FORM NO. H66- REV. 1 Supersedes Form No. G66-6 Rev. WH1T SERIES Constant Torque (ECM) Efficiencies up to 1 SEER HIGH EFFICIENCY AIR HANDLER Features WH1T feature a Constant Torque motor (ECM) which provides enhanced SEER performance with most WeatherKing outdoor units. Versatile -way convertible design for upflow, downflow, horizontal left and horizontal right applications. Factory-installed indoor coil. Sturdy cabinet construction with 1.0 inch [. mm] of foil faced insulation for excellent sound and insulating characteristics. Field-installed auxiliary electric heater kits provide exact heat for indoor comfort. Kits include circuit breakers which meet U.L. and cul requirements for service disconnect. 1 1 / ton [. kw] through ton [17.6 kw] models are between 1 / to 7 inches [1080 to 18 mm] tall and inches [9 mm] deep. All models meet or exceed 0 to 00 CFM [16 to 189 L/s] per ton at. inches [.7 kpa] of external static pressure. Enhanced airflow up to.7" external static pressure. Evaporator is constructed of aluminum fins bonded to internally grooved aluminum tubing. Suitable for application in mobile homes. A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance with Department of Energy test procedures.
Table of Contents TABLE OF CONTENTS Engineering Features... Model Number Identification... Dimensional Data...-6 Airflow Directional Data...7 Airflow Performance Data...8-1 Electrical Data...1-18 Electrical Wiring...19 Accessories...19 Limited Warranty...0 WeatherKing
Engineering Features Engineering Features WH1T- Series The most compact unit design available, all standard heat air handler models only 1 / to 7 inches [1079 to 18 mm] high. Attractive pre-painted cabinet exterior. Rugged wall steel cabinet construction, designed for added strength and versatility. 1.0" foil faced insulation mechanically retained in blower compartment for excellent thermal and sound performance. Four leg blower motor mount. Blower housing with controls, motor and blower. Slide out design for service and maintenance convenience. Traditional open wire element design for heat applications. Field convertible for vertical downflow, horizontal left hand or right hand air supply. combustible floor base accessories fit all model sizes when required for downflow installations on combustible floors. Indoor coil design provides low air side pressure drop, high performance and extremely compact size. Expansion valve on indoor coil provides for operation with air conditioning or heat pump using the same coil. Coils are constructed of aluminum fins bonded to internally grooved aluminum tubing. Coils are tested at the factory with an extensive refrigerant leak check. Coils have copper sweat refrigerant connections. Coils utilize chatleff metering device connections. Molded polymer corrosion resistant condensate drain pan is provided on all indoor coils. Supply duct flanges provided as standard on air handler cabinet. Provisions for field electrical, connections available from either side or top of the air handler cabinet. Connection point for high voltage wiring is inside the air handler cabinet. Low voltage connection is made on the outside of the air handler cabinet. Concentric knockouts are provided for power connection to cabinet. Installer may pull desired hole size up to inches [1 mm] for 1 1 / inch [8 mm] conduit. Front refrigerant and drain connections. WeatherKing
Model Number Identification W H 1 T 17 S T A N A A *** Option Code (see ADS-80) Blank = None Minor Series A = First Voltage A = 11/1/60 D = 80V//60 J = 08/0/1/60 Controls C = Communicating N = Non-Communicating Major Series A = First Metering Device T = TEV Coil Efficiency S = Standard M= Medium H = High Width 17 = 17." [1.8 mm] (600-100 CFM) 1 = 1" [. mm] (800-1600 CFM) =." [609.6 mm] (100-1800 CFM) Nominal Capacity = 18,000 [.7 kw]-,000 [7.0 kw] BTU/H 6 = 0,000 [8.79 kw]-6,000 [10. kw] BTU/H 8 =,000 [1.1 kw]-8,000 [1.06 kw] BTU/H 60 = 60,000 [17.8 kw] BTU/H Type T = Constant Torque (ECM) Stages of Air Flow 1 = Single Product Category H = Air Handler WeatherKing Available Models at 11V A Voltage WH1T17STANAA WH1T617STANAA WH1T61MTANAA WH1T61HTANAA WH1T81STANAA WH1T81MTANAA WH1T601STANAA WH1T8STANAA WH1T60STANAA Available Models at 08V J Voltage WH1T17STANJA WH1T617STANJA WH1T61MTANJA WH1T61HTANJA WH1T81MTANJA WH1T81STANJA WH1T8STANJA WH1T601STANAA WH1T60STANJA Available Models at 80V D Voltage WH1T601STANDA WH1T60STANDA WeatherKing
