SYSCO CENTRAL PENNSYLVANIA, LLC. HARRISBURG, PENNSYLVANIA
|
|
- Todd Fox
- 5 years ago
- Views:
Transcription
1 SYSCO CENTRAL PENNSYLVANIA, LLC. HARRISBURG, PENNSYLVANIA July, 2018 Infrared Inspection Report Sysco Central Pennsylvania, LLC Corey Road Harrisburg, Pennsylvania, Company Contact Christopher Brooks Project: CHARTER OAK DRIVE, LITTLE ROCK, AR PHONE: & FAX:
2 ORDER OF REPORT CONTENTS 1: Data To Facilitate Understanding & Utilizing Scan Report 2: Scan Results Overview & Action Taken Form 3: Identified Faulting Conditions, Information & Photographs 4: List Of Facility Equipment Identified By The Customer Representative & Notations Of Faulting Conditions Found DISCLAIMER This report and the recommendations contained in it are based upon conditions and practices observed and information made available to United Spectrographics personnel. This report does not purport to list all hazards or faulty conditions. It is not intended to indicate that other hazards or faulty conditions do not exist. Severity ratings in the report are based on the criteria shown in this report and are intended as guidelines only. No responsibility is assumed for the control of the facility s condition, maintenance practices or correction of conditions indicated herein. By issuing this report, neither United Spectrographics nor any of its employees makes any warranty, expressed or implied, concerning the contents of this report. Furthermore, neither United Spectrographics nor any of its employees shall be liable in any manner (other than liability that may be expressed in any policy of insurance that may be issued by United Spectrographics) for personal injury or property damage or loss of any kind arising from or connected with this inspection or failure to inspect.
3 July 27, 2018 Sysco Central Pennsylvania, LLC. Attn: Christopher Brooks 3905 Corey Road Harrisburg, Pennsylvania Dear Mr. Brooks; During the course of our July 2018 Infrared Inspection of your facility s electrical equipment, no equipment indicating a faulty thermal signature was located at the Customer Harrisburg, Pennsylvania facility. Locating no faults is an unusual occurrence for us; we generally encounter only a small percentage of facilities a year with no faults. Your maintenance people appear to be doing an outstanding job. We greatly appreciated the opportunity to complete this project for you and look forward to the next one. If you have any questions concerning this infrared inspection, please call Sincerely, S Richard P. Lincourt United Spectrographics, LLC CHARTER OAK DRIVE, LITTLE ROCK, AR PHONE: & FAX: Logistics@usscanman.com
4 Utilizing Report Contents Included in this report are Photographs and Thermographs of problem areas found during our recent Infrared Inspection of your facility. Each problem area picture is accompanied by: Date Location Information Temperature Calculations Color-coded Temperature Intensity and/or Condition Significance Data A Brief Comment Relating The Item In The Photograph To Its Corresponding Thermograph Suggested Corrective Recommendations. In most cases, problems (faults) found will be listed according to the date and order that they were located, rather then by significance or priority, as we feel that you and/or your personnel can best judge this, keeping in mind circuit importance and thermograph intensity. Thermal intensity is indicated by use of a color-coded data inserts that locate a fault s position on the standard electrical failure curve. The color of the insert represents the temperature range of the hottest item, or a portion of the item's circuitry, pointed out in the thermograph. The temperature ranges which the colored inserts represent are grouped as follows: INSERT Red Orange Yellow Green Temperature Range 70ºC/126ºF and higher above Ambient Operating Temp. 40ºC/72ºF to 69ºC/124ºF above Ambient Operating Temp. 25ºC/45ºF to 39ºC/70ºF above Ambient Operating Temp. *10ºC/18ºF to 24ºC/43ºF above Ambient Operating Temp. ( * See page 4)
5 Determining Cost Effective Responses Electrical equipment failures generally follow a standard mechanical/electrical failure curve. Dividing the failure curve into temp. ranges and locating a problems position on the curve allows us to indicate the probable time to its failure. Knowing a problems probable time to failure allows you to make a cost effective response to the problem areas that we locate. Below is a depiction of the electrical fault failure curve with the thermal intensity ranges and the colors that we assign to faults detailed in our reports. STANDARD ELECTRICAL FAULT FAILURE CURVE (Does Not Include Area In Blue) MINOR INTERMEDIATE SERIOUS CRITICAL DEVICE TEMP IS AMBIENT, BUT DEVICE IS EITHER FAULTY OR UNSAFE. 10ºC * 18ºF 25ºC 45ºF 40 C 72ºF 70 C 126ºF AMBIENT TEMP YEARS MONTHS MONTHS TO WEEKS WEEKS TO NOW FAULTY EQUIP Built In Trend Monitoring When yearly scans are accomplished, report results allow you to trend monitor your electrical equipment without having to cross reference previous report findings. If a previous years problem is not repaired it will show up again in the current scan report and its current intensity range indicates a current effective response.
6 Defining Total Temperature and Ambient Operating Temperature And Explanation For Their Use Total Temperature: Total Temperature = Ambient Operating Temperature + Fault temperature Allows you, the customer, to evaluate possible damage to equipment. Leads fail between 90ºC/194ºF and 110ºC/230º Phenolic fails around 200ºC/392ºF Transformers and Motor Insulation failure temperature depends on insulation class rating. Contacts start to fail around 130ºC/266ºF Ambient Operating Temperature (AOT*) for Infrared Scanning Purposes: Temperature within a device container (Box or Cabinet) that is not directly affected by faulting component = Normal Equipment Operating Temperature Contained By Box or Cabinet. If there is no container (Example: Device mounted to a wall) it is the temperature adjacent to the device not affected by the fault. Allows you, the customer, to determine if device will operate at intended amperage. Most switchgear is rated to operate at approximately 40ºC/104ºF (Industrial) to 50ºC/122ºF (Marine) If AOT is enough above normal rated temperature, either of the following conditions can cause an unanticipated trip. 1. An intermittent high load. 2. A minor (Green) or intermediate (Yellow) fault. Report pages with photographs: PH stands for Visible Light Photograph TH stands for Infrared Light Thermograph *AOT stands for Ambient Operating Temperature Both black & white and color infrared thermographs are presented to better depict the fault condition.
