FLOOR AND CEILIN TYPE AIR CONDITIONERS Revision B: The fan guard for MUCFH-A 60VBhas been changed. Please void OB8 REVSED EDITION-A. E OUTDOOR UNIT SERVICE MANUAL HFC utilized R40A. OB8 REVISED EDITION-B Models MUCFH-A5VB - MUCFH-A50VB - E E MUCFH-A60VB - E Indoor unit service manual MCFH-A VB Series (OB80) CONTENTS MUCFH-A50VB. TECHNICAL CHANES. PART NAMES AND FUNCTIONS 5. SPECIFICATION 6 4. NOISE CRITERIA CURVES 7 5. OUTLINES AND DIMENSIONS 8 6. WIRIN DIARAM 0 7. REFRIERANT SYSTEM DIARAM 8. PERFORMANCE CURVES 9. ACTUATOR CONTROL 4 0. SERVICE FUNCTIONS 4. TROUBLESHOOTIN 5. DISASSEMBLY INSTRUCTIONS 5. PARTS LIST 4 4. RoHS PARTS LIST 48 NOTE: This service manual describes technical data of the outdoor units. RoHS compliant products have <> mark on the spec name plate. For servicing of RoHS compliant products, refer to the RoHS PARTS LIST (RoHS compliant).
Revision A : RoHS PARTS LIST has been added. Revision B : The fan guard for MUCFH-A 60VB- E has been changed. TECHNICAL CHANES MUH-AYV - E MUCFH-A5VB -. Indication of capacity has been changed. (BTU base kw) MUCFH-A8WV - E MUCFH-A50VB -. Indication of capacity has been changed. (BTU base kw) MUCFH-A4WV - E MUCFH-A60VB -. Indication of capacity has been changed. (BTU base kw) E E E INFORMATION FOR THE AIR CONDITIONER WITH R40A REFRIERANT This room air conditioner adopts HFC refrigerant (R40A) which never destroys the ozone layer. Pay particular attention to the following points, though the basic installation procedure is same as that for R conditioners. As R40A has working pressure approximate.6 times as high as that of R, some special tools and piping parts/ materials are required. Refer to the table below. Take sufficient care not to allow water and other contaminations to enter the R40A refrigerant during storage and installation, since it is more susceptible to contaminations than R. For refrigerant piping, use clean, pressure-proof parts/materials specifically designed for R40A. (Refer to. Refrigerant piping.) 4 Composition change may occur in R40A since it is a mixed refrigerant. When charging, charge liquid refrigerant to prevent composition change. Refrigeration Refrigerant oil New refrigerant Refrigerant R40A Composition (Ratio) HFC-: HFC-5 (50%:50%) Refrigerant handling Pseudo-azeotropic refrigerant Chlorine t included Safety group (ASHRAE) A/A Molecular weight 7.6 Boiling point (:) -5.4 Steam pressure [5:](Mpa).557 Saturated steam density [5:](Kg/K) 64 Combustibility n combustible ODP w 0 WP w 70 Refrigerant charge method From liquid phase in cylinder Additional charge on leakage Possible Kind Incompatible oil Color n Smell n w :Ozone Destruction Parameter : based on CFC- w :lobal Warmth Parameter : based on CO Previous refrigerant R R (00%) Single refrigerant Included A 86.5-40.8 0.94 44.4 n combustible 0.055 700 as phase Possible Compatible oil Light yellow n
Compressor New Specification Current Specification The incompatible refrigeration oil easily separates from refrigerant and is in the upper layer inside the suction muffler. Raising position of the oil back hole enables to back the Since refrigerant and refrigerating oil are compatible each, refrigeration oil goes back to the compressor through the lower position oil back hole. refrigeration oil of the upper layer to flow back to the compressor. Suction muffler Suction muffler Compressor Oil back hole Refrigeration oil Compressor Oil back hole Refrigerant Refrigeration oil /Refrigerant NOTE : The unit of pressure has been changed to MPa on the international system of units(si unit system). The conversion factor is: (MPa [auge]) =0.(kgf/f [auge]) Conversion chart of refrigerant temperature and pressure (MPa [auge]) 4.0.5 R40A Saturated liquid pressure.0.5.0.5.0 0.5 R NOTE : The unit of pressure has been changed to MPa on the international system of units(si unit system). The conversion factor is: (MPa [auge]) =0.(kgf/f [auge]) 0.0-0.5-0 -0-0 0 0 0 0 40 50 60 (:).Tools dedicated for the air conditioner with R40A refrigerant The following tools are required for R40A refrigerant. Some R tools can be substituted for R40A tools. The diameter of the service port on the stop valve in outdoor unit has been changed to prevent any other refrigerant being charged into the unit. Cap size has been changed from 7/6 UNF with 0 threads to / UNF with 0 threads. R40A tools Can R tools be used? Description R40A has high pressures beyond the measurement range of existing auge manifold gauges. Port diameters have been changed to prevent any other refrigerant from being charged into the unit. Charge hose as leak detector Hose material and cap size have been changed to improve the pressure resistance. Dedicated for HFC refrigerant. Torque wrench 6.5 mm and 9.5 mm.7 mm and 5.88 mm Flare tool Flare gauge New Clamp bar hole has been enlarged to reinforce the spring strength in the tool. Provided for flaring work (to be used with R flare tool). Vacuum pump Provided to prevent the back flow of oil. This adapter enables you to use New adapter vacuum pumps. Electronic scale for It is difficult to measure R40A with a charging cylinder because the New refrigerant charging refrigerant bubbles due to high pressure and high-speed vaporization : t Substitutable for R40A : Substitutable for R40A
.Refrigerant piping Specifications Use the refrigerant pipes that meet the following specifications. Pipe Outside diameter mm Wall thickness Insulation material For liquid 6.5 9.5 0.8 mm 0.8 mm Heat resisting foam plastic For gas.7 5.88 0.8 mm.0 mm Specific gravity 0.045 Thickness 8 mm Use a copper pipe or a copper-alloy seamless pipe with a thickness of 0.8 mm (6.5, 9.5,.7),.0 mm (5.88). Never use any pipe with a thickness less than 0.8 mm (6.5, 9.5,.7),.0 mm (5.88), as the pressure resistance is insufficient. Flaring work and flare nut Flaring work for R40A pipe differs from that for R pipe. For details of flaring work, refer to Installation manual FLARIN WORK. Pipe diameter mm 6.5 9.5.7 5.88 Dimension of flare nut R40A 7 6 9 R 7 4 7.Refrigerant oil Apply the special refrigeration oil (accessories: packed with indoor unit) to the flare and the union seat surfaces. 4.Air purge Do not discharge the refrigerant into the atmosphere. Take care not to discharge refrigerant into the atmosphere during installation, reinstallation, or repairs to the refrigerant circuit. Use the vacuum pump for air purging for the purpose of environmental protection. 5.Additional charge For additional charging, charge the refrigerant from liquid phase of the gas cylinder. If the refrigerant is charged from the gas phase, composition change may occur in the refrigerant inside the cylinder and the outdoor unit. In this case, ability of the refrigeration cycle decreases or normal operation can be impossible. However, charging the liquid refrigerant all at once may cause the compressor to be locked. Thus, charge the refrigerant slowly. Union Stop valve Indoor unit Refrigerant gas cylinder operating valve Liquid pipe as pipe Service port Outdoor unit auge manifold valve (for R40A) Charge hose (for R40A) Refrigerant gas cylinder for R40A with siphon Refrigerant (liquid) Electronic scale for refrigerant charging 4
PART NAMES AND FUNCTIONS MUCFH-A5VB MUCFH-A50VB Air inlet (back and side) Piping Drain hose Air inlet (back and side) Piping Drain hose Air outlet Air outlet Drain outlet Drain outlet MUCFH-A60VB Air inlet (back and side) Piping Drain hose Air outlet Drain outlet ACCESSORIES Item Drain socket Drain cap [ Drain cap [6 MUCFH-A5VB Q'ty MUCFH-A50VB MUCFH-A60VB 5
SPECIFICATION Outdoor model Function Power supply Capacity kw Dehumidification r/h Air flow(high) K /h Power outlet A Running current A Power input W Power factor % Starting current A Compressor motor current A Fan motor current A Coefficient of performance(c.o.p) Model Output W Winding " resistance(at 0:) Model Winding " resistance(at 0:) Dimensions WOHOD mm Weight kg Sound level(high) db Fan speed(high) rpm Fan speed regulator Refrigerant filling kg capacity(r40a) Refrigeration oil (Model) cc Thermistor RT6(at 0:) k" Capacity Electrical data Compressor Fan motor Special remarks MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB Cooling Heating Cooling Heating Single phase 0V, 50Hz Single phase 0V, 50Hz.5.7 6.0 6.8.5. 4.85,094,70 0 4. 954 98 9 4.54.9 0..0.6 RN5VHSHT 900 C-R.79 C-S.6 RA6V-JB WHT-BLK 5. BLK-RED 06.9 780o540o55 40 49 85.00 60 (NEO).8 Cooling Heating Single phase 0V, 50Hz 4.8 5.0.4,96 5 8.0,70 8.8,80 94 7 7.6 7.99 0.9.65.65 RN96VHSHT,00 C-R.80 C-S.00 RA6V50-PA WHT-BLK 79.5 BLK-RED 8.0 850o605o90 47 5 88.85 50 (NEO).8 NOTE: Test conditions are based on ISO 55. Cooling : Indoor DB7 C WB9 C Heating : Indoor DB0 C WB 5.5 C Outdoor DB5 C WB(4 C) Outdoor DB 7 C WB 6 C Indoor-Outdoor piping length : 5m 0.5,70,760 5.7,640 98 74 9.9. 0.58.45.50 NN9VBAHT,900 C-R 0.80 C-S.64 RA6V85-DA WHT-BLK 68.8 BLK-RED 9. 840o850o0 74 5 70.0,00 (NEO).8 6