Unit Dimensions ELECTRICAL CONNECTIONS MAY EXIT TOP OR EITHER SIDE HIGH VOLTAGE CONNECTION 7/8 [. mm], 1/ [7.8 mm], 11/ [0 mm] DIA. KNOCKOUTS. SUPPLY AIR 10 /16 [6 mm] NOTE: CLEARANCE REQUIRED IN FRONT OF UNIT FOR FILTER AND COIL MAINTENANCE. W Dimensional Data LOW VOLTAGE CONNECTION /8 [1.9 mm] AND 7/8 [. mm] KNOCKOUT A Return Air Opening Dimensions Model Cabinet Size Return Air Opening Width (Inches) Return Air Opening Depth/Length (Inches) 17 1 7 /8 19 / 1 19 /8 19 / 7 /8 19 / H AUXILIARY DRAIN CONNECTION / [19.1 mm] FEMALE PIPE THREAD (NPT) HORIZONTAL APPLICATION ONLY PRIMARY DRAIN CONNECTION / [19.1 mm] FEMALE PIPE THREAD (NPT) AUXILIARY DRAIN CONNECTION / [19.1 mm] FEMALE PIPE THREAD (NPT) UPFLOW/DOWNFLOW APPLICATION ONLY LIQUID LINE CONNECTION COPPER (SWEAT) 19 1 / [9 mm] RETURN AIR OPENING 1 11 /16 [1 mm] VAPOR LINE CONNECTION COPPER (SWEAT) UPFLOW UNIT SHOWN: UNIT MAY BE INSTALLED UPFLOW, DOWNFLOW, HORIZONTAL RIGHT OR LEFT AIR SUPPLY. 1 /16 [11 mm] 1 /8 [10 mm] 1 /16 [76 mm] 1 /16 [8 mm] 11 /8 [9 mm] 1 1 /16 [7 mm] 1 /8 [ mm] 1 /16 [71 mm] 1 / [1 mm] /8 [16 mm] UPFLOW UNIT SHOWN: UNIT MAY BE INSTALLED UPFLOW, DOWNFLOW, HORIZONTAL RIGHT OR LEFT AIR SUPPLY. ( ) Designates Unit with Double Coil Cabinet WeatherKing
Dimensional Data Unit Dimensions & Weights Refrigerant Connections [ ] Air Designates Flow Metric Conversions Unit Weight/Shipping Weight Model Sweat (In.) [mm] ID Unit Unit Supply CFM Size ( ) Designates (Nom.) [L/s] Width Unit with Double (Lbs.) Height Coil Cabinet [kg] Duct Unit WH1T Dimensions Liquid & WeightsVapor W In. [mm] H In. [mm] A In. [mm] Unit With Lo Hi Coil (Max. KW) 17ST /8 [9.] / [19.0] 17 1 / [] 1 / [1080] 16 1 / [06] 600 [8] 800 [78] 9/106 [/8] 617ST /8 [9.] / [19.0] 17 1 / [] 1 / [1080] 16 1 / [06] 1000 [7] 100 [66] 96/110 [/0] 61HT /8 [9.] 7/8 [.] 1 1 / [] 7 1 / [18] 19 1 / [9] 1000 [7] 100 [66] 17/19 [6/68] 61MT /8 [9.] 7/8 [.] 1 1 / [] 0 1 / [18] 19 1 / [9] 1000 [7] 100 [66] 16/1 [7/6] 81MT /8 [9.] 7/8 [.] 1 1 / [] 7 1 / [18] 19 1 / [9] 100 [661] 1600 [7] 19/11 [6/68] 81ST /8 [9.] 7/8 [.] 1 1 / [] 0 1 / [18] 19 1 / [9] 100 [661] 1600 [7] 18/1 [6/6] 8ST /8 [9.] 7/8 [.] 1 / [6] 0 1 / [18] 1 / [8] 1600 [7] 1/160 [6/7] 601ST /8 [9.] 7/8 [.] 1 1 / [] 7 1 / [18] 19 1 / [9] 1600 [7] 17 [81] 19/11 [6/68] 60ST /8 [9.] 7/8 [.] 1 / [6] 1 / [110] 1 / [8] 1800 [80] 19/176 [7/80] *Maximum dehumidification airflow. 6 WeatherKing
Airflow Directional Data Airflow Directional Data UPFLOW DOWNFLOW HORIZONTAL LEFT HAND AIRFLOW HORIZONTAL RIGHT HAND AIRFLOW WeatherKing 7
Airflow Performance Data Airflow Performance Airflow performance data is based on cooling performance with a coil and no filter in place. Select performance table for appropriate unit size, voltage and number of electric heaters to be used. Make sure external static applied to unit allows operation within the minimum and maximum limits shown in table below for both cooling and electric heat operation. For optimum blower performance, operate the unit in the. [8 mm] to.7 inches [18 mm] W.C. external static range. Units with coils should be applied with a minimum of.1 inch [ mm] W.C. external static range. Airflow Operating Limits Model Cabinet Width 17 17/1 Cooling BTUH x 1,000 Cooling Tons Nominal Heat Pump or Air Conditioning Maximum Heat/Cool CFM [L/s] (7. CFM [18 L/s]/1,000 BTUH) (0 CFM [1 L/s]/Ton Nominal) Heat Pump or Air Conditioning Nominal Heat/Cool CFM [L/s] (. CFM [16 L/s]/1,000 BTUH) (00 CFM [189 L/s]/Ton Nominal) Heat Pump or Air Conditioning Minimum Heat/Cool CFM [L/s] (0.0 CFM [1 L/s]/1,00 BTUH) (60 CFM [170 L/s]/Ton Nominal) Maximum kw Electric Heating & Minimum Electric Heat CFM [L/s] -18 1. 67 [19] 600 [8] 0 [] 1 87 [0] - 900 [] 800 [78] 70 [0] 1 617 [91] -0. 11 [1] 1000 [7] 900 [] 18 81 [8] -6 10 [67] 100 [66] 1080 [10] 18 10 [97] -. 17 [7] 100 [661] 160 [9] 0 1171 [] -8 1800 [80] 1600 [7] 10 [680] 10 [709] -8 1800 [80] 1600 [7] 10 [680] 10 [709] Maximum Electric Heat Rise F [ C] 80 [6.7] 6 [17.] 66 [18.9] 1 [10.6] 9 [9.] 0 [10] 0 [10] 1-60 190 [911] 1800 [80] 160 [76] 0 1666 [786] [1.] 8 WeatherKing
