70054 Toilet Repair 700539 70054 Bay Name: Plumbing Repair 4.1 1 of 1 1 Toilet Repair 72" from floor to bottom of AV 2 3 4 5 6 7 2 Installing a Toilet Ensure that Install a new Place the toilet Tighten the nuts 1 the floor flange 2 wax or rubber 3 bowl straight 4 on the floor bolts. 5 is intact. If floor gasket on down over the Do not overtighten or you broken, it must the bottom of new floor bolts. be replaced. the toilet Apply pressure risk cracking the Place the new bowl. on bowl to porcelain. Place toilet floor bolts ensure wax ring level on bowl. into the slots on seals in all On tile floors use the floor flange. areas. floor shims to stabilize the toilet if necessary. Re-install the water supply line and turn the water on. Flush the toilet and check for leaking. 3 Replacing a Fill Valve Turn off water Remove old fill Insert new fill valve. Attach fill tube 1 supply valve. 2 valve float ball 3 Floatless/Universal 4 to the overflow 5 Drain water from tank by holding down the tank lever. Unscrew supply line nut under tank. Dry inside of tank using sponge. and arm. Remove any dirt/build-up inside of tank with rag. styles do not have float arm/ball and are easier to install. tube with clip as shown. Make sure the fill valve sits 1 above overflow tube. Re-install the water supply line under tank as shown. Turn the water on and flush toilet to check for leaks. 4 5 6 7 Toilet Repair Toilet Install and Repair Instructions: [Aisle Violators] Install Aisle Violator using AV clips so bottom edge is 72" above the floor [Channel Signs] Insert channel signs into C Channel hardware
Bay Name: Plumbing Repair 4.1 2 of 1 5" x 96" x 36" Waterfall Deck @ 141 '' Notch= 47 Millwork Requirements: Peg Board 96"W x 36.5"H set back 23" 47 X 11" Peghook, One-piece with lable 22 in 5" x 96" x 36" Waterfall Deck @ 114 '' Notch= 3 1.5 in 37 in 14 in 23.25 in Notch= 4 2 3 175544 66149 430245 11445 515022 515013 515013 430245 11445 5" x 96" x 36" Waterfall Deck @ 90 '' Notch= 30 515005 51473 515014 515014 11442 515017 515017 515006 514940 112461 51493 11442 514946 51501 514943 514972 51414 51412 51479 5147 11442 112461 515052 514970 66362 131459 514955 430244 665476 51472 6614 430244 66146 51416 515011 51416 51474 Notch= 29 2" x 96" x 36" Base Wire @ 3 '' Notch= 2 Notch= 0 665474 4551 665475 11499 5143 7205 51415 514976 5143 733040 51490 51406 11462 515012 131456 131456 149490 665156 51441 4" x 96" x 36" Wood @ 4 '' Notch= 16 667410 72416 66360 77939 51440 51439 77579 51424 5147 667409 4" x 96" x 36" Wood @ 30 '' Notch= 10 4 5 6 7 131457 5146 11443 13407 73100 Notch= 4 Notch= 2 733042 733042733041 733041 In Bay Signage Requirements Item # Part # Description Quantity HD Article # Hardware Requirements How to Order 1 D26026C-AV4 Toilet Repair Aisle Violator 1 - AV Clips epop 2 70054-01 'Installing a Toilet' Channel Sign 1 - C-Channel epop 3 70054-03 'Replacing a Fill Valve' Channel Sign 1 - C-Channel epop 4 TAS1LE 'Installing a Toilet' Storyboard 1 - epop 5 TAS2LE 'Toilet Repair Solutions' Storyboard 1 - epop 6-03 'Toilet Install' Strip 1 - epop 7-01 'Toilet Install and Repair' Strip 1 - epop 700539 4" x 4" Solid Red POP C-Channel Insert 4 - epop GA001C Aisle Violator Clips 2 - - epop GA442TBC 4" x " C-Channel 2 - - epop GA975C 4" x 4" C-Channel 4 - - epop Merchandising POG shown is for POP reference only and is not to be used to set product. Refer to your store specific Merchandise POG for product placement.
