Leading Safety Standards. Superior Ease of Use. Reduced Cost of Ownership

Leading Safety Standards Superior Ease of Use Reduced Cost of Ownership

Heidolph Tuttnauer Sterilizers Safe Benchtop Steam Sterilization Greater awareness of potential hazards. Ever more stringent regulations. Increasing emphasis on green facilities and processes. Now more than ever, it s critical to decontaminate your laboratory's equipment, materials and bio hazardous waste. That s what the Tuttnauer Company is all about. For more than 80 years, Tuttnauer has been designing and manufacturing a wide range of laboratory sterilization equipment to safe guard you and your lab. Tuttnauer s E model benchtop sterilizers provide a fast, safe, dependable and convenient means of sterilizing instruments, glassware, and clothing. The line includes a wide range of models from our manually controlled analog M models to our electronically controlled E models with an optional builtin printer for GLPcompliant documentation. Standard Operating Features Standard Safety Features Selfcontained design eliminates external plumbing and hardwiring for easy installation Simple Operation ASME stamped, L stainless steel chamber ensures longlasting reliability, durability and high corrosion resistance Fast/slow exhaust; fast exhaust allows quick cycle time of solids and slow exhaust for glassware Continuous pressure purge eliminates air pockets and ensures thorough, even sterilization Drying cycle removes residual moisture after sterilization Largecapacity reservoir provides an ample water supply to avoid frequent fillups; the water drain is conveniently located on top to allow for quick and easy cleaning of the reservoir Automatic shutoff feature saves energy Oneyear warranty Heatinsulated, doublelocking door protects against accidental burns; the door cannot be opened while the chamber is under pressure Automatic low water level shutoff prevents damage to the heater elements if there is insufficient water for the sterilization cycle Overtemperature cutoff and overpressure valve ensure safe operation UL and CSAapproved PreProgramed Cycles (E s ONLY) Sterilization Programs Unwrapped instruments Wrapped instruments and porous loads Glassware Dry ONLY Temperature C (7 F) C (7 F) C (50 F) Alternative for when Sterilization time Slow exhaust Dry time minutes n/a none 7 minutes n/a s EA 0 min 0 minutes 5 to 0 minutes the dry time in the wrapped or unwrapped cycle is insufficient s E/EK 0 min Not Allowed

Analog Sterilizers M Suitable for: EP s EA s These manually operated models feature analog controls and gauges for simple operation. If you re tight on space, the new compact 70M is the perfect choice for your basic solid sterilization needs. Product Features 0minute cycle timer Temperature selection from 00 C to C ( F to 7 F) Combination pressure and temperature gauge with peak indicator Ordering Information 0000 0000 000 0079 00550 Every stage of the cycle, including waterfill, heating, sterilization, exhaust and drying, are microprocessorcontrolled and completely automatic with these electronic models. The digital display continuously show you temperature, pressure and running time. Four fully adjustable, singlebutton programs make these sterilizers easy to use and ensure reproducible runs. Product Features Sterilization time to 59 minutes Analog M models 70M 0M 50M 850M 870M Temperature selection from 05 C to 7 C ( F to 79 F) Inline particle filter to protect valves Electronic pressure and temperature sensors Lowwater alarm sounds when reservoir needs to be refilled Standby heating keeps chamber warm for quicker cycles Number of Stainless Steel Trays Chamber Diameter 7 in 9 in 0 in 5 in 5 in Automated Electronic Sterilizers E Voltage Suitable for: Includes Stand Glassware Glassware