T-0PL Manual SERVICE PARTS LIST for MODELS AC0 & AC0 With BT Digital Display or 80P/8P Electronic Thermostat T-0PL REV. 06/0 0 Mobile Climate Control
TABLE OF CONTENTS TABLE OF CONTENTS... i CONDENSER ASSEMBLY - AC0... CONDENSER ASSEMBLY - AC0... EVAPORATOR ASSEMBLY - AC0... EVAPORATOR ASSEMBLY - AC0... FRAMES AND COVERS - AC0... 6 6 FRAMES AND COVERS - AC0... 8 7 COOLING COMPONENTS, EVAPORATOR, DUAL LOOP - AC0 - GEN I... 0 8 COOLING COMPONENTS, EVAPORATOR, SINGLE LOOP - AC0 - GEN I... 9 COOLING COMPONENTS, EVAPORATOR, SINGLE LOOP - AC0 GEN II... 0 COOLING COMPONENTS-CONDENSER, DUAL LOOP - AC0 - GEN I... 6 COOLING COMPONENTS, CONDENSER, SINGLE LOOP - AC0 - GEN I... 8 COOLING COMPONENTS, CONDENSER, SINGLE LOOP - AC0 - GEN II... 9 RETURN AIR FILTER & FRAME ASSEMBLY (EVAPORATOR)... 0 HEATING SYSTEM AC0 & AC0 - GEN I & GEN II... EVAPORATOR HOUSING INSULATION - AC0 - GEN I... 6 EVAPORATOR BLOWER AND CONDENSER FAN- AC0 - GEN I... 7 EVAPORATOR BLOWER AND CONDENSER FAN - LOW NOISE - GEN II... 8 OPERATOR CONTROLS - GEN I & II... 9 ELECTRICAL OPERATING PARTS CSDD (BT ) - GEN II... 6 0 ELECTRIC CONTROL AND OPERATING PARTS - AC0 & AC0 - GEN II... 7 ELECTRICAL OPERATING PARTS - AC0 - GEN I... 9 RELAY PANEL WITH 8P THERMOSTAT - AC0 & AC0... 0 ELECTRIC CONTROL AND OPERATING PARTS - (MOTOR FAULT BOARD)... COOLING SYSTEM COMPONENTS (Front Evaporator Option)... INDEX... Index- 0 Mobile Climate Control
INTRODUCTION This parts list identifies service replacement parts for the Mobile Climate Control Model AC0, available in Single or Dual Loop, and the AC0, available in single loop only. These Bus Rooftop Air Conditioning and Heating systems are listed in the following Model Chart. MODEL CHART AC0 Part Number GEN. Voltage With Heat Dual Loop Single Loop 77-60-00 I VDC Yes X 77-60-0 I VDC Yes X 77-60-0 I VDC Yes X 77-60-0 II VDC Yes X 77-60-0 II VDC Yes X 77-60-0 II VDC Yes X MODEL CHART AC0 (SINGLE LOOP) Part Number GEN. Voltage With Heat Controller With Cover 77-60-0 I VDC Yes Manual Yes 77-60-0 I VDC Yes Manual No 77-60-0 II VDC No BT No 77-60-0 II VDC No BT Yes 77-60-06 II VDC Yes BT Yes 77-60-07 II VDC Yes BT No ORDERING INSTRUCTIONS All orders and inquiries for parts must include: Unit Serial Number, Part No., description of part as shown on list and quantity required. Parts can be ordered through the following website: www.mcc-hvac.com GENERAL NOTES. This catalog contains those items most commonly required for replacement purposes. If parts other than those cataloged are required, please provide the model number and serial number of the unit on which the parts are to be used and a complete description including references to items which are cataloged.. The replacement parts listed in this catalog are MCC Factory-Authorized Parts