7 In addition to the corrective response time frame suggested below and the failure curve located on the previous page, you may want to consider using the military standard responses presented below. Military Standard For Evaluating Faults Located In Electrical Equipment Utilizing Temperature Data Obtained With Infrared Imaging Equipment: Temperatures rise above Ambient Operating Temperature: *10ºC/18ºF to 24ºC/43ºF component failure unlikely, but corrective measures required at next scheduled routine maintenance period or as scheduling permits. (Green Label) 25ºC/45ºF to 39ºC/70ºF component failure probable, unless corrected. (Yellow Label) 40ºC/72ºF to 69ºC/124ºF component failure almost certain, unless corrected. (Orange Label) 70ºC/126ºF and above component failure imminent. Immediately inform the person responsible for continued operation of equipment. (Red Label) Note: United Spectrographics uses a Blue Label to indicate faults that require attention due to either ambient temperature (Ex: Phase Not Operating), faulty equipment elements or unsafe conditions. * Note: Temperature conditions below 10ºC/18ºF rise above AOT are not considered significant enough to record and are usually not included in the reports unless the fault temperature is being affected by a cooling medium such as oil or wind. Fault Correction Recommendation When Our Source Assessment Is Inaccurate: When a fault is indicated in a connection or component and examination by your electrician does not turn up a loose connection or faulty component where we have indicated, a fault does exist. The electrician should continue to investigate the next connection or component to be found in the direction that the heat is coming from until a source is located. Example: If a molded case breaker line side lead connection lug is indicated as a fault source and is found to be secure, but not frozen in place, look for a loose connection or sign of over temp. in the lead holder lug.
8 SCAN RESULTS OVERVIEW PROMPT ATTENTION ITEMS: Because of: 1. The intensity or heat level indicated at the time of the scan. 2. Deterioration caused by excessive temperature not present at the time of the scan. 3. Physical condition irregularities observed at the time of the scan. We recommend that the following faults be given prompt attention: Faults: No Faults Found Items With Asterisks Have High Total or Ambient Operating Temperatures. United Spectrographics July, 2018
9 SUMMARY OF FINDINGS FAULTS BY CATEGORY NUMBER OF FAULTS FAULT NO./ITEM NO. MINOR 0 0 INTERMEDIATE 0 0 SERIOUS 0 0 CRITICAL 0 0 SERIOUS 0 0 Number of items located at facility: 143 Number of faults: 0
10 ACTION TAKEN Sysco Central Pennsylvania, LLC. Harrisburg, Pennsylvania July, 2018 None Required
11 AREA/EQUIPMENT LIST Following is a list of the electrical equipment located at the Sysco Central Pennsylvania, LLC., Harrisburg, PA, facility and data relating to its operating condition at the time the scan was performed. NOTE: Items noted as visually inspected were not operational or show no visible load at the time of the inspection. No. Equipment Operating Visually Inspected EQUIPMENT LIST COMPRESSOR ELECTRICAL ROOM GE Switchgear Section 1 Fault # 1 Panel HA X 2 New Ice Cream Room Evap X 3 Panel HDC X 4 BHI X GE Switchgear Section 2 5 Comp 1 X 6 Panel H8 X 7 Comp 3 X 8 Comp 4 X GE Switchgear Section 3 9 Panel H6 X 10 VFD Panel Refrig MCC X 11 Panel HDB X 12 Elevator X 13 Panel H7 X GE Switchgear Section 4 14 Spare 15 Comp 2 X 16 Panel HAD X 17 Comp 5 X GE Switchgear Section 5
12 No. Equipment Operating Visually Inspected 18 Panel HDB X Fault # 19 Buss Duct X GE Switchgear Section 6 20 Main Shutoff X GE Switchgear Section 7 21 Terminal Connections X 22 C1 Outside Lighting Contactor X 23 C2 Outside Lighting Contactor X 24 HDA 480/277 Volt Distribution Panel X 25 H-5 480/277 Volt Distribution Panel X 26 H-4 480/277 Volt Distribution Panel X 27 L-4 208/120 Volt Distribution Panel X 28 RMCC Panel (4 Doors) X COMPRESSOR ROOM 29 #1 Compressor Control Cabinet X 30 #2 Compressor Control Cabinet X 31 #3 Compressor Control Cabinet X 32 #4 Compressor Control Cabinet X 33 #5 Compressor Control Cabinet X 34 Refrigeration Control Panel X 35 Water Treatment Combination Starter X 36 FC02 Air Compressor Control Cabinet X 37 FC02 Air Compressor Disconnect X 38 Jockey Pump Controller X 39 Electric Fire Pump Controller X 40 Jockey Pump Disconnect X 41 High Temperature Fan Combination Starter X TANK ROOM
13 No. Equipment Operating Visually Inspected 42 H-7 480/277 Volt Distribution Panel X 43 L-7 208/120 Volt Distribution Panel X KVA GE 3ø Transformer X 45 C-4 Lighting Contactor X 46 C-5 Lighting Contactor X 47 C-6 Lighting Contactor X GENERATOR ROOM 48 PPL Electric Switchgear Section 1 Main 3000 Amp Switch X 49 PPL Electric Switchgear Section 2 Terminal Connections X 50 PPL Electric Switchgear Section 3 Terminal Connections (PPL Sealed) 51 Building Electric Switchgear Section 1 Main 3000 Amp Switch 52 Building Electric Switchgear Section 2 Automatic Transfer Switch 53 Building Electric Switchgear Section 3 Terminal Connections 54 Unlabeled 208/120 Volt Distribution Panel X WILL CALL 55 Unlabeled 60 Amp GE Fuse Disconnect X KVA GE 3ø Transformer (On Roof of Office) X 57 WC-1 208/120 Volt Distribution Panel X MAINTENANCE AREA X X X Didn t Scan 58 TPJ Panel 208/120 Volt Distribution Panel X KVA Square D 3ø Transformer X KVA Square D 1ø Transformer X 61 L /120 Volt Distribution Panel X ELECTRICAL CLOSET (Behind Break Room) 62 H-6 480/277 Volt Distribution Panel X 63 Unlabeled 400 Amp Molded Case Breaker X 64 L /120 Volt Distribution Panel X Fault #