Wrapped EP s help you meet GLP documentation requirements. These sterilizers have a builtin printer that provides a printed summary at the end of each cycle documenting temperature, sterilization, elapsed drying times for selected cycle, cycle number, real time and date, as well as any errors or interruptions that may have occurred during the cycle. Ordering Information 005 00 000 00 00 0090 0095 0058 007 Electronic EP models, with printer 0EP 0EP 50EP 50EP Environmental 50EPK 55EP 850EP 870EP 870EAP Accessories Autoclave Ordering Information EA s are ideal for sterilizing wrapped and sealed instruments. These fully automatic autoclaves are specially designed with preloaded cycles for sterilizing packs, pouches, sealed pipette racks, unwrapped instruments and other contained/wrapped materials. The highly efficient airdriven pump circulates hot air after the sterilization cycle to ensure thorough drying of samples and to reduce overall drying time. Number of Stainless Steel Trays Chamber Diameter 9 in 9 in 0 in 0 in 0 in. in 5 in 5 in 5 in Voltage Includes Stand Ordering Information 0007 008 000 005 Electronic E models 0E 0EA 50E 50E Number of Stainless Steel Trays Chamber Diameter 9 in 9 in 0 in 0 in Voltage Includes Stand 000 007 009 080 0 Package of 5 rolls printer paper, for EP models Stand for 5075EP Stand, for all 850 and 870 Bench Top s Chamber BRITE Sterilizer Cleaner Urethane Casters set Diameter for 5075 Stand, Casters welded to stand legs and must be ordered with 007 000 50EA 0 in 005 55E. in 0087 850E 5in 000 870E 5in 0057 870EA 5in 0005 000 009 005 Accessories Printer, for s 0E, 50E, 850E, and 870E Package of 5 rolls printer paper, for EP models Stand, for all 850 and 870 models Printer DPU0 Seiko, 55 & ELV 5

Technical Specifications Heidolph Tuttnauer Laboratory Suitable for: and Benchtop Vertical Autoclaves Glassware Wrapped Liquids Media Advanced Laboratory Autoclaves 70 0 50 55 850 870 Power Supply Current Phase Chamber Volume Gallons Liters,050 W A 7,5,00 W A 5 9,00 W A,00 W. A 7,8,,00 W. A 7 5,00 W. A 8 Chamber Dimension Inches 7 x 9 x 8 0 x 8. x 8.5 5 x 0 5 x 7 (Dia. x D) Centimeters 7.8 x 0.5.9 x.7 5. x 5.7 x.9 8. x 50.8 8. x 8. Tray Dimensions Inches.7 x. x 0.8.7 x. x 0.8.7 x. x 0.8 7.8 x. x x 0 x x x (W x D x H) Centimeters x 9.5 x 7 x.5 x 7 x.5 x 9.8 x 0.8 x.5 5 x 50 x.5 5 x 7 x.5 Overall Dimensions Inches 7 x x.5 0 x 0 x 5 0 x 0 x 5.5 x.5 x 8 x 7 x x x (W x D x H) Centimeters. x 0. x.8 50.8 x 50.8 x 8. 50.8 x 50.8 x 8. 9.7 x 5. x 5.7 x 8. x 5. x 8. x 5. Reservoir volume Gallons,, (W x D x H) Liters Minimum Water Gallons 0, 0, 0, 0, 0,5 0,5 Volume in Reserivoir Liters Net Weight Pounds Kilograms 55 5 79 0 8 0 9 89 5 0 980 Erlenmeyer 5 ml 5 8 Flask Size 500 ml L L 0 7 7 0 500 ml Media Bottle 9 5 7 Bottom Tray to Top of Chamber Middle Tray Top Middle Tray Top Tray 5 in / in in 5 in in 8 /8 in in / in / in 0 in 5 /8 in in 7 /8 in in 7 /8 in Voltage (55R) OR Nema Plug (5R) Max. Allowable Wor.7 bar (0 psi) king Pressure (MAWP) Water Pump Fuse Air Pump Fuse.5 amps.0 amps.5 amps Pounds 55 79 0 9 5 Shipping Weight Kilograms Cubic Feet 5,5 9, 8 9, 0, 89, 0,8 Shipping Volume m 0,8 0,7 0,7 0,5 0, 0,7 Tuttnauer laboratory autoclaves have been designed to provide high quality repeatable performance and accountability for a wide range of applications used in modern laboratories, which include: Liquid sterilization (using two flexible PT00 probes) with various cooling options Pipette and Glass sterilization Instrument sterilization (wrapped or unwrapped) Biohazard and Waste sterilization Agar preparation Specialized customized cycles The laboratory autoclave line is designed for laboratory applications used in research institutes, universities, medical, pharmaceutical, biotechnology, food and chemical industries. Each model