and, as a result of standardization, may not be identical to the original part furnished on the equipment.. To find replacement parts, determine major group in which replacement part is located. Consult table of contents for the appropriate page for the illustrated breakdown of the replacement part. The following letter designations are used to classify parts throughout this list. A/R As Required NSA Non-Stock Assembly - Order components listed under the assembly. NSS Not Sold Separately - Ordernexthigherassemblyorkit. P-- Suffix P-- added to part number means part is available in packaged quantity only. PL Purchase Locally. SST Stainless Steel - 00 Series unless otherwise specified. SV Suffix SV added to part number designates service replacement part. NS Not Shown on illustration. 0 Mobile Climate Control
CONDENSER ASSEMBLY - AC0 Item Cover (Refer to Section ) Cooling System (Refer to Sections 0 & ) Tubing Assemblies, (Refer to Section 0 & ) Frame (Refer to Section ) Description 0 Mobile Climate Control
CONDENSER ASSEMBLY - AC0 Item Cover (Refer to Section 6) Cooling System (Refer to Sections 0 & ) Tubing Assemblies, (Refer to Section 0 & ) Frame (Refer to Section 6) Description 0 Mobile Climate Control
EVAPORATOR ASSEMBLY - AC0 Item Cover (Refer to Section ) Coils and Filters (Refer to Sections 7 & ) Heat Coils (Refer to Section ) Frame (Refer to Section ) Return Air Filter Assembly (Refer to Section ) Description 0 Mobile Climate Control
EVAPORATOR ASSEMBLY - AC0 Item Cover (Refer to Section 9) Coils and Filters (Refer to Sections 9) Heat Coils (Refer to Section ) Frame (Refer to Section 9) Return Air Filter Assembly (Refer to Section ) Description 0 Mobile Climate Control
FRAMES AND COVERS - AC0 6 7 8 9 8 7 8 8 8 6 9 7 8 0 0 Mobile Climate Control 6
FRAMES AND COVERS - AC0 - Continued: 7--0-0 Cover, Evaporator 7--0-00 Frame, Evaporator 7--0- Frame, Condenser 7--0-6 Cover, Condenser -606-00 Lock, Base 8 6 --0-0 Bolt, Locking 7-0-0-00 Rivet 6 8 --0-06 Washer, Retaining 9 --0-09 Lock, Base 0 --0-0 Bolt, Locking 8-0--00 Gasket, (Profiled Joint) X 0 Feet Long -0--0 Gasket, (Profiled Joint) X Feet Long -0--00 Gasket, (Profiled Joint) X Feet Long --0-00 Connector Assembly, Water Drain 6-7-0-0 Bushing, Cable (GU PG6) 6-7-0-0 Bushing, Cable (GU PG9) 6-7-0-0 Bushing, Cable (GU PG) 6-7-07-008 Nut (For Cable Bushing PG6) 6 6-7-07-007 Nut (For Cable Bushing PG9) 6-7-07-006 Nut (For Cable Bushing PG) 7-0-0-0 Cover, Fresh Air 8-07-6-07 Cover, Drain Pan 9 0--0-07 Bracket, Condenser Motor 0 Mobile Climate Control 7
6 FRAMES AND COVERS - AC0 6, A, B 7 0 9 8 6 0 Mobile Climate Control 8
