DCG Commercial Submittal Data Form 15-25 Tons Packaged Gas / Electric Units 15 Tons Cooling Capacity: 180,000 BTU/h 20 Tons Cooling Capacity: 240,000 BTU/h 25 Tons Cooling Capacity: 290,000 BTU/h 15 Tons Heating Capacity: 350,000 BTU/h 20 Tons Heating Capacity: 400,000 BTU/h 25 Tons Heating Capacity: 400,000 BTU/h Job Name Purchaser Order No. Engineer Unit No. Model No. Unit Designation Performance Data Certified By: Standard Features Patented tubular heat exchanger High-efficiency scroll compressor Aluminum micro-channel indoor coil on 25-ton units 25-ton units contain two outdoor fans Copper tube / aluminum fin coils High- and low-pressure switches High-capacity, steel-cased filter drier 24-volt terminal strip Contactor with lugs Units meet the performance outlined in Table 6.8.1-1 of ASHRAE Standard 90.1-2013 AHRI Certified; ETL Listed Cabinet Features Heavy-gauge, galvanized-steel cabinet with UV-resistant powder-paint finish Condenser hail guards Full perimeter rail Built-in filter rack with standard 2 filters (convertible to 4 filters) Sloped drain pan * Complete warranty details available from your local dealer or at www.daikincomfort.com. SF-DCG15 www.daikincomfort.com 3/16 Supersedes 9/15
Performance Data Cooling Performance Tota Capacity MBH Sensible Capacity MBH Outdoor Design TMP ºF DB / WB Air Temp entering Evaporator Coil ºF Power Input Required kw (less blower motor) Heating Performance Total Heating Capacity kw BTU/h Supply Air Blower Performance Total Supply Air Ext. Static Pressure Blower Speed Power Output Required Motor Ratings Power Input Required Electrical Data Power Supply Total Unit Amps Amps Max Overcurrent Device: Fuse Breaker Amps CFM IWG RPM BHP HP kw Notes 2 www.daikincomfort.com SF-DCG15
Dimensions 15 & 20 Tons TOP VIEW FORK HOLES BOTH SIDES AND CONDENSER END LIFT SHACKLE HOLES BOTH SIDES AND ENDS CONDENSATE DRAIN OUTLET THIS SIDE ONLY 35.551 133.354 BACK VIEW ALL DIMENSIONS ARE GIVEN IN INCHES ALL DIMENSIONS AND SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTIFICATION 50.750 7.017 LINE WIRE ENTRANCE 88.116 LEFT END VIEW DC*180/240*** 15 AND 20 TON COMERCIAL DISCONNECT SWITCH LOCATION (if applicable) TSTAT WIRE ENTRANCE 8.204 18.579 3.058 8.949 12.137 SF-DCG15 www.daikincomfort.com 3
Dimensions 15, 20, & 25 Tons CONDENSATE DRAIN BOTTOM EXIT 2X 60.000 44.063 2X 7.000 7.000 RETURN AIR DUCT 22.000 35.505 48.000 SUPPLY AIR DUCT 22.000 BASE PAN VIEW (VIEWED FROM TOP DOWN) 4 www.daikincomfort.com SF-DCG15
Dimensions 25 Tons TOP VIEW 53.212 FORK HOLES BOTH SIDES AND CONDENSER END CONDENSATE DRAN OUTLET THIS SIDE ONLY LEFT SHACKLE HOLES BOTH SIDES AND ENDS 133.354 BACK VIEW ALL DIMENSION GIVEN ARE IN INCHES ALL DIMENSIONS AND SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE. 35.551 7.017 50.750 88.116 LEFT END VIEW LINE WIRE ENTRANCE TSTAT WIRE ENTRANCE 8.204 3.058 12.125 DC*300*** 25-TON COMMERCIAL SF-DCG15 www.daikincomfort.com 5
Accessories List (Dimensions and specifications begin on the following page.) Filed-Installed Item # Description Fits Model Sizes Field- Installed 14CURB180300 14" Roof Curb 15-25 tons D25FD180300 25% Manual Fresh Air Damper 15-25 tons D25MFD180300 25% Motorized Fresh Air Damper 15-25 tons DDNBB180240 Burglar Bar Sleeves with Supply and Return 15-25 tons CDK180 Concentric Duct Kit 15 tons CDK240 Concentric Duct Kit 20 tons CDK300 Concentric Duct Kit 25 tons Factory- Installed Convenience Outlet: Powered All Models Convenience Outlet: Non Powered All Models Disconnect Switch (non-fused) All Models Ultra Low-Leak Downflow Economizer3 15-25 tons DDNECNJ180300B Low-Leak Downflow Economizer4 15-25 tons HAKT36300 High-Altitude Kit All Models HSKT180G ¹ High-Static Kit (230/460v) 15 tons HSKT180G-7 ¹ High-Static Kit (575v) 15 tons HSKT240 ¹ High-Static Kit (230/460v) 20 tons HSKT240-7 ¹ High-Static Kit (575v) 20 tons HSKT300G High-Static Kit (all voltages) 25 tons HZCURB180240ED Horizontal Discharge Curb End Discharge 15-25 tons HZCURB180240SDN HZCURB180240SDS Horizontal Discharge Curb Side Discharge; duct openings on non-service side Horizontal Discharge Curb Side Discharge; duct openings on service side 15-25 tons 15-25 tons GHRC-1 Hurricane Restraint Clips All Models LAKT03 Low-Ambient Kit 15-20 tons LAKT05 Low-Ambient Kit (208/230V & 460V) 25 tons LPKT180300A LP Conversion Kit 15-25 tons DPE1803002 Downflow Power Exhaust (208/230v) 15-25 tons DPE1803004 Downflow Power Exhaust (460v) 15-25 tons DPE1803007 Downflow Power Exhaust (575v) 15-25 tons Smoke Detector All Models FSKT02A Freeze Stat Kit 25 tons 2 ¹HSKT High-static kits are for use with standard single-speed belt-drive units only. 2FSK02A is standard on 2 speed, V, models, and field installed for single speed, B, models. 3 Please contact RRS Rooftop Systems directly if Power Exhaust is required. 4 Please use part number DPE1803002 / DPE1803004 / DPE1803007 if Power Exhaust is required. Note: Where multiple variations are available, the heaviest combination is listed. 6 www.daikincomfort.com SF-DCG15
Roof Curb #14CRB180300 4 3 2 1 D 123.5 CURB TOP O.D. 120.25 CURB I.D. D 17.25 17.25 17.25 S 4 C S/A R/A 74.75 CURB I.D. C 61.88 22 61.88 22.88 78 CURB TOP O.D. B INSULATED PANELS 4 4 11.25 1.63 TYP. B 1.75 1.75 3 14 1.38 123 CURB BOTTOM O.D. TYP. 77.5 CURB BOTTOM O.D. DRAWN mikeg CHECKED 4/28/2010 A QA MFG TITLE 14CURB180-240 A APPROVED 4 3 2 SIZE C SCALE DWG NO 1 SHEET 1 OF 1 REV Specifications 14-Gauge Construction 1 x 4 Wood Nailer attached to top of the curb Shipped knocked down with all hardware Gasket included Bed-Rail style corners Note: outside duct dimension should be ½ less than opening dimensions above. SF-DCG15 www.daikincomfort.com 7
Manual Fresh Air Damper #D25MFD180300 Motorized Fresh Air Damper #D25MFD180300 Specifications Manual Damper Provides up to 25% fresh air Locking selection knob provides constant opening Painted to match the unit Fits 15-25 ton package units in all fuels Motorized Damper 24 VAC Damper motor with spring return Fully assembled and factory wired Painted to match the unit Fits 15-25 ton package units in all fuels 8 www.daikincomfort.com SF-DCG15
Downflow Economizer #DDNECNJ1803000B Specifications Fully modulating Up to 100% fresh air Integral barometric relief Hoods painted to match unit Honeywell economizer control Single adjustable enthalpy control convertible to dual enthalpy Adjustable minimum fresh air Factory wired Gas/Electric for 15-25 ton units SF-DCG15 www.daikincomfort.com 9
Power Exhaust for 208/230v Units #DPE1803002 Power Exhaust for 460v Units #DPE1803004 Power Exhaust for 575V units - #DPE1803007 Specifications Features propeller-type fans 208/230V and 460V models available Used in conjunction with DNECONHP150 or DNECONGS180240 Fans engage when economizer fresh-air dampers are 70% open Gives up to 100% relief Integrates into downflow economizer hood 10 www.daikincomfort.com SF-DCG15
Concentric Duct Kits #CDK180, #CDK240 & #CDK300 Light Commercial T-Bar Ceiling Commercial T-Bar Ceiling Hanging Support from the Diffuser Turing Vane to Ensure Proper Airflow Aluminum Egg Crate Specifications All-aluminum diffuser with aluminum return air egg crate Built-in anti-sweat gasket Molded fiberglass transition (through five tons) Built-in hanging supports Diffuser box constructed of fiberglass duct board (through 7½ tons) or sheet metal Molded Fiberglass Transition SF-DCG15 www.daikincomfort.com 11
Notes Our continuing commitment to quality products may mean a change in specifications without notice. 2016 Houston, Texas Printed in the USA. 12 www.daikincomfort.com SF-DCG15