All your heating and hot water solutions with high energy savings www.auer.fr 2016 Catalogue FRENCH MANUFACTURER
centre de recherches et d innovations Auer: a centre for research and innovation AUER has been on the cutting edge of research and innovation for over 120 years, and we offer a wide variety of heating and domestic hot water solutions for domestic, community and tertiary installations. Thanks to our multi-energy solutions (gas, fuel, renewable energies), AUER can provide the right solution for you to ensure your comfort and well-being. At AUER, we are dedicated to producing high-quality products which save energy, are easy to install and user-friendly. We pride ourselves on our strong ecological approach and our products all meet the requirements of the most recent European and French heating regulations. All AUER products are designed, developed and manufactured at our plant in northern France. This unique concentration of skills and craftsmanship showcases our savoir-faire. Our marketing team will ensure that there is always someone on hand to provide you with all the information you need about AUER products. 2
3 CONTENTS HEAT PUMPS HRC 70... 4 HEAT PUMP WATER HEATERS Edel... 6 Xiros AIR... 8 Cylia AIR...10 Edel, Xiros & Cylia WATER...12 COMMERCIAL SOLUTIONS Heat pump water heater solutions...14 Gas solutions...16 BOILERS Pulsatoire...18 Lélia...20 Gialix...22 Rembrandt...24 HYDRAULIC MODULES Logix...26 CIC Modules...27 Thorix ÉVOLUTION...28 MURO VENTILATION UNIT...29 GAS RADIATORS AND FIRES Dulcis & MV...30 Radiators and fires...31
HRC 70 70 C HIGH TEMPERATURE MODULATING HEAT PUMP 7-140 kw Heating guaranteed, even in extreme cold 100% heat pump DOWN TO -20 C PATENTED TECHNOLOGY HFC FREE R290 up to A + HIGH PERFORMANCE A genuine high-temperature heat pump which provides heating up to 70 C even on extremely cold days. Modulating power: guaranteeing excellent seasonal performances. Equipped with a multifunctional hydraulic pilot for turnkey installation. Extremely quiet thanks to the low-speed fan Runs using only the heat pump until the outdoor air temperature drops to - 20 C. Wide range for domestic use: - 7 and 11 kw - 17, 20 and 25 kw - 35 kw Heating water up to 70 C Energy efficiency A+ THE RESULT : For 1 kwh of electricity, up to 4.5 kwh of heat goes back into the heating circuit ECO-FRIENDLY AND ECONOMICAL EVEN MORE ECO-FRIENDLY equivalent potential in tonnes.. The HRC 70 uses a very low quantity of refrigerant which is not a fluoride gas. The result: the potential equivalent of 10 tons of CO 2 is avoided. Energy category: A+ Eco-friendly refrigerant which is not subject to a mandatory annual maintenance check HP HP 4
HYDRAULIC STRUCTURE OF THE PILOT The Pilot provides smart decoupling of the water flow in each circuit, making your installation safer and more reliable. It degasses, decants and desludges your installation PILOTE XS Heating circuit PILOTE PREMIUM It enables you to control 2 heating circuits. Bypass It is equipped with 0-6 kw electrical back-up Heat Pump circuit Heating circuits Heat Pump boiler It controls a back-up boiler FULLY EQUIPPED, READY TO INSTALL BATTERY installation from 35-140 kw The solution for commercial, tertiary and industrial buildings The hydraulic management system ensures optimum management of the heat pumps The decoupling tank guarantees the safety and durability of the installation COMPLETE CONTROL OF THE INSTALLATION THANKS TO HYDRAULIC MANAGEMENT For heating: apartment blocks, offices, schools, farm buildings, hotels, industrial buildings, etc. Start-ups in stages to increase power progressively Wall-fitted, hydraulic control system, including the regulation for linking 2, 3 or 4 HRC 70 s. A 200 L multi-functional decoupling tank, which decouples, degasses the hydraulic circuits, decants sludge and stratifies temperatures. Example of a 3x25 kw battery installation for an apartment block 5
NEW Edel THE REVOLUTIONARY SANITARY WATER HEAT PUMP 200 and 270 L A Naturally economical hot water LOW ENERGY at 1 m PATENTED TECHNOLOGY DESIGNAPPROVED CATEGORY A AN INNOVATIVE DESIGN Optimum heating for your water thanks to the patented ehd high performance heat exchanger OUTSTANDING C O P 3.44 standard NF 16147 EXCLUSIVE: all STAINLESS STEEL Regular system A pipe rolled around the tank, creating an imperfect contact surface. Highly efficient compressor Reinforced airtightness Stainless steel tank : no anode Variable speed fan Patented ehd heat exchanger An aluminium heat exchanger with mini channels that maintain perfect contact with the tank for highly efficient heat transfer. LITTLE ENVIRONMENTAL IMPACT A great advantage for the environment: contains no greenhouse effect gasses Up to 80 % free energy extracted from the air to heat your domestic water SMART CONTROLS Choose your mode according to your needs: BOOST, COMFORT, ECO or HOLIDAY Automatic heating time function Integrated 'day/night' contact for operating on off-peak time. 6
