DFG-00 XCEL SERIES GAS CONVECTION OVEN REPLACEMENT PARTS LIST EFFECTIVE JANUARY, 0 Superseding All Previous Parts Lists. The Company reserves the right to make substitution in the event that items specified are not available. ERRORS: Descriptive and/or typographic errors are subject to correction. BLODGETT OVEN COMPANY Lakeside Avenue, Burlington, Vermont 00 USA Telephone: (80) 8-00 Fax: (80) 80- www.blodgett.com P/N 80 Rev B
SERIAL NUMBER LOCATION / KEY: IMPORTANT: When ordering parts, please provide the model, gas type and serial number of the oven. The identification plate is located above the right hand door under the ledge. SERIAL NUMBER IDENTIFICATION CODE: RI = DFG00 XCEL SERIAL NUMBER EXAMPLES 000RI00T (NEW STYLE) 0/0/0 = DATE RI = LETTER CODE FOR DFG00XCEL 00 = FACTORY SEQUENCE T = TOP OVEN TO OBTAIN LITERATURE: Email: literature@blodgett.com or visit www.blodgett.com JANUARY, 0 DFG-00 XCEL
TABLE OF CONTENTS Doors Are Not Returnable INFINITE CONTROL... DIGITAL TIME & TEMP CONTROL, KEY... CHPRO CONTROLS, KEY... 8 IQ CONTROLS, KEY... 0 HUMIDAIRE KEY... HUMIDAIRE COMPONENTS... EXPLODED INTERIOR VIEW... INTERIOR COMPONENTS W/EXTERIOR VIEW... BURNER & PIPING COMPONENTS... GAS VALVE ASSY... DOOR COMPONENTS... LOWER DOOR SUPPORT COMPONENTS... 8 ACCESSORIES... 9 JANUARY, 0 DFG-00 XCEL
0 0 INFINITE CONTROL OVEN OFF COOL DOWN HIGH FAN LOW FAN HIGH RATE DISABLED WITH LOW FAN LIGHT OFF OVEN READY 0 0 00 0 90 00 0 0 0 8 0 90 0 0 00 0 C F 0 90 00 0 THERMOSTAT 0 OFF 0 0 0 0 0 0 TIMER 0 80,000 BTU 0,000 BTU ROAST FROZEN HEAVY LOAD RAPID COOK BAKE FRESH LIGHT LOAD STD. COOK ON GAS SHUTOFF 9 OFF DISCONNECT THIS PRODUCT FROM THE POWER SUPPLY BEFORE OPENING THE CONTROL MODULE Controller, Temperature, Solid State Modular 0 Probe, Temperature, Solid State 8 Timer, 0 Minute, 0V, 0 HZ 08 Mode Selector Switch, pos Knob, Replacement, all functions Qty 0 Rate Switch Gas Switch, On/Off 8 8 Indicator Light, Round, Red 8V 9 Buzzer, 0V 0 0 Transformer V to V Spark Box Nat & LP 0 Relay, 0V 0 Momentary Light Switch Kit Plug, for Light Switch NOTE: For units without lights only, use this plug piece. 0 Terminal Block, for controller 00 Terminal Block, interconnecting, at rear of unit 0 Axial Fan, Low Velocity, V, 0 HZ (Qty ) 0 Capacitor, Electrolytic SP 80 Harness, Rear Connecting NOTE: Modules include everything pictured above, except probe. JANUARY, 0 DFG-00 XCEL
INFINITE CONTROL VOLT FOR OVENS BUILT AFTER 0//00 Timer, 0 Min V 89 Buzzer, V 090 Harness, Module Inf 08 High Fan Relay, V 8 Low Fan Relay, DPST V Harness, Infinte Add-In R80 Rate Switch Module Assy, Infinte SP-Includes everything pictured. JANUARY, 0 DFG-00 XCEL
DIGITAL TIME & TEMPERATURE CONTROL KEY DIGITAL 0 OVEN OFF COOL DOWN HIGH FAN LOW FAN HIGH RATE DISABLED WITH LOW FAN HEAT PULSE HOLD START STOP TIME TEMP 8 HOLD PULSE 80,000 BTU ROAST FROZEN HEAVY LOAD RAPID COOK 0,000 BTU BAKE FRESH LIGHT LOAD STD. COOK ON OFF GAS SHUTOFF 9 DISCONNECT THIS PRODUCT FROM THE POWER SUPPLY BEFORE OPENING THE CONTROL MODULE 08 Controller, Temperature, Solid State Digital 0 Probe, Temperature, Solid State 08 Mode Selector Switch, pos Knob, Replacement, Mode Knob, Replacement, Adjust temperature 0 Rate Switch Gas Switch, On/Off 8 0 Transformer V to V 9 Spark Box Nat & LP 0 0 Relay, 0V 0 Momentary Light Switch Kit Plug, for Light Switch NOTE: For units without lights only, use this plug piece. 0 Terminal Block, for controller 00 Terminal Block, interconnecting, at rear of unit 0 Axial Fan, Low Velocity, V, 0 HZ (Qty ) 0 Capacitor, Electrolytic SP 80 Harness, Rear Connecting JANUARY, 0 DFG-00 XCEL
