EEDEN08-00 technical data RZQS7-40C7VB air conditioning systems Split Sky Air
Split - Sky Air Daikin s unique position as a manufacturer of air conditioning equipment, compressors and refrigerants has led to its close involvement in environmental issues. For several years Daikin has had the intention to become a leader in the provision of products that have limited impact on the environment. This challenge demands the eco design and development of a wide range of products and an energy management system, resulting in energy conservation and a reduction of waste. Het ISO400 assures an effective environmental management system in order to help protect human health and the environment from potential impact of our activities, products and services and to assist in maintaining and improving the quality of the environment. Daikin Europe N.V. is approved by LRQA for its Quality Management System in accordance with the ISO900 standard. ISO900 pertains to quality assurance regarding design, development, manufacturing as well as to services related to the product. The present publication is drawn up by way of information only and does not constitute an offer binding upon Daikin Europe N.V.. Daikin Europe N.V. has compiled the content of this publication to the best of its knowledge. No express or implied warranty is given for the completeness, accuracy, reliability or fitness for particular purpose of its content and the products and services presented therein. Specifications are subject to change without prior notice. Daikin Europe N.V. explicitly rejects any liability for any direct or indirect damage, In the broadest sense, arising from or related to the use and/or interpretation of this publication. All content is copyrighted by Daikin Europe N.V.. Daikin units comply with the European regulations that guarantee the safety of the product. Naamloze Vennootschap Zandvoordestraat 300 B-8400 Ostend, Belgium www.daikin.eu BTW: BE 042 20 336 RPR Oostende Daikin Europe N.V. participates in the Eurovent Certification Programme for Air Conditioners (AC), Liquid Chilling Packages (LCP) and Fan Coil Units (FC); the certified data of certified models are listed in the Eurovent Directory. EEDEN08-00 - 02/2008 Printed in Belgium by Goekint Graphics Copyright Daikin
EEDEN08-00 technical data RZQS7-40C7VB air conditioning systems Split Sky Air
Outdoor Units R-40A RZQS7-40C7VB TABLE OF CONTENTS RZQS7-40C7VB Features............................................................. 5 2 Specifications....................................................... 6 Nominal Capacity and Nominal Input............................... 6 Technical Specifications............................................. 7 Electrical Specifications............................................. 9 3 Electrical data...................................................... 0 4 Options............................................................. 2 5 Capacity tables.................................................... 3 Combination table................................................... 3 Cooling capacity tables............................................. 5 Heating capacity tables............................................. 22 6 Dimensional drawing & centre of gravity....................... 27 Dimensional drawing................................................ 27 Centre of gravity.................................................... 28 7 Piping diagram..................................................... 29 8 Wiring diagram..................................................... 3 Wiring diagram...................................................... 3 9 Sound data......................................................... 32 Sound pressure spectrum........................................... 32 Sound power spectrum............................................. 34 0 Installation.......................................................... 35 Installation method.................................................. 35 Operation range................................................... 36 Split Sky Air Outdoor Units 4
i 7 n y 0 k 4 r - o t o 07 i d l t 4 puz - Outdoor Units R-40A RZQS7-40C7VB Features V C U S A S Q SR O Outdoor units for pair, twin, triple, double twin application The Sky Air Inverter is developed for use in shops, restaurants and small offices. This innovative Daikin unit provides a more comfortable environment and offers great savings in energy consumption to shop and office owners. The use of inverter type outdoor units results in an air conditioning system with a high energy efficiency and very low sound level An inverter driven compressor allows the capacity to be adjusted precisely to match variations in room and outside temperatures. During start up, the room can be cooled down or heated very quickly. Once the temperature in the room has reached its set point, the low power operation starts to save energy. Daikin outdoor units are neat and sturdy and can be mounted easily on a roof or terrace or simply placed against an outside wall. Outdoor units are fitted with either a swing or scroll compressor, renowned for low noise and high energy efficiency A special acryl precoated fin for anti-corrosion treatment on the heat exchanger ensures greater resistance against severe weather conditions 5 Split Sky Air Outdoor Units
