TCD-TCH. Self-contained rooftop unit. VOYAGER I and II range TCD: Downflow discharge and intake TCH: Horizontal discharge and intake

Transcription

1 TCD-TCH 5-20 TR 50 Hz, TR 60 Hz Single circuit unit : sizes 06 and 07, Dual circuit unit : sizes 00 to 200, D-Scroll compressor for sizes 25 to 250, Internal protection of winding for fans and compressor(s), Crankcase heater on size 06 to 00, Direct drive outdoor axial fan : - fan : TCD/H 06 to 25, - 2 fans : TCD/H 50 to 250, Variable pulley-belt drive indoor centrifugal fan, Galvanised steel water-tight casing, Disposable filters supplied as standard. Self-contained rooftop unit VOAGER I and II range TCD: Downflow discharge and intake TCH: Horizontal discharge and intake Economizer for fresh air intake and free-cooling (comparative enthalpy control), Motorized hood 0-50% for fresh air intake, Electric heater, Field installed accessories : NEW : Remote potentiometer (for remote control of the motorized hood 0-50%), Fire thermostat, Roofcurbs (TCD only), Control : Control of the unit by microprocessor, Non-programmable electronic thermostat BASENS 00, Programmable electronic thermostat BASENS 09 (accessory). Interface for communication with Tracer- Tracker and supervisor Varitrac, CTI board to adapt to thermostats other than zone sensors. BASENS 00 BASENS 09 Outdoor air temperature - 8 C to + 46 C Min. intake temperature on the indoor coil + 8 C Model TC* ARI Gross Cooling Capacity (MBH) System Power (kw) Optional Electric Heater (kw) Compressor No./Type /Recip. /Recip. /Recip. 2/Recip. 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll Sound Rating (BELS) Drain Connection Number. 2 2 Drain Connection Size in. PVC PVC PVC NPT NPT NPT NPT NPT 2 NPT NPT NPT NPT NPT NPT Outdoor Fan No. Motors/HP /0.5 /0.5 /0.5 /0.75 /0.75 2/0. 2/0.75 2/0.75 2/0.75 2/0.5 2/0.5 2/.0 2/.0 2/.0 Indoor Fan HP Refrigerant Charge (lbs of R22) per circuit () with inlet air temperature of 27 C DB/9 C WB and outdoor temperature of 5 C. (2) Sound Ratings shown are tested in accordance with ARI standard 270 or 70. () Refrigerant charge is an approximate value. For a more precise value, see unit nameplate and service instructions. Dimensions : see page UN-PRC00-EN

2 CD-CH 5-20 TR, TR 60 Hz Gas-fired self-contained rooftop unit VOAGER I and II range CD: downflow discharge and intake CH : horizontal discharge and intake BASENS 00 BASENS 09 CD Heating mode Outside air temperature - 8 C to + 46 C - Min. inlet temperature on indoor coil + 8 C - on the burner C Single circuit unit : sizes 06 to 089, Dual circuit unit : sizes 00 to 200, D-Scroll compressor for sizes 25 to 250, Internal protection of windings for fans and compressor(s), Crankcase heater on size 06 to 00, Direct drive axial outdoor fan : - fan for sizes 06 to fans for sizes 50 to 250. Variable pulley-belt drive centrifugal indoor fan, Galvanised steel water-tight casing, Disposable filters supplied as standard. Characteristics of the GAS heating module : Burner with forced combustion blower, High efficiency (> 86%),. Gases used : natural gas. Option L.P. gas. Economizer for fresh air intake and freecooling (comparative enthalpy control), Motorized hood 0-50% for fresh air intake, Propane gas conversion, Field installed accessories : NEW : Remote potentiometer (for remote control of the motorized hood 0-50%), Fire thermostat, Roofcurbs (CD only), Controls : Control of unit by 24 V microprocessor, Non-programmable electronic thermostat BASENS 00, Programmable electronic thermostat BASENS 09. TC interface for communication with Tracer-Tracker and supervisor Varitrac CTI board to adapt to thermostats other than BASENS 00 or BASENS 09 Model C* ARI Gross Cooling Capacity (MBH) System Power (kw) Heating Output (MBH) First Stage (MBH) Steady State Efficiency (%) Gas Connection Pipe (in.) Compressor No./Type /Recip. /Recip. /Recip. 2/Recip. 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll Sound Rating (BELS) Drain Connection Number. 2 2 Drain Connection Size in. PVC PVC PVC NPT NPT NPT NPT NPT NPT NPT NPT NPT NPT NPT Outdoor Fan No. Motors/HP /0.5 /0.5 /0.5 /0.75 /0.75 2/0. 2/0.75 2/0.75 2/0.75 2/0.5 2/0.5 2/.0 2/.0 2/.0 Indoor Fan HP Refrigerant Charge (lbs of R22) per circuit () with inlet air temperature of 27 C DB/9 C WB and outdoor temperature of 5 C. (2) High output capacity. () Sound Ratings shown are tested in accordance with ARI standard 270 or 70. (4) Refrigerant charge is an approximate value. For a more precise value, see unit nameplate and service instructions. Dimensions : see page 58 LIGHT COMMERCIAL RANGE UN-PRC00-EN 7

