HEALTH DEPARTMENT MONTCLAIR, NJ 07042 TEL: # (973) 509-4970 Inspection Date: 12-06-01 RETAIL FOOD INSPECTION REPORT Activity Type: Evaluation: CHAPTER 24 CONDITIONAL JUST JAKES OWNER NAME: LSZ,INC TRADE NAME: LOCATION (STREET ADDRESS): 30 PARK STREET CITY: MONTCLAIR ZIP CODE: 07042 MAILING ADDRESS: 30PARK STREET PHONE: 655-8987 E-MAIL: JUSTJAKES@COMCAST.NET INSPECTING OFFICIAL: LICENSE #: B-2289 HEALTH OFFICER: SUSAN B. PORTUESE LICENSE # A-486 RISK TYPE: 3 Time/Activity Date: 12-06-01 Start Time -1: 14:35 End Time: 16:14 Date: 12-06-01 Start Time-2: End Time: RISK FACTOR are improper practices identified as the most common factors resulting in foodborne illness ( INTERVENTIONS are control measures to prevent FBI. "" Marked in appropriate Boxes IN=In Compliance - OUT=Not in Compliance - NO=Not Observed - NA=Not Applicable - COS=Corrected On-site - RV=Repeat Violation IN OUT RV NO NA COS **** FOODBORNE ILLNESS RISK FACTOTS & INTERVENTIONS **** **** MANAGEMENT & PERSONNEL **** 1 PIC demonstrates knowledge of food safety principles pertaining to this operation. 2 PIC in Risk Level 3 Retail Food Establishments is certified by January 2, 2010. 3 Ill or injured foodworkers restricted or excluded as required. **** PREVENTING CONTAMINATION FROM HANDS **** 4 Handwashing conducted in a timely manner; prior to work, after using restroom, etc. 5 Handwashing proper; duration at least 20 seconds with at least 10 seconds of vigorous lathering. 6 Handwashing facilities provided in toilet rooms and prep areas, convenient, accessible, and unobstructed. 7 Handwashing facilities provided with warm water; soap & acceptable hand drying method. 8 Direct bare hand contact with exposed, ready-to-eat foods is avoided. **** FOOD SOURCE **** 9 All foods, including ice and water, from approved sources with proper records. 10 Shellfish/Seafood record keeping procedures; storage; proper handling; parasite destruction. 11 PHFs received at 41F or below. Except: milk, shell eggs and shellfish (45F). **** FOOD PROTECTED FROM CONTAMINATION **** 12 Proper separation of raw meats and raw eggs from ready-to-eat foods provided. 13 Food protected from contamination. 14 Food contact surfaces properly cleaned and sanitized. **** PHFs TIME/TEMPERATURE CONTROLS **** 15 SAFE COOKING TEMPERATURES (Internal temperatures for raw animal foods for 15 seconds) Except: Foods may be served raw or undercooked in response to a consumer order and for immediate service. 130F for 112 minutes: Roasts or as per cooking chart found un 16 PASTEURIZED EGGS: substituted for shell eggs in raw or undercooked egg-containing foods, i.e. Caesar salad dressing, hollandaise sauce, tiramisu, chocolate mousse, meringue, etc. 17 COLD HOLDING: PHFs maintained at "Refrigeration Temperatures" (41F). 18 COOLING: PHFs rapidly cooled from 135F to 41F within 6 hours and from 135F to 70F within 2 hours. 19 COOLING: PHFs prepared from ingredients at ambient temperature cooled to 41F within 4 hours. 20 REHEATING: PHFs rapidly reheated (within 2 hours) in proper facilities to at least 165F; or commercially processed PHFs heated to at least 135F prior to hot holding 21 HOT HOLDING: PHFs Hot Held at 135F or above in appropriate equipment. 22 TIME as a PUBLIC HEALTH CONTROL: Approval; written procedures; time marked; discarded in 4 hours. 23 SPECIALIZED PROCESSING METHODS: Approval; written procedures; conducted properly. 24 HIGHLY SUSCEPTIBLE POPULATIONS: Pasteurized foods used; prohibited foods not offered. **** SAFE FOOD & WATER/PROTOACTION FROM CONTAMINATION **** 25 Hot and cold water available; adequate pressure. 26 Food properly labeled, original container. 27 Food protected from potentially contamination during preparation, storage, display. 28 Utensils, spatulas, tongs, forks, disposable gloves provided & used to restrict bare hand contact. FOODBORNE ILLNESS RISK FACTORS AND INTERVENTIONS
29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 Raw fruits & vegetables washed prior to serving. Wiping cloths properly used and stored. Toxic substances properly identified, stored and used. Presence of insects/rodents minimized; outer openings protected, animals are allowed. Personal cleanliness (fingernails, jewelry, outer clothing, hair restraint). **** FOOD TEMPERATURE CONTROL **** Food temperature measuring devices provided and calibrated. Thin-probed temperature measuring device provided for monitoring thin foods (i.e. meat patties and fish fillets). Frozen foods maintained completely frozen. Frozen foods properly thawed. Plant food for hot hot holding properly cooked to at least 135F. Methods for rapidly cooling PHFs are properly conducted and equipment is adequate. **** EQUIPMENT, UTENSILS & LINENS **** Materials, construction, repair, design, capacity; location, installation, maintenance. Equipment temperature measuring devices provided (refrigeration units, etc). In-use utensils properly stored. Utensils, single service items, equipment, linens properly stored, dried and handled. Food and non-food contact surfaces properly constructed, cleanable, used. Proper warewashing facilities installed, maintained, cleaned, used; sanitizer test strips available, used. **** PHYSICAL FACILITIES **** Plumbing system properly installed; safe and in good repair; no potential backflow or back siphonage conditions. Sewage & waste water properly disposed. Toilet facilities are adequate, properly constructed, properly maintained, supplied and cleaned. Design, construction, installation & maintenance proper. Adequate ventilation; lighting; designated areas used. Premises maintained free of litter, unnecessary articles, cleaning and maintenance equipment properly stored; and garbage and refuse properly maintained. All required signs (handwashing, inspection placard, etc) provided and conspicuously posted. IN OUT RV NO NA COS