4 NOISE CRITERIA CURVES MUCFH-A5VB FUNCTION SPL(dB(A)) LINE COOLIN 49 HEATIN Test conditions, Cooling : Dry-bulb temperature 5: Wet-bulb temperature (4:) Heating : Dry-bulb temperature 7: Wet-bulb temperature 6: 90 MUCFH-A50VB FUNCTION COOLIN HEATIN SPL(dB(A)) Test conditions, Cooling : Dry-bulb temperature 5: Wet-bulb temperature (4:) Heating : Dry-bulb temperature 7: Wet-bulb temperature 6: 90 5 LINE OCTAVE BAND SOUND PRESSURE LEVEL, db re 0.000 MICRO BAR 80 70 60 50 40 0 0 0 APPROXIMATE TERESHOLD OF HEARIN FOR CONTINUOUS NOISE 6 5 50 500 000 000 4000 8000 NC-70 NC-60 NC-50 NC-40 NC-0 NC-0 OCTAVE BAND SOUND PRESSURE LEVEL, db re 0.000 MICRO BAR 80 70 60 50 40 0 0 0 APPROXIMATE THRESHOLD OF HEARIN FOR CONTINUOUS NOISE 6 5 50 500 000 000 4000 8000 NC-70 NC-60 NC-50 NC-40 NC-0 NC-0 BAND CENTER FREQUENCIES, Hz BAND CENTER FREQUENCIES, Hz MUCFH-A60VB FUNCTION COOLIN HEATIN SPL(dB(A)) Test conditions, Cooling : Dry-bulb temperature 5: Wet-bulb temperature (4:) Heating : Dry-bulb temperature 7: Wet-bulb temperature 6: 90 5 LINE OCTAVE BAND SOUND PRESSURE LEVEL, db re 0.000 MICRO BAR 80 70 60 50 40 0 0 0 APPROXIMATE THRESHOLD OF HEARIN FOR CONTINUOUS NOISE 6 5 50 500 000 000 4000 8000 NC-70 NC-60 NC-50 NC-40 NC-0 NC-0 MICROPHONE OUTDOORUNIT m BAND CENTER FREQUENCIES, Hz 7
5 OUTLINES AND DIMENSIONS MUCFH-A5VB 09 Air in 0 55 85 0 REQUIRED SPACE 00mm or more 00mm or more 00mm or more Unit: mm Air in Drainage holes [ 47 0 Air out 5 Service panel 400mm or more 50mm or more 540 5- Liquid refrigerant pipe joint Refrigerant pipe (flared) [6.5 0 60 40 500 780 74 55 90 04 4- as refrigerant pipe joint Refrigerant pipe (flared) [.7 MUCFH-A50VB Drainage hole [6. 5 55 50 Air in 0 REQUIRED SPACE 00mm or more 00mm or more 00mm or more 48 Air in 90 0 45 Drainage holes [ Air out 0 500mm or more Service panel 50mm or more Liquid refrigerant pipe joint Refregerant pipe (flared) [6.5 605 90 50 5-0- 0 9 500 850 8 57 74 00 6 as refregerant pipe joint Refregerant pipe (flared) [.7 8
MUCFH-A60VB 5 4 66 55 99 40 REQUIRED SPACE 00mm or more Open as a rule 500mm or more if the front and both sides are open Unit: mm 00mm or more 00mm or more if there are obstacles to both sides 850 40 0 60 500 840 80 Open as a rule 500mm or more if the back, both sides and top are open 50mm or more Service panel Liquid refrigerant pipe joint Refrigerant pipe (flared) [6.5 0-5- 55 90 98 as refrigerant pipe joint Refrigerant pipe (flared) [5.88 9
6 WIRIN DIARAM MUCFH-A5VB TO INDOOR UNIT CONNECTIN V CIRCUIT BREAKER POWER SUPPLY ~/N 0V 50Hz TB N TB L PE N RN/YLW BRN BLU RED BLK BRN DSAR BLU S4 RT6 CN70 F6 CN66 CN7 CN7 WHT SR6 BLK RED T6 C65 NR6 SR6 TAB0 5C 4 DEICER P.C.BOARD WHT C C RED MC S R BLK MF SYMBOL NAME SYMBOL NAME SYMBOL NAME C COMPRESSOR CAPACITOR OUTDOOR FAN MOTOR T6 TRANSFORMER MF C65 OUTDOOR FAN CAPACITOR (INNER FUSE) TB,TB TERMINAL BLOCK DSAR F6 SURE ABSORBER FUSE(A) NR6 RT6 VARISTOR DEFROST THERMISTOR S4 5C R.V. COIL COMPRESSOR CONTACTOR MC COMPRESSOR(INNER PROTECTOR) SR6,SR6 SOLID STATE RELAY NOTE:. About the indoor side electric wiring refer to the indoor unit electric wiring diagram for servicing.. Use copper conductors only. (For field wiring). Symbols below indicate. /: Terminal block, : Connector MUCFH-A50VB POWER SUPPLY ~ /N 0V 50Hz TB TO INDOOR UNIT N CONNECTIN V CIRCUIT BREAKER PE TB L N RN/YLW RED BLK BRN BRN BLU DSAR BLU RT6 CN70 F6 TAB0 CN66 4 T6 5C S4 CN7 SR6 NR6 SR6 C65 DEICER P.C.BOARD C C WHT RED MC S R BLK RED ORN MF WHT BLK 4 CN7 WHT BLK RED SYMBOL C C65 DSAR F6 MC NAME COMPRESSOR CAPACITOR OUTDOOR FAN CAPACITOR SURE ABSORBER SYMBOL MF NR6 RT6 NAME OUTDOOR FAN MOTOR (INNER PROTECTOR) VARISTOR DEFROST THERMISTOR SYMBOL TB,TB S4 5C NAME TERMINAL BLOCK R.V. COIL COMPRESSOR CONTACTOR FUSE (A) SR6,SR6 SOLID STATE RELAY COMPRESOR (INNER PROTECTOR) T6 TRANSFORMER NOTES:.About the indoor side electric wiring refer to the indoor unit electric wiring diagram for servicing..use copper conductors only. (For field wiring).symbols below indicate. : Terminal block : Connector 0
MUCFH-A60VB CIRCUIT BREAKER TB L POWER SUPPLY ~/N 0V 50Hz TO INDOOR UNIT CONNECTIN V N TB N P E RN/YLW BRN DSAR BLU BLU BRN BLU BRN RT6 CN66 X6 X5 DEICER P.C.BOARD 5C 4 SR6 A 5C A BLK WHT BLK WHT RED ORN C CN7 CN7 X6 X5 COM NO TAB5 CN70 7 T6 5 NR6 F6 WHT 4 MF ORN RED C COM RED NO BLK S C MC R BLU S4 RED BLU SYMBOL C C DSAR F6 MC MF NR6 RT6 SR6 TB TB T6 X5 X6 S4 5C NAME COMPRESSOR CAPACITOR OUTDOOR FAN CAPACITOR SURE ABSORBER FUSE (.5A) COMPRESSOR (INNER PROTECTOR) OUTDOOR FAN MOTOR (INNER PROTECTOR) VARISTOR DEFROST THERMISTOR SOLID STATE RELAY TERMINAL BLOCK TERMINAL BLOCK TRANSFORMER CONTACTOR R. V. COIL RELAY R. V. COIL COMPRESSOR CONTACTOR NOTES:.Use copper conductors only (For field wiring)..since the indoor and outdoor unit connecting wires have polarity, connect them according to the numbers (,N)..Symbols below indicate. : Terminal block, : Connector 7 REFRIERANT SYSTEM DIARAM MUCFH-A5VB Refrigerant pipe [.7 (with heat insulator) 4-way valve Unit:mm Flared connection Stop valve (with service port) Muffler Defrost thermistor RT6 Outdoor heat exchanger Capillary tube [.0x[.4x500(pcs) Compressor Capillary tube [.0x[.6x600 Flared connection Strainer #00 Capillary tube [.0x[.6x050 R.V. coil heating ON cooling OFF Refrigerant pipe [6.5 (with heat insulator) Stop valve Check valve Refrigerant flow in cooling Refrigerant flow in heating
MUCFH-A50VB Refrigerant pipe [.7 (with heat insulator) 4- way valve Flared connection Stop valve (with service port) Oil separator #00 Defrost thermistor RT6 Outdoor heat exchanger Capillary tube [.5o[0.6o,000 Compressor Flared connection Refrigerant pipe[6.5 (with heat insulator) Stop valve Receiver Strainer #00 Capillary tube [.0o[.6o650 Check valve Capillary tube [.0o[.6o500 Capillary tube [.0o[.6o750 ( pcs) R.V. coil Heating ON Cooling OFF Refrigerant flow in cooling Refrigerant flow in heating MUCFH-A60VB Refrigerant pipe [5.88 (with heat insulator) 4- way valve Flared connection Stop valve (with service port) Muffler Muffler #00 Outdoor heat exchanger Compressor Defrost thermistor RT6 Flared connection Capillary tube [.0X[.0X400 Receiver Refrigerant pipe [6.5 (with heat insulator) Stop valve Strainer #00 Capillary tube [.0X[.0X800 R.V. coil Heating ON Check valve Cooling OFF Refrigerant flow in cooling Refrigerant flow in heating
MAX. REFRIERANT PIPIN LENTH & MAX. HEIHT DIFFERENCE Model MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB Refrigerant piping MAX. length : m A 5 as {.7 {5.88 Piping size O.D. : mm Liquid {6.5 wit does not matter which unit is higher. W Max. Height difference 0m A: Refrigerant piping Max.length 5m ADDITIONAL REFRIERANT CHARE (R40A : g) If pipe length exceeds 7m, additional refrigerant (R40A) charge is required. Models MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB Outdoor unit: precharged,000,850,00 Calculation : g = 0g/m (Refrigerant piping length (m)-7) 7m 0 Refrigerant piping length (one way) 0m 5m 0m 60 60 60 5m 60 8 PERFORMANCE CURVES MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB The standard data contained in these specifications apply only to the operation of the air conditioner under normal condition. Operating conditions vary according to the areas where these units are installed. The following information has been provided to clarify the operating characteristics of the air conditioner under the conditions indicated by the performance curve. () UARANTEED VOLTAE 98~64V, 50Hz () AIR FLOW Air flow should be set at MAX. () MAIN READINS COOLIN () Indoor intake air wet-bulb temperature : CWB () Indoor outlet air wet-bulb temperature : CWB () Outdoor intake air dry-bulb temperature : CDB (4) Total input : W HEATIN () Indoor intake air dry-bulb temperature : CDB () Indoor outlet air dry-bulb temperature : CDB () Outdoor intake air wet-bulb temperature : CWB (4) Total input : W Indoor air wet/dry-bulb temperature difference on the left side of the chart on next page shows the difference between the indoor intake air wet/dry-bulb temperature and the indoor outlet air wet/dry-bulb temperature for your reference at service.
