Breville Customer Service Centre Australian Customers Mail: PO Box 22 Botany NSW 2019 AUSTRALIA Phone: 1300 139 798 Fax: (02) 9384 9601 Email: Customer Service: askus@breville.com.au New Zealand Customers Mail: Private Bag 94411 Botany Manukau 2163 Auckland NEW ZEALAND Phone: 0800 273 845 Fax: 0800 288 513 Email: Customer Service: askus@breville.com.au www.breville.com.au Breville is a registered trademark of Breville Pty. Ltd. A.B.N. 98 000 092 928. Copyright Breville Pty. Ltd. 2012. Due to continued product improvement, the products illustrated/photographed in this brochure may vary slightly from the actual product. BJS600 Issue - A12
the Juice Fountain Crush Instruction Booklet BJS600
CONGRATULATIONS on the purchase of your Breville Product
Contents 4 Breville recommends safety first 6 Know your Breville product 8 Assembling your Breville product 12 Operating your Breville product 15 Disassembling your Breville product 17 Care & cleaning 19 Troubleshooting 23 Recipes 3
Breville recommends safety first At Breville we are very safety conscious. We design and manufacture consumer products with the safety of you, our valued customer, foremost in mind. In addition we ask that you exercise a degree of care when using any electrical appliance and adhere to the following precautions. Important safeguards Read all instructions BEFORE USE AND SAVE FOR FUTURE REFERENCE Carefully read all instructions before operating the appliance for the first time and save for future reference. Remove and safely discard any packaging materials and promotional labels before using the appliance for the first time. To eliminate a choking hazard for young children, remove and safely discard the protective cover fitted to the power plug of this appliance. To protect against electrical shock, do not immerse the power cord, power plug or motor base in water or any other liquid. Always use the appliance on a dry, level surface. Do not use the appliance on a sink drain board. Do not place the appliance near the edge of a bench or table during operation. Vibration during operation may cause the appliance to move. Do not place the appliance on or near a hot gas or electric burner, or where it could touch any other source of heat. Unwind the power cord fully before use. Do not allow the power cord to hang over the edge of a table or counter, touch hot surfaces or become knotted. Always ensure the appliance is completely assembled before connecting to the power outlet and operating. The appliance will not turn on unless properly assembled. Follow the instructions provided in this book. Always avoid contact with moving parts. Strictly follow the care and cleaning instructions described in this book. This appliance is for household use only. Do not use the appliance for anything other than its intended purpose as described in this book. Do not use outdoors. Do not use in moving vehicles or boats. The use of attachments not sold or recommended by Breville may cause fire, electric shock or injury. Do not leave the appliance unattended when in use. Do not operate the juice extractor without the pulp and juice container in place. Do not use the juice extractor if the juicing screw is damaged. Do not push produce into the feed chute with your fingers. Always use the food pusher provided. Do not juice stone fruit unless seeds and/or stones have been removed. Always switch the juice extractor off after each use. Ensure the motor stops completely and unplug the power cord from the wall outlet before attempting to move the appliance, before cleaning, disassembling, assembling and when storing the appliance. Do not operate the machine longer than 20 seconds before inserting ingredients. 4
Breville recommends safety first IMPORTANT SAFEGUARDS FOR ALL ELECTRICAL APPLIANCES Fully unwind the power cord before use. Do not let the power cord hang over the edge of a bench or table, touch hot surfaces or become knotted. To protect against electric shock do not immerse the power cord, power plug or appliance in water or any other liquid. The appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety. Children should be supervised to ensure that they do not play with the appliance. It is recommended to regularly inspect the appliance. To avoid a hazard do not use the appliance if power cord, power plug or appliance becomes damaged in any way. Return the entire appliance to the nearest authorised Breville Service Centre for examination and/or repair. Any maintenance other than cleaning should be performed at an authorised Breville Service Centre. This appliance is for household use only. Do not use this appliance for anything other than its intended use. Do not use in moving vehicles or boats. Do not use outdoors. Misuse may cause injury. The installation of a residual current device (safety switch) is recommended to provide additional safety protection when using electrical appliances. It is advisable that a safety switch with a rated residual operating current not exceeding 30mA be installed in the electrical circuit supplying the appliance. See your electrician for professional advice. SAVE THESE INSTRUCTIONS 5