has a number of optional addedvalue features which can be configured for fast cooling ( C ), efficient drying ( PV ), efficient heating ( G ), biohazard and waste sterilization ( BH ), builtin water reservoir ( WR ELV models only), Fo control, and more. Benchtop lab autoclaves are designed to save space on your laboratory workbench. Vertical lab autoclaves are designed for your convenience and ease of use when vertically loading the autoclave. Advanced Control System for Your Laboratory F software control Protect your liquid media, save time, save energy: An additional challenge with liquid sterilization is the need to 0 prevent liquid media exposure to high temperatures for a long time, which may harm the quality of the liquid media. The advanced F0 optional feature minimizes the time liquids are exposed to high temperatures during sterilization there by protecting liquid media, saving your lab time and reducing energy consumption Stores the last 00 cycles in builtin memory Passwords for access level control The controller and software comply with the CFR part standard with optional R.PC.R. software Sterilization Temperature range 05 C to 7 C Optional Disinfection/Isothermal Temperature Range 0 C to 05 C Optional Independent Recording for crosschecking cycle measurements Filter replacement notifications based on the number of cycles, optional air exhaust filtration for (hazardous) waste sterilization Optional air over pressure cycle is intended to sterilize liquids in heat sensitive bags in order to avoid expansion and distortion of the bags under steam pressure. Optional Fast Liquid Cooling The chamber is surrounded by coils that are filled with cold tap water to help, rapidly cooling down the chamber to safe temperature, reducing the cycle time and protecting the load by minimizing its exposure to high temperatures (5075ELVC only) Sterilization Programs Sterilization Programs Program Glass Plastic Liquid A Liquid B Waste Temperature C C C C Sterilization time (minutes) 5 5 0 *Can program to a total of 0 Custom Cycles 7

Lab Line Features Lab Line Technical Specifications Codes for Main Optional Features Feature Codde Feature Name Feature C C + F PV G PV G BH WR * Configuration available upon appointment with consultation Liquid Load Fast Cooling Applications Sterilizing liquid requires longer heating and cooling times for completing a cycle, especially with sensitive liquid loads. When time is critical, advanced optional fast cooling features are available with Tuttnauer s laboratory autoclaves that prevent a sudden drop in chamber pressure, which can cause liquids to boil over. Fast Liquid Cooling Fast cooling (up to 75%) Super fast cooling (up to 90%) Efficient air removal Efficient moisture removal Efficient heating Complete drying Biohazard and Waste System Water Reservoir After sterilization is completed, compressed air is passed through a microbiological filter into the autoclave chamber in order to prevent a drop in pressure which also prevents load deformation, cracks or spills. Cold water is then circulated through cooling pipes that rapidly reduces the chamber temperature and that of the liquid load to a safe temperature. Water circulation through cooling pipes cools chamber Water circulation through cooling coils and air ventilation with fan rapidly cools chamber Efficient air and moisture removal by vacuum pump Efficient heating by steam from steam generator Steam from generator in combination with vacuum for complete drying Biohazard filtration of air removed from chamber before sterilization. Also used for waste sterilization. Mineral free water reservoir for vertical autoclave to avoid water filling & drain connection. Power Supply Current Phase Chamber Volume Gallons Liters Chamber Dimension Inches (Dia. x D) Centimeters Tray Dimensions Inches (W x D x H) Centimeters Overall Dimensions Inches (W x D x H) Centimeters Reservoir volume Gallons Liters Net Weight Pounds Kilograms Bottom Tray to Top of Chamber Middle Tray Top Middle Tray Top Tray Voltage Nema Plug Shipping Weight Pounds Shipping Volume Cubic Feet m 80 EL 007 00 W 0 A Single 7. 