3 WCD-WCH 5-20 TR Single circuit unit : sizes 06 and 07, Dual circuit unit : sizes 00 to 200, Internal protection of winding for fans and compressor(s), Crankcase heater on size 06 to 00, 4-way reversing valve, Direct drive outdoor axial fan : - fan : WCD-WCH 06 to 25-2 fans : WCD-WCH 50 to 250, Variable pulley-belt drive indoor centrifugal fan, Galvanised steel water-tight casing, Disposable filters supplied as standard. Economizer for fresh air intake and freecooling (comparative enthalpy control), Motorized hood 0-50% for fresh air intake, Electric heater, Washable filters, Field installed accessories : NEW : Remote potentiometer (for remote control of the motorized hood 0-50%), Fire thermostat, Roofcurbs (WCD only), Duct mounting CO2 sensor kit. Control : Control of the unit by microprocessor (24 V), Non-programmable electronic thermostat BASENS 09, Programmable electronic thermostat, Interface for communication with Tracer- Tracker and supervisor Varitrac, CTI board to adapt to thermostats other than BASENS 0 or BASENS 09. Self-contained rooftop unit VOAGER I and II range WCD: Downflow discharge and intake WCH: Horizontal discharge and intake BASENS 0 BASENS 09 Heating mode Outdoor air temperature - 8 C to + 46 C - 4 C to + 8 C Min. intake temperature on the indoor coil + 8 C + 0 C Model WC* ARI Gross Cooling Capacity (MBH) System Power kw Heating Output (MBH) System Power Heating (kw) Compressor No./Type /Recip. /Recip. 2/Recip. 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll 2/Scroll Sound Rating (BELS) Drain Connection No./Size in. / PVC / PVC / NPT / NPT / NPT 2/ NPT / NPT / NPT / NPT Outdoor fan No. Motors/HP /0.5 /0.5 /0.75 2/0. 2/0. 2/0.75 2/0.5 2/0.5 2/.0 Indoor Fan HP Refrigerant Charge (lbs of R22) per circuit () with inlet air temperature of 27 C DB/9 C WB and outdoor temperature of 5 C. (2) High output capacity. () Sound Ratings shown are tested in accordance with ARI standard 270 or 70. (4) Refrigerant charge is an approximate value. For a more precise value, see unit nameplate and service instructions. Dimensions : see page UN-PRC00-EN

4 TCD-TCH TED-TEH, CD-CH Voyager III TR CD BASENS 00 BASENS 09 TCD/TED : downflow discharge and intake TCH/TEH : horizontal discharge and intake TED/TEH : cooling only + electric heater CD/CH : Gas fired Heating mode Outdoor air temperature - 8 C to + 46 C - Min. inlet temperature on indoor coil + 8 C - on burner C 60 Hz 50 Hz General Date Model TC* ARI Gross Cooling Cap. (MBH) Heating Output (MBH) First Stage (MBH) Steady State Efficiency (%) No. Burners/No. Stages Gas Connection Pipe Size (in.) 2 Electric Heat Range (kw) Compressor No./Type 2/Scroll 2/Scroll 2/Scroll /Scroll /Scroll 2/Scroll 2/Scroll 2/Scroll /Scroll /Scroll Comp. Size (Nominal Tons) 0/ /5/0 4 0/5 5/5 5/5 5/5/0 5/5/5 Comp. Unit Cap. Steps (%) /50 00/50 00/600 00/67/ /50 00/50 00/600 00/67/ Outdoor Fan No Motors/HP /.0 /.0 /.0 4/.0 4/.0 /0.75 /0.75 /0.75 4/0.75 4/0.75 Indoor Fan Type/No. Used FC/ FC/ FC/ FC/ FC/ FC/ FC/ FC/ FC/ FC/ Indoor Fan Diameter (in) Indoor Fan Width (in) Indoor Fan Motor HP 7.5/0 7.5/0 7.5/0/5 0/5 0/ Filters Type Throwaway Throwaway Filters No. es/6 es/6 es/6 es/7 es/7 es/6 es/6 es/6 es/7 es/7 Filters Recommended Size (in) 6x20x2 6x20x2 6x20x2 6x20x2 6x20x2 6x20x2 6x20x2 6x20x2 6x20x2 6x20x2 Refrigerant Charge (lbs of R22) per circuit D-Scroll compressor, Internal protection of windings for fans and compressor(s), Direct drive axial outdoor fan : - fans for sizes and , - 4 fans for sizes and Variable pulley-belt drive centrifugal indoor fan (drive type selected with order). Economizer for fresh air intake and freecooling (comparative enthalpy control), Barometric relief or exhaust fan, Propane gas conversion (CD/CH), Washable filters, Hinged access doors, Coil guard for condenser, Field installed accessories (NEW) : Remote potentiometer (for remote control of the motorized hood 0-50%) Fire thermostat Roofcurbs (TCD, TED, CD only) Control : Control of unit by 24 V microprocessor, Non-programmable electronic thermostat BASENS 00, Programmable electronic thermostat BASENS 09 (accessory), Interface for communication with Tracer- Tracker and supervisor Varitrac, CTI board to adapt to thermostats other than BASENS 00 or BASENS 09. () Minimum Outside Air Temp. For Mechanical Cooling (F) (2) with inlet air temperature of 27 C DB/9 C WB and outdoor temperature of 5 C. () High output capacity. (4) Steady state efficiency is rated in accordance with DOE test procedures. (5) Refrigerant charge is an approximate value. For a more precise value, see unit nameplate and service instructions. Dimensions : see page 58 LIGHT COMMERCIAL RANGE UN-PRC00-EN 7

