BCG SERIES SERIAL NUMBERS WITH IW/IX/IZ/JG/JO REPLACEMENT PARTS LIST EFFECTIVE March 0, 00 BLODGETT OVEN COMPANY, Lakeside Avenue, Burlington, Vermont 050 USA Telephone: (0) 0-700 (00) -5 Fax: (0) 0-7 www.blodgett.com Superseding All Previous Parts List. The Company reserves the right to make substitution in the event that items specified are not available. ERRORS: Descriptive and or typographical errors are subject to correction.
TABLE OF CONTENTS CONTROL PANEL COMPONENTS... DOOR COMPONENTS... STEAM GENERATOR COMPONENTS... 5 HOT AIR GAS COMPONENTS... INTERIOR OVEN COMPONENTS... 7 EXTERIOR OVEN COMPONENTS... PLUMBING COMPONENTS... 9 TRANSFORMERS... 0 AUTO DELIMING KITS... ACCESSORIES...
BCG CONTROL PANEL COMPONENTS 9 7 5 0 5 0 Ref Description Part No. Ref Description Part No. Logic Board R05 Relay Module Assy(for units with serial numbers IN, IX, IZ) R5 Relay, Logic 90 Switch, Hi/Low R59 Relay, V, SPDT R79 Relay, DPST 0V R79 Switch, Flush/Drain R75 Switch, Mode R Knob and Shaft Assy, mode R55 7 Controller, Digital R70 Sensor, Temperature R9 7 Thermostat, Manual R07 Probe, Thermostat R00 Potentiometer, Steam R9 Timer, 0 Minute R 5 Buzzer Kit, 0V R99 5 Knob, Small R7 Knob, Large R7 Light, Indication- Green R 9 Light, Indication- Clear R0 Fuse, amp V R5755 Fuse Holder M7 0 Control, Meat Probe V R79 0 Control, Meat Probe 0V R5 Probe, Meat plug-in R55 Switch, Meat probe R70 Harness, Meat probe R79 Control, Motor speed R909 Connector, Jack Panel R59
BCG DOOR COMPONENTS 5 Ref Description Part No. Door Assy R Gasket, Door Perimeter R95 Retainer Strip, Gasket, Horizontal R77 Retainer Strip, Gasket, Vertical R775 Glass Window, Door R5797 Gasket, Door Window,(per foot- 7 total ft) R05 Handle, Door R Screws, Door Handle, set of R0 5 Catch and Latch Assy R9 Switch, Door 5 Magnet, Door Switch() R70 Bracket Assy, Door Switch R9 Hinge Assy, Top and Bottom R Drip Pan R07 Trough, Door Drip Pan R957 Nameplate, 7-/ BLODGETT 9 7 Deliming, Port Kit (hose fitting) R0 Deliming, Fitting on Pump (male) R0 Deliming, Port Female quick disconnut R00 Toggle Switch R900
5 BCG STEAM GENERATOR COMPONENTS 5 7 Ref Description Part No. Steam Generator w/ Burners, Nat R0 Steam Generator w/ Burners, LP R0 Steam Generator, Insulated- no burners R0 Insulation, Steam Generator R7 Drain Pump R7 Thermostat, High Limit F R0 Thermostat, Flush/ Drain P R0 Float Switch Assy R07 Floats () R7 Float Gasket, foot R0 Tube Assy, Float R5 Gasket, Float to pump tube R05 Burner Assy, Nat R9 Burner Assy, LP R9 Pilot Assy, Steam, Nat R99 Pilot Assy, Steam, LP R0 Orifice, Nat #5 Drill R90 Orifice, LP #7 Drill R9 5 Flue Assy R95 7 Hose, Deliming, / ID sold in 5 ft sections R00 Deliming Port Kit R0
BCG HOT AIR GAS COMPONENTS 9 7 5 Ref Description Part No. Burner Assy, Hot Air, Nat R9 Burner Assy, Hot Air, LP R9 Burner, Inshot R7 Pilot Assy, HotAir, Nat R9 Pilot Assy, Hot Air, LP R95 Bracket, Pilot mounting R90 7 Orifice,.5 mm drill, Nat (qty ) R97 7 Orifice, #7 drill. LP (qty ) R97 5 Manifold Assy, welded R95 Control, ignition G770 0 Valve, Gas main R7 Valve, Gas pilot R90 Valve, Gas, main (CNV) R957 Valve, Gas manual R0 Fitting, / NPT X.5 Compression 570 Bracket, Burner R0 9 Mounting Assy, Burner R97
