Standard operating procedures for the TEAL Stop n Wash TSNW230 The best hot water hand wash in the world TEAL Medical and Healthcare Division Unit 2, Waterloo Avenue Chelmsley Wood Industrial Estate, Birmingham B37 6QQ, United Kingdom Tel: 0121 770 0593. Email: enquiries@tealwash.com www.tealwash.com
Safety Instructions This appliance can be used by:- children aged from eight years and above persons with reduced physical, sensory or mental capabilities persons with lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision. If the supply cord is damaged, it must be replaced by the manufacturer, its service agent or similarly qualified persons, in order to avoid a hazard. IMPORTANT Please retain all packaging to re-use for collection at the end of the hire period. Your TEAL hand wash pack contents 1 x TEAL Stop n Wash 1 x Tube of 1.8g Haz-Tabs chlorine tablets (sufficient for one week disinfection) 1 x PAT Test certificate attached to body of unit 1 x COSHH Sheet for Haz-Tabs chlorine tablets Your TEAL Stop n Wash has been disinfected both internally and externally before being labelled and packed in box. Fit your own liquid soap and paper towel dispensers The TEAL Stop n Wash Backboard is made to take all types of liquid soap and paper towel dispensers. These can be attached by means of their adhesive backing or screen fixings (screws and Velcro supplied). Customer Responsibility DAILY disinfection and clean is VITAL to ensure that your TEAL Stop n Wash delivers the highest quality wash possible. Please refer to pages 6 & 7 Cleaning and Maintenance for full details. To enable you to record your disinfection routine please sign and date the disinfection register at rear of the Stop n Wash (left). The Hand Wash unit is rated at 230VAC 13 amps. Please ensure that your electrical supply is rated accordingly. Page 2
Index Getting to know your TEAL Stop n Wash Page 3/4 How to set up your TEAL Stop n Wash Page 6 Operation: How to wash hands effectively Page 7 Cleaning and Maintenance Page 8/9 TEAL Medical and Healthcare Division Page 10 Backboard (3) 7 Steps handwashing sticker, supplied to stick on your own towel dispenser (1) Soap dispenser (not supplied, fit your own) (5) Towel dispenser (not supplied, fit your own) (4) 7 Steps hand washing video (14) Greensensor (2) Medical standard wheels. 2 x lockable at front and 2 x rear, free run wheels (3) Page 3
Blue purge button (11) On/off Switch (12) Removable drip tray (9) Power cable (17) Removable back panel (10) Waste pipe (13) Removable Tray (7) 2x Twinbag TEALtainers (6) Fresh water pick up pipe (8) Waste water red cap (16) Fresh water white cap (15) Page 4
How to set up your TEAL Stop n Wash Stop n Wash provides hands free hot water hand wash without the need for external plumbing or drainage. It s entirely self-contained with both the fresh and the wastewater contained in the twin bag TEALtainer II. Each heavy-duty polyethylene bag holds 10 litres of water. When the fresh water is used up, the waste bag is full. The TEAL Stop n Wash provides up to 40 complete wash cycles per filling of the Twin Bag TEALtainer II. Please note: The TEAL Stop n Wash is fully automatic in operation. There is nothing to adjust. Both the water temperature of approximately 40 C and the wash programme are factory set. Unpacking Check for any damage and retain the packaging. Notify TEAL immediately if any damage is discovered. Set up Fit your own liquid soap dispenser (5) on the backboard (3) and put soap in Fit your own paper towel dispenser (4) on the backboard (3) and fill up with towel and put 7 steps handwashing sticker on the towel dispenser (1). Disconnect the Twin Bag TEALtainer II (6) from the fresh water pick up pipe (8) and remove from unit. Unscrew the white cap (15) and fill the fresh water bag from the cold tap to just below the filler cap. Refit the white cap (15). Return the Twin Bag TEALtainer II to left hand side of tray into the TEAL Stop n Wash and place on the removable tray (7) Reconnect the fresh water delivery pipe (8) and make sure that the waste pipe (13) is inserted into the red waste cap hole. Fit the 13-amp plug into a suitable 230v mains socket outlet and switch the unit on by means of the ON/OFF switch (12) located on the rear of the unit. The unit will automatically operate a 