Worldwide Contacts www.tyco-fire.com Model BFV-/BFV-C Butterfly Grooved End General Description The TYCO Models BFV- (Normally Open) and BFV-C (Normally Closed) Grooved End Butterfly s are indicating type valves designed for use in fire protection systems where a visual indication is required as to whether the valve is open or closed. They are used, for example, as system, sectional and pump water control valves. They have grooved inlet and outlet connections that are suitable for use with grooved end pipe couplings that are listed and approved for fire protection systems. For applications requiring supervision of the open or closed position of the valve, the Gear Operators for the Model BFV-/BFV-C Butterfly s are provided with two sets of factory installed internal switches each having SPDT contacts (Ref. Figures and ). The supervisory switches transfer their electrical contacts when there is movement from the normally open or normally closed disc position during the first two revolutions of the handwheel. NOTICE The Model BFV-/BFV-C Grooved End Butterfly s described herein must be installed and maintained in compliance with this document, as well as with the applicable standards of the National Fire Protection Association, in addition to the standards of any other authorities having jurisdiction. Failure to do so may impair the performance of these devices. The owner is responsible for maintaining their fire protection system and devices in proper operating condition. Contact the installing contractor or product manufacturer with any questions. Technical Data s: ANSI 2-/2, (DN80), (DN00), 5 (DN), 6 (DN50), 8 (DN200), 0 (DN0) Approvals UL Listed FM Approved CE Certified All laboratory listings and approvals are for indoor and outdoor use. Maximum Working Pressure 2-/2 8 Inch (DN65 DN200): psi bar 0 Inch (DN0): 75 psi (2,0 bar) Maximum Working Temperature 22 F (00 C) in accordance with UL 09 Materials of Construction Body Ductile Iron A56 Body Coating Nylon: RILSAN Fine Powders (PA) Black Disc Ductile Iron A56 Disc Seal EPDM Encapsulated Upper & Lower Stem AISI 0 Actuator 2-/2 6 Inch (DN65 DN50): IP 65, bronze traveling nut gearbox with internal dual switch in ductile iron housing 8, 0 Inch (DN200, DN0): IP 65, segmented gearbox with internal dual switch in ductile iron housing For fire protection pressure rating, listing and approval information, contact your TYCO representative. Tapping Bosses Two factory-plugged NPT threaded tapping bosses are located in the valve body on the up- and downstream sides of the disc for connection to valve trim. Tapping boss sizes: 2-/2, inch (DN65, DN80)...2 x / NPT 0 inch (DN00 DN0)...2 x /2 NPT Conforms to UL 260 - ANSI/NFPA 00% Silicone Free BFV-/BFV-C Butterfly s are produced and assembled not using silicone lubricants in any form (like grease or aerosol spray) and are suitable for paint or oxygen applications. Control Seat Leakage Class IEC 605- CLASS VI (Type C) Control Seat Leakage according to ANSI/FCI 70-2-2006 (ASME B6.0) Page of 8 SEPTEMBER 205 TFP5
