mtwfsusa.com Convotherm Combi Oven-Steamers Options & Accessories
Longevity, Cleanliness & Peace of Mind Racks & Racking Systems Free Service Start-Up ASA StartUp Convotherm authorized service agency to inspect installation, review cleaning and maintenance instructions, and start warranty protection Extended Labor Warranty CELW available for all models CLARIS Water Filters CWT-06 for all Combi's Includes: one Pre Filter one Claris Flow Meter one Claris X-Large Steam System one Water Test Kit Filter Accessories CWT-XLC Claris X-Large Filter Cartridge EC-110 Prefilter Replacement Cartridge KLEENSTEAM II Water Filters 9797-K2PF for all OEB & OGB series Combi's with a generator with inhibitor. Includes: one Pre Filter (9795-90) one SS10 ScaleStick Cartridge (9799-0201) two 7CB5 five micron carbonblock cartridges (9618-11) 9797-40 for all boilerless OES & OGS series Combi's. (Pre Filter not included, to add prefilter use Includes: part# 9795-90) two 7CB5 five micron carbonblock cartridges (9618-11) Filter Accessories 9799-0201 SS10 Replacement Cartridge (1 pk) replaces 9496-10 9799-02 SS10 Replacement Cartridge (12 per case) 9795-90 Pre Filter, filters out larger dirt and rust particles (20" clear housing) 9618-11 7CB5 Replacement Cartridge (1 pack) Water Quality Requirements for Convotherm COMBI S NOTE: The owner / operator / purchaser must ensure that the drinking/potable water quality requirements are met. Not meeting the water quality requirements will void the original equipment warranty. A water quality analysis is required prior to installing the water treatment system, since water conditions vary throughout the country. TDS 50-125 ppm ph Factor 7.0-8.5 Total Alkalinity 50-100 ppm Free Chlorine < 0.1 ppm Silica < 13 ppm Hardness 50-100 ppm (3<6 gpg) Chloride < 25 ppm Dynamic Water Pressure 35-80 psi ConvoClean Hands Free Built- In Automatic Washing System Includes Auto Wash Cleaning Kit (C-Start): one - 10 liter container of ConvoClean solution (C-CLEAN) one - 10 liter container of ConvoCare solution (C-CARE) set of connectors and hoses CACK ConvoClean cleaning system ConvoCARE Includes: two - 10 liter containers CCARE ConvoCARE Solution CCARE-C ConvoCARE Concentrate ConvoClean Includes: two - 10 liter containers CClean ConvoClean cleaning solution Pressure Spray Bottle CPSB2 Dissolve for manual cleaning with ConvoClean and ConvoRinse solutions (two spray bottles recommended) Includes: 6 - one gallon containers with quart markings 106174 boiler descaling solvent Storage Container CSC CSCD This option is built into the Combi when manufactured. stainless steel storage container for ConvoRinse and ConvoClean solutions, container can be wall-mounted Fiberglass molded dolly for storage container Wire Racks CWR10 CWR20 Pan Rack Adapters 12" x 20" rack for models 6.10 & 10.10 20" x 26" rack for models 6.20, 10.20, 12.20 & 20.20 (allows for 18" x 26" sheet pans to be used without wire racks) CUPR620 for model 6.20 (one rack) CUPR1020 for model 10.20 (one rack) CUPR2020 for model 20.20 (two racks) CUPR2020 for model 20.20 (two racks) Chicken Grill Racks CCGR10 CCGR20 Wire Baskets For fried like items such as french fries or chicken nuggets. CWB10 CWB20 12" x 20" rack for models 6.10, 10.10 12" x 20" rack for models 6.20, 10.20, 12.20 & 20.20 12" x 20" wire basket for all models 20" x 26" wire basket for models 6.20, 10.20, 12.20 & 20.20 ConvoGrill Racks For grilling meats - steaks, fish, chicken, etc. CGR10 13" x 18" grilling rack for all models
