CHP/CCP CEILING MOUNTED AIR HANDLER (ALL CAPACITIES) BACK TO INDEX ITEM QTY. DESCRIPTION PART NUMBER BY CAPACITY 9/12 15 18/24 30 36/42 48 1 1 FRONT PANEL W/LOUVER 550-373 550-373 550-374 550-374 550-388 550-388 2 1 HEATER ASSEMBLY 240-934 240-934 240-238 240-238 240-504 240-504 3 1 LIMIT SWITCH 240-250 240-250 240-250 240-250 240-250 240-250 4 1 EVAP COIL 104-199 104-199 104-200 104-203 104-104 104-104 4A 1 HYDRONIC COIL 104-24 104-24 104-211 104-211 N/A N/A 4B 1 EVAP COIL (CHILLED WATER) 104-255 N/A 104-256 104-257 N/A 104-258 5 1 CONTACTOR (FOR 7 KW HEATER ASSEMBLY) N/A N/A N/A N/A 240-499 240-499 6 1 T-STAT (FREEZE PROTECTION THERMOSTAT) 121-005 121-005 121-005 121-005 121-005 121-005 7 1 DRAIN PAN 109-2976 109-2976 109-2951 109-2951 109-3911 109-3911 8 1 MOTOR 208/230V (DOUBLE SHAFT) 102-42 102-42 102-28 102-28 102-28 102-28 8A 1 MOTOR 208/230V (SINGLE SHAFT) N/A N/A N/A N/A 102-46 102-46 8B 1 MOTOR 115V 102-41 102-41 N/A N/A N/A N/A 9 NOTE 1 BLOWER WHEEL (1) 114-03 114-03 240-225 240-225 240-225 240-225 10 1 I/R PANEL 109-4110 109-4110 109-4107 109-4107 109-4138 109-4138 11 1 SERVICE PANEL 109-2978 109-2978 109-2953 109-2953 109-3018 109-3018 11A 1 SERVICE PANEL (I/R) 109-4111 109-4111 109-4108 109-4108 109-4139 109-4139 12 1 FILTER PANEL 109-2979 109-2979 109-2954 109-2954 109-3019 109-3019 13 1 KEY PAD (I/R) 240-3181 240-3181 240-3181 240-3181 240-3181 240-3181 14 1 T'STAT BOARD (I/R) 240-3173 240-3173 240-3173 240-3173 240-3173 240-3173 15 1 RELAY BOARD (I/R) 240-2968 240-2968 240-2968 240-2968 240-2968 240-2968 15A 1 RELAY BOARD (24V WALL T'STAT CONTROL) 240-1764 240-1764 240-1764 240-1764 240-1764 240-1764 NOTE 3 1 INFRARED RECEIVER PACKAGE 550-1065 550-1065 550-1065 550-1065 550-1065 550-1065 NOTE 3 1 (³)INFRARED CONTROL PACKAGE REPLACEMENT 550-1042 550-1042 550-1042 550-1042 550-1042 550-1042 16 1 AIR FILTER 240-2113 240-2113 240-2114 240-2114 240-2115 240-2115 17A 1 CONDENSATE PUMP KIT EDC (230V) 550-1222 550-1222 550-1222 550-1222 550-1222 550-1222 17A 1 CONDENSATE PUMP KIT EDC (115V) 550-1221 550-1221 550-1221 550-1221 550-1221 550-1221 18 1 DISTRIBUTOR 240-500 240-500 240-500 240-2090 240-506 240-506 19 1 PISTON 240-727 240-1010 240-728 240-501 550-121 (2) 240-508 19A 1 PISTON (CHP42 ONLY) N/A N/A N/A N/A 240-508 (2) N/A 20 2 HANGING BRACKETS 109-2957 109-2957 109-2957 109-2957 109-2957 109-2957 NOT SHOWN 1 MOTOR CAPACITOR 126-03 126-03 126-03 126-04 126-04 126-04 NOT SHOWN 1 TERMINAL BLOCK (LOW VOLT CONNECTION) 240-2095 240-2095 240-2095 240-2095 240-2095 240-2095 NOT SHOWN 1 GROUND LUG 212-015 212-015 212-015 212-015 212-015 212-015 NOT SHOWN 1 COIL SENSOR (I/R) 240-2986 240-2986 240-2986 240-2986 240-2986 240-2986 NOT SHOWN 1 RETURN AIR SENSOR (I/R) 240-2987 240-2987 240-2987 240-2987 240-2987 240-2987 NOT SHOWN 1 8 CONDUCTOR RIBBON CABLE (I/R) 240-2566 240-2566 240-2566 240-2566 240-2566 240-2566 NOT SHOWN 1 5 CONDUCTOR WIRE HARNESS (I/R) (18 GAUGE) 240-1911 240-1911 240-1911 240-1911 240-1911 240-1911 NOT SHOWN 1 TRANSFORMER 230V 240-1264 240-1264 240-1264 240-1264 240-1264 240-1264 NOT SHOWN 1 TRANSFORMER 115V 119-002 N/A N/A N/A N/A N/A (1) TWO BLOWER WHEELS ON CHP 12-30; THREE ON CHP 36-48. (2) THE PISTON FOR A CHP36 IS 550-121. THE PISTON FOR A CHP42 IS 240-508. (3) PART NUMBER 550-1042 CONTAINS ALL THE COMPONENTS FOR THE INFRAREDCONTROL PACKAGE (IE RELAY BOARD, THERMOSTAT BOARD, ETC) PART NUMBER 550-1065 IS JUST THE KEYPAD AND THERMOSTAT BOARD.
