Heater Selection Guide SELECTING THE CORRECT SIZE HEATER FOR POOLS & SPAS

Heater Selection Guide SELECTING THE CORRECT SIZE HEATER FOR POOLS & SPAS Pool Sizing Determine your pool s surface area in square feet: Locate in the desired table below, the surface area equal to or just greater than the pool s surface area, read to the left and select the appropriate heater. For indoor pool installations divide the pool s surface area by 3. Tables are based on a 30 F temperature rise, 3 1 2 MPH average wind velocity and elevation of up to 2,000 feet above sea level. Recommended H-Series for Spas/Hot Tubs Spa/Tub Size in Gallons 200 300 400 500 600 700 800 900 1000 Model Time in minutes to Raise Spa/Tub Temperature 30 F H400 9 14 19 23 28 33 37 42 47 H350 11 16 21 27 32 37 43 48 54 H300 12 19 25 31 37 44 50 56 62 H250 15 22 30 37 45 52 60 67 75 H200 19 28 37 47 56 66 75 84 94 H150 25 37 50 62 75 87 100 112 125 Recommended H-Series for Swimming Pools Model Surface Area H400 1200 H350 1050 H300 900 H250 750 H200 600 H150 450 Example: Rectangular pool: 20 feet x 30 feet: 20 multiply 30 600 ft. 2 Surface Area Recommended H-Series Model Heater H200 Saving Money by Saving Energy Selecting a high efficiency heater for your new installation, or replacing an older inefficient model can have a significant impact on your fuel bill. Here are some additional energy saving tips. Check your pool chemistry regularly to maintain top operating condition. Set your pool water s temperature between 78 to 82 for most applications Use a pool cover or thermal blanket on your pool when it s not in use. Evaporation accounts for 70% of heat loss from your pool. Add wind breaks to your pool. A 7-mph wind at the surface of a pool can increase energy consumption 300%! Spa Sizing Determine your spa capacity in gallons (Surface area x average depth x 7 1 2). The reference tables list the time required in minutes to raise the temperature of the spa/hot tub by 30 F. Locate in the desired table below the spa/hot tub size in gallons equal to or just greater than the spa/hot tub size in gallons. Select the desired time to raise the spa/hot tub temperature 30 F, read to the left and select the appropriate heater. This guide can be adjusted for other temperature rises. For example, if you desire a 15 F increase in temperature, simply divide the time for 30 F rise by the ratio of 30/15 = 2. Note: Heat losses and/or heat absorbed by spa walls or other objects will add to heat-up time. Spa sizing is based on an insulated and covered spa. Always cover your spa or hot tub when not in use to minimize heat loss and evaporation. Recommended H100 Induced Draft Model for Spas Spa/Tub Size in Gallons 200 300 400 500 600 700 800 900 1000 Model Time in minutes to Raise Spa/Tub Temperature 30 F H100 38 56 74 94 112 132 150 168 188 Recommended H100 Induced Draft Model for Above Ground Pools H100 Induced Draft Heater will raise temperature of Above Ground Pool in 8 Hour period as follows: Temperature Rise in 8 Hours Pool Size Gallons Avg. Temp Rise (f) 15' Round 5,300 15.2 18' Round 7,600 10.4 12' x 24' Rectangle 8,600 9.6 21' Round 10,000 8.0 24' Round 13,500 5.6 27' Round 17,000 4.8 We highly recommend that your Hayward Above Ground Pool heater be used in conjunction with a solar blanket to maximize your heating efficiency. Recommended CSpaXI Models Model Spa/Tub Size in Gallons 200 300 400 500 600 700 800 900 1000 Time in minutes to Raise Spa/Tub Temperature 30 F CSPAXI55 160 240 320 400 480 560 640 720 800 CSPAXI11 80 120 160 200 240 280 320 360 400 Example: Want a 300 gallon spa to go from 70 F to 100 F in 120 minutes. 100 F subtract 70 F 30 F Requested Temperature Rise Recommended CSPA Model Heater CPAXI11

PAGE 1186 PRODUCT DESCRIPTION - HAYWARD HEATPRO HPABG & HP380 HAYWARD HEATPRO HPABG & HP380

PAGE 1187 PRODUCT DESCRIPTION - HAYWARD HEATPRO HPABG & HP380 HAYWARD HEATPRO HPABG & HP380 ILLUSTRATED PARTS BREAKDOWN ON PAGE 1186 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W---NLA HPX2327 1 Fan Top $ NLA 02W---NLA HPX2427H 2 Side Panel - HP380 NLA 03W---NLA HPX2428H Side Panel - HPABG NLA 04W---NLA HPX2416 3 Control Box Assembly NLA 05W0037093 HPX1811 4 Contactor 75.86 06W0058051 HPX1105 5 Thermostat 117.02 07W0030044 HPX1483 6 Time Delay Relay 60.88 08W0031093 HPX2181 7 Water Pressure Switch 63.86 09W0022034 HPX11023543 8 Capacitor 44.68 10W---NLA HPX2088 9 Bent Coil with Guard NLA 11W0734080 HPX2417 10 Compressor - 2.5 Ton 1,469.59 12W---NLA HPX2423 11 Condenser NLA 13W0152074 HPX11031134 12 Fan Motor 305.46 14W0177090 HPX1103113435 12 Fan Motor 355.80 (use on units HP380 and HPAB built prior to S/N 21120501007121001) 15W0095097 HPX0970 13 Fan Guard 191.93 16W0040093 HPX2415 14 Condenser Bracket 81.86 17W0050086 HPX689 15 Fan Blade 101.73 18W0096034 HPX1140 16 Fan Motor Mount 192.68 NOT SHOWN ITEM NO. KEY# DESCRIPTION SUGG. LIST 19W---NLA HPX2001 ** 1/2 Bulb Well $ NLA 20W0040080 HPX2179 ** Replacement LP Switch 81.60 21W0040080 HPX2186 ** High Pressure Switch 81.60 22W0122041 HPX15031135 ** Expansion Valve Assembly 244.82 23W-Quote HPX2261A ** Tie-Down Kit QUOTE 24W0013076 HPX0054 ** Compressor Mount Kit 27.53 25W0007093 HPX01023727 ** Knob Kit for HPX1105 Thermostat Kit 15.86 26W0013076 HPX05023549 ** Cover Gasket 27.53

PAGE 1188 PRODUCT DESCRIPTION - HAYWARD HEATPRO HP20854T & HP21104T HAYWARD HEATPRO HP20854T & HP21104T

PAGE 1189 PRODUCT DESCRIPTION - HAYWARD HEATPRO HP20854T & HP21104T HAYWARD HEATPRO HP20854T & HP21104T ILLUSTRATED PARTS BREAKDOWN ON PAGE 1188 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0058073 HPX01023502 1 Fan Top $ 117.46 02W0036037 HPX01023503 2 Side Panel 72.75 03W0045092 HPX01023504 3 Control Box Cover 91.83 04W0060066 HPX01023505 4 Control Box 121.32 05W0037093 HPX1985 5 Contractor 75.86 06W0099096 HPX26024139 6 Control Board Assembly 199.91 07W0058042 HPX11024130 7 Interface Board 116.85 08W0031093 HPX2181 8 Water Pressure Switch 63.86 09W0025085 HPX11023693 9 Transformer 51.69 10W0022019 HPX11024272 10 Capacitor - HP20854T 44.37 11W0023029 HPX11024743 10 Capacitor - HP21104T 46.58 12W0870038 HPX24024238 11 Bend Coil with Guard - HP20854T 1,740.75 13W1067025 HPX24024241 11 Bend Coil with Guard - HP21104T 2,134.49 14W0771025 HPX11024204 12 Compressor - HP20854T 1,542.49 15W0898094 HPX11024203 12 Compressor - HP21104T 1,797.88 16W0819084 HPX24024712 13 Condensor - HP20854T 1,639.68 17W0927065 HPX24024210 13 Condensor - HP21104T 1,855.30 18W0013076 HPX05023549 14 Cover Gasket 27.53 19W0164010 HPX11023564 15 Fan Motor, 1/3 HP 328.20 20W0050000 HPX01023561 16 Fan Guard 100.00 21W0063007 HPX15024321 17 Fan Blade 126.14 22W0031044 HPX11024258 18 Replacement HP Switch 62.88 23W0031044 HPX11024259 19 Replacement LP Switch 62.88 24W0159037 HPX15024215 20 Expansion Valve Assembly - HP20854T 318.75 25W0163012 HPX15024214 20 Expansion Valve Assembly - HP21104T 326.24 26W0021061 HPX2169 21 Temperature Sensor 43.22 27W0011002 HPX01023760 22 Electrical Entry Plug 22.04 28W0013076 HPX11024151 23 Fan Run Capactor 27.53 29W0016098 HPX11024169 24 Defrost Sensor 33.97 NOT SHOWN ITEM NO. KEY# DESCRIPTION SUGG. LIST 30W0022061 HPX10023517 -- HPC Cable $ 43.22 31W0060041 HPX02024108 -- Compressor Blanket 120.82 32W0013076 HPX0054 -- Compressor Mount Kit 27.53 33W0016090 HPX10024289 -- Compressor Electrical Plug 33.80 For product info., see page 297 in the product section.

PAGE 1190 PRODUCT DESCRIPTION - HAYWARD H-SERIES 100,000 BTU HEATER HAYWARD H-SERIES HEATER 100,000 BTU

PAGE 1191 PRODUCT DESCRIPTION - HAYWARD H-SERIES 100,000 BTU HEATER HAYWARD H-SERIES HEATER 100,000 BTU ILLUSTRATED PARTS BREAKDOWN ON PAGE 1190 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W037075 IDXJKT1100 1 Jacket Top $ 75.49 02W199052 IDXBWR1935 2 Conversion Kit, Combustion Blower 399.04 03W008090 IDXBLG1930 3 Blower Gasket 17.80 04W082064 IDXHLK1930 4 Hi Limits, Kit 165.28 05W068014 CZXPRS1105 5 Water Pressure Switch 136.27 06W---NLA IDXHXA1100 6 Heat Exchanger Assembly NLA 07W357042 IDXHXA1101 6 Heat Exchanger Assembly 714.84 (used starting at S/N 29F30088) 08W016005 IDXGKT1930 7 Heat Exchanger Gasket 32.10 09W035081 IDXWHA1930 8 Wire Harness 71.63 10W023085 IDXWHA1931 8 Wire Harness (used starting at S/N 20A01209) 47.69 11W007010 IDXBRG1930 9 Burner Gasket 14.20 12W165041 IDXBNR1930 10 Burner 330.81 13W049006 IDXIGN1930 12 Ignitor 98.12 14W046003 IDXAGK1930 11 & 13 Burner Orifice & Air Orifice Bracket Kit NG 92.07 15W046003 IDXAGK1931 11 & 13 Burner Orifice & Air Orifice Bracket Kit NG 92.07 16W190001 IDXVAL1931 14 Gas Valve 380.03 17W062000 IDXMAN1100 15 Gas Manifold 124.00 18W050054 IDXAPS1930 16 Air Pressure Switch 101.08 19W194059 IDXMOD1930 17 Control Module (ignition) 389.19 20W011025 IDXILS1930 18 Interlock Switch 22.50 21W---NLA IDXCPG1930 19 Coupling NLA 22W016060 IDXCPG1931 19 2 Coupling (used starting at S/N 29F30088) 33.19 23W068014 IDXTST1930 20 Thermostat 136.27 24W092003 IDXCPA1100 21 Control Panel 184.07 25W011051 IDXLBL1100 22 Label, Control Panel 23.02 26W048031 IDXFAD1100 23 Front Access Door 96.61 27W043090 IDXFAD1101 23 Front Access Door 87.80 (used starting at S/N 20A01209) 28W049063 IDXBLS1930 24 Blower Switch 99.25 NOT SHOWN ITEM NO. DESCRIPTION SUGG. LIST 29W014046 IDXCST1930 Cordset $ 28.92 30W035053 IDXCNK1933 Conversion Kit NG-LP 71.05 31W031042 IDXCNK1934 Conversion Kit LP-NG 62.84 For product info., see page 284 in the product section.

PAGE 1192 PRODUCT DESCRIPTION - HAYWARD H-SERIES ED-1 STYLE MV HEATER HAYWARD H-SERIES HEATER ED-1 STYLE

PAGE 1193 PRODUCT DESCRIPTION - HAYWARD H SERIES HEATER ED-1 STYLE/MV ED-1 HAYWARD H-SERIES HEATER ED-1 STYLE ILLUSTRATED PARTS BREAKDOWN ON PAGE 1192 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote -------- 1 Jacket Top (specify model) $ QUOTE 02W0033046 HAXDHO1930 2 DHO Insert 66.92 03W-PCAT ------- 3 Indoor Draft Hood (see product catalog page 235) --- 04W-PCAT ------- High Wind Stack (see product catalog page 235) --- 05W0575035 HAXHXA1153 4 Heat Exchanger Assembly 150 1,150.70 06W0647099 HAXHXA1203 Heat Exchanger Assembly 200 1,295.97 07W0761046 HAXHXA1253 Heat Exchanger Assembly 250 1,522.93 08W0784036 HAXHXA1303 Heat Exchanger Assembly 300 (all styles) 1,568.72 09W0850004 HAXHXA1353 Heat Exchanger Assembly 350 (all styles) 1,700.49 10W0936013 HAXHXA1403 Heat Exchanger Assembly 400 (all styles) 1,872.26 11W0022075 HAXWHA0003 5 Wire Harness, Rear - Elec. 45.50 12W0087034 HAXWHA0007 Wire Harness, Rear - Elec. (after 10-28-00) 174.68 13W0022064 HAXWHA0002 Wire Harness, Rear - MV 45.29 14W0087034 HAXWHA0006 Wire Harness, Rear - MV (after 10-28-00) 174.68 15W0004086 HAXFOR1930 6 Heater Union O-Ring (set of 2) 9.72 16W0026029 HAXNIP1930 7 Heater Union Nipples 52.58 17W0012014 HAXNUT1930 8 Heater Union Nut (set of 2) 24.28 18W---NLA HAXBPI1930 9 Bypass Valve Insert NLA (sub HAXBPK1930 or HAXBPK1931) 19W0032066 HAXFCT1930 10 Flow Control Thermostat 65.32 20W0011041 CHXPLG1930 11 3/4" NPT Brass Plug 22.82 21W0037008 HAXBPK1931 12-15 By-Pass Kit (includes bypass valve insert, 74.17 bypass valve, valve spring, brass shaft)(before 10-28-2000) 22W0037008 HAXBPK1932 12-15 By-Pass Kit (includes bypass valve insert, 74.17 bypass valve, valve spring, brass shaft)(after 10-28-2000) 23W0022085 HAXHLI1930 16 Hi-Limit 135 F 45.69 24W0022085 HMXHLI2932 17 Hi-Limit 160 F 45.69 25W0037049 HAXDRV1930 18 Drain Valve Assembly 74.98 26W0010097 CHXPSA1930 19 Pressure Switch Adapter 21.93 27W0015025 CHXTBW1930 20a Bulb Well (before 06-01-01) 30.51 28W0018036 HAXTBW1930 20b Bulb Well (after 06-01-01)(cotherm) 36.71 29W0102042 HAXFHD1930 21 Front Header Only, Heaters (made before 10-28-00) 204.82 30W0093003 HAXFHD1931 Front Header Only, Heaters (made after 10-28-00) 186.07 31W0032007 HAXLAC1930 22 Left Access Cover 64.14 32W0030029 HAXURA1930 23 Upper Right Access Cover 60.58 33W0023000 HAXLRA1931 24 Lower Right Access Cover 46.00 34W0024095 HAXPHK1930 25 Plastic Hardware Kit 49.90 35W0049088 HAXTLK1930 26 Temperature Limiters Kit 99.76 36W0009097 HAXTBK1931 27 2-Pole Terminal Block 19.93 37W---NLA HAXTBK1933 28 4-Pole Terminal Block NLA 38W---NLA CHXGRL1930 29 TA-2 Ground Lug NLA 39W0195092 HAXMOD1930 30 Control Module 391.83 40W0035024 CHXTRF1930 31 Transformer 70.48 41W0038042 HAXPSA1930 32 Pressure Switch 76.85 42W0038058 HAXTST1930 33 Thermostat 77.15 43W0034093 HAXLDK1930 34 LED Kit 69.86 44W0010097 CHXTSW1930 35 System Switch Single 21.93 45W0011029 CHXTSW1931 System Switch Dual 22.58