KNOW your Breville Product
KNOW your Breville PRODUCT A B J F I H G C. D. E. K. A. Food Pusher B. Hopper And Lid C. Juicing Screw D. Filter Basket E. Scraper Wiper F. Pulp Container G. Motor Base H. Juicing Jug I. ON OFF REVERSE J. Juicing Bowl K. Filter Cleaning Brush 7
ASSEMBLING your Breville Product
assembling your Breville PRODUCT Before first use Before using the juice extractor for the first time, remove and safely discard any packaging material and promotional labels. Ensure the power cord is unplugged from the wall outlet. Wipe the motor base with a damp cloth. Dry thoroughly. Wash the juicing bowl, filter basket, juicer cover, food pusher, juice jug and pulp container in warm soapy water with a soft cloth or nylon brush. Rinse and dry thoroughly. 4. Assemble the filter basket into the scraper wiper then place this assembly in to the juicing bowl. NOTE These parts are not dishwasher safe. 1. Place the motor base on a flat dry surface such as a counter-top. Ensure the power cord is unplugged from the wall outlet. 2. Underneath the filter bowl is the pulp extraction silicon, which is used to remove the pulp from the spout of the juicing bowl. Ensure that the silicon is firmly inserted into the juicing spout. 5. Note that the orange dot on the filter needs to align with the orange dot on the juicing bowl and motor base. Ensure that the filter basket is completely pushed down. 3. Place the juicing bowl on top of the motor base. Align the arrows to the ALIGN position then turn slightly clockwise to the ALIGN/LOCK (closed) position. 9
assembling your Breville PRODUCT 6. Place the juicing screw into the filter basket. Ensure that the juicing screw is in position by pressing down on it, and feel it click into place. 8. Ensure that the hopper is placed on the feed chute. Place the food pusher into the hopper. 7. Place the lid on to the juicing bowl. Align the orange dot on the lid with the orange dot on the motor base and turn clockwise to the closed position. The lid will click into position. 9. Place the pulp container supplied into position by tilting slightly and placing under the pulp spout. NOTE To minimize clean up, place a produce bag into the pulp container to collect the pulp. 10
assembling your Breville PRODUCT 10. Place the juice jug under the juicer spout; ensure that it is placed in position under the spout. 11
OPERATING your Breville Product
Operating your Breville PRODUCT Operating the breville juice fountain crush 1. Wash and prepare your selection of fruit and/or vegetables: Fruits with hard or inedible skins such as citrus fruit and melons should be peeled before juicing. Pineapple can be juiced with or without the rind removed. Fruits with pits, hard seeds or stones such as nectarines, peaches, mangoes, apricots, plums and cherries must be pitted before juicing. 2. Ensure the juice extractor is correctly assembled with the juice jug and pulp container is under the spout. NOTE As a safety precaution, the juicer will not operate if it has not been assembled correctly. 3. Plug the power cord into a 230/240V power outlet. 4. Cut fruit and vegetables into pieces that will fit down the feed chute. NOTE As a guide, apples should be cut in to quarters. 5. Push the ON button. 6. With the motor running gently guide food down the feed chute. To extract the maximum amount of juice, always push the food pusher down slowly. NOTE Do not exert excess pressure, the fruit or vegetable should almost be pulled down by the screw. NOTE If the fruit or vegetables become jammed in the screw and the juicer stops operating press the OFF button to the center. Ensure that the juicer comes to a complete stop. Press the REVERSE button and hold it until the fruit or vegetables become dislodged. NOTE The screw will move in reverse and release the food that is caught in the screw. Once the food is released, press the ON button and start juicing again. IMPORTANT Do not load the feed chute with food until the motor is running. 13
