Star Manufacturing International Inc. 10 Sunnen Dr. St. Louis, MO 63143 Phone: (314) 781-2777 FAX: (314) 781-3636 Installation and Operating Instructions 2M-Y5707 Rev. C 8/15/95 SOUP KETTLE COOKERS and HOLDERS MODELS 7C, 7H, 11C, 11H MODEL 11C 1
CAUTION This equipment is designed and sold for commercial use only by personnel trained and experienced in its operation and is not sold for consumer use in and around the home nor for use directly by the general public in food service locations. INSTALLATION These food warmers are equipped for the voltage and wattage indicated on the nameplate mounted to the back panel and are designed for use on alternating current (AC) only. Serious damage may result if appliance is used with incorrect voltage. CAUTION DO NOT CONNECT TO DIRECT CURRENT (DC). GENERAL OPERATING INSTRUCTIONS 1. Before using the soup kettle, clean the water and soup bowls and its cover if furnished with the kettle. 2. Do not operate the kettle dry. Place water in the water bowl (14 ounces of water for 11 qt. Model, 26 ounces for the 7 qt. Model). 3. The temperature control on these kettles is a combination On/Off switch with an infinite control. The "OFF" position will turn off the electric current to the heating element. 4. If PRE-HEATING IS DESIRED SET THE CONTROL AT "HI" for approximately 20-30 minutes. Prolonged "HI" setting may result in overcooking or scorching of certain food. 5. Set the dial to the number required to maintain the temperature desired. Because the consistency of different food varies, and because liquids and solids absorb heat at different rates, it is impractical to specify the exact dial setting. Therefore, we have indicated the setting with a series of numbers. A little experience will give you the proper setting for various foods you are serving. 6. The soup cookers are equipped with a warning light to prevent overheating or scorching of certain soups. When the light is on, all electric current to the heating elements will be off. Turn the heat setting down to a lower setting and wait 5-10 minutes for the light to go out. It would also be advisable to check the water level in the water bowl. 7. Turn the control to the "OFF" position when the unit is not in use. CAUTION DO NOT OVER-HEAT THE UNIT. CLEANING INSTRUCTIONS Change water in water bowl daily and remove any food collection that may have entered the water bath. Clean soup bowl, cover and the kettle at a sink with soap and water. The exterior surfaces of the warmer can be kept clean and attractive by wiping or washing regularly with a soft cloth and mild soap and water. Any discoloration on the bowls and cover can be removed with a non-abrasive cleaner. Do not use an abrasive cleaner as the attractive coatings will be affected adversely. MAINTENANCE AND REPAIRS Contact the factory, a service representative or a local service company for service or required maintenance. 2 RETAIN THIS MANUAL FOR FUTURE REFERENCE PART NO. 2M-Y5707 REV. C 8/15/95
Visit our Website at: www.star-mfg.com Email: service@star-mfg.com For Fax-On-Demand Literature: (800) 807-9814 THOROUGHLY INSPECT YOUR UNIT ON ARRIVAL This unit has been tested for proper operation before leaving our plant to insure delivery of your unit in perfect condition. However, there are instances in which the unit may be damaged in transit. In the event you discover any type of damage to your product upon receipt, you must immediately contact the transportation company who delivered the item to you and initiate your claim with same. If this procedure is not followed, it may affect the warranty status of the unit. LIMITED EQUIPMENT WARRANTY All workmanship and material in Star products have a one (1) year limited warranty on parts & labor in the United States and Canada. Such warranty is limited to the original purchaser only and shall be effective from the date the equipment is placed in service. Star's obligation under this warranty is limited to the repair of defects without charge, by the factory authorized service agency or one of its sub-agencies. Models that are considered portable (see below) should be taken to the closest Star service agency, transportation prepaid. > Star will not assume any responsibility for loss of revenue. > On all shipments outside the United States and Canada, see International Warranty. * The warranty period for the JetStar series six (6) ounce popcorn machines is two (2) years. * The warranty period for the Chrome-Max Griddles is five (5) years on the griddle surface. See detailed warranty provided with unit. * The warranty period for Teflon/Dura-Tec coatings is one year under normal use and reasonable care. This warranty does not apply if damage occurs to Teflon/Dura-Tec coatings from improper cleaning, maintenance, use of metallic utensils, or abrasive cleaners. This warranty does not apply to the non-stick properties of such materials. > This warranty does not apply to "Special Products" but to regular catalog items only. Star's warranty on "Special Products" is six (6) months on parts and ninety (90) days on labor. > This warranty does not apply to any item that is disassembled or tampered with for any purpose other than repair by a Star Authorized Service Center or the Service Center's sub-agency. > This warranty does not apply if damage occurs from improper installation, misuse, wrong