Airflow Performance Data 11V/08V/0V/60V Airflow Performance Data WH1T (Constant Torque (ECM) ) Model No. WH1T 17ST No Heat 17ST with 1 kw Heater 17ST No Heat 17ST with 1 kw Heater 617ST No Heater 617ST with 18 kw Heater 617ST No Heater 617ST with 18 kw Heater Tonnage Application 1. Ton 1. Ton Ton Ton. Ton. Ton Ton Ton Speed From Factory Manufacturer Recommended Air-Flow Range (Min/Max) CFM 68/8 [/9 L/s] 68/8 [/9 L/s] 88/697 [0/9 L/s] 68/8 [/9 L/s] 9/108 CFM [1/1 L/s] 910/109 CFM [9/00 L/s] 110/17 CFM [/60 L/s] 110/10 CFM [1/90 L/s] Blower Size/ HP [W] Speed CFM [L/s] Air Delivery/RPM/Watts (No Filter) External Static Pressure Inches W.C. [kpa] # of Speed 0.1 [.0] 0. [.0] 0. [.07] 0. [.10] 0. [.1] 0.6 [.1] 0.7 [.17] CFM 87 [9] 71 [66] 608 [87] [61] 8 [9] RPM 6 87 60 69 71 10x8 Watts 9 81 88 7 66 1/ HP [9] Speed CFM 68 [] 61 [90] 7 [70] RPM 789 8 89 Watts 10 19 1 CFM 81 [8] 69 [6] 89 [78] [] 67 [0] RPM 9 61 66 719 778 10x8 Watts 108 90 97 8 7 1/ HP [9] Speed CFM 808 [81] 69 [97] 8 [76] RPM 789 8 89 Watts 18 168 16 CFM 90 [6] 86 [99] 788 [7] 7 [0] 679 [0] RPM 96 6 69 71 791 10x8 Watts 10 108 116 11 10 1/ HP [9] Speed CFM 88 [76] 816 [8] 770 [6] RPM 8 879 9 Watts 18 18 1 CFM 88 [16] 87 [90] 769 [6] 7 [1] 661 [1] RPM 9 670 719 767 817 10x8 Watts 11 1 1 19 197 1/ HP [9] Speed CFM 8 [9] 791 [7] 76 [] RPM 8 898 9 Watts 19 189 CFM 109 [16] 100 [96] 1017 [80] 977 [61] 9 [1] RPM 671 7 76 809 8 10x8 Watts 1 168 17 180 188 1/ HP [7] Speed CFM 108 [1] 100 [91] 1001 [7] RPM 896 96 971 Watts 9 7 61 CFM 1068 [0] 10 [8] 99 [68] 9 [9] 910 [9] RPM 711 76 80 89 89 10x8 Watts 16 179 18 191 199 1/ HP [7] Speed CFM 109 [00] 101 [79] 976 [61] RPM 96 976 1011 Watts 60 68 7 CFM 170 [99] 17 [8] 1199 [66] 116 [0] 110 [] RPM 77 816 86 88 96 10x8 Watts 7 9 9 68 77 1/ HP [7] Speed CFM 17 [60] 1 [87] 111 [71] RPM 96 999 109 Watts 8 8 6 CFM 1 [88] 11 [7] 117 [] 110 [8] 110 [1] RPM 81 86 886 9 966 10x8 Watts 8 60 70 79 88 1/ HP [7] Speed CFM 10 [90] 119 [7] 1186 [60] RPM 100 109 1069 Watts 9 9 7 WeatherKing 9
Airflow Performance Data 11V/08V/0V/60V Airflow Performance Data WH1T (Constant Torque (ECM) ) (con t.) Model No. WH1T 61MT No Heater 61MT with 18 kw Heater 61MT No Heater 61MT with 18 kw Heater Tonnage Application. Ton. Ton &. Ton &. Ton Speed From Factory Manufacturer Recommended Air-Flow Range (Min/Max) CFM 8/110 CFM [0/1 L/s] 88/1016 CFM [91/79 L/s] 1070/188 CFM [0/608 L/s] 10/17 CFM [9/9 L/s] Blower Size/ HP [W] # of Speed 1/ HP [7] Speed 1/ HP [7] Speed 1/ HP [7] Speed 1/ HP [7] Speed Speed CFM [L/s] Air Delivery/RPM/Watts (No Filter) External Static Pressure Inches W.C. [kpa] 0.1 [.0] 0. [.0] 0. [.07] 0. [.10] 0. [.1] 0.6 [.1] 0.7 [.17] CFM 107 [06] 1016 [79] 96 [] 906 [8] 8 [0] RPM 67 69 76 801 87 Watts 10 1 1 16 176 CFM 110 [1] 109 [00] 1000 [7] RPM 917 97 1001 Watts 6 71 8 CFM 10 [9] 988 [66] 96 [] 880 [1] 88 [91] RPM 678 7 791 8 88 Watts 11 1 18 171 18 CFM 1016 [79] 961 [] 90 [7] RPM 99 968 101 Watts 6 CFM 16 [97] 1 [77] 1171 [] 111 [] 1070 [0] RPM 7 761 81 868 900 Watts 198 08 7 CFM 188 1 100 RPM 97 [608] 101 [87] 10 [66] Watts 6 71 CFM 1 [8] 119 [6] 11 [9] 108 [1] 10 [9] RPM 79 79 8 91 9 Watts 19 1 7 1 61 CFM 17 [9] 11 [7] 1169 [] RPM 100 10 10 Watts 68 76 Notes: Constant Torque motor speed changes. All Constant Torque motors have speed tabs. Speed tab 1 is for continuous fan. Speed tab (low static) and Speed tab (high static) are for lower tonnage. Speed tab (low static) and Speed tab (high static) are for higher tonnage. Constant Torque air handlers are always shipped from factory at Speed tab, except for -8, which is set at Speed tab. For instance, (-)H1T-HM17JA is always shipped at high static -ton airflow (Speed tab ). To change to 1.