CNR CORNER MOUNTED AIR HANDLER (ALL CAPACITIES) BACK TO INDEX ITEM QTY. DESCRIPTION PART NUMBER BY CAPACITY 9/12 1 1 FRONT PANEL W/LOUVER 109-4479 2 1 FILTER 240-3994 3 1 EVAP COIL 104-288 4 1 MOTOR ACCESS PANEL 109-4521 5 1 MOTOR 208/230V (CLOCKWISE) RIGHT SIDE 102-107 5A 1 MOTOR 208/230V (COUNTER CLOCKWISE) LEFT SIDE 102-021 6 1 PANEL, BOTTOM 109-4519 7 2 HEATER 3 KW 240-3988 8A 1 WHEEL - BLOWER CLOCKWISE 240-3986 8B 1 WHEEL - BLOWER COUNTER CLOCKWISE 240-3987 9 2 LOUVER 108-019 10 2 COVER PANEL - LOUVER 109-4466 11 1 TOP PANEL 109-4467 12 1 MOUNTING (POSITIONING) BRACKET 109-4480 13 1 BACK PANEL 109-4478 14 1 KEY PAD (I/R) 240-3181 15 1 T'STAT BOARD (I/R) 240-3173 16 1 RELAY BOARD (I/R) 240-2968 NOT SHOWN 1 TRANSFORMER 230V 240-1264 NOT SHOWN 1 TRANSFORMER 115V 119-002
EMI CASSETTES (ALL CAPACITIES) BACK TO INDEX ITEM QTY. DESCRIPTION PART NUMBER BY CAPACITY 9-12 15-24 30-36 42-48 1 1 HAND-HELD REMOTE (INFRARED CONTROL) 240-3027 240-3027 240-3027 240-3027 2 1 BLOWER MOTOR ASSEMBLY (MODEL # ENDING IN "C") 240-3132 240-3538 240-3503 240-3503 2A 1 BLOWER MOTOR ASSEMBLY (MODEL # ENDING IN "D") 240-4686 240-3538 240-3503 240-3503 3 1 RELAY BOARD 240-1764 240-1764 240-1764 240-1764 3A 1 INFRARED CONTROL BOARD 240-3636 240-3636 240-3636 240-3636 4 1 INFRARED RECEIVER 240-3509 240-3509 240-3509 240-3509 5 1 HEATER 240-3519 240-3616 240-3617 240-3617 NOT SHOWN 1 AUTO LIMIT SWITCH 240-3618 240-3618 240-3618 240-3618 NOT SHOWN 1 MANUAL LIMIT SWITCH 240-1180 240-1180 240-1180 240-1180 6 1 COIL (REFRIGERANT) 240-3523 240-3619 240-3620 240-3620 6A 1 COIL (HYDRONIC) N/A 240-3662 240-3663 240-3663 6B 1 COIL (WATER) 240-3623 240-3535 240-3505 240-3505 7 1 DRAIN PAN 240-2318 240-2319 240-2122 240-2122 8 1 CONDENSATE PUMP 240-3506 240-3506 240-3506 240-3506 9 1 CONDENSATE SENSOR 240-1183 240-1183 240-1183 240-1183 10 1 RETURN AIR SENSOR 240-3625 240-3625 240-3625 240-3625 11 1 VANE MOTOR N/A 240-3512 240-3512 240-3512 12 - FILTER(S) 240-3067 (1) 240-1189 (2) 240-1189 (3) 240-1189 (3) NOT SHOWN - CAPACITOR (1) 240-3627 (1) 240-1184 (1) 240-1184 (2) 240-1184 (2) NOT SHOWN 1 PISTON (METERING DEVICE) 240-3628 N/A N/A N/A NOT SHOWN 1 EXPANSION VALVE (TXV) N/A 240-2346 240-4565 240-2347 NOT SHOWN 1 COIL SENSOR 240-3625 240-3625 240-3625 240-3625 13 1 RETURN AIR GRILLE 240-2408 240-2408 240-2408 240-2408 14 1 FREEZE T'STAT 240-3059 240-3059 240-3059 240-3059 NOT SHOWN 1 TRANSFORMER ( DX AND CHILLED WATER UNITS) 240-1264 240-1264 240-1264 240-1264 NOT SHOWN 1 CONDENSATE PUMP RELAY 240-1175 240-1175 240-1175 240-1175 15 1 FASCIA ASSENBLY (MICRO-PROSSESOR UNITS) 240-3527 240-3543 240-3514 240-3514 15A 1 FASCIA ASSEMBLY (ELECTRO-MACHANICAL) 240-3526 240-3542 240-3513 240-3513 NOT SHOWN 1 ELECTRIC HEAT RELAY (CAF UNITS) 240-4327 240-4327 240-4327 240-4327 NOT SHOWN 1 TERMINAL BLOCK 240-3577 240-3577 240-3577 240-3577 NOT SHOWN 1 TERMINAL BLOCK (GROUND) 240-3578 240-3578 240-3578 240-3578 NOT SHOWN 1 TERMINAL BLOCK (WITH FUSE) 240-3576 240-3576 240-3576 240-3576 NOT SHOWN 1 FUSE (6.3 AMPS) 240-3575 240-3575 240-3575 240-3575 NOT SHOWN 1 TERMINAL BLOCK END STOP 240-3579 240-3579 240-3579 240-3579 16 1 FAN INLET RINGS (CAH 15-24) N/A 240-4141 N/A N/A 16A 1 FAN INLET RING (CAH 30-48) N/A N/A 240-4647 240-4647 17A 1 CONDENSATE TRAY SUPPORT (LEFT HAND) 240-3520 N/A N/A N/A 17A 1 CONDENSATE TRAY SUPPORT (RIGHT HAND) 240-3521 N/A N/A N/A 17B 1 CONDENSATE TRAY SUPPORT (LEFT HAND) N/A 240-3537 N/A N/A 17B 1 CONDENSATE TRAY SUPPORT (RIGHT HAND) N/A 240-3536 N/A N/A 17C 1 CONDENSATE TRAY SUPPORT (LEFT HAND) N/A N/A 240-3491 240-3491 17C 1 CONDENSATE TRAY SUPPORT (RIGHT HAND) N/A N/A 240-3492 240-3492 NOT SHOWN 1 BATTERY - MICRO PROCESSOR ONLY 240-3222 240-3222 240-3222 240-3222 NOT SHOWN 1 PLUG - DRAIN PAN 240-3300 240-3300 240-3300 240-3300 (1) THE LARGE CAPACITY CAH UNITS REQUIRE TWO CAPACITORS. NOTE: THE FASCIA IS THE WHOLE PLASTIC SUPPLY AND RETURN AIR ASSEMBLY.
ITEM QTY. DESCRIPTION FHP/FCP FLOOR MOUNTED AIR HANDLER (ALL CAPACITIES) BACK TO INDEX PART NUMBER BY CAPACITY 9/12 15 18/24 30 36/42 48 1A 1 TOP PANEL ASSY (UNIT MOUNT CONTROL) 550-628 550-628 550-628 550-628 550-650 550-650 1B 1 TOP PANEL ASSY (WALL T'STAT CONTROL) 550-1193 550-1193 550-1193 550-1193 550-1192 550-1192 2 1 SERVICE PANEL 109-3223 109-3223 109-3223 109-3223 109-3301 109-3301 3 1 RETURN AIR GRILLE 240-2463 240-2463 240-2463 240-2463 240-2473 240-2473 4 1 AIR FILTER 240-2875 240-2875 240-2875 240-2875 240-2876 240-2876 5 1 COND PUMP 115V (FACTORY INSTALLED) 240-3107 240-3107 N/A N/A N/A N/A 5A 1 COND PUMP 208/230V (FACTORY INSTALLED) 240-3106 240-3106 240-3106 240-3106 240-3106 240-3106 6 2-3 BLOWER WHEEL(S) 114-003 114-003 240-225 240-225 240-225 240-225 7 1 EVAP MOTOR 115V (DOUBLE SHAFT) 102-041 102-041 N/A N/A N/A N/A 7A 1 EVAP MOTOR 208/230V (SINGLE SHAFT) N/A N/A N/A N/A 102-046 102-046 7B 1 EVAP MOTOR(S) 208/230V (DOUBLE SHAFT) 102-042 102-042 102-028 102-028 102-028 102-028 8 1-2 FAN CAPACITOR(S) 208/230V 126-003 126-003 126-003 126-004 126-004 126-004 9 1 RELAY BOARD 240-2968 240-2968 240-2968 240-2968 240-2968 240-2968 9A 1 RELAY BOARD (WALL T'STAT CONTROL) 240-1764 240-1764 240-1764 240-1764 240-1764 240-1764 10 1 THERMOSTAT BOARD 240-3173 240-3173 240-3173 240-3173 240-3173 240-3173 11 1 KEY PAD 240-3181 240-3181 240-3181 240-3181 240-3181 240-3181 11A 1 DECO PANEL LABEL (WALL T'STAT ONLY) 240-2898 240-2898 240-2898 240-2898 240-2898 240-2898 NOTE 3 1 KEY PAD/THERMOSTAT BOARD PACKAGE 550-1065 550-1065 550-1065 550-1065 550-1065 550-1065 NOTE 3 1 UNIT MOUNT/INFRARED CONTROL PACKAGE 550-1042 550-1042 550-1042 550-1042 550-1042 550-1042 12 1 DRAIN PAN 109-539 109-2045 109-1843 109-1886 109-2093 109-2093 13 1 ELECTRIC HEATER ASSEMBLY 240-934 240-934 240-238 240-238 240-504 240-504 14 1 LIMIT SWITCH 240-250 240-250 240-250 240-250 240-250 240-250 15 1 DISTRIBUTOR 240-500 240-500 240-500 240-742 240-506 240-506 16 1 PISTON 240-727 240-1010 240-728 240-501 550-121 (1) 240-508 16A 1 PISTON (FHP42 ONLY) N/A N/A N/A N/A 240-508 (1) N/A 17 1 EVAP COIL 104-041 104-029 104-058 104-064 