2 Specifications Outdoor Units R-40A RZQS7-40C7VB 2- NOMINAL CAPACITY AND NOMINAL INPUT RZQS7C7VB RZQS00C7VB RZQS25C7VB RZQS40C7VB For combination indoor units + outdoor units Indoor Units FCHQ7C7VEB FCHQ00C7VEB FCHQ25C7VEB FCHQ40C7VEB Cooling capacity Standard kw 7. 0.0 2.5 4.0 Heating capacity Standard kw 8.0.2 4.0 6.0 Power Input Cooling Standard kw 2.36 3.56 3.88 4.98 Heating Standard kw 2.34 3.28 4. 4.98 For EER Nominal 3.0 2.8 3.22 2.8 combination COP Nominal 3.4 3.4 3.4 3.2 indoor units + Energy Label Cooling B C A C outdoor units Heating B B B C Annual energy consumption kwh,80,780,940 2,490 Indoor Units FCQ7C7VEB FCQ00C7VEB FCQ25C7VEB FCQ40C7VEB Cooling capacity Standard kw 7. 0.0 2.5 4.0 Heating capacity Standard kw 8.0.2 4.0 6.0 Power Input Cooling Standard kw 2.46 3.83 4.4 5.36 Heating Standard kw 2.6 3.47 4.52 5.69 For EER Nominal 2.89 2.6 3.02 2.6 combination COP Nominal 3.07 3.23 3. 2.8 indoor units + Energy Label Cooling C D B D outdoor units Heating D C D D Annual energy consumption kwh,230,95 2,070 2,680 Indoor Units FBQ7B8V3B FBQ00B8V3B FBQ25B8V3B FBQ40B8V3B Cooling capacity Standard kw 7. 0.0 2.5 3.4 Heating capacity Standard kw 8.0.2 4.0 5.5 Power Input Cooling Standard kw 2.52 3.83 4.4 4.97 Heating Standard kw 2.40 3.47 4.24 4.99 For EER Nominal 2.82 2.6 2.84 2.70 combination COP Nominal 3.33 3.23 3.3 3. indoor units + Energy Label Cooling C D C D outdoor units Heating C C C D Annual energy consumption kwh,260,95 2,200 2,485 Indoor Units FHQ7BVVB FHQ00BVVB FHQ25BVVB Cooling capacity Standard kw 7. 0.0 2.5 Heating capacity Standard kw 8.0.2 4.0 Power Input Cooling Standard kw 2.53 4.5 4.58 Heating Standard kw 2.85 3.99 4.96 For EER Nominal 2.8 2.4 2.73 combination COP Nominal 2.8 2.8 2.82 indoor units + Energy Label Cooling C E D outdoor units Heating C D D Annual energy consumption kwh,265 2,075 2,290 Indoor Units FAQ7BVVB FAQ00BVVB FDQ25B8V3B Cooling capacity Standard kw 7. 0.0 2.5 Heating capacity Standard kw 8.0.2 4.0 Power Input Cooling Standard kw 2.53 4.08 4.45 Heating Standard kw 2.6 3.73 4.08 For EER Nominal 2.8 2.45 2.8 combination COP Nominal 3.07 3.00 3.43 indoor units + Energy Label Cooling C F C outdoor units Heating D D B Annual energy consumption kwh,265 2,040 2,225 Indoor Units FVQ7BVB FVQ00BVB FVQ25BVB Cooling capacity Standard kw 7. 0.0 2.5 Heating capacity Standard kw 8.0.2 4.0 Power Input Cooling Standard kw 2.53 4.02 4.45 Heating Standard kw 2.49 3.99 4.36 3 2 Split Sky Air Outdoor Units 6
2 Specifications Outdoor Units R-40A RZQS7-40C7VB 2 2- NOMINAL CAPACITY AND NOMINAL INPUT RZQS7C7VB RZQS00C7VB RZQS25C7VB RZQS40C7VB For combination indoor units + outdoor units EER Nominal 2.8 2.49 2.8 COP Nominal 3.2 2.8 3.2 Energy Label Cooling C E C Heating C D C Annual energy consumption kwh,265 2,00 2,225 2-2 TECHNICAL SPECIFICATIONS RZQS7C7VB RZQS00C7VB RZQS25C7VB RZQS40C7VB Casing Colour Ivory White Material Painted galvanised steel Dimensions Unit Height mm 770 700,70 70 Width mm 900 900 900 900 Depth mm 320 320 320 320 Packing Height mm 900 900,349 349 Width mm 980 980 980 980 Depth mm 420 420 420 420 Weight Unit kg 68 68 03 03 Packed Unit kg 72 72 4 4 Heat Dimensions Length mm 857 857 857 857 Exchanger Nr of Rows 2 2 2 2 Fin Pitch mm.4.4.4.4 Nr of Passes 8 8 0 0 Face Area m² 0.64 0.64 0.98 0.98 Nr of Stages 34 34 52 52 Tube type Hi-XSS(8) Fin Type WF fin Treatment Anti-corrosion treatment (PE) Fan Type Propeller Discharge direction Horizontal Quantity 2 2 Air Flow Rate Cooling m³/min 52 6.3 00 97 (nominal at Heating m³/min 52 63.5 88 88 230V) Motor Quantity 2 2 Model KFD-325-70-8A KFD-325-70-8A Brushless DC Motor Motor Speed Steps 8 8 0 0 (nominal) Cooling rpm 800 920 850 830 (Standard) Heating rpm 745 950 740 740 (Standard) Fan Motor Output W 70 70 70 70 Compressor Quantity Motor Model 2YC63DXD 2YC63DXD JT00G-VD JT00G-VD Type Hermetically sealed swing compressor Hermetically sealed scroll compressor Motor Output W,700 2,400 2,200 2,200 Operation Range Crankcase Heater W 33 33 Starting Method Inverter driven Cooling Min CDB -5-5 -5-5 Max CDB 46 46 46 46 Heating Min CWB -5-5 -5-5 Max CWB 5.5 5.5 5.5 5.5 7 Split Sky Air Outdoor Units
