UP WALL / CLOSET AN COIL CONDITIONERS ENGINEERING GUIDE Models: YCW, YCWE and YCW-HW Standard unit shown (Closet application - ront Return Air) Unit shown with louvered wall panel (Recessed wall application) 77VIP
Table of Contents Description............................. Nomenclature........................... General Description...................... YCW Series Wall / Closet an Coils......... YCWE Series Wall / Closet an Coils........ YCW-HW Series Wall / Closet an Coils...... Accessories............................7 Valve Packages.........................8 Description YORK UP / WALL CLOSET AN COIL S YCW YCW -Pipe Chilled Water Cooling The YCW series fan coil is designed as an upflow indoor air handler with a chilled water coil for cooling. The unit to the left is shown with the bottom return air kit for bottom return air in a closet application. (-17 ) YCWE YCWE -Pipe with Electric Heat The YCWE series fan coil is designed as an upflow indoor air handler with a chilled water coil for cooling, and electric heat. The unit to the left is the standard unit shown with front return air for closet application. (19-11 Chilled Water Cooling) (Up to 1kW Electric Heat) YCW-HW YCW-HW -Pipe Chilled Water Hot Water The YCW-HW series fan coil is designed as an upflow indoor air handler with a chilled water coil for cooling and hot water coil for heating. (19-18 ) YORK INTERNATIONAL
Nomenclature NOM. (1 s),, 8, 1 YORK Y CW - X - 1 Unit Voltage 1-1V - 1 Ph - Hz - 8/V - 1 Ph - Hz YCW - Upfl ow Wall / Closet (Cooling) YCWE - Upfl ow Wall / Closet (Electric Heat) YCW-HW - Upfl ow Wall / Closet (Hot Water) or YCWE units only. X is the kw of heat available. Refer to page for additional details. General Description The YCW Series units can be installed on a closet platform, hung on a closet wall, or recessed in a wall between the studs. All models are " wide to allow standard stud spacing for all sizes. The cabinet is made of embossed galvanized steel and is fully insulated. The condensate pan is sloped to ensure proper drainage. or installation flexibility, drain piping can come from the bottom, front, left, or right side of the cabinet. The YCW series units come factory equipped with a control board that allows a V control signal from a YORK or rd party thermostat to select low, medium, or high fan speed. Three compatible -speed thermostats are available from YORK: manual changeover (#T), auto changeover (#T1), and the all new "Autospeed V" (#T). The T Autospeed V provides maximum comfort and efficiency by automatically varying the fan speed between High, Medium, and Low speeds, depending on room temperature and desired thermostat setting. Optional Accessories: See Page 7 Standard eatures: 1V motor*, V -speed fan control 1/V -speed control board (/V for YCWE) Electrical service pullout (YCW & YCWE only) Non-corrosive thermoplastic drain pan, sloped for positive drainage Separate compartment for drain connections (allows the use of PVC drain piping) Drain pan has female primary and secondary fittings Easily accessible 1" filter Various optional factory installed valve packages Coil connections stub out top of unit YCWE Models: Have V motors and factory installed electric heat /V -speed control board YCW-HW Models: Chilled water coil for cooling and hot water coil for heating *YCW models with other motor voltages may be available. (Contact factory) YORK INTERNATIONAL