8 x5.7 8 x 0.7 x. x 0.8 7 x.5 x. 0.9 x.8 x 7. 5 x x.7.5 9.8 9 7.7.5 0, Phase 8 9.. 850 EL 0080 00 W 0 A Single 7 5 5 x 0 8. x 50.8 x 0 x 5 x 50 x.5 8. x 0. x. 7 x 7.5 x 5.9 7.. 0. x x 7.5 0, Phase 9.. 870 EL 007 800 W 0 A Three 85 5 x 7 8. x 8. x x 5 x 7 x.5 8. x 7 x. 7 x 9 x 5.9 7. 8. 0. x x 7.5 0, Phase 5.8.7 5075 EL 0075 00 W 0 A Three 0 9. x 9.5 50 x 75. x 0.7 x 78.9 x. x 9. 8 x x 7. 0L 7.5 0 7 0, Phase 87 58.7. Tuttnauer s fast liquid cooling technology reduces cycle time by as much as 75% and minimizes load exposure to high temperatures. Erlenmeyer Flasks (ml) Loading Capacity 50 500 000 000 000 5000 Schott Duran Flask (ml) Loading Capacity 50 500 000 000 5000 Glassware, Hollow and Tip Applications Efficient air removal is an important requirement for sterilizing hollow loads such as laboratory glassware and tips where the standard gravity displacement air removal method is not effective. Air removal after sterilization also assists in fast drying of your laboratory glassware. Efficient Air Removal Active Drying with Post Vacuum 80 x 9 x 0 0 0 850 x 7 x x x 0 0 870 x x 7 x 0 x 5 0 0 5075 x 50 x 8 x 8 x 8 x 5 x 7 x x 80 x x 9 x 5 0 0 850 x 7 x x x 0 870 x x x 8 x 9 0 5075 x 55 x 9 x x 7 x 0 x 0 x 5 An optional vacuum pump can be used for fractioned pre vacuum air removal eliminating air pockets from all load types and maximizing efficient steam penetration throughout the entire load. For benchtop autoclaves, an optional vacuum pump can be used for post vacuum drying, at the end of the sterilization cycle, ensuring improved drying of porous loads and hollow instruments such as pipette tips. The benchtop autoclave is equipped with a heating plate attached under the chamber that heats the chamber during the drying phase. The low pressure in the autoclave chamber, caused by the vacuum, reduces the boiling temperature forcing moisture to evaporate rapidly. The vapour is then removed from the chamber by vacuum resulting in a dry load. 8 9

ELV Technical Specifications 80ELV Mobile 870ELV Mobile 5075ELVC 007 0075 00990 Chamber Volume L 85 L 0 L "Plug & Play" to operate only with an electric power connection. No need to connect autoclave to building utilities for distilled water, tap water and drain. "Plug & Play" to operate only with an electric power connection. No need to connect autoclave to building utilities for distilled water, tap water and drain. Chamber Dimensions (Dia. x Depth) 8 x cm 8 x 70 cm 50 x 75 cm Mobile is not an option and must be connected to building utilities for distilled water, tap water and drain Overall Dimensions (D x W x H) 5 x 98 x cm 7 x 07.5 x 7cm 0 x 8. x 7.5 cm x 9 x 7in 9 x x 9in x x 8 in Max Temperature 5C 5C 5C Chamber Material Stainless Steel Ti (.57) Stainless Steel Ti (.57) Stainless Steel Ti (.57) Housing/Door Material Stainless Steel 0 L Stainless Steel 0 L Stainless Steel 0 L Comes Standard with Units Internal Thermometer included included included Sample Temperature Probes set of, included set of, included set of, included Watersensing Electrode included included included External Pressure Gauge included included included Printer included included included USB included included included Wire Baskets set of (small) set of (large) set of (large) Wheels w/ lock included included n/a Customer must supply Plug Configurations These units do not come with a plug. Nema (L50P & R or L0R & P) will need to be installed. These units do not come with a plug. Nema (L50P & R