2 Specifications Outdoor Units R-40A RZQS7-40C7VB 2-2 TECHNICAL SPECIFICATIONS RZQS7C7VB RZQS00C7VB RZQS25C7VB RZQS40C7VB Sound Level (nominal) Cooling Heating Sound Power Sound Pressure (Standard) Sound Pressure (Standard) dba 65 67 67 68 dba 49 5 5 52 dba 5 55 53 54 Sound Level (Night quiet) Sound Pressure dba 47 49 49 50 Refrigerant Type R-40A Charge kg 2.75 2.75 3.7 3.7 Control Expansion valve (electronic type) Nr of Circuits Refrigerant Oil Type FVC50K FVC50K Daphne FVC68D Daphne FVC68D Charged Volume l 0.75 0.75.0.0 Piping Liquid (OD) Quantity connections Type Flare connection Diameter (OD) mm 9.52 9.52 9.52 9.52 Gas Quantity Type Flare connection Diameter (OD) mm 5.9 5.9 5.9 5.9 Drain Quantity 3 3 3 3 Type Hole Diameter mm 26 26 26 26 (OD) Piping Length Minimum m 5 5 5 5 Maximum m 30 50 50 50 Equivalent m 40 70 70 70 Chargeless m 30 30 30 30 Additional Refrigerant Charge kg/m see installation manual 4PW4046- see installation manual 4PW34874- Installation height difference Maximum m 5 30 30.0 30.0 Max. internunit level difference m 0.5 0.5 0.5 0.5 Heat Insulation Both liquid and gas pipes Defrost Method Pressure equalising Defrost Control Temperature Sensor for outdoor heat exchanger temperature Capacity Control Method Inverter controlled Safety Devices High pressure switch Fan motor thermal protector Fuse Standard Item Tie-wraps Accessories Quantity 2 2 2 2 Item Installation manual Quantity Notes Nominal cooling capacities are based on : indoor temperature : 27 CDB, 9 CWB, outdoor temperature : 35 CDB, equivalent refrigerant piping : 5m, level difference : 0m. Nominal heating capacities are based on : indoor temperature : 20 CDB, outdoor temperature : 7 CDB, 6 CWB, equivalent refrigerant piping : 5m, level difference : 0m 3 2 Split Sky Air Outdoor Units 8
2 Specifications Outdoor Units R-40A RZQS7-40C7VB 2 2-3 ELECTRICAL SPECIFICATIONS RZQS7C7VB RZQS00C7VB RZQS25C7VB RZQS40C7VB Power Supply Name V Phase ~ Frequency Hz 50 50 50 50 Voltage V 220-240 Voltage range Minimum V 98 98 98 98 Maximum V 264 264 264 264 Current Rsce/Sse -/kva Equipment complying with EN 6000-3-2 Recomended fuses A 20 20 32 32 Wiring For Power Supply Remark see installation manual 4PW4046- see installation manual 4PW34874- connections For connection with indoor Remark see installation manual 4PW4046- see installation manual 4PW34874- Power Supply Intake Outdoor unit only Notes See separate drawings for electrical data Power supply to the FDQ indoor unit is separate 9 Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 3 Electrical data RZQ(S)7-00C Unit combination Power supply Comp. OFM IFM Indoor unit Outdoor unit Hz-volts Voltage range MCA TOCA MFA MSC RLA kw FLA kw FLA 3 3 Max. 50Hz 264V Min. 50Hz 98V Max. 50Hz 264V Min. 50Hz 98V Max. 50Hz 264V Min. 50Hz 98V SYMBOLS MCA : Min. Circuit Amps (A) TOCA : Total Over Current Amps (A) MFA : Max. Fuse Amps (A) (See note 7) MSC : MSC means the max. current during the starting of compressor. (A) RLA : Rated Load Amps (A) OFM : Outdoor Fan Motor (A) IFM : Indoor Fan Motor FLA : Full Load Amps kw : Fan Motor Rated Output RLA is based on the following conditions: Power supply: 50Hz - 230V Cooling Indoor temperature 27 CDB/9 CWB Outdoor temperature 35 CDB Heating Indoor temperature 20.0 CDB Outdoor temperature 7.0 CDB/6.0 CWB 2 TOCA means the total value of each OC set 3 Voltage range Units are suitable for use on electrical systems where voltage supplied to unit terminals is not below or above listed operation range limits 4 Maximum allowable voltage unbalance between phases is 2% 5 MCA represents maximum input current., MFA represents capacity which may accept MCA (next lower standard fuse rating, min.5a) 6 Select wire size based on the larger value of MCA or TOCA 7 MFA is used to select the circuit breaker and the ground fault circuit interrupter (earth leakage circuit breaker) 3D0599A Split Sky Air Outdoor Units 0
Outdoor Units R-40A RZQS7-40C7VB 3 Electrical data RZQS25-40C 3 Unit combination Power supply Comp. OFM IFM Indoor unit Outdoor unit Hz-volts Voltage range MCA TOCA MFA MSC RLA kw FLA kw FLA Max. 50Hz 264V Min. 50Hz 98V Max. 50Hz 264V Min. 50Hz 98V SYMBOLS MCA : Min. Circuit Amps (A) TOCA : Total Over Current Amps (A) MFA : Max. Fuse Amps (A) (See note 7) MSC : MSC means the max. current during the starting of compressor. (A) RLA : Rated Load Amps (A) OFM : Outdoor Fan Motor (A) IFM : Indoor Fan Motor FLA : Full Load Amps kw : Fan Motor Rated Output RLA is based on the following conditions: Power supply: 50Hz - 230V Cooling Indoor temperature 27 CDB/9 CWB Outdoor temperature 35 CDB Heating Indoor temperature 20.0 CDB Outdoor temperature 7.0 CDB/6.0 CWB 2 TOCA means the total value of each OC set 3 Voltage range Units are suitable for use on electrical systems where voltage supplied to unit terminals is not below or above listed operation range limits 4 Maximum allowable voltage unbalance between phases is 2% 5 MCA represents maximum input current., MFA represents capacity which may accept MCA (next lower standard fuse rating, min.5a) 6 Select wire size based on the larger value of MCA or TOCA 7 MFA is used to select the circuit breaker and the ground fault circuit interrupter (earth leakage circuit breaker) 3D057296C Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 4 Options Available options for RZQS00-40C7VB Kit name Name of option RZQS25C7VB Central drain pan kit KKPJ5F80 Refrigerant branch piping Twin KHRQ22M20TA Triple KHRQ27H Double twin KHRQ22M20TA (3x) Demand adaptor KRP58M5 RZQS40C7VB 3TW26739-E 3 4 Split Sky Air Outdoor Units 2