104-104 104-104 17A 1 HYDRONIC COIL 104-024 104-024 104-151 104-151 104-152 104-152 17B 1 EVAP COIL (CHILLED WATER) 104-290 N/A 104-291 N/A N/A 104-258 NOT SHOWN 1 CONTACTOR (FOR 7 KW HEATER ASSEMBLY) N/A N/A N/A N/A 240-2955 240-2955 NOT SHOWN 1 FAN SPEED SWITCH (24V WALL T'STAT ONLY) 240-3002 240-3002 240-3002 240-3002 240-3002 240-3002 NOT SHOWN 1 TERMINAL BLOCK (LOW VOLT CONNECTION) 240-2095 240-2095 240-2095 240-2095 240-2095 240-2095 NOT SHOWN 1 GROUND LUG 212-015 212-015 212-015 212-015 212-015 212-015 NOT SHOWN 2 SIDE PANELS 109-3207 109-3207 109-3207 109-3207 109-3207 109-3207 NOT SHOWN 1 T-STAT (FREEZE PROTECTION T'STAT) 121-005 121-005 121-005 121-005 121-005 121-005 NOT SHOWN 1 COIL SENSOR (UNIT MOUNT) 240-2986 240-2986 240-2986 240-2986 240-2986 240-2986 NOT SHOWN 1 RETURN AIR SENSOR (UNIT MOUNT) 240-2987 240-2987 240-2987 240-2987 240-2987 240-2987 NOT SHOWN 1 8 CONDUCTOR RIBBON CABLE (UNIT MOUNT) 240-2566 240-2566 240-2566 240-2566 240-2566 240-2566 NOT SHOWN 1 5 CONDUCTOR WIRE HARNESS (U/M) (18 GA) 240-1911 240-1911 240-1911 240-1911 240-1911 240-1911 NOT SHOWN 1 TRANSFORMER 230V 240-1264 240-1264 240-1264 240-1264 240-1264 240-1264 NOT SHOWN 1 TRANSFORMER 115V 119-002 119-002 119-002 119-002 119-002 119-002 NOTE: (3) PART NUMBER 550-1042 CONTAINS ALL THE COMPONENTS FOR THE INFRAREDCONTROL PACKAGE (IE RELAY BOARD, THERMOSTAT BOARD, ETC) PART NUMBER 550-1065 IS JUST THE KEYPAD AND THERMOSTAT BOARD.
MC2/MH2 MULTI-ZONE CONDENSER (ALL CAPACITIES) BACK TO INDEX ITEM QTY. DESCRIPTION 9 12 15 1 1 COMPRESSOR (230V) 101-24 101-09 101-94 2 1 MOTOR (230V) 102-55 102-55 102-60 3 1 CONDENSOR COIL 104-76 104-76 104-77 4 1 FAN BLADE 240-4104 240-4104 240-4104 5 1 COMPRESSOR CAPACITOR 126-002 126-002 126-002 6 1 MOTOR CAPACITOR 126-003 126-003 126-003 7 1 LOSS OF CHARGE SWITCH 127-10 127-10 127-10 8 1 ACCUMULATOR 136-01 136-01 136-01 9 1 TRANSFORMER 240-1264 240-1264 240-1264 10 1 CONTACTOR 117-01 117-01 117-01 11 1 SERVICE VALVE (LIQUID) 209-211 209-211 209-211 12 1 SERVICE VALVE (SUCTION) 209-210 209-210 209-208 13 1 REVERSING VALVE 240-4659 240-4659 240-4659 14 1 REVERSING VALVE COIL (24 VOLT) 240-4640 240-4640 240-4640 15 1 HARD START CAPACITOR 240-364 240-364 240-364 16 1 CRANKCASE HEATER (208/230 VOLT) 240-1773 240-1773 240-1773 17 1 CHANGEOVER T'STAT (HEAT PUMP) 121-20 121-20 121-20 18 1 TXV VALVE (HEAT PUMP ONLY) 240-344 240-344 240-344 18A 1 AXV VALVE (LOW AMBIENT FOR H/P) 240-394 240-394 240-394 19 1 TOP PANEL 109-2657 109-2657 109-2657 20 1 LEFT SIDE PANEL 109-2659 109-2659 109-2659 21 1 RIGHT REAR PANEL 109-2655 109-2655 109-2655 22 1 ACCESS PANEL 109-2759 109-2759 109-2759 23 1 FAN GRILL 109-2660 109-2660 109-2660 24 1 FILTER DRIER (STRAIGHT COOL) 240-1800 240-1800 240-1800 24A 1 FILTER DRIER (HEAT PUMP) 240-4085 240-4085 240-4085 25 1 MOTOR BRACKET 240-2328 240-2328 240-2328 26 1 LOW VOLTAGE TERMINAL BLOCK 240-251 240-251 240-251 NOT SHOWN PER ZONE FAN CYCLING SWITCH (COOLING ONLY LOW AMB.) 127-007 127-007 127-007 27 PER ZONE RELAY, LOCK OUT, LOW AMBIENT, HEAT PUMP ONLY 240-007 240-007 240-007 NOTE: FOR 265/277 VOLT UNITS CONSULT FACTORY FOR CORRECT PART NUMBERS. PART NUMBER BY CAPACITY
ITEM QTY. DESCRIPTION MC4/MH4 MULTI-ZONE CONDENSER (ALL CAPACITIES) BACK TO INDEX PART NUMBER BY CAPACITY 9 12 15 18 24 30 1 1 COMPRESSOR (208/230V) 101-24 101-09 101-196 101-187 101-197 101-198 2 1 COIL (HEAT PUMP) 104-076 104-76 104-77 104-076 104-076 104-77 2A 1 COIL (STRAIGHT COOL) 104-126 104-76 104-77 104-126 104-124 104-125 3 1 MOTOR (230V) 102-55 102-55 102-060 102-55 102-55 102-060 4 1 FAN BLADE 131-07 131-07 131-07 131-07 131-07 131-07 5 1 CAPACITOR (CONDENSER MOTOR 208/230V) 126-003 126-003 126-003 126-003 126-003 126-003 6 1 CAPACITOR (COMPRESSOR 208/230V) 126-002 126-002 126-011 126-011 126-011 126-017 NOT SHOWN 1 LOSS OF CHARGE SWITCH 127-10 127-10 N/A N/A N/A N/A NOT SHOWN 1 HIGH PRESSURE SWITCH N/A N/A 127-14 127-14 127-14 127-14 9 1 ACCUMULATOR 136-01 136-01 N/A N/A N/A N/A 10 1 TRANSFORMER 240-1264 240-1264 240-1264 240-1264 240-1264 240-1264 11 1 CONTACTOR 117-01 117-01 117-01 117-01 117-01 117-01 12 1 SERVICE VALVE (LIQUID) 209-211 209-211 209-211 209-209 209-209 209-209 13 1 SERVICE VALVE (SUCTION) 209-210 209-210 209-208 209-208 209-212 209-212 14 1 REVERSING VALVE 240-4659 240-4659 240-4660 240-4660 240-4660 240-4660 15 1 REVERSING VALVE COIL (24 VOLT) 240-4640 240-4640 240-4640 240-4640 240-4640 240-4640 16 1 START ASSIST CAPACITOR 240-364 240-364 240-364 240-364 240-364 240-364 17 1 CRANKCASE HEATER 240-1773 240-1773 N/A N/A N/A N/A 18 1 CHANGEOVER T'STAT (HEAT PUMP) 121-20 121-20 121-20 121-20 121-20 121-20 19 1 EXPANSION VALVE (HEAT PUMP) 240-344 240-344 240-345 240-345 240-345 240-345 20 1 AUTO EXPANSION VALVE (LOW AMBIENT FOR H/P) 240-394 240-394 240-394 240-394 240-394 240-394 21 1 TOP PANEL (ALSO ORDER 240-746 GRILL) 109-2760 109-2760 109-2760 109-2760 109-2760 109-2760 21A 1 TOP PANEL DISCHARGE GRILLE 240-746 240-746 240-746 240-746 240-746 240-746 22 1 RIGHT PANEL (COIL GUARD) 109-2716 109-2716 109-2716 109-2716 109-2716 109-2716 23 1 LEFT PANEL (COIL GUARD) 109-2717 109-2717 109-2717 109-2717 109-2717 109-2717 24 1 SERVICE PANEL (ELECTRICAL SIDE) 109-2718 109-2718 109-2718 109-2718 109-2718 109-2718 25 1 FILTER DRIER (STRAIGHT COOL) 240-1800 240-1800 240-1800 N/A N/A N/A 26 1 FILTER DRIER (HEAT PUMP) 240-4085 240-4085 240-4085 N/A N/A N/A 27 1 SERVICE PANEL (SERVICE VALVE SIDE) 109-2719 109-2719 109-2719 109-2719 109-2719 109-2719 NOT SHOWN PER ZONE FAN CYC SW (LOW AMB CLG ONLY) 127-007 127-007 127-007 127-007 127-007 127-007 NOT SHOWN 1 GROUND LUG 212-015 212-015 212-015 212-015 212-015 212-015 30 PER ZONE RELAY, LOCK OUT, LOW AMBIENT, HEAT PUMP ONLY 240-007 240-007 240-007 240-007 240-007 240-007 31 1 SPLASH GUARD 109-1951 109-1951 109-1951 109-1951 109-1951 109-1951 32 1 PANEL - VALVE COVER 109-4282 109-4282 109-4282 109-4282 109-4282 109-4282 NOTE: ALL UNITS ARE STANDARD 208/230 VOLT. FOR DIFFERENT VOLTAGE APPLICATIONS OR FOR NON-STANDARD COMBINATIONS, PLEASE CONTACT CUSTOMER SERVICE.