6 FRAMES AND COVERS - AC0 - Continued: 7-7-0-8-00 Cover, Evaporator (For 77-60-0 & -06) A -0-0-709...Insulation, Evaporator Cover B -0-0-97...Tape, Insulation 7-7-0- Cover Condenser (For 77-60-0 & -06) -606-00 Lock, Base A/R --0-0 Bolt, Locking A/R -0-0-00 Rivet A/R 6 --0-06 Washer, Retaining A/R 7 --0-09 Lock, Base A/R 8 --0-0 Bolt, Locking A/R 9-0-0-0 Washer A/R 0-0--0 Gasket, (Profiled Joint) X Feet Long --0-00 Connector Assembly, Water Drain 6-7-0-0 Bushing, Cable (GU PG6) 6-7-0-0 Bushing, Cable (GU PG9) 6-7-07-008 Nut (For Cable Bushing PG6) 6-7-07-007 Nut (For Cable Bushing PG9) -07-6-07 Cover, Drain Pan 0 Mobile Climate Control 9
7 COOLING SYSTEM COMPONENTS, EVAPORATOR, DUAL LOOP - AC0 - GEN I 0 9 6 7 6 6 7 8 7 8 9 0 8 0 0 Mobile Climate Control 0
7 COOLING SYSTEM COMPONENTS, EVAPORATOR, DUAL LOOP - AC0 - GEN I 7-0-0-07 Coil Assembly, Evaporator, (Includes -Curbside and -Roadside Coil) -0-0-7 Expansion Valve, (Ra) -07-0-08 Sightglass -0-7-0 Equalizer Line 0-60-0-098 Tube Assembly, Liquid Line to Solenoid Valve 6 0-60-0-066 Tube Assembly, Liquid Line to Solenoid Valve 7-0--08 Valve, Solenoid, Volt, Includes: 8-0--007...Coil, Magnetic, Volt 9-0--00...Connector, Harness 0 0-60--08 Tube Assembly, Discharge 0-60-0-0 Tube Assembly, Suction 0-60-0-086 Connection Assembly, Right 0-60-0-068 Tube Assembly, Liquid Line (Solenoid Valve to Sight Glass) 0-60-0-00 Tube Assembly, Suction Line, Left 0-60-0-087 Connection Assembly, Left 6 0-60--08 Tube Assembly, Liquid Line 7 0-9-0-0 Plate, Upper Support 8 0-9-0-0 Plate. Middle Support 9 0-9-0-0 Plate, Lower Support 0-0-6-0 Plate, Support, Expansion Valve --6-6 Gasket, 7/8 inch (Flare Washer) 6-08-07-007 Filter Mat, PPI, AC0 0-08-09-00 Support, Filter -08-06-0 Filter Mat, White, (Evaporator Coil) -08-0-0 Filter Mat, Black, (Evaporator Coil - Without Heating) 0 Mobile Climate Control
8 COOLING SYSTEM COMPONENTS, EVAPORATOR, SINGLE LOOP - AC0 - GEN I 9 8 0 6 7 6 7 7 7 0 9 8 0 Mobile Climate Control
8 COOLING SYSTEM COMPONENTS, EVAPORATOR, SINGLE LOOP - AC0 - GEN I 7-0-0-0 Coil Assembly, Evaporator, (Includes -Curbside and -Roadside Coil) 0-9-0-0 Plate. Middle Support 0-60-0-06 Tube Assembly, Liquid Line (Solenoid Valve to Sight Glass) -0--08 Valve, Solenoid, Volt, Includes: -0--007...Coil, Magnetic, Volt 6-0--00...Connector, Harness 7 --6-6 Gasket, 7/8 inch (Flare Washer) 8-07-0-08 Sightglass 9-0-0-0 Expansion Valve, (Ra) 0-0-7-0 Equalizer Line 0-60-0-0 Tube Assembly, Liquid Line to Solenoid Valve 0-60-0-07 Connection Assembly, Left 0-60-0-09 Tube Assembly, Suction Line, Left 0-60-0-08 Tube Assembly, Suction Line, Right 0-60-0-06 Connection Assembly, Right 6-0-6-0 Plate, Support, Expansion Valve 7 --0-8 Clamp, Tube 8 --0-9 Cover Plate 9-0-0-0 Washer,Spring,J6, 0-0-0-09 Bolt, M6 X 0 0-08-09-00 Support, Filter -08-07-007 Filter Mat, PPI, AC0-08-06-0 Filter Mat, White, (Evaporator Coil) -08-0-0 Filter Matt, Black, (Evaporator Coil - Without Heating) 0 Mobile Climate Control