PAGE 1194 PRODUCT DESCRIPTION - HAYWARD H SERIES ED-1 STYLE/MV HAYWARD H-SERIES HEATER ED-1 STYLE continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1192 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote -------- 36 Control Panel Assy. (specify model) $ QUOTE 02W0237010 HAXGSV0001 37 Gas Valve (150-400 NA, MV) 474.20 03W0237010 HAXGSV0003 Gas Valve (150-400 LP, MV) 474.20 04W0213029 HAXGSV0004 Gas Valve (150-400 LP, DS) 426.58 05W0213029 HAXGSV0005 Gas Valve (150-400 NA, DS) 426.58 06W-Quote -------- 38 Gas Manifold (specify model) QUOTE 07W0052078 HAXBRN1930 39 Burner Tube 105.56 08W0007031 HAXBON1930 40 Burner Orifice NA 14.62 09W0007085 HAXBON1931 Burner Orifice NA HA 15.69 10W---NLA HAXBOP1930 Burner Orifice LP NLA 11W0007031 HAXBOP1931 Burner Orifice LP HA 14.62 12W-Quote ------- 41 Burner Manifold (specify model) QUOTE 13W-Quote -------- 42 Front Access Door Assembly (specify model) QUOTE 14W0049058 HAXIGN1931 43 Ignitor Assembly 99.15 15W0101007 HAXPLT1931 44 Pilot, NA 202.14 16W0105093 HAXPLT1932 Pilot, LP 211.86 17W0019014 HAXTRK1930 45 Pilot Tube Replacement Kit 38.28 18W0008090 HAXHOR1930 46 Header O-Ring 17.80 19W0046088 HAXRHD1930 47 Rear Header Only, (heaters made before 10-28-00) 93.76 20W0007031 HAXPLG1930 48 1/4" NPT Brass Plug 14.62 21W0017036 HAXCIA1930 49 Corner Piece Kit (4 pcs) 34.71 22W0214022 HAXFHA1930 50 Front Header Assembly (before 10-28-00) 428.44 23W0233041 HAXFHA1931 Front Header Assembly (after 10-28-00) 466.81 NOT SHOWN ITEM NO. DESCRIPTION SUGG. LIST 24W0060083 HAXWHA0005 Wire Harness, Main - Elec. $ 121.66 25W0059039 HAXWHA0001 Wire Harness, Main - MV 118.78 26W0029085 HAXWHA0004 Wire Harness Control Panel 59.69 27W-Quote HAXRFK1930 Retro Fit Kit QUOTE 28W-Quote -------- "V" Baffle (specify model) QUOTE 29W0311066 HAXCNK0001 MV Conversion Kit NA to LP (150-400) 623.32 30W0311066 HAXCNK0002 MV Conversion Kit LP to NA (150-400) 623.32

PAGE 1195 PRODUCT DESCRIPTION - HAYWARD H SERIES ED-2 ELECTRONIC STYLE HEATER HAYWARD H-SERIES HEATER ED-2 STYLE

PAGE 1196 PRODUCT DESCRIPTION - HAYWARD H SERIES ED-2 ELECTRONIC STYLE HEATER HAYWARD H-SERIES HEATER ED-2 STYLE ILLUSTRATED PARTS BREAKDOWN ON PAGE 1195 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote 1 Jacket Top Assembly (specify model) $ QUOTE 02W0033046 HAXDHO1930 2 DHO Insert 66.92 03W---PCAT 3 Indoor Draft Hood (see product cat. page 235) --- 04W---PCAT 3 High Wind Stack (see product cat. page 235) --- 05W0575035 HAXHXA1153 4 Heat Exchanger Assembly 150 1,150.70 06W0647099 HAXHXA1203 4 Heat Exchanger Assembly 200 1,295.47 07W0761046 HAXHXA1253 4 Heat Exchanger Assembly 250 1,522.93 08W0784036 HAXHXA1303 4 Heat Exchanger Assembly 300 1,568.72 09W0850004 HAXHXA1353 4 Heat Exchanger Assembly 350 1,700.09 10W0936013 HAXHXA1403 4 Heat Exchanger Assembly 400 1,872.26 11W0087034 HAXWHA0007 5 Rear Wire Harness, DS 174.68 12W0004086 HAXFOR1930 6 O-Rings (set of 2) 9.73 13W0026029 HAXNIP1930 7 Flange Pipe Nipples 52.58 14W0012014 HAXNUT1930 8 Union Nuts (set of 2) 24.28 15W---NLA HAXBPI1931 9 Bypass Insert NLA 16W0032066 HAXFCT1930 10 Flow Control Thermostat 65.32 17W0011041 CHXPLG1930 11 3/4 NPT Brass Plug 22.82 18W0037008 HAXBPK1932 12-15 Bypass Kit (includes bypass valve insert, 74.17 bypass valve, valve spring, brass shaft) 19W0022085 HAXHLI1930 16 Hi-Limit 135 F 45.69 20W0022085 HMXHLI2932 17 Hi-Limit 160 F 45.69 21W0037049 HAXDRV1930 18 Drain Valve Assembly 74.98 22W0038042 HAXPSA1930 19 Pressure Switch Adapter 76.85 23W0074085 IDXLTER1930 20 Thermistor 149.69 24W0093003 HAXFHD1931 21 Front Header Only 186.07 25W0032007 HAXLAC1930 22 Left Access Cover 64.14 26W0030029 HAXURA1930 23 Upper Right Access Cover 60.58 27W0023000 HAXLRA1931 24 Lower Right Access Cover 46.00 28W0024095 HAXPHK1930 25 Plastic Hardware Kit 49.90 29W0049088 HAXTLK1930 26 Temperature Limiters Kit 99.76 30W0016037 IDXLTMB1931 27 6-Pole Terminal Block 32.75 31W---NLA CHXGRL1930 28 TA-2 Ground Lug NLA 32W0035024 CHXTRF1930 29 Transformer 70.48 33W0038042 HAXPSA1930 30 Pressure Switch Assembly 76.85 34W03410017 HAXCPA1932 31 Control Bezel Assembly 682.35 35W0309031 HAXCPA3153 32 Control Panel Assembly 150 DS 618.61 36W0272043 HAXCPA3203 32 Control Panel Assembly 200 DS 544.87 37W0256010 HAXCPA3253 32 Control Panel Assembly 250 DS 512.20 38W0308003 HAXCPA3303 32 Control Panel Assembly 300 DS 616.06 39W0316063 HAXCPA3353 32 Control Panel Assembly 350 DS 633.25 40W0325008 HAXCPA3403 32 Control Panel Assembly 400 DS 650.17

PAGE 1197 PRODUCT DESCRIPTION - HAYWARD H SERIES ED-2 ELECTRONIC STYLE HEATER HAYWARD H-SERIES HEATER ED-2 STYLE continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1195 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0213029 HAXGSV0004 33 Gas Valve, DS Propane $ 426.58 02W0213029 HAXGSV0005 33 Gas Valve, DS Natural Gas 426.58 03W0069046 HAXMAN1150 34 Gas Manifold 150 138.92 04W0082064 HAXMAN1200 34 Gas Manifold 200 165.29 05W0096093 HAXMAN1250 34 Gas Manifold 250 193.86 06W0102017 HAXMAN1300 34 Gas Manifold 300 204.34 07W0112068 HAXMAN1350 34 Gas Manifold 350 225.36 08W0126049 HAXMAN1400 34 Gas Manifold 400 252.98 09W0052078 HAXBRN1930 35 Burner Tube 105.56 10W0007031 HAXBON1930 36 Burner Orifice, Natural Gas 14.62 11W0007085 HAXBON1931 36 Burner Orifice, Natural Gas HA 15.69 12W0007031 HAXBOP1931 36 Burner Orifice, Propane HA 14.62 13W0007031 HAXBOP1932 36 Burner Orifice, Propane 14.62 14W---NLA HAXBMA1153 37 Burner Manifold Assembly 150 DS NA NLA 15W---NLA HAXBMA1154 37 Burner Manifold Assembly 150 DS LP NLA 16W---NLA HAXBMA1203 37 Burner Manifold Assembly 200 DS NA NLA 17W-Quote HAXBMA1204 37 Burner Manifold Assembly 200 DS LP QUOTE 18W---NLA HAXBMA1253 37 Burner Manifold Assembly 250 DS NA NLA 19W-Quote HAXBMA1254 37 Burner Manifold Assembly 250 DS LP QUOTE 20W---NLA HAXBMA1303 37 Burner Manifold Assembly 300 DS NA NLA 21W---NLA HAXBMA1304 37 Burner Manifold Assembly 300 DS LP NLA 22W---NLA HAXBMA1353 37 Burner Manifold Assembly 350 DS NA NLA 23W-Quote HAXBMA1354 37 Burner Manifold Assembly 350 DS LP QUOTE 24W-Quote HAXBMA1403 37 Burner Manifold Assembly 400 DS NA QUOTE 25W-Quote HAXBMA1404 37 Burner Manifold Assembly 400 DS LP QUOTE 26W---NLA HAXFAD1150 38 Front Access Door Assembly 150 NLA 27W-Quote HAXFAD1200 38 Front Access Door Assembly 200 QUOTE 28W-Quote HAXFAD1250 38 Front Access Door Assembly 250 QUOTE 29W---NLA HAXFAD1300 38 Front Access Door Assembly 300 NLA 30W-Quote HAXFAD1350 38 Front Access Door Assembly 350 QUOTE 31W---NLA HAXFAD1400 38 Front Access Door Assembly 400 NLA 32W0049058 HAXIGN1931 39 Ignitor Assembly 99.15 33W0008090 HAXHOR1930 40 Header O-Ring 17.80 34W0017036 HAXCIA1930 41 Corner Piece Kit (4) 34.71 35W0214022 IDXLFHA1930 42 Front Header Assembly 428.44 36W0010066 HAXPLG1931 42 3/8 Brass Plug 21.32 NOT SHOWN 37W0060083 HAXWHA0008 ** Main Wire Harness $ 121.66 38W0248014 HAXCNK0009 ** Conversion Kit NG to LP (150E-400E) 496.27 39W0248014 HAXCNK0010 Conversion Kit LP to NG (150E-400E) 496.27

PAGE 1198 PRODUCT DESCRIPTION - HAYWARD H SERIES LOW NOx HEATER HAYWARD H-SERIES LOW NOx HEATER ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote FDXLJKT 1 Jacket Top & Flue Cover (specify model) $ QUOTE 02W-Quote FDXLTFC 2 Top/Flue Cover (specify model) QUOTE 03W-Quote FDXLFAD 3 Front Access Door Assembly (specify model) QUOTE 04W-Quote FDXLRAD 4 Rear Access Door Assembly (specify model) QUOTE 05W-Quote FDXLTFP 5 Top and Front Panel (specify model) QUOTE 06W0054068 FDXLUEC1930 6 Upper End Cap 109.37 07W0057017 FDXLLEC1930 7 Lower End Cap 114.34 08W0052047 FDXLLTP1930 8 Left Trim Panel Kit 104.94 09W0051012 FDXLRTP1930 9 Right Trim Panel Kit 102.24 For product info., see page 284 in the product section.

PAGE 1199 PRODUCT DESCRIPTION - HAYWARD H SERIES LOW NOx HEATER HAYWARD H-SERIES LOW NOx HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1198 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0037053 FDXLLCB1930 10 Left Connection Box $ 75.05 02W-Quote FDXRCB1930 10 Right Connection Box QUOTE 03W-Quote FDXLLJB1930 10 Left Junction Box QUOTE 04W-Quote FDXLRJB1930 10 Right Junction Box QUOTE 05W0024046 FDXLPBL1930 11 Base Leg 48.92 06W0040056 FDXLFCS1930 12 Flue Collector Side Panel 81.12 07W-Quote FDXLRGK 13 Rain Guard Assembly (specify model) QUOTE 08W-Quote FDXLHBP 14 Heat Barrier Panel (specify model) QUOTE 09W-Quote FDXLBBN 15 Blower Inlet Baffle (specify model) QUOTE 10W0018068 FDXLIAC1930 16 Ignitor Access Cover 37.36 11W0031085 FDXLCBC1930 17 Control Box Cover Assembly 63.69 12W0152051 FDXLGSV0001 18 Gas Valve - NG 305.02 13W0152051 FDXLGSV0002 18 Gas Valve - LP 305.02 14W0025015 FDXLBON1930 20 Burner Orifice Kit - NG 50.30 15W0025015 FDXLBOP1930 20 Burner Orifice Kit - LP 50.30 16W-Quote FDXLMAN 21 Gas Manifold (specify model) QUOTE 17W-Quote IDXLTMB1931 22 Terminal Block, Remote Connection QUOTE 18W0140054 FDXLBWR1930 23 Combustion Blower 281.08 19W0020010 FDXLBVS1930 24 Blower Vacuum Switch 40.20 20W0202086 FDXLICB1930 25 Integrated Control Board 405.73 21W0042086 FDXLFWP1930 26 Field Wiring Panel 85.60 22W0051002 FDXLIGN1930 27 Ignitor 102.04 23W-Quote IDXLFLS1930 28 Flame Sensor QUOTE 24W-Quote IDXL2TRF1930 29 Transformer QUOTE 25W0020044 FDXLWPS1930 30 Water Pressure Switch 40.88 26W0178099 IDXL2DB1930 31 Display Board Only 359.76 27W0065034 FDXLBKP1930 32 Bezel and Keypad Assembly (taupe) 130.60 28W0031066 FDXLHLI1930 33 High Limit 135 F 63.32 29W0024003 FDXLTER1930 34 Thermistor 48.06 30W0016073 FDXLGSK1932 35 Gasket, Bezel/Top 33.46 31W0035007 FDXLGSK1934 36 Gasket, CC Front/Air Box 70.14 32W0555001 FDXLHXA1150 37 Heat Exchanger Assembly - H150FD 1,110.03 33W0570087 FDXLHXA1200 37 Heat Exchanger Assembly - H200FD 1,141.74 34W0570087 FDXLHXA1250 37 Heat Exchanger Assembly - H250FD 1,141.74 35W--Quote FDXLHXA1250A 37 Heat Exchanger Assembly - H250FD ASME QUOTE 36W0622026 FDXLHXA1300 37 Heat Exchanger Assembly - H300FD 1,244.52 37W0674054 FDXLHXA1350 37 Heat Exchanger Assembly - H350FD 1,349.07 38W0723009 FDXLHXA1400 37 Heat Exchanger Assembly - H400FD 1,446.17 39W-Quote FDXLHXA1400A 37 Heat Exchanger Assembly - H400FD ASME QUOTE 40W0137088 FDXLFHA1930 38 Header Assembly 275.76 41W0025027 FDXLHDW1930 39 Header Hardware Kit 50.54 42W0027061 FDXLHMB1930 40 Header Mounting Base Kit 55.21 43W0023053 FDXLBPK1930 41 Bypass Cartridge Kit 46.06 44W-Quote FDXLPGL1930 42 1/8 NPT Brass Plug QUOTE 45W0011041 CHXPLG1930 43 3/4 NPT Brass Plug 22.82 46W0137088 FDXLFHA1930 44 Header Assembly 275.76 47W-Quote FDXLCRN1930 45 Header Cartridge Retaining Nut QUOTE 48W0002056 SPX4000FG 46 Drain Plug with Gasket 5.12 49W0183007 FDXLBRN1930 -- Burner 366.14 50W0015029 FDXLFOR1930 -- Header O-Ring Kit 30.58 51W0019019 FDXLFSK1930 -- Fuse Service Kit 38.38 52W0038017 FDXLGSK1930 -- Gasket Kit - Air Side 76.34 53W0072047 FDXLGSK1931 -- Gasket Kit - Exhaust Side (all models) 144.95 For product info., see page 284 in the product section.

PAGE 1200 PRODUCT DESCRIPTION - JANDY LJ LITE 2 HEATER JANDY LJ LITE 2 HEATER (MFG 2003-2009) MAIN GAS ASSEMBLY ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote ------ 1 Burner Tray Assembly (by model) $ QUOTE 02W-Quote ------ 2 Burner Tray Shelf Only (by model) QUOTE 03W0217072 R0317100 3 Gas Valve NG 435.44 04W0196030 R0319600 3 Gas Valve LP 392.60 05W0001085 L0032200 4 Gas Orifice LP (0-3,000 ft. alt.) 3.70 06W0001085 L0032900 4 Gas Orifice LP (0-5,000 ft. alt.) 3.70 07W-Quote 10835900 5 Anti-Rotation Bracket QUOTE 08W0014007 R0469800 6 Main Burner 28.14 09W0073069 L0052200+ 7 Burner Manifold 125 147.38 10W0078051 L0006300 7 Burner Manifold 175 157.02 11W0081046 L0006400 7 Burner Manifold 250 162.92 12W0085091 L0006500 7 Burner Manifold 325 171.82 13W0088086 L0006600 7 Burner Manifold 400 177.72

PAGE 1201 PRODUCT DESCRIPTION - JANDY LJ LITE 2 HEATER JANDY LJ LITE 2 HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1200 ELECTRICAL SYSTEM ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0282088 R0366200 8 Heater Control Assembly $ 565.76 02W0317068 R0366500 9 High Voltage Assembly 635.36 03W0042095 R0366700 10 Transformer with Wiring Harness 85.90 04W0303062 R0366800 11 Power Control Board 607.34 05W0039021 R0366900 12 115/230V Conversion Plug 78.42 06W0023033 S0069800+ 13 Bezel 46.66 07W0068012 R0367000 14 Temperature Sensor 136.24 08W-Quote E0237700 15 Temperature Sensor Gasket QUOTE 09W0008054 10462200+ Retainer Clip 17.08 10W0001085 10447300 16 Temperature Sensor Retainer Bracket 3.70 11W0001013 F0009100+ 17 Retainer Bracket Screw 2.26 12W---NLA R0097600 18 Pressure Switch & Siphon Loop Assembly 2 PSI NLA 13W0049049 R0013200 19 Pressure Switch 2 PSI 98.98 14W0064079 R0015500 19 Pressure Switch 1-10 PSI 129.58 15W0048092 R0057800 20 Siphon Loop Assembly 97.84 16W0056032 R0023200 21 High-Limit Switch Assembly 112.64 17W0027039 R0022700 22 135 0 F Hi-Limit Switch 54.78 18W0027039 R0023000 23 150 0 F Hi-Limit Switch 54.78 19W---NLA 10419301 25 High-Limit Switch Wire Harness NLA 20W-Quote 10728500+ 26 High-Limit Switch Retainer Clip QUOTE 21W0003033 10418300+ 27 High-Limit Switch Cover 6.66 22W0006069 R0012200 28 Fusible Link Assembly 13.38 23W0002022 10479900 29 Fusible Link Bracket 4.44 24W0114034 R0449800 30 Igniter Box Assembly R-Kit (old# R0383900) 228.68 25W---NLA R0449800 30 Igniter Box Assembly Kit NLA 26W0075049 R0367100 31 Igniter (pre-2006 units) 150.98 27W0114034 R0449800 31 Igniter (2006 & later units) 228.68 28W---NLA R0383300 32 Igniter Fuse Assembly (set of 2) NLA 29W0128055 R0334300 33 Flame Sense Rod 251.76 VENT SYSTEM 30W-Quote ------ 35 Top Enclosure $ QUOTE 31W-Quote ------ 36 Top Filler Plate QUOTE 32W-Quote ------ 37 Rainshield Kit QUOTE 33W-Quote ------ 38 Flue Collector Assembly QUOTE 34W-Quote ------ 39 Outdoor Vent Cap QUOTE 35W-Quote ------ 40 Indoor Drafthood QUOTE 36W-Quote ------ 41 Flue Transition Plate QUOTE 37W-Quote ------ 42 Adapter Plate QUOTE 38W-Quote 10211000 43 Clip QUOTE 39W---NLA 10726300 44 Flue Collector Hold Down Clamp NLA WATER SYSTEM 40W0379013 R0056400 45 Inlet / Outlet Header, 2 $ 758.26 41W0622004 R0016800 45 Inlet / Outlet Header, 2 Bronze 1,244.08 42W0313094 R0054600 46 Return Header, Bronze (includes set of 9 gaskets) 627.94 43W0021085 R0057000 47 Header Bolt Assembly (set of 8) 43.70 44W0001048 F0046100+ 48 Bolt for Headers, 2 1/2 2.96 45W0000074 F0011100+ 49 Washers for Headers 1.48

