE: DEFECTIVE Location/ Boiler Room Quantity 1 Photo1 Gas Trains And Vent At The Boiler Enclosed IDF Room on Room 254 Dedicated A/C on Room 254 4 - Between Fair and Poor DOES NOT EXIST Location/ Room 254 Quantity 1 INSTALL Photo1 KITCHEN on 1st Floor CO Detector on 1st Floor Not Required PB/A&W Page 12 of 15
KITCHEN Gas System on 1st Floor Grease Trap on 1st Floor Hood on 1st Floor Hood Exhaust Ductwork on 1st Floor Hood Exhaust Fan on 1st Floor Hood Fire Suppression System on 1st Floor Hot Water Temperature Booster on 1st Floor Kitchen Sink on 1st Floor MDF Room on Room 202 Dedicated A/C on Room 202 SCIENCE DEMO ROOM NYC Department of Education Building Assessment Survey 2017-2018 PB/A&W Page 13 of 15
Building Assessment Survey 2017-2018 SCIENCE DEMO ROOM on Room 225 Alternative use Yes Acid Waste Neutralizing Tank on Room 225 CO Detector Not Required on Room 225 Not Required Emergency Shower on Room 225 Eye Wash on Room 225 Hood Exhaust Ductwork on Room 225 Hood Exhaust Fan on Room 225 Fixed Laboratory Hood on Room 225 Laboratory Sink on Room 225 Make-up Air Unit on Room 225 SCIENCE LAB SCIENCE PREP ROOM SPRINKLERS, STANDPIPE, FIRE SYSTEM Dry Sprinkler Alarm Valve Assembly Wet Sprinkler Alarm Valve Assembly Fire Booster Pump Assembly Roof Tank Siamese Connection Sprinkler Head Sprinkler Piping Standpipe System Hose Valve Assembly Piping Water Gong SWIMMING POOL VENTILATION PB/A&W Page 14 of 15
Building Assessment Survey 2017-2018 VENTILATION Exhaust Fan Approximate Total # of Fans 1-25 Heating And Ventilating Unit Metal Ductwork DAMAGED FLEXIBLE CONNECTION Location/ MER below Gymnasium for Gymnasium Supply Fan Quantity 1 REPLACE Photo1 Supply Fan Approximate Total # of Fans 1-5 Unit Ventilator PB/A&W Page 15 of 15