9 COOLING SYSTEM COMPONENTS, EVAPORATOR, SINGLE LOOP - AC0 GEN II 6 9, 7 0 8 0 Mobile Climate Control
9 COOLING SYSTEM COMPONENTS, EVAPORATOR, SINGLE LOOP - AC0/AC0 - GEN II 7-0-0-8 Coil Assembly, Evaporator, ORFS, (Left & Right Coil Assemblies) -0-0-80 Expansion Valve, (Ra) -00- Gasket, ORFS For Expansion Valve -0-7-0 Equalizer Line -0--0 Coil, Magnetic, 7 Volt 6 78-07-0-00 Connector, Harness 7 0-60-0-06 Connection Assembly, Right 8 0-60-0-07 Connection Assembly, Left 9 0-60-0-7 Liquid Line ORFS 0 0-60-0-08 Suction Line, Right 0-60-0-09 Suction Line, Left -08-07-008 Filter Mat, PPI, AC0 0-08-09-0 Filter, Carrier -08--0 Filter Matt, Black, (Evaporator Coil - Without Heating) 0 Mobile Climate Control
0 COOLING SYSTEM COMPONENTS-CONDENSER, DUAL LOOP - AC0 - GEN I 7, 6 8 6 9 0 6 7, 6 0 Mobile Climate Control 6
0 COOLING SYSTEM COMPONENTS, CONDENSER, DUAL LOOP - AC0 - GEN I -0-- Condenser Coil Assembly, O-Ring Ftg (Includes Road & Curbside Coil) -0-- Condenser Coil Assembly, Flare Ftg. (Includes Road & Curbside Coil) 0-6-0-0 Receiver Tank -0--00 Valve, Shut-Off --6-6 Gasket, 7/8 inch (Flare Washer) 0 --0-00 O-Ring,Inch,Teflon 0-06-0-06 Drier, Filter 6 ---00 Clamp, Filter Drier 7-0--0 Valve, Shut-Off 8 0-60-0-06 Tube Assembly, Liquid Line, Receiver Inlet 9 0-60-0-07 Tube Assembly, Liquid Line, Receiver Outlet 0 0-60-0-08 Tube Assembly, Liquid Line, Receiver Inlet -0-0-0 Tape, Foam Rubber 6mm X mm X 0 Meters Long 0-60-0-09 Tube Assembly, Liquid Line, Receiver Outlet -0-0-00 Valve, Pressure Relief 0-60-7-00 Tube Assembly, Filter Drier Outlet -07--00 Bracket, Filter Drier 6 7-0-00 Ring, Teflon (White) 0 Mobile Climate Control 7
COOLING SYSTEM COMPONENTS, CONDENSER, SINGLE LOOP - AC0 - GEN I 0 0 9 8 7 7 6 6-0--0 Condenser Coil Assembly, (Includes Roadside and Curbside Coil) 0-6-0-00 Receiver Tank -0--0 Valve, Shut-Off, Receiver -0-0-00 Valve, Safety --6-6 Gasket, 7/8 inch (Flare Washer) 7 6 7-0-00 Ring, Teflon (White) 7-06-0-06 Drier, Filter 8 ---00 Clamp, Filter Drier 9-07--00 Bracket, Filter Drier 0-0--00 Valve, Shut-Off, Filter Drier 0-60--0 Tube Assembly, Liquid Line, Receiver Inlet 0-60--0 Tube Assembly, Liquid Line, Receiver Outlet 0-60--0 Tube Assembly, Filter Drier Outlet -0-0-0 Tape, Foam Rubber, 6mm X mm X 0 Meters Long 0-60--08 Tube Assembly, Discharge Line, Left or Right 6 0--0-00 Plate, Support 7 --0-069 O-Ring 0 Mobile Climate Control 8
COOLING SYSTEM COMPONENTS, CONDENSER, SINGLE LOOP - AC0 - GEN II 6 7, 7 7-6-0-00 Condenser Coil Assembly, (Both Coils With Receiver Tank) -0--0 Valve, Shut-Off, Filter Drier, /-6 x 7/8- -006-0 Drier, Filter, ORFS, / ORS -00-0 O-Ring For Filter Drier ORS -00-00 Valve, Pressure Relief (Regulating Spring) 6 0-60--060 Liquid Line, Filter Drier Outlet 7 0-60--08 Discharge Line, Right or Left 0 Mobile Climate Control 9