ITEM QTY. DESCRIPTION SCC/SHC SINGLE ZONE CONDENSER (ALL CAPACITIES) BACK TO INDEX PART NUMBER BY CAPACITY 9 12 15 18 24 30 36 1 1 COMPRESSOR 230V 101-24 101-09 101-94 101-187 101-197 101-198 101-199 1A 1 COMPRESSOR 115V 101-61 101-62 N/A N/A N/A N/A N/A 1B 1 COMPRESSOR (MITSUBISHI) 101-204 101-205 101-206 N/A N/A N/A N/A 1B 1 MITSUBISHI MOUNTING HARDWARE 240-4087 240-4087 240-4087 N/A N/A N/A N/A 1C 1 CRANKCASE HEATER (208/230 VOLT) 240-1773 240-1773 240-1773 N/A N/A N/A N/A 1C 1 CRANKCASE HEATER (115 VOLT) 240-1774 240-1774 N/A N/A N/A N/A N/A 2 1 MOTOR 230V 102-55 102-55 102-55 102-55 102-55 102-55 102-60 2A 1 MOTOR 115V 102-56 102-56 N/A N/A N/A N/A N/A 3 1 FAN BLADE 131-06 131-06 131-06 240-4104 240-4104 240-4104 240-4104 4 1 COIL (SCC ONLY) 104-72 104-73 104-149 104-126 104-124 104-125 104-125 4A 1 COIL (SHC ONLY) 104-073 104-74 104-149 104-76 104-076 104-077 104-077 5 1 CAPACITOR (MITSUBISHI) 126-020 126-025 126-025 N/A N/A N/A N/A 5A 1 CAPACITOR (SCC ONLY) 126-20 126-20 126-20 126-25 126-25 126-26 240-496 5B 1 CAPACITOR (SHC ONLY) 126-20 126-20 126-20 126-25 126-25 126-26 240-496 6 1 SERVICE VALVE (LIQUID) 209-211 209-211 209-211 209-209 209-209 209-209 209-209 7 1 SERVICE VALVE (SUCTION) 209-210 209-210 209-208 209-208 209-212 209-212 240-498 8 1 EXPANSION VALVE 240-344 240-344 240-344 240-345 240-345 240-345 240-345 9 1 REVERSING VALVE 240-4659 240-4659 240-4659 240-4660 240-4660 240-4660 240-4661 10 1 REVERSING VALVE COIL (24 VOLT) 240-4640 240-4640 240-4640 240-4640 240-4640 240-4640 240-4640 11 1 HIGH PRESSURE SWITCH 127-014 127-014 127-014 127-14 127-14 127-14 127-14 12 1 TRANSFORMER 230V 240-1264 240-1264 240-1264 240-1264 240-1264 240-1264 240-1264 12A 1 TRANSFORMER 115V 119-02 119-02 N/A N/A N/A N/A N/A 13 1 CONTACTOR 240-769 240-769 240-769 240-769 240-769 240-769 240-769 13A 1 RELAY 118-11 118-11 118-11 N/A N/A N/A N/A 14 1 ACCUMULATOR 136-01 136-01 136-01 N/A N/A N/A N/A 15 1 DEFROST CONTROL BOARD 240-199 240-199 240-199 240-199 240-199 240-199 240-199 16 1 TOP PANEL 109-2598 109-2598 109-2598 109-2657 109-2657 109-2657 109-2657 17 1 LEFT SIDE PANEL 109-2603 109-2603 109-2603 109-2659 109-2659 109-2659 109-2659 18 1 RIGHT REAR PANEL 109-2604 109-2604 109-2604 109-2655 109-2655 109-2655 109-2655 19 1 ACCESS PANEL 109-2758 109-2758 109-2758 109-2759 109-2759 109-2759 109-2759 20 1 FAN GRILL 109-2605 109-2605 109-2605 109-2660 109-2660 109-2660 109-2660 21 1 FILTER DRIER (HEAT PUMP) 240-4085 240-4085 240-4085 N/A N/A N/A N/A 21A 1 FILTER DRIER (STRAIGHT COOL) 240-1800 240-1800 240-1800 N/A N/A N/A N/A 22 1 MOTOR BRACKET 240-2328 240-2328 240-2328 240-2328 240-2328 240-2328 240-2328 23 1 LOW VOLTAGE TERMINAL BLOCK 240-251 240-251 240-251 240-251 240-251 240-251 240-251 NOT SHOWN 1 LOSS OF CHARGE SWITCH 127-10 127-10 127-10 N/A N/A N/A N/A NOT SHOWN 1 DEFROST T'STAT 240-4145 240-4145 240-4145 240-4145 240-4145 240-4145 240-4145 NOT SHOWN 1 START ASSIST CAPACITOR 240-364 240-364 240-364 240-364 240-364 240-495 240-3666 NOT SHOWN 1 LOW TEMPERATURE CUTOUT (SHC 9-15 ONLY) 240-1839 240-1839 240-1839 N/A N/A N/A N/A NOT SHOWN 1 FAN CYCLING SWITCH (LOW AMB CONTROL) 127-007 127-007 127-007 127-007 127-007 127-007 127-007 NOTE: ALL UNITS ARE STANDARD 208/230 VOLT. FOR DIFFERENT VOLTAGE APPLICATIONS, PLEASE CONTACT CUSTOMER SERVICE. NOTE: THE SHC36 REQUIRES A POTENTIAL RELAY (240-567) FOR START ASSIST. NOTE: WHEN FIELD INSTALLING LOW AMBIENT FOR SHC UNITS, THE RELAY WILL CHANGE. THE SHC 9-15 WILL USE 118-012 AND SHC 18-36 WILL USE 118-011.