Operating your Breville PRODUCT 7. As the fruits and vegetables are processed, juice will flow into the juice jug and the separated pulp will accumulate in the pulp container. NOTE The pulp container can be emptied during juicing by turning the juicer to the off position and removing the pulp container. Replace the empty pulp container into position before continuing to juice. Overload protection This protection device safeguards against overloading the motor with excessive loads. If overloading occurs, the motor will stop. The overload protection will automatically de-activate the motor. When this occurs, unplug the power cord from the wall outlet and allow the appliance to cool for at least 1 hour. Then reconnect the power cord to the wall outlet. Then recommence normal use. WARNING Do not operate juicer longer than 20 seconds before inserting ingredients. 8. Immediately after use, slowly pour a glass of water down the feed chute. Ensure that there is a separate jug under the spout as the water will pour directly into the juice jug that you juiced into. This is a cleaning aspect and will help when cleaning the filter basket. NOTE If you are making different fruit juices you can pour a glass of water (about 6oz) in between the different juices to rinse any left over flavors. It is not always necessary to completely clean the juicer in between making multiple juices. 14
PAge header DISASSEMBLING your Breville Product 15
Disassembling your Breville PRODUCT 1. Ensure the juicer is turned off and the power cord is unplugged from the power outlet. 2. Remove the pulp container and juicing jug. 3. Remove the lid by turning it to the open position (anti-clockwise). WARNING The juicing screw is a heavy object. Take care when removing the juicing screw. Be careful not to drop the juicing screw. 4. The juice bowl, scraper wiper, filter basket and juicing screw can all be removed together. Grip the juice bowl and turn to the open position (anti-clockwise) slightly, it will click out of position. This is a very small movement. The juicing bowl and all the internals can now be lifted off the motor base for cleaning. 16
PAge header CARE & CLEANING
care & CLEANING Always ensure that the juicer is turned off and the power cord is unplugged from the power outlet before cleaning, disassembling or assembling and storing the appliance. 1. Immediately after each use, use the provided nylon brush to thoroughly clean the fine mesh holes of the filter basket. Brush the inside of the filter basket under running water, holding it up towards the light to ensure the fine mesh holes are not blocked. 2. Use the filter brush provided with the juicer. This brush has been specially designed to clean the filter basket. Simply place the filter basket inside the brush and under running water twist the brush left and right to remove the pulp from the filter basket. You will need to use the small brush provided to clean the inside of the filter basket, this should also be done under running water. TIP If the filter basket cannot be cleaned immediately after use, soak the filter basket in hot soapy water immediately after juicing is complete. If pulp is left to dry on the filter basket, it may clog the fine mesh holes, thereby lessening the effectiveness of the juicer. Do not soak the filter basket in bleach. 3. Wash the juice bowl, scraper wiper, juicing screw, pulp container and juicing jug in warm soapy water with the small nylon brush provided or a soft cloth. Rinse and dry thoroughly. NOTE Do not place any part of the juicer in the dishwasher. If the holes are blocked, soak the filter basket in hot water with 10% lemon juice to loosen the blocked holes. TIP Discoloration of the plastic parts may occur with brightly colored fruit and vegetables. To help prevent this, wash parts immediately after use. If discoloration does occur, the plastic parts can be soaked in 10% lemon juice and water or they can be cleaned with a non abrasive cleaner. Do not soak the filter basket in bleach. Do not soak the motor base. 4. Wipe the motor base with a soft damp cloth and dry thoroughly. Do not use abrasive scouring pads or cleaners when cleaning the motor base as these may scratch the surface. Wipe any excess food particles from the power cord. 18
PAge header TROUBLESHOOTING