RETURN AIR FILTER & FRAME ASSEMBLY (EVAPORATOR) 9 8 7 6 7-9-0-00 Return Air Filter and Frame Assembly - AC0 & AC0 - Includes: 0-8-0-0...Frame, Composite -08-06-09...Filter Mat, Return Air 0-8-0-07...Grille, Diffuser, White 0-8-0-0...Cover, Frame 6 --0-08...Bolt, Locking, (/ Turn) 6 7 --0-060...Washer, Thrust, Steel 6 8 --0-09...Washer, Retaining, Mylar 6 9 ---00...Clip, Retaining 0 Mobile Climate Control 0
HEATING SYSTEM AC0 & AC0 - GEN I & GEN II 7 8 6 --0-066 Heater Coil, Right, AC0 --0-06 Heater Coil, Left, AC0 --0-06 Heater Coil, Right, AC0 --0-069 Heater Coil, Left, AC0 CM8- Valve, Solenoid, / Inch NPT Female, With VDC Coil - Includes: 6-0099-00...Valve, Solenoid, / Inch NPT Female, Without Coil 7-00-0...Coil, Solenoid, VDC With Connector -00-0 Coil, Solenoid, VDC With Connector (Reference) 8-0099-0 Valve, Solenoid, / Inch O.D. Beaded, Without Coil 0 Mobile Climate Control
EVAPORATOR HOUSING INSULATION - AC0 - GEN I 8 6 7 6-0-0-70 Insulation, Cover -0-0-708 Insulation, Drain Water 8-0-0-70 Insulation, Bottom Housing -0-0-706 Insulation, Right -0-0-707 Insulation, Left 6-0-0-77 Insulation, Middle 7-0-0-00 Tape, Foam Rubber, 0mm X mm X Meters Long 8-0-0-96 Insulation, Cover 0 Mobile Climate Control
6 EVAPORATOR BLOWER AND CONDENSER FAN- AC0 - GEN I 6 8 7 0 9 8-0-0-0 Blower Assembly, VDC 8 8-0-0-00 Blower Assembly, VDC 8 8--0-00 Blower Housing 8 8--0-00 Blower Wheel 8 8-0-0-0 Motor, Electric, VDC 8-0-0-0 Motor, Electric, VDC 8--07-00 Gasket, Motor 8 6 8--07-00 Clamp 6 7 8--0-0 Fan Blade 8-607-00 Clamp, Fan 9 86-66-00 Bracket, Motor Support 0-0-0-007 Washer, B6-0-7-0-0 Bracket, Blower Mounting 8 0-7-0-0 Bracket, Blower Mounting 8-0--0 Nut, M6 6-0-0-0 Washer, Toothlock, J6-6 0 Mobile Climate Control
7 EVAPORATOR BLOWER AND CONDENSER FAN - LOW NOISE - AC0 & AC0 - GEN II 0 6 8 7 9 6 8 0-7-0-0 Blower Mounting 8/ 67-670-00 Bracket Blower Mounting (AC0-06 & -07 Only) 7--70-0 Double Radial Blower Assembly, VDC (AC0) 7--70-06 Double Radial Blower Assembly, VDC (AC0) 6-008-00 Fan & Motor Assembly, VDC, Permanent Magnet (Double Radial) /6 8--07-0 Gasket, Blower (Not Included With Fan & Motor Assembly) /6 6-09-0-0 Speed Controller AC0 6-09-0-08 Speed Controller AC0 6 0-7-0-008 Blower Mounting 8/ 8-670-00 Bracket, Blower Mounting (AC0-06 & -07 Only) 6-0--0 Nut 8/ 7-0-0-006 Washer 8/ 8-0-0-0 Spring Washer 8/ 9 86-66-0 Mount Assembly, Condenser Fan Motor, Inch Diameter - Includes: /6 9A -009-08...Washer, Plain, M8 9B -009-08...Washer, Split Lock, M8 9C -0-0...Screw, Cap, Hex Head, M8 x 0MM Long, GR 0.9 0 8-0066-00 Condenser Fan, 7 Blades /6-607-00 Clip, Retainer, Condenser Fan /6-008-00 Motor, Fan, Condenser, VDC, PM /6 0 Mobile Climate Control