YCW Series Wall / Closet an Coils -Pipe Chilled Water Cooling COOLING CAPACITY YCW YCW 8YCW 1YCW 1.. 9.. 1. 18.7 11. DEGREE ENTERING WATER DEGREE ENTERING WATER 8 D.B. / 7 W.B. 7 D.B. / W.B. 8 D.B. / 7 W.B. 7 D.B. / W.B. TH SH TR TH SH TR TH SH TR TH SH TR 9.7 1. 1.1 17. 1.. 9. 1. 1.1 1.8 1. 17.1 1...9 1. 1 7.1 8.9 1. 1.7. 1.7.8 1 1 1. 19. 1. 7...9.... 1.7 9.8 1.1 1. 1. 1.1 1. 1.7.8..7.8.8 9.1. 17. 18.1 18...1 8.1 8. 1. 7. 1.9. 1. 1. 7. 1. 1.8 1...8 1.1 19..9 8.7....1 HEATING CAPACITY YCW YCW 8YCW 1YCW 1 1... 1.....1 7.1 1.7....9 18. 1.8.7 8... 7 8 1 1 1 19 1 1 1 18 1 HEATING DATA (7 ENTERING ) 1 1..7.1 9. 1. 9.7 17 1 1 1 11 1 17 19 19 1 1 1. 1..7 8..8.1 8. 9.8. 9.8 1.9 18 11 117 11 118 11 11 11 11 11 118 1 11.8 1.7 1 1.... 7.1 97 1 1 9 11 1 1 1 1 11 1 1 1. Above capacities are at nominal conditions. Maximum discharge air temperature must not exceed at actual. BER DATA H.P. (1V) AMPS YCW 1/.1 YCW 1/.1 8YCW 1/. 1YCW 1/. SPEED MED. MED. VS. EXTERNAL STATIC PRESSURE..1...... 8 1 8 71 8 17 87 7 7 8 7 8 8 8 1 9 8 8 8 8 9 7 7 8 7 7 1 8 8 8 7 77 98 8 7 7 7 9 1 7 9 78 71 1 9 7 Low Voltage High Voltage Disconnect Supply and Return Chilled Water Lines Optional Overflow Switch OPENING WITH COVER REMOVED: -/8 X 1 E D Drain Knockouts (Both Sides) C PHYSICAL DIMENSIONS 1.7 A B C D E 1. Coil connections are sweat and stub out top of unit ILTER SIZE CHILLED WATER COIL CONNECTIONS - 1YCW -1/8-1/8 1 1-1/ -/8 18 X 18 /8 O.D. A B YORK INTERNATIONAL
YCWE Series Wall / Closet an Coils -Pipe Chilled Water with Electric Heat COOLING CAPACITY YCWE YCWE 8YCWE 1YCWE 1.. 9.. 1. 18.7 11. DEGREE ENTERING WATER DEGREE ENTERING WATER 8 D.B. / 7 W.B. 7 D.B. / W.B. 8 D.B. / 7 W.B. 7 D.B. / W.B. TH SH TR TH SH TR TH SH TR TH SH TR 9.7 1. 1.1 17. 1.. 9. 1. 1.1 1.8 1. 17.1 1...9 1. 1 7.1 8.9 1. 1.7. 1.7.8 1 1 1. 19. 1. 7...9.... 1.7 9.8 1.1 1. 1. 1.1 1. 1.7.8..7.8.8 9.1. 17. 18.1 18...1 8.1 8. 1. 7. 1.9. 1. 1. 7. 1. 1.8 1...8 1.1 19..9 8.7....1 BER DATA H.P. (V) YCWE 1/ YCWE 1/ 8YCWE 1/ 1YCWE 1/ SPEED MED. MED. VS. EXTERNAL STATIC PRESSURE..1...... 9 1 1 7 8 7 9 11 91 7 7 8 8 11 9 7 8 7 9 8 8 17 88 71 8 1 7 8 7 78 8 9 1 1 7 1 8 8 9 19 8 7 97 81 7 9 79 In keeping with its policy of continuous progress and product improvement, YORK reserves the right to make changes without notice. ELECTRICAL DATA YCWE 1 ELECTRIC HEAT CAPACITY KW TOTAL AMPS MIN. CIR. AMPACITY MAX. OVERCURRENT PROTECTION V 8V V 8V V 8V V 8V V 8V 1.8.. 1 1 1 7 1 1.1. 9. 1. 1.7 8. 11.9 7 1 17 11 Low Voltage High Voltage E D YCWE 8YCWE 8 8...8...8 1 1 1 1 1 1 1 7 1 1 7 1 1 1.1 9. 1. 1 1.9.1 1.7 1. 18. 8. 11.9.7 1 1.1.. 1 17 8 18 9 11 9 1 1 9 Disconnect Supply and Return Chilled Water Lines Optional Overflow Switch OPENING WITH COVER REMOVED: -/8 X 1 Drain Knockouts (Both Sides) C 1YCWE 8 1 8 1..8 1 1 1 7 1.7. 7.7..7. 19 17 1 9 1.7 PHYSICAL DIMENSIONS A B C D E ILTER SIZE CHILLED WATER COIL CONNECTIONS - 1YCWE -1/8-1/8 1 1-1/ -/8 18 X 18 /8 O.D. A B 1. Coil connections are sweat and stub out top of unit YORK INTERNATIONAL