THE MOST ECO-FRIENDLY ANNUAL DHW CONSUMPTION THE MOST ECO-FRIENDLY SOLUTION kw/h* 1630 1790 Equivalent CO2 emissions over 15 years 5868 Over 90% CO2 emissions saved 3000 710 2787.4 2417 360 488.8 Edel 200 HPWH currently on market Gas condensing boiler Electric water heater Edel 200 HPWP currently on market Gas condensing boiler Electric water heater *Example:100m 2 house The Edel uses up to 5 times less energy than an electric water heater COMPACT AND USER FRIENDLY Outdoor air source installation THE PLUSES FOR INSTALLERS Inlet and outlet nozzles that rotate through 360 Easy to move thanks to the transport bag it comes with. 630 0 tank with improved, reinforced insulation THE MOST ECONOMICAL AND ECOLOGICAL SANITARY WATER HEAT PUMP ON THE MARKET A SMART PRODUCT The Edel will respond to external requests and alter its hot water temperature to store more heat coming from renewable energy sources, such as solar panels or wind turbines. It modulates its electrical power to suit the consumption needs of each site. Encore plus compact et plus pratique pour faciliter le transport et l installation 7
Xiros AIR THE ONLY WALL MOUNTED HEAT PUMP, WITH CONCENTRIC AIR DUCTS 50-150 L Revolutionising water heating A PATENTED TECHNOLOGY LOW ENERGY DESIGNAPPROVED CATEGORY A EFFICIENT The Xiros is classed in the highest energy-saving category: It is the best solution for new builds and renovation projects The Xiros provides domestic hot water and maintains it at 60 C using only the heat pump, right down to an outdoor temperature of -7 C The Xiros is ultra-quiet and can be installed in your living space ECONOMICAL Check how much electricity you re using... The Xiros uses 3 times less than an ordinary water heater Improve ENERGY EFFICIENCY in your home The integrated heat pump extracts free calories from the air. Thanks to the heat pump, hot water is made available very quickly and at a very low cost. The Xiros can make you up to 70% energy savings The Xiros helps to reduce your electricity consumption and only requires 250W on average. ECO-FRIENDLY Helps reduce CO2 emissions thanks to its low energy consumption and high efficiency Protects the o-zone layer and doesn t add to the greenhouse effect The only water heater to use a natural refrigerant in a very low quantity (just 80g). EASY TO INSTALL Compact, with 50 cm diametre and the 50L model is just 88cm high A wall bracket to make installation even easier: - the existing holes can be used - sturdy and reliable material - guarantees that your appliance will be perfectly vertical. Floor standing on an adjustable tripod (ref. 730007) with three adjustable feet 8
UNIQUE AND USER FRIENDLY With patented-technology insulated concentric air ducts 125 mm 80 mm Air inlet Air outlet Several connection options OUTDOOR AIR - Horizontal air duct - Vertical air duct AMBIENT AIR - Unheated premises - Non-heated premises with outdoor air exhaust Only one hole to drill: easy to connect thanks to the small diametre of the insulated concentric air duct (125 mm) Up to 5m of air conduits with piping Up to 10m through a chimney free calories from the air heat pump a range of 50, 80, 100 or150 L tanks to suit all of your DHW* needs Can rotate 360 smart controls, backlit screen - HOLIDAY mode to avoid energy consumption in case of prolonged absences - BOOST Mode to occasionally speed up heating if extra hot water is needed - Weekly programming to choose your heating modes day by day - COMFORT + Mode to guarantee you hot water in any circumstances 9
Cylia AIR FLOOR STANDING HEAT PUMP WATER HEATER - 300 L Recognised as the best heat pump water heater in its category A INNOVATIVE DESIGN Up to 75 % FREE ENERGY for Domestic Hot Water Certified and recognised with the NF 3-star performance label: COP of 3.03 in accordance with EN 16147 It provides domestic hot water and maintains it at 60 C using only the heat pump right down to outdoor temperatures of -7 C Smart and economical de-icing Very compact and easy to incorporate into low-height premises such as a basement. PATENTED TECHNOLOGY Easy to use LOW ENERGY DESIGNAPPROVED CATEGORY A Set your desired water temperature SMART CONTROLS Dynamic and extremely low-energy de-icing Ventilation function with the heat pump: constant or external control Choose BOOST, COMFORT, ECO or HOLIDAY mode depending on your needs An automatic anti-bacterial cycle is carried out at your desired frequency, using only the heat pump GUARANTEED PROTECTION AGAINST CORROSION Thanks to the magnesium anode that works without electricity ULTRA QUIET Soundproof outer casing and hood Variable-speed fan High-performance rotary compressor fixed on 3 silent blocks Air inlet and outlet situated on top to reduce noise levels. User friendly Transport bag with handles to make handling easier Removable soft-cover casing - protects against impacts - interchangeable 10