5 Capacity tables 5 - Combination table Outdoor Units R-40A RZQS7-40C7VB 5 Refrigerant R40A Model name Hi casette Thin cassette 2x2 cassette Duct (medium ESP) Ceiling suspended 4way ceiling Wall mounted Outdoor unit P = Pair 7 00 2 = Twin 35+35 50+50 3 = Triple 35+35+35 3TW30469- See main specifications table about MAX cooling capacity & heating capacity. 2 Combinations are possible regardingless type of I/U. (e.g. RZQS00 can be combined with FFQ50 + FBQ50) 3 Individual indoor capacities are not given because the combinations are for simultaneous operation (=indoor units installed in same room). 4 When different indoor models are used in combination, designate the infrared remote controller that is equipped with the most functions as the main unit. In table above are the indoor units mentioned in order of the possible function (most functions are on FCQ, less functions are on FAQ). 5 Refnet kits that are necessary to install the combinations: Twin: KHRQ22M20TA Triple: KHRQ27H 3 Split Sky Air Outdoor Units
5 Capacity tables Outdoor Units R-40A RZQS7-40C7VB 5 - Combination table RZQS 25-40C Possible combinations and standard capacity for twin, triple and double twin operation Possible indoor combination Simultaneous operation Twin Triple Double twin 3 5 Outdoor models Out Out Out In In In In In In In In In RZQS25C7VB 60-60 (KHRQ22M20TA) 50-50-50 (KHRQ27H) 35-35-35-35 (3x KHRQ22M20TA) RZQS40C7VB 7-7 (KHRQ22M20TA) 50-50-50 (KHRQ27H) 35-35-35-35 (3x KHRQ22M20TA) 3TW2969-3 Possible indoor units:fcqh7c, FCQ35-7C, FFQ35-60BV, FHQ35-7B, FBQ35-7B, FAQ7B 2 Individual indoor capacities are not given because the combinations are for simultaneous operation (=indoor units installed in same room). 3 When different indoor models are used in combination, designate the infrared remote controller that is equipped with the most functions as the main unit.in note are the indoor units mentioned in order of the possible function (most functions are on FCQ, less functions are on FAQ). 4 Between brackets are the required Refnet kits mentioned, that are necessary to install the combination. Split Sky Air Outdoor Units 4
5 Capacity tables 5-2 Cooling capacity tables RZQS7C Outdoor Units R-40A RZQS7-40C7VB 5 Cooling Coefficient of power input. Capacity range Rated point Cooling capacity Cooling capacity Indoor temp. Outdoor ( CDB) EWB EDB 25 30 35 40 ( C) ( C) 6.0 22 6.47 4.39 0.76 6.46 4.43 0.89 6.66 4.62 0.99 6.39 4.49.09 8.0 25 7.43 4.82 0.83 7.20 4.72 0.9 6.95 4.6.00 6.67 4.47.0 9.0 27 7.58 4.80 0.84 7.35 4.7 0.9 7.0 4.60.00 6.82 4.46.0 9.5 27 7.6 4.79 0.84 7.43 4.70 0.9 7.7 4.59.00 6.86 4.46.0 22.0 30 8.05 4.73 0.85 7.8 4.64 0.92 7.55 4.54.0 7.26 4.4. 24.0 32 8.37 4.66 0.85 8.2 4.58 0.93 7.85 4.48.02 7.55 4.35.2 3D05989A. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 5.0 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. (Multi) Model FCQH7C FCQ7C FBQ7 FHQ7 FAQ7 FVQ7 AFR 20 5.5 9 7 9 8 (BF) (0.7) (0.9) (0.) (0.0) (0.08) (0.6) Model FCQ35Cx2 FFQ35x2 FBQ35x2 FHQ35x2 AFR 0.5x2 0x2.5x2 3x2 (BF) (0.28x2) (0.25x2) (0.5x2) (0.2x2) SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw 0. Rated power input of each model is tabulated below. Model FCQH7C FCQ7C FBQ7 FHQ7 FAQ7 FVQ7 Cooling 2.36 2.46 2.52 2.53 2.53 2.53 Heating 2.34 2.6 2.40 2.85 2.6 2.49 (Multi) Model FCQ35Cx2 FFQ35x2 FBQ35x2 FHQ35x2 Cooling 2.59 2.6 2.57 2.66 Heating 2.75 2.70 2.47 2.85 5 Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 5 Capacity tables 5-2 Cooling capacity tables RZQS00C Cooling Coefficient of power input. 3 5 Capacity range Rated point Cooling capacity Cooling capacity Indoor temp. Outdoor ( CDB) EWB EDB 25 30 35 40 ( C) ( C) 6.0 22 9.2 6.9 0.76 9.0 6.25 0.89 9.38 6.5 0.99 9.00 6.32.09 8.0 25 0.5 6.78 0.83 0. 6.65 0.9 9.79 6.49.00 9.40 6.30.0 9.0 27 0.7 6.76 0.84 0.4 6.63 0.9 0.0 6.48.00 9.60 6.29.0 9.5 27 0.8 6.75 0.84 0.5 6.62 0.9 0. 6.47.00 9.7 6.28.0 22.0 30.3 6.66 0.85.0 6.54 0.92 0.6 6.39.0 0.2 6.2. 24.0 32.8 6.57 0.85.4 6.45 0.93. 6.30.02 0.6 6.3.2 3D05988A. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 5.0 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. (Twin) (Triple) Model FCQH00C FCQ00C FBQ00 FHQ00 FAQ00 FVQ00 AFR 32.5 23.5 27 24 23 28 (BF) (0.7) (0.6) (0.20) (0.4) (0.0) (0.9) Model FCQ35Cx2 FFQ35x2 FBQ35x2 FHQ35x2 AFR 0.5x2 0x2.5x2 3x2 (BF) (0.28x2) (0.25x2) (0.5x2) (0.2x2) Model FCQ35Cx3 FFQ35x3 FBQ35x3 FHQ35x3 AFR 0.5x3 0x3.5x3 3x3 (BF) (0.28x3) (0.25x3) (0.5x3) (0.2x3) SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw 0. Rated power input of each model is tabulated below. Model FCQH00C FCQ00C FBQ00 FHQ00 FAQ00 FVQ00 Cooling 3.56 3.83 3.83 4.5 4.08 4.02 Heating 3.28 3.47 3.47 3.99 3.73 3.99 (Twin) Model FCQ50Cx2 FFQ50x2 FBQ50x2 FHQ50x2 Cooling 3.83 3.83 3.83 4.5 Heating 3.65 3.54 3.58 3.99 (Triple) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 Cooling 3.83 3.83 3.83 4.5 Heating 3.65 3.54 3.58 3.99 Split Sky Air Outdoor Units 6