voltage, wrong gas or operated contrary to the Installation and Operating instructions. > This warranty is not valid on Conveyor Ovens unless a "start-up/check-out" has been performed by a Factory Authorized Technician. PARTS WARRANTY Parts that are sold to repair out of warranty equipment are warranted for ninety (90) days. The part only is warranted. Labor to replace the part is chargeable to the customer. SERVICES NOT COVERED BY WARRANTY 1. Travel time and mileage rendered beyond the 50 mile radius limit 2. Mileage and travel time on portable equipment (see below) 3. Labor to replace such items that can be replaced easily during a daily cleaning routine, ie; removable kettles on fryers, knobs, grease drawers on griddles, etc. 4. Installation of equipment 5. Damages due to improper installation 6. Damages from abuse or misuse 7. Operated contrary to the Operating and Installation Instructions 8. Cleaning of equipment 9. Seasoning of griddle plates PORTABLE EQUIPMENT Star will not honor service bills that include travel time and mileage charges for servicing any products considered "Portable" including items listed below. These products should be taken to the Service Agency for repair: * The Model 510F Fryer. * The Model 526TO Toaster Oven. * The Model J4R, 4 oz. Popcorn Machine. * The Model CFS Series Food Steamer. * The Model 526WO Warming Oven. * The Model 518CM & 526CM Cheese Melter. * The Model 12MC & 15MC & 18MCP Hot Food Merchandisers. * The Model 12NCPW & 15NCPW Nacho Chip/Popcorn Warmer. * All Hot Dog Equipment except Roller Grills & Drawer Bun Warmers. * All Nacho Cheese Warmers except Model 11WLA Series Nacho Cheese Warmer. * All Condiment Dispensers except the Model CSD & HPD Series Dispenser. * All Specialty Food Warmers except Model 130R, 500, 11RW Series, and 11WSA Series. 10. Voltage conversions 11. Gas conversions 12. Pilot light adjustment 13. Miscellaneous adjustments 14. Thermostat calibration and by-pass adjustment 15. Resetting of circuit breakers or safety controls 16. Replacement of bulbs 17. Replacement of fuses 18. Repair of damage created during transit, delivery, & installation OR created by acts of God ALL: * Pop-Up Toasters * Butter Dispensers * Pretzel Merchandisers * Pastry Display Cabinets * Nacho Chip Merchandisers * Accessories of any kind * Sneeze Guards * Pizza Ovens * Heat Lamps * Hot Cups * Pumps The foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty. FOR ASSISTANCE Should you need any assistance regarding the Operation or Maintenance of any Star equipment; write, phone, fax or email our Service Department. In all correspondence mention the Model number and the Serial number of your unit, and the voltage or type of gas you are using. Part# 2M-4497-2 02/03 RB
3
8 9 7 6 5 9 7 6 8 4 3 1 2 12 12 11 10 11
PARTS LIST EFFECTIVE 01-14-03 8O MODEL 7C-B, 11C-B Soup Kettle Key Part Per Unit Description 1 2D-Y5670 1 SOUP KETTLE COOKER - BLACK 2 2D-Y5660 1 TRANSFER COLLAR RING - BLACK (7C-B) (does not include gasket) (SKCB-7H w/gasket is option) 3 2D-Y5664 1 TRANSFER COLLAR RING - BLACK (11C-B) (does not include gasket) (SKCB-11H w/gasket is option) 4 O2-71109 1 COVER ASSEMBLY (7C-B) (does not include hinging parts) (SKLID-7 w/hinging parts is option) 5 O2-71110 1 COVER ASSEMBLY (11C-B) (does not include hinging parts) (SKLID-11 w/hinging parts is option) 2I-Y5712 1 GASKET - RING (not shown) 6 2R-Y5701 1 INSULATING HANDLE 7 O2-Y5703 1 HINGE LEAF 8 O2-Y5704 1 HINGE RING BRACKET 9 2B-Y5792 2 PIN - HINGE 10 2A-Y5684 3 FOOT - BLACK 11 O2-Y6209 2 SIGN CLIP 12 2M-Y5686 1 SOUP SIGN PACKET (soups only - 21 names) Baked Beans / Bean Soup / Beef Stew Chef s Special / Chicken Noodle / Chicken Rice / Chili Cream of Celery / Cream of Chicken / Cream of Mushroom Fish Chowder / Green Pea / Manhattan Clam Chowder Minestrone / Nacho Cheese / New England Clam Chowder Onion Soup / Potato / Soup Du Jour / Tomato Soup Vegetable Soup 2D-Y5696 1 POT - 7 QT. BAIN MARIE (7C-B) (not shown) (SKSSB-7 is option) 2D-Y5698 1 POT - 11 QT. BAIN MARIE (11C-B) (not shown) (SKSSB-11 is option) IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED INCLUDE MODEL AND SERIAL NUMBER PAGE 1 OF 2 Some items are included for illustrative purposes only and in certain instances may not be available. Star Manufacturing International, Inc.
14 13 15 16 17
PARTS LIST EFFECTIVE 01-14-03 8O MODEL 7C-B, 11C-B Soup Kettle Key Part Per Unit Description 13 2D-Y9029 1 LINER - WATER 2N-Y5677 1 ELEMENT - 1000W (120V) (not shown) 2N-Y5679 1 ELEMENT - 1000W (240V) (not shown) O2-Y5680 1 BAND - ELEMENT (not shown) 14 2R-9193 1 BUTTON - INDICATOR 2J-6402 1 INFINITE CONTROL (120V) (not shown) 2J-6403 1 INFINITE CONTROL (240V) (not shown) 15 2R-Y5682 1 KNOB - CONTROL 16 2M-Y5695 1 LABEL - CHECK HEAT/WATER 17 O2-71107 1 PILOT LIGHT ASSEMBLY (120V) O2-71108 1 PILOT LIGHT ASSEMBLY (240V) 2T-Y5708 1 THERMOSTAT - HI LIMIT (not shown) O2-Y5709 1 BRACKET - THERMOSTAT (not shown) Z1-S7523 1 CORD SET ASSEMBLY (120V) (not shown) A1-S7554 1 CORD SET ASSEMBLY (240V) (not shown) 2K-Y2967 1 HEYCO CORD BUSHING (not shown) O2-Y5689 1 BOTTOM (not shown) IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED INCLUDE MODEL AND SERIAL NUMBER PAGE 2 OF 2 Some items are included for illustrative purposes only and in certain instances may not be available. Star Manufacturing International, Inc.