FROST FREE REFRIGERATOR INSTRUCTION MANUAL Model No.: MCBR1010W MCBR1010S To ensure proper use of this appliance and your safety, please read the following instructions completely before operating this appliance.
TABLE OF CONTENTS NAMES OF THE PARTS 2 SPECIFICATIONS.. 3 IMPORTANT SAFETY INSTRUCTIONS 4 INSTALLATION INSTRUCTION BEFORE USING YOUR REFRIGERATOR.. 4 INSTALLING YOUR REFRIGERATOR 4 ELECTRICAL CONNECTION 5 OPERATING YOUR REFRIGERATOR TEMPERATURE CONTROL.. 6 CHANGING THE LIGHT BULB.. 6 OPERATING FREEZER COMPARTMENT TEMPERATURE CONTROL.. 7 ICE TRAY 7 THE FREEZER COMPARTMENT. 7 CARE AND MAINTENANCE CLEANING YOUR REFRIGERATOR 8 VACATION TIME. 8 MOVING YOUR REFRIGERATOR 8 ENERGY SAVING TIPS. 8 TROUBLESHOOTING GUIDE. 9-10 REFRIGERATOR WARRANTY. 11 1
NAMES OF THE PARTS MODEL NO. MCBR1010W / MCBR1010S 1.FREEZER BIN 7.LAMP COVER 2.REFRIGERATOR BIN 8.REFRIGERATOR SHELF 3.CAN DISPENSER 9.CRISPER COVER 4.FREEZER SHELF 10.CRISPER 5.FREEZER TEMPERATURE CONTROL KNOB 11.LEVELING LEG 6.REFRIGERATOR TEMPERATURE CONTROL KNOB WARNING : Never touch the interior of the Freezer Chamber or frozen foods in the compartment with wet hands as this could result in frost bite. 2
SPECIFICATIONS Model #MCBR1010W 3
IMPORTANT SAFETY INSTRUCTIONS WARNING To reduce the risk of fire, electrical shock, or injury when using your refrigerator, 4
Electrical Connection WARNING This refrigerator should be properly grounded for your safety. The power cord of this refrigerator is equipped with a three-prong plug which mates with standard three prong wall outlets to minimize the possibility of electrical shock. Do not, under any circumstances, cut or remove the third ground prong from the power cord supplied. This refrigerator requires a standard 115/120 Volt A.C. ~/60Hz electrical outlet with three-prong ground. This refrigerator is not designed to be used with an inverter. The cord should be secured behind the refrigerator and not left exposed or dangling to prevent accidental injury. Never unplug the refrigerator by pulling the power cord. Always grip the plug firmly and pull straight out from the receptacle. Do not use an extension cord with this appliance. If the power cord is too short, have a qualified electrician or service technician install an outlet near the appliance. Use of an extension cord can negatively affect the performance of the unit. If any problems with the appliance persist, please contact our Customer Service Dept. to consult with a representative at 888 775-0202 or visit our website to request warranty service at www.magicchefewave.com. 5
OPERATING YOUR REFRIGERATOR Temperature Control Your refrigerator has one control for regulating the temperature. The temperature control is located on the top left hand corner of the refrigerator compartment. The first time you turn the unit on, adjust the temperature control knob to MAX and run for at least 2 hours before putting foods inside. This will ensure the cabinet is thoroughly chilled before food is put in. The range of the REFRIGERATOR temperature control is from position "MIN" the warmest to "MAX" the coldest. Adjust the temperature control to the setting that best suits your needs. The setting of MED should be appropriate for home or office refrigerator use. NOTE; If the unit is unplugged, loses power; you must wait 3 to 5 minutes before restarting the unit. If you attempt to restart before this time delay, the refrigerator will not start. Large amounts of food will lower the cooling efficiency of the appliance. Do not place the foods on the air outlet, and leave spaces for airflow. If you choose to change the thermostat setting, adjust thermostat control by one increment at a time. Allow several hours for temperature to stabilize between adjustments. Adjusting the temperature control in the refrigerator compartment will affect the temperature in both the refrigerator and the freezer compartment. Changing The Light Bulb Before removing the light bulb, turn off the refrigerator first and then unplug the unit from the wall outlet. Failure to do so could result in electrical shock or personal injury. Use Phillips screwdriver to take out screw. Remove the light cover by pulling downwards gently Unscrew the bulb Replace with a 15 watt-refrigerator bulb that is the same shape and size. Replace the light bulb cover and tighten screw. 6
OPERATING FREEZER COMPARTMENT Temperature Control Your refrigerator has one control for regulating the temperature in the freezer compartment. The temperature control is located on the center of the freezer compartment s interior back panel. The first time you turn the unit on, adjust the temperature control knob to MAX and run for at least 2 hours before putting foods inside. This will ensure the cabinet is thoroughly chilled before food is put in. The range of the FREEZER temperature control is from position "MIN" the warmest to "MAX" the coldest. Adjust the temperature control to the setting that best suits your needs. Ice Tray It is for making ice, pour cool water into ice tray up to its 4/5 volume, place it in ice making chamber for two hours and the ice can be made automatically. When you want to take ice cubes, please twist the ice tray, and the ice cubes are separated from the ice tray. But do not bend it, otherwise it will crack. If you want to shorten the time of making ice, you can set the temperature control knob at MAX. Notes: Do not store can foods or food stored in glass containers in the freezer compartment. The Freezer Compartment This compartment is designed for the long-term storage of frozen food. Storage time period is up to three months. The storage life of frozen foods varies and the recommended storage time should not be exceeded. Place frozen food into the freezer as quickly as possible after purchase. If there are instructions on the packet, carefully follow these instructions regarding storage times. 7
