Pump-Mounted Heaters 4 - opper rute Heaters / Sizes, -,, Up to % Thermal Efficiency The unit will be designed and constructed in accordance with the SME oiler and Pressure essel ode Section I requirements for psi working pressure. The units will bear the SME "H" stamp and be registered by the National oard. -Year Limited Heat Exchanger Warranty / -Year Limited Warranty on omponent Parts. For more information on warranty, please visit www.bradfordwhite.com For products installed in US, anada and Puerto Rico. Some states do not allow limitations on warranties. See complete copy of the warranty included with the heater. MNUFTURED UNDER ONE OR MORE OF THE FOLLOWING U.S. PTENTS:,94,49;,,9;,94,94;,,9;,9,;,4,;,99,;,4,;,,;,4,9;,,; (),4,;,,;,9,9;,,; 4,94,4;,,;,,9; 4,9,44; 4,9,9; 4,,;,,;,9,9;,,4; 4,4,; 4,,4; 4,,9; 4,,99; Re. 4,4;,,. OTHER U.S. ND FOREIGN PTENT PPLITIONS PENDING. URRENT NDIN PTENTS:,,94;,,4;,9,;,4,;,,;,,;,,;,9,;,49,., radford White orporation. ll rights reserved. Printed in U.S.. 9-
opper-rute (-4) Heater Dimensions Illustrated dimensions are shown in inches. Optional ent ap Required Draft Hood (Dia.) " 4 9 /" INLET OUTLET /" RIGHT SIDE /" 4 /" opper-rute onvertible s NTURL GS ND LIQUID PROPNE GS 4SIN 4IN 4IN 44IN / / 4 / 4 / / 9 4EN 4EN 4EN 44EN / / 4 / 4 / / 9 4SIN 4IN 4IN 44IN 4EN 4EN 4EN 44EN Dimensions are nominal.
opper-rute (-4) Heater Specifications 4 4 9 4 SERIES SIZE 4 LOTION I - E - FUEL N - Natural P - Propane IGNITION - Stndg Pilot (Std.) - Spark 4 FIRING MODE - On/Off (Std.) K - Two-Stage ERSION - 9 Tube REISION - US HET EXHNGER - opper w/ronze trim (Std.) D - opper w/ronze trim, Rev. HX M - u/ni w/ronze trim, HX P - u/ni w/ronze trim PUMP N - Normal S - Soft opper-rute onvertible s NTURL GS ND LIQUID PROPNE GS 4SIN 4IN 4IN 44IN,,, 99, Output 4, 4,, 4, Temperature Rise cross Heater F 4 9 4 F Gas onnection Size / / / / / / / / pprox. 4 4EN 4EN 4EN 44EN 4SIN 4IN 4IN 44IN,,, 99, Output 4,,,, Output Temperature Rise cross Heater F 4 4 4 F 4 Temperature Rise cross Heater Liters Per Hour Delivered Gas onnection Size / / / / Gas onnection Size 9 9 9 9 / / / / pprox. 4 pprox. kg. 4 4EN 4EN 4EN 44EN Output Temperature Rise cross Heater Liters Per Hour Delivered Gas onnection Size 9 9 9 9 pprox. kg. Standard pumps provided based on water hardness. Hardness must be known before ordering. Soft water contains up to. grains per gallon. Normal water measures. through grains per gallon; and Hard water measures over grains per gallon. FOR INDOOR MODELS For s, change suffix N to P. configuration includes the separate drafthood. ll units feature: System Standing Pilot; Pump Delay; ll ronze Pump; Flow Switch (mounted and wired); and Remote quastat (E-44) FOR OUTDOOR MODELS For s, change suffix N to P. bove models include: Standing Pilot Ignition; Flow Switch (mounted and wired); ll ronze Pump and Fittings; and Remote quastat (E-44). Pump supplied for units to sized for normal water (- Grain Hardness). For hard or soft water pumps please consult factory. Notes:. drafthood required for all indoor applications. 4 needs p/n R 4 needs p/n R 4 needs p/n R4 44 needs p/n R. and output must be derated 4% per feet above sea level when installed above feet altitude.. ll dimensions are nominal.