8 OPERATOR CONTROLS - GEN I & II 6 8 0 0 7 9 9 60-0-0-06 Potentiometer, Thermostat Assembly - Includes: 6--0-00...Potentiometer, 0k 6--0-09...Knob 78-0-0-00...Base Plate 60-0-0-066 Potentiometer, Fan Speed Assembly - Includes: 6 78-0-0-00...Base Plate 7 60-0-0-060 Operating Panel Assembly - Includes: 8-0-06-07...Plate, Base 9 6-0-0-08...Insert, Switch, Black 0 6-0-0-06...Switch, (High-Medium-Low) 6-0-0-0...Switch (On-Off) 60-0-0-06 Operating Panel Assembly - Includes: -0-06-06...Plate, Base 6-0-0-00...Screen (Block-Off) 0 Mobile Climate Control
9 ELECTRICAL OPERATING PARTS CSDD (BT ) - GEN II 8 6 7 9 7-0-6-08 Controller Kit, CSDD, BT, AC0 (V) - Includes: 7-0-6-09 Controller Kit, CSDD, BT, AC0 (V) - Includes: 6-09-0-060-00...Controller CSDD/BT, VDC 6-09-0-060-0...Controller CSDD/BT, VDC 6-7--08...ITT Plug, Position 6--0-09...Connector, Male 7 6-7--09...Strain Relief 6 6-09-0-86 Sensor, Interior 7 6-09-0-8 Sensor, exterior (Used With Reheat Only) 8-0800-00 Fuse Socket, Megafuse 9-06- Fuse, AMP 0 Mobile Climate Control 6
0 ELECTRIC CONTROL AND OPERATING PARTS - AC0 & AC0 - GEN II o o o 8P Thermostat o xxxxxx xxxxxx xxxxxx o o 6 7 8 9 0 6 7 8 9 0 0 Mobile Climate Control 7
0 ELECTRIC CONTROL AND OPERATING PARTS - AC0 & AC0 - GEN II Continued: 6-8-08-00 Printed Circuit Board (AC0-0 & -0 Only) 6-8-08-007 Printed Circuit Board (AC0 All) 6-0--0 Fuse Box A/R 6-0-7-00 Relay, Volt (AC0) 6-0-7-07 Relay, Volt (AC0) A/R 6-09-0-07 Thermostat, Electronic, 8P 6 6-09-0-806 Sensor, Temperature (AC0-0 & -0 Only) A/R 7 6-0-0- Fuse Amp (AC0 All) A/R 6-0-0- Fuse 0 Amp (AC0-0 & -0 Only) 8 8 6-0-0-0 Breaker, Circuit, Amp (AC0 Only) 0 6-0-0-0 Breaker, Circuit, 0 Amp (AC0 Only) 7 9 6---00 Diode,N 06, 600 Volt, Amp (AC0 Only) 0 6-7--00 Connector, Female, Double A/R 6-7-0-00 Connector, Male, Double A/R 6-7--00 Connector, Male, Single 6-7-0-00 Connector, Female, Single A/R 6-7--00 Connector, Female, Pin (AC0-0, -0, -06 & -07) (AC0 - All) 6-7-0-00 Connector, Male, Pin 6 6-7--07 Connector, Pin 7-0098-77A Terminal, Male A/R 8 6--0- Terminal, Female A/R 9 6--0-97 Pin A/R 0 6--0-08 Terminal 0 Mobile Climate Control 8
ELECTRICAL OPERATING PARTS - AC0 - GEN I 6 7 8 6--0-00 Diode Board, (DL0) 6-09-0-80 Sensor, K76 6-0-7-0 Relay, 70 Amp, VDC 9 6-0-9-00 Relay Support, 70 Amp 9 6-0-9-00 Relay Support, 0/0/70 Amp 6 6-0--00 Thermostat, Freeze 7 6-0-0-07 Switch, Override 8-009-08 Switch, Pressure, Air (Adjustable) 0 Mobile Climate Control 9
RELAY PANEL WITH 8P THERMOSTAT - AC0 & AC0 8P Thermostat Connection For Mechanical Thermostat 6-8-08-00 Installed In Units With Electronic Thermostat Installed In Units With Step Ventilation Installed In Units With Heating Water Pump With Neg. Triggering Water Pump With Pos. Triggering - 6-8-08-006 Unit AC0 AC0 Relays For Evaporatop Blowers Relays For Condenser Blowers KM - KM K7M - K8M KM - K6M K7M - K9M + 60-0-8-00 Relay Panel With 8P Electronic Thermostat 6-8-08-006 Printed Circuit Board (AC0-0, -0, -0 & -0)) 6-8-08-00 Printed Circuit Board (AC0-0 & -0 Only) 0 Mobile Climate Control 0