PAGE 1202 PRODUCT DESCRIPTION - JANDY LJ LITE 2 HEATER JANDY LJ LITE 2 HEATER continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1200 WATER SYSTEM continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0000074 F0003100 50 Nut for Headers $ 1.48 02W0015094 R0050800 51 Header Gasket Assembly (set of 18) 31.88 03W0137076 R0055000 52 Flange & Gasket Assembly (set of 2) 275.52 04W0042062 10573500+ 53 2 Flange 85.24 05W0014007 S0078000+ 54 2 Flange Gasket 28.14 06W0006028 S0078100+ 54 1 1/2-2 Flange Gasket 12.56 07W0005067 S0078200+ 55 2 Flange Sleeve 11.34 08W---NLA F0031700 56 Flange Bolt NLA 09W0004091 R0316300 57 Rubber Grommet for Drain Plug 9.82 10W0002022 P0019700 59 Brass Connector Body 4.44 11W0003033 P0026800+ 60 1/4 Brass Drain Plug 6.66 12W0008014 P0027000 61 3/4 Brass Plug 16.28 13W0007044 R0013100 62 By-Pass Assembly without Spring (iron cap) 14.88 14W-Quote ------ 62 By-Pass Assembly with Spring (bronze cap) QUOTE 15W0009083 S0079800+ 63 By-Pass Valve Rod 19.66 16W0003047 R0011500 64 By-Pass Valve Disc 6.94 17W-Quote S0079900 65 By-Pass Spring, Purple QUOTE 18W0007042 S0061400+ 65 By-Pass Spring, White 14.84 19W0007042 S0061300+ 65 By-Pass Spring, Red 14.84 20W0007042 S0061200+ 65 By-Pass Spring, Blue 14.84 21W0005055 S0070100 65 By-Pass Spring, Black 11.10 22W0001048 F0048400+ 66 Brass Nut (for rod) 2.96 23W0022059 R0054900 67 By-Pass Valve Control Cap (iron) 45.18 24W0047040 R0054901 67 By-Pass Valve Control Cap (bronze) 94.80 25W0001048 F0041600+ 68 Control Cap Bolts (2 required) 2.96 26W0002037 R0011400 69 By-Pass Valve Gasket 4.74 27W-Quote ------ 70 Heat Exchanger Tube Assembly (quote by model) QUOTE (includes set of 18 gaskets) 28W-Quote ------ 71 Heat Exchanger Baffle (8 required) (quote by model) QUOTE 29W0011011 S0083900+ 72 Baffle Retainer 22.22 30W0000093 10457000 73 Heat Exchanger Support Clip (2 required) 1.87 31W-Quote ------ 75 Heat Exchanger End Baffles (quote by model) QUOTE (2 required) 32W-Quote ------ 76 Complete Combustion Chamber Assembly QUOTE JACKET COMPONENTS 33W-Quote ------ 77 Door with Latch (quote by model) $ QUOTE 34W-Quote ------ 78 Jacket Assembly, less Top (quote by model) QUOTE 35W0011019 R0344300 79 Inlet / Outlet Gap Closure 22.38 36W0008047 R0344400 80 Return Gap Closure 16.94 37W0004008 F0035300+ 81 Button Plug 1 3/4 8.16 38W0012058 R0210100 82 Button Plug 7/8 25.16 39W0002043 R0460300 83 Button Plug 2 (with hole for gas line) 4.86

PAGE 1203 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER

PAGE 1204 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER continued]

PAGE 1205 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER MAIN GAS ASSEMBLY ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W-Quote ----- 1 Burner Tray Assembly (by model) $ QUOTE 02W-Quote ------ 2 Burner Tray, Shelf Only (by model) QUOTE 03W0186016 R0494500 3 Gas Valve NG 372.32 04W0196030 R0494600 3 Gas Valve LP 392.60 05W0006098 R0469700 4 Anti-Rotation Bracket 13.96 06W0114034 R0457501 5 Hot Surface Igniter 228.68 07W0046070 R0458601 6 Flame Sensor Rod 93.40 08W0014007 R0469800 7 Main Burner 28.14 09W0073069 R0469901 8 Burner Manifold 125 147.38 10W0078051 R0469902 8 Burner Manifold 175 157.02 11W0081046 R0469903 8 Burner Manifold 250 162.92 12W0085091 R0469904 8 Burner Manifold 325 171.82 13W0088086 R0469905 8 Burner Manifold 400 177.72 14W0113079 R0469200 9 Orifice Set NG (0-3000 ft. alt.) 227.58 15W0039000 R0469500 9 Orifice Set LP (0-5000 ft. alt.) 78.00 16W0237087 R0495601 10 Manifold Assembly NG 125 475.74 17W0239074 R0495602 10 Manifold Assembly NG 175 479.48 18W0244081 R0495603 10 Manifold Assembly NG 250 489.62 19W0267064 R0495604 10 Manifold Assembly NG 325 535.28 20W0274068 R0495605 10 Manifold Assembly NG 400 549.36 For product info., see page 294 in the product section.

PAGE 1206 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1204 MAIN GAS ASSEMBLY continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0238047 R0495901 10 Manifold Assembly LP 125 $ 476.94 02W0238069 R0495902 10 Manifold Assembly LP 175 477.38 03W0241024 R0495903 10 Manifold Assembly LP 250 482.48 04W0310049 R0495904 10 Manifold Assembly LP 325 620.98 05W0217007 R0495905 10 Manifold Assembly LP 400 434.14 electrical system 06W0275022 R3008800 11 Universal Control User Interface $ 550.44 07W0514094 R0496700 12 Universal Control with Bezel 1,029.88 08W0113079 R0470200 13 Universal Control Power Interface 227.58 09W0042095 R0061100 14 Transformer 85.90 10W0068012 R0456500 15 Temperature Sensor - Regular 136.24 11W0148030 R0477300 16 Temperature Sensor - Salt 296.60 12W0001088 R0456600 17 Temperature Sensor Gasket 3.76 13W0005062 R0456800 18 Temperature Sensor Mounting Plug 11.24 14W0024044 R0455400 19 Cap Sensor/Pressure Swith with O-Ring 48.88 15W0049049 R0013200 20 Pressure Switch, 2 PSI 98.98 16W0064079 R0015500 21 Pressure Switch, 1-10 PSI 129.58 17W0048092 R0483600 22 Water Pressure Switch Tubing 97.84 18W0029097 R0457400 23 High-Limit Switch Assembly 59.94 19W0056032 R0457200 24 High-Limit Set (130 o F and 150 o F) 112.64 20W0027039 R0457300 25 High-Limit Switch, 130 o F 54.78 21W0027039 R0023000 26 High-Limit Switch, 150 o F 54.78 22W0086000 R0491300 27 Ignition Control 172.00 23W0006069 R0012200 28 Fusible Link Assembly 13.38 24W0006010 R0337200 29 Fusible Link Bracket 12.20 25W0113047 R0470000 30 Wire Harnesses Set 226.94 VENT system 26W-Quote ----- 31 Top Enclosure (by model) $ QUOTE 27W-Quote ----- 32 Vent Cover (by model) QUOTE 28W-Quote ----- 33 Rainshield - Partition (by model) QUOTE 29W-Quote ----- 34 Flue Collector Assembly (by model) QUOTE 30W-Quote ----- 35 Outdoor Vent Cap (by model) QUOTE 31W-Quote ----- 36 Indoor Drafthood (by model) QUOTE 32W-Quote ----- 37 Adapter Plate (by model) QUOTE 33W0011000 R0500200 38 Clip 22.00 For product info., see page 294 in the product section.

PAGE 1207 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1203 WATER SYSTEM - POLYMER ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0430059 R0470800 39 Inlet/Outlet Header Assembly - Polymer $ 861.18 02W0140069 R0454200 40 Return Header Assembly - Polymer 281.38 03W0091007 R0454500 41 Header Hardware Set - Polymer 182.14 04W0768065 R0470601 42 Heat Exchanger Assembly Complete - Copper 125 1,537.30 05W0833068 R0470602 42 Heat Exchanger Assembly Complete - Copper 175 1,667.36 06W0926073 R0470603 42 Heat Exchanger Assembly Complete - Copper 250 1,853.46 07W1003004 R0470604 42 Heat Exchanger Assembly Complete - Copper 325 2,006.08 08W1119083 R0470605 42 Heat Exchanger Assembly Complete - Copper 400 2,239.66 09W0899071 R0500701 42 Heat Exchanger Assembly Complete - CuNi 125 1,799.74 10W1023078 R0500702 42 Heat Exchanger Assembly Complete - CuNi 175 2,047.56 11W1247078 R0500703 42 Heat Exchanger Assembly Complete - CuNi 250 2,495.56 12W1454093 R0500704 42 Heat Exchanger Assembly Complete - CuNi 325 2,909.86 13W1690081 R0500705 42 Heat Exchanger Assembly Complete - CuNi 400 3,381.62 14W0006017 R0446000 43 Heat Exchanger Drain Plugs - Polymer (2) 12.34 15W0035055 R0454000 44 3 Coupling Nut Kit with O-Ring 71.10 16W0033032 R0453700 45 Bypass Assembly - Polymer 66.64 17W0024044 R0453900 46 Bypass Adjustable Spring - Polymer 48.88 18W0030020 R0449000 47 Tailpiece with Union Nut - Polymer (set of 2) 60.40 WATER SYSTEM - bronze 19W-Quote ----- 48 2 Inlet/Outlet Header Assemby - Bronze (by model) $ QUOTE 20W0268047 R0476700 49 Return Header Assemby - Bronze 536.94 (includes set of 9 gaskets) 21W-Quote ----- 50 Bypass Assembly - Bronze (by model) QUOTE 22W-Quote ----- 51 Bypass Spring - Bronze (by model) QUOTE 23W0002037 R0011400 52 Bypass Gasket - Bronze 4.74 24W0049035 R0477200 53 Heat Exchange Hardware Kit - Bronze 98.70 25W0003093 R0477400 54 Temp Sensor Mounting Bracket - Bronze 7.86 26W0005055 R0477501 55 Water Pressure Switch Tubing - Bronze 11.10 27W0142030 R0461500 56 Flange & Gasket Kit - Bronze 284.60 28W0005024 R0477800 57 Flange Bolts - Bronze 10.48 29W0008014 R0477900 58 3/4 NPT Plug - Bronze 16.28 30W0004085 R0478000 59 Drain Plug Header - Bronze 9.70 31W1252060 R0470701 60 Heat Exchanger Assembly Complete - Copper 125 2,505.20 32W1302083 R0470702 60 Heat Exchanger Assembly Complete - Copper 175 2,605.66 33W1407094 R0470703 60 Heat Exchanger Assembly Complete - Copper 250 2,815.88 34W1496014 R0470704 60 Heat Exchanger Assembly Complete - Copper 325 2,992.28 35W1601026 R0470705 60 Heat Exchanger Assembly Complete - Copper 400 3,202.52 36W1642000 R0500801 60 Heat Exchanger Assembly Complete - CuNi 125 3,284.00 37W1702062 R0500802 60 Heat Exchanger Assembly Complete - CuNi 175 3,405.24 38W1823091 R0500803 60 Heat Exchanger Assembly Complete - CuNi 250 3,647.82 39W1925071 R0500804 60 Heat Exchanger Assembly Complete - CuNi 325 3,851.42 40W2046098 R0500805 60 Heat Exchanger Assembly Complete - CuNi 400 4,093.96 For product info., see page 294 in the product section.

PAGE 1208 PRODUCT DESCRIPTION - JANDY LRZ LEGACY HEATER JANDY LRZ LEGACY HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1204 WATER SYSTEM - all ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0015094 R0454300 61 Header Gasket Assembly (set of 16) $ 31.88 02W0042021 R0453800 62 Bypass Hardware, Gaskets 84.42 03W-Quote ----- 63 Heat Exchanger Tube Assembly - Copper (by model) QUOTE 04W-Quote ----- 64 Heat Exchanger Tube Assembly - CuNi (by model) QUOTE 05W-Quote ----- 65 Heat Exchanger Baffles (by model) QUOTE firebox components 06W-Quote ----- 66 Combustion Chamber Panels (by model) $ QUOTE 07W0044041 R0484000 67 Igniter Bracket with Shield 88.82 jacket components 08W-Quote ----- 68 Door with Latch (by model) $ QUOTE 09W0008014 R0334900 69 Latch Assembly 16.28 10W0002043 R0460300 70 2 Sealing Grommet 4.86 11W0006002 R0491100 71 7/8 Button Plug 12.04 12W-Quote ----- 72 Rear Panel Assemby (by model) QUOTE 13W0031004 R0482400 73 Right Side Panel 62.08 14W0022010 R0482500 74 In/Out Cover Panel - Top 44.20 15W0017070 R0482600 75 In/Out Cover Panel - Bottom 35.40 16W0063076 R0482700 76 Left Side Panel 127.52 17W0020083 R0482800 77 Return Side Cover - Top 41.66 18W0022031 R0482900 78 Return Side Cover - Bottom 44.62 19W-Quote ----- 79 Heat Shield (by model) QUOTE 20W-Quote ----- 80 Front Heat Deflector Guard QUOTE 21W-Quote ----- 81 Rear Partition QUOTE 22W-Quote ----- 82 Rear Heat Deflector Guard QUOTE 23W-Quote ----- 83 Controller Mounting Panel QUOTE 24W0009058 R0491000 84 Weather Strippping 19.16 25W0007046 R0492800 85 7/8 Grommet 14.92 optional components 26W-Quote ----- 86 Noncombustible Base $ QUOTE 27W0033013 R0040400 87 Pressure Relief Valve Kit 75 PSI - Bronze 66.26 28W0036082 R0336100 88 Pressure Relief Valve Kit 75 PSI - Polymer 73.64 29W-Quote R0335800 89 Touch-Up Spray Paint - Pewter QUOTE 30W0082094 R0336000 90 Temp Rise measurement Kit 165.88 For product info., see page 294 in the product section.