-ton airflow, move the blue wire to Speed tab or on the Constant Torque motor. The low static Speed tab (lower tonnage) and (higher tonnage) are used for external static below 0." WC. The high static Speed tab (lower tonnage) and (higher tonnage) are used for external static exceeding 0." WC. Move the blue wire to the appropriate Speed tab as required by the application needs. The airflow for continuous fan (Speed tab 1) is always set at 0% of the Speed tab. The above airflow table lists the airflow information for air handlers without heater and air handler with maximum heater allowed for each model. The following formula can be used to calculate the approximate airflow, if a smaller (N kw) than the maximum heater kit is installed. Approximate Airflow = Airflow without heater (Airflow without heater Airflow with maximum heater) x (N kw/maximum heater kw) 10 WeatherKing
Airflow Performance Data 11V/08V/0V/60V Airflow Performance Data WH1T (Constant Torque (ECM) ) (con t.) Model No. WH1T 81ST No Heater 81ST with 0 kw Heater 81ST No Heater 81ST with kw Heater 8ST No Heater 8ST with kw Heater 60ST No Heater 60ST with 0 kw Heater Tonnage Application. Ton. Ton Ton Ton Ton Ton Ton Ton Speed From Factory Manufacturer Recommended Air-Flow Range (Min/Max) CFM 17/17 CFM [61/68 L/s] 197/1 CFM [61/69 L/s] 1/16 CFM [7/781 L/s] 19/161 CFM [706/76 L/s] 1/17 CFM [79/817 L/s] 10/169 CFM [710/798 L/s] 179/190 CFM [81/899 L/s] 1699/186 CFM [80/880 L/s] Blower Size/ HP [W] # of Speed / HP [9] Speed / HP [9] Speed / HP [9] Speed / HP [9] Speed 11x11 / HP [9] Speed 11x11 / HP [9] Speed 11x11 / HP [9] Speed 11x11 / HP [9] Speed Speed CFM [L/s] Air Delivery/RPM/Watts (No Filter) External Static Pressure Inches W.C. [kpa] 0.1 [.0] 0. [.0] 0. [.07] 0. [.10] 0. [.1] 0.6 [.1] 0.7 [.17] CFM 17 [69] 1 [681] 101 [661] 17 [68] 17 [61] RPM 781 8 867 90 99 Watts 7 71 0 07 1 CFM 17 [68] 1 [676] 10 [66] RPM 987 10 106 Watts 9 06 0 CFM 1 [676] 10 [66] 161 [6] 1 [69] 197 [61] RPM 81 87 919 9 989 Watts 77 9 1 19 CFM 1 [69] 100 [61] 167 [98] RPM 1011 106 1080 Watts 0 6 77 CFM 166 [786] 161 [770] 1601 [76] 17 [7] 1 [7] RPM 8 89 9 968 101 Watts 1 87 01 06 CFM 16 [781] 16 [766] 16 [78] RPM 106 1078 109 Watts 00 1 CFM 16 [767] 191 [71] 161 [77] 1 [7] 19 [706] RPM 89 9 970 100 10 Watts 89 00 10 0 0 CFM 161 [76] 18 [78] 1 [719] RPM 108 1090 110 Watts 1 0 0 CFM 178 [8] 1669 [788] 169 [77] 199 [7] 1 [79] RPM 660 698 7 76 79 Watts 97 11 6 0 CFM 17 [817] 168 [79] 160 [769] RPM 80 87 899 Watts 8 67 80 CFM 1708 [806] 169 [769] 199 [7] 19 [76] 10 [710] RPM 680 76 760 790 80 Watts 0 0 1 0 61 CFM 169 [798] 16 [77] 190 [70] RPM 86 890 101 Watts 60 70 81 CFM 190 [898] 186 [879] 1809 [8] 1781 [80] 179 [81] RPM 71 79 787 81 86 Watts 89 09 19 9 CFM 190 [899] 1866 [881] 18 [86] RPM 89 9 90 Watts 6 70 9 CFM 186 [879] 18 [860] 1769 [8] 171 [8] 1699 [80] RPM 70 790 810 80 880 Watts 10 0 0 79 CFM 186 [880] 186 [86] 179 [86] RPM 90 9 970 Watts 6 87 610 WeatherKing 11
Airflow Performance Data 11V/08V/0V/60V Airflow Performance Data WH1T (Constant Torque (ECM) ) (con t.) Model No. WH1T 60ST No Heater 60ST with 0 kw Heater Tonnage Application & Ton & Ton Speed From Factory Manufacturer Recommended Air-Flow Range (Min/Max) CFM 117/1699 CFM [716/801 L/s] 18/1661 CFM [700/78 L/s] Blower Size/ CFM [L/s] Air Delivery/RPM/Watts (No Filter) HP [W] Speed External Static Pressure Inches W.C. [kpa] # of Speed 0.1 [.0] 0. [.0] 0. [.07] 0. [.10] 0. [.1] 0.6 [.1] 0.7 [.17] CFM 170 [800] 1661 [70] 16 [770] 17 [71] 117 [91] RPM 66 701 71 78 819 11x11 Watts 9 09 1 7 / HP [9] Speed CFM 1697 [801] 166 [777] 1601 [76] RPM 87 89 90 Watts 7 66 90 CFM 1669 [788] 16 [767] 196 [7] 17 [7] 18 [700] RPM 698 79 76 816 8 11x11 Watts 08 17 9 61 7 / HP [9] Speed CFM 1661 [78] 1611 [760] 166 [79] RPM 88 91 99 Watts 7 80 87 Notes: All 08/0V PSC motors have voltage taps for 08 and 0 volts. All 08/0V PSC motors are shipped on high speed and 0 volts. If the application