ELECTRIC CONTROL AND OPERATING PARTS - (MOTOR FAULT BOARD) R6 D R D R7 R6 R7 OPEN CIRCUIT DS MOTOR POWER DS POWER 0-0V R9 R8 D0 D6 Q Q D R8 C R6 C R7 DS DS EVAP POWER OK T R86 R87 EVAP U C U C6 DS DS C9 EVAP DS Q D7 Q D8 R9 C C R6 R7 DS6 DS EVAP T6 F D9 C0 D D6 R0 R6 R76 R88 R7 R8 DS7 DS GROUND EVAP C R0 D8 D0 R9 D7 D9 R R R6 R66 R77 R78 DS8 DS9 DS6 DS7 EVAP6 R90 D D R89 Q6 Q C9 C8 EVAP7 DS0 DS8 C C U C U C7 EVAP8 + + U7 Q7 Q8 C0 C DS DS9 COND U8 D D R R67 R79 D9 D0 R R68 R80 DS DS0 R R COND DS DS R R COND D D R R69 R8 DS DS D D R6 R70 R8 COND Q0 Q9 C C U C U6 C8 Q Q C C D D6 R7 R7 R8 D D R8 R7 R8 R R6 R D R R D R R D0 R0 R D9 R9 R0 D8 R8 R9 D7 R7 R8 D6 R6 R7 D R R6 D R R D R R D R R D R R9 D7 T MOTOR RS EVAP WHT/RED BREAKER X-- T R0 D8 T MOTOR RS EVAP BLK/RED BREAKER X-- T R D9 T MOTOR RS EVAP WHT/YEL BREAKER X-- T R D0 T6 MOTOR RS EVAP BLK/YEL BREAKER X-- T R D T7 MOTOR RS EVAP WHT/ORN BREAKER X-- T R D T8 MOTOR RS6 EVAP6 BLK/ORN BREAKER X--6 T6 R D T9 MOTOR RS7 EVAP7 WHT/GRN BREAKER X--7 T7 CARRIER CRO MOTOR FAULT BOARD -00-00 D R6 D R7 D6 R8 T0 T T MOTOR MOTOR MOTOR RS8 RS9 RS0 EVAP8 COND COND BLK/GRN GRN/ORN GRN/WHT BREAKER BREAKER BREAKER X--8 T8 X-- T9 X-- T0 R9 D7 T MOTOR RS COND GRN/BLU BREAKER X-- T R60 D8 T MOTOR RS COND GRN/YEL BREAKER X-- T -00-00 Board, Motor Fault (PC) (AC0) 0 Mobile Climate Control
COOLING SYSTEM COMPONENTS (Front Evaporator Option) ---09 Nut, Swivel, for Front Box (Dash Air) Connection, -/6- UNS ---06 Nut, Swivel, for Front Box (Dash Air) Connection, 7/8- UNF 0-60--087 Check Valve assembly, (Discharge Line) 0-60--0 Hose Assembly, Adapter, Front Box (Dash Air) Connection 0-60--07 Tube Assembly, Liquid Line, (Solenoid Valve-Front Box) 0 Mobile Climate Control
PART # PAGE # 0-9-0-0... 0-9-0-0..., 0-9-0-0... 0-7-0-008... 0-7-0-0... 0-7-0-0... 0-7-0-0... 0--0-07... 7 0--0-00... 8 0-60-0-06..., 0-60-0-07..., 0-60-0-08..., 0-60-0-09..., 0-60-0-00... 0-60-0-0... 0-60-0-086... 0-60-0-087... 0-60-0-06... 7 0-60-0-07... 7 0-60-0-08... 7 0-60-0-09... 7 0-60-0-0... 0-60-0-06... 0-60-0-066... 0-60-0-068... 0-60-0-098... 0-60-0-7... 0-60--087... 0-60--08..., 8, 9 0-60--07... 0-60--08... INDEX PART # PAGE # 0-60--0... 8 0-60--0... 8 0-60--0... 8 0-60--0... 0-60--060... 9 0-60-7-00... 7 0-6-0-00... 8 0-6-0-0... 7 0-8-0-0... 0 0-8-0-0... 0 0-8-0-07... 0-00-00... -009-08... 0-0099-00... -0099-0... -006-0... 9-00-00... 9-00-0... -00-0... -0-0-96... -0-0-70... -0-0-70... -0-0-706... -0-0-707... -0-0-708... -0-0-709... 9-0-0-77... -0-0-97... 9-0-0-0... 7-0-6-0..., -07--00... 8-07--00... 7-07-6-07... 7, 9 7-0-00... 7, 8 0-08-09-00..., 0 Mobile Climate Control Index-
