TP Made In merica dvanced eating & ot Water Systems Series ighly fficient, ombination, omestic ot Water and Space eating ppliances Up To 96% fficient TP Made In merica TP Made In merica TP Made In merica -ydro -lame Save nergy, Save Money, Save Space and Save On Installation
ombination eaters ombination eaters, are ver y popular today because they can save space and money. ombination heater is a compact and efficient unit that provides all the space heating (such as in-floor radiant heating, baseboard heating and fan assistance air handler heating), and all the domestic hot water a home needs while saving on operating and installation costs. Why install a boiler, a water heater, and a buffer tank, when you can install just one combination unit and save money, space and on installation. The Series: ombined ydronic ppliances from TP represents the latest innovations in heating technology today. These modulating condensing gas appliances operates at ef ficiency rates up to 96%, contributing not only to the environment s well-being, but to the consumer s as well. The all-in-one design of the Series appliances results in considerable space and cost savings, setting a new standard for environmental responsibility, energy conservation, and consumer convenience. ydro The -ydro is the choice for units that call for plentiful domestic hot water over space heating needs. With ample domestic hot water storage (available in 3 gallon sizes from 55-119) the -ydro delivers massive amounts of water, reaching up to 335 gallons during the first hour rating @ 100 rise. The space heating module (up to 135,000 TU with a max temp of 160.) creates heat from the brazed plate heat exchanger, drawing energy from the stored heat in the tank to efficiently heat the home. lame The -lame is the choice for units with space heating as a primary need over domestic hot water. Space heating, available in units that deliver as high as 199,000 TU with up to 180. The heat exchanger of the -lame is constantly surrounded by 55 gallons of hydronic mass reducing cycling due to its low pressure drop. The tankless water heater draws energy stored in the tank boosting domestic hot water production. The -lame delivers 4.8 PM of endless hot water with a first hour rating of 300 gallons @ a 77 rise. lame LO S R LO O at TP s dvanced ydronic eating ppliance Pump Stainless Steel Tank Low Water ut Off Sensor Internal ir/irt Separator low Switch razed Plate eat xchanger State of the rt ontrol oard ybrid upronickel Stainless Steel ombustion eat xchanger igh fficiency eat & ndless ot Water Vents in Inexpensive, PV or PV pipe, with ombined quivalent Vent Lengths up to 200 - Room ir Intake
-lame ndless ot Water: irst our Rating (P): up to 300 P @ a 77º Rise t a 77 rise, deliver domestic hot water instantaneously up to 4.8 gallons per minute to multiple outlets Low maintenance design ill a tub faster than any tankless appliance R-IRULTOR PUMP OL INLT LL VLV VLV SIN OL INLT TU VLV SOWR RIN VLV TMP U LL VLV PRSSUR RLI VLV UNION OT OUTLT -lame VS ompetition ombi ppliance TP -lame ompetition VRS-LM R-IRULTIN Single Loop esign (eliminates need for primary secondary circulation) YS NO igh Mass 55 allons NO Low Pressure rop YS NO -lame Model Tank Size igh fficiency, igh Mass Space eating: Modulation provides up to 5 : 1 turndown ratio Thermal mass in the 55 allon stainless steel tank provides a buffer against cycling during low load conditions Single loop installation: The heat exchanger, constantly surrounded by water, is protected against flashing due to low flow conditions Up to 95% thermal efficiency Retro it: mple thermal mass, minimizing the change to piping, no secondary piping needed Room air intake, PV and PV venting with combined vent lengths up to 200' in 3" pipe 12 year limited Warranty TU / Input Range pprox. Shipping Weight al. per minute @ 77º rise 1st our Rating @ 77º Rise eight / iameter PR-130-55 55 gal. 35,000-130,000 190 lbs. 3.2 210 P 68 / 2 PR-160-55 55 gal. 40,000-160,000 197 lbs. 3.85 250 P 68 / 2 PR-199-55 55 gal. 40,000-199,000 197 lbs. 4.8 300 P 68 / 2 -lame pplications: Radiant floor an coil aseboard ombined heating & W Snow Melt uffer tank Retro fit
