Stock #: Date: / / Mileage In: Mileage Out: Manufacturer #: VIN #: _ USED P.D.I. CHECKLIST Year: Make: Model: Length: Store Location: Critical Inspections: Initials: WHEEL TORQUE* TORQUE SET AT : FR R MID RR LR L MID L R *TOWABLES ONLY TIRE PRESSURES TIRE PRESSURES SET AT: FR RR TAG R MID OR INSIDE DUAL RR LR LR TAG L MID OR INSIDE DUAL L R GFI TEST PASS FAIL MANOMETER GAS TEST PASS FAIL (9 OF WATER COLUMN FOR 10 MINUTES) LOCKOUT GAS TEST PASS FAIL ALL DETECTORS o LP PASS FAIL NONE o SMOKE PASS FAIL NONE o CO PASS FAIL NONE TRAILER BREAK TEST PASS FAIL I CERTIFY THAT I HAVE PERFORMED THE ABOVE TESTS WITH THE RESULTS SHOWN: TECHNICIAN SIGNATURE TECHNICIAN NUMBER Page 1 of 8
Chassis Inspection: PASS FAIL FLUID LEVELS: o ENGINE TRANSMISSION REAR AXLE HYD RESERVOIR o ENGINE COOLANT WINDSHIELD WIPER FLUID PASS FAIL PERFORM GENERATOR LOF & AIR FILTER INSPECTION: PASS FAIL CHECK FOR FLUID LEAKS: PASS FAIL ROUTING OF WIRES & FUEL LINES: Road Test: PASS FAIL IDLE UP OPERATION: PASS FAIL LOW AIR WARNING LIGHTS & BUZZERS: PASS FAIL ALL WARNING LIGHTS & BUZZERS: PASS FAIL PARK BRAKE SET & RELEASE: PASS FAIL BRAKES FUNCTION PROPERLY AND INSPECTED FOR WEAR: PASS FAIL PERCENTAGE REMAINING FRONG: PASS FAIL PERCENTAGE REMAINING REAR: PASS FAIL TRANSMISSION SHIFTS CORRECTLY: PASS FAIL ENGINE BRAKE OR EXHAUST BRAKE: PASS FAIL ALL GAUGES FUNCTION PROPERLY: PASS FAIL CRUISE CONTROL OPERATION: PASS FAIL ALIGNMENT (DRIVES STRAIGHT DOESN T PULL): 12Volt System (Chassis): PASS FAIL DASH PANEL LIGHTS: PASS FAIL WIPERS - WASHERS: PASS FAIL DASH HEATER AIR CONDITIONER: PASS FAIL HORN: PASS FAIL POWER SEATS: PASS FAIL BATTERY BOOST SWITCH: PASS FAIL DASH STEREO: PASS FAIL MIRRORS POWER HEAT: PASS FAIL DRIVER COMPARTMENT OVERHEAD FANS: PASS FAIL CB RADIO: PASS FAIL BACK-UP MONITOR: EXTERIOR LIGHTS: PASS FAIL COMPARTMENT LIGHTS: PASS FAIL FOG LIGHTS: PASS FAIL AIM AND CHECK HEADLIGHTS Page 2 of 8
PASS FAIL CLEARANCE LIGHTS: PASS FAIL TAIL LIGHTS: PASS FAIL BACK-UP LIGHTS: PASS FAIL BRAKE LIGHTS: PASS FAIL TURN SIGNALS: PASS FAIL DOCKING LIGHTS: _ PASS FAIL ALL LENSES: SERVICE BATTERIES HOUSE & CHASSIS: PASS FAIL DRAWS WITH DISCONNECTS ON: 12Volt System (Coach): PASS FAIL ENTRY STEP: PASS FAIL DOOR BELL: PASS FAIL SWITCHES: PASS FAIL INTERIOR LIGHTS: PASS FAIL MONITOR PANEL (ALL FUNCTIONS): PASS FAIL SOLAR PANEL OPERATION: CHECK ALL DETECTORS PASS FAIL LP PASS FAIL SMOKE PASS FAIL CARBON MONOXIDE: INSTALL BATTERY POWERED SMOKE AND LP DETECTORS IF NONE PRESENT 110Volt System: PASS FAIL SHORE CORD: PASS FAIL GENERATOR OUTPUT (LOAD /NO LOAD) - STARTS & STOPS @ EACH REMOTE SWITCH & PRE-HEATS: PASS FAIL TRANSFER SWITCHES: PASS FAIL INVERTER - CONVERTER: PASS FAIL CHECK ALL OUTLETS FOR CORRECT POLARITY (INT. & EXT.): PASS FAIL CHECKED AND CERTIFIED G.F.I. WITH TESTER Propane System: PASS FAIL MANOMETER TEST AND CERTIFICATION (9 OF WATER COLUMN FOR 10 MIN.): PASS FAIL LOCKOUT GAS TEST AND CERTIFICATION PASS FAIL LP REGULATOR: PASS FAIL TANK GAUGE READS CORRECTLY: PASS FAIL MONITOR GAUGE READS PROPERLY: Page 3 of 8