70054 Drain Repair 700539 700505 700503 Bay Name: Plumbing Repair 4.2 3 of 9 9 Drain Repair 10 11 72" from floor to bottom of AV 6 12 13 14 15 10 Replacing a Tank Flapper Turn off water Unhook the Follow the Install new 1 supply valve. 2 chain from the 3 instructions on 4 flapper and 5 Drain water tank lever. new flapper check that it from tank by Remove old package. sits properly holding down flapper by Scissors may be on the flush the tank lever. sliding up over required. valve hole. Dry inside of tube or detach tank using ears at bottom. sponge. Clean any sediment. Re-install the chain on the tank lever. Adjust as needed. Turn on water supply. Flush the toilet and check for leaks. 11 Replacing a Tub Spout REMOVING A Measure Screw on spout REMOVING A 1 SCREWED-ON 2 distance of the 3 by hand. Be 4 SPOUT HELD BY 5 SPOUT: Insert a large screwdriver or hammer handle and unscrew counter clockwise. pipe coming out from wall for proper replacement. Wrap Teflon tape around pipe threads. careful not to over-tighten. A SET SCREW: Look under spout to locate set screw. Use hex wrench to loosen screw and pull spout out. Loosen set screw and slip over copper pipe. Position upright and tighten set screw under spout. 12 13 6 Toilet Repair Drain Repair 14 15 Instructions: [Aisle Violators] Install Aisle Violator using AV clips so bottom edge is 72" above the floor [Channel Signs] Insert channel signs into C Channel hardware
Bay Name: Plumbing Repair 4.2 4 of 9 22 in 5" x 96" x 36" Waterfall Deck @ 141 '' Notch= 47 Millwork Requirements: Peg Board 96"W x 4.5"H set back 23" 103 X 11" Peghook, One-piece with lable 5" x 96" x 36" Waterfall Deck @ 114 '' Notch= 3 1.5 in 55 in 73100 Notch= 4 Notch= 2 733042 733042733041 733041 10 11 66001 1107 665265 665266 51446 66527 665276 11079 665264 51490 5" x 96" x 36" Waterfall Deck @ 90 '' Notch= 30 51451 77941 51447 66434 51456 51447 51454 66435 665279 66527 665176 6647 66517 665345 665179 514923 77944 66417 66510 514915 66512 514905 66511 514914 Notch= 2 514912 514912 514913 66526 77937 66421 664219 664740 514422 514409 514412 514910 514919 514906 514904 12 13 514427 51441 51442 51441 517365 514420 514419 514421 514453 6 14 514449 517032 51444 514541 72410 72412 51434 514456 514457 514517 514526 514425 514556 514509 724044 72414 72411 514515 51444 514511 514542 514423 514493 4" x 96" x 36" Wood @ 30 '' Notch= 10 72413 514510 51450 514460 514491 514445 514513 514521 514520 51451 514523 Notch= 4 51696 23.25 in 74713 74713 51477 51477 514557 514557 514524 Notch= 0 514524 15 117455 514476 514476 514476 514476 2" x 96" x 36" Base Wire @ 3 '' Notch= 2 514475 51447 In Bay Signage Requirements Item # Part # Description Quantity HD Article # Hardware Requirements How to Order 9 D26026C-AV4 Drain Repair Aisle Violator 1 - AV Clips epop 10 70054-02 'Replacing a Tank Flapper' Channel sign 1 - C-Channel epop 11 700503C 'Replacing a Tub Spout' Channel sign 1 - C-Channel epop 12 TAS3LE 'Toilet Leak Test' Storyboard 1 - epop 13 DAS1RE 'Tub Spouts' Storyboard 1 - epop 6-02 'Toilet Repair' Strip 1 - epop 14-06 'Drain Repair' Strip 1 - epop 700539 4" x 4" Solid Red POP C-Channel Insert 1 - epop 15 700505 4" x 4" Solid Yellow POP C-Channel Insert 1 - epop GA001C Aisle Violator Clips 2 - - epop GA442TBC 4" x " C-Channel 2 - - epop GA975C 4" x 4" C-Channel 4 - - epop Merchandising POG shown is for POP reference only and is not to be used to set product. Refer to your store specific Merchandise POG for product placement.