How to measure the indoor air wet-bulb/dry-bulb temperature difference. Attach at least sets of wet and dry-bulb thermometers to the indoor air inlet as shown in the figure, and at least sets of wet and dry bulb thermometers to the indoor air outlet. The thermometers must be attached to the position where air speed is high.. Attach at least sets of wet and dry-bulb thermometers to the outdoor air inlet. Cover the thermometers to prevent direct rays of the sun.. Check that the air filter is cleaned. 4. Open windows and doors of the room. 5. Press the EMERENCY OPERATION switch once(twice) to start the EMERENCY COOL(HEAT) MODE. 6. When system stabilizes after more than 5 minutes, measure temperature and take an average temperature. 7. 0 minutes later, measure temperature again and check that the temperature does not change. Air out INDOOR UNIT Wet and dry-bulb thermometers OUTDOOR UNIT Air in FRONT VIEW Wet and dry-bulb thermometers BACK VIEW 8.7 8.0 7. 6.6 5.9 5.. 0. 9. 8. 7.5 6.6 4.7.4. 0.9 9.7 8.5 8.6 7. 5.7 4..9.5 0.0 8.6.4.6 9.8 8.0 6. 4.4.6 0.8.8 9. 6.9 4.4.0 9.5 7. 4.7 MCFH-A5VB MUCFH-A5VB MCFH-A50VB MUCFH-A50VB MCFH-A60VB MUCFH-A60VB MCFH-A5VB MUCFH-A5VB MCFH-A50VB MUCFH-A50VB MCFH-A60VB MUCFH-A60VB OUTDOOR LOW PRESSURE AND OUTDOOR UNIT CURRENT COOL operation Both indoor and outdoor units are under the same temperature/humidity condition. Dry Bulb temperature ( C) 0 5 0 Relative humidity (%) 50 60 70 4
Air flow should be set at MAX. The unit of pressure has been changed to MPa on the international system of units(si unit system). The conversion factor is : (MPa [auge]) =0.(kgf/f [auge]) (kgf/f[auge])(mpa[auge]) Outdoor low pressure... 0.0 9 0.9 8 0.8 MUCFH-A5VB 0V Outdoor unit current (A) 6 5 4 0V 7 0.7 5 8 0 5 0 50 60 70 Ambient temperature( C) Ambient humidity(%) 5(:) (%) 5 8 0 5 0 50 60 70 Ambient temperature( C) Ambient humidity(%) 5(:) (%) (kgf/f [auge])(mpa [auge]). MUCFH-A50VB Outdoor low pressure 0 9 8 7..0 0.9 0.8 0.7 0V Outdoor unit current (A) 0 9 8 7 6 0V 6 0.6 5 8 0 5 0 5(:) 50 60 70 (%) Ambient temperature (:) Ambient humidity (%) 5 5 8 0 5 0 5(:) 50 60 70 (%) Ambient temperature (:) Ambient humidity (%) (kgf/f [auge])(mpa [auge]). MUCFH-A60VB Outdoor low pressure 0 9 8 7 6.0 0.9 0.8 0.7 0.6 0V Outdoor unit current (A) 0 9 8 7 0V 5 0.5 5 8 0 5 0 5(:) 50 60 70 (%) Ambient temperature (:) Ambient humidity (%) 6 5 8 0 5 0 5(:) 50 60 70 (%) Ambient temperature (:) Ambient humidity (%) 5
HEAT operation Condition Indoor : Dry bulb temerature 0.0: Outdoor : Dry bulb temerature 7,5,0: Wet bulb temerature 4.5: Wet bulb temerature 6,,4.5: MUCFH-A5VB Outdoor unit current (A) 6 5 4 0V MUCFH-A50VB Outdoor unit current (A) 0V 0 9 5 7 0 5 0 50 60 70 Ambient temperature( C) Ambient humidity(%) 5(:) (%) 8 5 7 0 5 0 5(:) 50 60 70 (%) Ambient temperature (:) Ambient humidity (%) MUCFH-A60VB 6 Outdoor unit current (A) 5 4 0V 5 7 0 5 0 5(:) 50 60 70 (%) Ambient temperature (:) Ambient humidity (%) 6
PERFORMANCE DATA COOL operation (0V) MCFH-A5VB : MUCFH-A5VB CAPACITY :.5(kW) SHF :0.70 INPUT :60(W) OUTDOOR DB(:) INDOOR INDOOR 5 7 0 DB(:) WB(:) Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT 8 4..4 0.5 98.94.05 0.5 974.78.97 0.5 0.64.89 0.5 067 0 4.9.7 0.40 974 4..65 0.40 0.99.60 0.40 056.85.54 0.40 0 8 4..0 0.56 98.94. 0.56 974.78. 0.56 0.64.04 0.56 067 0 4.9.89 0.44 974 4..8 0.44 0.99.76 0.44 056.85.69 0.44 0 4.46.4 0. 009 4..8 0. 07 4.0.4 0. 0 4.0.9 0. 48 8 4..47 0.60 98.94.6 0.60 974.78.7 0.60 0.64.8 0.60 067 0 4.9.06 0.48 974 4..97 0.48 0.99.9 0.48 056.85.85 0.48 0 4.46.6 0.6 009 4..55 0.6 07 4.0.5 0.6 0 4.0.45 0.6 48 4 8 4..6 0.64 98.94.5 0.64 974.78.4 0.64 0.64. 0.64 067 4 0 4.9. 0.5 974 4..4 0.5 0.99.07 0.5 056.85.00 0.5 0 4 4.46.79 0.40 009 4..7 0.40 07 4.0.68 0.40 0 4.0.6 0.40 48 4 4 4.69. 0.8 056 4.5.6 0.8 4 4.4. 0.8 48 4.7.0 0.8 06 5 8 4..80 0.68 98.94.68 0.68 974.78.57 0.68 0.64.48 0.68 067 5 0 4.9.40 0.56 974 4..0 0.56 0.99. 0.56 056.85.6 0.56 0 5 4.46.96 0.44 009 4..89 0.44 07 4.0.85 0.44 0 4.0.77 0.44 48 5 4 4.69.50 0. 056 4.5.44 0. 4 4.4.4 0. 48 4.7.7 0. 06 6 8 4..96 0.7 98.94.84 0.7 974.78.7 0.7 0.64.6 0.7 067 6 0 4.9.57 0.60 974 4..47 0.60 0.99.9 0.60 056.85. 0.60 0 6 4.46.4 0.48 009 4..07 0.48 07 4.0.0 0.48 0 4.0.9 0.48 48 6 4 4.69.69 0.6 056 4.5.6 0.6 4 4.4.59 0.6 48 4.7.54 0.6 06 6 6 4.8.6 0.4 4 4.69. 0.4 7 4.6. 0.4 06 4.48.08 0.4 4 7 8 4.. 0.76 98.94.99 0.76 974.78.87 0.76 0.64.77 0.76 067 7 0 4.9.74 0.64 974 4..6 0.64 0.99.55 0.64 056.85.46 0.64 0 7 4.46. 0.5 009 4..4 0.5 07 4.0.8 0.5 0 4.0.09 0.5 48 7 4 4.69.88 0.40 056 4.5.8 0.40 4 4.4.76 0.40 48 4.7.7 0.40 06 7 6 4.8.5 0.8 4 4.69. 0.8 7 4.6.9 0.8 06 4.48.5 0.8 4 8 8 4..9 0.80 98.94.5 0.80 974.78.0 0.80 0.64.9 0.80 067 8 0 4.9.9 0.68 974 4..80 0.68 0.99.7 0.68 056.85.6 0.68 0 8 4.46.50 0.56 009 4..4 0.56 07 4.0.5 0.56 0 4.0.5 0.56 48 8 4 4.69.06 0.44 056 4.5.99 0.44 4 4.4.94 0.44 48 4.7.88 0.44 06 8 6 4.8.55 0. 4 4.69.50 0. 7 4.6.48 0. 06 4.48.4 0. 4 9 8 4..45 0.84 98.94. 0.84 974.78.8 0.84 0.64.06 0.84 067 9 0 4.9.09 0.7 974 4..96 0.7 0.99.87 0.7 056.85.77 0.7 0 9 4.46.68 0.60 009 4..58 0.60 07 4.0.5 0.60 0 4.0.4 0.60 48 9 4 4.69.5 0.48 056 4.5.7 0.48 4 4.4. 0.48 48 4.7.05 0.48 06 9 6 4.8.74 0.6 4 4.69.69 0.6 7 4.6.66 0.6 06 4.48.6 0.6 4 0 8 4..6 0.88 98.94.47 0.88 974.78. 0.88 0.64.0 0.88 067 0 0 4.9.6 0.76 974 4.. 0.76 0.99.0 0.76 056.85.9 0.76 0 0 4.46.86 0.64 009 4..76 0.64 07 4.0.69 0.64 0 4.0.58 0.64 48 0 4 4.69.44 0.5 056 4.5.5 0.5 4 4.4.9 0.5 48 4.7. 0.5 06 0 6 4.8.9 0.40 4 4.69.88 0.40 7 4.6.85 0.40 06 4.48.79 0.40 4 8 4..78 0.9 98.94.6 0.9 974.78.48 0.9 0.64.5 0.9 067 0 4.9.4 0.80 974 4..9 0.80 0.99.9 0.80 056.85.08 0.80 0 4.46.0 0.68 009 4..9 0.68 07 4.0.86 0.68 0 4.0.74 0.68 48 4 4.69.6 0.56 056 4.5.5 0.56 4 4.4.47 0.56 48 4.7.9 0.56 06 6 4.8. 0.44 4 4.69.06 0.44 7 4.6.0 0.44 06 4.48.97 0.44 4 8 4..95 0.96 98.94.78 0.96 974.78.6 0.96 0.64.49 0.96 067 0 4.9.60 0.84 974 4..45 0.84 0.99.5 0.84 056.85. 0.84 0 4.46. 0.7 009 4..0 0.7 07 4.0.0 0.7 0 4.0.90 0.7 48 4 4.69.8 0.60 056 4.5.7 0.60 4 4.4.65 0.60 48 4.7.56 0.60 06 6 4.8. 0.48 4 4.69.5 0.48 7 4.6. 0.48 06 4.48.5 0.48 4 NOTE Q :Total capacity (kw) SHF :Sensible heat factor DB :Dry-bulb temperature SHC :Sensible heat capacity (kw) INPUT :Total power input (W) WB :Wet-bulb temperature 7
PERFORMANCE DATA COOL operation (0V) MCFH-A5VB : MUCFH-A5VB CAPACITY :.5(kW) SHF :0.70 INPUT :60(W) OUTDOOR DB(:) INDOOR INDOOR 5 40 4 DB(:) WB(:) Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT 8.4.78 0.5 7.5.64 0.5 06.0.57 0.5 0 0.6.44 0.40 8.6.4 0.40 4.4.0 0.40 76 8.4.9 0.56 7.5.76 0.56 06.0.70 0.56 0 0.6.59 0.44 8.6.48 0.44 4.4.4 0.44 76.8. 0. 0.57.4 0. 99.45.0 0. 8.4.06 0.60 7.5.89 0.60 06.0.8 0.60 0 0.6.7 0.48 8.6.6 0.48 4.4.55 0.48 76.8.7 0.6 0.57.9 0.6 99.45.4 0.6 4 8.4.0 0.64 7.5.0 0.64 06.0.94 0.64 0 4 0.6.87 0.5 8.6.75 0.5 4.4.68 0.5 76 4.8.5 0.40 0.57.4 0.40 99.45.8 0.40 4 4 4.0. 0.8 76.78.06 0.8 4.68.0 0.8 6 5 8.4. 0.68 7.5.4 0.68 06.0.06 0.68 0 5 0.6.0 0.56 8.6.88 0.56 4.4.8 0.56 76 5.8.68 0.44 0.57.57 0.44 99.45.5 0.44 5 4 4.0.9 0. 76.78. 0. 4.68.8 0. 6 6 8.4.47 0.7 7.5.7 0.7 06.0.8 0.7 0 6 0.6.6 0.60 8.6.0 0.60 4.4.94 0.60 76 6.8.8 0.48 0.57.7 0.48 99.45.65 0.48 6 4 4.0.45 0.6 76.78.6 0.6 4.68. 0.6 6 6 6 4.4.0 0.4.99 0.96 0.4 80.87 0.9 0.4 409 7 8.4.6 0.76 7.5.9 0.76 06.0.0 0.76 0 7 0.6. 0.64 8.6.5 0.64 4.4.07 0.64 76 7.8.98 0.5 0.57.86 0.5 99.45.79 0.5 7 4 4.0.6 0.40 76.78.5 0.40 4.68.47 0.40 6 7 6 4.4.9 0.8.99. 0.8 80.87.08 0.8 409 8 8.4.74 0.80 7.5.5 0.80 06.0.4 0.80 0 8 0.6.45 0.68 8.6.8 0.68 4.4.0 0.68 76 8.8.4 0.56 0.57.00 0.56 99.45.9 0.56 8 4 4.0.77 0.44 76.78.66 0.44 4.68.6 0.44 6 8 6 4.4.6 0..99.8 0. 80.87.4 0. 409 9 8.4.88 0.84 7.5.65 0.84 06.0.54 0.84 0 9 0.6.60 0.7 8.6.4 0.7 4.4. 0.7 76 9.8.9 0.60 0.57.4 0.60 99.45.07 0.60 9 4 4.0.9 0.48 76.78.8 0.48 4.68.76 0.48 6 9 6 4.4.5 0.6.99.44 0.6 80.87.9 0.6 409 0 8.4.0 0.88 7.5.77 0.88 06.0.66 0.88 0 0 0.6.74 0.76 8.6.55 0.76 4.4.46 0.76 76 0.8.44 0.64 0.57.8 0.64 99.45. 0.64 0 4 4.0.09 0.5 76.78.97 0.5 4.68.9 0.5 6 0 6 4.4.69 0.40.99.60 0.40 80.87.55 0.40 409 8.4.6 0.9 7.5.90 0.9 06.0.79 0.9 0 0.6.88 0.80 8.6.69 0.80 4.4.59 0.80 76.8.59 0.68 0.57.4 0.68 99.45.4 0.68 4 4.0.5 0.56 76.78. 0.56 4.68.06 0.56 6 6 4.4.86 0.44.99.76 0.44 80.87.70 0.44 409 8.4.9 0.96 7.5.0 0.96 06.0.9 0.96 0 0.6.0 0.84 8.6.8 0.84 4.4.7 0.84 76.8.75 0.7 0.57.57 0.7 99.45.48 0.7 4 4.0.4 0.60 76.78.7 0.60 4.68. 0.60 6 6 4.4.0 0.48.99.9 0.48 80.87.86 0.48 409 NOTE Q :Total capacity (kw) SHF :Sensible heat factor DB :Dry-bulb temperature SHC :Sensible heat capacity (kw) INPUT :Total power input (W) WB :Wet-bulb temperature 8