DIGITAL TIME & TEMPERATURE CONTROL VOLT FOR OVENS BUILT AFTER 0//00 Timer, 0 Min V 89 Buzzer, V 090 Harness, Module Inf 08 High Fan Relay, V 8 Low Fan Relay, DPST V Harness, Infinte Add-In R80 Rate Switch Module Assy, Infinte SP-Includes everything pictured JANUARY, 0 DFG-00 XCEL
CH PRO CONTROL KEYS 9 OVEN OFF COOL DOWN HIGH FAN LOW FAN HIGH RATE DISABLED WITH LOW FAN HR/MIN MIN/SEC 0 READY HEAT HOLD TEMP FAN START PROG STOP 80,000 BTU 0,000 BTU ROAST FROZEN HEAVY LOAD RAPID COOK ON GAS SHUTOFF BAKE FRESH LIGHT LOAD STD. COOK 8 OFF DISCONNECT THIS PRODUCT FROM THE POWER SUPPLY BEFORE OPENING THE CONTROL MODULE 08 Controller, CH Pro 0 Probe, Temperature, CH Pro 08 Mode Selector Switch, pos Knob, Replacement 0 Rate Switch Gas Switch, On/Off 0 Transformer V to V 8 Spark Box Nat & LP 9 0 Relay, 0V, Hi Speed 0 R98 Relay, 0V, Low Speed 0 Momentary Light Switch Kit Plug, for Light Switch NOTE: For units without lights only, use this plug piece. 0 Terminal Block, for controller 00 Terminal Block, interconnecting, at rear of unit 89 Control Panel & Decal Assy 0 Axial Fan, Low Velocity, V, 0 HZ (Qty ) 0 Capacitor, Electrolytic SP JANUARY, 0 8 DFG-00 XCEL
CH PRO CONTROL VOLT FOR OVENS BUILT AFTER 0//00 8 Low Fan Relay, DPST VAC 090 Harness, Control 08 High Fan Relay, VAC R80 Rate Switch JANUARY, 0 9 DFG-00 XCEL
IQ CONTROL KEYS OVEN OFF GAS SHUTOFF OVEN ON 80,000 BTU ON OFF 0,000 BTU HEAT HIGH FAN LOW FAN PROGRAM HOLD PROG COOL ACTUAL DOWN TEMP TOGGLE CLEAR SCAN SET TEMP ENTER 8 8 9 9 0 SHELF SHELF SHELF SHELF SHELF 0 0 Controller, IQ 0 Probe, IQ 99 Rocker Switch, DPST, Black Gas Switch, On/Off R80 Rate Switch Relay, V Qty per oven 8 Relay, V, Qty per oven 8 0 Terminal Block, pole 9 00 Transformer, 0/0V to V Step Down 0 Spark Box, Nat & LP 0 Decal, IQ, Before /0/00 089 Decal, IQ, After /0/00 0 Axial Fan, Low Velocity, V, 0 HZ (Qty ) 0 Capacitor, Electrolytic SP 80 Module Assy, IQ Controller (Less Controller) 0 Light Switch JANUARY, 0 0 DFG-00 XCEL
HUMIDAIRE KEYS 9 9 8 0 08 Controller, temperature 0 Transformer, V to V 0 Momentary Light Switch Kit 08 Switch, Rotary Position Knob, Mode Knob, Adjust Switch, Gas On/Off 8 Control, Ignition 9 090 Harness, Digital 0 R80 Switch, Rate 08 High Fan Relay, VAC 90 Light, Indicator 8 VAC Amber 8 Harness, Humidaire 8 Timer, Preset Humidaire 8 Relay, DPST V 0 Pushbutton, Humidaire 098 Harness, Rear Humidaire 9 Harness, Jumper Probe JANUARY, 0 DFG-00 XCEL
HUMIDAIRE COMPONENTS 9 Regulator and Solenoid Assy VAC (includes everything pictured above) M099 Fitting, Compression / x /8 R08 Valve, Solenoid R088 Coil, Solenoid VAC 8 Nipple, Brass Hex / x.8 80 Tee, Brass / x -9/ 90 Regulator, Pressure 809 Elbow, Brass / Pipe 90 DEG 8 Thermal Switch, SPNO 8 Tape, Gore-tex gasket, /" (by the foot) Dam, Liner Bottom 89 Cap, End 908 Grommet, Rubber /8 908 Grommet, Nylon Split 88 Tube, Flex / x " 909 Fitting, Compression 9 Tube, Water Inject 8 Clip, Thermostat Bulb JANUARY, 0 DFG-00 XCEL
EXPLODED INTERIOR VIEW LINER NOT REPLACEABLE Burner Assy, In Shot NAT 8 Burner Assy, In Shot LP 0 Heat Deflector Assy Blower Wheel (Before /0/00 and after //009) 8 Blower Wheel (After /000 and before //009) Wheel Puller Motor Mount & Panel Assy. 0 Motor, V, PH, / HP, SP JANUARY, 0 DFG-00 XCEL