Item # NJAC 8:24 REMARKS **Kitchen #1 2.1(b) PIC shall demonstrate knowledge. The Person in Charge did not demonstrate adequate knowledge of the NJ Food Code. #4 2.3(f) When hands must be washed 2.3f Food employee did not follow proper handwash procedures. Food employee did not wash his hands after removing single use gloves after coming from outside kitchen area. #5 2.3 (c) How hands must be washed 2.3c Food Employee did not follow proper handwashing procedure. Soap and/or warm water not used. Employee rinsed his hands in the three compartment sink and dried them with a paper towel. #6 2.3 (g) Where to wash hands 2.3g A food employee was observed washing their hands at the three compartment sink, rather than the designated handwash sink. #7 6.7(i) Supplied with soap 6.7i Soap was not available at the handwash sink #14 4.9(k) Temperature range for hot water @ the dishwasher manifold. Final rinse solution of conveyor type, dual temperature dishwasher did not reach 180 F as indicated by Thermo Label. Dishwasher must be serviced, and employees must utilize the three compartment sink in the meantime. #21 3.5(f)1 hot PHFs maintained at 135 F 3.5f1 Cooked fried chicken was held at 125 degrees F rather than 135 degrees F or above as required. Food was not held in proper hot holding equipment. This food product was reheated by food handler. All hot food products must be held in a hot holding unit and maintained at 135 F or above #21 3.5(f)1 hot PHFs maintained at 135 F 3.5f1 Beef chili was held at 125 degrees F rather than 135 degrees F or above as required. Chili was stored in a deep stainless steel container. Bottom of product was measured at a temperature of 145 F. These types of food products must be placed in shallow containers in order to achieve a more even distribution of temperature. #37 3.5(c) methods of Defrosting 3.5c Bags of frozen scallops were observed being thawed in containers of standing water. When this method is utilize, frozen food products must be thawed under cold running water. #45 4.8(k) Test kit required Sanitizer test strips not present at three compartment sink. #35 Thin-probed temperature measuring devices for monitoring thin foods (ie.) Meat patties and fish
fillets) Not provided #42 3.3(k) Storage during pauses in food preparation 3.3k Ice scoop located in the ice bin stored with food contact surfaces exposed to hand contact when retrieved for service. Scoop must be stored with handle above top surface of ice, or in a separate, clean location. #30 3.3(m) Wiping cloth use requirement 3.3m Moist wiping clothes observed lying on food prep surfaces and not stored in sanitizing solution. #41 4.2(c)5 Ambient air thermometers Several refrigeration units are not provided with a temperature measuring device #43 4.11(f) Utensils handled and dispensed improperly 4.11f Clean utensils in containers were observed being stored in a manner that hand contact cannot be avoided with the mouth / lip surface of the utensil. Food contact utensils must be stored so that only the handles are contacted by employees. #42 3.3(k) Storage during pauses in food preparation 3.3k Knives stored between table edges which are not easily cleaned and sanitized. Food contact utensils must be stored in a clean location #43 4.11(e) Storage requirements Dishes stored on shelves were not covered, wrapped inverted or otherwise protected from contamination. #27 3.3(z) Other Sources of Contamination Food products such as fried chicken, chili and sauces were stored in uncovered containers. All food products must be protected from environmental sources of contamination. #49 6.5(a) Facilities Wall and ceiling above dishwasher have an accumulation of black residue as well as peeling paint. These areas must be made non-absorbent, smooth and easily cleanable. #49 6.1(a) Indoor Surface Characteristics Cardboard was observed on floor near three compartment sink. Cardboard is an absorbent material and must not be utilized as a floor covering. #49 6.2(i) Protective shielding for light bulbs 6.2i Lights are not shielded from breakage to prevent broken glass particles from contaminating exposed food/food contact surfaces. #32 6.2(n) Outer Openings, Protected 6.2n Exit doors in the kitchen area do not protect against the entry of insects, rodents, and other animals. Several gaps are present between door frame and door, exposing kitchen to outdoors. These areas must
be repaired. **Wait station #43 4.11(f) Utensils handled and dispensed improperly 4.11f Clean utensils in containers were observed being stored in a manner that hand contact cannot be avoided with the mouth / lip surface of the utensil. Food contact utensils must be stored so that only the handles are contacted by employees. **Basement #44 4.6(c) Non-food contact surfaces shall be clean Black residue was observed on the surface of freezer door. This area must be cleaned often enough to prevent this occurrence.