PAGE 1209 PRODUCT DESCRIPTION - PENTAIR THERMALFLO HEAT PUMP PENTAIR THERMALFLO HEAT PUMP ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0002090 470439 1 10-32 Acorn Nut S/S $ 5.60 02W0062063 473368 2 Fan Guard 125.26 03W0004029 470441 3 Fan Guard Screw Kit 8.58 04W0159015 470289 4 Fan Motor w/acorn Nuts 318.30 05W0000069 473285 5 1/4-20 Acorn Nut S/S 1.38

PAGE 1210 PRODUCT DESCRIPTION - PENTAIR THERMALFLO HEAT PUMP PENTAIR THERMALFLO HEAT PUMP ILLUSTRATED PARTS BREAKDOWN ON PAGE 1209 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0345012 473134 6 Top HP $ 690.24 02W0000069 470159 7 #10 x 3/4 Ph Pan Head - Almond Head Screw 1.38 03W0000069 470161 8 #10 x 1 Button Head Torx - Almond Head Screw 1.38 04W0131068 473223 9 Fan Blade 4 263.49 05W---NLA 470135 10 Coil Air Evaporator 32 x 80 Formed NLA 06W---NLA 470136 10 Coil Air Evaporator 24 x 80 Formed NLA 07W0027093 473144 11 Orifice, Reversing (model #1200R) 55.86 08W0027095 473145 11 Orifice, (models 500, 700, 900, 1200, 1200C) 55.90 09W0051090 473121 12 Drier (models 500, 700, 900, 1200, 1200C) 103.80 10W0154017 473139 12 Drier, Reversible (model 1200R) 308.34 11W0000083 98219800 13 5/16-18 x 1 Bolt 1.66 12W0822043 473416 14 Coil, Water (model 500) 1,644.86 13W0984028 473417 14 Coil, Water (mdls 700, 900, 1200, 1200R, 1200C) 1,968.56 14W0000068 473295 15 Fender Washer 1.36 15W0062046 473175 16 Switch 90/120 Lo Press 124.92 16W0015069 473116 17 Compression Fitting, Water Line (model 500) 31.38 17W0009090 473117 17 Compression Fitting, Water Line 19.80 (models 700, 900, 1200, 1200R, 1200C) 18W0028022 471566 18 Thermistor Complete IID (probe) 56.44 19W0000083 071406 19 1/4-20 Hex Nut S/S 1.66 20W0041051 473605 20 Pressure Switch 83.02 21W0010083 470137 21 Bracket, Tie Down 21.66 22W0015029 473381 22 2 PVC Union 30.58 23W0256086 473424 23 Manifold Bypass Assembly / Hartford Loop Small 513.72 24W0266047 473320 23 Manifold Bypass Assembly / Hartford Loop Large 532.94 25W0000069 473294 24 5/16-18 x 1 3/4 Bolt S/S 1.38 26W0011092 473026 25 Compressor Isolation Kit, Grommet & Spacer (1 set) 23.80 27W0110088 473412 26 Panel Front Right Small 221.76 28W0126031 473431 26 Panel Front Right Tall 252.62 29W-Quote 470434 27 Panel Front Left Tall QUOTE 30W-Quote 470419 27 Panel Front Left Small QUOTE 31W0001041 470281 28 U-Clip Nut 2.82 32W0001068 470284 29 J-Clip Nut 3.36 33W0019007 R172305 30 Check Valve 38.14 34W0062046 473172 31 Switch 500/380 Hi Press 124.92 35W1197052 473024Z 32 Compressor Trane GH633-LL1-G 2,395.04 36W1197052 473025Z 32 Compressor Trane GH673-LM1-G 2,395.04 37W0008088 470147 33 Wire Harness, Compressor 17.76 38W0095076 473693 34 Bezel, Control Board with Label 191.52 39W0239042 472734 35 Control Board 478.84 40W0045076 473422 36 Wire Harness, Fan & Compressor Terminal Block 91.52 41W0088083 473155 37 Transformer 177.66 42W0044031 473423 38 Wire Harness, Main 88.62 43W0060078 473150 39 Relay, Fan 121.56 44W0094037 473149 40 Contactor 188.74 45W0045014 470146 41 Capacitor 5.0/7.5 Mfd 440V 90.28 46W0055086 473315 42 Wire Harness, Sensor Terminal Block 111.72 47W0482054 473135 ** Valve, Reversing (model 1200R) 965.08 48W0078046 473136 ** Solenoid, Reversing (model 1200R) 156.92

PAGE 1211 PRODUCT DESCRIPTION - PENTAIR CH HEATER PENTAIR CH HEATER

PAGE 1212 PRODUCT DESCRIPTION - PENTAIR CH HEATER PENTAIR CH HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1211 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W---PCAT ------ 1 Indoor Vent (see product catalog page 235) $ --- 02W---PCAT ------ 1a Outdor Vent (see product catalog page 235) --- 03W0043063 471991 2 Return Header Assembly 87.26 04W0000083 471622 3 Heat Exchanger Bolt 1.66 05W0000083 072184 4 3/8 x 7/8 Washer 1.66 06W0000078 070951 5 Tube Seal Gasket 1.56 07W0006093 470184 6 Thermostat Knob 13.86 08W0006078 470186 7 Rocker Switch 13.56 09W0062015 075468 9 150 MV Door 124.30 10W0090007 075604 9 200 MV Door 180.14 11W0066047 075488 9 250 MV Door 132.94 12W-Quote 075605 9 300 MV Door QUOTE 13W0116036 075606 9 350 MV Door 232.72 14W0121068 075490 9 400 MV Door 243.36 15W0032098 070256 10 150 Manifold Burner 65.96 16W0035010 075525 10 200 Manifold Burner 70.20 17W0037003 070257 10 250 Manifold Burner 74.06 18W0039039 075526 10 300 Manifold Burner 78.78 19W0039053 075527 10 350 Manifold Burner 79.06 20W0043078 070258 10 400 Manifold Burner 87.56 21W0225038 075457 11 Gas Valve (150-400 MV) NG 450.76 22W0222000 075458 11 Gas Valve (150-400 MV) LP 444.00 23W0048025 076084 12 Pilot Tube (150-200) 96.50 24W0034086 076085 12 Pilot Tube (250-300) 69.72 25W0034086 076086 12 Pilot Tube (350-400) 69.72 26W0676036 075493 13 150 NG Burner Tray Assembly Complete 1,352.72 27W-Quote 075496 13 200 NG Burner Tray Assembly Complete QUOTE 28W0822071 075494 13 250 NG Burner Tray Assembly Complete 1,645.42 29W0870033 075497 13 300 NG Burner Tray Assembly Complete 1,740.66 30W1067038 075495 13 400 NG Burner Tray Assembly Complete 2,134.76 31W0674074 075502 13 150 LP Burner Tray Assembly Complete 1,349.48 32W0751055 075505 13 200 LP Burner Tray Assembly Complete 1,503.10 33W0822016 075503 13 250 LP Burner Tray Assembly Complete 1,644.32 34W0870033 075506 13 300 LP Burner Tray Assembly Complete 1,740.66 35W0993033 075507 13 350 LP Burner Tray Assembly Complete 1,986.66 36W1037033 075504 13 400 LP Burner Tray Assembly Complete 2,074.66 37W0065017 070230 14 Burner (150-400) 130.34 38W0063036 470550 14a Burner with Pilot Bracket (150-400) 126.72 39W0041051 473605 15 Pressure Switch 83.02 40W0231009 073858 16 150 Combustion Chamber Assembly Complete 462.18 41W0247026 075586 16 200 Combustion Chamber Assembly Complete 494.52 42W0269054 073857 16 250 Combustion Chamber Assembly Complete 539.08 43W0282022 075587 16 300 Combustion Chamber Assembly Complete 564.44 44W0275099 075588 16 350 Combustion Chamber Assembly Complete 551.98 45W0310007 073856 16 400 Combustion Chamber Assembly Complete 620.14 46W0010095 075459 17 Presslite Igniter Assembly 21.90 47W0013015 471678 18 Potentiometer 26.30 48W0096065 471750 19 Flow Valve Assembly 193.30 49W0026064 471587 20 115 0 Hi-Limit Thermostat 53.28 For product info., see page 281 in the product section.

PAGE 1213 PRODUCT DESCRIPTION - PENTAIR CH HEATER PENTAIR CH HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1211 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0009064 471441 21 2 Bulkhead Adaptor $ 19.28 02W0008085 274440 22 Bulkhead Ring Adaptor 17.70 03W0034093 471993 23 Main Manifold Assembly 69.86 04W0223028 471992 24 Main Header Assembly 446.56 05W0037056 471419 25 Main Manifold Bottom 75.12 06W0007039 471420 26 Main Manifold Bottom Cap 14.78 07W0027014 471694 27 150 0 Hi-Limit Thermostat 54.28 08W0348000 472131 28 Heat Exchanger Assembly 150 696.00 09W0432052 472132 28 Heat Exchanger Assembly 200 865.04 10W0449043 472133 28 Heat Exchanger Assembly 250 898.86 11W0497035 472134 28 Heat Exchanger Assembly 300 994.70 12W0554041 472135 28 Heat Exchanger Assembly 350 1,108.82 13W0624012 472136 28 Heat Exchanger Assembly 400 1,248.24 14W0003053 070277 29 Baffle 150 7.06 15W0002098 075559 29 Baffle 200 5.96 16W0003053 070276 29 Baffle 250 7.06 17W0003031 075560 29 Baffle 300 6.62 18W0003053 070277 29 Baffle 350 7.06 19W0003076 070278 29 Baffle 400 7.52 20W0005046 472329 30 Baffle Hold Down (2 on 400) 10.92 21W0103008 073864 31 Flue Collector 150 206.16 22W0115039 075622 31 Flue Collector 200 230.78 23W0115039 073863 31 Flue Collector 250 230.78 24W--NLA 075623 31 Flue Collector 300 NLA 25W0109088 075624 31 Flue Collector 350 219.76 26W0115039 073862 31 Flue Collector 400 230.78 27W0215027 470471 32 Outdoor Top Assembly 150 430.54 28W0228056 470472 32 Outdoor Top Assembly 200 457.12 29W0216088 470473 32 Outdoor Top Assembly 250 433.76 30W0247086 470474 32 Outdoor Top Assembly 300 495.72 31W0305025 470475 32 Outdoor Top Assembly 350 610.50 32W0248025 470476 32 Outdoor Top Assembly 400 496.50 33W---Quote 075783 33 Lightback Shield LP Units Only QUOTE (quote by model) 34W0087036 471677 34 Electronic Thermostat MV Models 174.72 35W0016025 073789 35 Return Panel 32.50 36W0069003 472127 36 In / Out Panel 138.06 37W0022090 472101 37 Thermistor Probe Complete MV Models 45.80 For product info., see page 281 in the product section.

PAGE 1214 PRODUCT DESCRIPTION - PENTAIR CH HEATER PENTAIR CH HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1211 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0000076 070715 Plastic Mounting Bracket $ 1.52 02W0002098 471277 Clips for Wire Harness 5.96 03W0019047 075511 Wire Kit, MV 38.94 04W0000076 071703 #8 x 1/4 Hex Hd Screw 1.52 05W0000076 071698 #8 x 1/2 Hex Hd Screw 1.52 06W0000076 071716 #6 x 1/4 Screw 1.52 07W0000076 071659 10-32 x 1/4 Screw 1.52 08W0000076 075692 10-32 x 3/16 Screw 1.52 09W0000076 070551 1/2 Bushing 1.52 10W0004008 470414 Therm Knob Stopper 8.16 11W0000083 073725 5/16-18 x 3/4 Bolt 1.66 12W0035069 471292 Pilot NG, MV 71.38 13W0035069 471291 Pilot LP, MV 71.38 14W0057081 071515 Pilot Generator 115.62 15W0011053 075173 Thermal Cutoff Fusible Link 23.06 16W0083003 472330 Power Element Flow Valve 166.06 17W0015066 471293 Pilot Rainshield 31.32 18W0050086 471328 Pilot Electrode Only 101.72 19W0003007 074540 L Brackets 6.14 20W0010032 471271 Bracket Adapter Q379 Pilot MV 20.64 21W0002098 072253 Jumper 5.96 22W0005095 471612 Door Latch 11.90 For product info., see page 281 in the product section.

PAGE 1215 PRODUCT DESCRIPTION - PENTAIR MASTERTEMP HEATER PENTAIR MASTERTEMP HEATER ELECTRICAL SYSTEM REPLACEMENT PARTS ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0028095 420020035Z 2 Heater Display Cover $ 57.90 02W0028095 420010030S 3 Igniter Bracket 57.90 03W0044086 777070054 4 Igniter / Igniter Gasket Kit 89.72 04W0028095 420010066S 5 Igniter Gasket 57.90 05W0027059 420020025S 7 Automatic Gas Shutoff Switch AGS 55.18 06W0033054 420010063S 8 High Limit Switch 67.08 07W0042085 420010053S 9 Thermistor 85.70 08W0028095 420010056S 10 Terminal Board 57.90 09W0004005 328500099 11 Fireman s Switch Fuse 8.10 10W0179088 420010052S 12 Ignition Control Module 359.76 11W0030078 420010107S 13 115/230V Transformer 61.56 12W0074019 420010061S 14 Air Flow Switch 148.38 13W0340056 420020007S 15 Control Board Kit 681.12 14W0188086 420020034Z 17 Heater Top 377.72 15W0074034 472610Z 18 Membrane Pad 148.68 16W0064047 420020024S 19 Stack Flue Sensor 128.94 NOT SHOWN 17W0178049 420010104S 115/230V Heater Wiring Harness $ 356.98 18W0028095 420010105S 120/240V Plug Kit 57.90 For product info., see page 283 in the product section.

PAGE 1216 PRODUCT DESCRIPTION - PENTAIR MASTERTEMP HEATER PENTAIR MASTERTEMP HEATER WATER SYSTEM REPLACEMENT PARTS ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0469017 777070232 1 Tube Sheet Coil Assembly Kit 200 $ 938.34 02W0497046 460747 1 Tube Sheet Coil Assembly Kit 250 994.92 03W0656085 777070233 1 Tube Sheet Coil Assembly Kit 333 1,313.70 04W0731092 777070234 1 Tube Sheet Coil Assembly Kit 400 1,463.84 05W0344078 777070014 2 Manifold Kit 200 689.56 06W0274023 460748 2 Manifold Kit 250 548.46 07W0344074 777070015 2 Manifold Kit 333 689.56 08W0344078 777070016 2 Manifold Kit 400 689.56 09W0029042 777070117 3 Coil / Tubesheet Sealing O-Ring Kit 200 58.84 10W0028095 460749 3 Coil / Tubesheet Sealing O-Ring Kit 250 57.90 11W0028095 777070118 3 Coil / Tubesheet Sealing O-Ring Kit 300 57.90 12W0028095 777070119 3 Coil / Tubesheet Sealing O-Ring Kit 400 57.90 13W0164027 473716Z 9 Water Pressure Switch ASME 328.54 14W0029042 777070017 14 Connector Tube Kit 58.84 (includes 1 connector tube and 1 o-ring) 15W0056005 777070010 15 Thermal Regulator Kit 112.10 16W0038061 380000007S 16 Thermal Regulator (includes spring clip) 77.22 17W0002046 355051313 18 Thermal Regulator Cap O-Ring 4.92 18W0001078 U178920P 20 Drain Plug 3.56 19W---NLA u7860zps 21 3/4 Pipe Plug NLA 20W0084061 473715Z 22 Pressure Relief Valve 169.22 NOT SHOWN 21W0024066 777070120 O-Ring Kit $ 49.32 For product info., see page 283 in the product section.

PAGE 1217 PRODUCT DESCRIPTION - PENTAIR MASTERTEMP HEATER PENTAIR MASTERTEMP HEATER BURNER SYSTEM REPLACEMENT PARTS

PAGE 1218 PRODUCT DESCRIPTION - PENTAIR MASTERTEMP HEATER PENTAIR MASTERTEMP HEATER BURNER SYSTEM REPLACEMENT PARTS ILLUSTRATED PARTS BREAKDOWN ON PAGE 1217 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0235022 420010051S 1 Combination Gas Control Valve Kit $ 470.44 02W0019031 384044097S 2 3/4 Union 38.62 03W0444076 777070251 5 Air Blower Kit NG Units 200 889.50 04W0353078 460743 5 Air Blower Kit NG Units 250 707.56 05W0413075 460757 5 Air Blower Kit NG Units 300 827.50 06W0380030 777070253 5 Air Blower Kit NG Units 400 760.60 07W0444076 777070254 5 Air Blower Kit LP Units 200 889.52 08W0353073 460744 5 Air Blower Kit LP Units 250 707.56 09W0413075 460758 5 Air Blower Kit LP Units 300 827.50 10W0444076 777070256 5 Air Blower Kit LP Units 400 889.52 11W---NLA 420010114S 7 Air Orifice Grill NLA 12W0237003 420010200S 16 1 Pc Metal Chamber Combustion Assembly 474.06 13W0283032 420010214S 27 1 Pc Metal Elbow Combustion Chamber 566.64 Cover Assembly 14W---NLA 420020005S 28 Metal Vent Cover NLA NOT SHOWN 15W0029045 777070431 Gas Orifice Kit NG 200 $ 58.92 16W0027039 460739 Gas Orifice Kit NG 250 54.78 17W0027039 460753 Gas Orifice Kit NG 300 54.78 18W0029046 777070411 Gas Orifice Kit NG 400 58.92 19W0029046 777070461 Gas Orifice Kit LP 200 58.92 20W0027039 460740 Gas Orifice Kit LP 250 54.78 21W0027039 460754 Gas Orifice Kit LP 300 54.78 22W0029046 777070441 Gas Orifice Kit LP 400 58.92 23W0030000 777071461 NG to LP Conversion Kit 200 60.00 24W0028032 460741 NG to LP Conversion Kit 250 56.64 25W0028032 460755 NG to LP Conversion Kit 300 56.64 26W0030000 777071441 NG to LP Conversion Kit 400 60.00 27W0030044 777071431 LP to NG Conversion Kit 200 60.88 28W0028032 460742 LP to NG Conversion Kit 250 56.64 29W0028032 460756 LP to NG Conversion Kit 300 56.64 30W0030044 777071411 LP to NG Conversion Kit 400 60.88 31W0035041 777070111 Air Orifice Kit 200 70.82 32W0032095 460745 Air Orifice Kit 250 65.90 33W0032095 460759 Air Orifice Kit 300 65.90 34W0035041 777070113 Air Orifice Kit 400 70.82 35W0034088 777070011 Blower Adaptor Plate Gasket Kit 69.76 36W0082088 777070202 Flameholder Kit 200 165.76 37W0077010 460746 Flameholder Kit 250 154.20 38W0093025 777070203 Flameholder Kit 300 186.50 39W0108080 777070204 Flameholder Kit 400 217.60 40W0084046 777070008 Insulation Kit 168.92 41W0029066 420010074S Lower Enclosure Insulation 59.32 For product info., see page 283 in the product section.