14 No. Equipment Operating Visually Inspected 65 L-10A 208/110 Volt Distribution Panel X Fault # KVA GE 3ø Transformer X 67 HDB 480/277 Volt Distribution Panel X 68 Water Heater Control Cabient X 69 L-11 (Water Heater) Disconnect X DRY DOCK DOCK DOOR #14 70 Overhead 45 KVA GE 3ø Transformer X 71 H-9 Section 1 480/277 Volt Distribution Panel X 72 H-9 Section 2 480/277 Volt Distribution Panel X 73 L-9 208/120 Volt Distribution Panel X 74 C-A1A Lighting Contactor X 75 C-A2A Lighting Contactor X 76 C-A3A Lighting Contactor X 77 C-B1A Lighting Contactor X 78 C-B2A Lighting Contactor X NEAR STAIRWELL AREA 79 L-1A 208/120 Volt Distribution Panel X 80 L-1 208/120 Volt Distribution Panel X KVA GE 3ø Transformer X HUB AREA 82 H-1 480/277 Volt Distribution Panel X 83 HDAA 208/120 Volt Distribution Panel X 84 A-1 Lighting Contactor X 85 A-2 Lighting Contactor X 86 A-3 Lighting Contactor X 87 B-1 Lighting Contactor X 88 B-2 Lighting Contactor X
15 No. Equipment Operating Visually Inspected COOLER DOCK HUB AREA 89 H-2 480/277 Volt Distribution Panel X 90 L-2 208/120 Volt Distribution Panel X KVA GE 3ø Transformer X 92 L-2A 208/120 Volt Distribution Panel X 93 C-1 Lighting Contactor X 94 C-2 Lighting Contactor X 95 C-3 Lighting Contactor X 96 D-1 Lighting Contactor X 97 D-2 Lighting Contactor X 98 D-3 Lighting Contactor X 99 E-1 Lighting Contactor X 100 E-2 Lighting Contactor X ACROSS FROM DOCK DOOR #61 AREA 101 H-8 480/277 Volt Distribution Panel X 102 L-8 208/120 Volt Distribution Panel X 103 Overhead GE 3ø Transformer X 104 D-4 Lighting Contactor X 105 D-5 Lighting Contactor X 106 D-6 Lighting Contactor X 107 E-3 Lighting Contactor X 108 E-4 Lighting Contactor X 109 Unlabeled Contactor X OFFICE AREA ELEVATOR EQUIPMENT ROOM 110 Elevator Control Cabinet X 111 Elevator Fuse Disconnect X 112 Cab Lights Fuse Disconnect X Fault #
16 No. Equipment Operating Visually Inspected UPSTAIRS ELECTRICAL CLOSET Fault # 113 1L1 Section 1 208/120 Volt Distribution Panel X 114 1L1 Section 2 208/120 Volt Distribution Panel X kVA Transformer Fuse Disconnect X KVA GE 3ø Transformer X 117 L-3 208/120 Volt Distribution Panel X 118 H-3 480/277 Volt Distribution Panel X 119 HDC 480/277 Volt Distribution Panel X 120 (Left) 45 KVA GE 3ø Transformer X 121 (Right) 45 KVA GE 3ø Transformer X COMPUTER ROOM 122 UL1 208/120 Volt Distribution Panel X 123 UL2 208/120 Volt Distribution Panel X 124 UL3 208/120 Volt Distribution Panel X 125 UPS Control Cabinet X 126 UPS Feed Fuse Disconnect X JANITOR CLOSET 127 1L2 208/120 Volt Distribution Panel X UPSTAIRS SECURITY CLOSET 128 L-11 Section 1 208/120 Volt Distribution Panel X 129 L-11 Section 2 208/120 Volt Distribution Panel X 130 L-11 Section 3 208/120 Volt Distribution Panel X KVA GE 3ø Transformer X TEST KITCHEN 132 K-1 208/120 Volt Distribution Panel X 133 K-2 208/120 Volt Distribution Panel X TRUCK PARKING (Did not scan due to insects and company pesticides policies)
17 No. Equipment Operating Visually Inspected 134 BH1 480/277 Volt Distribution Panel X 135 BH2 208/120 Volt Distribution Panel X KVA GE 3ø Transformer (Near Space #103) Didn t Scan KVA GE 3ø Transformer (Near Space #105) Didn t Scan KVA GE 3ø Transformer (Near Space #199) Didn t Scan KVA GE 3ø Transformer (Near Space #303) Didn t Scan KVA GE 3ø Transformer (Near Space #318) Didn t Scan TRUCK SHED 141 Unlabeled 480/277 Volt Distribution Panel X 142 Unlabeled 208/120 Volt Distribution Panel X KVA GE 3ø Transformer X Fault #
ARAMARK CLEANROOM SERVICES LOS ANGELES, CALIFORNIA
ARAMARK CLEANROOM SERVICES LOS ANGELES, CALIFORNIA March, 2013 Infrared Inspection Report Aramark Cleanroom Services MC#513 Company Contact Emmanuel Rojas Project: 07060313 2605 CHARTER OAK DRIVE, LITTLE
More informationNLR ELECTRIC MURRAY HYDRO PLANT NORTH LITTLE ROCK, ARKANSAS
NLR ELECTRIC MURRAY HYDRO PLANT NORTH LITTLE ROCK, ARKANSAS January, 2013 Infrared Inspection Report NLR Electric Murray Hydro Plant Company Contact James Bray Project: 09170113 2605 CHARTER OAK DRIVE,
More informationPAVESTONE COMPANY MIDDLEBORO, MASSACHUSETTS
PAVESTONE COMPANY MIDDLEBORO, MASSACHUSETTS October, 2015 Infrared Inspection Report Pavestone Company Company Contact Greg Swider Project: 04161015 2605 CHARTER OAK DRIVE, LITTLE ROCK, AR 72227 PHONE:
More informationSIDEWINDER DRILLING RIG 107 HOUSTON, TEXAS
SIDEWINDER DRILLING RIG 107 HOUSTON, TEXAS January, 2017 Infrared Inspection Report Sidewinder Drilling Rig 107 Lufkin, Texas Company Contact: Jesse Russell Project: 06050117 2605 CHARTER OAK DRIVE, LITTLE
More informationBIMBO BAKERIES USA ROSEVILLE, MINNESOTA
BIMBO BAKERIES USA ROSEVILLE, MINNESOTA June, 2018 Infrared Inspection Report Bimbo Bakeries USA 2745 Long Lake Road Roseville, Minnesota, 55113 Company Contact: Kirk Clermont Project: 04140618 2605 CHARTER
More informationBIMBO BAKERIES USA ALBANY CAKE ALBANY, NEW YORK