TFP5 Page 2 of 8 Pipe OD Dimensions A B C D E F G H J Weight Lbs. (kg) 2-/2 2.88 (7,0).8 (96,).72 (297,8).5 (85) (9,8).92 ().28 (08,6).99 (50,5).2 (5,) 76, 76,.8 (96,).72 (297,8).5 (85) (9,8).92 ().28 (08,6.99 (50,5).2 (5,) (DN80).5 (88,9).8 (96,) 2.22 (0,).58 (9) 5.76 (6,).92 ().28 (08,6).99 (50,5) 2.57 (5,7) (DN00).5 (,).5 (5,).92 (5,5).29 (09) 6.75 (7,5).92 ().28 (08,6).99 (50,5) 5.65 (7,) 9,7 (DN) (9,7) 5.8 (8) 6 (06,6) 5.6 () 7.9 (20,5) 5.9 (50) 5.79 (7) 2.2 (58,9).79 (,7) 5 (DN) 6 (,) 5.8 (8) 6 (06,6) 5.6 () 7.9 (20,5) 5.9 (50) 5.79 (7) 2.2 (58,9).79 (,7) DN50 6.5 65, 5.8 (8) 7.07 (,6) 5.7 (5) 8. (2,5) 5.9 (50) 5.79 (7) 2.2 (58,9) 28,66 () 6 (DN50) 6.6 (68,) 5.8 (8) 7.07 (,6) 5.7 (5) 8. (2,5) 5.9 (50) 5.79 (7) 2.2 (58,9) 28,66 () 8 (DN200) 8.6 (29,) 5.2 () 9.67 (99,5) 6.69 (70) 9.29 (26) 8.86 (2) 8.9 (208) 2.76 (70) 5.66 (,7).2 (,) 6.9 (22,5) 0 (DN0) 0.75 (27) 6.26 (59) 22.6 (570,5) 7.68 (95). (282). (28) 8.9 (208) 2.9 (7) 7.2 (8,).65 (,8) 72.75 () G F /2" NPT CONDUIT CONNECTION INDICATOR FLAG GEAR OPERATOR E BODY TAPPING BOSSES D C B H HANDWHEEL DISC Installation The Model BFV-/BFV-C Grooved End Butterfly s may be installed with flow in either direction and can be positioned either horizontally or vertically. The grooved end pipe couplings used with the Model BFV-/BFV- C must be listed or approved for fire protection service and installed in accordance with the manufacturers instructions. FIGURE MODEL BFV-/BFV-C GROOVED END BUTTERFLY VALVE NOMINAL DIMENSIONS The Model BFV-/BFV-C Butterfly may be installed with any schedule of pressure class of pipe or tubing that is listed or approved for fire protection. As applicable, refer to Figure or 5 for the internal switch wiring diagram. J A Conduit and electrical connections are to be made in accordance with the authority having jurisdiction and/or the National Electrical Code. With reference to Figure for the open position or Figure 5 for the closed position, the supervisory switch is intended for connection to the supervisory circuit of a fire alarm control panel in accordance with NFPA 72. The auxiliary switch is intended for the unsupervised connection to auxiliary equipment in accordance with NFPA 70, National Electric Code. NOTE: For outdoor applications with internal supervisory switches, it is recommended that wiring connections be made at a temperature above 5 F (-9 C), in order to insure sufficient flexibility of the wire lead insulation.
TFP5 Page of 8 No. Part Material Qty. 0 Body A-56 02 Upper Stem AISI 0 0 Lower Stem AISI 0 0 Disc EPDM 05 O-Ring (P2) EPDM 06 07 Oiless B/R (MB0) End Cap 2-/2 Inch 08 Gear Box 09 09 Traveling Nut 2-/2 6 Inch Segment Gear 8, 0 Inch EPDM A-56 Bronze C60BD 0 Bushing (2) FD-0205-5 Cover A-69 2 Bushing Fe Headless Wrench Bolt M5 x 7L A-07 No. Part Material Qty. Stem Housing Fe 5 Spring Pin 6 Indicator A-228 A-69 7 O-Ring NBR 8 Cover Gasket Paper 9 Spring Pin Ø5 x T x A-228 20 O-Ring (P0) EPDM 2 Worm Shaft AISI 0 22 Bushing () FD-0205-5 2 Collar FD-0205-5 2 Spring Washer 26 Hex Bolt M8 x 20L Hex Bolt M8 x L A-67 A-67 A-67 27 Gasket Paper 2 2 No. Part Material Qty. 28 Spring Pin Ø x 0.8t x 29 Handwheel 0 Bolt (Round) Plate Washer A-228 A-56 A-67 A-67 2 Switch Assembly T/R Bolt Tapping Screw ST.5 x 7.5 A-07 2 S0C 5 Tooth Washer # S0C 6 Lever A-69 7 Connector 8 Sticker 9 Sticker 0 Spring Pin Ø x 0.6T x Headless Wrench Bolt /2 - NPT A-228 A-07 2 5 7 0 7 5 6 0 2 2 6 8, 9 8, 9 28 28 29 2 22 2 2 20 9, 0 7 0 2 8 0 09 08 05 02 6 5 27 26 29 20 2 22 2 2 9, 0 7 0 2 8 0 09 08 05 02 6 5 27 26 0 0 0 0 0 0 06 07 06 07 BFV- Normally Open Supervisory Switch Arrangement BFV-C Normally Closed Supervisory Switch Arrangement FIGURE 2 MODEL BFV- AND BFV-C GROOVED END BUTTERFLY VALVE ASSEMBLIES