CARE AND MAINTENANCE Cleaning Your Refrigerator Upon installation of your new appliance, it is recommended that it be cleaned thoroughly. Turn off the refrigerator first and then unplug the unit from the wall outlet. Remove all food content. Wash the inside with a damp warm cloth soaked in lukewarm water and baking soda solution. 8
TROUBLESHOOTING GUIDE You can solve many common refrigerator problems easily, saving you the cost of a possible service call. Try the suggestions below to see if you can solve the problem before calling for service. PROBLEM POSSIBLE CAUSE Refrigerator does not operate. Not plugged in. The circuit breaker tripped or a blown fuse. Compressor turns on and off frequently. The room temperature is hotter than normal. A large amount of food has been added to the refrigerator. The door is opened too often. The door is not closed completely. The temperature control is not set correctly. The door gasket does not seal properly. The refrigerator does not have the correct clearances. The refrigerator has recently been disconnected for a period of time. 4 hours are required for the refrigerator to cool down completely. Temperature inside the refrigerator is too warm. Temperature control is set too warm. Turn the control to a cooler setting and allow several hours for the temperature to stabilize. Door is kept open too long or is opened too frequently. Warm air enters the refrigerator every time the door is opened. Open the door less often. The door is not closed completely. The door gasket does not seal properly. A large amount of warm or hot food might have been stored recently. Wait until the refrigerator has had a chance to reach its selected temperature. The refrigerator has recently been disconnected for a period of time. 4 hours are required for the refrigerator to cool down completely. Temperature inside the refrigerator is too cold. Temperature control is set too cold. Turn the control to a warmer setting and allow several hours for the temperature to stabilize. Temperature of external refrigerator surface is The exterior refrigerator walls can be as much as warm. 30 ο F warmer than room temperature. This is normal while the compressor works to transfer heat from inside the refrigerator cabinet. Popping or cracking sound when compressor Metal parts undergo expansion and contraction, comes on. as in hot water pipes. This is normal. Sound will level off or disappear as refrigerator continues to run. Bubbling or gurgling sound, like water boiling. Refrigerant (used to cool refrigerator) is circulating throughout the system. This is normal. Vibrations. Check to assure that the refrigerator is on a level surface. Floor is uneven or weak. Refrigerator rocks on the floor when it is moved slightly. Be sure floor 9
Moisture forms on inside refrigerator walls. Moisture forms on outside of refrigerator. The door will not close properly. can adequately support refrigerator. Level the refrigerator by putting wood or metal shims under part of the refrigerator. The refrigerator is touching the wall. Re-level the refrigerator and move it from the wall. See Installation Instructions. Weather is hot and humid, which increases internal rate of frost build-up. This is normal. Door is slightly open. Door is kept open too long, or is opened too frequently. Open the door less often. The door is not sealed properly. Door is slightly open, causing cold air from inside the refrigerator to meet warm moist air from outside. The refrigerator is not on a level surface. The gasket is dirty. The storage basket is out of position. 10
Refrigerator Warranty MC Appliance Corporation warrants each new Refrigerator to be free from defects in material and workmanship and agrees to remedy any such defect or to furnish a new part(s) (at the company s option) for any part(s) of the unit that has failed during the warranty period. Parts and labor expenses are covered on this unit for a period of one year after the date of purchase. In addition, MC Appliance Corporation warrants the compressor (parts only) to be free from defects in material and workmanship for a period of 5 years. The consumer is responsible for all labor and transportation expenses related to the diagnosis and replacement of the compressor after the initial one-year warranty expires. A copy of the dated sales receipt / invoice is required to receive warranty service or a refund. This warranty covers appliances in use within the continental United States, Puerto Rico and Hawaii. The warranty does not cover the following: Damages due to shipping damage or improper installation. Damages due to misuse or abuse. Content losses due to failure of the unit. Inside components such as door panels, door shelves, racks, light bulbs, etc. Punctures to the evaporator system due to improper defrosting of the unit. Repairs performed by unauthorized service agents. Service calls that do not involve defects in material and workmanship such as instruction on proper use of the product, door reversal or improper installation. Replacement or resetting of house fuses or circuit breakers. Failure of this product if used for other than for its intended purpose. Disposal costs for any failed unit not returned to our factory. Any delivery costs incurred as the result of a unit that fails to perform as specified. This warranty is in lieu of all warranties expressed or implied and no representative or person is authorized to assume for us any other liability in connection with the sale of this product. Under no circumstances is the consumer permitted to return this unit to the factory without prior written consent from MC Appliance Corporation. Model Parts Labor Compressor (Part Only) Type of Service MCBR1010W One-Year One-Year Five Years In-Home MCBR1010S One- Year One- Year Five Years In-Home For Service or Assistance please call 888 775-0202. Or visit us on the web at www.magicchef-ewave.com to request warranty service. Magic Chef is a trademark of the Maytag Corporation and is used under license to MC Appliance Corp. All rights reserved. 11