PAGE 1219 PRODUCT DESCRIPTION - PENTAIR MINI MAX 100 HEATER PENTAIR MINI MAX 100 HEATER

PAGE 1220 PRODUCT DESCRIPTION - PENTAIR MINI MAX 100 HEATER PENTAIR MINI MAX 100 HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1219 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0139000 471187 1 Indoor Draft Hood Consisting of Indoor Draft $ 278.00 (471198 hood) and Items 2 & 3 02W0068029 471213 1A Outdoor Top 136.58 03W0045002 471075 2 Indoor Top (cover) 90.04 04W---NLA ------- 3 Indoor Stack Adapter NLA 05W0033019 471069 4 Middle Top 66.38 06W---NLA 471059 5 Flue Collector NLA 07W0038015 471096 6 Return Header 76.30 08W0000076 471200 7 Bolt 3/8" x 16 UNC x 3/4" (4 required) 1.52 09W0000078 070951 8 Rubber Seal Tube (10 required) 1.56 10W0218054 471093 9 Heat Exchanger Less Heads 437.08 11W0122088 471094 10 Main Header (inlet/outlet) 245.76 12W---NLA ------- 11 Combustion Chamber NLA 13W0018066 471058 12 Ignitor Electrode Bracket 37.32 14W0175058 471122 13 Burner Natural Gas 351.16 15W0175058 471136 13 Burner Propane 351.16 16W0437087 471219 13a Burner Tray Assembly (complete) 875.74 Natural Gas Millivolt 17W0437087 471236 13a Burner Tray Assembly (complete) 875.74 Propane Millivolt 18W0336064 471076 13a Burner Tray Assembly (complete) 673.28 Natural Gas DSI 19W0336064 471077 13a Burner Tray Assembly (complete) 673.28 Propane DSI 20W0026075 471090 14 Ignitor Electode 53.50 21W0149049 471088 15 Gas Valve Natural Gas DSI - (Robertshaw) 298.98 22W0149049 471089 15 Gas Valve Propane DSI - (Robertshaw) 298.98 23W0182042 471436 15 Gas Valve Natural Gas Millivolt -SIT 364.84 24W0155099 471435 15 Gas Valve Propane Millivolt - SIT 311.98 25W0083003 471431 16 Thermostat (electronic) - Direct Spark Models 166.06 26W0091031 072022 16 Thermostat - Millivolt Models 182.62 27W0004007 471128 17 On/Off Switch S.P.S.T. 8.14 28W---NLA 471070 18 Heat Shield Burner Tray NLA 29W0122048 471078 19 Control Panel Assembly 244.96 30W0050053 471067 20 Door Assembly 101.06 31W---NLA 471159 21 Control Bracket NLA 32W0143008 471091 22 Ignition Control DSI 286.16 33W0039097 471360 23 Transformer (old # 074033) 79.94 34W---NLA ------- 24 Jacket Assembly NLA 35W0011034 471071 25 Inspection Panel 22.68 36W---NLA ------- 26 Burner Tray Back Support NLA 37W0007010 471166 27 Burner Tray Side Support (2 required) 14.20 38W0012020 471164 28 Heat Exchanger Support Brackets (2 required) 24.20 39W0024078 071017 29 Hi-Limit Safety Switch (2 required) 49.56 40W0051093 471095 30 Flow Valve Assembly 103.86 41W0024024 471097 31 Pressure Switch 48.48 42W0005051 471064 32 Baffle Hold Down Bracket 11.02 43W0003031 471065 33 Flue Baffle 6.62 For product info., see pages 281 in the product section.

PAGE 1221 PRODUCT DESCRIPTION - PENTAIR MINI MAX 100 HEATER PENTAIR MINI MAX 100 HEATER continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1219 NOT SHOWN ITEM NO. DESCRIPTION SUGG LIST 01W---NLA 072169 Washer 3/8" I.D. (4 required) $ NLA 02W0011053 075173 Thermal Cut-Off Switch 23.06 03W0035069 471292 Pilot Natural Gas Millivolt 71.38 04W0035069 471291 Pilot Propane Millivolt 71.38 05W0057081 071515 Thermopile Generator 115.62 06W0069071 075284 Quick-Flange Kit for 2" Slip Connection 139.42 07W0029034 471083 Quick-Flange II Kit for 1.5" Thd. Connection 58.68 08W0049051 471201 Kit Wiring MMX 100 Millivolt 99.02 09W0058022 471202 Kit Wiring MMX 100 DSI 116.44 10W0006093 470184 Knob 13.86 11W0004008 470414 Knob Stopper 8.16 12W0010095 075459 Presslite Piezo Assembly Millivolt 21.90 13W0010064 072136 Valve Drain 1/4" NPT 21.28 14W0012049 471092 Hi-Tension Ignition Cable 24.98 15W0002098 070544 Bushing, 2" I.D. 5.96 16W0007042 471221 Pilot Bracket/Shield, Millivolt 14.84 17W0018054 471260 Manifold 37.08 For product info., see pages 281 in the product section.

PAGE 1222 PRODUCT DESCRIPTION - PENTAIR MINI MAX HEAT EXCHANGER MINIMAX HEAT EXCHANGER 1991-1997 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0129093 070994 1 Return Header $ 259.86 02W0000076 072180 2 Washer 3/8" I.D., 1" O.D. 1.52 03W0000081 073739 3 Bolt 3/8" x 16 x 2" PLT 1.62 04W0000076 070416 4 Bolt HH 3/8" x 16 x 1-1/2" S/S 1.52 05W0000076 072180 5 Washer 3/8" I.D., 1" O.D. 1.52 06W0000078 070951 6 Tube Seal Gasket (18 required) 1.56 07W0083003 471424 7 Flow Valve Assembly 166.06 08W0003007 074015 8 Gasket Flow Valve 6.14 09W0000083 075492 9 Bolt 3/8" x 16 x 2-1/2" PLT 1.66 10W---NLA 070903 Flange In/Out 2" Brass (pre 1994) NLA 11W0069071 075284 10 Quick Flange Kit (w/quick flange unit, bolts, 139.42 washers, 2" bushings, 1-1/2" bushings, sleeves) 12W0023020 075283 Flange Only 46.40 13W0002098 070544 11 Bushing In/Out 2" Lexan 5.96 14W0005063 071895 12 Sleeve, Rubber In/Out 2" 11.26 15W---NLA 070229 12 Sleeve, Rubber 1-1/2" NLA 16W0024078 071017 13 Hi Limit 135/120 49.56 17W0381059 070985 14 Main Header In/Out 763.18 18W0381084 074452 15 Heat Exchanger Less Heads, 150 763.68 19W0419084 075628 15 Heat Exchanger Less Heads, 200 839.68 20W0513029 074451 15 Heat Exchanger Less Heads, 250 1,026.58 21W0518012 075629 15 Heat Exchanger Less Heads, 300 1,036.24 22W0567058 075630 15 Heat Exchanger Less Heads, 350 1,135.16 23W0625026 074074 15 Heat Exchanger Less Heads, 400 1,250.12 24W-Quote -------- 15 Heat Exchanger w/heads (specify model) QUOTE 25W0016002 072134 16 Valve Boiler Drain 3/4" 32.04 26W---NLA 071983 17 3/4" Tee (ASME) NLA 27W0044036 072138 18 Valve Relief 3/4" 50# (ASME) 88.72 28W-Quote 071388 19 Nipple 3/4" x 2 1/2" (ASME) QUOTE

PAGE 1223 PRODUCT DESCRIPTION - PENTAIR MINI MAX BURNER TRAY ASSEMBLY MINIMAX BURNER TRAY ASSEMBLY ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0032098 070256 1 Manifold Burner - 150 $ 65.96 02W0035010 075525 1 Manifold Burner - 200 70.20 03W0037003 070257 1 Manifold Burner - 250 74.06 04W0039039 075526 1 Manifold Burner - 300 78.78 05W0039053 075527 1 Manifold Burner - 350 78.78 06W0043078 070258 1 Manifold Burner - 400 87.56 07W0172081 073998 2 Valve Gas 120-400 Natural IID 345.62 08W0172081 073999 2 Valve Gas 120-400 Propane IID 345.62 09W0225038 075457 2 Gas Valve Millivolt - Natural, All Models 450.76 10W0222000 075458 2 Gas Valve Millivolt - Propane, All Models 444.00 11W-Quote -------- 2 Gas Valve Replacement Kit (includes gas valve QUOTE bent tubing & fittings) 12W0048025 076084 3 Pilot Tube - Millivolt - 150/200 96.50 13W0034086 076085 3 Pilot Tube - Millivolt - 250/300 69.72 14W0034086 076086 3 Pilot Tube - Millivolt - 350/400 69.72 15W-Quote -------- 4 Burner Tray with Gas Valve & Pilot Assembly QUOTE 16W0065017 070230 5 Burner 50 K, All Models 130.34 17W0063036 470550 5A Burner with Pilot Bracket 126.72 NOT SHOWN: ITEM NO. DESCRIPTION SUGG. LIST 18W-Quote -------- Combustion Chamber Assembly $ QUOTE 19W0035069 471292 Pilot Assy. - Millivolt, Natural 71.38 20W0035069 471291 Pilot Assy. - Millivolt, Propane 71.38 21W0057081 071515 Pilot Generator with Cap - Millivolt 115.62 22W0064010 471204 Pilot Assy. - Natural IID Electronic 128.20 23W0064010 471205 Pilot Assy. - Propane IID Electronic 128.20 24W0065085 470965 Control Box Wire Harness IID Complete 131.70 25W0019047 075511 Wire Kit - Millivolt - All Models 38.94

PAGE 1224 PRODUCT DESCRIPTION - PENTAIR MINI MAX CONTROL PANEL MINIMAX CONTROL PANEL 1991-1997 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0039097 471360 1 Transformer 1384 C, Dual Voltage $ 79.94 02W---NLA 076153 1A Circuit Breaker, 1.4 Amp NLA 03W0092081 070272 2 Circuit Board Thermostat - Electronic 185.62 04W0168080 070271 2 Thermostat Assy. Complete - Electronic 337.60 (includes #2, 10 and thermistor) 05W0178073 073584 3 Module - Natural - S8600F IID Only 357.46 06W0184059 073585 3 Module - Propane - S8600H IID Only 369.16 07W---NLA 074202 4 Light Indicator Board IID Only NLA 08W---NLA 071134 5 Thermostat Knob, All Models NLA 09W0017010 071949 6 Rocker Switch, DPDT 6 Amp, All Models 34.20 10W-Quote -------- 7 Control Panel Assembly IID Only QUOTE 11W0065088 071580 8 Pressure Switch Barks MPS-PA 131.76 12W---NLA ------- 9 Thermostat Stopper Knob NLA 13W0031000 070273 10 Potentiometer Therm. Elec. IID Models 62.08 14W0011053 075173 11 Thermal Cutoff w/o Bracket 23.06 15W---NLA 074571 12 Mounting Screw for Transformer #8 1-1/2" NLA 16W0038061 075461 13 Presslite Matches Assembly - Millivolt 77.22 17W0091031 072022 14 Thermostat 60" Capillary - Millivolt Models Only 182.62 18W0010095 075459 15 Ignitor - Millivolt Models Only 21.90

PAGE 1225 PRODUCT DESCRIPTION - PENTAIR MINI MAX PLUS

PAGE 1226 PRODUCT DESCRIPTION - PENTAIR MINI MAX PLUS MINIMAX PLUS HEATER REPLACEMENT PARTS ILLUSTRATED PARTS BREAKDOWN ON PAGE 1225 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W-Quote ----- 1 150-400 Indoor Vent Kits $ QUOTE 02W-Quote ----- 1A 150-400 Outdoor Vent Kits QUOTE 03W0129093 070994 2 Return Header - (1) 259.86 04W0003000 074216 3 Bracket Washer - (1) 6.00 05W0000081 073739 4 Bolt 3/8" x 2 - (1) 1.62 06W0000076 070416 5 Bolt 3/8" x 1 1/2" - (1) 1.52 07W---NLA 072180 6 Washer 3/8" I.D. 1" O.D. - (1) NLA 08W0000078 070951 7 Tube Seal Gasket - (1) 1.56 09W0039097 471360 8 Transformer with Circuit Breaker 79.94 Duel Voltage - (1) 10W0118092 470179 9 Electronic Thermostat Circuit 237.84 Board - IID Models - (1) 11W0173053 073584 10 Module Nat. Gas - (1) 347.06 12W0184059 073585 10 Module Propane Gas - (1) 369.18 13W0018044 470122 11 Junction Box (IID Units) - (1) 36.88 14W0006093 470184 12 Thermostat Knob - (1) 13.86 15W0006078 470186 13 Switch Rocker 13.86 (single pole & double throw) - (1) 16W-Quote ----- 14 Control Panel Assembly Complete QUOTE 17W-Quote ----- 15 Front Heater Door QUOTE 18W0032098 070256 16 Manifold Burner - 150 65.96 19W0035010 075525 16 Manifold Burner - 200 70.20 20W0037003 070257 16 Manifold Burner - 250 74.06 21W0039039 075526 16 Manifold Burner - 300 78.78 22W0039053 075527 16 Manifold Burner - 350 79.06 23W0043078 070258 16 Manifold Burner - 400 87.56 24W0172081 073998 17 Gas Valve Natural - IID - (1) 345.62 25W0172081 073999 17 Gas Valve Propane - IID - (1) 345.62 26W0225038 075457 17 Gas Valve Natural - Millivolt - (1) 450.76 27W0222000 075458 17 Gas Valve Propane - Millivolt - (1) 444.00 28W0034086 075191 18 Pilot Tube - IID - (150-200) 69.72 29W0034086 075192 18 Pilot Tube - IID - (250-300) 69.72 30W0034086 075193 18 Pilot Tube - IID - (350-400) 69.72 31W0048025 076084 18 Pilot Tube - Millivolt - (150-200) 96.50 32W0034086 076085 18 Pilot Tube - Millivolt - (250-300) 69.72 33W0034086 076086 18 Pilot Tube - Millivolt - (350-400) 69.72 34W-Quote ----- 19 Burner Tray Assembly Complete QUOTE 35W0065017 070230 20 Burner (150 uses 2, 400 uses 7) 130.34 36W0063036 470550 20A Burner With Pilot Bracket 126.72 37W0052044 470190Z 21 Pressure Switch 104.88 38W-Quote --- 22 Combustion Chamber Assembly Complete QUOTE 39W0016002 072134 23 Valve Drain 3/4" 32.04 40W0010095 075459 24 Ignitor, Millivolt Models Only 21.90 41W0044036 072138 25 Valve Relief 3/4" 50# - (1) - (2) 88.72 42W0013015 471678 26 Potentiometer (millivolt only) - (1) 26.30 43W0083003 471424 27 Flow Valve Assy. Standard Complete - (1) 166.06 44W0003007 074015 28 Flow Valve Gasket - (1) 6.14 45W0000083 075492 29 Bolt 3/8" - 16 X 2 1/2 - (1) 1.66 46W0069071 075284 30 Quick Flange Kit - (1) 139.42

PAGE 1227 PRODUCT DESCRIPTION - PENTAIR MINI MAX PLUS MINIMAX PLUS HEATER REPLACEMENT PARTS continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1225 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0002098 070544 31 Bushing In/Out Lexan - (1) $ 5.96 02W0005063 071895 32 Sleeve, Rubber In/Out 2" - (1) 11.26 03W---NLA 070229 32 Sleeve, Rubber In/Out 1 1/2" - (1) NLA 04W0024078 071017 33 Safety Shut-Off - (1) 49.56 05W0381059 070985 34 Main Header In/Out - (1) 763.18 06W0381084 074452 35 150 Heat Exchanger w/o Heads 763.68 07W0419084 075628 35 200 Heat Exchanger w/o Heads 839.68 08W0513029 074451 35 250 Heat Exchanger w/o Heads 1,026.58 09W0518012 075629 35 300 Heat Exchanger w/o Heads 1,036.24 10W0567058 075630 35 350 Heat Exchanger w/o Heads 1,135.16 11W0625026 074074 35 400 Heat Exchanger w/o Heads 1,250.52 12W-Quote ------ 36 Baffle QUOTE 13W0005046 472329 37 Baffle Hold Down (2 req. on 400) - (1) 10.92 14W-Quote ------ 38 Flue Collector QUOTE 15W-Quote ------ 39 Outdoor Top Assy. QUOTE 16W-Quote ------ 40 Lightback Shield (propane only) QUOTE 17W0087036 471677 41 Electronic Thermostat - Millivolt - (1) 174.72 18W0016025 073789 42 Panel Return - (1) 32.50 19W0018093 073790 43 Panel In/Out - (1) 37.86 20W0024080 470180 44 Thermistor (probe IID models) - (1) 49.60 NOT SHOWN ITEM NO. DESCRIPTION SUGG. LIST 21W0065085 470965 Wire Kit Harness IID Complete - (1) $ 131.70 22W0019047 075511 Wire Kit - Millivolt - (1) 38.94 23W0004008 470414 Therm. Knob Stopper - (1) 8.16 24W0083003 472330 Power Element (flow-valve) - (1) 166.06 25W0064010 471204 Pilot - Natural - IID - (1) 128.20 26W0064010 471205 Piolt - Propane - IID - (1) 128.20 27W0035069 471292 Pilot - Natural - Millivolt - (1) 71.38 28W0035069 471291 Pilot - Propane - Millivolt - (1) 71.38 29W0057081 071515 Pilot Generator - (1) 115.62 30W0020005 471740 Thermistor (probe) Complete - Millivolt - (1) 40.10 31W0011053 075173 Thermal Cut-off - Fusible Link - (1) 23.06 32W0050086 471328 Pilot Electrode (only) - (1) 101.72 33W0002098 470181 Stem, Thermostat Control (IID models) - (1) 5.96 34W0000076 070715 Clips for Transformer - (1) 1.52 35W0010032 471271 Bracket Adapter Q379 Pilot, MV - (1) 20.64 36W0002098 072253 Jumper - (1) 5.96 37W0005095 471612 Door Latch - (1) 11.90 38W-Quote 074202 Indicator Board LED Lightstrip - (1) - (3) QUOTE 39W0031000 070273 Potentiometer (TSTAT) IID - (1) - (3) 62.00 40W0003071 073727 Orifice Main Burner Natural - (1) 7.42 41W0003071 073728 Orifice Main Burner Propane - (1) 7.42 (1) - Part # Used In Model #, 150-400 (2) - ASME or Local Code (3) - Previously Manufactured Model