PERFORMANCE DATA COOL operation(0v) MCFH-A50VB : MUCFH-A50VB CAPACITY :4.8(kW) SHF :0.65 INPUT :80(W) OUTDOOR DB(:) INDOOR INDOOR 5 7 0 DB(:) WB(:) Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT 8 5.64.65 0.47 448 5.40.54 0.47 50 5.8.44 0.47 59 4.99.5 0.47 665 0 5.88.06 0.5 50 5.64.97 0.5 6 5.47.9 0.5 647 5.8.85 0.5 70 8 5.64.88 0.5 448 5.40.75 0.5 50 5.8.64 0.5 59 4.99.55 0.5 665 0 5.88.9 0.9 50 5.64.0 0.9 6 5.47. 0.9 647 5.8.06 0.9 70 6..65 0.7 575 5.90.59 0.7 674 5.76.56 0.7 70 5.5.49 0.7 79 8 5.64.0 0.55 448 5.40.97 0.55 50 5.8.85 0.55 59 4.99.75 0.55 665 0 5.88.5 0.4 50 5.64.4 0.4 6 5.47.5 0.4 647 5.8.7 0.4 70 6..90 0. 575 5.90.8 0. 674 5.76.79 0. 70 5.5.7 0. 79 4 8 5.64. 0.59 448 5.40.9 0.59 50 5.8.06 0.59 59 4.99.95 0.59 665 4 0 5.88.76 0.47 50 5.64.65 0.47 6 5.47.57 0.47 647 5.8.48 0.47 70 4 6..4 0.5 575 5.90.07 0.5 674 5.76.0 0.5 70 5.5.9 0.5 79 4 4 6.4.48 0. 647 6.9.4 0. 78 6.05.9 0. 79 5.86.5 0. 88 5 8 5.64.55 0.6 448 5.40.40 0.6 50 5.8.7 0.6 59 4.99.4 0.6 665 5 0 5.88.00 0.5 50 5.64.88 0.5 6 5.47.79 0.5 647 5.8.69 0.5 70 5 6..9 0.9 575 5.90.0 0.9 674 5.76.5 0.9 70 5.5.5 0.9 79 5 4 6.4.74 0.7 647 6.9.67 0.7 78 6.05.6 0.7 79 5.86.58 0.7 88 6 8 5.64.78 0.67 448 5.40.6 0.67 50 5.8.47 0.67 59 4.99.4 0.67 665 6 0 5.88. 0.55 50 5.64.0 0.55 6 5.47.0 0.55 647 5.8.90 0.55 70 6 6..6 0.4 575 5.90.54 0.4 674 5.76.48 0.4 70 5.5.7 0.4 79 6 4 6.4.99 0. 647 6.9.9 0. 78 6.05.87 0. 79 5.86.8 0. 88 6 6 6.6.6 0.9 78 6.4. 0.9 88 6.4.0 0.9 88 6.4.7 0.9 97 7 8 5.64 4.00 0.7 448 5.40.8 0.7 50 5.8.68 0.7 59 4.99.54 0.7 665 7 0 5.88.47 0.59 50 5.64. 0.59 6 5.47. 0.59 647 5.8. 0.59 70 7 6..88 0.47 575 5.90.77 0.47 674 5.76.7 0.47 70 5.5.59 0.47 79 7 4 6.4.5 0.5 647 6.9.7 0.5 78 6.05. 0.5 79 5.86.05 0.5 88 7 6 6.6.5 0. 78 6.4.48 0. 88 6.4.46 0. 88 6.4.4 0. 97 8 8 5.64 4. 0.75 448 5.40 4.05 0.75 50 5.8.89 0.75 59 4.99.74 0.75 665 8 0 5.88.70 0.6 50 5.64.55 0.6 6 5.47.45 0.6 647 5.8. 0.6 70 8 6.. 0.5 575 5.90.0 0.5 674 5.76.94 0.5 70 5.5.8 0.5 79 8 4 6.4.5 0.9 647 6.9.4 0.9 78 6.05.6 0.9 79 5.86.8 0.9 88 8 6 6.6.79 0.7 78 6.4.74 0.7 88 6.4.7 0.7 88 6.4.66 0.7 97 9 8 5.64 4.46 0.79 448 5.40 4.7 0.79 50 5.8 4.0 0.79 59 4.99.94 0.79 665 9 0 5.88.94 0.67 50 5.64.78 0.67 6 5.47.67 0.67 647 5.8.54 0.67 70 9 6..7 0.55 575 5.90.5 0.55 674 5.76.7 0.55 70 5.5.04 0.55 79 9 4 6.4.77 0.4 647 6.9.66 0.4 78 6.05.60 0.4 79 5.86.5 0.4 88 9 6 6.6.05 0. 78 6.4.99 0. 88 6.4.96 0. 88 6.4.90 0. 97 0 8 5.64 4.68 0.8 448 5.40 4.48 0.8 50 5.8 4.0 0.8 59 4.99 4.4 0.8 665 0 0 5.88 4.7 0.7 50 5.64 4.00 0.7 6 5.47.89 0.7 647 5.8.75 0.7 70 0 6..6 0.59 575 5.90.48 0.59 674 5.76.40 0.59 70 5.5.6 0.59 79 0 4 6.4.0 0.47 647 6.9.9 0.47 78 6.05.84 0.47 79 5.86.75 0.47 88 0 6 6.6. 0.5 78 6.4.5 0.5 88 6.4. 0.5 88 6.4.5 0.5 97 8 5.64 4.9 0.87 448 5.40 4.70 0.87 50 5.8 4.5 0.87 59 4.99 4.4 0.87 665 0 5.88 4.4 0.75 50 5.64 4. 0.75 6 5.47 4.0 0.75 647 5.8.96 0.75 70 6..86 0.6 575 5.90.7 0.6 674 5.76.6 0.6 70 5.5.48 0.6 79 4 6.4.8 0.5 647 6.9.6 0.5 78 6.05.08 0.5 79 5.86.99 0.5 88 6 6.6.58 0.9 78 6.4.5 0.9 88 6.4.47 0.9 88 6.4.40 0.9 97 8 5.64 5. 0.9 448 5.40 4.9 0.9 50 5.8 4.7 0.9 59 4.99 4.54 0.9 665 0 5.88 4.65 0.79 50 5.64 4.46 0.79 6 5.47 4. 0.79 647 5.8 4.7 0.79 70 6. 4.0 0.67 575 5.90.96 0.67 674 5.76.86 0.67 70 5.5.70 0.67 79 4 6.4.54 0.55 647 6.9.4 0.55 78 6.05. 0.55 79 5.86. 0.55 88 6 6.6.85 0.4 78 6.4.77 0.4 88 6.4.7 0.4 88 6.4.64 0.4 97 NOTE Q : Total capacity (kw) SHF : Sensible heat factor DB : Dry-bulb temperature SHC : Sensible heat capacity (kw) INPUT : Total power input (W) WB : Wet-bulb temperature 9
PERFORMANCE DATA COOL operation(0v) MCFH-A50VB : MUCFH-A50VB CAPACITY :4.8(kW) SHF :0.65 INPUT :80(W) OUTDOOR DB(:) INDOOR INDOOR 5 40 4 DB(:) WB(:) Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT 8 4.70. 0.47 774 4..0 0.47 88 4.5.95 0.47 99 0 4.94.7 0.5 846 4.6.6 0.5 97 4.44.55 0.5 99 8 4.70.40 0.5 774 4..0 0.5 88 4.5. 0.5 99 0 4.94.9 0.9 846 4.6.80 0.9 97 4.44.7 0.9 99 5..4 0.7 99 4.90. 0.7 07 4.7.8 0.7 06 8 4.70.59 0.55 774 4..8 0.55 88 4.5.8 0.55 99 0 4.94. 0.4 846 4.6.98 0.4 97 4.44.9 0.4 99 5..6 0. 99 4.90.5 0. 07 4.7.47 0. 06 4 8 4.70.78 0.59 774 4..55 0.59 88 4.5.45 0.59 99 4 0 4.94. 0.47 846 4.6.7 0.47 97 4.44.09 0.47 99 4 5..8 0.5 99 4.90.7 0.5 07 4.7.65 0.5 06 4 4 5.5.7 0. 99 5.8.9 0. 08 5.04.6 0. 7 5 8 4.70.96 0.6 774 4..7 0.6 88 4.5.6 0.6 99 5 0 4.94.5 0.5 846 4.6.5 0.5 97 4.44.6 0.5 99 5 5..04 0.9 99 4.90.9 0.9 07 4.7.84 0.9 06 5 4 5.5.49 0.7 99 5.8.40 0.7 08 5.04.6 0.7 7 6 8 4.70.5 0.67 774 4..89 0.67 88 4.5.78 0.67 99 6 0 4.94.7 0.55 846 4.6.5 0.55 97 4.44.44 0.55 99 6 5..5 0.4 99 4.90. 0.4 07 4.7.0 0.4 06 6 4 5.5.7 0. 99 5.8.6 0. 08 5.04.56 0. 7 6 6 5.8.0 0.9 06 5.47.04 0.9 54 5.0.0 0.9 99 7 8 4.70.4 0.7 774 4..07 0.7 88 4.5.95 0.7 99 7 0 4.94.9 0.59 846 4.6.7 0.59 97 4.44.6 0.59 99 7 5..46 0.47 99 4.90.0 0.47 07 4.7. 0.47 06 7 4 5.5.9 0.5 99 5.8.8 0.5 08 5.04.76 0.5 7 7 6 5.8.4 0. 06 5.47.6 0. 54 5.0. 0. 99 8 8 4.70.5 0.75 774 4..4 0.75 88 4.5. 0.75 99 8 0 4.94. 0.6 846 4.6.90 0.6 97 4.44.80 0.6 99 8 5..67 0.5 99 4.90.50 0.5 07 4.7.4 0.5 06 8 4 5.5.5 0.9 99 5.8.0 0.9 08 5.04.97 0.9 7 8 6 5.8.57 0.7 06 5.47.48 0.7 54 5.0.4 0.7 99 9 8 4.70.7 0.79 774 4..4 0.79 88 4.5.8 0.79 99 9 0 4.94. 0.67 846 4.6.09 0.67 97 4.44.97 0.67 99 9 5..88 0.55 99 4.90.69 0.55 07 4.7.60 0.55 06 9 4 5.5.7 0.4 99 5.8. 0.4 08 5.04.7 0.4 7 9 6 5.8.80 0. 06 5.47.70 0. 54 5.0.64 0. 99 0 8 4.70.90 0.8 774 4..59 0.8 88 4.5.45 0.8 99 0 0 4.94.5 0.7 846 4.6.7 0.7 97 4.44.5 0.7 99 0 5..09 0.59 99 4.90.89 0.59 07 4.7.79 0.59 06 0 4 5.5.59 0.47 99 5.8.44 0.47 08 5.04.7 0.47 7 0 6 5.8.0 0.5 06 5.47.9 0.5 54 5.0.86 0.5 99 8 4.70 4.09 0.87 774 4..76 0.87 88 4.5.6 0.87 99 0 4.94.7 0.75 846 4.6.46 0.75 97 4.44. 0.75 99 5..0 0.6 99 4.90.08 0.6 07 4.7.98 0.6 06 4 5.5.8 0.5 99 5.8.64 0.5 08 5.04.57 0.5 7 6 5.8.7 0.9 06 5.47. 0.9 54 5.0.07 0.9 99 8 4.70 4.8 0.9 774 4..9 0.9 88 4.5.78 0.9 99 0 4.94.9 0.79 846 4.6.64 0.79 97 4.44.5 0.79 99 5..5 0.67 99 4.90.8 0.67 07 4.7.7 0.67 06 4 5.5.04 0.55 99 5.8.85 0.55 08 5.04.77 0.55 7 6 5.8.50 0.4 06 5.47.5 0.4 54 5.0.8 0.4 99 NOTE Q : Total capacity (kw) SHF : Sensible heat factor DB : Dry-bulb temperature SHC : Sensible heat capacity (kw) INPUT : Total power input (W) WB : Wet-bulb temperature 0
PERFORMANCE DATA COOL operation(0v) MCFH-A60VB : MUCFH-A60VB CAPACITY :6.0(kW) SHF :0.64 INPUT :450(W) OUTDOOR DB(:) INDOOR INDOOR 5 7 0 DB(:) WB(:) Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT 8 7.05.4 0.46 960 6.75. 0.46 058 6.48.98 0.46 56 6.4.87 0.46 54 0 7.5.50 0.4 058 7.05.40 0.4 8 6.84. 0.4 0 6.60.4 0.4 8 8 7.05.5 0.50 960 6.75.8 0.50 058 6.48.4 0.50 56 6.4. 0.50 54 0 7.5.79 0.8 058 7.05.68 0.8 8 6.84.60 0.8 0 6.60.5 0.8 8 7.65.99 0.6 7.8.9 0.6 66 7.0.87 0.6 8 6.90.79 0.6 46 8 7.05.8 0.54 960 6.75.65 0.54 058 6.48.50 0.54 56 6.4.7 0.54 54 0 7.5.09 0.4 058 7.05.96 0.4 8 6.84.87 0.4 0 6.60.77 0.4 8 7.65.0 0.0 7.8. 0.0 66 7.0.6 0.0 8 6.90.07 0.0 46 4 8 7.05 4.09 0.58 960 6.75.9 0.58 058 6.48.76 0.58 56 6.4.6 0.58 54 4 0 7.5.8 0.46 058 7.05.4 0.46 8 6.84.5 0.46 0 6.60.04 0.46 8 4 7.65.60 0.4 7.8.5 0.4 66 7.0.45 0.4 8 6.90.5 0.4 46 4 4 8.04.77 0. 0 7.74.70 0. 5 7.56.66 0. 46 7..6 0. 548 5 8 7.05 4.7 0.6 960 6.75 4.9 0.6 058 6.48 4.0 0.6 56 6.4.87 0.6 54 5 0 7.5.68 0.50 058 7.05.5 0.50 8 6.84.4 0.50 0 6.60.0 0.50 8 5 7.65.9 0.8 7.8.80 0.8 66 7.0.74 0.8 8 6.90.6 0.8 46 5 4 8.04.09 0.6 0 7.74.0 0.6 5 7.56.97 0.6 46 7..90 0.6 548 6 8 7.05 4.65 0.66 960 6.75 4.46 0.66 058 6.48 4.8 0.66 56 6.4 4. 0.66 54 6 0 7.5.97 0.54 058 7.05.8 0.54 8 6.84.69 0.54 0 6.60.56 0.54 8 6 7.65. 0.4 7.8.0 0.4 66 7.0.0 0.4 8 6.90.90 0.4 46 6 4 8.04.4 0.0 0 7.74. 0.0 5 7.56.7 0.0 46 7..0 0.0 548 6 6 8.8.49 0.8 5 8.04.45 0.8 475 7.9.4 0.8 548 7.68.8 0.8 6 7 8 7.05 4.94 0.70 960 6.75 4.7 0.70 058 6.48 4.54 0.70 56 6.4 4.7 0.70 54 7 0 7.5 4.6 0.58 058 7.05 4.09 0.58 8 6.84.97 0.58 0 6.60.8 0.58 8 7 7.65.5 0.46 7.8.9 0.46 66 7.0. 0.46 8 6.90.7 0.46 46 7 4 8.04.7 0.4 0 7.74.6 0.4 5 7.56.57 0.4 46 7..49 0.4 548 7 6 8.8.8 0. 5 8.04.77 0. 475 7.9.74 0. 548 7.68.69 0. 6 8 8 7.05 5. 0.74 960 6.75 5.00 0.74 058 6.48 4.80 0.74 56 6.4 4.6 0.74 54 8 0 7.5 4.56 0.6 058 7.05 4.7 0.6 8 6.84 4.4 0.6 0 6.60 4.09 0.6 8 8 7.65.8 0.50 7.8.69 0.50 66 7.0.60 0.50 8 6.90.45 0.50 46 8 4 8.04.06 0.8 0 7.74.94 0.8 5 7.56.87 0.8 46 7..78 0.8 548 8 6 8.8.5 0.6 5 8.04.09 0.6 475 7.9.06 0.6 548 7.68.00 0.6 6 9 8 7.05 5.50 0.78 960 6.75 5.7 0.78 058 6.48 5.05 0.78 56 6.4 4.87 0.78 54 9 0 7.5 4.85 0.66 058 7.05 4.65 0.66 8 6.84 4.5 0.66 0 6.60 4.6 0.66 8 9 7.65 4. 