Stainless Steel Stands for Table-Top Models Stacking Kits for Table-Top Models Open Base Stand With Adjustable Legs CST10OB for models 6.10 & 10.10 CST20OB for models 6.20 & 10.20 With Casters CST10OBCA for models 6.10 & 10.10 CST20OBCA for models 6.20 & 10.20 Closed Base Stand with Hinged Doors With Adjustable Legs CST10CB for models 6.10 & 10.10 CST20CB for models 6.20 & 10.20 With Casters CST10CBCA for models 6.10 & 10.10 CST20CBCA for models 6.20 & 10.20 Rack Cassette for Equipment Stands CST10R for models 6.10 & 10.10 CST20R for models 6.20 & 10.20 Stacking Kits For Electric Models - with legs CSTKE610 for stacking two 6.10's CSTKE610620 for stacking one 6.10 on top of a 6.20 CSTKE1010 for stacking one 6.10 on top of a 10.10 CSTKE6101020 for stacking one 6.10 on CSTKE620 for stacking two 6.20's CSTKE1020 for stacking one 6.20 on For Electric Models - with casters CSTKE610CA for stacking two 6.10's CSTKE610620CA for stacking one 6.10 on top of a 6.20 CSTKE1010CA for stacking one 6.10 on top of a 10.10 CSTKE6101020 for stacking one 6.10 on CSTKE620CA for stacking two 6.20's CSTKE1020CA for stacking one 6.20 on For Gas Models - with legs CSTKG610 for or stacking two 6.10's CSTKG610620 for stacking one 6.10 on top of a 6.20 CSTKG1010 for stacking one 6.10 on top of a 10.10 CSTKG6101020 for stacking one 6.10 on CSTKG620 for stacking two 6.20's CSTKG1020 for stacking one 6.20 on For Gas Models - with casters CSTKG610CA for or stacking two 6.10's CSTKG610620CA for stacking one 6.10 on top of a 6.20 CSTKG1010CA for stacking one 6.10 on top of a 10.10 CSTKG6101020CA for stacking one 6.10 on CSTKG620CA for stacking two 6.20's CSTKG1020CA for stacking one 6.20 on Chicken Grill Racks Press & Go, one touch controls
Trolley Systems Table-Top Models Floor Models Roll-In Frame (for holding the shelf rack cassette or plate rack cassette in the combi compartment) Floor Model Roll-In Trolley System CRF10 for models 6.10 & 10.10 CRF20 for models 6.20 & 10.20 Cassette Transport Trolley (holds both the shelf rack cassette or plate rack cassette) Shelf Roll-In Trolley CSRT1220 for model 12.20 (has 12 pair of slide rails) CSRT2020 for model 20.20 (has 20 pair of slide rails) CCTT10 for models 6.10 & 10.10 CCTT20 for models 6.20 & 10.20 Shelf Rack Cassette (used in conjunction with the roll-in frame and the cassette transport trolley) Plate Roll-In Trolley Thermal Cover CSRC610 CSRC1010 CSRC620 CSRC1020 Plate Rack Cassette (used in conjunction with the roll-in frame and the cassette transport trolley) CPRC610 CPRC1010 CPRC620 CPRC1020 Thermal Cover (for plate rack cassette & shelf rack cassette) for model 6.10 (has 6 pair of slide rails) for model 10.10 (has 10 pair of slide rails) for model 6.20 (has 6 pair of slide rails) for model 10.20 (has 10 pair of slide rails) for model 6.10 (holds 20 plates) for model 10.10 (holds 32 plates) for model 6.20 (holds 42 plates) for model 10.20 (holds 63 plates) CTC610 for model 6.10 CTC1010 for model 10.10 CTC620 for model 6.20 CTC1020 for model 10.20 Plate Roll-In Trolley CPRT1220 CPRT2020 Thermal Cover for model 12.20 (holds 59 plates) for model 20.20 (holds 98 plates) (for shelf roll-in trolley and plate roll-in trolley) CTC1220 for model 12.20 CTC2020 for model 20.20