USER FRIENDLY Can rotate 360 Just as easy to connect as a standard electric boiler Up to 20 m piping possible with PVC pipes and 10m with flexible hose with a diametre of just 160mm Cylindrical air inlets and outlets that can be rotated through 360 COMFORT FOR THE WHOLE FAMILY Even in winter, the large amount of stored water can be heated up to 60 C, using only the heat pump For occasional extra hot water: - The target temperature can be set to 65 C (using electrical back-up) - BOOST mode will double the power and speed up heating. This function is automatically cancelled as soon as the target temperature is reached. Up to 800 L of hot water per day OUTDOOR or AMBIENT AIR source Thanks to its low height, the Cylia AIR can be fitted anywhere The Cylia AIR can easily be transported in a van, in a vertical position. It can also be transported horizontally if necessary. The appliance is fully ready to operate (no intervention necessary on the refrigerating circuit) Adjustable feet to adapt to any floor Transport bag included with delivery Hydraulic Heat Exchanger The Cylia AIR is also available with one or two hydraulic heat exchangers to connect to another heat source (solar or boiler) Cylia AIR Cylia AIR with 2 heat exchangers Cylia AIR with 1 heat exchanger 11
Edel, Xiros & Cylia WATER HEAT PUMP WATER HEATERS ON A WATER LOOP 50-300 L Do you have underfloor heating? The Edel, Xiros & Cylia WATER use return flow water from your underfloor heating or any other very low-temperature heating circuit to heat your domestic water. LOW ENERGY DESIGNAPPROVED CATEGORY A PATENTED TECHNOLOGY A UNEQUALLED QUALITIES: - easy to install, only one hydraulic connection - high thermal efficiency, with a > 4 COP - incomparably quiet - more comfortable, safer and more efficient than a heat pump which provides both heating and hot water (up to 60% savings). OUTSTANDING COP 4.1 standard NF 16147 HIGHLY EFFICIENT The integrated heat pump extracts calories from your underfloor heating return flow water with an outstanding COP. In summer, the free heat drawn from your underfloor heating goes back into your domestic hot water while cooling your house down at the same time. In winter, the Xiros and Cylia WATER use the heat from the underfloor heating return flow to heat the domestic water with an outstanding COP. They are very compact and can be fitted anywhere in a house. ULTRA QUIET No fan, making it even quieter. High-performance compressor fitted on 4 silent blocks Easy to use Set your desired water temperature Choose BOOST, COMFORT, ECO or HOLIDAY mode depending on your requirements An automatic anti-bacterial cycle is carried out at your desired frequency, using only the heat pump 12
HOW DOES IT WORK? How it operates outside heating periods Edel, Xiros or Cylia WATER FREE HEAT FROM THE SUN Underfloor heating 20 C WATER DIVERSION DEVICE (INCLUDED) Domestic Hot Water Domestic Cold Water In summer, the free heat drawn from your underfloor heating goes back into your domestic water while cooling your house down at the same time, with an outstanding COP of up to 4.1. How it operates during heating periods Outdoor air -10 C POMPE À CHALEUR OU TOUT AUTRE RÉSEAU DE CHALEUR (GÉOTHERMIE, SOLAIRE ETC..) Underfloor heating 30 C WATER DIVERSION DEVICE (INCLUDED) Edel, Xiros or Cylia WATER Domestic Hot Water Domestic Cold Water In winter, the Cylia WATER and Xiros WATER extract free calories from the outdoor air, through the generator which supplies the underfloor heating, to provide water at 60 C. WATER DIVERSION DEVICE INCLUDED Low-energy circulator pump cabled in and fitted under the hood Less than 10 Watt energy consumption RETURN FLOW FROM UNDERFLOOR HEATING CIRCUIT Ø 1" 2 1 SUPPLY FLOW TO Cylia or Xiros WATER 3/4" Ø 3/4" Ø RETURN FLOW FROM Cylia or Xiros WATER Problem-free installation A > 35 C primary circuit mixing valve can be connected for the water diversion device (optional) 1 MANUAL STOP VALVES 2 CHECK VALVE 13
HEAT PUMP WATER HEATER SOLUTIO FOR COMMERCIAL, TERTIARY AND INDUSTRIAL APPLICATIONS COMMERCIAL HOT WATER PRODUCTION BY HEAT PUMP MégaPAC 35-140 kw A modular solution adapted to each project: - unlimited storage - unlimited power From 7 kw to several hundred kilowatts 500 L - 3 000 L in one storage tank Several tanks can be installed together for unlimited volume Anti-legionellosis treatment, 100% heat pump Sturdiness and finesse with a Gialix wallhung electric boiler as back-up Any other back-up type can be used - Pulsatoire boiler - electrical element in tank - solar thermal - district heating network INSTALLATION EXAMPLE HRC 70 heat pumps, battery installation HRC 70 Pilot Decoupling tank DHW tank 14