omparison Series Which ombi? - ydro Space eating: up to 160º 1st r. Rating @ 100º Rise up to 335 gal. - lame Space eating: up to 180º 1st r. Rating @ 77º Rise up to 300 gal. Product -ydro -lame Summary igh efficiency water heater with a space heating component, providing a large dump load capability for domestic hot water and space heating up to 130,000 TU at 160º ndless hot water and space heating with high volume of thermal mass and the ability to deliver a large volume of domestic hot water: 4.8 gal per minute @ 77º rise and space heating: up to 180º fficiency Up to 96% Thermal fficiency Up to 95% Thermal fficiency Turndown Ratio 5 to 1 Turndown 5 to 1 Turndown Range vailable in 3 gallons sizes 55, 80 and 119 with two TU outputs ranging from 130,000 TU to 199,000 TU vailable in three TU inputs ranging from 130,000 TU to 199,000 TU Serviceability Removable front cover with access to space heat pack as well as removable front cover with access to control board and combustion system Removable top cover for access to domestic hot water pack with removable front cover for access to combustion system and control board esign The -ydro fits the equivalent of a 135,000 TU boiler, an indirect water heater, and a buffer tank into one small footprint The -lame combines your space heating and domestic hot water into the same sizing footprint as a hot water tank onstruction ybrid stainless steel /cupronickel heat exchanger - Stainless steel tank Venting Room air intake, PV, PV Pipe, irect vent, flexible pipe (TP approved), oncentric ontrol eatures Two-line 20-character L control panel; capable of cascading up to 8 boilers; includes outdoor reset capability - TOTL SYSTM ONTROL 3-digit control display; capable of cascading up to 8 heaters; includes outdoors reset capability Tax redit ligibility ederal Tax credit for residential application as circulating water heater Warranty 12 year limited warranty 12 year limited warranty
-ydro Space eating & omestic ot Water ombined -ydro Model P130-55 / P199-55 P130-80 / P199-80 P130-119 / P199-119 L. 55 80 119 TU S SP TIN MOUL TU'S MX. SP TR TMP. 1st r. Rating@ 100º. Rise Recovery @ 100º. Rise 205 gal. 148 P 160 295 gal. 229 P 227 gal. 150 P 160 314 gal. 229 P 257 gal. 152 P 160 335 gal. 230 P Modulating W burner operates up to 5:1 turndown ratio, the space heating module operates at a 10:1 turndown ratio Ultra high 96% thermal efficiency n extremely durable cupronickel and stainless steel heat exchanger boasts excellent heat transfer properties and resists corrosion Incredible system flexibility: uilt-in auxiliary taps provide connection to air handlers or storage tanks 12 year limited warranty ROM LOW TMPRTUR TIN ZONS Saves space and installation time by combining the equivalent of a 135,000 TU boiler, an indirect water heater, and a buffer tank into one small footprint The tank has minimal heat loss, due to thick, water blown, foam insulation Virtually maintenance free operation PV or PV pipe, with combined vent lengths up to 200' in 3" pipe for the 199 model and combined vent lengths up to 85' in 2" for the 130 model OL INLT VRS-YRO IR NLR PPLITION LL VLV (TYPIL) MIXIN VLV (SUPPLI) LOW PROR OT OUTLT TMP/PRSSUR U RIN/PUR VLV UNION (TYP) LL VLVS XPNSION TN IR LIMINTOR TO LOW TMPRTUR TIN ZONS ZON IRULTORS w/i XPNSION TN IR NLR Solar Option PRSSUR RUIN VLV RIN -ydro pplications: Radiant floor an coil aseboard (160º) ombined heating & W Solar version o-gen. heat recovery Retro fit uffer tank
Specifications RIN VLV -lame imensions -lame Specifications IR lame Supplyir Vent as onn Return Sizes Vent Size 1.25" NPT (130) (160, 199) 1/8 RIT SI (SOLR) TMP/ PRSSUR RLI VLV T&P PORT ydro M INT IRIR INT UXILIRY ONNTION 23" 5 8 6.5" 68 7.5 2 8 6 34 L XUST XUST LTRIL ONNTIONS N RIN VLV RIN VLV O UXILIRY ONNTION LT SI I LIMIT STY OT WTR OUTLT LOW WTR UT-O VRS-YRO WTR TR SPIITIONS MOL #* TU S SP TIN MOUL TU'S IR INT/ XUST P130-55 / P199-55 IRIR P130-80 / P199-80 P130-119 / P199-119 WTR INLT/ OUTLT UX. ONN. ONN. SYSTM RLI PIP SIPPIN WIT 205 lbs 265 lbs 435 lbs UPPR TMP SNSOR LOWR TMP SNSOR OL WTR INLT IR INT ONNST RIN XUST T&P PORT T&P PORT VRS-YRO SOLR WTR TR SPIITIONS MOL #* TU S P130-80S / P199-80S P130-119S / P199-119S SP TIN MOUL TU'S IR INT/ XUST WTR INLT/ OUTLT UX. ONN. SYSTM RLI PIP SIPPIN WIT 275 lbs 445 lbs ONN. RONT VRS-YRO WTR TR IMNSIONS MOL #* LLONS P130-55 / P199-55 55 2 34 5 46 5½ 19½ 7-3/8 14½ 5 14 P130-119 / P199-119 119 27 74 6 7½ 20½ 8-3/8 15½ 6 14¼ P130-80 / P199-80 MOL #* 2 34 7 6 20½ 8-3/8 15½ 6 1 VRS-YRO SOLR WTR TR IMNSIONS P130-80S / P199-80S* P130-119S / P199-119S* * NX 80 LLONS 80 2 34 119 27 7 6 38½ 26 24 31¼ 74 6 7½ 38½ 26 24 3 L 46 M T P 46 6 64½ L M 6 66½ N O 64½ 64½ 10¼ 10¼ 64½ 64½ ( N o e a t x c h a n g e r ) Ve r s i o n o f t h e Ve r s a - y d r o i s a v a i l a b l e. * No suffix denotes natural gas and suffix LP denotes propane gas In keeping with its policy of continuous product improvement, TP reserves the right to make changes without notice. 120 raley Road, ast reetown, M 02717 www.htproducts.com M TLIT-35-06 / 2011 TP