0.54 7.8.99 0.54 66 7.0.89 0.54 8 6.90.7 0.54 46 9 4 8.04.8 0.4 0 7.74.5 0.4 5 7.56.8 0.4 46 7..07 0.4 548 9 6 8.8.48 0.0 5 8.04.4 0.0 475 7.9.8 0.0 548 7.68.0 0.0 6 0 8 7.05 5.78 0.8 960 6.75 5.54 0.8 058 6.48 5. 0.8 56 6.4 5. 0.8 54 0 0 7.5 5.5 0.70 058 7.05 4.94 0.70 8 6.84 4.79 0.70 0 6.60 4.6 0.70 8 0 7.65 4.44 0.58 7.8 4.8 0.58 66 7.0 4.8 0.58 8 6.90 4.00 0.58 46 0 4 8.04.70 0.46 0 7.74.56 0.46 5 7.56.48 0.46 46 7..7 0.46 548 0 6 8.8.8 0.4 5 8.04.7 0.4 475 7.9.69 0.4 548 7.68.6 0.4 6 8 7.05 6.06 0.86 960 6.75 5.8 0.86 058 6.48 5.57 0.86 56 6.4 5.7 0.86 54 0 7.5 5.44 0.74 058 7.05 5. 0.74 8 6.84 5.06 0.74 0 6.60 4.88 0.74 8 7.65 4.74 0.6 7.8 4.58 0.6 66 7.0 4.46 0.6 8 6.90 4.8 0.6 46 4 8.04 4.0 0.50 0 7.74.87 0.50 5 7.56.78 0.50 46 7..66 0.50 548 6 8.8.5 0.8 5 8.04.06 0.8 475 7.9.0 0.8 548 7.68.9 0.8 6 8 7.05 6.5 0.90 960 6.75 6.08 0.90 058 6.48 5.8 0.90 56 6.4 5.6 0.90 54 0 7.5 5.7 0.78 058 7.05 5.50 0.78 8 6.84 5.4 0.78 0 6.60 5.5 0.78 8 7.65 5.05 0.66 7.8 4.87 0.66 66 7.0 4.75 0.66 8 6.90 4.55 0.66 46 4 8.04 4.4 0.54 0 7.74 4.8 0.54 5 7.56 4.08 0.54 46 7..95 0.54 548 6 8.8.48 0.4 5 8.04.8 0.4 475 7.9. 0.4 548 7.68. 0.4 6 NOTE Q : Total capacity (kw) SHF : Sensible heat factor DB : Dry-bulb temperature SHC : Sensible heat capacity (kw) INPUT : Total power input (W) WB : Wet-bulb temperature
PERFORMANCE DATA COOL operation(0v) MCFH-A60VB : MUCFH-A60VB CAPACITY :6.0(kW) SHF :0.64 INPUT :450(W) OUTDOOR DB(:) INDOOR INDOOR 5 40 4 DB(:) WB(:) Q SHC SHF INPUT Q SHC SHF INPUT Q SHC SHF INPUT 8 5.88.70 0.46 40 5.40.48 0.46 548 5.9.9 0.46 597 0 6.8.0 0.4 499 5.76.96 0.4 6 5.55.89 0.4 695 8 5.88.94 0.50 40 5.40.70 0.50 548 5.9.60 0.50 597 0 6.8.5 0.8 499 5.76.9 0.8 6 5.55. 0.8 695 6.54.70 0.6 597 6..59 0.6 744 5.9.54 0.6 79 8 5.88.8 0.54 40 5.40.9 0.54 548 5.9.80 0.54 597 0 6.8.60 0.4 499 5.76.4 0.4 6 5.55. 0.4 695 6.54.96 0.0 597 6..84 0.0 744 5.9.77 0.0 79 4 8 5.88.4 0.58 40 5.40. 0.58 548 5.9.0 0.58 597 4 0 6.8.84 0.46 499 5.76.65 0.46 6 5.55.55 0.46 695 4 6.54. 0.4 597 6..08 0.4 744 5.9.0 0.4 79 4 4 6.90.5 0. 695 6.48.4 0. 88 6.0.9 0. 879 5 8 5.88.65 0.6 40 5.40.5 0.6 548 5.9. 0.6 597 5 0 6.8.09 0.50 499 5.76.88 0.50 6 5.55.78 0.50 695 5 6.54.49 0.8 597 6.. 0.8 744 5.9.5 0.8 79 5 4 6.90.79 0.6 695 6.48.68 0.6 88 6.0.64 0.6 879 6 8 5.88.88 0.66 40 5.40.56 0.66 548 5.9.4 0.66 597 6 0 6.8.4 0.54 499 5.76. 0.54 6 5.55.00 0.54 695 6 6.54.75 0.4 597 6..57 0.4 744 5.9.48 0.4 79 6 4 6.90.07 0.0 695 6.48.94 0.0 88 6.0.89 0.0 879 6 6 7.6. 0.8 79 6.84. 0.8 96 6.6.9 0.8 977 7 8 5.88 4. 0.70 40 5.40.78 0.70 548 5.9.6 0.70 597 7 0 6.8.58 0.58 499 5.76.4 0.58 6 5.55. 0.58 695 7 6.54.0 0.46 597 6..8 0.46 744 5.9.7 0.46 79 7 4 6.90.5 0.4 695 6.48.0 0.4 88 6.0.4 0.4 879 7 6 7.6.60 0. 79 6.84.50 0. 96 6.6.46 0. 977 8 8 5.88 4.5 0.74 40 5.40 4.00 0.74 548 5.9.84 0.74 597 8 0 6.8.8 0.6 499 5.76.57 0.6 6 5.55.44 0.6 695 8 6.54.7 0.50 597 6..06 0.50 744 5.9.96 0.50 79 8 4 6.90.6 0.8 695 6.48.46 0.8 88 6.0.9 0.8 879 8 6 7.6.89 0.6 79 6.84.78 0.6 96 6.6.7 0.6 977 9 8 5.88 4.59 0.78 40 5.40 4. 0.78 548 5.9 4.05 0.78 597 9 0 6.8 4.08 0.66 499 5.76.80 0.66 6 5.55.66 0.66 695 9 6.54.5 0.54 597 6..0 0.54 744 5.9.9 0.54 79 9 4 6.90.90 0.4 695 6.48.7 0.4 88 6.0.65 0.4 879 9 6 7.6.8 0.0 79 6.84.05 0.0 96 6.6.99 0.0 977 0 8 5.88 4.8 0.8 40 5.40 4.4 0.8 548 5.9 4.6 0.8 597 0 0 6.8 4. 0.70 499 5.76 4.0 0.70 6 5.55.89 0.70 695 0 6.54.79 0.58 597 6..55 0.58 744 5.9.4 0.58 79 0 4 6.90.7 0.46 695 6.48.98 0.46 88 6.0.90 0.46 879 0 6 7.6.47 0.4 79 6.84. 0.4 96 6.6.5 0.4 977 8 5.88 5.06 0.86 40 5.40 4.64 0.86 548 5.9 4.46 0.86 597 0 6.8 4.57 0.74 499 5.76 4.6 0.74 6 5.55 4. 0.74 695 6.54 4.05 0.6 597 6..79 0.6 744 5.9.66 0.6 79 4 6.90.45 0.50 695 6.48.4 0.50 88 6.0.5 0.50 879 6 7.6.76 0.8 79 6.84.60 0.8 96 6.6.5 0.8 977 8 5.88 5.9 0.90 40 5.40 4.86 0.90 548 5.9 4.67 0.90 597 0 6.8 4.8 0.78 499 5.76 4.49 0.78 6 5.55 4. 0.78 695 6.54 4. 0.66 597 6. 4.04 0.66 744 5.9.90 0.66 79 4 6.90.7 0.54 695 6.48.50 0.54 88 6.0.40 0.54 879 6 7.6.05 0.4 79 6.84.87 0.4 96 6.6.78 0.4 977 NOTE Q : Total capacity (kw) SHF : Sensible heat factor DB : Dry-bulb temperature SHC : Sensible heat capacity (kw) INPUT : Total power input (W) WB : Wet-bulb temperature
PERFORMANCE DATA HEAT operation(0v) MCFH-A5VB : MUCFH-A5VB CAPACITY :.7(kW) INPUT : 00(W) OUTDOOR WB(:) INDOOR -0-5 0 5 0 5 0 DB(:) Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT 5 6...00 66 74 765.8.66.48 796 847 898 HEAT operation(0v) MCFH-A50VB : MUCFH-A50VB CAPACITY :5.0(kW) INPUT :890(W) HEAT operation(0v) MCFH-A60VB : MUCFH-A60VB OUTDOOR WB(:) INDOOR -0-5 0 5 0 5 0 DB(:) Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT 5.5 9.80 474 4.45 66 5.0 796 5.75 909 6.5 966 7.00 00.00.60 569 4.5 79 4.85 87 5.50 966 6.0 0 6.7 098 6.70 48.5 66.95 8 4.60 966 5.5 060 5.85 7 6.50 74 CAPACITY :6.8(kW) INPUT :70(W).9.5.9 898 98 989 OUTDOOR WB(:) INDOOR -0-5 0 5 0 5 0 DB(:) Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT Q INPUT 5 4.8 768 5.7 6.05 94 6.94 584 7.8 747 8.64 89 9.5 88 4.08 904 4.90 58 5.78 50 6.60 69 7.48 89 8.0 90 9.5 09 6.67 040 4.56 94 5.7 68 6.6 89 7.4 965 7.96 046 8.84 8 NOTE Q :Total capacity (kw) INPUT:Total power input (W) DB : Dry-bulb temperature WB : Wet-bulb temperature.77.59.40 969 00 06 4.6 4.07.89 00 06 4.70 4.5 4. 06 09 4 5.8 4.98 4.8 08 7
9 ACTUATOR CONTROL MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB R.V. coil control Heating ON Cooling OFF Dry OFF NOTE. : The 4-way valve reverses for 5 seconds right before start-up of the compressor. Example. In case of power ON with remote controller (COOL / DRY) (HEAT) 5 sec. 5 sec. Compressor R.V. coil Outdoor fan ON OFF ON OFF ON OFF ON OFF ON OFF ON OFF 0 SERVICE FUNCTIONS MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB 0-. COMPULSORY DEFROSTIN MODE FOR SERVICE By short circuit of the connector JPDS and JPS (MUCFH-A5VB/A50VB) / JP and R87 (MUCFH-A60VB) on the outdoor deicer P.C. board, defrosting mode can be accomplished regardless of the defrost interval restriction. Defrost thermistor RT6 must read below -:. (Refer to -5.) 0-. CHANE IN DEFROST SETTIN <JRF> When the JRF wire of the deicer P.C. board is cut, the defrost interval time will be changed. <JR> When the JR wire of the deicer P.C. board is cut, the defrost temperature will be changed. (Refer to -5.) Model MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB Jumper wire JRF JR Change point Defrost interval time changes from 40 minutes to 5 minutes. Defrost start temperature changes from -: to 0:. (MUCFH-A5VB/A50VB) Defrost start temperature does not change.(-.0:) (MUCFH-A60VB) Defrost finish temperature changes 0.:.(MUCFH-A5VB) Defrost finish temperature changes from.: to 0.:.(MUCFH-A50VB) Defrost finish temperature changes from.: to 5:.(MUCFH-A60VB) 4
TROUBLESHOOTIN MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB -. CAUTIONS ON TROUBLESHOOTIN. Before troubleshooting, check the following: () Check the power supply voltage. () Check the indoor/outdoor connecting wire for mis-wiring.. Take care the following during service. () Before servicing the air conditioner, be sure to turn OFF the main unit first with the remote controller, and then after confirming the horizontal vane has completely closed, turn OFF the breaker. () Be sure to unplug the power cord before removing the air inlet grille, the front panel, the cabinet, the top panel and the electronic control P.C. boards. () When removing the electronic control P.C. board, hold the edge of the board with care NOT to apply stress on the components. (4) When connecting or disconnecting the connectors, hold the housing of the connector. DO NOT pull the lead wires.. Troubleshooting procedure () First, check if the OPERATION INDICATOR lamp on the indoor unit is flashing on and off to indicate an abnormality. To make sure, check how many times the abnormality indication is flashing on and off before starting service work. () If the electronic control P.C. board is supposed to be defective, check the copper foil pattern for disconnection and the components for bursting and discoloration. () When troubleshooting, refer to -. Instruction of troubleshooting. 5