TBC/TBH IN-CEILING AIR HANDLER (ALL CAPACITIES) BACK TO INDEX ITEM QTY. DESCRIPTION PART NUMBER BY CAPACITY 9-12 18-24 1 1 FILTER 20 x 20 240-465 240-465 2 1 GRILLE RETURN & DISCHARGE 240-839 240-839 3 1 CONDENSATE OVERFLOW SWITCH 240-454 240-454 4 1 HEATER ASSEMBLY 240-455 240-700 5 1 LOW VOLTAGE TERMINAL BLOCK 240-251 240-251 6 1 LIMIT SWITCH 240-549 240-549 7 1 BLOWER RELAY 118-011 118-011 8 1 HEATING CONTACTOR 240-769 240-769 9 1 DRAIN PAN 109-1503 109-1503 10 1 EVAPORATOR COIL 104-097 104-098 11 1 MOTOR CAPACITOR 126-006 126-003 12 1 BLOWER MOTOR PACKAGE 114-008 N/A 13 1 BLOWER HOUSING N/A 240-463 14 1 MOTOR 208/230 N/A 102-055 15 1 MOTOR MOUNTING BRACKETT N/A 240-464 16 1 PISTON (METERING DEVICE) 240-727 240-728 17 1 CONDENSATE PUMP 240-063 240-063 18 1 DISTRIBUTOR 3 FEED 240-742 240-742 NOT SHOWN 1 GROUND LUG 212-015 212-015 NOT SHOWN 1 TRANSFORMER 230V 240-1264 240-1264 NOT SHOWN 1 TRANSFORMER 115V 119-002 119-002
VCH/VHH IN-WALL CONDENSER (ALL CAPACITIES) BACK TO INDEX ITEM QTY. DESCRIPTION PART NUMBER BY CAPACITY 18 24 30 1 1 COMPRESSOR 101-187 101-197 101-198 2 1 COMP/MOTOR CAPACITOR 126-025 126-026 126-026 3 1 MOTOR 102-104 102-104 102-104 4 1 BLOWER ASSEMBLY 240-3572 240-3572 240-3572 5 1 COIL (STRAIGHT COOL ONLY) 104-281 104-282 104-282 6 1 GRILL STANDARD 240-1025 240-1025 240-1025 7 1 HIGH PRESSURE SWITCH 127-014 127-014 127-014 8 1 CONTACTOR 240-769 240-769 240-769 9 1 TERMINAL BLOCK 240-251 240-251 240-251 10 1 LIQUID LINE SERVICE VALVE 209-209 209-209 209-209 11 1 SUCTION LINE SERVICE VALVE 209-208 209-212 209-212 17 1 ARTHITECTURAL LOUVER (OPTION) 240-2324 240-2324 240-2324 18 1 GROUND LUG (NOT SHOWN) 212-015 212-015 212-015 19 1 SERVICE PANEL 109-1596 109-1596 109-1596 HEAT PUMP ONLY 5A 1 COIL (HEAT PUMP) 104-282 104-282 104-282 11A 1 SUCTION LINE SERVICE VALVE (HP) 209-208 209-208 209-208 12 1 START ASSIST 240-364 240-364 240-364 13 1 CHANGE OVER T'STAT 121-020 121-020 121-020 14 1 REVERSING VALVE 240-4660 240-4660 240-4660 15 1 REVERSING VALVE COIL. 240-4640 240-4640 240-4640 16 1 TXV 240-345 240-345 240-345 17 1 ARTHITECTURAL LOUVER (OPTION) 240-2324 240-2324 240-2324 20 1 RELAY 24V SPDT 25A 118-011 118-011 118-011
WATTERSAVER HEAT PUMP WATER HEATER BACK TO INDEX ITEM QTY. DESCRIPTION PART NUMBER 1 1 24" FAN CORD 240-0817 2 1 230V HPWH FAN 240-3192 3 1 HIGH TEMPERATURE CUT-OUT SWITCH 240-3653 4 1 CONTROL BOARD SUPPORT (NOT SHOWN) 240-3289 5 1 CONTROL BOARD (60 HZ) 240-4177 5A 1 CONTROL BOARD (50 HZ) 240-4248 6 1 UPPER ELEMENT COVER 240-3665 7 1 4500 WATT ELECTRICAL ELEMENT 240-3645 8 1 ELEMENT GASKET 240-3646 9 1 DIP TUBE (NOT SHOWN) 240-3647 10 1 TEMP. AND PRESSURE RELIEF VALVE 240-3648 11 1 TEMPERATURE CONTROLLER 240-3556 12 1 ACCESS DOOR 240-3659 13 1 ANODE ROD (NOT SHOWN) 240-3644 14 1 EVAP TEMP. SENSOR (NOT SHOWN) 240-3229 15 1 DISCHARGE TEMP. SENSOR (NOT SHOWN) 240-3770 16 1 UPPER TANK TEMP. SENSOR (NOT SHOWN) 240-3771 17 1 LOWER TANK TEMP. SENSOR (NOT SHOWN) 240-3772 18 1 DRAIN VALVE 240-3650 19 1 TEMP. CONTROLLER KNOB 240-3557 20 1 FRONT TOP COVER 240-4279 21 1 REAR TOP COVER 240-4280 22 1 ELECTRIC / H/P TOGGLE SWITCH N/A 23 1 WATTER$AVER CMS KIT (OPTIONAL) 550-1119 24 1 3500 WATT HEATING ELEMENT (OPTIONAL) 550-1140
WHP/WCP WALL MOUNTED AIR HANDLER (ALL CAPACITIES) BACK TO INDEX ITEM QTY. DESCRIPTION PART NUMBER BY CAPACITY 9/12 15/18 24/30 36 1 1 FRONT COVER KIT 550-375 550-413 550-376 550-410 2 1 SUPPLY LOUVER KIT 550-1026 550-1027 550-411 550-411 3 1 SHEET METAL WRAPPER KIT REV "C" 550-613 550-612 550-611 550-610 4 1 CONTROL PANEL ASSEMBLY 550-1020 550-1020 550-1020 550-1020 4A 1 UNIT MOUNT/ INFRARED CONTROL PACKAGE 550-1019 550-1019 550-1019 550-1019 5 1 KEY PAD (UNIT MOUNT) 240-3181 240-3181 240-3181 240-3181 5A 1 DECO PANEL LABEL (24V WALL T'STAT ONLY) 240-2898 240-2898 240-2898 240-2898 6 1 T-STAT BOARD (UNIT MOUNT) 240-3173 240-3173 240-3173 240-3173 7 1 RELAY BOARD (UNIT MOUNT) 240-2968 240-2968 240-2968 240-2968 7A 1 RELAY BOARD (24V WALL T'STAT) 240-1764 240-1764 240-1764 240-1764 8 1 DRAIN PAN 109-539 109-820 109-2511 109-2511 9 1 AIR FILTER 240-1720 240-1722 240-1724 240-1727 10 1 MOTOR 208/230 V 102-21 102-45 102-45 102-45 10A 1 MOTOR 115 V 102-109 102-106 102-106 102-106 11 1 BLOWER WHEEL KIT REV "C" 550-618 550-619 550-620 550-620 12B 1 CONDENSATE PUMP KIT PIPE CHASE MT. (230 V) 550-1202 550-1202 550-1202 550-1202 12C 1 CONDENSATE PUMP KIT PIPE CHASE MT. (115 V) 550-1201 550-1201 550-1201 550-1201 13 1 DISTRIBUTOR 2 FEED 240-500 240-500 240-500 240-1155 14 1 PISTON 240-727 240-1010 240-2089 240-501 15 1 HEATER ASSEMBLY 240-469 240-218 240-502 240-502 16 1 LIMIT SWITCH 240-470 240-482 240-250 240-250 17 1 WALL MOUNTING BRACKET 109-560 109-650 109-1178 109-1178 18 1 MOTOR CAPACITOR (208/230V) 240-2062 126-06 126-03 126-03 18A 1 MOTOR CAPACITOR (115V) 126-03 126-04 126-04 126-04 19 1 COIL EVAP 104-041 104-058 104-103 104-154 19A 1 COIL EVAP (CHILLED WATER) 104-290 104-291 104-283 N/A NOT SHOWN 2 FILTER CLIP (2 REQUIRED) 240-872 240-872 240-872 240-872 NOT SHOWN 1 FUSIBLE LINK 240-188 N/A N/A N/A NOT SHOWN 1 FAN SPEED SWITCH (24V WALL T'STAT ONLY) 240-3002 240-3002 240-3002 240-3002 NOT SHOWN 1 BLOWER WHEEL BEARING ASSY (SHAFT END) 240-2460 240-2460 240-2460 240-2460 NOT SHOWN 1 COIL SENSOR (UNIT MOUNT) 240-2986 240-2986 240-2986 240-2986 NOT SHOWN 1 RETURN AIR SENSOR (UNIT MOUNT) 240-2987 240-2987 240-2987 240-2987 NOT SHOWN 1 8 CONDUCTOR RIBBON CABLE (UNIT MOUNT) 240-2566 240-2566 240-2566 240-2566 NOT SHOWN 1 5 CONDUCTOR WIRE HARNESS (UNIT MOUNT 18GA) 240-1911 240-1911 240-1911 240-1911 NOT SHOWN 1 TRANSFORMER 230V 240-1264 240-1264 240-1264 240-1264 NOT SHOWN 1 TRANSFORMER 115V 119-002 119-002 119-002 119-002 NOTE: Part number 550-1020 contains the Key Pad, Thermostat Board with sensors, and Sheet Metal control plate. NOTE: Part number 550-1019 contains the Key Pad, Thermostat Board with sensors, Sheet Metal control plate, Relay Board, 8 Conductor Ribbon Cable, and 5 conductor Wire Harness.