5 Capacity tables 5-2 Cooling capacity tables RZQS25C Outdoor Units R-40A RZQS7-40C7VB 5 Cooling Coefficient of power input. Capacity range Rated point Cooling capacity Cooling capacity Indoor temp. Outdoor ( CDB) EWB EDB 25 30 35 40 ( C) ( C) 6.0 22.4 7.73 0.76.4 7.8 0.89.7 8.4 0.99.3 7.90.09 8.0 25 3. 8.48 0.83 2.7 8.32 0.9 2.2 8.2.00.8 7.88.0 9.0 27 3.3 8.45 0.84 2.9 8.29 0.9 2.5 8.09.00 2.0 7.86.0 9.5 27 3.5 8.44 0.84 3. 8.28 0.9 2.6 8.08.00 2. 7.85.0 22.0 30 4.2 8.33 0.85 3.8 8.8 0.92 3.3 7.99.0 2.8 7.76. 24.0 32 4.7 8.2 0.85 4.3 8.06 0.93 3.8 7.88.02 3.3 7.67.2 3D057300A. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 5.0 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. (Twin) (Triple) Model FCQH25C FCQ25C FBQ25 FHQ25 FAQ25 FVQ25 AFR 32.5 27.5 35 30 45 32 (BF) (0.9) (0.9) (0.4) (0.3) (0.25) (0.6) Model FCQ60Cx2 FFQ60x2 FBQ60x2 FHQ60x2 AFR 3.5x2 5x2 9x2 7x2 (BF) (0.2x2) (0.x2) (0.x2) (0.2x2) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 AFR 2.5x3 2x3 4x3 3x3 (BF) (0.2x3) (0.6x3) (0.5x3) (0.x3) (Double twin) Model FCQ35Cx4 FFQ35x4 FBQ35x4 FHQ35x4 AFR 0.5x4 0x4.5x4 3x4 (BF) (0.28x4) (0.25x4) (0.5x4) (0.2x4) SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw 0. Rated power input of each model is tabulated below. Model FCQH25C FCQ25C FBQ25 FHQ25 FAQ25 FVQ25 Cooling 3.88 4.4 4.40 4.58 4.45 4.45 Heating 4. 4.52 4.24 4.96 4.08 4.36 (Twin) Model FCQ60Cx2 FFQ60x2 FBQ60x2 FHQ60x2 Cooling 4.36 4.4 4.48 4.76 Heating 4.76 4.42 4.42 4.92 (Triple) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 Cooling 4.36 4.4 4.48 4.76 Heating 4.76 4.42 4.42 4.92 (Double twin) Model FCQ35Cx4 FFQ35x4 FBQ35x4 FHQ35x4 Cooling 4.36 4.4 4.48 4.76 Heating 4.76 4.42 4.42 4.92 7 Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 5 Capacity tables 5-2 Cooling capacity tables RZQS40C (Pair + twin/triple/double twin) Cooling Coefficient of power input. 3 5 Capacity range Rated point Cooling capacity Cooling capacity Indoor temp. Outdoor ( CDB) EWB EDB 25 30 35 40 ( C) ( C) 6.0 22 2.8 8.66 0.76 2.7 8.74 0.89 3. 9.2 0.99 2.6 8.84.09 8.0 25 4.6 9.50 0.83 4.2 9.3 0.9 3.7 9.09.00 3.2 8.82.0 9.0 27 5.0 9.47 0.84 4.5 9.29 0.9 4.0 9.07.00 3.4 8.80.0 9.5 27 5. 9.45 0.84 4.7 9.27 0.9 4. 9.05.00 3.6 8.79.0 22.0 30 5.9 9.33 0.85 5.4 9.6 0.92 4.9 8.95.0 4.3 8.69. 24.0 32 6.5 9.20 0.85 6.0 9.03 0.93 5.5 8.83.02 4.9 8.59.2 3D05730. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 5.0 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. (Triple) Model FCQH40C FCQ40C AFR 32.5 27.5 (BF) (0.20) (0.22) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 AFR 2.5x3 2x3 4x3 3x3 (BF) (0.2x3) (0.6x3) (0.5x3) (0.x3) 0. Rated power input of each model is tabulated below. Model FCQH40C FCQ40C Cooling 4.98 5.36 Heating 4.98 5.69 (Triple) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 Cooling 5.36 5.2 5.2 5.25 Heating 5.55 5.70 5.64 5.70 SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw (Twin) Model FCQ7Cx2 FBQ7x2 FHQ7x2 FAQ7x2 AFR 5.5x2 9x2 7x2 9x2 (BF) (0.9x2) (0.x2) (0.x2) (0.08x2) (Double twin) Model FCQ35Cx4 FFQ35x4 FBQ35x4 FHQ35x4 AFR 0.5x4 0x4.5x4 3x4 (BF) (0.28x4) (0.25x4) (0.5x4) (0.2x4) (Twin) Model FCQ7Cx2 FBQ7x2 FHQ7x2 FAQ7x2 Cooling 5.36 5.2 5.25 5.25 Heating 5.55 5.64 5.70 5.63 (Double twin) Model FCQ35Cx4 FFQ35x4 FBQ35x4 FHQ35x4 Cooling 5.36 5.2 5.2 5.25 Heating 5.55 5.70 5.64 5.70 Split Sky Air Outdoor Units 8
5 Capacity tables 5-2 Cooling capacity tables RZQS40C Outdoor Units R-40A RZQS7-40C7VB 5 Cooling Coefficient of power input. Cooling capacity Rated point Capacity range Cooling capacity Indoor temp. Outdoor ( CDB) EWB EDB 25 30 35 40 ( C) ( C) 6.0 22 2.3 8.29 0.76 2.2 8.37 0.89 2.5 8.73 0.99 2. 8.46.09 8.0 25 4.0 9.09 0.83 3.6 8.9 0.9 3. 8.70.00 2.6 8.44.0 9.0 27 4.4 9.06 0.84 3.9 8.89 0.9 3.4 8.68.00 2.8 8.42.0 9.5 27 4.5 9.05 0.84 4. 8.87 0.9 3.5 8.66.00 3.0 8.4.0 22.0 30 5.2 8.93 0.85 4.7 8.77 0.92 4.3 8.57.0 3.7 8.32. 24.0 32 5.8 8.8 0.85 5.3 8.64 0.93 4.8 8.45.02 4.3 8.22.2 3TW2849-. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 7.5 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. AFR (BF) FBQ40 35 (0.4) SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw 0. Rated power input of each model is tabulated below. Outdoor Indoor Cooling Heating RZQS40C7 FBQ40B8 4.97kW 4.99kW 9 Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 5 Capacity tables 5-2 Cooling capacity tables RZQS7-00C7VB Capacity in function of field piping length for non-inverter 3 5 Capacity (%) length (m) Cooling Heating 3TW29069-3 Split Sky Air Outdoor Units 20
5 Capacity tables 5-2 Cooling capacity tables RZQS25-40C Outdoor Units R-40A RZQS7-40C7VB 5 Capacity in function of field piping length for non-inverter Capacity (%) Cooling Heating length (m) 3TW29069-3 2 Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 5 Capacity tables 5-3 Heating capacity tables RZQS7C Heating Coefficient of power input. 3 5 Capacity range Rated point Heating capacity Heating capacity Indoor Outdoor ( CDB) temp. EDB -0-5 0 6 0 ( C) 6.0 5.68.2 6.22.7 6.75.23 8.02 0.92 8.64 0.97 8.0 5.67.6 6.2.22 6.74.28 8.0 0.96 8.62.0 20.0 5.67.2 6.20.27 6.74.33 8.00.00 8.6.05 2.0 5.66.23 6.20.29 6.73.35 8.00.02 8.6.07 22.0 5.66.25 6.9.32 6.73.28 7.99.04 8.60.09 24.0 5.65.30 6.9.36 6.72.43 7.98.08 8.59.3 3D05989A. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 5.0 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. (Multi) Model FCQH7C FCQ7C FBQ7 FHQ7 FAQ7 FVQ7 AFR 20 5.5 9 7 9 8 (BF) (0.7) (0.9) (0.) (0.0) (0.08) (0.6) Model FCQ35Cx2 FFQ35x2 FBQ35x2 FHQ35x2 AFR 0.5x2 0x2.5x2 3x2 (BF) (0.28x2) (0.25x2) (0.5x2) (0.2x2) SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw 0. Rated power input of each model is tabulated below. Model FCQH7C FCQ7C FBQ7 FHQ7 FAQ7 FVQ7 Cooling 2.36 2.46 2.52 2.53 2.53 2.53 Heating 2.34 2.6 2.40 2.85 2.6 2.49 (Multi) Model FCQ35Cx2 FFQ35x2 FBQ35x2 FHQ35x2 Cooling 2.59 2.6 2.57 2.66 Heating 2.75 2.70 2.47 2.85 Split Sky Air Outdoor Units 22