NS FOR COMMERCIAL DHW INDIVIDUAL HOT WATER PRODUCTION BY HEAT PUMP Edel 200 and 270 L Floor standing Very compact: 630 mm Ø Water inlet and outlet can be connected at the front Stainless steel tank = no anode maintenance Recommended for low energy consumption buildings High energy class (ERP) Find out about all our electrical heating solutions for communal housing CS = 0.05 Edel 50-150 L Wall-hung Very compact: 520 mm Ø Easy to fit into all types of configuration thanks to the concentric air duct. Only one 125mm Ø pipe is needed A wide range of products is available to suit all needs and all accommodation, from a studio to a three-bedroom property Complies with the latest French heating regulations 15
GAS SOLUTIONS FOR COMMERCIAL FOR COMMERCIAL, TERTIARY AND INDUSTRIAL APPLICATIONS Logix + MTHL THERMAL MODULE WITH DOMESTIC HOT WATER STORAGE CAPACITY For individualised heating and domestic hot water supply in community housing All the advantages of a boiler room, the comfort of individual control and energy consumption per person. + 5 8 8 9 9 7 7 6 Service shaft Apartment 1 Apartment 2 1 Circulator pump(s) 2 Heating supply 2 Communal boiler room 3 Heating return 1 4 Domestic cold water pipe 5 MTHL hydraulic distribution module 6 Domestic cold water manifold 7 Radiator / underfloor heating circuit 8 Logix central unit 4 3 16 9 Optional extras: - Room temperature sensor, room thermostat
HOUSING Pulsatoire GAS CONDENSING BOILER WITH PULSE REACTOR 64-240 kw - The most eco-friendly gas condensing boiler on the market, with the best energy consumption levels - Less power required - Power start-ups in stages - The Pulsatoire will only use as much energy as it needs, depending on the outdoor temperature - Power production is decentralised, which prevents distribution losses and affords you more flexibility for managing your heating VS tank heaters 500-3000 L - Enamelled tank - Coiled thermal heat exchanger - Soft-cover casing, fire safety category M1 - Thick steel, tested to 10 bar - Ideal to combine with Pulsatoire gas boilers or HRC 70 heat pumps. 17
Pulsatoire GAS CONDENSING BOILER WITH PULSE REACTOR 20-240 kw Eco-friendly and economical PATENTED TECHNOLOGY A LOW ENERGY DESIGNAPPROVED CATEGORY A THE PULSATOIRE: A ONE-OF-A-KIND TECHNOLOGICAL WONDER THE MANY ADVANTAGES OF A PULSATOIRE A complete range is available to meet any needs: - 20 kw, 32 kw, 40 kw and 60 kw boilers - battery installation possible for 64 kw to 240 kw 50mm 63mm All you need for combustion exhaust is a simple PVC pipe Durability and reliability: Thanks to its self-cleaning function, this boiler is always at peakperformance level Incredibly efficient, up to 109% LHV: The 800 C temperature in the combustion chamber drops to 25 C as it leaves the boiler Up to 40% savings on your gas consumption: Continuous condensation means that almost all of the energy produced is transferred to the water for your heating The genius of the Pulsatoire simple design easy to install user-friendly highly efficient 4 times less electricity consumption: The Pulsatoire uses 4 times less electricity than other condensing boilers as it doesn t need to extract combustion products 3-circuit self-adapting regulation: Can manage an underfloor heating circuit, a radiator circuit and a domestic water circuit Change your old boiler for a Pulsatoire: and you will improve energy efficiency without having to change your energy source A patented-design stainless steel heating body, which is perfectly adapted to condensation, guaranteeing durability and efficiency. 18
THE BEST FOR THE ENVIRONMENT Naturally smart The pulse reactor function limits greenhouse gases (CO 2 ), and brings NOx emissions almost down to zero. Can manage up to 3 seperate circuits: (radiators, fan coil units, underfloor heating, DHW, swimming pool, etc...) COMFORT, ECO, or FROST PROTECTION, modes available to ensure optimum comfort when you re at home and savings when you re not. 60-240 kw for commercial, tertiary and industrial applications Less power needed: fitting a battery series of Pulsatoire boilers instead of one high-energy-consumption boiler gives greater flexibility for the user and requires less power Heating capacity increases in stages It will only use as much energy as it really needs, depending on the outdoor temperature Unlimited heating capacity: Heating capacity can reach several thousand kilowatts: this makes it the ideal solution for heating hotels, offices, factories or farm buildings. Pulsatoire boilers can easily be installed near to their points of use to reduce distribution losses. Watts 700 600 500 400 300 200 PERTES WASTE GENERATED A L ARRÊT FROM GAS CONDENSING BOILERS DONNEES WHEN NOT PERRENOUD RUNNING RT 2012 661 464 428 370 187 100 0 PULSATOIRE Chaudières Gas condensing gaz boilers à condensation currently on du the marché market P ~ 250 kw 240 kw THE BEST ENERGY CONSUMPTION LEVELS UP TO 5 TIMES LESS WASTE WHEN NOT RUNNING depending on model According to calculations and findings in thermal data, waste when appliances are not running impacts more on a building s energy consumption than efficiency does. The Pulsatoire boiler has very low waste levels when not running, which makes it the most efficient gas condensing boiler room solution. 19