or L0R & P) will need to be installed. Voltage requirements 0V/ 500 Hz, Single Phase 0V/ 500 Hz, phase 0V/ 500 Hz, phase Amps 5A 0A 0A Power requirements. KW.0 KW 9.0 KW Requirements Compressed Air n/a n/a /" Bar (58 psi) Tap Water n/a n/a /" Bar (9 psi) Mineral Free Water RO or Distilled RO or Distilled /" Bar (9 psi) RO or Distilled Drain n/a n/a " Min Withstanding temp of 80C (7F) Heidolph Tuttnauer Autoclaves Services All Heidolph Tuttnauer sterilizers require general maintenance and cleaning. A sterilizer often requires regulatory compliance at some local, or federal standard based on the application within the operation of the unit. Our factory trained technicians are here to provide basic product upkeep, and to support your sterilizer through a variety of services outlined below: Preventative Maintenance (with and without calibration recommended yearly on site or in house) Replacement of: Chamber BRITE, safety valve, safety valve holder, door bellow, door gasket, clean water electrode, strainer, and inspect the reservoir and piping Solonoid Valves are checked for proper operation Safety features are tested Preventative maintenance agreements come with discount on parts PM with Calibration Includes everything included with the PM service, plus temperature and pressure calibration with temperature mapping A total of three cycles with probes will be run HEIDOLPH SUPPORT CENTER Customer Service: 85090 IQ/OQ (recommended) Part Number Desciption 080000850 IQ/OQ Service All s 080000 Lab Line Autoclave Onsite Setup and Training 08000085 IQ/OQ/PQ* 08000007 Tuttnauer OnSite Service Documented proof that facilities and equipment have been delivered and installed, in accordance with the requirements and safety regulations stipulated in the design qualifications Consists of: IQ/OQ test plan and report Temperature and pressure mapping IQ/OQ/PQ Documented proof that facilities and equipment have been delivered and installed, in accordance with the requirements and safety regulations stipulated in the design qualifications Consists of: IQ/OQ/PQ all testing and reports in the IQ/OQ plus a half and full load cycle tests Please contact Heidolph to discuss your PQ needs to structure the load testing to meet you application Part Number Desciption 0800008 E OnSite Setup and Training 0800005 Preventive Maintenance Service 080000 Preventive Maintenance with Calibration Service Online Support: service@heidolph.com Desciption For use in D x H (in) 0850 Wire Basket, small 080 Wire Basket, large 0790 Wire Basket, large 0795 Wire Basket, small 870 ELV.0 x 8. 870ELV.0 x 5075ELV 8. x.7 5075ELV 8. x 9. Solid Baskets, ideal for medical waste sterilizations 080 Solid Basket, small 870ELV. x 8. 0870 Solid Basket, large 0890 Solid Basket, large 0895 Solid Basket, small 870ELV. x 5075ELV 8. x.7 5075ELV 8. x 9. We respond in hours or less. Guaranteed! 0

Heidolph Tuttnauer 5075HSG Pre & Post Vacuum Autoclave The 0 liter standalong pre & post vacuum autoclave. A pre vacuum pump removes the air from the chamber. Then a pules of steam is admitted. This process is repeated to times (as selected). With each cycle of vacuum and steampule the air fraction decreases. This allows for complete Air removal and for faster and more efficient steam penetration throughout the entire load. Suitable for: Glassware Wrapped Liquids Media Large Capacity Autoclaves The Heidolph Tuttnauer offers an unmatched range of models that are available in three series: Compact, Mid Range, and Large Capacity. The sterilizer chambers range in volume from 0 to 05 liters. Additional, we design customer sizes and offer the enduser an unlimited amount of upgrades to choose from. Each model is available in either single or double door configurations. Suitable for: Glassware Wrapped Liquids Media