9,000 Btu/h STRAIGHT COOL SYSTEM (ECW9000) Parts list for ACW09DB (9,000 Btu/h Air Handler) Part # Description CN12001100A1 FRAME FILTER ASS'Y WM101320 STEP MOTOR WR100051 PCB ASS'Y (IND.) WM101002 PCB ASS'Y (MAIN) WM100669 PCB ASS'Y (POWER) WM100054 PCB ASS'Y (S/W) WM100130 COVER ASS'Y S/W CN61500600Z3 THERMISTER ASS'Y CN69000500Z5 RELAY WM101413 REMOTE CONTROL WM100296 FAN MOTOR ASS'Y WR100505 FAN CROSS ASS'Y WM100167 INDICATOR LAMP ASSY CN61700500Z3 POWER TRANS K403603 BEARING HOUSING ASS'Y CN33001000Z3 WALL HOOK PLATE WM200161 HEAT EXCH. EVAP. ASS'Y WHICH CONSISTS OF: THERMISTER ASS'Y AND MTG THERMISTER LOUVER ASS'Y WHICH ALSO CONSISTS OF THE FOLLOWING LOUVER WM101379 BLADE (H), LOUVER BLADE (V), LOUVER FRAME, INDICATOR LAMP ASSY, PCB ASSY. (IND), STEP MOTOR, DRAIN HOSE ASSY, MTG. LOUVER (A) AND MTG. LOUVER (B) CONTROL ASS'Y (IN) WHICH ALSO CONSISTS OF THE FOLLOWING AUTO WM101301 RESTART MODULE, COVER S/W, PCB ASSY (S/W), PCB ASSY (POWER), POWER CORD ASSY, BOX - CONTROL, POWER TRANS ASSY, RELAY, MICOM (IN), PCB ASSY (MAIN), TERMINAL BLOCK FRONT COVER ASS'Y WHICH CONSISTS OF THE FOLLOWING WM101409 GRILLE - AIR INLET, FRAME FILTER ASS'Y, CAP, FRONT COVER, ELECTRICAL WIRING DIAGRAM, COVER - CONTROL Parts list for CCW09DB (9,000 Btu/h Condenser) Part # Description WM300411 FRONT PANEL CO51100100Z1 PROPELLER WM300252 FAN MOTOR CO53000100Z2 MOTOR MOUNTING BRACKET WM400148 CONDENSER COIL ASS'Y WM300087 COMPRESSOR ASS'Y WM301159 REAR PANEL CL61300600Z5 CAPACITOR FOR FAN/COMP WM300224 THERMOSTAT(SPEED) ASS'Y WM301230 VALVE 1/4 ASS'Y (LIQUID) WM301236 VALVE 3/8 ASS'Y (GAS) WM300186 TUBE, SUCTION (3/8, 1/2, 5/8) CO12200100Z2 SERVICE DOOR
12,000 Btu/h STRAIGHT COOL SYSTEM (ECW12000) Part # CN12001100A1 WM101003 WM100669 WM100167 CN61500600Z3 CN61700500Z3 K403603 CN33001000Z3 WR100051 WM101320 WR100054 WM100130 CN69000500Z5 WM101413 WM100296 WR100505 WM101409 WM101303 WM200162 WM101379 Parts list for ACW12DB (12,000 Btu/h Air Handler) Description FRAME FILTER ASS'Y PCB ASS'Y (MAIN) PCB ASS'Y (POWER) INDICATOR LAMP ASSY THERMISTER ASS'Y POWER TRANS BEARING HOUSING ASS'Y WALL HOOK PLATE PCB ASS'Y (IND) STEP MOTOR PCB ASS'Y (S/W) COVER ASS'Y S/W RELAY REMOTE CONTROL FAN MOTOR FAN CROSS ASS'Y FRONT COVER ASS'Y WHICH CONSISTS OF THE FOLLOWING GRILLE - AIR INLET, FRAME FILTER ASS'Y, CAP, FRONT COVER, ELECTRICAL WIRING DIAGRAM, COVER - CONTROL CONTROL ASS'Y (IN) WHICH ALSO CONSISTS OF THE FOLLOWING AUTO RESTART MODULE, COVER S/W, PCB ASSY (S/W), PCB ASSY (POWER), POWER CORD ASSY, BOX - CONTROL, POWER TRANS ASSY, RELAY, MICOM (IN), PCB ASSY (MAIN), TERMINAL BLOCK HEAT EXCH. EVAP. ASS'Y WHICH CONSISTS OF: THERMISTER ASS'Y AND MTG THERMISTER LOUVER ASS'Y WHICH ALSO CONSISTS OF THE FOLLOWING LOUVER BLADE (H), LOUVER BLADE (V), LOUVER FRAME, INDICATOR LAMP ASSY, PCB ASSY. (IND), STEP MOTOR, DRAIN HOSE ASSY, MTG. LOUVER (A) AND MTG. LOUVER (B) Parts list for CCW12DB (12,000 Btu/h Condenser) Part # Description CO51100200Z1 PROPELLER CO53000200C2 MOTOR MOUNTING BRACKET WM300197 FAN MOTOR CO40000100F2 CONDENSER COIL ASS'Y WM300385 COMPRESSOR ASS'Y CL11000200E5 FRONT PANEL WM301161 REAR PANEL WM300352 CAPACITOR FOR FAN/COMP WM300224 THERMOSTAT(SPEED) ASS'Y WM301232 VALVE ASS'Y (LIQUID) WM301234 VALVE ASS'Y (GAS) WM300356 SUCTION SUCTION (3/8, 1/2, 5/8) CO12200100Z2 SERVICE DOOR
12,000 Btu/h HEAT PUMP SYSTEM (EHW12000) Parts list for AHW12DB (12,000 Btu/h Heat Pump Air Handler) Part # Description WM101421 REMOTE CONTROL WM101004 PCB ASS'Y (MAIN) WM100378 PCB ASS'Y (POWER) CN12001100A1 FRAME FILTER ASS'Y WM100296 FAN MOTOR WR100505 FAN CROSS ASS'Y WM101320 STEP MOTOR WM100167 IND. LAMP ASS'Y WR100051 PCB ASS'Y (IND) WR100054 PCB ASS'Y (S/W) WM100130 COVER S/W ASS'Y CN61500600Z3 THERMISTER ASS'Y CN69000500Z5 RELAY CN61700500Z3 POWER TRANS K403603 BEARING HOUSING ASS'Y CN33001000Z3 WALL HOOK PLATE CONTROL ASS'Y (IN) WHICH ALSO CONSISTS OF THE FOLLOWING AUTO WM101305 RESTART MODULE, COVER S/W, PCB ASSY (S/W), PCB ASSY (POWER), POWER CORD ASSY, BOX - CONTROL, POWER TRANS ASSY, RELAY, MICOM (IN), PCB ASSY (MAIN), TERMINAL BLOCK FRONT COVER ASS'Y WHICH CONSISTS OF THE FOLLOWING WM101417 GRILLE - AIR INLET, FRAME FILTER ASS'Y, CAP, FRONT COVER, ELECTRICAL WIRING