TFP5 Page of 8 S- 6A V/0 VAC CLOSED (RED) FIRE ALARM CONTROL PANEL SUPERVISORY CIRCUIT COMMON (WHITE) OPEN (YELLOW) END OF LINE RESISTOR OR NEXT DEVICE ACTUATOR CASE GROUND (GREEN) CLOSED (ORANGE) S-2 VOLTAGE SOURCE COMMON (BLACK) OPEN (BLUE) AUX. DEVICE (BELL OR HORN) FIGURE MODEL BFV- BUTTERFLY VALVE INTERNAL SWITCH WIRING DIAGRAM WITH VALVE IN NORMALLY OPEN POSITION S- 6A V/0 VAC CLOSED (RED) FIRE ALARM CONTROL PANEL SUPERVISORY CIRCUIT COMMON (WHITE) OPEN (YELLOW) END OF LINE RESISTOR OR NEXT DEVICE ACTUATOR CASE GROUND (GREEN) CLOSED (ORANGE) S-2 VOLTAGE SOURCE COMMON (BLACK) OPEN (BLUE) AUX. DEVICE (BELL OR HORN) FIGURE MODEL BFV-C BUTTERFLY VALVE INTERNAL SWITCH WIRING DIAGRAM WITH VALVE IN NORMALLY CLOSED POSITION
TFP5 Page 5 of 8 NOMINAL PRESSURE DROP IN POUNDS PER SQUARE INCH (PSI) 9.0 8.0 7.0 6.0 5.0.0.0 2.0.0 0.9 0.8 0.7 0.6 0.5 0. FLOW RATE IN LITERS PER MINUTE (LPM) ( GPM =,785 LPM) 00 600 8000 2000 000 600000 20000 2-/2 INCH INCH (DN80) INCH (DN00) 5 INCH (DN) 6 INCH (DN50) 8 INCH (DN200) 0 INCH (DN0) 0,60 0,50 0,0 0,0 0,20 0,0 0,09 0,08 0,07 0,06 0,05 0,0 0,0 NOMINAL PRESSURE DROP IN BAR ( PSI = 0,06895 BAR) 0. 00 200 00 600 8000 200 000 6000 FLOW RATE IN GALLONS PER MINUTE (GPM) GRAPH A 2-/2 INCH THROUGH 0 INCH (DN0) MODEL BFV-/BFV-C BUTTERFLY VALVE NOMINAL PRESSURE DROP VERSUS FLOW
TFP5 Page 6 of 8 2-/2 DN65 (DN80) (DN00) DN 5 (DN) DN50 6 (DN50) 8 (DN200) 0 (DN0) Pipe O.D. 2.88 (7,0) 76,,5 (88,9).5 (,) (9,7) 6 (,) 6.5 (65,) 6.6 (68,) 8.6 (29,) 0.75 (27) PSI (bar) 75 (2) BFV- Supervisory Switch OPEN Part Number BFV-C Supervisory Switch CLOSED 59G0WS 59G0WSC 59G026WS 59G026WSC 59G00WS 59G00WSC 59G00WS 59G00WSC 59G056WS 59G056WSC 59G050WS 59G050WSC 59G066WS 59G066WSC 59G060WS 59G060WSC 59G080WS 59G080WSC 59G00WS 59G00WSC Agency Listing/Approval CE UL C-UL FM VdS CCCf PAVUS VNIPPO TABLE A MODEL BFV-/BFV-C GROOVED END BUTTERFLY VALVE WITH INTERNAL NORMALLY OPEN OR CLOSED SUPERVISORY SWITCHES PART NUMBER SELECTION AND AGENCY LISTINGS/APPROVALS 2-/2 DN65 (DN80) (DN00) DN 5 (DN) DN50 6 (DN50) 8 (DN200) 0 (DN0) Pipe O.D. 2.88 (7,0) 76,,5 (88,9).5 (,) (9,7) 6 (,) 6.5 (65,) 6.6 (68,) 8.6 (29,) 0.75 (27) PSI (bar) 75 (2) BFV- Supervisory Switch OPEN Part Number BFV-C Supervisory Switch CLOSED Agency Listing/Approval CE UL C-UL FM VdS CCCf APSAD PAVUS VNIPPO 59G0AWS 59G0AWSC 59G026AWS 59G026AWSC 59G00AWS 59G00AWSC 59G00AWS 59G00AWSC 59G056AWS 59G056AWSC 59G050AWS 59G050AWSC 59G066AWS 59G066AWSC 59G060AWS 59G060AWSC 59G080AWS 59G080AWSC 59G00AWS 59G00AWSC TABLE B MODEL BFV-/BFV-C GROOVED END BUTTERFLY VALVE WITH INTERNAL NORMALLY OPEN OR CLOSED SUPERVISORY SWITCHES APSAD PART NUMBER SELECTION AND AGENCY LISTINGS/APPROVALS