opper-rute II (-) Heater Dimensions Illustrated dimensions are shown in inches. opper-rute Energy Saver s NTURL GS ND LIQUID PROPNE GS 4IN 4IN 4IN 4IN 4IN 4IN 44IN 4IN 4IN 4EN 4EN 4EN 4EN 4EN 4EN 44EN 4EN 4EN 4IN 4IN 4IN 4IN 4IN 4IN 44IN 4IN 4IN 4EN 4EN 4EN 4EN 4EN 4EN 44EN 4EN 4EN 9 / / 44 / / 9 44 / 9 9 / 44 / / 4 9 / 9 9 44 4 9 / 9 / / / / / / 9 / 9 / 9 / 4 s s ll dimensions are nominal. 4
opper-rute II (-) Heater Specifications 4 4 9 4 SERIES SIZE 4 LOTION I - E - FUEL N - Natural P - Propane IGNITION 9 - Spark Ign. (Std.) - Standing Pilot FIRING MODE - On/Off (Std.) K - Two-Stage (Std.) L - Four Stage F - Motor Mod. R - Motor On/Off T - Motor Two-Stage REISION - US ERSION - Tube () - Tube () HET EXHNGER - opper Tubes/Rev. HX - opper Tubes w/ronze trim - opper Tubes (Std.) D - opper Tubes w/ronze trim, Rev. HX K - ronze/opper Tubes L - ronze/opper Tubes, Rev. HX M - u/ni Rev. HX N - opper/nickel P - u/ni w/ronze trim R - u/ni Rev. HX S - ronze/uni T - u/ni w/ronze trim, Rev. HX PUMP OPTIONS Normal Pump, No Option Normal Pump w/sd- Soft Pump, No Option Soft Pump w/sd- Hard Pump, No Option Hard Pump w/sd- XX JX QK QJ HX P opper-rute Energy Saver s NTURL GS ND LIQUID PROPNE GS 4IN 4IN 4IN 4IN 4IN 4IN 44IN 4IN 4IN 4EN 4EN 4EN 4EN 4EN 4EN 44EN 4EN 4EN 4IN 4IN 4IN 4IN 4IN 4IN 44IN 4IN,,,,,,,,,4,,,,,,,,,,,,,,4,,,,, Output 4, 4, 9, 9,, 9,,,,,,4, Output 4, 4, 9, 9,, 9,,,,,,4, Output Temperature Rise cross Heater 9 F 4 4 9 9 9 44 4 9 9 F 4 4 9 9 9 44 4 9 F 4 9 9 9 4 F 4 9 9 9 4 4IN Standard pumps provided based on water hardness. Hardness must be known before ordering. Soft water contains up to. grains per gallon. Normal water measures. through grains per gallon; and Hard water measures over grains per gallon. FOR INDOOR MODELS & OUTDOOR MODELS For propane models, change N to P. units include ent Terminal and ombustion Terminal. bove models include: Hot Surface Ignition; Flow Switch (mounted and wired); ll ronze Fitted Pump; Pump Delay and Remote Sensor. Pump supplied are sized for normal water (- Grain Hardness). For hard or soft water pumps please consult factory. No drafthood required on size - outdoor units. 4 F 4 4 49 9 99 9 Temperature Rise cross Heater 4 F 4 4 49 9 99 9 Temperature Rise cross Heater Liters Per Hour Delivered Gas onnection Size, Notes:. and output must be derated 4% per feet above sea level when installed above feet altitude.. When two gas connections are shown, the smaller applies to the standard gas train, while the larger applies to optional trains such as four stage or motorized gas valves.. ll dimensions are nominal. / / / Gas onnection Size, / / / Gas onnection Size, / / / / / / / / / / pprox. 4 9 9 4 4 4 pprox. 4 9 9 4 4 4 pprox. kg.
Standard Features Thermal efficiency up to % SME psi working pressure heat exchanger SME "H" stamp, designed and certified for potable water use Flanged bronze water connections Glass-lined headers External header gaskets psi ( kpa) SME rated pressure relief valve Flow switch, mounted and wired Temperature/pressure gauge Pump, mounted and wired Multiple operating gas valve/pressure regulators Optional Equipment opper-nickel heat exchanger Normally open vent valve (- only, see IRI Package) Low water cutoff Motorized gas safety valve (-, see LDS Package) Double stack stand (- only) Reverse Heat Exchanger - switches the inlet and outlet to left side and pump to the right side enting ccessories (required for sidewall venting) Manual gas valve Washable intake air filter Multiple, removable burner trays Stainless steel burners uilt-in draft fan for ategory I or III vent systems ir pressure switch urner site glass 4 control system transformer Ignitor access panels Energy Management Monitor (EM ) pump time delay Manual reset high limit utomatic reset high limit (- only) SD- Package includes: Size -: Single Try Ignition, High and Low Gas Pressure Switches, and Gas Regulator. Excludes Low utoff. IRI Package, added to the SD- package includes: Size -: Single Try Ignition, High and Low Gas Pressure Switches with Manual reset, Normally Open ent alve, Safety alve with Gas Regulator and Leak Test alve. Excludes Low utoff Electronic PID staging control with LD and touchpad P board for electrical connections External controller connections with selector switch Hot surface ignition On/Off toggle switch Pump time delay Diagnostic lights Less than ppm NOx (- only) Less than ppm NOx (-4 only) ll models can be converted to either indoor use or outdoor use. For outdoor use, you must order exhaust vent and air intake vent (consult factory for part numbers) LDS Package includes: Size -: Safety alve with Gas Regulator, High Gas Pressure Switch and Leak Test alve. Size -: Solenoid Safety alve, Motorized alve with Proof of losure, Leak Test alve, High and Low Gas Pressure Switches. learances PPLINE SURFE REQUIRED LERNE FROM OMUSTILE MTERIL SUGGESTED SERIE ESS LERNES inch cm inch cm Left Side. 4 Right Side. 4 Top. ack*. Front. 9 ent Per venting supplier s instructions *When vent and/or air is connected to the back, " (9cm) is suggested. Motor Electrical Data WTER TEGORY Power (HP) urrent (mps) s Soft Normal Hard Soft Normal Hard W 4... W 4... W4 4... W 4... W 4... W 4... W 4... W 4 4... W 4 4 4... W 9. 9. 9. mbler, P For U.S. and anada field service, contact your professional installer or local radford White sales representative. Sales --9 Fax -4- / Technical Support -4-9 Fax 9-9-9 Warranty -- Fax 9-9-9 International: Telephone -4-94 Telefax -4-9 / www.bradfordwhite.com Sales / Technical Support -9-9 / 9-- Fax 9-- / www.bradfordwhite.com, radford White orporation. ll rights reserved. 9--- Printed in U.S..