DIAGRAM, COVER - CONTROL LOUVER ASS'Y WHICH ALSO CONSISTS OF THE FOLLOWING LOUVER WM101379 BLADE (H), LOUVER BLADE (V), LOUVER FRAME, INDICATOR LAMP ASSY, PCB ASSY. (IND), STEP MOTOR, DRAIN HOSE ASSY, MTG. LOUVER (A) AND MTG. LOUVER (B) WM200162 HEAT EXCH. EVAP. ASS'Y WHICH CONSISTS OF: THERMISTER ASS'Y AND MTG THERMISTER Parts list for CHW12DB (12,000 Btu/h Heat Pump Condenser) Part # Description CO51100200Z1 PROPELLER WM301161 REAR PANEL ASS'Y WM300197 MOTOR ASS'Y WM300385 COMPRESSOR ASS'Y CL11000200E5 FRONT COVER ASS'Y WM301487 TUBE ASS'Y (GAS) WM400116 HEAT EXCH. COND. ASS'Y WM300232 CRANK CASE HEATER WM301409 TUBE ASS'Y (LIQUID) WM301529 PIPE ASS'Y WM300352 CAPACITOR FOR FAN/COMP WM400114 HEADER ASS'Y (LIQUID) CO53000200C2 MOTOR MTG BKT WM300224 THERMOSTAT(SPEED) ASS'Y K504360 RELAY CO12200100Z2 SERVICE DOOR WM301233 VALVE ASS'Y 1/4 WM301235 VALVE ASS'Y (GAS) WM301239 SOL VALVE ASS'Y WM301240 4-WAY VALVE COIL ASS'Y
18,000 Btu/h STRAIGHT COOL SYSTEM (ECW18000) Part # K403603 WM101321 WM100488 WM100532 WM100949 WM100589 WM100591 WM100606 WM100633 WM100634 WM100939 WM101021 WM101413 WM101389 WM100943 WM101423 WM200158 Parts list for ACW18DB (18,000 Btu/h Air Handler) Description BEARING HOUSING ASS'Y STEP MOTOR FRAME FILTER ASS'Y THERMISTER MTG BKT FAN CROSS ASS'Y PCB ASS'Y (POWER) PCB ASS'Y (IND.) IND. LAMP ASS'Y WALL HOOK PLATE FAN MOTOR PCB ASS'Y (MAIN) THERMISTER ASS'Y REMOTE CONTROL LOUVER ASS'Y WHICH ALSO CONSISTS OF THE FOLLOWING LOUVER BLADE (H), LOUVER BLADE (V), LOUVER FRAME, INDICATOR LAMP ASSY, PCB ASSY. (IND), STEP MOTOR, DRAIN HOSE ASSY, MTG. LOUVER (A) AND MTG. LOUVER (B) CONTROL ASS'Y (IN) WHICH ALSO CONSISTS OF THE FOLLOWING AUTO RESTART MODULE, COVER S/W, PCB ASSY (S/W), PCB ASSY (POWER), POWER CORD ASSY, BOX - CONTROL, POWER TRANS ASSY, RELAY, MICOM (IN), PCB ASSY (MAIN), TERMINAL BLOCK FRONT COVER ASS'Y WHICH CONSISTS OF THE FOLLOWING GRILLE - AIR INLET, FRAME FILTER ASS'Y, CAP, FRONT COVER, ELECTRICAL WIRING DIAGRAM, COVER - CONTROL HEAT EXCH. EVAP. ASS'Y WHICH CONSISTS OF: THERMISTER ASS'Y AND MTG THERMISTER Parts list for CCW18DB (18,000 Btu/h Condenser) Part # Description CM31100500Z5 COMPRESSOR ASS'Y AO41100100Z0 PROPELLER K404609 MAGNATIC CONTACTOR K406708 HIGH PRESSURE S/W CO45100800B4 TUBE SUCTION 5/8 CM46100300Z3 VALVE ASS'Y (LIQUID) A036201100A3 VALVE ASS'Y (GAS) AO32300303Z3 FILTER DRIER CL11100201A2 FRONT PANEL CL11200200Z2 FAN GUARD CO12200200A2 SERVICE DOOR WM301023 TOP PANEL CO40000400E2 CONDENSER COIL ASS'Y WM300224 THERMOSTAT(SPEED) ASS'Y WM300719 FAN MOTOR WM300914 TUBE ASS'Y (LIQUID) WM301163 REAR PANEL ASS'Y WP100460 CAPACITIR FOR FAN WP300041 CAPACITOR FOR COMP CO53000300B2 MOTOR MTG BKT CO53000400Z3 UNIT MTG BKT
18,000 Btu/h HEAT PUMP SYSTEM (EHW18000) Part # WM101421 WM100941 WM100488 WM101321 WM100607 WM100589 WM100591 WM100594 WM100633 WM100634 WR100949 K403603 WM101388 WM100945 WM101427 WM200158 Parts list for AHW18DB (18,000 Btu/h Heat Pump Air Handler) Description REMOTE CONTROL PCB ASS'Y (MAIN) FRAME FILTER ASS'Y STEP MOTOR IND. LAMP ASS'Y PCB ASS'Y (POWER) PCB ASS'Y (IND) THERMISTER ASS'Y WALL HOOK PLATE FAN MOTOR FAN CROSS ASS'Y BEARING HOUSING ASS'Y LOUVER ASS'Y WHICH ALSO CONSISTS OF THE FOLLOWING LOUVER BLADE (H), LOUVER BLADE (V), LOUVER FRAME, INDICATOR LAMP ASSY, PCB ASSY. (IND), STEP MOTOR, DRAIN HOSE ASSY, MTG. LOUVER (A) AND MTG. LOUVER (B) CONTROL ASS'Y (IN) WHICH ALSO CONSISTS OF THE FOLLOWING AUTO RESTART MODULE, COVER S/W, PCB ASSY (S/W), PCB ASSY (POWER), POWER CORD ASSY, BOX - CONTROL, POWER TRANS ASSY, RELAY, MICOM (IN), PCB ASSY (MAIN), TERMINAL BLOCK FRONT COVER ASS'Y WHICH CONSISTS OF THE FOLLOWING GRILLE - AIR INLET, FRAME FILTER ASS'Y, CAP, FRONT COVER, ELECTRICAL WIRING DIAGRAM, COVER - CONTROL HEAT EXCH. EVAP. ASS'Y WHICH CONSISTS OF: THERMISTER ASS'Y AND MTG THERMISTER Parts list for CHW18DB (18,000 Btu/h Heat Pump Condenser) Part # Description AO41100100Z0 PROPELLER K504360 RELAY WM301184 4-WAY REVERSING V/V ASS'Y K406706 HIGH PRESSURE S/W CL11100201A2 FRONT PANEL CL11200200Z2 FAN GUARD WM301023 TOP PANEL C012200200A2 SERVICE DOOR CL36000100A3 FILTER DRIER WM301185 4-WAY V/V COIL ASS'Y K404609 MAGNATIC CONTACTOR WM300719 FAN MOTOR CL48000500A3 TUBE ASS'Y (GAS) CL46100100Z3 VALVE ASS'Y (LIQUID) A036201100A3 VALVE ASS'Y (GAS) CM31100500Z5 COMPRESSOR ASS'Y WM301533 PIPE ASS'Y WM300224 THERMOSTAT(SPEED) ASS'Y WM300436 CRANK CASE HEATER WM301163 REAR PANEL ASS'Y WM300799 TUBE ASS'Y (LIQUID) WM400069 HEADER ASS'Y (LIQUID) WM400173 CONDENSER COIL ASS'Y WP100460 CAPACITOR FOR FAN WP300041 CAPACITOR FOR COMP CO53000400Z3 UNIT MTG BKT