BIMBO BAKERIES USA ALBANY CAKE ALBANY, NEW YORK August, 2018 Infrared Inspection Report Bimbo Bakeries USA Albany Cake 78 North Manning Boulevard Albany, New York, 12206 Company Contact: Steve Gauck Project:
More informationInfrared Electrical Inspection Report
Infared Inspections * Switchgear Testing & Cleaning Vibration Analysis * Arc Flash Hazard Analysis & Training SAMPLE REPORT Company Address City, ST 12345 Inspected on: 9/29/2016 Infrared Electrical Inspection
More informationELECTRICAL/MECHANICAL INFRARED INSPECTION REPORT. The Corporate Facility 2001 Freedom Way United City, USA
ELECTRICAL/MECHANICAL INFRARED INSPECTION REPORT for The Corporate Facility 2001 Freedom Way United City, USA January 01, 2012 Job Number: 1111-12 TABLE OF CONTENTS I - Introduction to the Report Explains
More informationStockton Infrared Thermographic Services, Inc. presents. A Qualitative Infrared Thermographic Survey Of Electrical Switchgear at the facilities of
Stockton Infrared Thermographic Services, Inc. presents A Qualitative Infrared Thermographic Survey Of Electrical Switchgear at the facilities of Stockton Infrared Thermographic Services, Inc. 8472 Adams
More informationElectrical Preventive Maintenance (EPM) Program
Electrical Preventive Maintenance (EPM) Program Only qualified and properly trained persons may work on electric circuit parts or equipment. Such persons shall be capable of working safely and shall be
More informationElement D Services Electrical
PART 1 - GENERAL 1.01 OVERVIEW A. This Section includes design standards and requirements for electrical service and distribution. This is a design standard and is not intended to be used as a Specification.
More informationSample Infrared Report Company Address Line 2
Line 1 Line 2 Date: March 13, 2014 Prepared for: Customer Name Company Name Customer/ Line 1 Customer/ Line 2 Prepared By: SDM METRO Employee, Thermographer Engineer March 13, 2014 SDM METRO 220 Maple
More informationEBAC MODEL AD850 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL
EBAC MODEL AD850 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL Ebac Industrial Products 704 Middle Ground Boulevard Newport News VA 23606 Telephone (757) 873-6800 FAX (757) 873-3632 Website: www.ebacusa.com INTRODUCTION
More informationSTER 1981 ANNUAL INDUSTRIAL SUMMARY OF FIRE AND PROPERTY DAMAGE EXPERIENCE. Monsanto. MOUND FACILITY Miemisburg. Ohio MLM.ML
DISCLAIMER This report was prepared as an account of work sponsored by an agency of the United States Government. Neither the United States Government nor any agency thereof, nor any of their employees,
More informationEnhancing Current Maintenance Practices 04. Managing the Risk 06. Constant Monitoring of Electrical Enclosures 08
2 Table of Contents Enhancing Current Maintenance Practices 04 Managing the Risk 06 Constant Monitoring of Electrical Enclosures 08 Delta T Alert A Simple Device with Staggering Results 10 An Easy Way
More informationMachinery Room Electrical Best Practices
Machinery Room Electrical Best Practices Brad Heeres Angus-Young Associates February 8, 2007 Understand and comply with applicable codes and standards The National Electrical Code requirements for a safe
More informationBrown University Revised June 29, 2012 Facilities Design & Construction Standards SECTION ELECTRICAL DESIGN CRITERIA
PART 1 - GENERAL 1.1 Background SECTION 26 00 10- ELECTRICAL DESIGN CRITERIA A. Brown University maintains it own campus electrical distribution system which serves the majority of the buildings and facilities
More informationFreeze Protection Thermostat TRACON MODEL GPT 3 Installation and Operation Manual
MANUAL We manage heat Freeze Protection Thermostat TRACON MODEL GPT 3 Installation and Operation Manual Environmental Technology, Inc. 1850 N Sheridan Street South Bend, Indiana 46628 http://www.networketi.com/
More informationASSESSING THE HIDDEN DANGERS IN YOUR INDUSTRIAL CONTROL PANELS
Schneider Electric NEC 409.2 January 15, 2008 ASSESSING THE HIDDEN DANGERS IN YOUR INDUSTRIAL CONTROL PANELS by Grant Van Hemert, P.E., application engineer, Water and Wastewater Competency Center, Schneider
More informationTechnical II Report Electrical Systems
Technical II Report Electrical Systems Kelly Chan Consultant: Prof T. Dannerth, P.E. Part A Drawings Drawings needed for single-line diagram EE1.01 title sheet (electrical drawings) EE2.09 penthouse/roof
More informationInstallation Instructions
50ES---A, 50EZ---A, 50VL---A, 50VG---A, 50VR---A, 50VT---A, 604D--- ---A, 607C--- ---A, 607E,--- ---A, 704D--- ---A, 707C--- ---A, 707E--- ---A PA3G --- --- A, PH3G --- --- A SMALL PACKAGED PRODUCTS Electric
More informationInstallation Instructions
EHNA Electric Heaters 5-20kW For 60 Hz Small Packaged Products MODELS: PAD3, PHD3, PAD4, PHD4, PAD5, PHD5, WPA3, WPH3 Installation Instructions NOTE: Read the entire instruction manual before starting
More informationThermography Inspection SAMPLE REPORT
1 (15) 2014-07-22 INFORMATION Inspection Site Information Customer Address Contact person Phone number E-mail address Thermographer Thermal inspection conducted on all functioning plant equipment prior
More informationRev Pulse Modulating Anti- Sweat Control (PMAC II) Installation and Operation Manual