Lélia WALL MOUNTED OR FLOOR STANDING GAS CONDENSING BOILER 8-30 kw Up to 40 % savings compared to a regular boiler PATENTED TECHNOLOGY A LOW ENERGY DESIGNAPPROVED CATEGORY A OUTSTANDING EFFICIENCY Optimum efficiency: up to 109 % and energy savings of up to 40 %. Modulating heating control of up to 24 kw depending on the outdoor temperature. Modulating domestic water control of up to 30 kw to provide domestic hot water at the desired temperature, even in large quantities The installation has a high-performance degassing chamber to degas and purge extremely quickly and to provide better protection against corrosion. OPTIMUM SAFETY A filter valve with a stainless steel screen retains any dirt particles coming from the heating circuit. A permanent flow rate monitor keeps track of the water flow rate in the installation to prevent any abnormal rise in temperature in the heating body. An integrated bypass means that there is no need for a differential valve, even on an installation which is entirely equipped with thermostatically controlled valves. Instantly available MICRO-ACCUMULATED domestic hot water The Lélia constantly maintains the DHW temperature in its oversized stainless steel heat exchanger. The result: hot water is available immediately, whatever rate it may be drawn at. Customised operation: the Lélia Mixte can be used for microaccumulated DHW or instant DHW with a simple adjustment to the settings. LOW MAINTENANCE Sturdy and reliable valves are included, which enable you to isolate the boiler from the rest of the installation. Incredibly quick and easy access to all of the boiler s components and accessories via the front panel. The screen filter can be cleaned without draining the installation. The burner is quick and easy to remove for annual cleaning. 20
PRODUCT RANGE LÉLIA MIXTE Heating and instantaneous domestic hot water With a flow rate of up to 14.5 L per minute LÉLIA ACCUMULATION Heating and accumulated domestic hot water Incoming from the heating body Outgoing to the heating body Incoming from the heating body Outgoing to the heating body DHW tank DHW DHW Heating water Plated heat exchanger DCW Circulator pump Water sensor Circulator pump Heat exchanger for domestic water Hydraulic distribution panel 3-way valve Hydraulic distribution panel 3-way valve DCW With a flow rate of up to 14.5 L per minute, without drawing from the tank: the boiler will work like a Lélia Mixte. Incoming from the heating body Heating water LÉLIA PROFUSION Instantaneous and accumulated heating and DHW Plated heat exchanger Circulator pump Outgoing to the heating body DHW tank DHW Connection Easy and safe connection to exhaust gas pipe: - sliding ring - connection elbow can rotate through 360 Exhaust - Horizontal air duct 60 /100 Ø up to 14 m - Vertical air duct 60 /100 Ø up to 14 m 80 /125 Ø up to 23 m - Chimney 80 Ø up to 30 m - Compatible with communal flue systems up to 14 m Hydraulic distribution panel 3-way valve Water sensor DCW What's the Lélia's secret? The CAST-IRON hydraulic distribution panel From 14 L per minute to 29 L per minute, the boiler will draw the extra hot water needed from the reserve accumulated in the tank, providing a flow rate of up to 29 L per minute. Water sensor DHW DCW Tank can be positioned on the left OR right The cast-iron hydraulic distribution panel incorporates all the main hydraulic components, which makes it extremely compact and gives easy access to parts. Lélia Profusion WALL HUNG Lélia Profusion FLOOR STANDING 21
Gialix ELECTRIC, MODULATING WALL MOUNTED BOILERS 2-196 kw An outstanding boiler for outstanding efficiency LOW ENERGY DESIGNAPPROVED CATEGORY A Heating and domestic hot water for new-builds and renovation projects: Domestic applications: 0.7 to 24 kw Tertiary applications 36 to 196 kw No storage tank or fuel pipes needed Odourless NUMEROUS ADVANTAGES The carefully chosen components and smart design make the Gialix an extremely quiet and reliable boiler No CO / CO 2 / NOx emissions Seasonal efficiency 100% guaranteed Every kw used goes back into your heating CAST IRON Making the Gialix the most efficient electric boiler Robust and corrosion-proof. Hard-wearing over time. 100 % recyclable. Monobloc moulded, incoporates all hydraulic components, eliminates the need for piping and the risk of leakage No gas or fuel leaks No chimney or piping needed No installation work required No mandatory annual maintenance Only one energy provider needed Integrated load shedding function Energy billed after use Stable energy costs Ultra-quiet modulating regulation UNIQUE The boiler degasses naturally thanks to the hydraulic connections being on top of the boiler Access to all hydraulic components through the front of the boiler. Hydraulically equipped for up to 24 kw. The inertia of the cast iron heating body means it operates gently and steadily, giving you greater comfort. 22