PAGE 1228 PRODUCT DESCRIPTION - PENTAIR MINI MAX NT HEATER MINIMAX NT HEATER

PAGE 1229 PRODUCT DESCRIPTION - PENTAIR MINI MAX NT HEATER MINIMAX NT HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1228 ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W-Quote 472352 1 Exhaust Grill with Gasket $ 89.94 02W0010042 471701 2 Gasket, Exhaust Grill 20.84 03W-Quote ------ 3 Top Cover with Posts QUOTE 04W-Quote ------ 4 Exhaust Assembly QUOTE 05W-Quote ------ 5 Blower with Gasket QUOTE 06W0011029 471610 6 Gasket, Blower 22.58 07W-Quote ------ 7 Flue Collector QUOTE 08W0004095 472270 8 Insulation, Header / Hi-Limit 9.90 09W0043063 471991 9 Return Manifold Assembly 87.26 10W0000083 471622 10 Bolt, Heat Exchanger 1.66 11W0000083 072184 11 Washer, Heat Exchanger 1.66 12W-Quote ------ 12 Fire Box Assembly QUOTE 13W0432052 471933 13 200 Heat Exchanger w/o Headers 865.04 14W0449043 471934 250 Heat Exchanger w/o Headers 898.86 15W0496059 471935 300 Heat Exchanger w/o Headers 993.18 16W0624012 471936 400 Heat Exchanger w/o Headers 1,248.24 17W1174048 470371 200 Heat Exchanger Assy ASME w/ Headers 2,348.96 18W1227007 470372 250 Heat Exchanger Assy ASME w/ Headers 2,454.14 19W1258013 470373 300 Heat Exchanger Assy ASME w/ Headers 2,516.26 20W-QUOTE ------ 14 Baffle, Heat Exchanger QUOTE 21W0028022 471566 15 Thermistor Probe 56.44 22W0026064 471587 16 Hi-Limit Thermostat - 115 F 53.28 23W0027014 471694 17 Hi-Limit Thermostat - 150 F 54.28 24W0052044 470190 18 Water Pressure Switch, ASME 104.88 25W0041051 473605 Water Pressure Switch, NON-ASME 83.02 26W0073013 472363 19 In/Out Top Sub-Header Assembly 146.26 27W0223028 471992 20 In/Out Main Header Assembly 446.56 28W0091000 472364 21 In/Out Bottom Sub-Header 182.00 29W0007039 471420 22 In/Out Cap, Bottom Sub-Header 14.78 30W0002059 274494 23 O-Ring Adapter 5.18 31W0008085 274440 24 Adapter, Bulkhead Ring 17.70 32W0009064 471441 25 Adapter, Bulkhead 2" 19.28 33W0000078 070951 26 Gasket, Fin Tube, Seal 1.56 34W0096065 471750 27 Flow Valve Assembly 193.30 35W0083003 472330 28 Power Element Flow Valve 166.06 36W0052012 472365 29 Sub Gas Manifold with Plug 104.24 37W0163006 460760 30 Gas Valve - NG 326.12 38W0190069 460761 Gas Valve - LP 381.38 39W-Quote ------ 31 Burner Tray Assembly NG QUOTE 40W0080031 460799Z 32 Igniter 160.62 41W0016029 471603 33 Flame Sensor 32.58 42W-Quote ------ 34 Gas Manifold Assembly NG QUOTE

PAGE 1230 PRODUCT DESCRIPTION - PENTAIR MINI MAX NT HEATER MINIMAX NT HEATER ILLUSTRATED PARTS BREAKDOWN ON PAGE 1228 ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0003071 073727 35 Orifice, Natural Gas 0-2000 ft. $ 7.42 02W0003071 073728 Orifice, Propane, 0-2000 ft. 7.42 03W0065017 070230 36 Burner Only 130.34 04W0034061 471970 Burner with Bracket 69.22 05W0058036 471575 37 Jacket, Upper Panel, Left 116.72 06W0058036 471576 38 Jacket, Upper Panel, Right 116.72 07W0027047 471767 39 Jacket, Upper Subplate 54.94 08W0154007 472015 40 Junction Box Assembly 308.14 09W-Quote ------- 41 Air Pressure Switch QUOTE 10W0295003 460783 42 Module, Ignition Control 590.06 11W0240094 472086 43 Temperature Controller Assembly 481.88 12W0506061 471727 44 Right Door Assembly with Controller 1,013.22 13W0204080 472372 Right Door Assembly w/o Controller 409.60 NOT SHOWN ITEM NO. DESCRIPTION SUGG. LIST 14W0011053 075173 Thermal Cut-Off $ 23.06 15W0028054 472508 Transformer 40VA 57.08 16W0136053 472375 Wire Harness Assembly 273.06

PAGE 1231 PRODUCT DESCRIPTION - RAYPAK HEATER R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 (1993-1998) continued BURNER TRAY ITEM # KEY# DESCRIPTION SUGG. LIST 01W0744097 005221F 1B Burner w/gas Valve NG - MV R185 $ 1,489.94 02W0905059 005222F 1B Burner w/gas Valve NG - MV R265 1,811.18 03W0949022 005223F 1B Burner w/gas Valve NG - MV R335 1,898.44 04W1029086 005224F 1B Burner w/gas Valve NG - MV R405 2,059.72

PAGE 1232 PRODUCT DESCRIPTION - RAYPAK HEATERS R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 (1993-1998) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1231 BURNER TRAY continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0744097 005225F 1B Burner w/gas Valve LPG - MV R185 $ 1,489.94 02W0905059 005226F 1B Burner w/gas Valve LPG - MV R265 1,811.18 03W0949022 005227F 1B Burner w/gas Valve LPG - MV R335 1,898.44 04W1029086 005228F 1B Burner w/gas Valve LPG - MV R405 2,059.72 05W0809075 005229F 1B Burner w/gas Valve NG - IID R185 1,619.50 06W0827048 005230F 1B Burner w/gas Valve NG - IID R265 1654.96 07W1010003 005231F 1B Burner w/gas Valve NG - IID R335 2,020.06 08W1088069 005232F 1B Burner w/gas Valve NG - IID R405 2,177.38 09W0811073 005233F 1B Burner w/gas Valve LPG - IID R185 1,623.46 10W0967073 005234F 1B Burner w/gas Valve LPG - IID R265 1,935.46 11W1010003 005235F 1B Burner w/gas Valve LPG - IID R335 2,020.06 12W1088069 005236F 1B Burner w/gas Valve LPG - IID R405 2,172.38 13W0036036 005237F 2B Burner Spacer/Hold Down Kit R185 72.72 14W0045061 005238F 2B Burner Spacer/Hold Down Kit R265 91.22 15W0061047 005239F 2B Burner Spacer/Hold Down Kit R335 122.94 16W0067042 005240F 2B Burner Spacer/Hold Down Kit R405 134.84 17W0010058 301210 3B Burner R185 (13 required) 21.16 18W0010058 301210 3B Burner R265 (19 required) 21.16 19W0010058 301210 3B Burner R335 (24 required) 21.16 20W0010058 301210 3B Burner R405 (29 required) 21.16 21W0002064 350083F 4B Burner Orifice LPG #57 R185 (13 required) 5.28 22W0002064 350083F 4B Burner Orifice LPG #57 R265 (19 required) 5.28 23W0002064 350083F 4B Burner Orifice LPG #57 R335 (24 required) 5.28 24W0002064 350083F 4B Burner Orifice LPG #57 R405 (29 required) 5.28 25W0002064 350080F 4B Burner Orifice NG #51 R185 (13 required) 5.28 26W0002064 350080F 4B Burner Orifice NG #51 R265 (19 required) 5.28 27W0002064 350080F 4B Burner Orifice NG #51 R335 (24 required) 5.28 28W0002064 350080F 4B Burner Orifice NG #51 R405 (29 required) 5.28 29W0190037 005265F 5B Burner Tray w/o Manifold or Burners R185 380.74 30W0216015 005266F 5B Burner Tray w/o Manifold or Burners R265 432.30 31W0253083 005267F 5B Burner Tray w/o Manifold or Burners R335 507.66 32W0330051 005268F 5B Burner Tray w/o Manifold or Burners R405 661.02 Controls 33W0025012 600892B 1C AGS 135 0 (Auto Gas Shut Off)-Red Epoxy $ 50.24 34W0025012 600893B 2C High Limit 140 0 - Black Epoxy 50.24 35W0249086 005241F 3C PC Board Control IID Units 499.72 36W0014054 005384F 6C Fuse PC Board IID Units 29.08 37W0088058 003346F 4C Thermostat Control MV Units Mechanical 177.16 (old # 600827B) 38W0043063 005299B 5C Temperature Sensor IID Units 87.26 Gas VALVES 39W0206024 003898F 1G Combination Valve NG - MV $ 412.48 40W0206024 003899F 1G Combination Valve LPG - MV 412.48 41W0202027 003900F 1G Combination Valve NG - IID 404.54 42W0198097 004306F 1G Combination Valve LPG - IID 397.94

PAGE 1233 PRODUCT DESCRIPTION - RAYPAK HEATERS R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 (1993-1998) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1231 HEAT EXCHANGER ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W1278041 005244F 1H Heat Exchanger Assy. Complete Cast Iron R185 $ 2,556.82 02W1348047 005245F 1H Heat Exchanger Assy. Complete Cast Iron R265 2,696.94 03W1415090 005246F 1H Heat Exchanger Assy. Complete Cast Iron R335 2,831.80 04W1451059 005247F 1H Heat Exchanger Assy. Complete Cast Iron R405 2,903.18 05W1477037 005248F 1H Heat Exchanger Assy. Complete Brass R185 2,954.74 06W1682095 005249F 1H Heat Exchanger Assy. Complete Brass R265 3,365.90 07W1753002 005250F 1H Heat Exchanger Assy. Complete Brass R335 3,506.04 08W1859044 005251F 1H Heat Exchanger Assy. Complete Brass R405 3,718.88 09W0274098 003759F 2H Inlet/Outlet Header Cast Iron 549.96 10W0454078 003760F 2H Inlet/Outlet Header Brass 909.56 11W0080064 002450F 3H Return Header Cast Iron 161.28 12W0141046 002451F 3H Return Header Brass 282.92 13W0571078 005252F 4H Heat Exchanger (tube bundle) R185 1,143.56 14W0618071 005253F 4H Heat Exchanger (tube bundle) R265 1,237.42 15W0660036 005254F 4H Heat Exchanger (tube bundle) R335 1,320.72 16W0710059 005255F 4H Heat Exchanger (tube bundle) R405 1,421.18 17W0069041 005256F 5H Heat Exchanger Tube 1 R185 (single tube) 138.82 18W0078066 005257F 5H Heat Exchanger Tube 1 R265 (single tube) 157.32 19W0093020 005258F 5H Heat Exchanger Tube 1 R335 (single tube) 186.40 20W0109073 005259F 5H Heat Exchanger Tube 1 R405 (single tube) 219.46 21W0048092 005260F 6H Baffle Kit 8 R185 97.84 22W0056085 005261F 6H Baffle Kit 8 R265 113.70 23W0076002 005262F 6H Baffle Kit 8 R335 152.04 24W0095019 005263F 6H Baffle Kit 8 R405 190.38 25W0037068 001303F 7H Bolt Kit 75.36 26W0012056 800014B 8H Header Gasket (9) 25.12 27W0040098 062234B 9H Unitherm Governor 81.96 28W0001032 013792F 10H U. G. Retainer Spring 2.64 29W0021081 062235B 11H Bypass Valve 43.62 30W0001098 850252 12H Bypass Spring R185 3.96 31W0001098 850253 12H Bypass Spring R265 - R335 - R405 3.96 32W0002074 500719 13H Drain Valve 5.47 33W0034037 003765F 14H Sensor Well 68.74 34W0000066 300203 15H Well Retaining Clip 1.32 35W0049058 003766F 16H Inlet/Outlet Flange 99.16 36W0007027 062236B 17H Flange Gasket 1 1/2" Connection 14.54 37W0005095 800080B 17H Flange Gasket 2" Connection 11.90 38W0007093 005264F 18H Rear Drain Plug & Cover 15.86 Control Box 39W0138081 004817B 1J Ignition Control IID - NG $ 277.62 40W0138081 004818B 1J Ignition Control IID - LPG 277.62 41W0047059 006736F 2J Transformer 120/240/24V 95.18 42W0007093 006872F 3J Rocker Switch MV 15.86 43W0003031 650903 3J Rocker Switch IID Models 6.62

PAGE 1234 PRODUCT DESCRIPTION - RAYPAK HEATERS R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 (1993-1998) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1231 Miscellaneous Components ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0039066 062237B 1M Pressure Switch $ 79.32 02W0029008 005392F 2M Pressure Switch Tube Assembly 58.16 03W0001098 800303 3M Thermostat Knob (1) 3.96 04W0004063 006886F 4M Knob Stop (1) 9.26 05W0020049 005899F 5M Thermal Fuse 40.98 06W0039066 008091F 6M PRV 125 PSI (optional ) R185 79.32 07W0057051 007224F 6M PRV 125 PSI (optional ) R265 - R335 - R405 115.02 08W0148073 052871F 7M Deliming Kit 297.46 09W0058083 005269F 8M Wire Harness - MV 117.66 10W0089090 005270F 8M Wire Harness - IID 179.80 11W---NLA 005271F 9M LED's (2 green, 2 red) NLA 12W0071039 005291F 10M Control Panel - MV 142.78 13W0069041 005292F 11M Control Panel - IID (inc. switch decal) 138.82 14W0003031 009499F 12M Thermostat Knob Kit - MV 6.62 15W0001032 800304 13M Thermostat Shaft - IID 2.64 16W0003031 009499F 13M Thermostat Shaft - MV 6.62 17W0035069 005393F 14M CPVC Adapter 71.38 PILOT 17W0061047 600525B 1P Pilot NG - MV $ 122.94 18W0060081 600575B 1P Pilot LPG - MV 121.62 19W0054020 002003F 3P Pilot NG/LPG - IID 108.40 20W0005029 003901F 5P Pilot Orifice NG - MV 10.58 21W0019017 003902F 5P Pilot Orifice LPG - MV 38.34 22W0005029 003903F 7P Pilot Orifice NG - IID 10.58 23W0005029 004308F 7P Pilot Orifice LPG - IID 10.58 24W0042097 600019B 9P Pilot Generator - MV 85.94 25W0138081 004817B 12P Ignition Control IID - NG 277.62 26W0138081 004818B 12P Ignition Control IID - LPG 277.62 27W0004063 306693 13P Pilot MTG Bracket - MV 9.26 28W0004063 306692 14P Pilot MTG Bracket - IID 9.26 29W0004063 062996 15P Lighter Tube (MV units only) 9.26 30W0029075 004078F 16P Pilot Tube 59.50 31W0029075 002654B 17P Hi Tension Wire - IID 59.50 32W0052022 007864F 17P Hi Tension Wire - IID with Pilot Electrode 104.44 33W0001098 307223 18P Pilot Shield 3.96 REFRACTORY 34W0202027 005282F 1R Refractory Common (left & right) $ 404.54 35W0155034 005283F 2R Refractory Uncommon (front & rear) 310.68 36W0040098 005287F 3R Refractory Retainer Kit R185 81.96 37W0044095 005288F 3R Refractory Retainer Kit R265 89.90 38W0052022 005289F 3R Refractory Retainer Kit R335 104.44 39W0055053 005290F 3R Refractory Retainer Kit R405 111.06

PAGE 1235 PRODUCT DESCRIPTION - RAYPAK HEATERS R185, R265, R335, R405 RAYPAK HEATER MODELS R185 - R265 - R335 - R405 (1993-1998) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1231 SHEET METAL ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0169088 005303F 1S Jacket Top (louvered) R185 $ 339.76 02W0181012 005304F 1S Jacket Top (louvered) R265 362.24 03W0193002 005305F 1S Jacket Top (louvered) R335 386.04 04W0205058 005306F 1S Jacket Top (louvered) R405 411.16 05W0223042 005307F 2S Flue Collector R185 446.84 06W0224075 005308F 2S Flue Collector R265 449.50 07W0225041 005309F 2S Flue Collector R335 450.82 08W0226073 005310F 2S Flue Collector R405 453.46 09W0075036 005315F 3S Door Assembly R185 150.72 10W0086059 005316F 3S Door Assembly R265 173.18 11W0099015 005317F 3S Door Assembly R335 198.30 12W0111005 005318F 3S Door Assembly R405 222.10 13W0045061 005277F 4S Acess Panel Set (3 pieces) 91.22 14W0128024 005300F 5S Side Panel Right 256.48 15W0128024 005301F 6S Side Panel Left 256.48 16W0024046 005302F 7S Side Panel Cap 48.92 17W0063046 005278F 8S Rear Panel Kit (2 pieces) R185 126.92 18W0075036 005279F 8S Rear Panel Kit (2 pieces) R265 150.72 19W0075036 005280F 8S Rear Panel Kit (2 pieces) R335 150.72 20W0086059 005281F 8S Rear Panel Kit (2 pieces) R405 173.18 21W-Quote 005182 9S Sub-Base For Combustible Flooring R185 QUOTE 22W-Quote 005183 9S Sub-Base For Combustible Flooring R265 QUOTE 23W-Quote 005184 9S Sub-Base For Combustible Flooring R335 QUOTE 24W-Quote 005185 9S Sub-Base For Combustible Flooring R405 QUOTE 25W0023014 005294F 10S High Limit Cover 46.28 26W0067042 005198 11S Poolstat Cover/Lock 134.84 27W0081097 005394F 12S Up Front Control Panel R185 163.94 28W0088058 005395F 12S Up Front Control Panel R265 177.16 29W0095019 005396F 12S Up Front Control Panel R335 190.38 30W0103012 005397F 12S Up Front Control Panel R405 206.24 VENTING 31W-Quote 006696 1V Indoor Stack (includes inner adapter panel) R185 $ QUOTE 32W-Quote 006697 1V Indoor Stack (includes inner adapter panel) R265 QUOTE 33W-Quote 006698 1V Indoor Stack (includes inner adapter panel) R335 QUOTE 34W-Quote 006699 1V Indoor Stack (includes inner adapter panel) R405 QUOTE 35W-Quote 007990 3V "Pagoda" Top R185 QUOTE 36W-Quote 007991 3V "Pagoda" Top R265 QUOTE 37W-Quote 007992 3V "Pagoda" Top R335 QUOTE 38W-Quote 007993 3V "Pagoda" Top R405 QUOTE CONVERSION KITS 39W0098049 004690B NG to LPG MV Pilot R185 - R265 $ 196.98 40W0103012 004692B NG to LPG MV Pilot R335 - R405 206.24 41W0107075 005319F LPG to NG MV Pilot R185 - R265 215.50 42W0109073 005320F LPG to NG MV Pilot R335 - R405 219.46