10 second coldwater purge and on the completion of the purge cycle the Greensensor ready light will come on (2). The TEAL Stop n Wash is now ready for use. Cleaning and maintenance DAILY DAILY cleaning instructions Before any maintenance, turn off with the switch at rear of unit (12), disconnect your TEAL Stop n Wash from the power supply by removing the 13-amp plug from the socket. Disconnect the TEALtainer in use (8) and empty both TEALtainers (6) completely dispose of contents to a foul water drain or sluice. Flush out both wastewater compartments (Red Cap) (16) and replenish both fresh water compartments (White Cap) (15) with cold water. Replace both TEALtainers in the base of the TEAL Stop n Wash and reconnect the one on the left hand side. Replace plug; switch on at back panel (12). A 10 second coldwater purge runs automatically. The TEAL Stop n Wash is now ready for use. DAILY disinfection using the following simple routine Remove both TEALtainers (6) and empty completely. Refill the fresh water compartments and add suitable chlorine disinfection tablet to each and create a solution of 500ppm. Reconnect the TEALtainer and use the Blue Purge Button (11) to run the decontamination programme. This will run automatically for 5 min. Ensure that both TEALtainers (6) are decontaminated in your maintenance programme. Empty the TEALtainers and rinse thoroughly with fresh water. Refill fresh water compartments, reconnect left TEALtainer and your TEAL Stop n Wash is ready for use. The TEAL Stop n Wash is now ready for use. These instructions can be seen on the Tealtainer II 1. The left side TEALtainer is in use and the right TEALtainer is the spare water container. 2. When the left side TEALtainer s fresh water is empty and the waste water full, replace immediately with right side TEALtainer that contains fresh water to ensure the TEAL Stop n Wash operates without disruption. 3. Empty the TEALtainer waste water into the main drain or sluice and refill with fresh water in white cap and put back into unit on the right side, ready to replace immediately when the left hand TEALtainer is full. Each TEALtainer contains up to 40 hot washes per filling. Page 6
Cleaning and maintenance (continued) Replacement of TEALtainer bags Replacement waste and fresh water bags can be purchased only from TEAL. Do not use any substitutes Waste bag; WB sold in pairs. Fresh water bag assembly: FB complete with white collar. To replace the fresh water bag 1. Disconnect the unit, remove the TEALtainer and dispose of all the water to a sluice or foul water drain. 2. Pull on the white cap and ease the bag through the opening. 3. Then unscrew the cap making sure that the dip pipe and filter are protected from any contamination. 4. To refit new bag reverse the procedure. 6. Unscrew the red cap and push the bag back into the TEALtainer. 7. Pull the waste bag out through the larger fresh water opening. 8. For refitting, reserve this procedure. Storage Before returning to TEAL or placing in storage: - 9. Operate the purge button until water flow stops and press purge button to stop running. 10. Empty the TEALtainer completely, clean and wipe down. 11. Carry out disinfection routine. 12. Ensure that the unit is kept free from frost To replace the waste water bag 5. Remove the fresh water bag as above. TEAL Medical and Healthcare Division TEAL design and manufacture some of the most innovative yet dependable mobile and portable hand washing solutions currently available for the medical and healthcare sector. Our extensive range of mobile sinks and basins are proving to be the effective, cost-effective and environmentally friendly way of delivering hand hygiene wherever and whenever it s required without the need for complicated and expensive plumbing TEAL hand wash units are ideal for Emergency clinics Acute settings Primary Care Trusts Mental Health Trusts Prisons Pharmacies Therapists The TEAL Medical and Healthcare Range see them at www.washyourhands.co.uk Pro-Wash Super Stallette Hygienius Patientwash Big Synk TEAL support Monday-Friday 8-5 (Fri 1pm) Helpline 0121 770 0593 TEAL Patents Ltd, Unit 2 Waterloo Avenue Chelmsley Wood Industrial Estate, Birmingham B37 6QQ Tel: +44(0) 121 770 0593. Fax: +44(0) 121 770 0385 Email: enquiries@tealwash.com www.tealwash.com Page 7