-. INSTRUCTION OF TROUBLESHOOTIN Start Indoor unit operates. Outdoor unit doesn't operate. Indoor unit operates. Outdoor unit doesn't operate normally. Indoor unit doesn't receive the signal from remote controller. OPERATION INDICATOR lamp on the indoor unit is flashing on and off. Outdoor unit operates only in Test Run operation.w Outdoor unit doesn't operate even in Test Run operation.w Outdoor unit doesn't stop even if indoor unit stops. Unit doesn't operate normal operation in COOL or HEAT mode. Indoor unit operates, when the EMERENCY OPERATION switch is pressed. Indoor unit doesn't operate, when the EMERENCY OPERATION switch is pressed. Check room temperature thermistor. Refer to -5. "Test point diagram and voltage". Refer to -4. A "Check of outdoor unit". Refer to -4. C "Check of outdoor unit". Refer to -4. D "Check of R.V. coil". Refer to "Check of remote controller and receiver P.C. board".. Check indoor / outdoor connecting wire.. Refer to "Check of indoor electronic control P.C. board". Flash on and off at 0.5- second interval Cause: Indoor/ Outdoor unit Mis-wiring or trouble of serial signal -time flash Cause: Indoor unit Trouble of room temperature/ indoor coil thermistor 4-time flash Cause: Indoor unit Trouble of indoor electric control P.C. board 6-time flash Cause: Outdoor unit Trouble of thermistor in outdoor unit 7-time flash Cause: Outdoor unit Trouble of outdoor control system Refer to -4. B "How to check miswiring and serial signal error (When outdoor unit doesn't work)". Check room temperature thermistor and indoor coil thermistor. Refer to -5. "Test point diagram and voltage". Refer to "Check of indoor electric control P.C. board". Refer to -4. E "Check of outdoor thermistor". Replace the deicer P.C. board. Refer to indoor unit service manual. w "Test Run operation" means the operation within 0 minutes after EMERENCY OPERATION switch is pressed. 6
-. TRUBLE CRITERION OF MAIN PARTS MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB Part name Defrost thermistor (RT6) Check method and criterion Measure the resistance with a tester. (Part temperature -0 C ~ 40 C) rmal Abnormal 5kΩ ~ 60kΩ Open or short-circuit Figure Compressor (MC) INNER PROTECTOR MUCFH-A5VB 55i 5: OPEN 90i0: CLOSE MUCFH-A50VB /A60VB 60i 5: OPEN 90i0: CLOSE Measure the resistance between the terminals with a tester. (Part temperature -0 C ~ 40 C) Color of lead wire C-R C-S rmal MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB.46 ~.0Ω.96 ~.6Ω.05 ~.0Ω.8 ~.9Ω 0.84 ~.04Ω.8 ~.4Ω Abnormal Open or short-circuit WHT C P AUX. MAIN S RED R BLK MUCFH-A5VB MAIN AUX. Outdoor fan motor (MF) MUCFH-A5VB INNER FUSE 45i: CUT OFF MUCFH-A50VB /A60VB INNER PROTECTOR 45i 8: OPEN ( 88i5: CLOSEw) Measure the resistance between the terminals with a tester. (Part temperature -0 C ~ 40 C) Color of lead wire WHT-BLK BLK-RED BLK-YLW YLW-RED 9 ~ Ω 7 ~ 0 Ω rmal MUCFH-A5VB MUCFH-A50VB MUCFH-A60VB 70 ~ 86 Ω 74 ~ 89 Ω 6 ~ 74 Ω 8 ~ 00 Ω Abnormal Open or short-circuit BLK MUCFH-A50VB P BLK FUSE MAIN AUX RED WHT REDORNWHT MUCFH-A60VB MAIN AUX P BLK RED ORN WHT R.V. coil (S4) Measure the resistance using a tester. (Part temperature -0 C ~ 40 C) rmal Abnormal.94 kω ~.9 kω Open or short-circuit w Reference value P : INNER PROTECTOR 7
-4. TROUBLESHOOTIN FLOW Compressor and/or outdoor fan motor doesn t operate. A Check of outdoor unit MUCFH-A5VB MUCFH-A50VB Operate the unit in COOL or HEAT mode by pressing the EMERENCY OPERATION switch. -minute time delay works. Test run operation operates for 0 minutes. Compressor doesn't operate. Is there 5V DC between J05 + J0 on the deicer P.C. board? w Is there 0V AC between on the compressor contactor (5C) and N on the outdoor terminal block (TB)? Check the compressor and compressor capacitor. Refer to -. Replace the deicer P.C. board. Is there 0V AC between 4 on the compressor contactor (5C) and TAB0 on the deicer P.C. board? w Replace the deicer P.C. board. Rectify the indoor and outdoor connecting wire. Is there 0V AC between L N on the outdoor terminal block (TB)? Rectify the connecting wire. Outdoor fan motor doesn't operate. Rectify the indoor and outdoor connecting wire. Is there 5V DC between J05 + J0 on the deicer P.C. board? w Is there 0V AC between 4 on the compressor contactor (5C) and TAB 0 on the deicer P.C. board? w Is there 0V AC between L N on the outdoor terminal block (TB)? Check the outdoor fan motor. Refer to -. Replace the deicer P.C. board. Rectify the connecting wire. w Refer to -5. 8
Compressor and/or outdoor fan motor doesn t operate. A Check of outdoor unit MUCFH-A60VB Start Operate the unit in COOL or HEAT mode by pressing the EMERENCY OPERATION switch. -minute time delay works. Test run operation operates for 0 minutes. Compressor doesn't operate. Is there 5V DC between J0 + - J40 on the deicer P.C. board? w Is there 0V AC between CN70 - on the deicer P.C. board? w Replace the deicer P.C. board. Make the connection of wiring correct. Is there 0V AC between A-A on the compressor contactor(5c)? Replace the deicer P.C. board. Is there 0V AC between 4 on the compressor contactor(5c) and N on the outdoor terminal block? Check the compressor. Refer to -.. Is there 0V AC between on the compressor contactor(5c) and N on the outdoor terminal block? Replace the compressor contactor(5c). Make the connection of wiring correct. Outdoor fan motor doesn't operate. Is there 5V DC between J0 + - J40 on the deicer P.C. board? w Is there 0V AC between CN70 - on the deicer P.C. board? w Replace the deicer P.C. board. Make the connection of wiring correct. Is there 0V AC between CN7 - or - on the deicer P.C. board? w Replace the deicer P.C. board. Check the outdoor fan motor. Refer to -. w Refer to -5. 9
When OPERATION INDICATOR lamp flashes ON and OFF in every 0.5-second. Outdoor unit does not operate. B How to check mis-wiring and serial signal error (when outdoor unit does not work) Start Make them sure. Is this mis-wiring, poor contact, or disconnection of wire?. Turn OFF the power supply(indoor/outdoor unit) and disconnect indoor and outdoor connecting wire on indoor side.. Short-circuit between indoor terminal block N and.. Turn ON the power supply(indoor unit) and press once EMERENCY OPERATION switch. Is there 0V DC between both ends of R on indoor electronic control P.C. board? ( By tester, the stylus is between 0 ~ 0V. ) Turn OFF the power supply(indoor unit). Connect ON indoor and outdoor connecting wire. Replace the indoor electronic control P.C. board. Turn ON the power supply(outdoor unit). Is there 0V AC between outdoor terminal block L-N (TB)? Check the outdoor power supply, power supply cord and connection. Is there 5V DC between J05 + J0 - (MUCFH-A5VB/A50VB)/ J0 + J40 - (MUCFH-A60VB) on the deicer P.C. board? Replace the deicer P.C. board. Turn ON the power supply(indoor unit). During EMERENCY OPERATION, is there 0V DC between both ends of R60? (By tester, the stylus is between 5 ~0V) Make the wiring between CN70 on the deicer P.C. board and outdoor terminal block correct. Replace the deicer P.C. board. Refer to indoor unit service manual. 0
Compressor and/or outdoor fan motor doesn t stop. C Check of outdoor unit MUCFH-A5VB MUCFH-A50VB Turn OFF the power supply. After 0 seconds, turn ON the power supply again. Operate the unit in COOL or HEAT mode by pressing the EMERENCY OPERATION switch. 4 Operate the unit for minute or more and stop it by pressing the EMERENCY OPERATION switch again. Does compressor stop? OK Is there 0V AC between on the compressor contactor (5C) and N on the outdoor terminal block (TB)? Replace the deicer P.C. board. Rectify the connecting wire. Does outdoor fan motor stop? Replace the deicer P.C. board. OK MUCFH-A60VB Turn OFF the power supply. After 0 seconds, turn ON the power supply again. Operate the unit in COOL or HEAT mode by pressing the EMERENCY OPERATION switch. 4 Operate the unit for minute or more and stop it by pressing the EMERENCY OPERATION switch again. After 0 seconds, does compressor stop? Is there 0V AC between A-A on the compressor contactor(5c)? Is there 0V AC between 4 on the compressor contactor and N on the outdoor terminal block? Make the connection of wiring correct. OK Replace the deicer P.C. board. Replace the compressor contactor(5c). After 0 seconds, does outdoor fan motor stop? Replace the deicer P.C. board. OK Unit operates HEAT mode even if it is set to COOL mode. D Check of R.V. coil w First, measure the resistance of R.V. coil to confirm it is disconnected or is not short-circuit. Disconnect the TAB5 on the deicer P.C. board. (MUCFH-A60VB) Turn ON the power supply and operate the indoor unit in COOL mode by pressing the EMERENCY OPERATION switch. After minutes, does the unit operate in HEAT mode? OK Is there 0V AC between CN7 (MUCFH-A5VB/A50VB)/ CN7 (MUCFH-A60VB) on the deicer P.C. board? Replace the deicer P.C. board. Replace the R.V. coil.
