Asset: P.S. 163 - BRONX, 2075 WEBSTER AVENUE, New York, 10457 Inspection Id Inspection Type Time In Last Edited ME : Mechanical 2018-03-22 8:33 AM 2018-03-22 3:13 PM Asset Data Are there fuel tanks? Total # of above ground tanks 1 Answer Total capacity of all above ground tanks in gal. 10,000 Total # of below ground tanks 0 Total capacity of all below ground tanks in gal. 0 Total # of water main service entries to the asset 1 MERs/Fan Rooms Locations Are there any spaces with Missing or Defective CO Detectors? Are there any Emergency Stop Switches with Missing Hammers? Are there any Painted/Obstructed Sprinkler Heads? Have any Systems/Major Building Components been upgraded? Priority Yes None No No No Yes Systems: Years: 2017 Systems: Years: 2014 Systems: Years: 2013 Systems: Years: 2012 Kitchen - Grease Trap MDF Room - Dedicated A/C Equipment (DX Split System) Gas Meter Room Vent Packaged / Rooftop Unit for 2nd and 3rd Floor Hallways (1 of 5); Return Fan; Climate Control System; Metal Ductwork (60%) Systems: Drinking Fountains (60%) Years: 2011 Priority Priority Exist Category Last Year? Description Component Affected Location Description Person(s) Notified Person(s) Title Status PhotoImage No Defective Boiler Safety Auxiliary Leaking Boiler Safety Valve HEATING PLANT Boiler Auxiliaries Boiler Safety Valve Miguel Bizardi Fireman Sent to DSF Inspection Mechanical AIR CONDITIONING Chilled Water System Condenser Water Distribution: Piping, Pumps and Auxiliaries Cooling Coil in Ductwork Cooling Tower DX Split System Dry Cooler Packaged / Rooftop Unit Instance Instance Instance Quantity 1 Roof 1 - Good PB/A&W Page 1 of 10
AIR CONDITIONING Packaged / Rooftop Unit Instance Source of Heating Electric Instance Manufacturer Trane Equipment A/C -1 Capacity/Size Quantity 8 Capacity/Size UOM Tons Source of Capacity/Size Inspector Estimate Installation Year 2012 Source of Installation Custodial Staff Instance Roof Instance Instance Quantity 4 Instance Source of Heating Steam Instance Manufacturer Seasons4 Equipment MZ-1, MZ-2, MZ-3, MZ-4 Capacity/Size Quantity 33 Capacity/Size UOM Tons Source of Capacity/Size Inspector Estimate Installation Year 2000 Source of Installation Inspector Estimate Packaged Terminal A/C Refrigerant Piping Return Fan 1 - Good CENTRAL ACID WASTE NEUTRALIZING TANK CLIMATE CONTROL SYSTEM BMS Instance 2nd and 3rd Floor - Throughout Instance Instance Quantity 1 Instance Building Area Covered by Operational System 81-100% Installation Year 2012 Source of Installation Custodial Staff Pneumatic System Hybrid System Electric System COMPACTOR NOT IN USE Location/Instance Room C11 Quantity 1 PB/A&W Page 2 of 10
COMPACTOR NO ACTION Urgency of Action PRIORITY 1 Purpose of Action LEVEL 1 Photo1 CONVEYING Dumbwaiter Elevator Are all the existing elevators operable? Yes Escalator Non-auditorium Handicap Lift - Vertical Non-auditorium Handicap Lift - Stair Ash Hoist Sidewalk Elevator DOMESTIC WATER SYSTEM Domestic Cold Water System Gravity System Pressure Booster System Water Service Instance Room C4 Instance 4 - Between Fair and Poor Instance Quantity 1 Instance WATER MAIN: DEFECTIVE ISOLATION VALVE Location/Instance Room C4 Quantity 1 Photo1 WATER MAIN: MISSING BACKFLOW PREVENTION DEVICE Location/Instance Room C4 Quantity 1 INSTALL Photo1 Domestic Hot Water System Domestic Hot Water Remote Storage Tank Domestic Water Heat Exchanger PB/A&W Page 3 of 10