Autoclave Features High volume waterring vacuum pump for fast and efficient air removal Standby heating mode keeps the autoclave warm and ready for use L grade stainless steel chamber and door with electropolish finish Two RTD load probes for liquid cycles Double locking safety device prevents door from opening at high pressure and high temperature Control lockout switch prevents start a cycle if door is not properly locked Builtin alphanumeric printer Mounted on wheels for easy mobility and sterilization on demand Installation, Training and Freight Part Number provided on a case by case basis Contact a Heidolph representative to obtain certified drawings ONLY One chamber size available Chamber Dimension (Dia x L) (inches) Chamber Volume (Liters) 5075HSG (Includes BuiltIn Generator) 9.5 x 9.5 0 Erlenmeyer Flask 09700000 Bottom Shelf ONLY 50ml x 50 x 8 500ml x 8 x 8 000ml 5 x 5 000ml 8 x 7 000ml 7 x 5000ml x Horizontal Schott Duran 50ml 50 x 55 x 9 500ml x x 7 000ml x 0 000ml x 0 5000ml 8 x 5 and 55 Compact Series Small Laboratory Autoclaves with chamber volumes from 0 to 50 liters. Mid Range Series Medium Laboratory Autoclaves with chamber Volumes from 0 to 0 liters. 9 Large Capacity Series Large Laboratory Autoclaves with chamber volumes from 50 to 05 liters No. of Shelves Shelf Dimensions W x H x L (inches) Electrical Requirements (Control System, Vacuum Pump) Electrical Requirements (0kW Generator) Small:.9 x 0.8 x 7. Large: 8. x 0.8 x 7. Phase,, 0 AMP Phase, 08V, 5 AMP (Draw) or Sterilization Programs Program Unwrapped Wrapped Temp 0C (70F) 0C (70F) Steilization time (minutes) 0 Dry time (minutes) The and 55 series are available with following door options: Fully automatic vertical sliding door Manual Hinged Door We offer different models The series is available with the following door options: Fully Automatic vertical sliding door Hinged door with automatic locking We offer 5 different models The 9 Series is available with the following door options: Fully automatic horizontal sliding door Hinged door with automatic locking We offer 7 different models Phase, 80V, 5 AMP (Draw) Wrapped Pouches 0C (70F) 7 0 Plant Steam Supply Cold Water Supply Building Drain *Floor Sink Recommended Heat Load to Room (Btu/Hr) N/A / NPT 750 Unwrapped delicate instruments 5 Wrapped delicated instruments Test Programs Test 0C (500F) 0C (500F) 0 0 0 0 Overal Dimensions W x H x L (inches). x 5. x.8 Leak test n/a 5 + 0 min test time n/a Autoclave Weight (Lbs) 95 B&D test 0C (70F)

Specifications Specifications Compact & Mid Range Series Compact & 9 Mid Range Series 7 559 A B C D E 9A 9B 9C 9D 9E 9F 9G Chamber Dimensions WxHxL (Inches) xx8 0x0x8 xx xx8 xx9 xx9 xx0 Chamber Dimensions WxHxL (Inches) xx xx8 xx0 xx7 x7.5x x7.5x8 x7.5x0 Chamber Volume Cubit Feet (Liter) (0) 9 (50) (0) (50) 5 (0) 9 (50) (0) Chamber Volume Cubit Feet (Liter) 8 (50) (80) 0 (80) (05) 0 (575) 7 (70) (950) External Dimensions Cabinet Enclosed WxHxL (Inches) Autoclave Weight Empty Chamber Lbs (kg) Single Hinged Door Single Sliding Door Double Hinged Door Double Sliding Door Single Sliding Door Double Sliding Door 8x75x5 x75x 5x75x 7x75x 00 (99) 50 (57) 8x75x0 x75x5 9x75x5 5x75x9 70 (798) 90 (8) x75x5 0x75x0 58x75x5 0x75x59 955 (0) 05 (5) x75x8 0x75x7 58x75x 0x75x7 00 (5) 50 (55) x75x7 0x78x7 0x75x x78x9 50 (9) 00 (5) x75x7 0x78x7 0x75x x78x9 50 (50) 00 () x75x8 0x78x77 0x75x77 x78x79 550 (0) 800 (7) External Dimensions Cabinet Enclosed WxHxL (Inches) Autoclave Weight Empty Chamber Lbs (kg) Single Hinged Door Single Sliding Door Double Hinged Door Double Sliding Door Single Door Double Door 5x75x5 75x75x 58x75x5 75x75x 0 (50) 70 (9) 5x75x8 75x75x7 58x75x 75x75x75 770 (70) 070 (8) 5x75x80 75x75x8 58x75x75 75x75x8 00 (80) 00 (99) 5x75x9 75x75x98 58x75x87 75x75x98 500 (0) 800 (77) 55x75x5 