700515 Sink Repair 700539 700577 700535 Bay Name: Plumbing Repair 4.3 5 of 17 17 Millwork Requirements: Peg Board 96"W x 4.5"H set back 23" Millwork Requirements: Peg Board 96"W x 4.5"H set back 23" Millwork Requireme Sink Repair 1 19 Attach top of C-Ch viders 72" from floor to bottom of AV 20 21 22 23 S Vendor Vendor supplied supplied Mi M 24 25 1 19 Installing a Pop-up Drain Apply plumber s Thread the Set drain flange Slide plunger into 1 putty on bottom 2 locknut onto the 3 in hole with 4 top drain hole. 5 cover of drain drain body. putty side down Fit the pivot ball flange. Add the friction and screw into into opening on washer and drain body. side of drain gasket. Make sure the body. Push the drain arm hole is Screw retaining body up from facing the back nut onto threads underneath sink. of sink. Hand of drain. tighten locknut and secure with pliers. Slide arm through nearest hole on lever strap. Fasten with clip. Check and adjust as necessary. Convert a 2 or 3 Handle Shower Faucet Turn off water Trace out Install NEW Apply silicone to 1 and remove 2 supplied 3 single handle 4 back of plate 5 existing handles template. valve. and fasten and trim. Cut hole in (sold separately) screws. wall and remove old valve. Complete with Remodel Plate and Trim. 20 21 22 23 Sink Repair Faucet Repair 24 25 Instructions: [Aisle Violators] Install Aisle Violator using AV clips so bottom edge is 72" above the floor [Channel Signs] Insert channel signs into C Channel hardware
Bay Name: Plumbing Repair 4.3 6 of 17 5" x 96" x 36" Waterfall Deck @ 141 '' Notch= 47 Millwork Requirements: Peg Board 96"W x 4.5"H set back 23" 132 X 11" Peghook, One-piece with lable 22 in 5" x 96" x 36" Waterfall Deck @ 114 '' Notch= 3 1.5 in 55 in 1 19 Notch= 4 14115 514627 514627 514610 514490 514577 514577 416726 724056 51461 5" x 96" x 36" Waterfall Deck @ 90 '' Notch= 30 514607 514607 514590 514623 514623 514621 514574 514574 514654 514653 51465 51464 514614 514646 51469 514692 514641 514615 514619 514647 514649 514655 51465 514614 514619 514652 514649 514655 51465 51461 514650 7793 51470 514644 514720 514722 514704 514747 514719 514722 755261 514725 514722 Notch= 2 755262 51471 51460 514712 664216 514714 514717 20 21 51471 514717 514709 664217 6643 514716 779146 779642 779145 515641 514622 779147 22 23 515642 515673 515567 515576 515510 51560 515601 51559 516403 515636 515513 515540 515601 515572 51553 515610 515512 515563 515609 515605 51550 515610 515509 515609 515561 515543 77940 515607 515549 515532 5152 515597 4" x 96" x 36" Wood @ 30 '' Notch= 10 51529 515643 516364 515571 515571 515545 515537 516363 515570 724045 515644 724050 51530 515643 515710 Notch= 4 515506 23.25 in 5144 514461 51442 517029 51445 514560 514779 660016 660016 660015 660015 514774 514774 24 25 2" x 96" x 36" Base Wire @ 3 '' Notch= 2 Notch= 0 514753 514742 724057 51475 51475 514739 514745 514745 In Bay Signage Requirements Item # Part # Description Quantity HD Article # Hardware Requirements How to Order 17 D26026C-AV3 Sink Repair Aisle Violator 1 - AV Clips epop 1 700515 'Installing a Pop-up Drain' Channel sign 1 - C-Channel epop 19 700535-03 'Convert a 2/3 Handle...' Channel sign 1 - C-Channel epop 20 SAS1LE 'Kitchen Sink Strainers' Storyboard 1 - epop 21 FAS1LE 'Replacing a Handle' Storyboard 1 - epop 22-05 'Sink Repair' Strip 1 - epop 23-04 'Faucet Repair' Strip 1 - epop 24 700530 4" x 4" Solid Green POP C-Channel Insert 1 - epop 25 700577 4" x 4" Solid Blue POP C-Channel Insert 1 - epop GA001C Aisle Violator Clips 2 - - epop GA442TBC 4" x " C-Channel 2 - - epop GA975C 4" x 4" C-Channel 4 - - epop Merchandising POG shown is for POP reference only and is not to be used to set product. Refer to your store specific Merchandise POG for product placement.