PART # PAGE # 0-08-09-0... -0--00... 7-0--00... 7-0--0... 7, 9-08-0-0..., -08-06-0..., -08-06-09... 0-08-07-007..., -08-07-008... -08--0... -0-0-0... 7, 8-0-0-00... -0800-00... 6-06-... 6-0--08..., -0--007..., -0--0... -0--00..., -0--00... 7, 8-0--0... 7, 8-0--0... 9 ---09... --0-00... 7, 9 ---06... -0098-77A... 9-0--... 7-0--... 7-0--0... 8-0-0-0... -0-0-7... -0-0-80... -0-0-00... 7, 8-0-7-0...,, -06-0-06... 7, 8 INDEX PART # PAGE # -07-0-08..., --0-06... --0-06... --0-066... --0-069... 6-0-0-0... 6-0-0-06... 6-0-0-08... 6-0-0-00... 6-0-0-07... 0 6-0-7-0... 0 6-0-9-00... 0 6-0-9-00... 0 6-0--00... 0 6-0-0-0... 9 6-0-0-... 9 6-0-0-... 9 6-0-7-00... 9 6-0--0... 9 6-0-7-07... 9 6-09-0-07... 9 6-09-0-060-00... 6 6-09-0-060-0... 6 6-09-0-80... 0 6-09-0-806... 9 6-09-0-8... 6 6-09-0-86... 6 6-09-0-08... 6-09-0-0... 6--0-00... 6---00... 9 6-7-0-00... 9 6-7-0-00... 9 6-7-0-00... 9 6-7--08... 6 0 Mobile Climate Control Index-
PART # PAGE # 6-7--09... 6 6-0-0-0... 9 6-7--00... 9 6-7--00... 9 6-7--07... 9 6-7--00... 9 6--0-08... 9 6--0-00... 0 6-7-0-0... 7 6-7-0-0... 7, 9 6-7-0-0... 7, 9 6-7-07-006... 7 6-7-07-007... 7, 9 6-7-07-008... 7, 9 6--0-... 9 6--0-97... 9 6--0-09... 6 6-8-08-00... 9, 6-8-08-006... 6-8-08-007... 9 6--0-09... 8-0-0-0... 8-0-0-0... 8-0-0-00... 8-0-0-0... 8--0-00... 8--0-00... 8--07-00... 8--07-00... 8--07-0... 8--0-0... INDEX PART # PAGE # -0-0-09... -0--0..., -0-0-007... -0-0-0... 9-0-0-006... -0-0-0...,, -0-0-00... 7, 9 ---00... 7, 8 --0-8... --0-9... ---00... 0 --0-069... 8 --0-00... 7 --6-6...,, 7, 8 --0-0... 7, 9 --0-06... 7, 9 --0-0... 7, 9 --0-09... 7, 9 --0-08... 0 --0-09... 0 --0-060... 0-009-08... -009-08... -0-06-06... -0-06-07... -0-0... -606-00... 7, 9-607-00..., 8-0066-00... -00-0... 9 0 Mobile Climate Control Index-
PART # PAGE # -00-... -008-00... -008-00... 8-670-00... 6 60-0-8-00... 60-0-0-060... 60-0-0-06... 60-0-0-06... 60-0-0-066... 67Ć670Ć00... 7 7-0-0-0... 7-0-0-07... 7-0-0-8... 7-9-0-00... 0 INDEX PART # PAGE # 7--0-... 7 7--0-6... 7 7--0-00... 7 7--0-0... 7 7--70-0... 7--70-06... 7-7-0-8-00... 9 7-7-0-... 9 7-0-6-08... 6 7-0-6-09... 6 7Ć6Ć0Ć00... 9 78-0-0-00... 78-0-0-00... 78-07-0-00... 8 86-66-00... 86-66-0... C CM8-... 0 Mobile Climate Control Index-
Every driver deserves the best possible vehicle climate with MCC products MCC provides exceptional performance in mobile climate comfort. www.mcc-hvac.com Member of MCC Group S Certified ISO 900 and ISO 00. Specifications subject to change without notice. MCC is a registered trademark. 89 Farmtrail Road York PA 706 USA Tel: --800--67-- Fax: --77--76--00 0 Mobile Climate Control