Water System: PASS FAIL CITY WATER FILL: PASS FAIL POTABLE WATER FILL OR BYPASS VALVE: PASS FAIL HOLDING TANKS: PASS FAIL PERFORM FRESH WATER PLUMBING TEST (SHOULD HOLD 45PSI FOR 10 MIN.): PASS FAIL WATER PUMP & ALL REMOTE SWITCHES: PASS FAIL ALL VALVES: PASS FAIL HOT & COLD AT ALL FAUCETS (INT. & EXT.): PASS FAIL FAUCETS & FIXTURES: PASS FAIL TOILET & SPRAYER: PASS FAIL SHOWER ENCLOSURE: PASS FAIL WATER FILTER: PASS FAIL FLOOD TEST WASTE WATER SYSTEM: PASS FAIL PLUMBING & DRAINS: PASS FAIL DUMP VALVES: PASS FAIL BLACK TANK FLUSH: PASS FAIL LOW POINT DRAINS: PASS FAIL FRESH WATER TANK DRAIN Coach Interior: PASS FAIL WALLS FIT & FINISH: PASS FAIL CABINETS FIT & FINISH: PASS FAIL ALL DOORS & DRAWERS (FIT, LATCHES, ETC.) INCLUDES POCKET DOORS & BATH. DOOR: PASS FAIL COUNTERTOPS: PASS FAIL WINDOWS & SCREENS: PASS FAIL WINDOW BOXES & SHADES: _ PASS FAIL CURTAINS INCLUDES PRIVACY CURTAINS: PASS FAIL CARPET: PASS FAIL FLOORING (TILE, WOOD, & LINOLEUM): PASS FAIL FURNITURE & UPHOLSTERY: PASS FAIL BEDSPREAD & PILLOWS: PASS FAIL DINETTE TABLE & CHAIRS: PASS FAIL SEATBELTS: PASS FAIL HEADLINER: Appliances (Operation): PASS FAIL FRONT TELEVISION WITH REMOTE: PASS FAIL REAR TELEVISION WITH REMOTE: Page 4 of 8
PASS FAIL VCR PLAYER WITH REMOTE:_ PASS FAIL DVD PLAYER WITH REMOTE: PASS FAIL SURROUND SOUND/STEREO WITH REMOTE (LIVING ROOM & BEDROOM): PASS FAIL TELEVISION ANTENNA (UP, ROTATES, & STOWS): PASS FAIL TELEVISION ANTENNA BOOST:_ PASS FAIL TELEVISION SWITCH BOX: PASS FAIL SATELLITE SYSTEM: REFRIGERATOR PASS FAIL 12V PASS FAIL 120V PASS FAIL LP GAS PASS FAIL ICEMAKER (INSIDE REFRIGERATOR &/OR STAND ALONE): PASS FAIL WATER HEATER (120V, & LP GAS): PASS FAIL FURNACE(S) / HEATING SYSTEM_/ FANS FOR HOT WATER HEATING PASS FAIL ROOF AIR CONDITIONERS (COMFORT HEAT IF APPLICABLE) PASS FAIL GALLEY & BATHROOM EXHAUST FANS: PASS FAIL WASHER - DRYER: PASS FAIL DISHWASHER: PASS FAIL COOK TOP & OVEN (120V & LP GAS): PASS FAIL MICROWAVE CONVECTION OVEN: SLIDE OPERATION (NO ABNORMAL SOUNDS & SMOOTH) Slide-Out: PASS FAIL DRIVER FRONT SLIDE PASS FAIL PASSENGER FRONT SLIDE PASS FAIL DRIVER BEDROOM SLIDE PASS FAIL PASSENGER BEDROOM SLIDE PASS FAIL INTERIOR &EXTERIOR SEALS (TIGHT TO WALL INSIDE & OUT): PASS FAIL EXTERIOR MOULDINGS: PASS FAIL INTERIOR SURROUND: PASS FAIL TRAVEL LOCKS: Coach Exterior: PASS FAIL ENTRY DOOR (FIT, LOCKS, & ETC.): PASS FAIL DRIVER & PASSENGER DOORS: PASS FAIL GENERATOR SLIDE (IF EQUIPPED): PASS FAIL BODY ARMOR (IF EQUIPPED): _ PASS FAIL COMPARTMENT DOORS (FIT, LOCKS & ETC.): PASS FAIL COMPARTMENT BAYS: Page 5 of 8
PASS FAIL WINDSHIELDS & WINDOWS: PASS FAIL SEALING (MOLDING, TRIM, & ETC.): PASS FAIL ROOF SEAL & ATTACHMENTS:_ PASS FAIL ROOF RACK & LADDER: AWNINGS PASS FAIL MAIN PATIO PASS FAIL WINDOW AWNINGS PASS FAIL TOPPER AWNINGS: PASS FAIL PAINT & DECALS: PASS FAIL HITCH: PASS FAIL HUBCAPS (LUG NUTS, ETC.): _ Miscellaneous PASS FAIL TWO (2) FULL SETS OF KEYS: _ PASS FAIL WINTERIZE (IF NECESSARY): Page 6 of 8
USED P.D.I. FOUND DURINGS Year: Make: Model: Length Stock #: Mileage: Page 7 of 8
USED P.D.I. FOUND DURINGS Year: Make: Model: Length Stock #: Mileage: Page 8 of 8