external static is less than 0." WC, adjust the motor speed to the low static speed as described below: Unplug the black motor wire off the relay on the control board and plug in the red motor wire. Replace the cap on the black motor wire. Voltage change (08/0V motors): Move the orange lead to transformer 08V tap from 0V tap. Replace the wire cap on 0V tap. Unplug the purple motor wire off the transformer and plug in the yellow motor wire. Replace the cap on the purple motor wire. The above airflow table lists the airflow information for air handlers without heater and air handler with maximum heater allowed for each model. The following formula can be used to calculate the approximate airflow, if a smaller (N kw) than the maximum heater kit is installed. Approximate Airflow = Airflow without heater - (Airflow without heater - Airflow with maximum heater) x (N kw/maximum heater kw) 1 WeatherKing
Airflow Performance Data 11V/08V/0V/80V Airflow Performance Data WH1T (Constant Torque (ECM) ) (con t.) Model No. WH1T 61H No Heat 61H 18 Kw Heat 61H No Heat 61H 18 Kw Heat 81M No Heat 81M 0 Kw Heat 81M No Heat Nonimal Cooling Capacity Tons.... Manufacturer Recommended Air-Flow Range (Min/Max) CFM Blower Size/ HP [W] # of Speed 1/ HP [7] Speed dual voltage 1/ Hp [7] Speed dual voltage 1/ Hp [7] Speed dual voltage 1/ Hp [7] Speed dual voltage / Hp [9] Speed dual voltage / Hp [9] Speed dual voltage / Hp [9] Speed dual voltage Speed From Factory Speed CFM [L/s] Air Delivery/RPM/Watts (No Filter) External Static Pressure Inches W.C. [kpa] 0.1 [.0] 0. [.0] 0. [.07] 0. [.10] 0. [.1] 0.6 [.1] 0.7 [.17] CFM 10 11 10 11 1101 106 99 RPM 668 77 7 797 8 888 91 Watts 19 187 18 08 10 1 7 CFM 19 119 118 108 106 970 91 RPM 7 780 88 877 9 97 101 Watts 11 1 1 1 11 161 170 CFM 180 18 1176 11 107 100 968 RPM 69 76 777 817 88 899 99 Watts 189 191 197 08 67 CFM 11 1166 1110 10 998 9 886 RPM 76 80 8 901 99 997 10 Watts 119 18 17 17 16 16 17 CFM 168 11 177 1 18 10 119 RPM 79 77 8 86 901 97 97 Watts 8 68 76 07 1 0 97 CFM 17 10 117 11 1067 1016 961 RPM 68 706 7 797 88 877 9 Watts 180 189 189 190 0 6 CFM 1 199 1 108 16 116 1170 RPM 79 799 89 878 918 98 997 Watts 77 9 0 08 0 90 CFM 19 1197 11 109 10 990 98 RPM 68 78 77 816 89 90 97 Watts 18 186 19 0 1 0 8 CFM 190 16 11 176 1 11 178 RPM 81 878 909 9 98 101 109 Watts 77 7 79 90 06 0 7 CFM 189 11 101 19 116 178 11 RPM 70 801 8 88 90 9 98 Watts 70 8 77 88 88 90 CFM 167 1 197 16 17 19 18 RPM 86 89 97 96 998 10 1069 Watts 7 79 86 96 08 0 CFM 16 1 181 18 196 1 11 RPM 779 816 8 891 99 967 100 Watts 7 70 81 87 90 89 8 CFM 180 1760 117 168 168 161 176 RPM 886 919 9 988 1019 10 1088 Watts 7 0 1 87 89 0 81 CFM 1681 161 198 16 18 19 1 RPM 8 8 907 90 96 1010 10 Watts 8 8 88 97 88 WeatherKing 1
Airflow Performance Data 11V/08V/0V/80V Airflow Performance Data WH1T (Constant Torque (ECM) ) (con t.) Model No. WH1T 81M 0 Kw Heat 601S No Heat 601S 0 Kw Heat 601S No Heat 601S 0 Kw Heat Nonimal Cooling Capacity Tons & & Manufacturer Recommended Air-Flow Range (Min/Max) CFM Blower Size/ HP [W] # of Speed / Hp [9] Speed dual voltage / Hp [9] Speed dual voltage / Hp [9] Speed dual voltage / Hp [9] Speed dual voltage / Hp [9] Speed dual voltage Speed From Factory Speed CFM [L/s] Air Delivery/RPM/Watts (No Filter) External Static Pressure Inches W.C. [kpa] 0.1 [.0] 0. [.0] 0. [.07] 0. [.10] 0. [.1] 0.6 [.1] 0.7 [.17] CFM 1779 17 170 1667 160 19 1 RPM 90 96 970 100 107 1070 110 Watts 0 1 6 7 86 97 09 CFM 169 161 18 16 109 171 1 RPM 8 879 916 9 988 10 1061 Watts 67 8 97 1 7 CFM 181 1798 178 178 1699 1660 169 RPM 898 90 967 997 107 107 109 Watts 69 70 8 90 98 1 1 CFM 1716 1669 161 19 1 1 18 RPM 861 887 911 98 98 101 100 Watts 9 7 79 97 7 19 7 CFM 1817 178 178 171 1679 16 1609 RPM 91 97 979 1011 10 1076 1108 Watts 70 76 8 9 07 1 8 CFM 1691 16 161 177 18 100 16 RPM 871 90 9 967 999 101 106 Watts 67 79 9 0 16 8 0 CFM 0 00 1968 191 190 1868 18 RPM 96 99 10 100 110 11 119 Watts 61 6 616 69 67 67 711 CFM 1886 189 1809 1776 171 170 1677 RPM 917 98 981 101 107 1076 1108 Watts 91 01 09 0 60 69 CFM 01 1987 19 1918 188 180 1816 RPM 980 101 107 1080 111 117 1180 Watts 618 6 66 60 668 690 71 CFM 00 1970 196 1901 1867 18 1799 RPM 997 100 106 1097 110 116 1196 Watts 617 6 69 666 68 698 71 1 WeatherKing