DOMESTIC WATER SYSTEM Domestic Hot Water System Domestic Water Heat Exchanger Electric Domestic Water Heater 5 - Poor DEFECTIVE/DETERIORATED Location/Instance Quantity 1 Photo1 Gas Fired Domestic Water Heater Oil Fired Domestic Water Heater Domestic Water Distribution Piping DRAIN/WASTE/VENT AND STORM SYSTEM Interior Storm Piping Sewage/Waste/Vent Piping Sewage Ejector Pump Sump Pump DUAL TEMPERATURE SYSTEM (CHILLED AND HOT WATER) FIXTURES Staff And Other Janitor Sink Lavatory/Sink Toilet Urinal Student Drinking Fountain PB/A&W Page 4 of 10
FIXTURES Student Lavatory/Sink Locker Room Shower Sink And Fountain Combo Unit Toilet Urinal GAS FIRED FURNACE GAS SERVICE Gas Distribution Piping Gas Meter Room Exhaust Fan Gas Meter Room Vent 1 - Good Gas Pressure Booster CO/Gas Leak Detection HEATING Heating Coil In Ductwork Hydronic Heating Radiator/Convector/Fin Tube Steam Heating F&T/Steam Drip Trap MER Steam and Condensate Piping Steam Condensate Return Piping Steam Condensate Return Pumping System Steam Piping Terminal Unit Thermostatic Trap Steam supplied by External Sources Unit Heater/Cabinet Heater HEATING PLANT Replacement Quantity 3,036 PB/A&W Page 5 of 10
HEATING PLANT Replacement Uom Burner Type Heating Plant Oil Number Boiler Auxiliaries Boiler Auxiliary Piping Boiler Emergency Stop Switch Boiler Feedwater System Location/Instance Quantity 1 MBH Net Oil 4 FEEDWATER TANK: DEFECTIVE TANK AUXILIARIES(AUTO FEEDWATER VALVE, LOW LEVEL CUT OFF,ETC) MAINTENANCE Photo1 Boiler Feedwater Treatment(Automatic) Location/Instance Quantity 1 4 - Between Fair and Poor DEFECTIVE MAINTENANCE Photo1 Boiler Flue Exhaust Boiler Make-up Water Backflow Preventer Steam And Condensate Piping PB/A&W Page 6 of 10
HEATING PLANT Boiler Auxiliaries Steam And Condensate Piping Boiler Safety Valve 4 - Between Fair and Poor DEFECTIVE Location/Instance Quantity 1 Urgency of Action PRIORITY 5 Purpose of Action LEVEL 6 Photo1 Boiler System Coal-fired Boiler Hot Water Boiler Modular Boiler Steam Boiler Instance Instance Instance Quantity 3,036 Instance MBH Net Instance Manufacturer H. B. Smith Co., Inc. Equipment 63497-1 Capacity/Size Quantity 3,036 Capacity/Size UOM MBH Net Source of Capacity/Size Documented Installation Year 1975 Source of Installation Documented BEYOND USEFUL LIFE Location/Instance Quantity 1 Urgency of Action PRIORITY 1 Photo1 Fuel System PB/A&W Page 7 of 10
HEATING PLANT Fuel System Boiler Fresh Air Louver/Damper Burner/Burner Control Panel Fuel Oil Storage/Supply System Gas Trains And Vent At The Boiler Enclosed IDF Room KITCHEN CO Detector Not Required Not Required Gas System Grease Trap 1 - Good Hood Hood Exhaust Ductwork Hood Exhaust Fan 4 - Between Fair and Poor DEFECTIVE MOTOR Location/Instance Roof Quantity 1 Photo1 Hood Fire Suppression System Hot Water Temperature Booster PB/A&W Page 8 of 10
KITCHEN Hot Water Temperature Booster Kitchen Sink MDF Room Instance on Room inside Room 106 Dedicated A/C Equipment Instance on Room inside Room 106 SCIENCE DEMO ROOM SCIENCE LAB SCIENCE PREP ROOM SPRINKLERS, STANDPIPE, FIRE SYSTEM Dry Sprinkler Alarm Valve Assembly Wet Sprinkler Alarm Valve Assembly Fire Booster Pump Assembly Roof Tank Siamese Connection Sprinkler Head Sprinkler Piping Standpipe System Hose Valve Assembly Piping Water Gong SWIMMING POOL VENTILATION Exhaust Fan 1 - Good Approximate Total # of Fans 1-25 4 - Between Fair and Poor DEFECTIVE MOTOR Location/Instance Roof (3 of 4) Quantity 3 PB/A&W Page 9 of 10
VENTILATION Exhaust Fan Photo1 Heating And Ventilating Unit Metal Ductwork Supply Fan Unit Ventilator PB/A&W Page 10 of 10