TROUBLESHOOTING POSSIBLE PROBLEM Juicer will not work or suddenly turns off during juicing Motor appears to stall when juicing Reduced juice extraction EASY SOLUTION Check that the power plug is securely inserted into wall outlet. Insert the power plug into an independent outlet. Insert the power plug into a different outlet. Ensure the juicer is assembled correctly. The Overload Protection may have automatically deactivated the motor. Unplug the power cord from the wall outlet and allow the appliance to cool for at least 1 hour. Insufficient cooling time may result in the motor de-activating again. After sufficient cooling time, reconnect the power cord to the wall outlet and recommence normal use. Either too much food is being processed at one time or the pieces are not small enough. Try trimming food, cutting food into smaller pieces of even size and/or processing a smaller amount per batch. Ensure the motor is running before loading the feed chute with food. Also try the reversing method to unstuck the screw. Hard fruits and vegetables will put excess strain onto the motor. Stop the juicing process and remove the power cord from the wall outlet. Use the nylon brush provided to thoroughly clean the fine mesh holes of the Filter Basket. Brush the inside of the Filter Basket under running water, holding it up towards a light to ensure the fine mesh holes are not blocked. If the holes are blocked, soak the Filter Basket in hot water with 10% lemon juice to loosen the blocked holes. Cleaning the Filter Basket will remove excess fiber build up (from juicing the fruit or vegetables) which could be inhibiting the juice flow. 20
PAge TROUBLESHOOTING header POSSIBLE PROBLEM Pulp too wet and reduced extracted juice Juice leaks between the rim of the Juicer Cover EASY SOLUTION Try a slower juicing action. Remove juice disc and thoroughly clean mesh walls with a cleaning brush. Rinse the juice disc under hot water. If the fine mesh holes are blocked, soak the basket in a solution of hot water with 10% lemon juice to unblock the holes or wash in the dishwasher. This will remove excess fibre build up (from fruit or vegetables) which could be inhibiting the juice flow. Try a slower juicing speed and push the food pusher down the feed chute more slowly. 21
PAge TROUBLESHOOTING header PURCHASING AND STORAGE OF FRUIT AND VEGETABLES Always wash fruit and vegetables before juicing. Always use fresh fruit and vegetables for juicing. To save money and obtain fresher produce, purchase fruit or vegetables that are in season. Keep your fruit and vegetables ready for juicing by washing them before storing. Most fruits and hardier type vegetables can be stored at room temperature. The more delicate and perishable items such as berries, leafy greens, celery, cucumbers and herbs should be stored in the refrigerator until required. PREPARATION OF FRUIT AND VEGETABLES FOR JUICING If using fruits with hard or inedible skins such as mangoes, citrus, melons and pineapples, always peel before juicing. Some vegetables, such as cucumbers, can be processed un-peeled depending on the softness of the skin and the juicing requirements. All fruits with large pits, hard seeds or stones such as nectarines, peaches, mangoes, apricots, plums and cherries must be pitted before juicing. Ensure vegetables such as beetroots, carrots etc have all soil removed, are washed well and trimmed of leaves before juicing. Citrus fruits can be juiced in the juicer but remove the skin and excess pith before juicing. A small amount of lemon juice can be added to apple juice to reduce discoloration. 22
RECIPES
PAge RECIPES header ORANGE, BROCCOLI & CARROT 3 oranges (750g), peeled and segmented 2 cups (150g) broccoli florets and stems 2-3 medium carrots(280g), cut into quarters POMEGRANATE, BEETROOT & ORANGE 1 pomegranate (360g), skin and white pith removed Or 1 ¼ cups pomegranate seeds 1 medium (230g) beet, scrubbed and cut into pieces 3 oranges (750g), peeled and segmented CARROT, CELERY, PEAR & BEETROOT 2-3 medium (280g) carrots, cut into quarters 1 trimmed (100g) celery stalk 1 medium (230g) pear, cut into quarters 1 medium (230g) beetroot, scrubbed and cut into pieces TOMATO, CELERY & CARROT 1 pint (250g) cherry tomatoes or 3 small tomatoes 1 trimmed (100g) celery stalk 2-3 medium (280g) carrots, cut into quarters BEETROOT, ORANGE & GINGER 1 medium (230g) beet, scrubbed and cut into pieces 3 oranges (750g), peeled and segmented 1 inch (2cm) piece of fresh ginger GRAPES, PEAR & CUCUMBER 2 cups (184g) grapes 1 large (330g) pear, cut into quarters 1 (160g) Lebanese cucumber, quartered 24