Electrical Data Electrical Data Blower Only No Electric Heat WH1T Model WH1T Voltage Application Phase* Hertz HP [W] RPM Speeds Circuit Amps. Minimum Circuit Ampacity Maximum Circuit Protector 17ST 1/ [9] 00-1100 1.6 1 617ST 1/ [7] 00-1100.7 1 61MT/61H 08/0 1 & 60 1/ [7] 00-1100.8 1 81ST/81M/601S / [9] 00-1100.8 1 60ST/8ST / [9] 00-1100.6 6 1 17ST 1/ [9] 00-1100.8 6 1 617ST 1/ [7] 00-1100 6.8 9 1 61MT/61H 11 1 60 1/ [7] 00-1100 6.8 9 1 81ST/81M/601S / [9] 00-1100 8. 11 1 60ST / [9] 00-1100 8. 11 1 60ST 80 60 / [9] 00-1100. 1 * Blower motors are all single phase motors. WeatherKing 1
Electrical Data Electrical Data With Electric Heat WH1T Installation of the U.L. Listed original equipment manufacturer provided heater kits listed in the following table is recommended for all auxiliary heating requirements. Air Handler Model WH1T 17STAN 617STAN 61HTAN/ 81MTAN/ 81STAN/ 601STAN Heater Model No. Heater kw (08/0V) (80V) PH/HZ No. Elements kw Per Type Supply Circuit Single Circuit Multiple Circuit Amps. Ampacity Minimum Circuit Ampacity Maximum Circuit Protector RXBH-17?0J./ 1/60 1 - SINGLE 10.8/1..8 18/0 0/0 RXBH-17?0J.6/.8 1/60 1 -.8 SINGLE 17./0.8 6/9 0/0 RXBH-17?07J./7. 1/60 -.6 SINGLE 6/0.8 6/1 0/ RXBH-17?10J 7./9.6 1/60 -.8 SINGLE.6/0.8 7/ 0/60 RXBH-17A07C./7. /60 -. SINGLE 1/17..8 /6 /0 RXBH-17A10C 7./9.6 /60 -. SINGLE 0/.1.8 9/ 0/ RXBH-17A1C 9./1. /60 -.17 SINGLE 6.1/0.1.8 7/ 0/ RXBH-17A1J 9./1. 1/60 -.17 SINGLE.1/.1.8 60/69 60/70 RXBH-17A1J.1/. 1/60 1 -.17 MULTIPLE CKT 1 1/17..8 /6 /0 RXBH-17A1J 6./8. 1/60 -.17 MULTIPLE CKT 0.1/.7 0 8/ 0/ RXBH-17?0J./ 1/60 1 - SINGLE 10.8/1..1 19/1 0/ RXBH-17?0J.6/.8 1/60 1 -.8 SINGLE 17./0.1 7/1 0/ RXBH-17?07J./7. 1/60 -.6 SINGLE 6/0.1 8/ 0/ RXBH-17?10J 7./9.6 1/60 -.8 SINGLE.6/0.1 9/6 0/60 RXBH-17A07C./7. /60 -. SINGLE 1/17..1 /7 /0 RXBH-17A10C 7./9.6 /60 -. SINGLE 0/.1.1 1/ / RXBH-17A1C 9./1. /60 -.17 SINGLE 6.1/0.1.1 8/ 0/ RXBH-17A1J 9./1. 1/60 -.17 SINGLE.1/.1.1 6/71 70/80 RXBH-17A1J.1/. 1/60 1 -.17 MULTIPLE CKT 1 1/17..1 /7 /0 RXBH-17A1J 6./8. 1/60 -.17 MULTIPLE CKT 0.1/.7 0 8/ 0/ RXBH-17A1C 10.8/1. /60 -.8 SINGLE 0/.6.1 /9 /0 RXBH-17A1J 10.8/1. 1/60 -.8 SINGLE 1.9/60.1 70/81 70/90 RXBH-17A1J.6/.8 1/60 1 -.8 MULTIPLE CKT 1 17./0.1 7/1 0/ RXBH-17A1J 7./9.6 1/60 -.8 MULTIPLE CKT.6/0 0 /0 /0 RXBH-17A18C 1.8/17 /60 -.67 SINGLE./1.1 0/7 0/60 RXBH-17A18J 1.8/17 1/60 -.67 SINGLE 61.6/70.8.1 8/9 90/100 RXBH-17A18J./.7 1/60 1 -.67 MULTIPLE CKT 1 0./.6.1 1/ / RXBH-17A18J 8./11. 1/60 -.67 MULTIPLE CKT 1.1/7. 0 /60 60/60 RXBH-17?0J./ 1/60 1 - SINGLE 10.8/1..1 19/1 0/ RXBH-17?0J.6/.8 1/60 1 -.8 SINGLE 17./0.1 7/1 0/ RXBH-17?07J./7. 1/60 -.6 SINGLE 6/0.1 8/ 0/ RXBH-17?10J 7./9.6 1/60 -.8 SINGLE.6/0.1 9/6 0/60 RXBH-17A07C./7. /60 -. SINGLE 1/17..1 /7 /0 RXBH-17A10C 7./9.6 /60 -. SINGLE 0/.1.1 1/ / RXBH-17A1C 9./1. /60 -.17 SINGLE 6.1/0.1.1 8/ 0/ RXBH-17A1J 9./1. 1/60 -.17 SINGLE.1/.1.1 6/71 70/80 RXBH-17A1J.1/. 1/60 1 -.17 MULTIPLE CKT 1 1/17..1 /7 /0 RXBH-17A1J 6./8. 1/60 -.17 MULTIPLE CKT 0.1/.7 0 8/ 0/ RXBH-17A1C 10.8/1. /60 -.8 SINGLE 0/.6.1 /9 /0 RXBH-17A1J 10.8/1. 1/60 -.8 SINGLE 1.9/60.1 70/81 70/90 RXBH-17A1J.6/.8 1/60 1 -.8 MULTIPLE CKT 1 17./0.1 7/1 0/ RXBH-17A1J 7./9.6 1/60 -.8 MULTIPLE CKT.6/0 0 /0 /0 Supply circuit protective devices may be fuses or HACR type circuit breakers. Largest motor load is included in single circuit and multiple circuit 1. If non-standard fuse size is specified, use next size larger standard fuse size. J Voltage (0V) single phase air handler is designed to be used with single or three phase 0 volt electric heaters. In the case of connecting -phase power to the air handler terminal block without the heater, bring only two leads to the terminal block cap, insulate and fully secure the third lead. 16 WeatherKing
