DSC Series Submittal Data Form 3-5 Ton Packaged Air Conditioner 14 SEER / Up to 12.0 EER Job Name Purchaser Order No. Engineer Unit No. Model No. Unit Designation Performance Data Certified By: Standard Features High-efficiency scroll compressor Copper tube/aluminum fin coils High- and low-pressure switches Contactor with lugs High-capacity, steel-cased filter drier Heater kits with single-point entry 24-volt terminal strip Convertible airflow orientation Easy to service Built-in filter rack with standard 2" filters Bottom utility entry AHRI Certified; ETL Listed 3-5 Tons with single speed blower motor units meet the performance specified in Table 6.8.1-1 of ASHRAE Standard 90.1-2013 Cabinet Features Heavy-gauge, galvanized-steel cabinet with UV-resistant powder-paint finish Full Perimeter Rail Sloped drain pan * Complete warranty details available from your local distributor or manufacturer s representative or at www.daikincomfort.com. SS-DSC3 www.daikincomfort.com 11/16
Performance Data Cooling Performance Total Capacity MBH Sensible Capacity MBH Outdoor Design TMP ºF DB / WB Air Temp entering Evaporator Coil ºF Power Input Required kw (less blower motor) Heating Performance Total Heating Capacity kw BTU/h Supply Air Blower Performance Total Supply Air Ext. Static Pressure Blower Speed Power Output Required Motor Ratings Power Input Required CFM IWG RPM BHP HP kw Electrical Data Power Supply Total Unit Amps Amps Max Overcurrent Device: Fuse Breaker Amps 2 www.daikincomfort.com SS-DSC3
Dimensions 19.470 5.104 12.000 CONDENSATE DRAIN BOTTOM EXIT SUPPLY AIR DUCT 17.000 48.312 23.442 11.000 20.905 6.192 5.558 25.000 RETURN AIR DUCT 74.061 BASE PAN VIEW (VIEWED FROM TOP) CONDENSATE MODEL TONNAGES "A" "B" "C" 3 TON COMMERCIAL GAS, HT PUMP, AIR CONDITIONER 38.840 16.555 26.055 4 TON COMMERCIAL GAS, HT PUMP, AIR CONDITIONER 38.840 16.555 26.055 5 TON COMMERCIAL GAS, AIR CONDITIONER 38.840 16.555 26.055 BOTTOM EXIT 7.984 LINE WIRE ENTRANCE "A" "C" "B" 8.555 TSTAT WIRE ENTRANCE 5.872 10.372 LEFT END VIEW SS-DSC3 www.daikincomfort.com 3
Accessories Daikin Master Item # Description Fits Model Sizes Field- Installed HSKTS0361 High Static Kit - 230v & 460v DS*, 3 Ton HSKTS0481 High Static Kit - 230v & 460v DS*, 4 Ton HSKTS0601 High Static Kit - 230v & 460v DS*, 5 Ton HSKTS060HP1 High Static Kit - 230v & 460v DS*, 5 Ton, Heat Pump HSKTS036-71 High Static Kit - 575v DS*, 3 Ton HSKTS048-71 High Static Kit - 575v DS*, 4 Ton HSKTS060-71 High Static Kit - 575v DS*, 5 Ton HSKTS060HP-71 High Static Kit - 575v DS*, 5 Ton, Heat Pump Factory- Installed **EHK2 Heater Kits 3-5 Ton 14CURB3672B Roof Curb 14 Tall 3-5 Ton 14CURB3672BNP Roof Curb 14 Tall No Insulated Panels 3-5 Ton 36DROP3672B Supply and Return Drop 3-5 Ton CDK36 Concentric Duct Kit 3 Ton CDK36515 Flush Mount Concentric Duct Kit w/ Filter 3 Ton CDK36530 Step Down Concentric Duct Kit 3 Ton CDK36535 Step Down Concentric Duct Kit w/ Filter 3 Ton CDK4872 Concentric Duct Kit 4-5 Ton CDK4872515 Flush Mount Concentric Duct Kit w/ Filter 4-5 Ton CDK4872530 Step Down Concentric Duct Kit 4-5 Ton CDK4872535 Step Down Concentric Duct Kit w/ Filter 4-5 Ton D25FD3672 25% Manual Fresh Air Damper 3-5 Ton D25MFD3672 25% Motorized Fresh Air Damper 3-5 Ton DBRD3672 Barometric Relief Damper 3-5 Ton DDNECNJ3672C4 Low Leak Downflow Economizer 3-5 Ton (MCDANIEL METALS)4 DDNECNJ3672NR4 Downflow Low-Leak Economizer 3-5 Ton (No Barometric Relief) (MCDANIEL METALS)4 Ultra Low Leak Downflow Economizer (ROOFTOP SYSTEMS) 3 3-5 Ton DDNSQRD3616 Downflow Square to Round Adapter (16 Round) 3 Ton DDNSQRD487218 Downflow Square to Round Adapter (18 Round) 4-5 Ton DHZECNJ3672 Horizontal Economizer 3-5 Ton DNBBS3672 Burglar Bar Sleeves Includes Supply and Return 3-5 Ton DPE367224 Downflow Power Exhaust (208/230v) 3-5 Ton DPE367244 Downflow Power Exhaust (460v) 3-5 Ton DPE367274 Downflow Power Exhaust (575v) 3-5 Ton 4 www.daikincomfort.com SS-DSC3