79x75x 0x75x5 79x75x 0 (5) 800 (77) 55x75x8 79x75x7 0x75x 79x75x75 970 (80) 70 (97) 55x75x80 79x75x8 0x75x7 79x75x87 00 (950) 00 (087) Utility Consumptions / Requirements Utility Consumptions / Requirements 9A 9B 9C 9D 9E 9F 9G Plant Steam Supply Pipe Size 5080 PSIG Dynamic 9700% Dry Sturated Vapor Condensate Flow Rate Free Cold Water Supply Pipe Size 070 PSIG Dynamic, 070 F Contact Heidolph for Recommended Water Quality Flow Rate (Peak) Building Drain Pipe Size Compressed Air Requirements Electrical Requirements (Control System) Electircal requirements (Optional Vacuum Pump) Electrical Requirements (Optional Steam Generator) 7 /" NPT 8 Lbs/Hr Peak 7Lbs/ /" NPT GPM (5L) " ODT 08V.A 5.9A 559 /" NPT 00 Lbs/Hr Peak Lbs/ /" NPT 8 GPM (0L) " ODT 08V.A 5.9A 7595 PSIG Dynamic,.5 SCFM. /8" NPT Phase,, 50/0 Hz. 0A Contact a Heidolph representative for specific electrical requirements *Dimensions and weights are approximate and for reference only. *The addition of certain options could impact the above stated utilities *Contact a Heidolph representative to obtain certified drawings. *Due to continuing equipment development, specifications are subject to change without notice *Request an Industrial Checklist from your Heidolph Specialist today A 0 Lbs/Hr Peak Lbs/.5 GPM (7L) " ODT 08V 7.A 80V.A B 0 Lbs/Hr Peak 9Lbs/ GPM (5L) " ODT 08V 7.A 80V.A C 0 Lbs/Hr Peak Lbs/.5 GPM (5L) " ODT 08V 7.A 80V.A D 0 Lbs/Hr Peak 9Lbs/ 5 GPM (57L) " ODT 08V 7.A 80V.A E Lbs/Hr Peak Lbs/ 9 GPM (7L) " ODT 08V 7.A 80V.A Plant Steam Supply Pipe Size 5080 PSIG Dynamic 9700% Dry Sturated Vapor Condensate Flow Rate Free Cold Water Supply Pipe Size 070 PSIG Dynamic, 070 F Contact Heidolph for Recommended Water Quality Flow Rate (Peak) Building Drain Pipe Size Compressed Air Requirements Electrical Requirements (Control System) Electircal requirements (Optional Vacuum Pump) Electrical Requirements (Optional Steam Generator) 5 Lbs/Hr Peak 0Lbs/ 8 GPM (8L) " ODT 08V 8A 00 Lbs/Hr Peak Lbs/ 0 GPM (7L) " ODT 08V 8A 70 Lbs/Hr Peak Lbs/ GPM (8L) Benefits of Choosing Tuttnauer 7595 PSIG Dynamic,.5 SCFM. /8" NPT Phase,, 50/0 Hz. 0A Contact a Heidolph representative for specific electrical requirements The control panel is an advanced microprocessor providing significantly greater accuracy than an electromechanical control. The control is isolated and covered to protect it from heat and moisture damage. All Piping is corrosion resistant stainless steel and has unions between components to make maintenance much easier. You do not have to dismantle large sections of piping just to replace a single part. A design that will minimize any down time. Control valves are air driven (pneumatic) and last 5 times longer than older style electromagnetic valves The chamber and jacket are 00% stainless steel. The jacket is 0 SS and the chamber is L SS for superior corrosion resistance and is very stain resistant for easier maintenance/clean up in event of a spill. The chamber is fully insulated to be energy efficient and prevent heat loss and thermal loading of the work area. The Unit must have a full thickness of rigid, chloride free insulation. This is important in a moisture laden environment. The insulation is then completely covered with corrosion resistant stainless steel cladding to prevent damage and degradation of the insulation. " ODT 08V 8A 5 Lbs/Hr Peak Lbs/ GPM (9L) " ODT 08V 8A 5 Lbs/Hr Peak Lbs/ 8 GPM (8L) " ODT 08V 8A 0 Lbs/Hr Peak Lbs/ 0 GPM (7L) " ODT 08V 8A 80 Lbs/Hr Peak 5Lbs/ GPM (8L) " ODT 08V 8A 5