DOMESTIC USE Maximum power, adjustable to fit with the latest thermal regulations (RT 2012) 6 kw : - 0 to 2 kw 12 kw :- 0 to 2 kw 16 kw :- 0 to 2.7 kw - 0 to 4 kw - 0 to 4 kw - 0 to 5.3 kw - 0 to 6 kw - 0 to 6 kw - 0 to 8 kw - 0 to 8 kw - 0 to 10.7 kw - 0 to 10 kw - 0 to 13.3 kw - 0 to 12 kw - 0 to 16 kw TERTIARY USE GIALIX 12MT - 2 CIRCUITS community housing and the tertiary sector - radiators - underfloor heating - unit heaters - domestic hot water etc.. Community domestic hot water with a plated heat exchanger or heating tank Swimming pools, with a plated heat exchanger Industrial processes Designed to supply 2 independent heating circuits: - 1 underfloor heating circuit + 1 radiator circuit - 2 radiator circuits - 2 underfloor heating circuits 2 independent cast iron heating bodies Adjustable maximum power : - 2 kw (0 to 2 kw) 2 x - 4 kw (0 to 4 kw) - 6 kw (0 to 6 kw) Back-up for renewable energies Wall mounted and very compact, easy to install anywhere TA1 Underfloor heating RTS2 TA2 Radiators Gialix 2 circuits FINE-TUNED CONTROLS FOR PRECISE REGULATION The Gialix MT range is enhanced with electronic power modulation: - Reliable and long-lasting (no mechanical wear) - Extremely quiet - continuously produces and diffuses just the right level of heat As well as this, the Gialix MT range is highly monitored with both the finesse of electrical power control and the safety of mechanical power control. Max. temp. Min. temp. Boiler temperature ( C) Ordinary electric boiler Gialix MA Gialix MT Time (minutes) Overconsumption 23
Rembrandt CAST IRON, FLOOR STANDING FUEL CONDENSING BOILER 25 and 40 kw A LOW ENERGY DESIGNAPPROVED CATEGORY A Better comfort and lower costs, without changing your energy source RCB Heating RCB 25-100 Heating + DHW The Rembrandt fuel condensing boiler uses water vapour from combustion and condenses it to recover the heat which is usually lost. The result: higher efficiency and lower consumption It is the most environmentally-friendly and economical fuel boiler on the market. OUTSTANDING PERFORMANCE The blue-flame burner and ceramic condenser provide an exceptional performance of up to 104% and also help you to make substantial energy savings Up to 40% more economical than an old boiler Changing your old boiler for a Rembrandt fuel condensing boiler means that you can improve your home s energy efficiency without changing your energy source. EFFICIENT, ROBUST AND RELIABLE A winning combination for a hardy boiler that is sure to stand the test of time: The blue-flame burner for efficient combustion and reduced NOx emissions Cast iron heating body with very thick walls, three fume paths and a large heat exchanger surface The ceramic condenser is compact and integrated into the boiler. the ceramic properties ensure better protection against acidic fuel condensates and prolong the lifespan of the boiler. Outgoing to heating fumées Fume condensation Incoming from heating 24
Rembrandt fuel or gas: HIGH PERFORMANCE Simple, robust and efficient A complete range from 20 to 40 kw to suit any needs and budget Enjoy all the qualities of the Rembrandt range: - suitable as back-up for renewable energies - little maintenance required REB 25 Chauffage REB 25-100 Chauffage + ECS OUTSTANDING PERFORMANCE The Rembrandt can be connected with air ducts or a chimney, depending on your configuration The Rembrandt is compact, making it easy to install All of the components can be accessed through the front of the boiler CAST IRON HEATING BODY Optimum resistance thanks to the cast iron heating body: robust, corrosion-proof and hard-wearing The cast iron heating body lengthens operating cycles: - reduces dirt and clogging in the burner - reduces NOx and CO emissions - highly efficient The inertia of the cast iron means it operates steadily and gently for your increased comfort. DOMESTIC HOT WATER With a Rembrandt boiler: With an integrated 100 L enamelled tank: - REB 25-100 - RCB 25-100 or Connected to an AUER tank: + RCB or REB PEJ BRV With a 100 to 300 L heat pump water heater: To save even more money, your domestic hot water can be produced using the floor-standing Cylia or wall mounted Xiros Connections: - onto outdoor or ambient air - onto return-low water from the underfloor circuit - Up to 20m piping possible Xiros AIR or Xiros WATER Edel AIR or Edel WATER Cylia AIR or Cylia WATER 25