INTERIOR COMPONENTS & EXTERIOR VIEW 0 8 9 Interior Baffle, Porcelain, Blower Wheel Cover (Before /0/00) Baffle Assembly (After /0/00 and before //009) 00 Baffle Assembly (After //009) Lamp, Qty per oven 9 Socket, for Lamp Qty per oven Housing, for Socket & Lamp 88 Racks, Each, Qty per oven D08 Bulb, Halogen, Qty per oven D0 Bezel, Halogen Light D0 Gasket, Halogen Light 09 Lens, Halogen Light 9 VDC, Power Supply M Fuse, power Supply 900 Rack Support Kit, Set of 0 Stops, Rack Each Qty per oven 0 Combustion Compartment Cover 89 Crumb Pan Set (LR & RH) 8 Burner Assy, In Shot NAT 8 8 Burner Assy, In Shot LP 9 Cover, Access Panel 0 0 Axial Fan, Qty Bodytop, with opening for flue box 0 Bodyside, RH 0 Bodyside, LH JANUARY, 0 DFG-00 XCEL
BURNER & PIPING, EXPLODED 0 Burner Assy, In Shot NAT 8 Burner Assy, In Shot LP Manifold Assy 8 Ignitor Upgrade Kit Consists of Flame Sensor Probe and Ignitor Rod 998 Flame Sensor Probe 8 Ignitor, Spark Rod 9 Flame Sensor Wire 9 Flex Hose, for Manifold 99 Nipple, Close / NPT 0 8 Reducer, / to /" Orifice, Main Burner Qty per oven, Specify gas type & model) BLANK Orifice, Main Burner Pre-Drilled NAT Orifice, Main Burner Pre-Drilled LP 0 Ignitor Wire JANUARY, 0 DFG-00 XCEL
GAS VALVE ASSY 08 Dual Gas Valve Assy, Nat. 9 Flex Tubing, with fittings acts as thru pipe 8 Dual Gas Valve, LP 8 Conversion kit, Nat. to LP 88 Conversion Kit, LP to Nat. JANUARY, 0 DFG-00 XCEL
DOOR COMPONENTS 8 Right Hand Door - Attached to unit 0 Left Hand Door 9 8 0 DOOR HINGE COMPONENTS Left Hand Door 9 8 0 Door Assy Sld, RH Door Assy, Sld LH Door Assy, Gls RH Door Assy, Gls LH 90 Window Tool, for installation and removal of window assy 90 Window Assy., Drop In (0-/8" x -/8") 8 Door Handle, Porc. 808 Top Plate, Door Handle 900 Washers, Door (Set of ) 9000 Bushings, Door Hinge (Set of ) Sleeve, Upper Door Bushing 8 Hinge Pin, Upper Door 9 Center Trim, Door 0 0 Pressure Lock 8 Gasket Assy, Perimeter 0 Lower Door Support Assy 9 Microswitch, Door 0 Nameplate 900 Arm Assy, RH 09 Arm Assy, w/welded hinge pin, LH Side View, Lower Door Support Assy JANUARY, 0 DFG-00 XCEL
LOWER DOOR SUPPORT COMPONENTS 0 Lower Door Support Assy NOTE: Lower Door Support Assy includes the hinge pins, arms, chain & turnbuckles, sprocket assys, cam assy, and microswitch. 9 Microswitch, Door 900 Arm Assy, RH 09 Arm Assy, w/welded hinge pin, LH NOTE: If you need to replace the sprockets, chain & turnbuckle, or the hinge pin we strongly suggest ordering the e tire lower door support. It will include all of these components and will greatly reduce your labor costs and time invested. JANUARY, 0 8 DFG-00 XCEL
ACCESSORIES 89 Drafthood Assy., Direct Vent, S/S (" dia.) DFG00 Xcel Sgl 80 Draft Diverter, Canopy Vent, S/S DFG00 Xcel Sgl 08 Drafthood Assy., Direct Vent, S/S (8" dia.) DFG00 Xcel Dbl 0 Draft Diverter, Canopy Vent, S/S DFG00 Xcel Dbl 8 Flue Connector Assy, Piece DFG00 Xcel Dbl 8 Flue Box Single Oven DFG00 Xcel 80 Clips, Stacking Double Oven 08 Backpipe Assy, Dbl 8 Installation Hose " Installation Hose 8" Bodyback, ALCT 98 Backsheet 800 Legs, " w/ Bolts, S/S Set of 898 Legs, " w/ Bolts, S/S Set of 9 Seismic Legs, ", S/S Set of 9000 Studs, Leg Set of 8 Bolts, Leg Set of 8 9 Casters w/ Plate Set of Dbl Oven 00 Casters Set of Sgl Oven Only 98 Casters, Low Profile Set of Dbl Oven 0 Casters, Heavy Duty Low Profile Set of (Jarvis & Jarvis) Dbl Oven * 8 Open Stand w/ Feet, S/S DFG00 * Open Stand w/ Casters, S/S DFG00 JANUARY, 0 9 DFG-00 XCEL