Electrical Data Electrical Data With Electric Heat WH1T (Cont.) Installation of the U.L. Listed original equipment manufacturer provided heater kits listed in the following table is recommended for all auxiliary heating requirements. Air Handler Model WH1T 61HTAN/ 81MTAN/ 81STAN/ 601STAN 61MTAN Heater Model No. Heater kw (08/0V) (80V) PH/HZ No. Elements kw Per Type Supply Circuit Single Circuit Multiple Circuit Amps. Ampacity Minimum Circuit Ampacity Maximum Circuit Protector RXBH-17A18C 1.8/17 /60 -.67 SINGLE./1.1 0/7 0/60 RXBH-17A18J 1.8/17 1/60 -.67 SINGLE 61.6/70.8.1 8/9 90/100 RXBH-17A18J./.7 1/60 1 -.67 MULTIPLE CKT 1 0./.6.1 1/ / RXBH-17A18J 8./11. 1/60 -.67 MULTIPLE CKT 1.1/7. 0 /60 60/60 RXBH-A0C 1./19. /60 6 -. SINGLE 0/6..1 6/6 60/70 RXBH-A0C 7./9.6 /60 -. MULTIPLE CKT 1 0/.1.1 1/ / RXBH-A0C 7./9.6 /60 -. MULTIPLE CKT 0/.1 0 /9 /0 RXBH-A0J 1./19. 1/60 -.8 SINGLE 69./80.1 9/106 100/110 RXBH-A0J 7./9.6 1/60 -.8 MULTIPLE CKT 1.6/0.1 9/6 0/60 RXBH-A0J 7./9.6 1/60 -.8 MULTIPLE CKT.6/0 0 /0 /0 RXBH-AC 18/ /60 6 - SINGLE 0/7.8.1 68/78 70/80 RXBH-AC 9/1 /60 - MULTIPLE CKT 1 /8.9.1 7/ 0/ RXBH-AC 9/1 /60 - MULTIPLE CKT /8.9 0 /7 /0 RXBH-AJ 18/ 1/60 6 - SINGLE 86./99.9.1 11/10 1/10 RXBH-AJ 6/8 1/60 - MULTIPLE CKT 1 8.8/..1 /7 /0 RXBH-AJ 6/8 1/60 - MULTIPLE CKT 8.8/. 0 7/ 0/ RXBH-AJ 6/8 1/60 - MULTIPLE CKT 8.8/. 0 7/ 0/ RXBH-17?0J.6/.8 1/60 1 -.8 SINGLE 17./0.1 7/1 0/ RXBH-17?07J./7. 1/60 -.6 SINGLE 6/0.1 8/ 0/ RXBH-17?10J 7./9.6 1/60 -.8 SINGLE.6/0.1 9/6 0/60 RXBH-17A07C./7. /60 -. SINGLE 1/17..1 /7 /0 RXBH-17A10C 7./9.6 /60 -. SINGLE 0/.1.1 1/ / RXBH-17A1C 10.8/1. /60 -.8 SINGLE 0/.6.1 /9 /0 RXBH-17A1J 10.8/1. 1/60 -.8 SINGLE 1.9/60.1 70/81 70/90 RXBH-17A1J.6/.8 1/60 1 -.8 MULTIPLE CKT 1 17./0.1 7/1 0/ RXBH-17A1J 7./9.6 1/60 -.8 MULTIPLE CKT.6/0 0 /0 /0 RXBH-17A18C 1.8/17 /60 -.67 SINGLE./1.1 0/7 0/60 RXBH-17A18J 1.8/17 1/60 -.67 SINGLE 61.6/70.8.1 8/9 90/100 RXBH-17A18J./.7 1/60 1 -.67 MULTIPLE CKT 1 0./.6.1 1/ / RXBH-17A18J 8./11. 1/60 -.67 MULTIPLE CKT 1.1/7. 0 /60 60/60 Supply circuit protective devices may be fuses or HACR type circuit breakers. Largest motor load is included in single circuit and multiple circuit 1. If non-standard fuse size is specified, use next size larger standard fuse size. J Voltage (0V) single phase air handler is designed to be used with single or three phase 0 volt electric heaters. In the case of connecting -phase power to the air handler terminal block without the heater, bring only two leads to the terminal block cap, insulate and fully secure the third lead. WeatherKing 17
Electrical Data Electrical Data With Electric Heat WH1T (Cont.) Installation of the U.L. Listed original equipment manufacturer provided heater kits listed in the following table is recommended for all auxiliary heating requirements. Air Handler Model WH1T 8STAN/ 60STAN Heater Model No. Heater kw (08/0V) (80V) PH/HZ No. Elements kw Per Type Supply Circuit Single Circuit Multiple Circuit Amps. Ampacity Minimum Circuit Ampacity Maximum Circuit Protector RXBH-17?0J./ 1/60 1 - SINGLE 10.8/1. 6 1/ / RXBH-17?0J.6/.8 1/60 1 -.8 SINGLE 17./0 6 0/ 0/ RXBH-17?07J./7. 1/60 -.6 SINGLE 6/0 6 0/ 0/ RXBH-17?10J 7./9.6 1/60 -.8 SINGLE.6/0 6 1/8 60/60 RXBH-17A07C./7. /60 -. SINGLE 1/17. 6 7/0 0/0 RXBH-17A10C 7./9.6 /60 -. SINGLE 0/.1 6 /7 /0 RXBH-17A1C 9./1. /60 -.17 SINGLE 6.1/0.1 6 1/6 /0 RXBH-17A1J 9./1. 1/60 -.17 SINGLE.1/.1 6 6/7 70/80 RXBH-17A1J.1/. 1/60 1 -.17 MULTIPLE CKT 1 1/17. 6 7/0 0/0 RXBH-17A1J 6./8. 1/60 -.17 MULTIPLE CKT 0.1/.7 0 8/ 0/ RXBH-17A1C 10.8/1. /60 -.8 SINGLE 0/.6 6 /1 /60 RXBH-17A1J 10.8/1. 1/60 -.8 SINGLE 1.9/60 6 7/8 80/90 RXBH-17A1J.6/.8 1/60 1 -.8 MULTIPLE CKT 1 17./0 6 0/ 0/ RXBH-17A1J 7./9.6 1/60 -.8 MULTIPLE CKT.6/0 0 /0 /0 RXBH-17A18C 1.8/17 /60 -.67 SINGLE./1 6 /9 60/60 RXBH-17A18J 1.8/17 1/60 -.67 SINGLE 61.6/70.8 6 8/97 90/100 RXBH-17A18J./.7 1/60 1 -.67 MULTIPLE CKT 1 0./.6 6 /8 /0 RXBH-17A18J 8./11. 1/60 -.67 MULTIPLE CKT 1.1/7. 0 /60 60/60 RXBH-A0C 1./19. /60 6 -. SINGLE 0/6. 6 8/66 60/70 RXBH-A0C 7./9.6 /60 -. MULTIPLE CKT 1 0/.1 6 /7 /0 RXBH-A0C 7./9.6 /60 -. MULTIPLE CKT 0/.1 0 /9 /0 RXBH-A0J 1./19. 