7 BCG INTERIOR OVEN COMPONENTS 5 Ref Description Part No. Motor, 5V/0V / hp R50 Seal, motor shaft R Gortex Seal, 9 feet R5 Motor Assy w/ Seal andgortex R5 Wheel, blower R50 Baffle, air R970 Filter, grease R70 Fan, axial 0 Rack guides R09 Wire Shelf s/s R 5 Rack, Chicken R579 Heat Exchanger Assy, LH R5 Heat Exchanger Assy, RH R Heat Exchanger Retro Kit R05 Water Regulator R Cooking Compartment High Limit
BCG EXTERIOR COMPONENTS 7 Drain Assy 0 9 Ref Description Part No. Ref Description Part No. Module, Power Upgrade R0997 Power Cord, 5V R05 Hose, Silicone R0 Drain Assy R07 Vent Extension Assy Bottom R075 Hose, Flex Drain, R90 Clamp, Hose 7/ to R07 Support Bracket R055 Exhause tube, stacked unit LH R9 Exhaust tube, stacked unit RH R97 7 Flue Assy, Steam Generator R99 7 Flue Assy, Steam Gen. (CNV) R955 Panel, Float switch ALCT R957 Panel, Float switch, SS R9575 Flue Ext Assy, bottom R05 Flue Outlet, Top/sgl section R99 Flue Outlet, Bottom/dbl sec. R990 Kit, Vent/Drain Single R95 Kit, Vent/Drain Double R95 Cover, Motor ALCT R95 Cover, Motor SS R9 9 Caster Kit, low profile R0 0 Kit, Stacking Gas Manifold R9570 0 Kit, Stacking Gas Man.(CNV) R9 Body Back, ALCT R0 Body Back, SS R0 Guard, Axial Fan 7 Axial Fan 0 Model power inlet for pump R90 Fuses for pump R0 Cord for pump R9
PLUMBING COMPONENTS 9 BCG 9 7 0 5 9 Ref Description Part No Solenoid Assy, complete R99 Manifold Assy, complete R9579 Pressure Regulator Assy R Manifold, Inlet Water R957 5 Fitting, / NPT to GHT R950 Washer, Garden Hose R7750 Hot Water Conversion G R90 7 Solenoid Valve Assy () R Tube, / X s/s flex R95 9 Tube, / x ss flex R0 0 Fitting, Compression / R95 Supressor, Assy Arc R790 Reducer, slow fill R9
0 BCG TRANSFORMERS Ref Description Part No. Transformer 0/ 0VA M99 Transformer, 0/ 50VA R7 Control, Ignition G770 MGC 0 Autotransformer, KVA 0-5 R9
BCG AUTODELIMING KITS Description Part No. FOR A COMPLETE KIT INCLUDING PUMP: Single/ Bottom, aluminized R079 Top section of double, aluminized R079 Single/Bottom, stainless steel R0797 Top section double, stainless steel R0799 Fuse, 5 X 0MM Time Lag, High R0 FOR A KIT TO HANG AN EXISTING PUMP: Single, aluminized R07 Double Stack, aluminized R07 Single, stainless steel R077 Dounle Stack, stainless steel R079 Fuse, 5 X 0MM Time Lag, High R0
BCG ACCESSORIES 5 7 Ref Description Part No. Description Part No. Stand, R55 Body Back, ALCT R0 Stand, R5550 Body Back, SS R0 Casters, for Stand R55 Kit, Stacking Gas Manifold R9570 Legs, 5 R99 Kit, Stacking Gas Man.(CNV) R9 Legs, w/bolts S/S 00 Water Filter Kit BWG-K 07 Legs, R09 Water Filter Kit BWG-7K 07 Legs, bolt down/seismic for stands R55 Kit, Filter Accessory Single 090 Caster Kit, set of, low profile R0 Kit, Filter Accessory Double Casters, for 5 legs 00 NOTE: Cartridges must be ordered from Casters, set of, mounts to bottom of unit R Selecto ONLY--00-75-9. Pressure Spray Bottle R0955 Rack, Wire R 5 Rack, Chicken Holder R579 Rack, French Fry D0 Hose and Spray Assy, 0Ft R099 7 Deliming Bottle (w/ garden hose conn.) R59 7 Deliming Bottle (w/ male hose barbed fitting) R0559