Options & Accessories Software & Networking Flanged Feet Interface Board CST4FF for table-top models - secures unit to a table or countertop CCONTROL CONVOControl software for HACCP and combi oven management. (One software license per PC.) Lockable Control Cover Recommended for correctional facilities. CPLC for all Convotherm models (except the Mini) Operating Software CICBOARD CONVOInterface communication board for Ethernet connections. (One board is required to be installed in each combi oven.) Preheat Bridge (allows for preheating of the cooking compartment when trolley is not in the unit) CICBOARD CICBOARD Ethernet cable(s) Not supplied by Cleveland CICBOARD Switch/Router (for connecting to multiple combi ovens) Not supplied by Cleveland CPHB20 for models 12.20 & 20.20 Disappearing Door Electrical Options CVOS3A for table type models - 460/480 volts, 60 cycle, 3 phase CVOS2A for floor models - 460/480 volts, 60 cycle, 3 phase Open the door... and push backwards along the side
Quick Reference Charts for Options & Accessories Floor Models Electric Units Gas Units ConvoClean OEB12.20 / OEB20.20 / OGB12.20 / OGB20.20 / OES12.20 OES20.20 OGS12.20 OGS20.20 Cleaning System CACK CACK ConvoCARE CCARE, CCARE-C CCARE, CCARE-C ConvoClean Solution CCLEAN CCLEAN Pressure Spray Bottle CPSB2 CPSB2 Descaling Solution DISSOLVE DISSOLVE Storage Container CSC CSC Water Filters KleenSteam II 9797-K2PF 9797-K2PF Claris CWT-06 CWT-06 Racks & Racking Systems Wire Racks, 12" x 20" CWR10 CWR10 Wire Racks, 18" x 26" CWR20 CWR20 Pan Racks Adapters CUPR1220 CUPR2020 CUPR1220 CUPR2020 Chicken Grill Racks 18" x 26" CCGR20 CCGR20 Wire Baskets, 12" x 20" CWB10 CWB10 Wire Baskets, 18" x 26" CWB20 CWB20 Grilling Racks 12" x 20" CGR10 CGR10 Trolley Systems Shelf Roll-In Trolley CSRT1220 CSRT2020 CSRT1220 CSRT2020 Plate Rack Roll-In Trolley CPRT1220 CPRT2020 CPRT1220 CPRT2020 Thermal Cover (for CSRT & CPRT) CTC1220 CTC2020 CTC1220 CTC2020 Software & Networking CONVOControl software CCONTROL CCONTROL Module for adding units to network CICBOARD CICBOARD Options & Accessories Lockable Control Covers CPLC1220 CPLC2020 CPLC1220 CPLC2020 460/480 volts, 60 cycle, 3 phase CVOS3A CVOS3A Preheat Bridge CPHB20 CPHB20
Table-Top Models ConvoClean Electric Units OEB6.10 / OEB10.10 / OEB6.20 / OEB10.20 / OGB6.10 / OGB10.10 / OGB6.20 / OGB10.20 / OES6.10 OES10.10 OES6.20 OES10.20 OGS6.10 OGS10.10 OGS6.20 OGS10.20 Cleaning System CACK CACK ConvoCARE CCARE, CCARE-C CCARE, CCARE-C ConvoClean Solution CCLEAN CCLEAN Pressure Spray Bottle CPSB2 CPSB2 Descaling Solution DISSOLVE DISSOLVE Storage Container CSC CSC Dolly for Storage Container CSCD CSCD Water Filters KleenSteam II KLEENSTEAM II KLEENSTEAM II Equipment Stands Open Base with Legs CST10OB CST20OB CST10OB CST20OB Open Base with Casters CST10OBCA CST20OBCA CST20OBCA CST20OBCA Closed Base with Doors and Legs CST10CB CST20CB CST10CB CST20CB Closed Base with Doors and Casters CST10CBCA CST20CBCA CST10CBCA CST20CBCA Pan Racks for Stands CST10R CST20R CST10R CST20R Racks & Racking Systems Wire Racks, 12" x 20" CWR10 CWR10 Wire Racks, 18" x 26" CWR20 CWR20 Pan Rack Adapters CUPR620 CUPR1020 CUPR620 CUPR1020 Chicken Grill Racks 12" x 20" CCGR10 CCGR10 Chicken Grill Racks 18" x 26" CCGR20 CCGR20 Wire Baskets, 12" x 20" CWB10 CWB10 Wire Baskets, 18" x 26" CWB20 CWB20 Grilling Racks 12" x 20" CGR10 CGR10 Stacking Kits For two 6.10s CSTKE610 CSTKG610 For two 6.10s with Casters CSTKE610CA CSTKG610CA For two 6.20s CSTKE620 CSTKG620 For two 6.20s with Casters CSTKE620CA CSTKG620CA For one 6.10 on one 6.20 CSTKE610620 CSTKE610620 CSTKG610620 CSTKG610620 For one 6.10 on one 6.20 with Casters CSTKE610620CA CSTKE610620 CSTKG610620 CSTKG610620 For one 6.10 on one 10.10 CSTKE1010 CSTKG1010 For one 6.10 on one 10.10 with Casters CSTKE1010CA CSTKG1010CA Gas Units For one 6.10 on one 10.20 CSTKE6101020 CSTKE6101020 CSTKG6101020 CSTKG6101020 For one 6.10 on one 