TFP5 Page 7 of 8 Pipe O.D. PSI (bar) Part Number Agency Listing/Approval CE UL C-UL FM VdS CCCf PAVUS VNIPPO 2-/2 DN65 (DN80) (DN00) DN 5 (DN) DN50 6 (DN50) 8 (DN200) 0 (DN0) 2.88 (7,0) 76,,5 (88,9).5 (,) (9,7) 6 (,) 6.5 (65,) 6.6 (68,) 8.6 (29,) 0.75 (27) 75 (2) 59G0NS 59G026NS 59G00NS 59G00NS 59G056NS 59G050NS 59G066NS 59G060NS 59G080NS 59G00NS TABLE C MODEL BFV- GROOVED END BUTTERFLY VALVE WITHOUT SUPERVISORY SWITCHES PART NUMBER SELECTION AND AGENCY LISTINGS/APPROVALS 2-/2 (DN65 DN00) 5 6 (DN DN50) 8, 0 (DN200, DN0) Bernstein i88-ip65 Regular Switch Part Number Bernstein i88-ip65 LED Switch-2V Bernstein GC-SUZ Ex IP-66/67 ATEX (II 2 Ex d IIC T6) Switch 59SPBRACKSW0 59SPBRACKSW0LED 59SPBRACKSW0ATEX 59SPBRACKSW20 59SPBRACKSW20LED 59SPBRACKSW20ATEX 59SPBRACKSW0 59SPBRACKSW0LED 59SPBRACKSW0ATEX TABLE D MODEL BFV- GROOVED END BUTTERFLY VALVE MOUNTING BRACKET ASSEMBLY INCLUDING BERNSTEIN EXTERNAL SWITCH PART NUMBER SELECTION Part Number 2-/2 (DN65 DN00) 5 6 (DN DN50) 8, 0 (DN200, DN0) 59SPHWHEEL0 59SPHWHEEL20 59SPHWHEEL0 TABLE E BFV-/BFV-C GROOVED END BUTTERFLY VALVE HANDWHEEL WITH PIN PART NUMBER SELECTION
TFP5 Page 8 of 8 Care and Maintenance Before closing a fire protection system control valve for maintenance or inspection work on either the valve or fire protection system which it controls, permission to shut down the affected fire protection systems must be obtained from the proper authorities and all personnel who may be affected by this decision must be notified. The owner is responsible for the inspection, testing, and maintenance of their fire protection system and devices in accordance with the applicable standards of the National Fire Protection Association (e.g., NFPA ), in addition to the standards of any authority having jurisdiction. Contact the installing contractor or product manufacturer with any questions. Any impairment must be immediately corrected. It is recommended that automatic sprinkler systems be inspected, tested, and maintained by a qualified inspection service. Limited Warranty For warranty terms and conditions, visit www.tyco-fire.com. Ordering Procedure Model BFV-/BFV- Grooved End Butterfly s BFV- With Internal Normally Open Supervisory Switches Specify: (specify size) Model BFV- Grooved End Butterfly, Internal Normally Open Supervisory Switches, P/N (specify per Table A) BFV-C With Internal Normally Closed Supervisory Switches Specify: (specify size) Model BFV- C Grooved End Butterfly, Internal Normally Open Supervisory Switches, P/N (specify per Table A) BFV- With Internal Normally Open Supervisory Switches APSAD Approved Specify: (specify size) Model BFV- Grooved End Butterfly, Internal Normally Open Supervisory Switches, APSAD Approved, P/N (specify per Table B) BFV-C With Internal Normally Closed Supervisory Switches APSAD Approved Specify: (specify size) Model BFV- C Grooved End Butterfly, Internal Normally Open Supervisory Switches, APSAD Approved, P/N (specify per Table B) Without Supervisory Switches Specify: (specify size) Model BFV- Grooved End Butterfly, P/N (specify per Table C) Replacement Parts Refer to Figure 2 to identify parts. NOTE: Only items described in this section are offered as replacement parts. Mounting Bracket Assembly with Bernstein External Switch Specify: Mounting Bracket with Bernstein (specify model per Table D) External Switch, (specify size) Model BFV- Grooved End Butterfly, P/N (specify per Table D) Handwheel with Pin Specify: Handwheel with Pin, (specify size) Model BFV-/BFV- C Grooved End Butterfly, P/N (specify per Table E) GLOBAL HEADQUARTERS 00 Pennbrook Parkway, Lansdale, PA 96 Telephone +--62-0700 Copyright 205 Tyco Fire Products, LP. All rights reserved. RILSAN is a registered trademark of Arkema, Inc.