Accessories (cont.) Daikin Master Item # Description Fits Model Sizes Field- Installed Factory- Installed 3PMK01 3-Phase Monitor (for models with DDC Control) 3-5 Ton 3PMNDK01 3-Phase Monitor (Non-DDC Control models) 3-5 Ton DFSKT01 Ditry Filter Kit (for models with DDC Control) 3-5 Ton FSK01A Freeze Stat Kit All Models Convenience Outlet : Non Powered All Models Convenience Outlet : Powered All Models Disconnect Switch All Models GHRC-3672B Hurricane/Seismic Clips 3-6 Ton HAILGD03D Hail Guard Kit 3-5 Ton IRKT-01 Isolation Relay Kit 3-5 Ton LAKT11 Low Ambient Kit 3-5 Ton (208/230v) LAKT13 Low Ambient Kit 3-5 Ton (460v) LAKT14 Low Ambient Kit 3-5 Ton (575v) DLAKT01 Low Ambient Kit (for models with DDC Control) 3-5 Ton SPKT01 Single Point Kit - Single Phase 3-5 Ton SPKT02 Single Point Kit - Three Phase 3-5 Ton Smoke Detector (supply and/or return) 3-5 Ton Hinged Panels 3-5 Ton DDC Communicating Controller 3-5 Ton (built-in BACnet MS/TP) LONKT01 LonWorks (for models with DDC Control) 3-5 Ton 1 High static airflow requires installation of high static kit (HSKT*). 2Complete listing of EHK kits listed on electrical data page in this manual. 3If this economizer is used for factory installed and power exhaust is also required, please contact RRS Rooftop Systems directly for more information and ordering accessories. Ultra Low-Leak Economizer is used with DDC controller. 4If this economizer is used for factory or field installed application and power exhaust is also required, please use appropriate power exhaust: DPE36722, DPE36724, DPE36727. SS-DSC3 www.daikincomfort.com 5
Roof Curb #D14CURB3672 3-D View Top View Insulated Panels 70¾ 40¼ 14 x 20 Supply Opening 31⅝ x 14 Return Opening 14 1 5 /6 ¾ 1⅜ 14 18-Gauge Construction 1 x 4 Wood Nailer attached to top of the curb Shipped knocked down with all hardware Gasket included Bed-Rail style corners Note: outside duct dimension should be ½ less than opening dimensions above. No Curb Adapter Required when Replacing Carrier & Bryant Models No curb adapter is required when replacing an existing Carrier or Bryant RTU with a Daikin RTU in these situations; the footprints and locations of the return and supply duct work match. New Unit Existing Carrier Existing Bryant 3 to 6 Tons 48/50 TJ, LJ, DJ, QJ 48/50 TM, HJ 004-007 580C-D, 558C-D, 548C-D 580F, 558F, 581B 036-072 6 www.daikincomfort.com SS-DSC3
Manual Fresh Air Damper #D25FD3672 Motorized Fresh Air Damper #D25MFD3672 Manual Damper Provides up to 25% fresh air Locking selection knob provides constant opening Painted to match the unit Fits all 3- to 5-ton package units in all fuels Motorized Damper 24 VAC Damper motor with spring return Fully assembled and factory wired Painted to match the unit Fits all 3- to 5-ton package units in all fuels Hail Guard #HailGD0* Condenser coil protection Prevents hail damage Easy to remove and clean Powder paint finish SS-DSC3 www.daikincomfort.com 7
Downflow Economizer #DDNECNJ3672 Fully modulating Up to 100% fresh air Integral barometric relief Hoods painted to match unit Honeywell economizer control Single adjustable enthalpy control convertible to dual enthalpy Adjustable minimum fresh air Factory wired Fits all 3- to 5-ton models 8 www.daikincomfort.com SS-DSC3
Horizontal Economizer #DHZECNJ3672 Fully modulating Up to 100% fresh air Honeywell economizer control Single adjustable enthalpy control convertible to dual enthalpy Adjustable minimum fresh air Factory wired Fits all 3- to 5-ton models SS-DSC3 www.daikincomfort.com 9
Barometric Relief Damper #DBRD3672 Hurricane / Seismic Clip GHRC-3672B 14-gauge construction and quantity of clips dictated by unit need Clips are fastened to the unit and curb using sheet-metal screws Seismic angle is fastened with approved fastener 10 www.daikincomfort.com SS-DSC3
Concentric Duct Kit #CDK36 / #CDK4872 Light Commercial T-Bar Ceiling Commercial T-Bar Ceiling All-aluminum diffuser with aluminum return air egg crate Built-in anti-sweat gasket Molded fiberglass transition (through five tons) Built-in hanging supports Diffuser box constructed of fiberglass duct board (through 7½ tons) or sheet metal Aluminum Egg Crate Hanging Support from the Diffuser Turing Vane to Ensure Proper Airflow Molded Fiberglass Transition SS-DSC3 www.daikincomfort.com 11
3-Ton Square-to-Round #DDNSQRD3616 4- to 6-ton Square-to-Round #DDNSQRD487218 Our continuing commitment to quality products may mean a change in specifications without notice. 2016 Houston, Texas Printed in the USA. 12 www.daikincomfort.com SS-DSC3