PUREWISE Water Distillers Think wise. Think Pure. Think Tuttnauer. PUREWISE water distillers operate by heating water to F (00 C), which kills bacteria, cysts and or viruses that may be present, and converting it to steam. As the steam rises it leaves behind any solids, salts, heavy metals, etc.; lowboiling, light gases are discharged through the gaseous vent. The steam is then cooled in the stainless steel condenser, where it turns back into high quality, pure water. To further enhance water quality, the distilled water passes through a coconut shell carbon filter to extract any volatile organic compounds (VOCs) and is finally deposited in the unit s GE Lexan polycarbonate collection/storage container. Product features Effectively removes most tap water impurities Automatic shutoff after gallon cycle Rustproof stainless steel condenser Includes collector/storage bottle UL listing: #8KL Water system is 99% free of impurities Easttoremove boiler for manual fill no water hookup Unique recessed heating base reduces scale buildup Additional product features of 7000 series Extralarge capacity Benchtop and floorstanding models available Front or sidemounting spout for easy dispensing and storage Directly connects to tap water supply for continuous operation Technical specifications 9000 7000 70008 7000 Distillate capacity gal/.8l in.5h; up to 5gal/8.9L in h.5 gal/. L in 8h 8 gal/0. L in 8 h gal/5. L in 0 h Clean & Simple Ultrasonic Baths Ultrasonic bath features Builtin heater ( H models) for added sample processing and cleaning power High efficiency 0 khz of cavitation for thorough and quiet cleaning Durable vinylclad steel housing is easy to clean and resist scratching Stainless steel tank with cover included Full line of accessories available Technical Specifications Tank dimensions (W x H x D) External dimensions (W x H x D) Tank capacity 9. x x 5. in.8 x 0. x.7 cm. x 8.8 x 9.9 in x. x 5 cm 0.8 gal/. L New Clean & Simple ultrasonic baths feature 0kHz of quiet cleaning power, which is less aggressive to instruments, yet strong enough to remove all surface contamination. Systems are available in and gallon sizes for standard glassware and instruments. A full selection of optional accessories are available to meet your specific needs. For added samples processing and cleaning power, choose an H model. Which features a builtin heating unit. Fill your ultrasonic bath water and drop in two cleaning tablets. Watch them dissolve and clean in about a minute. The tablets create a nonionic cleaning solution that is noncorrosive, nontoxic, noncaustic and biodegradable. 9. x x 5. in.8 x 0. x.7 cm. x 8.8 x 9.9 in x. x 5 cm 0.8 gal/. L Cleaning Tablet features Eliminates handling of heavy gallon containers No bulky storage of premixing Enzymatic solution effectively breaks down protein CSU CSU H CSU CSU H 5.5 x x 9 in 9. x 5. x.9 cm 9 x.5 x in 9. x. x 0. cm.0 gal/.7l 5.5 x x 9 in 9. x 5. x.9 cm 9 x.5 x in 9. x. x 0. cm.0 gal/.7l Power supply Dimensions (W x H x D) Weight 5V/ 0 Hz 9.5 x 5 x in. x 8. x 0. cm 0lb/.5kg 5V/ 0 Hz x 7 x 7 in 8 x x cm 0lb/.5kg 5V/ 0 Hz x x 7 in 8 x 9 x cm 7lb/.5kg Ordering information 050 Benchtop water distiller 9000 00 Benchtop water distiller 7000 070 Floorstanding water distiller 70008 080 Floorstanding water distiller 7000 000 Carbon filter cartridge, for 9000, change after every months of use 5V/ 0 Hz x x 7 in 8 x 07 x cm lb/ 0kg Ordering Information Ultrasonic baths 0055 CSU, includes bath lid/cover 0075 CSU H, with builtin heater, includes bath lid/cover 005 CSU, includes bath lid/cover 0085 CSU H, with builtin heater, includes bath lid/cover Accessories 000 CSU spare parts kit, includes beaker holder, glass beakers, bands and beaker lids 000 CSU spare parts kit, includes beaker holder, glass beakers, bands and beaker lids 0050 CSU sample basket 000 CSU sample basket 000 Carbon filter cartridge, pkg. of 000 Clean & Simple ultrasonic cleansing tablets, box of tablets 7

Heidolph North America Jarvis Avenue Elk Grove Village, IL 0007 Phone 5900 Fax 59 sales@heidolph.com www.heidolphna.com