Unit operates COOL mode even if it is set to HEAT mode. D Check of R.V. coil w First, measure the resistance of R.V. coil to confirm it is disconnected or is not short-circuit. Disconnect the TAB5 on the deicer P.C. board. (MUCFH-A60VB) Turn ON the power supply and operate the indoor unit in HEAT mode by pressing the EMERENCY OPERATION switch. After minutes, does the unit operate in COOL mode? OK Is there 0V AC between CN7 (MUCFH-A5VB/A50VB)/ CN7 (MUCFH-A60VB) on the deicer P.C. board? Replace the R.V. coil. Replace the deicer P.C. board When OPERATION INDICATOR lamp flashes 6-time. Thermistors in the outdoor unit are abnormal. E Check of outdoor thermistor w Disconnect the connectors CN66 from the deicer P.C. board. (Check the characteristics of each thermistor.) Turn OFF the power supply. Defrost thermistor(rt6) Measure resistance between CN 66 and. Does the resistance of thermistor have the characteristics on -5.? Replace the thermistor. Reconnect CN66. Turn ON the power supply and press the EMERENCY OPERATION switch. Replace the deicer P.C. board. Does the unit operate 0 minutes or more? OK W. W. It is thought defective contact of the connector.
0V AC} -5. TEST POINT DIARAM AND VOLTAE MUCFH-A5VB MUCFH-A50VB Outdoor deicer P.C. board CN7 Outdoor fan motor 0V AC } CN7 R.V. coil 0V AC } Power supply input NR6 Varistor 5V DC J05 J0 -- + (Refer to -4.A or B.) } F6 Fuse A/50V + -- R60 5~0V DC CN66 - Defrost thermistor RT6 (Refer to -4.E.) } Defrost interval time short pin (JPDS, JPS) (Refer to 0-.) } Jumper wire for change in defrost setting (JRF,JR) (Refer to 0-.) V DC J04 J0 -- +
MUCFH-A60VB Outdoor deicer P.C. board Defrost thermistor (RT6) 00 90 Resistance(k") 80 70 60 50 40 0 0 0 0-0 -0 0 0 0 0 40 Temperature(:) CN66 - Defrost thermistor (RT6) (Refer to -4.E.) Fan motor (CN7) 0V Varistor (NR6) Defrost interval time short pin(jp, R87) (Refer to 0-.) J0 + 5V DC J40 (Refer to -4.A or B.) } Jumper wire for change in defrost setting (JRF, JR) (Refer to 0-.) + R.V. coil } (CN7) 0V } V DC Fuse (F6).5A / 50V Varistor (NR6) Power supply input } CN70-0V AC (Refer to -4.A.) } R60 0V DC + (Refer to -4.B.) 4
DISASSEMBLY INSTRUCTIONS <"Terminal with locking mechanism" Detaching points> The terminal which has the locking mechanism can be detached as shown below. There are two types ( Refer to () and ()) of the terminal with locking mechanism. The terminal without locking mechanism can be detached by pulling it out. Check the shape of the terminal before detaching. () Slide the sleeve and check if there is a locking lever or not. () The terminal with this connector has the locking mechanism. Sleeve Locking lever Slide the sleeve. Pull the terminal while pushing the locking lever. Connector Hold the sleeve, and pull out the terminal slowly. -. MUCFH-A5VB OPERATIN PROCEDURE. Removing the cabinet () Remove the screws of the top panel. () Remove the screw of the service panel. () Remove the screws of the cabinet. (4) Remove the screws of the front panel and motor support. (5) Remove the service panel, and remove the screw from the insides. (6) Remove the top panel. (7) Remove the cabinet. Photo PHOTOS Screws of the front panel and motor support Photo Screws of the cabinet Screws of the service panel Screws of the top panel Photo Screws of the cabinet Service panel Screw of the top panel Screws of the cabinet 5
OPERATIN PROCEDURE. Removing the deicer P.C. board () Remove the service panel and the cabinet. () Disconnect all the connectors and the terminals on the deicer P.C. board. () Remove the deicer P.C. board. Photo 4 PHOTOS Deicer P.C. board Screws Screw Relay panel Terminal block. Removing the propeller and the outdoor fan motor () Remove the cabinet. (Refer to.) () Remove the propeller nut. () Remove the propeller. NOTE : Loose the propeller in the rotating direction for removal. When attaching the propeller, align the mark on the propeller and the motor shaft cut section. Set the propeller in position by using the cut on the shaft and the mark on the propeller. (4) Remove lead clamps and disconnect the outdoor fan motor connector. (5) Remove screws fixing the fan motor. (6) Remove the outdoor fan motor. Photo 5 Propeller nut Screws of the outdoor fan motor Propeller Hook Lead clamps Outdoor fan motor connector Screws of the outdoor fan motor 6
OPERATIN PROCEDURE 4. Removing the compressor () Remove the cabinet. (Refer to.) () Remove the relay panel. () Remove the soundproof felt. (4) Remove the terminal cover on the compressor. (5) Disconnect lead wires from the glass terminal of the compressor. (6) Recover gas from the refrigerant circuit. NOTE : Recover gas from the pipes until the pressure gauge shows 0 kg/cm (0 MPa). (7) Disconnect the welded part of the discharge pipe. (8) Disconnect the welded part of the suction pipe. (9) Remove nuts fixing the compressor. (0) Remove the compressor. Photo 6 lass terminal Compressor Discharge pipe PHOTOS Suction pipe Compressor nuts Terminal cover 7
-. MUCFH-A50VB OPERATIN PROCEDURE. Removing the cabinet () Remove the screws of the cabinet. () Hold the bottom of the cabinet on both sides and remove the cabinet. Photo PHOTOS Photo Screws of the cabinet Screws of the cabinet Service panel. Removing the deicer P.C. board () Remove the service panel and the cabinet. () Disconnect all the connectors and the terminals on the deicer P.C. board. () Remove the deicer P.C. board. Photo Screw of the relay panel Deicer P.C. board Terminal blocks Relay panel Screw of the relay panel 8
OPERATIN PROCEDURE PHOTOS. Removing the propeller and the outdoor fan motor () Remove the cabinet. (Refer to.) () Remove the propeller nut and the propeller. NOTE : Loose the propeller in the rotating direction for removal. When attaching the propeller, align the mark on the propeller and the motor shaft cut section. Set the propeller in position by using the cut on the shaft and the mark on the propeller. () Remove the clamp of outdoor fan motor lead wire and disconnect the outdoor fan motor connector. (4) Remove the screws fixing the outdoor fan motor. (5) Remove the outdoor fan motor. Photo 4 Propeller Set screws of the outdoor fan motor Lead clamps Propeller nut Set screws of the outdoor fan motor Outdoor fan motor 4. Removing the compressor () Remove the cabinet. (Refer to.) () Remove the relay panel. () Remove the soundproof felt. (4) Remove the terminal cover on the compressor. (5) Disconnect lead wires from the compressor. (6) Recover gas from the refrigerant circuit. NOTE : Recover gas from the pipes until the pressure gauge shows 0 kg/cm (0 MPa). (7) Disconnect the welded part of the discharge pipe. (8) Disconnect the welded part of the suction pipe. (9) Remove nuts fixing the compressor. (0) Remove the compressor. Photo 5 Discharge pipe Terminal cover Compressor Suction pipe Compressor nuts 9
-. MUCFH-A60VB OPERATIN PROCEDURE.Removing the cabinet () Remove the screws of the service panel. () Remove the screws of the top panel. () Remove the screw of the valve cover. (4) Remove the service panel. (5) Remove the top panel. (6) Remove the valve cover. (7) Remove the screws of the front panel. (8) Remove the front panel. (9) Remove the screws of the back panel. (0) Remove the back panel. Photo Screws of the cabinet PHOTOS Screw of the top panel Photo Screw of the motor support Photo Screws of the cabinet Screw of the service panel Screws of the back panel Screws of the front panel Screws of the top panel Set screws of the back panel Screw of the valve cover. Removing the deicer P.C. board () Remove the service panel and the cabinet. () Disconnect all the connectors and the terminals on the deicer P.C. board. () Remove the deicer P.C. board. Photo 4 Deicer P.C. board Terminal blocks Screws of the relay panel Screws of the relay panel 40