PAge RECIPES header PINEAPPLE, MINT & APPLE 1 ¾ cup (300g) pineapple, skin removed, roughly chopped 2-3 sprigs mint 2 medium (300g) green apples, cut into pieces CUCUMBER, CARROT, LEMON & MINT 2 (320g) Lebanese cucumbers, quartered 2-3 medium (280g) carrots, cut into quarters ½ lemon, skin and white pith removed 2-3 sprigs mint CARROT, APPLE & BEETROOT 2-3 medium (280g) carrots, cut into quarters 2 medium (300g) green apples, cut into pieces 1 small (100g) beet, scrubbed and cut into pieces CARROT, CELERY, PARSLEY & GINGER 3 medium (360g) carrots, cut into quarters 2 trimmed (200g) celery stalks 2-3 sprigs flat leaf parsley 1 inch (2cm) piece ginger TOMATO, CARROT & RED BELL PEPPER 1 small (150g) red bell pepper, trimmed, seeds removed 1 pint (250g) cherry tomatoes or 3 small tomatoes 3 medium (360g) carrots, cut into quarters 2-3 sprigs flat leaf parsley SWEET POTATO, CELERY, GINGER & ORANGE ½ (300g) sweet potato, peeled and roughly chopped 1 trimmed (100g) celery stalk 1 inch (2cm) piece fresh ginger 3 oranges (750g), peeled and segmented 25
Recipes TOMATO, CUCUMBER, PARSLEY AND CARROT 1 pint (250g) cherry tomatoes or 3 small tomatoes 1 (160g) Lebanese cucumber, quartered 2-3 sprigs flat leaf parsley 2-3 medium (280g) carrots, cut into quarters CELERY, TOMATO, CILANTRO, GREEN BELL PEPPER + GARLIC 4 trimmed (400g) celery stalks 2 medium (300g) tomatoes, roughly chopped 2 sprigs cilantro 1 medium (200g) green bell pepper, trimmed, seeds removed 1 clove garlic, peeled SWISS CHARD, KIWI + APPLE 3-4 Swiss Chard leaves, ribs removed 3 medium (255g) kiwi fruit, peeled, cut into quarters 1 medium (150g) green apple, cut into pieces CARROTS, BEETROOT, ORANGE + PEAR BROCCOLI, PARSLEY, APPLE and CELERY 6 cups (450g) broccoli florets and stems 3-4 sprigs flat leaf parsley 2 medium (300g) green apples, cut into pieces 1 trimmed (100g) celery stalk 2-3 medium (280g) carrots, cut into quarters 1 medium (230g) beetroot, scrubbed and cut into pieces 1 medium (240g) orange, peeled and segmented 1 medium (230g) pear, cut into quarters 26
Recipes ORANGE, GRAPEFRUIT + PAPAYA 2 medium (480g) oranges, peeled and segmented 1 small (350g) grapefruit, peeled and segmented 1 small (650g) papaya, seeds and skin removed, roughly chopped ORANGE AND BANANA ICE BLOCKS 3 oranges (750g), peeled and segmented 2 medium (400g) ripe bananas METHOD 1. Add bananas into slow juicer followed by oranges. 2. Stir juice to combine. Pour into ice cube tray mold and freeze until frozen. HONEYDEW, APPLE + MINT ¼ large (400g) honeydew melon, skin and seeds removed, roughly chopped 1 medium (150g) green apple, cut into pieces 2 sprigs mint WATERMELON + HONEY ICE BLOCKS 1 large 2.25lb (1kg) watermelon, skin removed, roughly chopped 1 tablespoon honey METHOD 1. Add watermelon into slow juicer. 2. Stir juice and honey to combine. Pour into ice cube tray mold and freeze until frozen. 27
Recipes GRAPE ICE BLOCKS 6 L cup (600g) red grapes, stem removed METHOD 1. Add grapes to slow juicer. 2. Stir juice and cream together. Pour into ice cube tray mold and freeze until frozen. Blueberry Ice cream Makes approximately 800ml 3 ¾ cups (600g) fresh or frozen blueberries 1 tablespoon honey ¼ cup (60ml) condensed milk ½ cup (125ml) cream ¼ cup (60ml) milk METHOD 1. Add grapes to slow juicer. If using frozen blueberries, thaw first. 2. Stir juice, condensed, cream and milk together. 3. Churn in an automatic ice cream maker until frozen. Honeydew Melon milk Ice Makes approximately 1 quart ¼ large (400g) honeydew melon, skin and seeds removed, roughly chopped ¼ cup (60ml) condensed milk ¾ cup (185ml) cream METHOD 1. Add honeydew to slow juicer. 2. Stir juice, condensed milk and cream and together. 3. Churn in an automatic ice cream maker until frozen. Pineapple and Mint Sorbet Makes approx 750ml 1 cup (250ml) water 1 cup (200g) granulated sugar 1 medium (1.25kg) pineapple, skin removed, roughly chopped 1 tablespoon finely shredded mint METHOD 1. Place the water and sugar in a small saucepan. Stir over a low heat until the sugar dissolves. Bring to a boil and cook for 2 minutes. Remove from heat. Refrigerate until cold. 2. Add pineapple to slow juicer. 3. Combine the sugar syrup, 2 ½ cups pineapple juice and shredded mint and stir to combine. 4. Churn in an automatic ice cream maker until frozen. 28
Recipes Green Apple gelato Makes approx 1 quart 3 small green apples ½ lemon, skin and white pith removed 1 cup (250ml) water 1 cup (200g) granulated sugar 2 3 cup (160ml) cream Green food coloring (optional) METHOD 1. Add apples and lemon to slow juicer. 2. Place the water, sugar, apple and lemon juice in a small saucepan. Stir over a low heat until the sugar dissolves. Bring to a boil and cook for 2 minutes. Remove from heat. 3. Strain mixture through a fine sieve. Refrigerate until cold. 4. Combine apple mixture and cream and stir to combine. 5. Churn in an automatic ice cream maker until frozen. 29
Notes 30
Notes 31