1/60 -.8 SINGLE 69./80 6 9/108 100/110 RXBH-A0J 7./9.6 1/60 -.8 MULTIPLE CKT 1.6/0 6 1/8 60/60 RXBH-A0J 7./9.6 1/60 -.8 MULTIPLE CKT.6/0 0 /0 /0 RXBH-AC 18/ /60 6 - SINGLE 0/7.8 6 70/80 70/80 RXBH-AC 9/1 /60 - MULTIPLE CKT 1 /8.9 6 9/ 0/ RXBH-AC 9/1 /60 - MULTIPLE CKT /8.9 0 /7 /0 RXBH-AJ 18/ 1/60 6 - SINGLE 86./99.9 6 116/1 1/10 RXBH-AJ 6/8 1/60 - MULTIPLE CKT 1 8.8/. 6 /0 /0 RXBH-AJ 6/8 1/60 - MULTIPLE CKT 8.8/. 0 7/ 0/ RXBH-AJ 6/8 1/60 - MULTIPLE CKT 8.8/. 0 7/ 0/ RXBH-A0C 1.6/8.8 /60 6 -.8 SINGLE 60/69. 6 8/9 90/100 RXBH-A0C 10.8/1. /60 -.8 MULTIPLE CKT 1 0/.7 6 /1 /60 RXBH-A0C 10.8/1. /60 -.8 MULTIPLE CKT 0/.7 0 8/ 0/ RXBH-A0J 1.6/8.8 1/60 6 -.8 SINGLE 10.8/10 6 18/18 10/17 RXBH-A0J 7./9.6 1/60 -.8 MULTIPLE CKT 1.6/0 6 1/8 60/60 RXBH-A0J 7./9.6 1/60 -.8 MULTIPLE CKT.6/0 0 /0 /0 RXBH-A0J 7./9.6 1/60 -.8 MULTIPLE CKT.6/0 0 /0 /0 Supply circuit protective devices may be fuses or HACR type circuit breakers. Largest motor load is included in single circuit and multiple circuit 1. If non-standard fuse size is specified, use next size larger standard fuse size. J Voltage (0V) single phase air handler is designed to be used with single or three phase 0 volt electric heaters. In the case of connecting -phase power to the air handler terminal block without the heater, bring only two leads to the terminal block cap, insulate and fully secure the third lead. 18 WeatherKing
Electrical Wiring Electrical Wiring Power Wiring Field wiring must comply with the National Electrical Code (C.E.C. in Canada) and any applicable local ordinance. Supply wiring must be 7 C minimum copper conductors only. See electrical data for product Ampacity rating and Circuit Protector requirement. Accessories Combustible Floor Base RXHB- Model Cabinet Size 17 1 Combustible Floor Base Model Number RXHB-17 RXHB-1 RXHB- Jumper Bar Kit Ckt. to 1 Ckt. RXBJ-A1 is used to convert single phase multiple three circuit units to a single supply circuit. Kit includes cover and screw for line side terminals. Jumper Bar Kit Ckt. to 1 Ckt. RXBJ-A1 is used to convert single phase multiple two circuit units to a single supply circuit. Kit includes cover and screw for line side terminals. Note: No jumper bar kit is available to convert three phase multiple two circuit units to a single supply circuit. Grounding This product must be sufficiently grounded in accordance with National Electrical Code (C.E.C. in Canada) and any applicable local ordinance. A grounding lug is provided. Auxiliary Electric Heater Kits RXBH- Heater Kits include circuit breakers which meet UL and cul requirements for service disconnect. See the Electric Heat Electrical Data in this specification sheet for specific Heater Kit Model numbers. External Filter Base RXHF- Model Cabinet Size *Accommodates 1" or " filter Filter Size In. [mm] 17 16 x 0 [06 x 08] 1 0 x 0 [08 x 08] Part Number* RXHF-17 RXHF-1 x 0 [6 x 08] RXHF-.70 A 1.70 19.0 B 17. 1.0. Auxiliary Horizontal Overflow Pan Accessory RXBM- Nominal Cooling Capacity-Tons Auxiliary Horizontal Overflow Pan Accessory Model Number 1 1 / - RXBM-AC8 1 / - RXBM-AC61 WeatherKing 19
Limited Warranty GENERAL TERMS OF LIMITED WARRANTY* WeatherKing will furnish a replacement for any part of this product which fails in normal use and service within the applicable periods stated, in accordance with the terms of the limited warranty. Parts...Five () Years *For complete details of the Limited and Conditional Warranties, including applicable terms and conditions, contact your local contractor or the Manufacturer for a copy of the product warranty certificate. 0 WeatherKing
Notes WeatherKing 1
Notes WeatherKing
Notes WeatherKing
Before proceeding with installation, refer to installation instructions packaged with each model, as well as complying with all Federal, State, Provincial, and Local codes, regulations, and practices. In keeping with its policy of continuous progress and product improvement, WeatherKing reserves the right to make changes without notice. PRINTED IN U.S.A. -16 QG FORM NO. H66- REV. 1 Supersedes Form No. G66-6 Rev.