5 Capacity tables 5-3 Heating capacity tables RZQS00C Outdoor Units R-40A RZQS7-40C7VB 5 Heating Coefficient of power input. Capacity range Rated point Heating capacity Heating capacity Indoor Outdoor ( CDB) temp. EDB -0-5 0 6 0 ( C) 6.0 7.9.07 8.66.2 9.4.7.2 0.92 2. 0.97 8.0 7.90. 8.65.6 9.39.22.2 0.96 2..0 20.0 7.89.5 8.64.2 9.38.27.2.00 2..05 2.0 7.89.7 8.63.23 9.38.29.2.02 2..07 22.0 7.88.20 8.63.26 9.37.32.2.04 2.0.09 24.0 7.87.24 8.62.30 9.36.36.2.08 2.0.3 3D05988A. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 5.0 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. (Twin) (Triple) Model FCQH00C FCQ00C FBQ00 FHQ00 FAQ00 FVQ00 AFR 32.5 23.5 27 24 23 28 (BF) (0.7) (0.6) (0.20) (0.4) (0.0) (0.9) Model FCQ35Cx2 FFQ35x2 FBQ35x2 FHQ35x2 AFR 0.5x2 0x2.5x2 3x2 (BF) (0.28x2) (0.25x2) (0.5x2) (0.2x2) Model FCQ35Cx3 FFQ35x3 FBQ35x3 FHQ35x3 AFR 0.5x3 0x3.5x3 3x3 (BF) (0.28x3) (0.25x3) (0.5x3) (0.2x3) SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw 0. Rated power input of each model is tabulated below. Model FCQH00C FCQ00C FBQ00 FHQ00 FAQ00 FVQ00 Cooling 3.56 3.83 3.83 4.5 4.08 4.02 Heating 3.28 3.47 3.47 3.99 3.73 3.99 (Twin) Model FCQ50Cx2 FFQ50x2 FBQ50x2 FHQ50x2 Cooling 3.83 3.83 3.83 4.5 Heating 3.65 3.54 3.58 3.99 (Triple) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 Cooling 3.83 3.83 3.83 4.5 Heating 3.65 3.54 3.58 3.99 23 Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 5 Capacity tables 5-3 Heating capacity tables RZQS25C Heating Coefficient of power input. 3 5 Capacity range Rated point Heating capacity Heating capacity Indoor Outdoor temp. ( CDB) EDB -5-0 -5 0 6 0 ( C) 6.0 8.83.05 9.76. 0.7.6.6.22 4.0 0.92 5. 0.97 8.0 8.82.0 9.74.5 0.7.2.6.27 4.0 0.96 5..0 20.0 8.8.4 9.73.20 0.7.26.6.32 4.0.00 5..05 2.0 8.8.6 9.73.22 0.6.28.6.34 4.0.02 5..07 22.0 8.80.8 9.72.24 0.6.3.6.37 4.0.04 5..09 24.0 8.79.22 9.7.29 0.6.35.5.42 4.0.08 5.0.3 3D057300A. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 5.0 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. (Twin) (Triple) Model FCQH25C FCQ25C FBQ25 FHQ25 FAQ25 FVQ25 AFR 32.5 27.5 35 30 45 32 (BF) (0.9) (0.9) (0.4) (0.3) (0.25) (0.6) Model FCQ60Cx2 FFQ60x2 FBQ60x2 FHQ60x2 AFR 3.5x2 5x2 9x2 7x2 (BF) (0.2x2) (0.x2) (0.x2) (0.2x2) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 AFR 2.5x3 2x3 4x3 3x3 (BF) (0.2x3) (0.6x3) (0.5x3) (0.x3) (Double twin) Model FCQ35Cx4 FFQ35x4 FBQ35x4 FHQ35x4 AFR 0.5x4 0x4.5x4 3x4 (BF) (0.28x4) (0.25x4) (0.5x4) (0.2x4) SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw 0. Rated power input of each model is tabulated below. Model FCQH25C FCQ25C FBQ25 FHQ25 FAQ25 FVQ25 Cooling 3.88 4.4 4.40 4.58 4.45 4.45 Heating 4. 4.52 4.24 4.96 4.08 4.36 (Twin) Model FCQ60Cx2 FFQ60x2 FBQ60x2 FHQ60x2 Cooling 4.36 4.4 4.48 4.76 Heating 4.76 4.42 4.42 4.92 (Triple) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 Cooling 4.36 4.4 4.48 4.76 Heating 4.76 4.42 4.42 4.92 (Double twin) Model FCQ35Cx4 FFQ35x4 FBQ35x4 FHQ35x4 Cooling 4.36 4.4 4.48 4.76 Heating 4.76 4.42 4.42 4.92 Split Sky Air Outdoor Units 24
5 Capacity tables 5-3 Heating capacity tables RZQS40C (Pair + twin/triple/double twin) Outdoor Units R-40A RZQS7-40C7VB 5 Heating Coefficient of power input. Capacity range Rated point Heating capacity Heating capacity Indoor Outdoor temp. ( CWB) EDB 5 0 5 0 6 0 ( C) 6.O 9.82.05 0.8..9.6 2.9.22 6.0 0.92 7.3 0.97 8.O 9.80.0 0.8.5.8.2 2.9.27 6.0 0.96 7.2.0 20.0 9.79.4 0.8.20.8.26 2.9.32 6.0.00 7.2.05 2.O 9.79.6 0.8.22.8.28 2.8.34 6.0.02 7.2.07 22.O 9.78.8 0.8.24.8.3 2.8.37 6.0.04 7.2.09 24.0 9.77.22 0.8.29.8.35 2.8.42 6.0.08 7.2.3 3D05730. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 5.0 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. (Triple) Model FCQH40C FCQ40C AFR 32.5 27.5 (BF) (0.20) (0.22) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 AFR 2.5x3 2x3 4x3 3x3 (BF) (0.2x3) (0.6x3) (0.5x3) (0.x3) 0. Rated power input of each model is tabulated below. Model FCQH40C FCQ40C Cooling 4.98 5.36 Heating 4.98 5.69 (Triple) Model FCQ50Cx3 FFQ50x3 FBQ50x3 FHQ50x3 Cooling 5.36 5.2 5.2 5.25 Heating 5.55 5.70 5.64 5.70 SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw (Twin) Model FCQ7Cx2 FBQ7x2 FHQ7x2 FAQ7x2 AFR 5.5x2 9x2 7x2 9x2 (BF) (0.9x2) (0.x2) (0.x2) (0.08x2) (Double twin) Model FCQ35Cx4 FFQ35x4 FBQ35x4 FHQ35x4 AFR 0.5x4 0x4.5x4 3x4 (BF) (0.28x4) (0.25x4) (0.5x4) (0.2x4) (Twin) Model FCQ7Cx2 FBQ7x2 FHQ7x2 FAQ7x2 Cooling 5.36 5.2 5.25 5.25 Heating 5.55 5.64 5.70 5.63 (Double twin) Model FCQ35Cx4 FFQ35x4 FBQ35x4 FHQ35x4 Cooling 5.36 5.2 5.2 5.25 Heating 5.55 5.70 5.64 5.70 25 Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 5 Capacity tables 5-3 Heating capacity tables RZQS40C Heating Coefficient of power input. 