10.20 with Casters CSTKE6101020CA CSTKE6101020CA CSTKG6101020CA CSTKG6101020CA For one 6.20 on one 10.20 CSTKE1020 CSTKG1020 For one 6.20 on one 10.20 with Casters CSTKE1020CA CSTKG1020CA Trolley Systems Roll-In Frame (for oven compartment) CRF10 CRF20 CRF10 CRF20 Cassette Transport Trolley CCTT10 CCTT20 CCTT10 CCTT20 Shelf Rack Cassette (CRF & CCTT req.) CSRC610 CSRC1010 CSRC620 CSRC1020 CSRC610 CSRC1010 CSRC620 CSRC1020 Plate Rack Cassette (CCF & CCTT req.) CPRC610 CPRC1010 CPRC620 CPRC1020 CPRC610 CPRC1010 CPRC620 CPRC1020 Thermal Cover (for CSRC & CPRC) CTC610 CTC1010 CTC620 CTC1020 CTC610 CTC1010 CTC620 CTC1020 Software & Networking CONVOControl software CCONTROL CCONTROL Module for adding units to network CICBOARD CICBOARD Options & Accessories Flanged Feet CST4FF CST4FF Lockable Control Covers CPLC610 CPLC1010 CPLC620 CPLC1020 CPLC610 CPLC1010 CPLC620 CPLC1020 460/480 volts, 60 cycle, 3 phase CVOS2A CVOS2A
Ph: 1-800-338-2204 / Web: www.convothermusa.com / Email: info@convothermusa.com Convotherm Standard Features Fully insulated holding cabinet keeps prepared foods at serving temperatures. Removable top mounted power unit with controls. Powerful, yet efficient, 2000 Watt heating system maintains the right temperature to properly hold products; temperature range up to 200 F (93 C). Control panel has electronic temperature control with easy-to-read digital temperature display; self-contained power top allows interior of cabinet to be hosed-out during cleaning. High temperature ceramic magnetic latch with composite, anti-microbial handle for easy open ; twistlock catch secures door during transport. Latches and hinges mounted inboard. Combi Oven-Steamer Capacity Chart Wire Racks Sheet Pans Steam Table Pans** Frying Baskets** Slide (half size - 12" x 20") (half size - 12" x 20") (12" x 20") (half size - 12" x 20") ConvoGrill Rails (full size - 18" x 26") (full size - 18" x 26") 1" 2 1/2" (full size - 18" x 26") Racks 6.10 7 7 half size 7 half size 7 6 6 half size 7 10.10 11 11 half size 11 half size 11 10 10 half size 11 6.20 7 7 full size 10.20 11 11 full size 12.20 12 12 full size 20.20 20 20 full size * wire racks required, ** wire racks not required 14 half size* 14 half size 14 14 7 full size* 6 full size 22 half size* 20 half size 22 20 11 full size* 10 full size 24 half size* 24 half size 24 24 12 full size 11 full size 40 half size* 40 half size 40 40 20 full size* 18 full size 14 22 24 40 SOLUTIONS CONVOTHERM provides many of the operational solutions from Manitowoc Foodservice, a global company dedicated to bringing value to foodservice operators by equipping them with highly individualized real-world answers that enhance menus, service, profits and efficiency. FINANCE Manitowoc Foodservice offers low-rate, fast approval financing on all our leading brands through Manitowoc Finance. Preserve capital, simplify budgeting and get the equipment you need, today. SERVICE CONVOTHERM products are backed nationwide by STAR Service. This network of certified service agents provides fast response with factory-trained experts to assure your equipment will be fixed right the first time. STAR Service agents guarantee their work and use genuine OEM parts for best equipment performance and longer life. To learn how Manitowoc Foodservice and its leading brands can equip you, visit our global web site at www.manitowocfoodservice.com then find the regional or local resources available to you. 2011 Manitowoc Foodservice Inc. except where explicitly stated otherwise. All rights reserved. CBCACC 0313