PAGE 1236 PRODUCT DESCRIPTION - RAYPAK HEATERS 206A, 266A, 366A, 406A RAYPAK HEATER MODELS 206A - 266A - 366A - 406A 11-01-04 - Current

PAGE 1237 PRODUCT DESCRIPTION - RAYPAK HEATER 206A, 266A, 366A, 406A RAYPAK HEATER MODELS 206A - 266A - 366A - 406A 11-01-04 - Current ILLUSTRATED PARTS BREAKDOWN ON PAGE 1236 BURNER TRAY ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0748027 010399F 1B Burner Tray with Gas Valve NG - MV 206A $ 1,496.54 02W0905059 010400F 1B Burner Tray with Gas Valve NG - MV 266A 1,811.18 03W0949022 010401F 1B Burner Tray with Gas Valve NG - MV 336A 1,898.44 04W1029086 010402F 1B Burner Tray with Gas Valve NG - MV 406A 2,059.72 05W0748027 010403F 1B Burner Tray with Gas Valve LP - MV 206A 1,496.54 06W0905059 010404F 1B Burner Tray with Gas Valve LP - MV 266A 1,811.18 07W0949022 010405F 1B Burner Tray with Gas Valve LP - MV 336A 1,898.44 08W1029086 010406F 1B Burner Tray with Gas Valve LP - MV 406A 2,059.72 09W0811073 010407F 1B Burner Tray with Gas Valve NG - IID 206A 1,623.46 10W0967073 010408F 1B Burner Tray with Gas Valve NG - IID 266A 1,935.46 11W1010003 010409F 1B Burner Tray with Gas Valve NG - IID 336A 2,020.06 12W1090002 010410F 1B Burner Tray with Gas Valve NG - IID 406A 2,180.04 13W0811073 010411F 1B Burner Tray with Gas Valve LP - IID 206A 1,623.46 14W0967073 010412F 1B Burner Tray with Gas Valve LP - IID 266A 1,935.46 15W0949022 010413F 1B Burner Tray with Gas Valve LP - IID 336A 1,898.46 16W1090022 010414F 1B Burner Tray with Gas Valve LP - IID 406A 2,180.04 17W0031073 010415F 2B Burner Spacer / Hold Down Kit 206A 63.46 18W0038034 010416F 2B Burner Spacer / Hold Down Kit 266A 76.68 19W0054086 010417F 2B Burner Spacer / Hold Down Kit 336A 109.72 20W0057071 010418F 2B Burner Spacer / Hold Down Kit 406A 115.02 21W0010058 301210 3B Burner 206A (13 required) 21.16 22W0010058 301210 3B Burner 266A (18 required) 21.16 23W0010058 301210 3B Burner 336A (22 required) 21.16 24W0010058 301210 3B Burner 406A (27 required) 21.16 25W0002064 350079F 4B Burner Orifice NG #50 206A (13 required) 5.28 26W0002064 350079F 4B Burner Orifice NG #50 266A (18 required) 5.28 27W0002064 350079F 4B Burner Orifice NG #50 336A (22 required) 5.28 28W0002064 350079F 4B Burner Orifice NG #50 406A (27 required) 5.28 29W0002064 350083F 4B Burner Orifice LP #57 206A (13 required) 5.28 30W0002064 350083F 4B Burner Orifice LP #57 266A (18 required) 5.28 31W0002064 350083F 4B Burner Orifice LP #57 336A (22 required) 5.28 32W0002064 350083F 4B Burner Orifice LP #57 406A (27 required) 5.28 33W0179014 010421F 5B Burner Tray w/o Manifold w/o Burners 206A 358.28 34W0202093 010422F 5B Burner Tray w/o Manifold w/o Burners 266A 405.86 35W0238063 010423F 5B Burner Tray w/o Manifold w/o Burners 336A 477.26 36W0309036 010424F 5B Burner Tray w/o Manifold w/o Burners 406A 618.72 CONTROLS 37W0025012 006725F 1C Thermostat Auto Reset 135 0 Surface Mount $ 50.24 38W0025012 600892B 2C AGS 135 0 (auto gas shut-off) Red Epoxy 50.24 39W0025012 600893B 3C High Limit 140 0 - Black Epoxy 50.24 40W0235032 013464F 4C P.C. Board / Controls IID Units 470.64 41W0088058 003346F 5C Thermostat Control MV Units Mechanical 177.16 42W0042031 009577F 6C Temperature Sensor IID Units 84.62 43W-Quote 013640F 7C LCD Display (MFG from 5/2011) QUOTE GAS VALVE 44W0206024 003898F 1G Combination Valve NG - MV $ 412.48 45W0206024 003899F 1G Combination Valve LP - MV 412.48 46W0202027 003900F 1G Combination Valve NG - IID 404.54 47W0198097 004306F 1G Combination Valve LP - IID 397.94 For product info., see page 289 in the product section.

PAGE 1238 PRODUCT DESCRIPTION - RAYPAK HEATER 206A, 266A, 366A, 406A RAYPAK HEATER MODELS 206A - 266A - 366A - 406A continued 11-01-04 - Current ILLUSTRATED PARTS BREAKDOWN ON PAGE 1236 HEAT EXCHANGER ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W1093013 010043F 1HP Heat Exchanger Assy. Copper 206A $ 2,186.26 02W1153004 010044F 1HP Heat Exchanger Assy. Copper 266A 2,306.08 03W1210070 010045F 1HP Heat Exchanger Assy. Copper 336A 2,421.40 04W1241022 010046F 1HP Heat Exchanger Assy. Copper 406A 2,482.44 05W1595003 010356F 1HP Heat Exchanger Assy. Cupro Nickel 206A 3,190.06 06W1719031 010357F 1HP Heat Exchanger Assy. Cupro Nickel 266A 3,438.62 07W1838095 010358F 1HP Heat Exchanger Assy. Cupro Nickel 336A 3,677.90 08W1938010 010359F 1HP Heat Exchanger Assy. Cupro Nickel 406A 3,876.20 09W0370017 006827F 2HP Inlet/Outlet Header Complete 740.34 10W0281059 006706F 2HP Inlet/Outlet Header (includes flange nut kit) 563.18 11W0082063 006707F 3HP Return Header (includes flange nut kit) 165.26 12W0488091 010059F 4HP Tube Bundle Copper 206A 977.82 13W0529004 010060F 4HP Tube Bundle Copper 266A 1,058.08 14W0564065 010061F 4HP Tube Bundle Copper 336A 1,129.30 15W0607061 010062F 4HP Tube Bundle Copper 406A 1,215.22 16W0847042 010364F 4HP Tube Bundle Cupro Nickel 206A 1,694.84 17W0955017 010365F 4HP Tube Bundle Cupro Nickel 266A 1,910.34 18W1047071 010366F 4HP Tube Bundle Cupro Nickel 336A 2,095.42 19W1156078 010367F 4HP Tube Bundle Cupro Nickel 406A 2,313.56 20W0046093 010038F 5HP Baffle 93.86 21W0056085 005261F 5HP Baffle 113.70 22W0085027 010040F 5HP Baffle 170.54 23W0088058 010041F 5HP Baffle 177.16 24W0011024 008259F 6HP Flange Nut Kit 22.48 25W0015086 006713F 7HP O-Ring Gasket (2) 31.72 26W0018051 006714F 8HP Sensor Adapter Digital Electronic 37.02 27W0021015 006805F 8HP Sensor Well Millivolt 42.30 28W0026044 006715F 9HP Bypass Kit 52.88 29W0020049 006716F 10HP Bypass Valve 40.98 30W0021015 006717F 11HP Bypass Dam / Shaft 42.30 31W0017085 006718F 12HP Bypass Spring (all sizes included) 35.70 32W0040098 006719F 13HP Unitherm Governor 81.96 33W0021015 006720F 14HP Unitherm Governor Plug 42.30 34W0010058 006721F 15HP Drain Plug 21.16 35W0019083 006826F 16HP Inlet / Outlet Header Dam 39.66 36W0026044 006723F 17HP 2 PVC Connector & Nut (2) 52.88 37W0013088 006724F 18HP O-Ring (2) 27.76 38W0019083 006826F 19HP Baffle S/S 38.34 CONTROL BOX 39W0047059 006736F 1J Transformer 120/240/24V $ 95.18 40W0011024 009493F 2J Rocker Switch 22.48 MISCELLANEOUS COMPONENTS 41W0037068 006737F 1M Pressure Switch 1.75 PSI $ 75.36 42W0003031 009499F 2M Thermostat Knob 6.62 For product info., see page 289 in the product section.

PAGE 1239 PRODUCT DESCRIPTION - RAYPAK HEATER 206A, 266A, 366A, 406A RAYPAK HEATER MODELS 206A - 266A - 366A - 406A continued 11-01-04 - Current ILLUSTRATED PARTS BREAKDOWN ON PAGE 1236 MISCELLANEOUS COMPONENTS continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0004063 006886F 4M Knob Stop $ 9.26 02W0020049 005899F 5M Thermal Fuse 40.98 03W0039066 008091F 6M PRV 125 PSI (optional) 206A 79.32 04W0057051 007224F 6M PRV 125 PSI (optional) 266A, 336A, 406A 115.02 05W0148073 052871F 7M Deliming Kit 297.46 06W0060015 010386F 8M Wire / Harness Millivolt 120.30 07W0090056 009490F 8M Wire / Harness IID 181.12 08W0064078 009489F 9M Control Bezel MV (includes dial decal) 129.56 09W0006061 009858F 10M Dial Decal MV 13.22 10W0101014 009491F 11M Control Bezel IID (includes switch decal)(from 5/11) 202.28 11W-Quote 013491F 11M Control Bezel IID (includes switch decal)(prior to 5/11) QUOTE 12W-Quote 013492F 12M Switch / Decal Membrane (Mfg from 5/11) QUOTE 11W0035003 009492F 12M Switch / Decal Membrane(Mfg prior to 5/11) 70.06 12W0017019 009487F 13M Control Bezel Cover 34.38 13W0017085 010350F 14M Gasket Insulation (swaybrace and jacket top) 35.70 14W0029075 750125 15M Touch-Up Paint - Green 59.50 PILOT 15W0061047 600525B 1P Pilot NG - MV $ 122.94 16W0060081 600575B 1P Pilot NG - MV 121.62 17W0054020 002003F 2P Pilot NG & LP IID 108.40 18W0005029 003901F 3P Pilot Orifice NG - MV 10.58 19W0019017 003902F 3P Pilot Orifice LP - MV 38.34 20W0005029 003903F 4P Pilot Orifice NG - IID.020 10.58 21W0005029 004308F 4P Pilot Orifice LP - IID.012 10.58 22W0042097 600019B 5P Pilot Generator MV 85.94 23W0005029 010352F 6P Pilot Mounting Bracket - MV 10.58 24W0004063 306692 7P Pilot Mounting Bracket - IID 9.26 25W0004063 062996 8P Lighter Tube (MV units only) 9.26 26W0029075 004078F 9P Pilot Tube 58.50 27W0052022 007864F 10P Hi Tension Wire IID with Pilot Electrode 104.44 28W0004063 010351F 11P Pilot Shield 9.26 REFRACTORY 29W0133053 010088F 1R Refractory Common Lt. & Rt. $ 267.06 30W0103078 010089F 2R Refractory Uncommon (front and rear) 207.56 31W0038034 010387F 3R Refractory Retainer Kit 206A 76.68 32W0043063 010388F 3R Refractory Retainer Kit 266A 87.26 33W0048092 010389F 3R Refractory Retainer Kit 336A 97.84 34W0052022 010390F 3R Refractory Retainer Kit 406A 104.44 SHEETMETAL 35W0175083 010047F 1S Jacket Top (louvered) 206A $ 351.66 36W0187073 010048F 1S Jacket Top (louvered) 266A 375.46 37W0198031 010049F 1S Jacket Top (louvered) 336A 396.62 38W0209054 010050F 1S Jacket Top (louvered) 406A 419.08 For product info., see page 289 in the product section.

PAGE 1240 PRODUCT DESCRIPTION - RAYPAK 206A, 266A, 366A, 406A HEATERS RAYPAK HEATER MODELS 206A - 266A - 366A - 406A continued 11-01-04 - Current ILLUSTRATED PARTS BREAKDOWN ON PAGE 1236 SHEETMETAL continued ITEM NO. KEY# DESCRIPTION SUGG. LIST 01W0224075 010071F 2S Flue Collector (units w/ polymer headers) 206A $ 449.50 02W0224075 010072F 2S Flue Collector (units w/ polymer headers) 266A 449.50 03W0235098 010073F 2S Flue Collector (units w/ polymer headers) 336A 471.96 04W0235098 010074F 2S Flue Collector (units w/ polymer headers) 406A 471.96 05W0226073 010075F 2S Flue Collector (units w/ metal headers) 206A 453.46 06W0226073 010076F 2S Flue Collector (units w/ metal headers) 266A 453.46 07W0238063 010077F 2S Flue Collector (units w/ metal headers) 336A 477.26 08W0238063 010078F 2S Flue Collector (units w/ metal headers) 406A 477.26 09W0134085 010378F 3S Door Assembly 206A 269.70 10W0144076 010379F 3S Door Assembly 266A 289.52 11W0152003 010380F 3S Door Assembly 336A 304.06 12W0156000 010381F 3S Door Assembly 406A 312.00 13W0119064 010311F 4S Access Panel Set 3 pc (units w/polymer header) 239.28 14W0119064 010312F 4S Access Panel Set 3 pc (units w/metal header) 239.28 15W0137049 010376F 5S Jacket Side Panel Right 274.98 16W0130088 010377F 6S Jacket Side Panel Left 261.76 17W0072005 010372F 7S Jacket Rear Panel 206A 144.10 18W0078000 010373F 7S Jacket Rear Panel 266A 156.00 19W0085027 010374F 7S Jacket Rear Panel 336A 170.54 20W0095085 010375F 7S Jacket Rear Panel 406A 191.70 21W0052054 009505 8S Poolstat Cover/Lock 105.08 22W0024046 010319F 9S High Limit Cover 48.92 23W0021015 010320F 10S Base Heat Shield 42.30 24W0032039 010321F 11S Up Front Control Panel 206A 64.78 25W0033005 010322F 11S Up Front Control Panel 266A 66.10 26W0034037 010323F 11S Up Front Control Panel 336A 68.74 27W0035003 010324F 11S Up Front Control Panel 406A 70.06 28W0020049 010342F 12S High Limit Shield 40.98 29W0056085 010325F 13S Weather Shield 206A 113.70 30W0058083 010326F 13S Weather Shield 266A 117.66 31W0058017 010327F 13S Weather Shield 336A 116.34 32W0061047 010328F 13S Weather Shield 406A 122.94 VENTING 33W0072097 009838 1V Indoor Stack Kit (includes inner adapter panel) 206A $ 145.94 34W0074032 009839 1V Indoor Stack Kit (includes inner adapter panel) 266A 148.64 35W0077003 009840 1V Indoor Stack Kit (includes inner adapter panel) 336A 154.06 36W0078038 009841 1V Indoor Stack Kit (includes inner adapter panel) 406A 156.76 37W0045061 010330F 2V Stack Adapter 91.22 38W0022082 010334 3V Pagoda Top 206A 45.64 39W0035003 010335 3V Pagoda Top 266A 70.06 40W0040032 010336 3V Pagoda Top 336A 80.64 41W0048092 010337 3V Pagoda Top 406A 97.87 CONVERSION KITS 42W0098049 004690B ** NG to LP - MV Pilot 206A and 266A $ 196.98 43W0103012 004692B ** NG to LP - MV Pilot 336A and 406A 206.24 44W0081097 010419F ** LP to NG - MV Pilot 206A and 266A 163.94 45W0087092 010420F ** LP to NG - MV Pilot 336A and 406A 175.84 For product info., see page 289 in the product section.