OPERATIN PROCEDURE. Removing the propeller and the outdoor fan motor () Remove the cabinet. (Refer to.) () Remove the propeller nut and the propeller. NOTE : Loose the propeller in the rotating direction for removal. When attaching the propeller, align the mark on the propeller and the motor shaft cut section. Set the propeller in position by using the cut on the shaft and the mark on the propeller. () Remove the clamp of outdoor fan motor lead wire and disconnect the outdoor fan motor connector. (4) Remove the screws fixing the outdoor fan motor. (5) Remove the outdoor fan motor. Photo 5 Propeller nut PHOTOS Set screws of the outdoor fan motor Propeller Set screws of the outdoor fan motor 4. Removing the compressor () Remove the cabinet. (Refer to.) () Remove the relay panel. () Remove the soundproof felt. (4) Remove the terminal cover on the compressor. (5) Disconnect lead wires from the compressor. (6) Recover gas from the refrigerant circuit. NOTE : Recover gas from the pipes until the pressure gauge shows 0 kg/cm (0 MPa). (7) Disconnect the welded part of the discharge pipe. (8) Disconnect the welded part of the suction pipe. (9) Remove nuts fixing the compressor. (0) Remove the compressor. Photo 6 Suction pipe Discharge pipe Terminal cover Compressor nuts 4
PARTS LIST (non-rohs compliant) MUCFH-A5VB -. OUTDOOR UNIT STRUCTURAL PARTS 4 5 6 7 8 9 0 4
PARTS LIST (non-rohs compliant) MUCFH-A5VB -. OUTDOOR UNIT STRUCTURAL PARTS Part numbers that are circled are not shown in the illustration. Symbol Q'ty/unit. Part. Part name in Wiring Remarks Diagram MUCFH-A5VB- E 4 5 6 7 8 9 0 4 5 E0 87 60 E0 85 E0 85 5 E0 754 900 E0 075 506 E0 8 90 E0 90 66 E0 90 66 E0 9 96 E0 85 45 E0 86 E0 44 55 E0 85 97 E0 56 96 E0 76 96 E0 87 96 E0 89 64 OUTDOOR HEAT EXCHANER CABINET RILLE (OUT) COMPRESSOR COMPRESSOR RUBBER SET BASE STOP VALVE (AS) STOP VALVE (LIQUID) 4-WAY VALVE SERVICE PANEL BACK PANEL MOTOR SUPPORT TOP PANEL CAPILLARY TUBE CAPILLARY TUBE CAPILLARY TUBE CHECK VALVE MC RN5VHSHT RUBBERS/SET {.7 {6.5 {.0x{.4x500 {.0x{.6x600 {.0x{.6x050 4
PARTS LIST (non-rohs compliant) MUCFH-A5VB -. OUTDOOR UNIT ELECTRICAL PARTS AND FUNCTIONAL PARTS -. ACCESSORY 8 7 6 4 5 -. OUTDOOR UNIT ELECTRICAL PARTS AND FUNCTIONAL PARTS Part numbers that are circled are not shown in the illustration. Symbol Q'ty/unit. Part. Part name in Wiring Remarks MUCFH-A5VB- E Diagram 4 5 6 7 8 9 0 E0 665 50 E0 67 0 E0 696 5 E0 86 45 E0 890 8 E0 87 74 E0 86 74 E0 699 0 E0 90 490 E0 095 8 E0 80 85 PROPELLER OUTDOOR FAN MOTOR COMPRESSOR CAPACITOR DEICER P.C. BOARD SURE ABSORBER TERMINAL BLOCK TERMINAL BLOCK DEFROST THERMISTOR R. V. COIL FUSE VARISTOR MF C DSAR TB TB RT6 S4 F6 NR6 RA6V- 0+ /440V AC P P 50V /A -. ACCESSORY E0 87 704 E0 444 705 DRAIN SOCKET DRAIN CAP [ PCS/SET 44
PARTS LIST (non-rohs compliant) MUCFH-A50VB -4. OUTDOOR UNIT STRUCTURAL PARTS, ELECTRICAL PARTS AND FUNCTIONAL PARTS DEFROST THERMISTOR 0 9 8 7-5. ACCESSORY 7 8 5 4 6 0 Part numbers that are circled are not shown in the illustration.. 4 5 6 7 8 9 0 4 5 6 7 8 9 0 4 5 6 Part. E0 87 E0 87 E0 87 5 E0 64 60 E0 4 50 E0 9 55 E0 075 506 E0 87 900 E0 87 90 E0 87 66 E0 80 66 E0 87 45 E0 89 96 E0 888 5 E0 86 0 E0 895 8 E0 80 45 E0 87 74 E0 8 74 E0 80 0 E0 87 009 E0 9 96 E0 746 97 E0 89 97 E0 80 96 E0 095 8 E0 8 490 E0 89 64 E0 80 85-5. ACCESSORY 7 8 E0 87 704 E0 444 705 E0 444 706 4 5 6 7 8 9-4. OUTDOOR UNIT STRUCTURAL PARTS, ELECTRICAL PARTS AND FUNCTIONAL PARTS Part Name BACK PANEL CABINET RILLE OUTDOOR HEAT EXCHANER PROPELLER MOTOR SUPPORT COMPRESSOR RUBBER SET COMPRESSOR BASE STOP VALVE (AS) STOP VALVE (LIQUID) SERVICE PANEL 4-WAY VALVE COMPRESSOR CAPACITOR OUTDOOR FAN MOTOR SURE ABSORBER DEICER P.C. BOARD TERMINAL BLOCK TERMINAL BLOCK DEFROST THERMISTOR HANDLE CAPILLARY TUBE CAPILLARY TUBE CAPILLARY TUBE CAPILLARY TUBE FUSE R.V. COIL CHECK VALVE VARISTOR DRAIN SOCKET DRAIN CAP DRAIN CAP Symbol in Wiring Diagram 45 MC C MF DSAR TB TB RT6 F6 S4 NR6 Q'ty/unit MUCFH-A50VB- E Remarks RUBBERS/SET RN96VHSHT {.7 { 6.5 40+/440V AC RA6V50 - P P {.0 {.6 750 {.0 {.6 650 {.0 {.6 500 {.5 {0.6 000 50V / A [ PCS/SET [6
PARTS LIST (non-rohs compliant) MUCFH-A60VB -6. OUTDOOR UNIT STRUCTURAL PARTS, ELECTRICAL PARTS AND FUNCTIONAL PARTS 7 6 5 4 0 9 8 4 5 6 7 9 7 8 0 6 4 5-7. ACCESSORY 46
PARTS LIST (non-rohs compliant) MUCFH-A60VB -6. OUTDOOR UNIT STRUCTURAL PARTS, ELECTRICAL PARTS AND FUNCTIONAL PARTS Part numbers that are circled are not shown in the illustration.. 4 5 6 7 8 9 0 4 5 6 7 8 9 0 4 5 6 7 8 9 0 Part. E0 89 97 E0 8 60 E0 89 0 E0 4 50 E0 8 90 E0 89 E0 89 009 E0 89 5 E0 89 96 E0 8 490 E0 8 0 E0 57 506 E0 8 900 E0 89 66 E0 8 66 E0 89 650 E0 89 45 E0 890 8 E0 8 74 E0 87 74 E0 895 5 E0 9 45 E07 0 40 E0 889 5 E0 89 E0 87 009 E0 76 55 E0 7 8 E0 6 85 E0 89 64 E0 069 96 E0 9 97 Part Name TOP PANEL OUTDOOR HEAT EXCHANER OUTDOOR FAN MOTOR PROPELLER BASE CABINET HANDLE FAN UARD 4-WAY VALVE R.V. COIL DEFROST THERMISTOR COMPRESSOR RUBBER SET COMPRESSOR STOP VALVE (AS) STOP VALVE (LIQUID) VALVE COVER SERVICE PANEL SURE ABSORBER TERMINAL BLOCK TERMINAL BLOCK OUTDOOR FAN CAPACITOR DEICER P.C. BOARD COMPRESSOR CONTACTOR COMPRESSOR CAPACITOR BACK PANEL (OUT) HANDLE MOTOR SUPPORT FUSE VARISTOR CHECK VALVE CAPILLARY TUBE CAPILLARY TUBE Symbol in Wiring Diagram MF S4 RT6 MC DSAR TB TB C 5C C F6 NR6 Q'ty/unit MUCFH-A60VB - E 4 Remarks RA6V85-4RUBBERS/SET NN9VBAHT {5.88 {6.5 P P.0+/440V AC 55+/440V AC 50V/.5A {.0x{.0x400 {.0x{.0x800-7. ACCESSORY E0 87 704 E0 444 705 DRAIN SOCKET DRAIN CAP [ PCS/SET 47
4 RoHS PARTS LIST (RoHS compliant) MUCFH-A5VB 4-. OUTDOOR UNIT STRUCTURAL PARTS 4 5 6 7 8 9 0 48
PARTS LIST (non-rohs compliant) MUCFH-A5VB 4-. OUTDOOR UNIT STRUCTURAL PARTS Part numbers that are circled are not shown in the illustration. Symbol Q'ty/unit. Part. Part name in Wiring Remarks Diagram MUCFH-A5VB- E 4 5 6 7 8 9 0 4 5 RoHS E 87 60 E 85 E 85 5 E 754 900 E 075 506 E 8 90 E 90 66 E 90 66 E 9 96 E 85 45 E 86 E 44 55 E 85 97 E 56 96 E 76 96 E 87 96 E 89 64 OUTDOOR HEAT EXCHANER CABINET RILLE(OUT) COMPRESSOR COMPRESSOR RUBBER SET BASE STOP VALVE (AS) STOP VALVE (LIQUID) 4-WAY VALVE SERVICE PANEL BACK PANEL MOTOR SUPPORT TOP PANEL CAPILLARY TUBE CAPILLARY TUBE CAPILLARY TUBE CHECK VALVE MC RN5VHSHT RUBBERS/SET {.7 {6.5 {.0x{.4x500 {.0x{.6x600 {.0x{.6x050 49
RoHS PARTS LIST (RoHS compliant) MUCFH-A5VB 4-. OUTDOOR UNIT ELECTRICAL PARTS AND FUNCTIONAL PARTS 4-. ACCESSORY 8 7 6 4 5 4-. OUTDOOR UNIT ELECTRICAL PARTS AND FUNCTIONAL PARTS Part numbers that are circled are not shown in the illustration.. RoHS Part. Part name Symbol in Wiring Diagram Q'ty/unit MUCFH-A5VB- E Remarks 4 5 6 7 8 9 0 E 665 50 E 67 0 E 900 5 E 86 45 E 890 8 E 87 74 E 86 74 E 699 0 E 90 490 E 095 8 E 80 85 PROPELLER OUTDOOR FAN MOTOR COMPRESSOR CAPACITOR DEICER P.C. BOARD SURE ABSORBER TERMINAL BLOCK TERMINAL BLOCK DEFROST THERMISTOR R. V. COIL FUSE VARISTOR MF C DSAR TB TB RT6 S4 F6 NR6 RA6V- 0+ /440V AC P P 50V /A 4-. ACCESSORY E 87 704 E 444 705 DRAIN SOCKET DRAIN CAP [ PCS/SET 50
RoHS PARTS LIST (RoHS compliant) MUCFH-A50VB 4-4. OUTDOOR UNIT STRUCTURAL PARTS, ELECTRICAL PARTS AND FUNCTIONAL PARTS DEFROST THERMISTOR 9 8 0 7 4-5. ACCESSORY 7 8 5 4 6 0 4 5 6 7 8 9 4-4. OUTDOOR UNIT STRUCTURAL PARTS, ELECTRICAL PARTS AND FUNCTIONAL PARTS Part numbers that are circled are not shown in the illustration.. 4 5 6 7 8 9 0 4 5 6 7 8 9 0 4 5 6 RoHS Part. E 87 E 87 E 87 5 E 64 60 E 4 50 E 9 55 E 075 506 E 87 900 E 87 90 E 87 66 E 80 66 E 87 45 E 89 96 E 888 5 E 86 0 E 895 8 E 80 45 E 87 74 E 8 74 E 80 0 E 87 009 E 9 96 E 746 97 E 89 97 E 80 96 E 095 8 E 8 490 E 89 64 E 80 85 4-5. ACCESSORY 7 8 E 87 704 E 444 705 E 444 706 Part Name BACK PANEL CABINET RILLE OUTDOOR HEAT EXCHANER PROPELLER MOTOR SUPPORT COMPRESSOR RUBBER SET COMPRESSOR BASE STOP VALVE (AS) STOP VALVE (LIQUID) SERVICE PANEL 4-WAY VALVE COMPRESSOR CAPACITOR OUTDOOR FAN MOTOR SURE ABSORBER DEICER P.C. BOARD TERMINAL BLOCK TERMINAL BLOCK DEFROST THERMISTOR HANDLE CAPILLARY TUBE CAPILLARY TUBE CAPILLARY TUBE CAPILLARY TUBE FUSE R.V. COIL CHECK VALVE VARISTOR DRAIN SOCKET DRAIN CAP DRAIN CAP Symbol in Wiring Diagram 5 MC C MF DSAR TB TB RT6 F6 S4 NR6 Q'ty/unit MUCFH-A50VB- E Remarks RUBBERS/SET RN96VHSHT {.7 { 6.5 40+/440V AC RA6V50 - P P {.0 {.6 750 {.0 {.6 650 {.0 {.6 500 {.5 {0.6 000 50V / A [ PCS/SET [6