YCW-HW Series Wall / Closet an Coils -Pipe Chilled Water - Hot Water COOLING CAPACITY YCW-HW YCW-HW 8YCW-HW 1YCW-HW 1.. 9.. 1. 18.7 11. DEGREE ENTERING WATER DEGREE ENTERING WATER 8 D.B. / 7 W.B. 7 D.B. / W.B. 8 D.B. / 7 W.B. 7 D.B. / W.B. TH SH TR TH SH TR TH SH TR TH SH TR 9.7 1. 1.1 17. 1.. 9. 1. 1.1 1.8 1. 17.1 1...9 1. 1 7.1 8.9 1. 1.7. 1.7.8 1 1 1. 19. 1. 7...9.... 1.7 9.8 1.1 1. 1. 1.1 1. 1.7.8..7.8.8 9.1. 17. 18.1 18...1 8.1 8. 1. 7. 1.9. 1. 1. 7. 1. 1.8 1...8 1.1 19..9 8.7....1 HEATING CAPACITY YCW-HW YCW-HW 8YCW-HW 1YCW-HW 1.. 1. 1. 1 1 18...9.. 9.. 19 17 1 19 17 11 1 1 18 1 HEATING DATA (7 ENTERING ) 1. 7....8 1.. 17 1 1 18 1 1 1 117 1 1. 7. 9.1.1.7. 9.8.9 11 11 18 11 1 18 11 111 17 18 1 1..1 1 1.8..8. 8. 1 17 97 1 1 97 99 99 9 9 97 BER DATA H.P. (1V) AMPS YCW-HW 1/ 1.1 YCW-HW 1/.9 8YCW-HW 1/.8 1YCW-HW 1/ SPEED VS. EXTERNAL STATIC PRESSURE..1...... 8 9 7 89 7 7 18 91 7 7 8 8 71 8 87 1 89 7 8 8 8 17 87 7 8 7 1 8 1 99 8 9 8 1 1 9 78 1 97 8 8 7 19 9 9 7 7 9 7 1 9 9 78 Low Voltage High Voltage Hot Water Return Hot Water Supply Supply and Return Chilled Water Lines E D C PHYSICAL DIMENSIONS A B C D E ILTER SIZE CW AND HW COIL CONNECTIONS - 1YCW-HW -1/8-1/8 18 1-1/ -/8 18 X 18 /8 O.D. Optional Overflow Switch OPENING WITH COVER REMOVED: -/8 X 1 Drain Knockouts (Both Sides) 1.7 1. Coil connections are sweat and stub out top of unit A B YORK INTERNATIONAL
Accessories OPTIONAL ACCESSORIES (IELD INSTALLED) DESCRIPTION PART # DIMENSIONS WALL PANEL (1) 9-/8 X -/8 -/8 X -/8 9PWUCL (Outside rame) (Inside rame) HANGER BRKT. SET 9PK 1-1/ X -1/8 RETURN COVER 9PK 1-/8 X CONDENSATE OVER SWITCH SS WALL -SPD., MANUAL CHANGEOVER WALL -SPD., AUTO CHANGEOVER V WALL -SPD., MANUAL CHANGEOVER (AUTOSPEED V) T (1//77) T1 (1//77) T (V) Optional wall panel (Recessed wall application) T - T1 Unit shown with optional bottom return air kit (#9PK) T "AUTOSPEED V TM " See orm 1.-S1 for more details. Condensate drain connections (With drain cover removed) (Thermoplastic pan shown) YORK INTERNATIONAL 7
Valve Packages (Unit shown with an optional valve package) OPTIONAL VALVE CLUSTERS (actory installed) PART # DESCRIPTION VALVE CLUSTER 9VCWNV-M No valves, stub kit only 9VCWBV-M hand valves 9VCWB-M -way, valve body, hand valves 9VCWB-M -way, valve body, hand valves POWER HEAD (one required for each valve cluster) 911-111 V All models are available without valves or with factory installed valve clusters. Above are "standard" -way and -way valve clusters. Contact the factory for other options such as circuit setters, strainers, auto-fl ow valves, etc. P.O. Box 9, York, Pennsylvania USA 17-9 Johnson Controls, Inc. orm 1.-EG (1) Supersedes: 1.-EG () Tele. -81-11 www.york.com Subject to change without notice. Printed in USA ALL RIGHTS RESERVED