Logix THERMAL MODULE WITH ACCUMULATED DOMESTIC HOT WATER 80 and 120 L Simple and sustainable water distribution PATENTED TECHNOLOGY B LOW ENERGY DESIGNAPPROVED CATEGORY A The Logix is a substation which manages heating and domestic hot water production for your accommodation using energy from a boiler room. It includes an 80 or 120 litre storage volume. The aim: to improve user comfort and the energy efficiency of the building, with up to 10% savings The advantages of a collective boiler room, the comfort of individual regulation and individualised consumption THE UNIQUE ADVANTAGES No need to maintain primary circuit temperature No discomfort caused by the common parts of the installation overheating in the summer. The comfort of accumulated DHW No plated heat exchanger = no scale Individual electronic regulation and heating and domestic hot water consumption displayed Simplified design = less space needed and any unnecessary piping can be removed Simplified hydraulic balancing, with the MTHL module installed in the service shaft. No DHW loop needed as long as a maximum piping distance of 8 m, horizontally or vertically, is respected. + MTHL : Multi-apartment thermal module for the Logix The interface is located in the service shaft between the collective network and the Logix units installed in the apartments 26 Logix In each apratment MTHL On the landing of each floor Heat-reading meters (2) can be installed in the service shaft on MTHL modules to monitor the cost of your heating and domestic hot water consumption. (1) Domestic Hot Water (2) not supplied
CIC* Modules MULTI-APARTMENT DISTRIBUTION MODULES FOR HEATING AND DOMESTIC WATER 1-8 apartments Streamlining collective distribution LOW ENERGY DESIGNAPPROVED CATEGORY A The interface is located in the service shaft in between the collective network and the apartments KEEPING COSTS UNDER CONTROL The distribution circuits are hydraulically independent Time saving installation Groups delivered pre-assembled and insulated Space allocated for monitoring individual consumption STREAMLINING Easy-to-balance primary output, by level (apartment loops are automatically balanced) Easy-to-recognise circuits thanks to the layout of the components Easy access to all parts 1 to 8 apartments per floor 2 versions: - standard accommodation - new builds with very low flow rate PRODUCT RANGE Heating modules EXCLUSIVE PATENTED TECHNOLOGY MTHC with circulator pumps MTH2V with 2-way control valves with thermal actuators Heating and domestic hot water modules EXCLUSIVE PATENTED TECHNOLOGY MDC with circulator pumps MD2V with 2-way control valves with thermal actuators 27
Thorix EVOLUTION HYDRAULIC MANAGEMENT MODULE For optimum management of your heating circuits EXCLUSIVE PATENTED TECHNOLOGY USER-FRIENDLY, QUICK AND EASY TO INSTALL: - For both NEW BUILDS and RENOVATION PROJECTS: manages a radiator circuit and an underfloor heating circuit - PLUS: it assists the heat pump de-icing function THE ADVANTAGES Manages mixed circuit depending on outdoor temperature Easy tests and adjustments Optimised annual performance Compact, accessible and ready to connect Low energy circulating pump EEI < 0.23 Ideal for heat pumps and condensing boilers Reduced labour time and costs Can be fitted to the wall quickly and easily Heat pump de-icing assistance function: PATENTED TECHNOLOGY The inertia from the underfloor heating serves as a heat reserve, which is needed for the heat pump de-icing cycles, making a larger reserve available. Integrated bypass Outdoor temperature function: constantly measures the temperature delivered by the generator and simultaneoulsy deducts the target temperature for the mixed circuit. Thorix ÉVOLUTION T C T C All types of generator: boiler, heat pump... Key 1multifunctional group: Low-energy, variable-speed circulator pump with 3-way motorised control valve T C 2-way motorised valve (optional extra) for controlling direct circuit RT DIRECT CIRCUIT Radiators or convector fans at the temperature of the generator MIXED CIRCUIT Underfloor heating or radiators at a lower temperature T C Room thermostat or room temperature sensor (optional extra) for mixed or direct circuits Outdoor sensor (supplied) Generator temperature sensor Thermostatically controlled valve 28