3 5 Heating capacity Rated point Heating capacity Indoor Outdoor temp. ( CWB) EDB 5 0 5 0 6 0 ( C) 6.O 9.5.05 0.5..5.6 2.5.22 5.5 0.92 6.8 0.97 8.O 9.49.0 0.5.5.4.2 2.5.27 5.5 0.96 6.7.0 20.0 9.48.4 0.5.20.4.26 2.5.32 5.5.00 6.7.05 2.O 9.48.6 0.5.22.4.28 2.4.34 5.5.02 6.7.07 22.O 9.47.8 0.5.24.4.3 2.4.37 5.5.04 6.7.09 24.0 9.46.22 0.5.29.4.35 2.4.42 5.5.08 6.7.3 3TW2849-. Ratings shown are net capacities which include a deduction for indoor fan motor heat 2. On the figure the mark j show the max. at standard conditions. On the figure the mark Q show rated capacity and rated coefficient of power input. However the max. capacity is not guaranteed, except at standard condition. 3. On the tables Q show rated capacity and rated coefficient of power input. 4. is based on each EWB and EDB * = correction for other dry bulb * = 0.02 x AFR (m 3 /min.) x ( BF) x (DB* EDB) Add * to. 5. Capacities are based on following conditions: Outdoor air : 85 % RH. however, the condition on nominal capacity is 7 CDB/6 CWB (heating) Corresponding refrigerant piping length : 7.5 m Level difference : 0 m 6. Coefficient of power input is the percentage when the rated valve is defined as.00. 7. The value contains less than 5% error acording to indoor unit type. 8. Heating capacity include the drop of frost formation. 9. Air flow rate and BF are tabulated below. AFR (BF) FBQ40 35 (0.4) SYMBOLS AFR: Air flow rate (m 3 /min) BF: Bypass factor EWB: Entering wet bulb temp. ( CWB) EDB: Entering dry bulb temp. ( CDB) : Total cooling/heating capacity : Sensible heating capacity PI: Power input (comp.+indoor+outdoor fan motor) : Coefficient of power input. Caution: and are shown by kw 0. Rated power input of each model is tabulated below. Outdoor Indoor Cooling Heating RZQS40C7 FBQ40B8 4.97kW 4.99kW Split Sky Air Outdoor Units 26
Outdoor Units R-40A RZQS7-40C7VB 6 Dimensional drawing & centre of gravity 6 - Dimensional drawing 6 RZQS7-00C Hole for anchor bolt 4-M2 Gas pipe connection J5.9 flare 2 Liquid pipe connection - J9.5 flare 3 Service port (in the unit) 4 Grounding terminal M5 (in switch box) 5 Refrigerant piping intake 6 Power supply wiring intake (knock out hole J34) 7 Control wiring intake (Knock out hole J27) 8 Drain outlet unit (mm) 3TW2544-A RZQS25-40C Hole for anchor bolt 4-M2 Gas pipe connection J5.9 flare 2 Liquid pipe connection - J9.5 flare 3 Service port (in the unit) 4 Grounding terminal M5 (in switch box) 5 Refrigerant piping intake 6 Power supply wiring intake (knock out hole J34) 7 Control wiring intake (Knock out hole J27) 8 Drain outlet 3TW26364-27 Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 6 Dimensional drawing & centre of gravity 6-2 Centre of gravity RZQS7-00C7VB 3 6 4TW30469-3 RZQS25-40C 4TW2969-4 Split Sky Air Outdoor Units 28
Outdoor Units R-40A RZQS7-40C7VB 7 Piping diagram RZQS7-40C 7 Electronic expansion valve Filter Filter Heat exchanger 4-way valve Heat exchanger Low pressure sensor High pressure switch Filter J9.5 C220T-0 J5.9 C220T-0 Compressor Service port 5/6 Accumulator Indoor unit Stop valve (with service port 5/6 flare) Outdoor unit Heating Cooling O Check valve L Flare connection M Screw connection N Flange connection Z Pinched pipe P Spinned pipe 3TW2965- RZQS7-40C (Twin) Heat exchanger Electronic expansion valve Filter Filter Heat exchanger Filter 4-way valve Indoor unit Low pressure sensor High pressure switch Heat exchanger Branch duct connection Option J9.5 Compressor Service port 5/6 J5.9 Accumulator Filter Outdoor unit Heating Cooling Indoor unit Stop valve (with service port 5/6 flare) Note:. The pipes between the branch and the indoor units should have the same size as the indoor connections. O Check valve L Flare connection M Screw connection N Flange connection Z Pinched pipe P Spinned pipe 3TW2965-2 29 Split Sky Air Outdoor Units
7 Piping diagram Outdoor Units R-40A RZQS7-40C7VB RZQS7-40C (Triple) Indoor unit 3 Heat exchanger Stop valve (with service port 5/6 flare) Filter Electronic expansion valve Filter Heat exchanger 7 Filter Heat exchanger Indoor unit 4-way valve J9.5 Low pressure sensor High pressure switch Filter J5.9 Heat exchanger Indoor unit Branch duct connection Compressor Service port 5/6 Option Accumulator Note:. The pipes between the branch and the indoor units should have the same size as the indoor connections. Outdoor unit Filter Heating Cooling O Check valve L Flare connection M Screw connection N Flange connection Z Pinched pipe P Spinned pipe 3TW2965-3 RZQS25-40C (Double twin) Heat exchanger Indoor unit Electronic expansion valve Filter Filter Filter Heat exchanger Heat exchanger Indoor unit J9.5 J5.9 4-way valve Filter Low pressure High pressure sensor switch Heat exchanger Indoor unit Branch duct connection Option J9.5 J5.9 Compressor Service port 5/6 Accumulator Filter Heat exchanger J9.5 Stop valve (with service port 5/6 flare) Outdoor unit Heating Cooling J5.9 Filter O Check valve L Flare connection M Screw connection N Flange connection Z Pinched pipe P Spinned pipe Note:. The pipes between the branch and the indoor units should have the same size as the indoor connections. 3TW2965-4 Split Sky Air Outdoor Units 30