026-1501 Rev 5 3-20-03 Pulse Modulating Anti- Sweat Control (PMAC II) Installation and Operation Manual 1640 Airport Road, Suite 104 Kennesaw, GA 31044 Phone: (770) 425-2724 Fax: (770) 425-9319 ALL RIGHTS
More informationSurna 25-Ton Chiller Operating & Maintenance Manual
www.surna.com 303.993.5271 Surna 25-Ton Chiller Operating & Maintenance Manual Models: 300F3-3. 300F4-3, 300FW-3 Revised: July 2015 Table of Contents Warranty Information 4 Limited Warranty 4 Limitation
More informationMODEL REO-1620SE ELECTRIC RETHERMALIZER OPERATING INSTRUCTIONS
MODEL REO-1620SE ELECTRIC RETHERMALIZER OPERATING INSTRUCTIONS 302 Spencer Lane P.O. Box 5369 San Antonio, Texas 78201 (800) 525-8130 (210) 731-5000 FAX: (210) 731-5099 PREFACE This manual was written
More informationTECHNICAL SERVICE DEPARTMENT Technical Service Bulletin Heat Pump Water Heater (Generation 4) Troubleshooting (Effective 1 Nov 2016)
No Power,, Fan or Compressor Nothing happens at all. No compressor motor; no fan; no display. 1. See use and care manuals to turn unit ON and set operating MODE. 2. Check for the presence of power at the
More informationEQUIVALENT INITIAL ELECTRICAL SAFETY ASSESSMENT
EQUIVALENT INITIAL ELECTRICAL SAFETY ASSESSMENT Factory Assessor: Thakurbari TEAC, Masumabad, Bhulta, Rupganj, Narayangonj Rupgonj Uttaron 18 Nov 2013 The Alliance for Bangladesh Worker Safety Page 1/12
More informationInstallation Instructions
50ES--A, 50EZ--A, 50VG--A, B, 50VL--A, B, 50VR--A, 50VT--A, B 604D-- --A, 607C-- --A, B, 607E-- --A, 704D-- --A, 707C-- --A, B, 707E-- --A PA3G -- -- A, PH3G -- -- A, PA4G, PH4G PAD3, PHD3, PAD4, PHD4,
More informationMODEL HDM-4 AND HDM-6 PERFECT HOLD DELI CASE INSTALLATION/OPERATION MANUAL
An American Tradition Since 1954! MODEL HDM-4 AND HDM-6 PERFECT HOLD DELI CASE INSTALLATION/OPERATION MANUAL Be sure ALL installers read, understand, and have access to this manual at all times. Broaster,
More informationStudent Services & Classroom Addition. A. Section includes distribution panelboards and lighting and appliance branch-circuit panelboards.
SECTION 262416 - PANELBOARDS PART 1 - GENERAL 1.1 SUMMARY A. Section includes distribution panelboards and lighting and appliance branch-circuit panelboards. 1.2 PERFORMANCE REQUIREMENTS A. Seismic Performance:
More informationCPX MEDICAL AIR PLANT INSTALLATION, OPERATIONS & MAINTENANCE MANUAL
CPX MEDICAL AIR PLANT INSTALLATION, OPERATIONS & MAINTENANCE MANUAL Company Registered Office: Crown House, Stockport, Cheshire, SK13RB No. 850 Registered in England and Wales No. 05058855 VAT VERSION
More informationDelta T Alert: Wireless Temperature Monitoring of Electrical Enclosures
Delta T Alert: Wireless Temperature Monitoring of Electrical Enclosures Fred Baier, Level III Certified Infrared Thermographer Delta T Engineering, LLC 136 Main Street Metuchen, NJ 08840 Ph: 877-321-0576
More informationEnergy-Saving Demand Ventilation System
Energy-Saving Demand Ventilation System Installation, Operation and Maintenance Manual Your Password Protection Code is: 0000 Commercial Kitchen Ventilation Products CONTENTS OVERVIEW...... 3 Energy Saving...
More informationSpa Control System OWNER S MANUAL
LIMITED WARRANTY ONE YEAR LIMITED WARRANTY: UNITED SPAS, INC. warrants, to the original purchaser, the Spa Equipment against defects in materials or workmanship for a period of one year from date of purchase.
More informationIntegra Family. Operations Manual. Models: Integra TX SS, Integra HD, Integra DS, Integra DS LA, Integra UHS, Machine Name: Serial Number:
Integra Family GREEN CIRCLE CERCLE VERT Operations Manual Models: Integra TX SS, Integra HD, Integra DS, Integra DS LA, Integra UHS, Machine Name: Date of Purchase: Serial Number: Service Center Number:
More informationOPERATION AND MAINTENANCE INSTRUCTIONS FOR ROOF TOP HEAT PUMPS AND CEILING PLENUMS
OPERATION AND MAINTENANCE INSTRUCTIONS FOR ROOF TOP HEAT PUMPS AND CEILING PLENUMS RV Products A Division of Airxcel, Inc. P.O. Box 4020 Wichita, KS 67204 1976H207 (10-06) PP TABLE OF CONTENTS I. General
More informationResidential * Commercial * Mobile Homes * New Construction
January 9, 2016 Mr. & Mrs. Smith RE: Lutz, FL 33549 Dear Mr. & Mrs. Smith: At your request, and in your presence or in your realtors presence, a visual inspection of the above referenced property was conducted
More informationAprilaire Dehumidifier Troubleshooting Manual Models 1830 & 1850
Aprilaire Dehumidifier Troubleshooting Manual Models 1830 & 1850 Table of Contents Troubleshooting Diagnostic Codes... 2 E1, E2... 2 E3, E4... 3 E5, E6 & E7... 7 E8... 8 E9 9 Verifying Capacity... 10 Water
More informationProduct Information and Technical Guide
Product Information and Technical Guide Side by Side and Top Mount Refrigerators July 2003 - December 2003 White-Westinghouse 5995540384 January 2004 TABLE OF CONTENTS Safe Servicing Practices ------------------------------------------------------------------------------------------
More informationUnderwood Heater Installation Manual
Underwood Heater Installation Manual Contents Important Safeguards and Warnings... 3 1 General Information... 3 1.1 Use of the Manual... 3 1.2 Safety Guidelines... 3 1.3 Remember to measure resistance...
More informationA. Section includes distribution panelboards and lighting and appliance branch-circuit panelboards.