Muro HOME VENTILATION UNIT WITH HEAT RECOVERY The ideal solution for clean and healthy air in your renovation projects IMPROVED DPE AMÉLIORÉ EPC DÉDUCTIBLE DES REVENUS LOCATIFS Outstanding energy efficiency: up to In winter, the supply air is heated by the warmth of the extracted air. In summer, the air brought in from outside cools and refreshes your room at night time. THE ADVANTAGES Up to 90% energy recovery, saving you more 25% reduction in your heating consumption thanks to the high-performance heat exchanger 4-speed fan Up to 55m 3 /h renewed air Energy savings Up to 90% heat recovery from extracted air 25% less heating needed: mandatory minimal air renewal means a substantial reduction in heat losses. DC technology, low energy fans Motorised shutters, ensuring that the appliance is completely airtight when not running Optional: air quality control for adjustable air flow Comfort No draughts Controlled air renewal. Improved air quality, due to a reduction in humidity and dust in the air. Easy to use Integral control with display Adjustable flow rate15/30/45/55m 3 /h. or Auto (optional) Automatic de-icing Removable filters which are easy to access from the inside Control 4 appliances with just 1 remote control (optional) Set air flow levels IN DESCENDING ORDER (4 to 1 speeds) Set air flow levels IN ASCENDING ORDER (1 to 4 speeds) Supply air Heated supply air Stale indoor air Cooled stale exhaust air ULTRA FAST air recycling Ambient air recycling VIA THE AIR QUALITY SENSOR 29
Dulcis and MV LOW ENERGY GAS RADIATORS 100-2 200 W INNOVATIVE AND ECONOMICAL: these radiators meet the latest heating regulation requirements 30 3 Dulcis models - 100-1000 W - 100-1500 W - 100-2200 W 5 MV models - 1200-6500 W THE ADVANTAGES Very high energy output Precise modulating control NOx: category V in CE standards AUER patented horizontal duct system Low in power, adjustable to your needs No hydraulic circuit needed No electrical devices required No annual maintenance required Low installation costs Can be fitted directly onto the wall, fits easily into your room, even in corners. Easy maintenance without removing the gas line A design which combines simplicity and elegance to blend in perfectly with any decor Energy performance equivalent to that of a gas condensing boiler, without annual maintenance WORKS WITHOUT ELECTRICITY Outstanding output up to 92 % CAST IRON HEATING BODY: MAKING IT THE MOST EFFICIENT OF RADIATORS Radiates the steady, gentle heat that comes from inertia Diffuses heat gently and consistently for guaranteed comfort. Robust and corrosion-proof Long life span 100 % recyclable Moulded aluminium Visually discreet Easy to operate CAST IRON Heating body 20 year guarantee THE PATENTED HORIZONTAL DUCT SYSTEM The appliance functions with an airtight circuit which does not communicate with the air in the room. No gas can escape into the apartment so there is no risk of CO or CO 2 poisoning. radiator air inlet pipe air outlet pipe
GAS fires and radiators RN 5200 F109 VR/VT Radiators that can operate without electricity**, guaranteeing heating at any time Very low energy All the benefits of heating room by room Less costly to install than a central heating system WORKS WITHOUT ELECTRICITY CAST IRON Heating body 20 year guarantee ** ENSURING YOUR COMFORT Savings through direct heating. Only the gas energy needed to heat the room is used. This means approximately 15% less energy is used than in a central heating system. * The remarkable reliability and undisputed durability of AUER cast iron heating bodies, which come with a 20-year guarantee **. Chimney or air duct connection (depending on model) The modulating regulation enhances your comfort, as the radiators diffuse heat evenly and operate ultra-quietly These radiators work without electricity ** and are unaffected by wind, floods, ice or snow. Simplified maintenance: no annual maintenance required ** Easy to install thanks to the horizontal air duct connection (depending on model) Domestic or tertiary Visible or invisible flame *High performance boiler **Except for the Mérapi and the Séméru. 31
AUER, a certified training centre (1) We provide courses which enable participants to become operational immediately. We offer professionals a wide range of courses on installations and heating and domestic hot water solutions. The courses take place on our development and manufacturing site in Picardy; our training centre in Feuquières-en-Vimeu is equipped with specially-adapted rooms for: handling materials in a real context training with simulation control boards The photographs and information contained in this document are non-contractual. AUER reserves the right to modify all characteristics of all appliances without prior notice. Ref. B5000609 - MARCH 2016 (1) Certified training organisation n 22 75 01 376 80 (2) Courses available on demand. Minimum number of participants required. Communication materials A wide range of commercial documents are available to you on our website: www.auer.fr HEAD OFFICE AND EXPORT 109 boulevard Ney - 75876 Paris cedex 18 Tel: + 33 1 53 06 28 00 - Fax. +33 1 53 06 28 20 TRAINING AND TECHNICAL ADVICE Tel: +33 3 22 61 33 33 - Fax. +33 3 22 30 01 19 E-mail: enr@auer.fr 32