700535 Faucet Repair 700535 700577 Bay Name: Plumbing Repair 4.4 7 of 26 Millwork Requirements: Peg Board 96"W x 4.5"H set back 23" 26 Millwork Requirements: Peg Board 96"W x 4.5"H set back 23" Faucet Repair 27 2 ividers 72" from floor to bottom of AV 29 30 23 23 31 Find it Fast! Quick Vendor Vendor supplied supplied Millwork Millwork Bins Bins with with Adjustable Dividers Dividers 25 25 27 2 Faucet Repair Basics No matter what Turn off the water Turn on handles To make sure 1 kind of faucet 2 to the faucet. 3 and let any water 4 you get the right 5 you are dealing There may be in the pipe drain replacement with, there are individual water out. parts, take any some basics shut-off valves Put the drain parts you remove when it comes under the sink stopper or a from the faucet to repairing any or you may towel in the sink with you to the of them. need to shut off in case you drop store so you'll be the main water something (you sure to get an supply for the don't want exact match. house. it going down the drain). It is helpful to know what the brand and model of faucet you are repairing. Most manufacturers' parts and repairs are different from each other. Replacing a cartridge Turn off water and COMPRESSION BALL FAUCET - CARTRIDGE 1 remove existing 2 FAUCET - 3 1 handle faucets 4 FAUCET - 1 or 2 5 handles and trim 2 handle faucets only handle faucets - this will vary by only Tools required - Tools required - type of faucet. Pry Tools required - screwdriver, hex screwdriver, hex off cap if screw is screwdriver, wrench, slip-joint wrench, slip-joint hidden. slip-joint pliers, and needle-nose and needle-nose Complete utility knife. pliers, utility pliers. repair kits are Change entire knife, tweezers. Change entire available if you cartridge if Change o-rings, cartridge if know the brand unsure where seals and ball if unsure where and model. leak is located. necessary. leak is located. CERAMIC DISC FAUCET - 1 or 2 handle faucets Tools required - screwdriver, hex wrench, slip-joint and needle-nose pliers. 29 30 31 23 Faucet Repair 25 Instructions: [Aisle Violators] Install Aisle Violator using AV clips so bottom edge is 72" above the floor [Channel Signs] Insert channel signs into C Channel hardware
Bay Name: Plumbing Repair 4.4 of 26 22 in 5" x 96" x 36" Waterfall Deck @ 141 '' Notch= 47 Millwork Requirements: Peg Board 96"W x 4.5"H set back 23" 19 X 11" Peghook, One-piece with lable 5" x 96" x 36" Waterfall Deck @ 114 '' Notch= 3 1.5 in 55 in 27 2 Notch= 4 66473 112973 17341 16963 5" x 96" x 36" Waterfall Deck @ 90 '' Notch= 30 66430 11776 11143 141261 51544 515447 515432 515696 724047 724046 515697 17325 66437 515732 51562 515665 724049 51561 72404 515764 515725 515725 515729 515731 515731 515740 515741 515703 515742 515702 515772 515772 515705 515705 515711 515707 51570 516273 515714 515715 515679 516365 516227 516227 516342 516291 516275 516257 516290 516267 516292 516292 516296 516296 516226 516226 516300 516370 516267 516230 516371 516371 51515 516356 516372 Notch= 29 66432 51504 515765 515777 51576 515769 515770 515776 51571 51577 51570 515745 516369 51513 515796 51579 51575 51577 51546 51536 51531 51532 515747 51543 515901 51513 51537 51543 51506 51514 515763 51574 515344 515374 515366 51530 515379 515335 516334 51531 515335 515314 515336 51633 51534 7754 77943 51534 516332 515417 515417 515334 51532 51532 29 30 31 Quick Reference Guide 4" x 96" x 36" Wood @ 30 '' Notch= 10 Vendor supplied Millwork Bins Bins with with Adjustable Dividers 23 23 51501 51503 51505 51531 51531 51531 515319 515319 515276 515276 51525 515111 515117 515117 515117 51511 51511 51511 515120 515120 515120 515121 515121 515121 Find it Fast! 51507 51507 515102 515103 515079 51502 Notch= 4 23.25 in 72405 13130 515445 515443 125602 12559 2" x 96" x 36" Base Wire @ 3 '' Notch= 2 25 Notch= 25 0 515666 514791 514790 51535 In Bay Signage Requirements Item # Part # Description Quantity HD Article # Hardware Requirements How to Order 23-04 'Faucet Repair' Strip 2 - epop 25 700577 4" x 4" Solid Blue POP C-Channel Insert 2 - epop 26 D26026C-AV2 Faucet Repair Aisle Violator 1 - AV Clips epop 27 700535-01 'Faucet Repair Basics' Channel sign 1 - C-Channel epop 2 700535-02 'Replacing a Cartridge' Channel sign 1 - C-Channel epop 29 FAS3LE 'Aerators' Storyboard 1 - epop 30 FAS2LE 'Ceramic Disc Faucet' Storyboard 1 - epop 31 n/a 'Find it Fast Cartridge and Diverter' Flipbook 1 - Vendor GA001C Aisle Violator Clips 2 - - epop GA442TBC 4" x " C-Channel 2 - - epop GA975C 4" x 4" C-Channel 4 - - epop Merchandising POG shown is for POP reference only and is not to be used to set product. Refer to your store specific Merchandise POG for product placement.