SECTION 262416 - PANELBOARDS PART 1 - GENERAL 1.1 SUMMARY A. Section includes distribution panelboards and lighting and appliance branch-circuit panelboards. 1.2 PERFORMANCE REQUIREMENTS A. Seismic Performance:
More informationProperty risk solutions
Property risk solutions Inside this issue Welcome to this edition of the Property risk solutions newsletter. This quarterly publication focuses on fixed fire protection and human element safety solutions
More informationTypical Installation Breaker Box Class A 50 amp, 120/240 volt, GFCI
READ THIS FIRST!!!! TYPICAL GFCI INSTALLATION GUIDELINES ATTENTION ELECTRICIAN: All PDC Spa Units must be installed with an approved G.F.C.I. in accordance with all applicable codes. Installation of G.F.C.I.
More informationOperator s Manual. IP-100 Immersion Probe Cooler
Operator s Manual IP-100 Immersion Probe Cooler 110-810 04.27.11 Table of Contents Introduction... 3 General Information... 3 General Safety Information... 3 Safety Recommendations... 4 Unpacking Your
More informationKRSCP Self-Contained Walk-In Unit Installation and Service Manual Addendum
KRSCP Self-Contained Walk-In Unit Installation and Service Manual Addendum P/N 1H52918001_B Version 1.1 May 2011 P/N_1H52918001_B P/N 1H52918001_B iii TABLE OF CONTENTS I. Overview.....................
More informationINSTALLATION AND OPERATING INSTRUCTIONS. For Reliance Controls Emergency Power Transfer Switch Kit Model Number 30216BRK
INSTALLATION AND OPERATING INSTRUCTIONS For Reliance Controls Emergency Power Transfer Switch Kit Model Number 30216BRK Congratulations on your purchase of the Reliance Controls Generator Power Transfer
More informationSeries: MBC1-TC Mini Benchtop Temperature Controller
User s Guide Series: MBC1-TC Mini Benchtop Temperature Controller Imagine Instruments LLC:: 4500 Williams Drive, Ste 212-318 :: Georgetown, TX 78633 :: p. 855.574.6243 e-mail: info@imagineinstruments.com
More informationInstallation and Operation Manual. 445 Procedures Cart. Page 3. Page 5. Page 8. Page 10. Important Information Page 2. Installation.
Important Information Page 2 Installation and Operation Manual 445 Procedures Cart Installation Page 3 Description Page 5 Components Overview Page 6 Controls & Indicators Page 7 Operation Page 8 HOT Operator
More informationPM100/PM100E PLANTER MONITOR. Operator s Manual
PM100/PM100E PLANTER MONITOR Operator s Manual TABLE OF CONTENTS Safety Notices... 1 Introduction... 3 System Overview... 3 Installation... 5 Console Mounting... 5 Monitor and Power Connections... 5 Console
More informationUser s Manual. TIGER S EYE E-Series Mark V Jockey. TIGERFLOW Systems, Inc Mint Way Dallas, Texas
User s Manual TIGER S EYE E-Series Mark V Jockey TIGERFLOW Systems, Inc. 4034 Mint Way Dallas, Texas 75237 214-337-8780 www.tigerflow.com TABLE OF CONTENTS Introduction... 4 Sequence of Operation... 5
More informationUHIR Series. Horizontal or Vertical Mounting Industrial / Commercial Electric Unit Heater. Owner s Manual
UHIR Series Horizontal or Vertical Mounting Industrial / Commercial Electric Unit Heater Owner s Manual This manual covers installation, maintenance and repair parts. Read carefully before attempting to
More informationMulti-Technology Fault Identification
Multi-Technology Fault Identification By: Reggie Fett, MCA/IR Analyst Industry: Food and Beverage Component: Motor Technology: On-line MCA (Initially) Part: Electrical Connections Time Context Tuesday,
More informationEnergy consumption storage facilities examined in ICE-E
Energy consumption storage facilities examined in ICE-E August 2012 Edited by Lars Reinholdt Danish Technological Institute = ICE-E Audit report 1 Contents EXECUTIVE SUMMARY 3 INTRODUCTION 4 THE ISSUES
More informationIEEE Transformer Committee PC Distribution Transformer Monitoring - User
IEEE Transformer Committee PC57.167 Distribution Transformer Monitoring - User Mark Scarborough Electrical Engineering Consultant DuPont January 9, 2019 Transformer Types in DuPont Control power Dry-type
More informationELECTRICAL PANEL SAFETY ALERT I N S T I T U T E
ELECTRICAL PANEL SAFETY ALERT CONSUMER SAFETY I N S T I T U T E Dangerous Panels brochure.indd 1 9/29/08 11:41:48 AM The Electrical Panel The Heart of a Home s Electrical System The home s electrical system
More informationThe Baked Food Company
The following report is prepared and published by: 7 CORPORATE BLVD. SINKING SPRING, PA 19608 USA T: 610-678-5890 F: 610-693-6262 www.readingthermal.com The Baked Food Company Leesport, PA. USA OVEN SAFETY
More informationSilicone Rubber Heating Tape with Adjustable Thermostat Control (HSTAT Series) Instruction Manual
Silicone Rubber Heating Tape with Adjustable Thermostat Control (HSTAT Series) Instruction Manual Read and understand this material before operating or servicing these heating tapes. Failure to understand
More information(HSTAT Series) Instruction Manual
Silicone Rubber Heating Tapes with Adjustable Thermostat Control (HSTAT Series) Instruction Manual Read and understand this material before operating or servicing these heating tapes. Failure to understand
More informationInfrared quartz heater
Infrared quartz heater User manual English...2 USA Introduction Infrared quartz heater Introduction Congratulations! You have made an excellent choice with the purchase of this quality Easy Home product.
More informationIntroduction... 1 System Overview... 1 System Diagram... 2
TABLE OF CONTENTS Introduction... 1 System Overview... 1 System Diagram... 2 Installation... 3 Console Mounting... 3 Monitor And Power Connections... 3 ASM II Console Main Harness... 4 Module Mounting...