5 Impack (.5-5 TR) Model and size TCC/CC/WCC TCC/CC/WCC Dimensions () Length () (mm) 40 6 Width () (mm) Height () (mm) Clearance (A) (mm) 900 Clearance (B) (mm) 00 Clearance (C) (mm) 920 Clearance (D) (mm) 920 Clearance (E) (mm) 00 () A : condenser air outlet - B : condenser air inlet - C : maintenance (elec. pannel, gaz module ) - D : condenser air inlet - E : maintenance (economizer ) Shipping Weights Size Model TCC Model WCC Model CC TCD-TCH (7-60 kw 50 Hz, TR 60 Hz) C A B D E TC*80 TC*80 TC*20 TC*240 TC*00 Model and size TC*06 TC*07 TC*00 TC*25 TC*55 TC*75 TC*200 TC*250 Dimensions () Length () (mm) Width () (mm) Height () (mm) Clearance (A) (mm) 900 Clearance (B) (mm) Clearance (C) (mm) Clearance (D) (mm) Clearance (E) (mm) 00 Weight (2) (kg) () A : condenser air outlet - B : condenser air inlet - C : maintenance (elec. pannel, gaz module ) - D : condenser air inlet - E : maintenance (economizer ) 74 UN-PRC00-EN

6 TCD/TCH - TED/TEH (25-50 TR) Model and size TC 275/0 TC 00/60 TC 5020 TC TC 500/600 Model and size TE 275/0 TE 00/60 TE 5020 TE TE 500/600 Dimensions () Length () (mm) Width () (mm) Height () (mm) Clearance (A) (mm) 900 Clearance (B) (mm) 2440 Clearance (C) (mm) 220 Clearance (D) (mm) 220 Clearance (E) (mm) 80 Weight (2) TCD/TCH (kg) 584/ TED/TEH (kg) 599/ () A : condenser air outlet - B : condenser air inlet - C : maintenance (elec. pannel, gaz module ) - D : condenser air inlet - E : maintenance (economizer ). WCD-WCH (7-60 kw 50 Hz, TR 60 Hz) C A E B D Model and size WC 06 WC 07 WC 00 WC 25/50 WC 55/80 WC Dimensions () Length () (mm) Width () (mm) Height () (mm) Clearance (A) (mm) 900 Clearance (B) (mm) Clearance (C) (mm) Clearance (D) (mm) Clearance (E) (mm) 00 Weight (2) (kg) () A : condenser air outlet - B : condenser air inlet - C : maintenance (elec. pannel, gas module ) - D : condenser air inlet - E : maintenance (economizer ). LIGHT COMMERCIAL RANGE UN-PRC00-EN 75

7 CD-CH (7-62 kw 50 Hz and TR 60 Hz) Model and size Dimensions () Length () (mm) Width () (mm) Height () (mm) Clearance (A) (mm) 900 Clearance (B) (mm) Clearance (C) (mm) Clearance (D) (mm) Clearance (E) (mm) 00 Weight (2) (kg) () A : condenser air outlet - B : condenser air inlet - C : maintenance (elec. pannel, gaz module ) - D : condenser air inlet - E : maintenance (economizer ) CD-CH (27-50 TR) C A B D E 76 Model and size 275/0 L 00/60 L 5020 L 400 L 500 L Model and size 275/0 H 00/60 H 5020 H H 500/600 H Dimensions () Length () (mm) Width () (mm) 268 Height Clearance (A) (mm) 900 Clearance (B) (mm) 2440 Clearance (C) (mm) 220 Clearance (D) (mm) 220 Clearance (E) (mm) 80 Weight (2) CD (kg) CH (kg) () A : condenser air outlet - B : condenser air inlet - C : maintenance (elec. pannel, gaz module ) - D : condenser air inlet - E : maintenance (economizer ) UN-PRC00-EN