24,000 Btu/h STRAIGHT COOL SYSTEM (ECW24000) Parts list for ACW24DB (24,000 Btu/h Air Handler) Part # Description WM100488 FRAME FILTER ASS'Y WM101413 REMOTE CONTROL WM101321 STEP MOTOR WM100606 INDICATOR LAMP ASSY WM100634 FAN MOTOR WM100949 FAN CROSS ASS'Y K403603 BEARING HOUSING ASS'Y WM100940 PCB ASS'Y (MAIN) WM100532 MTG THERMISTER CM62201503Z5 TERMINAL BLOCK WM100594 THERMISTER ASS'Y WM100633 WALL HOOK PLATE WM100589 PCB ASS'Y (POWER) WM100591 PCB ASS'Y (IND) CONTROL ASS'Y (IN) WHICH ALSO CONSISTS OF THE FOLLOWING AUTO WM100944 RESTART MODULE, COVER S/W, PCB ASSY (S/W), PCB ASSY (POWER), POWER CORD ASSY, BOX - CONTROL, POWER TRANS ASSY, RELAY, MICOM (IN), PCB ASSY (MAIN), TERMINAL BLOCK FRONT COVER ASS'Y WHICH CONSISTS OF THE FOLLOWING WM101423 GRILLE - AIR INLET, FRAME FILTER ASS'Y, CAP, FRONT COVER, ELECTRICAL WIRING DIAGRAM, COVER - CONTROL LOUVER ASS'Y WHICH ALSO CONSISTS OF THE FOLLOWING LOUVER WM101389 BLADE (H), LOUVER BLADE (V), LOUVER FRAME, INDICATOR LAMP ASSY, PCB ASSY. (IND), STEP MOTOR, DRAIN HOSE ASSY, MTG. LOUVER (A) AND MTG. LOUVER (B) WM200150 HEAT EXCH. EVAP. ASS'Y WHICH CONSISTS OF: THERMISTER ASS'Y AND MTG THERMISTER Parts list for CCW24DB (24,000 Btu/h Condenser) Part # Description AO41100100Z0 PROPELLER K404609 MGT CONTACTOR WM300719 MOTOR ASS'Y A036100300B3 VALVE ASS'Y (LIQUID) AO36201100A3 VALVE ASS'Y (GAS) AO32300303Z3 FILTER DRIER CO53000400Z3 MTG BKT CL11100201A2 FRONT PANEL WM301023 TOP PANEL C012200200A2 SERVICE DOOR CL11200200Z2 FAN GUARD CO40000400E2 CONDENSER COIL ASS'Y WM300224 THERMOSTAT(SPEED) ASS'Y WM300909 TUBE ASS'Y (LIQUID) CM62201502Z5 TERMINAL BLOCK CO53000300B2 MOTOR MTG BKT WM300641 COMPRESSOR ASS'Y AO51200700A3 CAPACITOR FOR COMP WP100460 CAPACITOR FOR FAN WM301163 REAR PANEL ASS'Y K406708 HIGH PRESSURE S/W CL45102200Z4 SUCTION TUBE 5/8
24,000 Btu/h HEAT PUMP SYSTEM (EHW24000) Parts list for AHW24DB (24,000 Btu/h Heat Pump Air Handler) Part # Description WM100488 FRAME FILTER ASS'Y WM101321 STEP MOTOR WM100607 IND. LAMP ASS'Y WM100634 FAN MOTOR WM100949 FAN CROSS ASS'Y K403603 BEARING HOUSING ASS'Y WM100942 PCB ASS'Y (MAIN) WM100589 PCB ASS'Y (POWER) WM100591 PCB ASS'Y (IND) WM100594 THERMISTER ASS'Y WM100633 WALL HOOK PLATE CM62201504Z5 TERMINAL BLOCK WM100532 MTG THERMISTER WM101421 REMOTE CONTROL WM100946 WM101388 WM101427 WM200150 CONTROL ASS'Y (IN) WHICH ALSO CONSISTS OF THE FOLLOWING AUTO RESTART MODULE, COVER S/W, PCB ASSY (S/W), PCB ASSY (POWER), POWER CORD ASSY, BOX - CONTROL, POWER TRANS ASSY, RELAY, MICOM (IN), PCB ASSY (MAIN), TERMINAL BLOCK LOUVER ASS'Y WHICH ALSO CONSISTS OF THE FOLLOWING LOUVER BLADE (H), LOUVER BLADE (V), LOUVER FRAME, INDICATOR LAMP ASSY, PCB ASSY. (IND), STEP MOTOR, DRAIN HOSE ASSY, MTG. LOUVER (A) AND MTG. LOUVER (B) FRONT COVER ASS'Y WHICH CONSISTS OF THE FOLLOWING GRILLE - AIR INLET, FRAME FILTER ASS'Y, CAP, FRONT COVER, ELECTRICAL WIRING DIAGRAM, COVER - CONTROL HEAT EXCH. EVAP. ASS'Y WHICH CONSISTS OF: THERMISTER ASS'Y AND MTG THERMISTER Parts list for CHW24DB (24,000 Btu/h Heat Pump Condenser) Part # Description CL68000300A5 TEMPERATURE SENSOR AO41100100Z0 PROPELLER K504360 RELAY WM301184 4-WAY REVERSING VALVE WM301185 4-WAY V/V COIL ASS'Y CM62201503Z5 TERMINAL BLOCK CL48000500A3 TUBE ASS'Y (GAS) CL11100201A2 FRONT PANEL CL11200200Z2 FAN GUARD K406706 HIGH PRESSURE S/W CL36000100A3 FILTER DRIER WM300224 THERMOSTAT(SPEED) ASS'Y WM300436 CRANK CASE HEATER CL46100400Z3 VALVE ASS'Y (3/8) A036201100A3 VALVE ASS'Y (GAS) WM301532 PIPE ASSY. CO48000300Z3 CHECK VALVE ASS'Y CO53000300B2 MOTOR MOUNTING BRACKET WM300719 MOTOR ASS'Y AO51200700A3 CAPACITOR FOR COMP WP100460 CAPACITOR FOR FAN K404609 MGT CONTACTOR WM300641 COMPRESSOR ASS'Y WM400174 HEAT EXCH. COND. ASS'Y WM301023 TOP PANEL C012200200A2 SERVICE DOOR WM301163 REAR PANEL ASS'Y WM300709 TUBE ASS'Y (LIQUID) CO5300040Z3 UNIT MTG BKT