More informationHorizontal Bottle Cooler Installation and Operation Manual
Speeds Up the Pace of Innovation Horizontal Bottle Cooler Installation and Operation Manual Please read this manual completely before attempting to install or operate this equipment! TBC-50SD, 50SB/ TBC-95SD,
More informationNFPA 70E Arc Flash Considerations for MV Equipment. By: Dominik Pieniazek, P.E. HV Engineering, LLC
NFPA 70E Arc Flash Considerations for MV Equipment By: Dominik Pieniazek, P.E. dominik@hv-eng.com HV Engineering, LLC http://sites.ieee.org/houston/ Full link for PDF copies of presentations: http://sites.ieee.org/houston/communities/ie
More informationUnderstanding NFPA, NEC 2005 Article 409 a White Paper by Paul A. Terry, P.E.
a White Paper by Paul A. Terry, P.E. NFPA 70, NEC 2005: Article 409 Industrial Control Panel Short Circuit Panel Ratings Executive Summary Many panel shops are providing industrial control panels with
More informationInstallation/Instruction Manual
1510876HC8902 Pressurized ventilators (for device cooling) Model Blade diameter (cm) Indoor or outdoor EF-20UYS-UL EF-25UAS-UL EF-30UBS-UL 20 25 30 Indoor Installation/Instruction Manual For customers
More informationINITIAL ELECTRICAL ASSESSMENT REPORT (EAR)
INITIAL ELECTRICAL ASSESSMENT REPORT (EAR) Factory Assessor: 5th floor, Ehasan Tower, 227/B, Hafez Nagar, Bakalia, Chittagong. Uttaron 22 Jul 2014 The Alliance for Bangladesh Worker Safety Page 1/19 Factory
More informationEBAC MODEL CD425 ( ) INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL
EBAC MODEL CD425 (1018110) INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL Ebac Industrial Products, Inc. 700 Thimble Shoals Blvd, Suite 109 Newport News, VA. 23606-2575 Tel: (757) 873 6800 Fax: (757) 873 3632
More informationAprilaire Dehumidifier Troubleshooting Manual Models 1830, 1850, 1870
Aprilaire Dehumidifier Troubleshooting Manual Models 1830, 1850, 1870 Table of Contents Troubleshooting Diagnostic Codes... 2 E1... 2 E2, E3... 3 E4.4 E5, E6... 7 E7, E8... 8 E9.9 Verifying Capacity...
More informationEBAC MODEL BD-150 ( ) INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL
EBAC MODEL BD-150 (1025000) INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL BD-150 OWNERS MANUAL Page 1 of 12 INTRODUCTION Designed for a wide range of applications, the BD-150 dehumidifier is a super high capacity
More information18E ELECTRIC FAN HEATER
18E ELECTRIC FAN HEATER MODEL 18E-1 (Single Phase) MODEL 18E-3 (Three Phase) PRODUCT MANUAL IMPORTANT READ AND UNDERSTAND THIS MANUAL BEFORE ASSEM- BLING, STARTING OR SERVICING THE HEATER. IMPROPER USE
More informationEBAC MODEL CD30 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL
EBAC MODEL CD30 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL Ebac Industrial Products, Inc. 700 Thimble Shoals Blvd, Suite 109 Newport News, VA. 23606-2575 Tel: (757) 873 6800 Fax: (757) 873 3632 Website www.ebacusa.com
More informationIce Cream Freezer Installation and Operation Manual Please read this manual completely before attempting to install or operate this equipment!
Turbo Air Speed up the Pace of Innovation CAUTION! PLEASE KEEP POWER SWITCH ON BEFORE OPERATING THIS EQUIPMENT Ice Cream Freezer Installation and Operation Manual Please read this manual completely before
More informationHotPoly Tote Tank / IBC Heaters (TTH Series)
HotPoly Tote Tank / IBC Heaters (TTH Series) Instruction Manual Read and understand this material before operating or servicing these heaters. Failure to understand how to safely operate these heaters
More information40E ELECTRIC FAN HEATER
40E ELECTRIC FAN HEATER PRODUCT MANUAL IMPORTANT READ AND UNDERSTAND THIS MANUAL BEFORE ASSEM- BLING, STARTING OR SERVICING THE HEATER. IMPROPER USE OF HEATER CAN CAUSE SERIOUS INJURY. KEEP THIS MANUAL
More informationNorthwest RV Supply Manual Compliments of Printed From 900 & 9100 Series
900 & 9100 Series Service Manual & Parts List for Models 9182 9183 9162 9163 982 983 962 963 Safety Information............... 1 Introduction................... 2 Specifications.................. 3 Operating
More informationOT-FX2 OLED TOUCH for the FX II Touch control panel OPERATOR S MANUAL. Technicold Marine Systems
OT-FX2 OLED TOUCH for the FX II Touch control panel OPERATOR S MANUAL Technicold Marine Systems www.technicold.com Technicold by Northern Lights 1419 W. Newport Center Drive Deerfield Beach, FL 33442 Tel:
More informationSauna Craft CTT Heater Installation Manual
Sauna Craft CTT Heater Installation Manual NOTES FOR ALL HEATERS Heater Guard Fence: A non-metallic guard (not included) shall be provided and installed as follows: a) 4 from CW Series heaters b) 6 from
More informationTHERMOMAX COLTREC RCX 100 MICROPROCESSOR REFRIGERATION CONTROL SYSTEM ENGLISH.