PAGE 1241 PRODUCT DESCRIPTION - RAYPAK 055B HEATER RAYPAK HEATER MODEL 055B (1989-CURRENT)

PAGE 1242 PRODUCT DESCRIPTION - RAYPAK HEATER MODEL 055B RAYPAK HEATER MODEL 055B (1989-CURRENT) ILLUSTRATED PARTS BREAKDOWN ON PAGE 1241 BURNER TRAY ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0276031 004688F 1B Burner Tray w/burners (sea level) $ 552.62 02W0010058 301210 2B Burner (4 required) 21.16 03W0002064 350081F 3B Burner Orifice #52 NG (4 required) 5.28 04W0002064 350086F 3B Burner Orifice #62 LPG (4 required) 5.28 CONTROLS 05W0025012 600889B 1C High Limit 135 0 $ 50.24 06W0025012 600890B 2C High Limit 140 0 50.24 07W0088058 003346F 3C Thermostat Control MV (mechanical) 177.16 08W0199063 005391F 8C Thermostat Control MV (solid state) 399.26 09W0165025 005089B 5C PC Board 330.50 10W0029075 005087B 6C Potentiometer 59.50 11W0044029 005088B 7C Temperature Sensor 88.58 12W0176049 005390F 9C Thermostat Control IID (solid state) 352.98 13W0150005 005086B 4C PC Board 300.10 GAS VALVE 14W0206024 003898F 1G Combination Valve NG - MV $ 412.48 15W0206024 003899F 1G Combination Valve LPG - MV 412.48 16W0202027 003900F 1G Combination Valve NG - IID 404.54 17W0198097 004306F 1G Combination Valve LPG - IID 397.94 HEAT EXCHANGER 18W0393031 004694F 1H Heat Exchanger Assembly Complete $ 786.62 19W0254049 004695F 2H Heat Exchanger (tubed kit) 508.98 20W0025012 004715F 3H Baffle Kit 50.24 21W0039066 600885 4H Unitherm Governor 79.32 22W0006061 400734 5H U. G. Cap 13.22 23W0001098 850247 6H U. G. Spring 3.96 24W0005029 013791F 7H Drain Valve 10.58 25W0019083 007211F 8H Sensor Well 39.66 26W0000066 300203 9H Bulb Retainer Clip 1.32 27W0000066 800276 10H U. G. Gasket 1.32 28W0011090 306079 13H Bypass Baffle 23.80 29W0036036 002432F 11H Inlet/Outlet Flange 72.72 30W0004063 800013B 12H Flange Gasket 9.26 CONVERSION KITS IID Units Not Available 31W0093020 004696B NG to LPG MV Units $ 186.40 32W0097083 004697B LPG to NG MV Units 195.66 For product info., see page 288 in the product section.

PAGE 1243 PRODUCT DESCRIPTION - RAYPAK HEATER MODEL 055B RAYPAK HEATER MODEL 055B (1989-CURRENT) continued ILLUSTRATED PARTS BREAKDOWN ON PAGE 1241 PILOT ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0061047 600525B 1P Pilot NG - MV $ 122.94 02W0060081 600575B 1P Pilot LPG - MV 121.62 03W0054020 002003F 3P Pilot NG - IID 108.40 04W0062080 002001F 3P Pilot LPG - IID 125.60 05W0005029 003901F 5P Pilot Orifice NG - MV 10.58 06W0019017 003902F 5P Pilot Orifice LPG - MV 38.34 07W0005029 003903F 5P Pilot Orifice NG - IID 10.58 08W0005029 004308F 5P Pilot Orifice LPG - IID 10.58 09W0042097 600019B 9P Pilot Generator MV 85.94 10W0138081 004817B 11P Ignition Control NG - IID 277.62 11W0138081 004818B 11P Ignition Control LPG - IID 277.62 12W0030041 004716F 12P Pilot Mounting Bracket - IID 60.82 13W0030041 004717F 13P Pilot Mounting Bracket - MV 60.82 14W0029075 004078F 14P Pilot Tube 59.50 15W0030041 002654B 15P Hi Tension Wire - IID 60.82 REFRACTORY AND SHEET METAL 16W0103078 003544F 1R Refractory Block Kit $ 207.56 17W0035069 002525F 1S Jacket Top 71.38 18W0047059 002530F 2S Flue Collector 95.18 19W0085027 004689F 3S Door Assembly 170.54 20W0035003 003791F 4S Upper Jacket Control Panel 70.06 21W0024046 306094 5S Wiring Box 48.92 22W0044090 006492 6S Thermostat Lock/Cover 89.80 VENTING 23W0035014 003709 1V Stackless Top (outdoor) $ 70.28 24W0043024 003722 2V Drafthood (indoor) 86.48 MISCELLANEOUS COMPONENTS 25W0039066 062237B 1M Pressure Switch $ 79.32 26W0033005 003543F 2M Pressure Switch Tube Assembly 66.10 27W0001098 006885F 3M Thermostat Knob 3.96 28W0004063 006886F 4M Knob Stop 9.26 29W0018051 900741 5M Dial Plate - MV 37.02 30W0020049 900742 5M Dial Plate - IID 40.98 31W0047059 006736F 6M Transformer IID Unit (old #005345F) 95.18 32W0013088 650595 7M Toggle Switch 27.76 33W0041064 004010F 8M Wire Harness - MV 83.28 34W0048092 004011F 8M Wire Harness - IID 97.84 35W0020049 005899F 9M Thermal Fuse 40.98 For product info., see page 288 in the product section.

PAGE 1244 PRODUCT DESCRIPTION - RAYPAK MODEL 105B CAST IRON HEATER RAYPAK HEATER MODEL 105B CAST IRON

PAGE 1245 PRODUCT DESCRIPTION - RAYPAK HEATER MODEL 105B CAST IRON RAYPAK HEATER MODEL 105B CAST IRON (1999-CURRENT) ILLUSTRATED PARTS BREAKDOWN ON PAGE 1244 BURNER TRAY ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0376078 004899F 1B Burner Tray with Burners (sea level) $ 753.56 02W0010058 301210 2B Burner (8 required) 21.16 03W0002064 350080F 3B Burner Orifice NG #51 (sea level) (8 required) 5.28 04W0002064 350350F 3B Burner Orifice LPG #59 (sea level) (8 required) 5.28 CONTROLS 05W0025012 006725F 1C Thermostat (hi limit) $ 50.24 06W0088058 003346F 2C Thermostat Control 177.16 GAS VALVE 07W0206024 003898F 1G Combination Valve NG - MV $ 412.48 08W0206024 003899F 1G Combination Valve LPG - MV 412.48 09W0202027 003900F 1G Combination Valve NG - IID 404.54 10W0198097 004306F 1G Combination Valve LPG - IID 397.94 HEAT EXCHANGER 11W0490047 006888F 1H Heat Exchanger Assembly Complete $ 980.94 12W0099081 006887F 2H Inlet/Outlet Header 199.62 13W0363056 006889F 3H Heat Exchanger (tube bundle) 727.12 14W0042031 003964F 4H Baffle Kit 84.62 15W0027010 006890F 5H Bolt Kit 54.20 16W0006061 006891F 6H Header Gasket (4) 13.22 17W0021081 062235B 7H Bypass Valve 43.62 18W0001098 850252 8H Bypass Spring 3.96 19W0000066 300203 9H Well Retaining Clip 1.32 MISCELLANEOUS COMPONENTS 20W0037068 006737F 1M Pressure Switch $ 75.36 21W0001098 006885F 2M Thermostat Knob 3.96 22W0004063 006886F 3M Knob Stop 9.26 23W0031073 006866F 4M Dial Plate MV 63.46 24W0031073 006867F 4M Dial Plate IID 63.46 25W0047059 006736F 5M Transformer IID Unit 95.18 26W0007093 006872F 6M Rocker Switch (SPST) 15.86 27W0028042 006873F 7M Wire Harness MV (not shown) 56.84 28W0037068 006874F 7M Wire Harness IID (not shown) 75.36 29W0148073 052871F 8M Deliming Kit (not shown) 297.46 30W0019083 008126F 9M Thermal Fuse 39.66 31W0013088 006929F 10M Bezel (less label) 27.76

PAGE 1246 PRODUCT DESCRIPTION - RAYPAK HEATER MODEL 105B CAST IRON RAYPAK HEATER MODEL 105B CAST IRON (1999-CURRENT) continued ILLUSTRATED PARTS BREAKDOWN ON 1244 PILOT ITEM NO. KEY # DESCRIPTION SUGG. LIST 01W0061047 600525B 1P Pilot NG - MV $ 122.94 02W0060081 600575B 1P Pilot LPG - MV 121.62 03W0054020 002003F 3P Pilot NG/LPG - IID 108.40 04W0005029 003901F 5P Pilot Orifice NG - MV 10.58 05W0019017 003902F 5P Pilot Orifice LPG - MV 38.34 06W0005029 003903F 7P Pilot Orifice NG - IID 10.58 07W0005029 004308F 7P Pilot Orifice LPG - IID 10.58 08W0042097 600019B 9P Pilot Generator MV 85.94 09W0138081 004817B 11P Ignition Control NG - IID 277.62 10W0138081 004818B 11P Ignition Control LPG - IID 277.62 11W0030041 004907F 12P Pilot Mounting Bracket MV 60.82 12W0030041 004908F 13P Pilot Mounting Bracket IID 60.82 13W0029075 004078F Pilot Tube 59.50 14W0030041 002654B 15P Hi Tension Wire IID 60.82 15W0052022 007864F 15P Hi Tension Wire w/pilot Electrode 104.44 REFRACTORY AND SHEETMETAL COMPONENTS 16W0161095 004909F 1R Refractory Block Kit $ 323.90 17W0027010 006877F 1S Jacket Top 54.20 18W0084061 004911F 2S Flue Collector 169.22 19W0101080 004912F 3S Door Assembly 203.60 20W0034037 006881F 4S Upper Jacket Control Panel 68.74 21W0021015 306899 5S Wiring Box 42.30 22W0035069 006883F 6S Access Panel (inlet/outlet end) 71.38 VENTING 23W0152069 006930F 1V Outdoor Stackless Top $ 305.38 24W0072020 004897 2V Indoor Drafthood 144.40 25W0102024 004301 3V Outdoor Stack with Adapter 204.48 26W-Quote 951018 4V Outdoor Stack QUOTE CONVERSION KITS 27W0082063 004915B NG to LPG MV Units $ 165.26 28W0089090 004916B LPG to NG MV Units 179.80 29W0198097 004917F NG to LPG IID Units 397.94 30W0152003 004918F LPG to NG IID Units 304.06

PAGE 1247 PRODUCT DESCRIPTION - RAYPAK RP2100 HEATER RAYPAK RP2100 HEATER Model P-R185A to P-R335A (11-1-98 THROUGH 2003) 3-P 14-P 1-P 15-P 9-P 1-P 15-P 3-P 9-P 7-P 16-P Honeywell IID 13-P 13-P 14-P 16-P 16-P Honeywell MV 16-P 5-P 5-P 17-P 7-P Robertshaw MV Robertshaw IID

PAGE 1248 PRODUCT DESCRIPTION - RAYPAK RP2100 HEATER RAYPAK RP2100 HEATER Model P-R185A to P-R335A (11-1-98 THROUGH 2003) ILLUSTRATED PARTS BREAKDOWN ON PAGE 1247 ITEM NO. KEY DESCRIPTION SUGG. LIST 01W-Quote -------- 1B Burner Tray (specify model) $ QUOTE 02W-Quote -------- 2B Burner Spacer/Hold Down Kit (specify model) QUOTE 03W0010058 301210 3B Burner 21.16 04W0002064 350080F 4B Burner Orifice - NG 5.28 05W0002064 350083F Burner Orifice - LP 5.28 06W-Quote -------- 5B Burner Tray w/o Manifold & Burners QUOTE 07W0025012 006725F 1C Thermostat Auto Reset, 135 Deg. 50.24 08W0025012 600892B 2C Auto Gas Shut-Off, 135 Deg. Red Epoxy 50.24 09W0025012 600893B 3C High Limit, 140 Deg. Black Epoxy 50.24 10W0305039 010253F 4C PC Board/Control, Electronic 610.78 11W0088058 003346F 5C Thermostat Control - MV 177.16 12W0043063 006701F 6C Temperature Sensor - Electronic 87.26 13W0206024 003898F 1G Combination Valve NG - MV 412.48 14W0206024 003899F Combination Valve LP - MV 412.46 15W0202027 003900F Combination Valve NG - Electronic 404.54 16W0198097 004306F Combination Valve LP - Electronic 397.94 17W1278041 006702F 1HP Heat Exchanger Assy. Complete - 185 2,556.82 18W1348047 006703F Heat Exchanger Assy. Complete - 265 2,696.94 19W1415090 006704F Heat Exchanger Assy. Complete - 335 2,831.80 20W1451059 006705F Heat Exchanger Assy. Complete - 405 2,903.18 21W0281059 006706F 2HP Inlet/Outlet Header with Gaskets 563.18 22W0082063 006707F 3HP Return Header with Gaskets 165.26 23W0571079 006708F 4HP Heat Exchanger (tube bundle) - 185 1,143.56 24W0618071 006709F Heat Exchanger (tube bundle) - 265 1,237.42 25W0660036 006710F Heat Exchanger (tube bundle) - 335 1,320.72 26W0710059 006711F Heat Exchanger (tube bundle) - 405 1,421.18 27W0047059 006712F 5HP Bolt Kit 95.18 28W0015086 006713F 6HP O-Ring Gaskets 31.72 29W0018051 006714F 7HP Sensor Adapter Digital - Electronic 37.02 30W0021015 006805F Sensor Well - MV 42.30 31W0026044 006715F 8HP Bypass Kit 52.88 32W0020049 006716F 9HP Bypass Valve 40.98 33W0021015 006717F 10HP Bypass Dam/Shaft 42.30 34W0017085 006718F 11HP Bypass Springs (all sizes incl.) 35.70 35W0040098 006719F 12HP Unitherm Governor 81.96 36W0021015 006720F 13HP Unitherm Governor Plug 42.30 37W0010058 006721F 14HP Drain Plug 21.16 38W---NLA ----- 15HP Inlet/Outlet Header Dam (Sub 006826F Kit) NLA 39W0026044 006723F 16HP 2" PVC Connector & Nut (2) 52.88 40W0013088 006724F 17HP O-Ring (2) 27.76 41W0019083 006826F 18HP Header Baffle 39.66 42W0138081 004817B 1J Ignition Control NG - Electronic 277.62 43W0138081 004818B Ignition Control LP - Electronic 277.62 44W0047059 006736F 2J Transformer, 120/240/24V 95.18 45W0007093 006872F 3J Rocker Switch 15.86

PAGE 1249 PRODUCT DESCRIPTION - RAYPAK RP2100 HEATER RAYPAK RP2100 HEATER CONTINUED Model P-R185A to P-R335A (11-1-98 THROUGH 2003) ILLUSTRATED PARTS BREAKDOWN ON PAGE 1247 ITEM NO. KEY DESCRIPTION SUGG. LIST 01W0037068 006737F 1M Pressure Switch $ 75.36 02W0003031 800303 3M Thermostat Knob 6.62 03W0004063 006886F 4M Knob Stop 9.26 04W0020049 005899F 5M Thermal Fuse 40.98 05W0039066 008091F 6M Pressure Relief Valve, 125 PSI 79.32 06W0058083 005269F 8M Wire Harness - MV 117.66 07W0089090 006738F Wire Harness - Electronic 179.80 08W0071039 005291F 9M Control Panel - MV 142.78 09W0071039 006739F 10M Control Panel - Electronic 142.78 10W0003031 800307 11M Thermostat Shaft, MV 6.62 11W0061047 600525B 1P Pilot NG - MV 122.94 12W0060081 600575B Pilot LP - MV 121.62 13W0054020 002003F 3P Pilot NG/LP - Electronic (after 6/1/2000) 108.40 14W0005029 003901F 5P Pilot Orifice NG - MV 10.58 15W0019017 003902F Pilot Orifice LP - MV 38.34 16W0005029 003903F 7P Pilot Orifice NG - Electronic 10.58 17W0005029 004308F Pilot Orifice LP - Electronic 10.58 18W0042097 600019B 9P Pilot Generator - MV 85.94 19W0138081 004817B 12P Ignition Control NG - Electronic 277.62 20W0138081 004818B Ignition Control LP - Electronic 277.62 21W0004063 306693 13P Pilot Bracket - MV 9.22 22W0004063 306692 14P Pilot Bracket - Electronic 9.22 23W0004063 062996 15P Lighter Tube - MV 9.22 24W0029075 004078F 16P Pilot Tube 59.50 25W0052022 007864F 17P High Tension Wire - IID w/pilot Electrode 104.44 26W0001098 307223 18P Pilot Shield 3.96 27W0202027 005282F 1R Refractory Common (left & right) 404.54 28W-Quote -------- 2R Refractory Uncommon (specify model) QUOTE 29W-Quote -------- 3R Refractory Retainer Kit (specify model) QUOTE 30W-Quote -------- 1S Jacket Top (specify model) QUOTE 31W-Quote -------- 2S Flue Collector (specify model) QUOTE 32W-Quote -------- 3S Door Assembly (specify model) QUOTE 33W0008059 006744F 4S Screw & Retainer 17.18 34W0128090 006745F 5S Access Panel Set (3) 252.50 35W0128024 005300F 6S Side Panel, Right 256.48 36W0128024 005301F 7S Side Panel, Left 256.48 37W0024046 005302F 8S Side Panel Cap 48.92 38W-Quote -------- 9S Rear Panel Kit (specify model) QUOTE 39W-Quote -------- 10S Sub Base for Combust. Floor (specify model) QUOTE 40W0067042 005198 11S Poolstat Cover/Lock 134.84 41W0023014 005294F 12S High Limit Cover 46.28 42W0098049 004690B Conversion Kit - MV, NG to LP 196.98 43W0107075 005319F Conversion Kit - MV, LP to NG 215.50

PAGE 1250 PRODUCT DESCRIPTION - RAYPAK VERSA HEATER MODEL 155C RAYPAK VERSA HEATER Model 155C (11-1-96 THROUGH 6-30-06)