8 Wiring diagram 8 - Wiring diagram Outdoor Units R-40A RZQS7-40C7VB RZQS7C7VB 8 AP A2P BS BS4 C 3 DS FU F6U HP 7P(A2P) HAP KR K0R KR LR MC MF PS R R2 RT R2T R3T R4T R5T R6T RC R0T SNPH SPH VR V2R,V3R VT XM YE YS ZC ZF 4F : Printed circuit board : Printed circuit board : Push button switch : Capacitor : Dip switch : Fuse (T 6.3A/250V) : Fuse (T 5.0A/250V) : Pilot lamp (service monitor-orange) Flashing lamp (service monitor-green) : Magnetic relay (YS) : Magnetic relay : Magnetic relay : Reactor : Motor (compressor) : Motor (fan) : Switching power supply : Resistor : Resistor : Thermistor (Air) : Thermistor (MC Discharge) : Thermistor (Suction) : Thermistor (Coil) : Thermistor (Coil middle) : Thermistor (Liquid) : Signal receiver circuit : Thermistor (fin) : Pressure sensor(high) : Pressure switch (High) : Signal transmission circuit : Power module : Diode bridge : IGBT : Terminal block : Electronic expansion valve : Solenoid valve (4 way valve) : Noise filter (ferrite core) : Noise filter Power supply 220-240V 50Hz Position of compressor terminal Indoor unit (Note 3) (Back) (Front) El, compo, box (Note 2) Notes:. : Field wiring : Terminal block : Connector : Relay connector : Terminal 2. Refer to the optional manual, for connection wiring to X6A. 3. The positions of the selector switches (DS) indicate factory setting. Refer to the service manual in detail. 4. Colours: WHT: White / RED: Red / BLU: Blue / GRY: Gray / GRN: Green / YLW: Yellow / ORG: Orange / BLK: Black 3D058404C RZQS7-00C Indoor ON OFF Outdoor (Note 4) AP : Printed circuit board (Main) A2P : Printed circuit board (Inverter) BS BS4 : Push button switch C C3 : Capacitor DS : Dip switch FU : Fuse (T 6.3A / 250V) F6U : Fuse (T 3.5A / 250V) HP 7P (A2P) : Light emitting diode (service monitor orange) HAP (AP) : Light emitting diode (service monitor green) KR : Magnetic relay (YS) K0R : Magnetic relay KR : Magnetic relay LR : Reactor MC : Motor (compressor) MF : Motor (fan) PS : Switching power supply QDI : Field earth leakage breaker (30mA) R : Resistor R2 : Resistor RT : Thermistor (air) R2T : Thermistor (discharge) R3T : Thermistor (Suction) R4T : Thermistor (Heat exchanger) R5T : Thermistor (Thermistor (heat exchanger middle)) R6T : Thermistor (liquid) R0T : Thermistor (fin) RC : Signal receiver circuit SNPH : Pressure sensor SPH : Pressure switch (High) : Signal transmission circuit VR : Power module V2R,V3R : Diode module VT : IGBT XM : Terminal strip (Power supply) YE : Electronic expansion valve YS : Solenoid valve (4 way valve) ZC : Noise filter (ferrite core) ZF Z4F : Noise filter Position of compressor terminal El. comp. Assy Position of elements (Back) (Front) Notes:. This wiring diagram only applies to the outdoor unit 2. L: Live, N: Neutral, : Field wiring 3. : Terminal strip : Connector : Connection : Protective earth (screw) : Relay connector : Noiseless earth : Terminal 4. Refer to the option manual, for connecting wiring to x6a. 5. Refer to the Wiring diagram sticker (on back of front plate) on how to use BS BS4 and DS switch. 6. Do not operate the unit by short-circuiting protection device SPH 7. Colours: WHT: White / RED: Red / BLU: Blue / ORG: Orange BRN: Brown / GRN: Green / YLW: Yellow 8. Confirm the method of setting the selector switches (DS) by service manual. Factory setting of all switches: OFF. 2TW30466-B 3 Split Sky Air Outdoor Units
Outdoor Units R-40A RZQS7-40C7VB 9 Sound data 9 - Sound pressure spectrum RZQS7C7VB - Cooling RZQS7C7VB - Heating 3 Sound pressure level (db) Sound pressure level (db) 9 3TW30467- Octave band center frequency (Hz) Data is valid at free field condition 2 db(a) = A-weighted sound pressure level (A-scale according to IEC) 3 Reference acoustic pressure 0dB = 20μPa 4 Data is valid at nominal operation condition 3TW30467-2 Octave band center frequency (Hz) Data is valid at free field condition 2 db(a) = A-weighted sound pressure level (A-scale according to IEC) 3 Reference acoustic pressure 0dB = 20μPa 4 Data is valid at nominal operation condition Measuring location (discharge side) Measuring location (discharge side) RZQS00C7VB - Cooling RZQS00C7VB - Heating Sound pressure level (db) Sound pressure level (db) 3TW30477- Octave band center frequency (Hz) Data is valid at free field condition 2 db(a) = A-weighted sound pressure level (A-scale according to IEC) 3 Reference acoustic pressure 0dB = 20μPa 4 Data is valid at nominal operation condition 3TW30477-2 Octave band center frequency (Hz) Data is valid at free field condition 2 db(a) = A-weighted sound pressure level (A-scale according to IEC) 3 Reference acoustic pressure 0dB = 20μPa 4 Data is valid at nominal operation condition Measuring location (discharge side) Measuring location (discharge side) Split Sky Air Outdoor Units 32