THERMOMAX COLTREC RCX 100 MICROPROCESSOR REFRIGERATION CONTROL SYSTEM ENGLISH www.thermomax-group.com CONTENTS SECTION 1 - INTRODUCTION... 2 SECTION 2 - INSTALLATION... 3 2.1 - RCX 100 UNIT... 4 2.2 -
More informationInstallation & Maintenance Instructions
PRH Series Plenum Heaters Installation & Maintenance Instructions Dear Owner, Congratulations! Thank you for purchasing this new heater manufactured by Marley Engineered Products. You have made a wise
More informationE1.5 ELECTRIC FAN HEATER
E1.5 ELECTRIC FAN HEATER PRODUCT MANUAL IMPORTANT READ AND UNDERSTAND THIS MANUAL BEFORE ASSEM- BLING, STARTING OR SERVICING THE HEATER. IMPROPER USE OF HEATER CAN CAUSE SERIOUS INJURY. KEEP THIS MANUAL
More informationEQUIVALENT INITIAL ELECTRICAL SAFETY ASSESSMENT
EQUIVALENT INITIAL ELECTRICAL SAFETY ASSESSMENT Factory Assessor: 33/1, Darail, Shataish Tongi, Gazipur Tongi, Gazipur Dhaka Emkay Enterprises 26 Feb 2014 The Alliance for Worker Safety Page 1/12 26 Feb
More informationBulletin 140G Molded Case Circuit Breakers Product Selection 225 A, I-Frame
Product Selection 225 A, I-Frame Assembled 225 A I-Frame Interrupting Rating/Breaking Capacity Thermal-Magnetic Circuit Breakers Interrupting Rating (50/60 Hz), UL 489/CSA C22.2-5, No. 5-02 [ka] Thermal-Magnetic,
More informationEBAC MODEL CD60 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL
EBAC MODEL CD60 INDUSTRIAL DEHUMIDIFIER OWNER S MANUAL CD60 OWNERS MANUAL Page 1 of 9 INTRODUCTION Designed for a wide range of applications, the CD60 dehumidifier is a rugged, industrial unit which utilizes
More informationGuide To Troubleshooting INEFFICIENT COOLING FANS
Guide To Troubleshooting INEFFICIENT COOLING FANS TABLE OF CONTENTS Introduction Enclosure Cooling Basics Key Attributes of Enclosure Cooling Symptoms of Poor Enclosure Cooling Typical Cooling Fan Problems
More informationInstallation and operating instructions. Temperature difference controller 6 inputs, 3 outputs, integrated data logger for SD card
SOLARTHERMIE - SOLAR THERMAL - SOLAR TÉRMICO - SOLAIRE THERMIQUE - SOLARE TERMICO Installation and operating instructions Temperature difference controller 6 inputs, 3 outputs, integrated data logger for
More informationInstallation and Operation Guide
Hot Water on Demand Installation and Operation Guide Thermo-Pro Thermostatic Series 18kW, 21kW, 24kW, 27kW 118 º F www.atmorusa.com Table of Contents Description Page Safety Guidelines...2 Technical Information...3
More informationXC Portable Air Conditioning
PORTABLE AIR CONDITIONERS XC Portable Air Conditioning XC-14A, XC-22A, XC-30A Models USER & INSTALLATION MANUAL www.xpcc.com 2013 Xtreme Power Conversion Corporation. All rights reserved. Table of Contents
More informationUnity Board Micro Air Corporation Phone (609) Route Allentown NJ Fax (609)
Unity Board Micro Air Corporation Phone (609) 259-2636 124 Route 526. WWW.Microair.net Allentown NJ 08501 Fax (609) 259-6601 January 11, 2016 1 Revision 1.02 Introduction The Unity board is a next generation
More informationGAS MONITOR Model Model
Sierra Monitor Corporation 1991 Tarob Court, Milpitas, CA 95035 (408) 262-6611 (800) 727-4377 (408) 262-9042 - Fax E-mail: sierra@sierramonitor.com Web Site: www.sierramonitor.com GAS MONITOR Model 2350-00
More informationInstallation & Operation Manual Ice Cream Freezers
Installation & Operation Manual Ice Cream Freezers Please read this manual completely before installing or operating this unit! BACF11 BACF15 Blue Air reserves the right to make product modification at
More informationInstallation and Maintenance Manual Please retain this manual for future reference.
342 N. Co. Rd. 400 East Valparaiso, IN 46383 219-464-8818 Fax 219-462-7985 www.heatwagon.com Installation and Maintenance Manual Please retain this manual for future reference. Electric Construction Heaters
More informationSTART UP FORM PACKET
START UP FORM PACKET Condenser/Fluid Cooler DIVISIONS OF RAE CORPORATION 4492 Hunt St. - Pryor, OK 74361 - (918) 825-7222 - Fax (918) 825-6366 www.rae-corp.com Bulletin# CONFLUIDCOOLER-START UP-1213 RAE
More informationGETZ MANUFACTURING PART # CYLINDER DRYER
GETZ MANUFACTURING PART # 59339 CYLINDER DRYER 540 S. Main St., North Pekin, IL 61554 PH. (800) 553-3503 Fax (800) 473-6088 Website: www.getzmfg.com "YOUR FULL LINE EQUIPMENT MANUFACTURER" LIMITED WARRANTY
More informationSWEATMISER ANTI-SWEAT HEATER CONTROLLER. Table of Contents
SWEATMISER ANTI-SWEAT HEATER CONTROLLER UPGRADE MANUAL Table of Contents Upgrade Kit & Record Store Information...2-3 Circuits... 20-22 Check for Sweating... 4 Record Amperage...23 Troubleshoot & Record...
More informationUser Guide. For THE SWIMSUIT DRYER. Swimsuit Dryer manual Final 120v 60Hz. Copyright 2017 Page of 20
User Guide For THE SWIMSUIT DRYER. Swimsuit Dryer manual Final 120v 60Hz Copyright 2017 Page of 20 1 Table of Contents 1 LOCATION & INFORMATION DIAGRAMS... 4 2 PURPOSE... 5 2.1 PROPER USAGE AND LIABILITY...
More informationQuest Dry 105, 155, and 205 Dual
Quest Dry 105, 155, and 205 Dual Read and Save These Instructions This manual is provided to acquaint you with the dehumidifier so that installation, operation and maintenance can proceed successfully.
More informationTM Series. Induced Draft, Counter Flow Optional Accessories
ANTIFREEZE PACKAGE / RESISTANCE HEATING OPTION The antifreeze package is supplied to provide protection against freezing of standing water in the cooling tower sump due to shutdown during winter operation.
More informationGE Industrial Solutions. Residential Electronic Circuit Interrupters
GE Industrial Solutions Residential Electronic Circuit Interrupters Dual Function Circuit Interrupter (DFCI) Provides ground fault and arc fault circuit protection in one unit The 2014 National Electric
More informationAir Cleaning Equipment, Inc. 303 N. Main St. Broadway, NC iers.com
Read and Save These Instructions Horizon Galaxy - Installation and Operations Manual Air Cleaning Equipment, Inc. 303 N. Main St. Broadway, NC 27505 www.horizondehumidif iers.com 1 Safety Notes: The Horizon
More informationModel GPT 3 Freeze Protection Thermostat
We manage heat Model GPT 3 Freeze Protection Thermostat Part Number 19425 Installation and Operation Manual Environmental Technology, Inc. 1850 N Sheridan Street South Bend, Indiana 46628 (574) 233-1202
More information